2025 Toyota Rav4 — Known Issues & Recalls

While driving at 75 mph, you heard a loud explosion and pulled over, initially worried about a flat tire or damage. You found no visible damage or dashboard warnings, so you continued driving but noticed a whistling sound. You later discovered your sunroof had shattered for no apparent reason—you hadn't opened it in the nearly 3 months you've owned the car, and there were no nearby vehicles, overpasses, or trees that could have caused it. The sunroof glass will likely need to be replaced and the sunroof assembly inspected for defects.

Your info center display becomes very difficult to read in bright sunlight. The screen appears excessively dark when you're driving in sunny conditions, making it hard to see important information.

Your infotainment display screen frequently goes black while the audio and navigation systems continue working normally. When this happens, you need to restart the system multiple times to get the screen back on, and it glitches when switching between Apple CarPlay and the Toyota interface. The fix likely involves a software update or replacement of the display unit.

WHY a Brand NEW 2025 Toyota RAV4 EV ONLY 6 months old needed a brand New Battery? Car on the Highway could only reach speed of 40 MPH. I did not receive any RECALL on my NEW RAV4 EV Took it to the Toyota dealer in Wausau Wi they said they had NO CLUE what the issue was and put in a brand new battery.

The complaint does not describe a specific vehicle problem or issue that could be translated.

Your 2025 RAV4 Hybrid's 12-volt battery drains completely even when the car isn't in use, making the vehicle unusable without charging the battery for 3-4 hours before each drive. This problem started about two weeks after you purchased the car and happens consistently. A mechanic will need to diagnose what's causing the electrical drain, which could involve checking for faulty components drawing power when the car is off.

Your instrument panel display goes black intermittently, and this problem has gotten worse over time. You've been notified of a recall (NHTSA Campaign 25V595000) to fix this electrical issue, but the required part isn't available yet from Toyota or your dealer. The fix will likely involve replacing the electrical component controlling your instrument panel.

Your 2025 RAV4 was included in a recall (Campaign 25V595000) for an electrical system issue, but the replacement part hasn't been released yet. You contacted a dealer and feel the manufacturer has taken too long to make the repair available. You haven't experienced any actual failure with your car. The recall repair will likely involve replacing or updating the affected electrical component once the part becomes available.

Your 2025 RAV4's Check Engine light is on permanently due to a fuel system switching valve and fuel tank pressure sensor failure. The dealer is refusing to repair it under warranty, and you're concerned the vehicle could lose power or stall while driving. Fixing this will likely involve replacing the faulty fuel tank pressure sensor and/or the switching valve in the fuel system.

Your 2025 RAV4's powertrain failed at 39,919 miles, well within the 60,000-mile warranty period. You report that Toyota's warranty claim handling appears designed to avoid resolution—including calls only after dealership hours and legal threats when you pursue your claim. You believe this violates federal warranty law and poses a safety concern.

Your tire's sidewall cracked randomly while you were driving on the interstate at night, without hitting any debris or potholes that would explain the damage. The sidewall is the part of the tire between the tread and the rim, and cracks there can lead to tire failure. You'll likely need to replace the affected tire.

While driving on the interstate at 60 mph, you heard a loud noise followed by a thump. When you pulled over, you discovered that the sidewall of your tire had separated from the tread—a condition called delamination. This happened on your original equipment tires at just 5,343 miles. The tire will need to be replaced, and you may want to have a tire shop or Toyota dealer inspect it to determine the cause of the premature failure.

Your car has shaken violently and shut off while idling twice — once in your driveway and once at a stoplight. When this happened, a warning appeared saying the engine stopped and steering power is low. This is a serious issue because you lose power steering while driving, which makes the car difficult to control.

Your RAV4 randomly jerks or pulls to the left while you're driving straight, regardless of where you are in the lane. The jerking can range from gentle to violent, and it happens whether lane-keeping assistance and pre-collision warning are on or off. This has already pushed you across lane lines multiple times at speeds from 15 to 65 mph, creating a serious safety risk if another vehicle is nearby. The dealer performed an alignment without fixing it and now wants to charge $425 to recalibrate the forward camera, which might solve the problem but should be covered under warranty.

Your car suddenly accelerated to a very high speed without control and crashed head-on into a guard rail, causing serious injuries to multiple occupants including broken ribs and whiplash. This happened shortly after a recall service was performed at the dealership. The crash involves potential failures in the speed control and braking systems that need immediate investigation.

While slowly parking at 1-3 mph with your foot on the brake, your 2025 RAV4 suddenly accelerated on its own and hit a stone wall about 3 feet away. You were not pressing the gas pedal, and no warning lights appeared before the incident. The vehicle has only 3,500 miles and had no previous issues. Toyota is investigating the cause, which could involve the throttle control system, brake system interaction, or engine management computer.

Your windshield developed a stress fracture at the bottom edge where it meets the car's body, below the wipers. The crack is semi-circular in shape and wasn't caused by an object hitting the glass—dealer glass technicians confirmed it's a stress crack. Your car had less than 12,000 miles when this happened, but the dealer refused to cover it under warranty. The repair will likely involve full windshield replacement.

Your rear driver's side window suddenly shattered while driving at highway speed (60 MPH), accompanied by a loud bang. The dealer was unable to diagnose or repair the issue because there were no recalls available for your vehicle. The window may need to be replaced, and the cause of the spontaneous failure should be investigated.

While driving your RAV4, you heard a loud bang noise and discovered the sunroof had shattered, even though it was closed at the time. You didn't see any external impact or damage that would have caused this. The sunroof may need to be completely replaced, which typically involves removing the old glass panel and installing a new one.

Your backup camera screen turns off randomly while you're driving, particularly when you're in reverse trying to use the camera. This has been happening since about a month after you purchased the car new, though your vehicle wasn't included in the existing recall for this issue. The problem occurs both while driving forward and when backing up. A technician will likely need to diagnose the backup camera system and infotainment display to identify whether the issue is a software glitch, electrical connection problem, or a faulty camera module.