Data sourced from NHTSA public database. For informational purposes only. Always consult a qualified mechanic.
2007 Toyota Rav4 — Known Issues & Recalls
Complaints from Jan 2011 to Dec 2014
The most reported issue is steering problems (225 complaints). 53 complaints involved crashes. 37 involved fires.
Open Safety Recalls (14)
NHTSA Campaign: 16V096000
Component: SEAT BELTS:REAR/OTHER
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
Risk: A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Fix: Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
NHTSA Campaign: 16V596000
Component: SUSPENSION:REAR
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Risk: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Fix: Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
NHTSA Campaign: 15V689000
Component: VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Risk: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Fix: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
NHTSA Campaign: 14V743000
Component: SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Risk: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Fix: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
NHTSA Campaign: 16V396000
Component: SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Risk: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Fix: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
NHTSA Campaign: 14V168000
Component: AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
Risk: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Fix: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
NHTSA Campaign: 12V373000
Component: SUSPENSION:REAR
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Risk: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Fix: Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
NHTSA Campaign: 11V245000
Component: AIR BAGS
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
Risk: INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
Fix: TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
NHTSA Campaign: 13V383000
Component: SUSPENSION:REAR
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Risk: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Fix: Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
NHTSA Campaign: 12V491000
Component: VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Risk: If the switch overheats, it may melt, possibly resulting in a fire.
Fix: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
NHTSA Campaign: 11V113000
Component: VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Risk: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Fix: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
NHTSA Campaign: 09V223000
Component: EQUIPMENT:OTHER:LABELS
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Risk: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Fix: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
NHTSA Campaign: 10V036000
Component: EQUIPMENT:OTHER:LABELS
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Risk: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Fix: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
NHTSA Campaign: 10V035000
Component: EQUIPMENT:OTHER:LABELS
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Risk: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Fix: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Owner-Reported Issues (20 of 1002)
Electrical System →3 issues
Your driver's side door caught fire and was completely destroyed, along with all the wiring in that door. Toyota had your contact information on file but never reached out to notify you about any safety recalls that may have been related to this issue.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Your car caught fire while driving at 25 mph—flames came from the driver's side door panel near the window control buttons. You smelled smoke before noticing the fire, and the vehicle had to be towed. This appears to be an electrical system issue in the door control area that caused the fire.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
While driving, your RAV4 suddenly lost engine power with no warning light appearing, but it restarted right away. A mechanic diagnosed a battery failure and replaced it, but the problem happened again after the repair. The underlying cause may not have been fully resolved, and your vehicle could lose power unexpectedly while driving.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Structure →3 issues
Your car's unibody frame has severe rust that makes it structurally unsafe to drive, according to a mechanic's assessment. The vehicle could potentially fall apart due to this corrosion damage. Addressing this issue would likely involve either extensive rust repair/replacement of affected frame sections or, in severe cases, determining if the vehicle is economically repairable.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Your car's subframe has rusted severely and won't pass your state's vehicle inspection. This is a structural integrity issue that needs attention before your inspection expires.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Your car's frame is experiencing rust and corrosion. This is a structural integrity issue that should be inspected by a professional to determine the extent of the damage and whether repairs are needed.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Suspension →3 issues
Your car's rear subframe has broken and rusted, making it unsafe to drive. The rear subframe is a structural component that supports your suspension and wheels, so this needs to be repaired before you can safely operate the vehicle. The repair will involve removing and replacing the damaged rear subframe.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Your RAV4's rear tie rods are welded together, making it impossible to align the wheels properly. This happened even after the vehicle was previously serviced under a suspension recall. The tire shop confirmed the alignment cannot be fixed without addressing the welded tie rods.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
While having new tires installed at 179,000 miles, a mechanic discovered that your wheel bearings were fractured and both front axles were heavily rusted. Multiple independent mechanics confirmed this damage. The vehicle was not repaired, and the dealer was contacted but did not respond.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Unknown Or Other →2 issues
Your steering wheel became stiff, so you decided to take the car to a nearby mechanic. While driving on local streets, you smelled smoke and noticed the battery and airbag warning lights flickering on and off, even though the temperature gauge appeared normal. The smoke quickly grew into flames that couldn't be extinguished until the fire department arrived. You're concerned that no warning sensors alerted you before the fire started, and that the problem escalated so quickly you didn't have time to reach the repair shop.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Your car's rear subframe has rusted through completely. The subframe is the metal framework that supports the rear of your vehicle, so this is a structural integrity issue that needs professional attention. Fixing this will likely require replacing the rusted subframe or having it welded and reinforced by a mechanic.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Air Bags,unknown Or Other →2 issues
You're concerned that other people may be connecting to your RAV4's Bluetooth system without your permission, and you've noticed suspicious activity with your vehicle app and people stopping near your car. You're also experiencing unrelated issues with your insurance status and bank account security. To address unauthorized Bluetooth access, you may need to clear your vehicle's paired device list and reset the Bluetooth system.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
You're expressing frustration about lack of communication from Toyota since purchasing your 2007 RAV4 secondhand in 2018, and you're concerned about information regarding the airbag system. You've also experienced separate incidents with stolen vehicle plates and identity-related issues. While this complaint involves the airbag component, it primarily describes communication and administrative concerns rather than a specific vehicle malfunction.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Steering →1 issue
While driving at 40 mph, your steering wheel suddenly locked up and became difficult to turn. You were able to regain control of the vehicle, and no warning lights came on. The cause hasn't been diagnosed yet, but it could involve the power steering system, steering column, or related components that may need inspection and repair.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Suspension,structure →1 issue
Your car's subframe has rusted severely and broken in half, which was discovered during shock replacement. This caused the new tire to lose about half its tread due to the damaged suspension geometry. This is a serious safety issue—if the rear tire had failed completely, it could have caused loss of control and sent your car into oncoming traffic.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Air Bags →1 issue
Your passenger side airbag has started to separate from its cover and can be pushed back in, but you're concerned it might deploy unexpectedly. Toyota and your dealer indicated this issue isn't part of a current recall. A repair would likely involve reseating or replacing the airbag cover and inspecting the airbag assembly for proper function.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Electrical System,engine →1 issue
Your engine caught fire while you were driving, with flames visible coming from under the car and from under the hood. You were alerted by other drivers and were able to pull over safely. This is a serious electrical or engine fire that requires immediate professional inspection to determine the cause.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Steering,electrical System,unknown Or Other →1 issue
While driving on a mountain road, your car suddenly lost power steering and the steering wheel locked up, making it impossible to turn. Your battery warning light was flashing and multiple dashboard lights came on at the same time. You were unable to control the vehicle and hit a guardrail. The dealership couldn't identify the cause or provide a fix, and Toyota says there's no recall for this issue.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Steering,unknown Or Other →1 issue
Your steering system has an unspecified issue that needs attention. Without more details about what you're experiencing, it's difficult to pinpoint the exact problem. You should have a mechanic inspect your steering components to diagnose what's causing concern.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Suspension,traction Control System,engine →1 issue
You're hearing an abnormally loud noise coming from underneath your RAV4 while driving at various speeds. A mechanic inspected the vehicle and suggested the sound may be coming from the tires, but found no specific issues. Additionally, your check engine light, traction control warning light, and another unknown warning light are all illuminated on your dashboard. The problem hasn't been diagnosed or repaired yet. You may need to have the tires inspected, the engine scanned for fault codes, and the traction control system evaluated by a qualified technician.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Get notified when any of these become free repairs
We'll alert you if a new recall is issued for your vehicle — that means a free fix at the dealer.
Related Vehicles
Other Toyota Rav4 years: