2012 Ford Fusion Engine Problems

The contact owns a 2012 Ford Fusion. The contact stated that while driving under 35 MPH, the vehicle was shaking abnormally. The vehicle was shaking abnormally while idling as if the vehicle would shut off. The contact had replaced the battery 8 times; however, the failure persisted. While driving approximately 65 MPH and overtaking other vehicles, the check engine warning light began flashing temporarily. The failure had occurred twice. The vehicle was taken to the dealer who diagnosed the vehicle that the oil was leaking from the valve cover gasket, oil pan, and front seal and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The manufacturer referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was unknown.

Vehicle loses power while driving, with no response when accelerator is depressed further. The engine continues to run but no throttle response. No engine warning light came on. No codes stored. Must stop, turn off engine and perform an engine restart to continue driving again.

THE WRENCH LIGHT COMES ON AND THE VEHICLE CUTS OFF IT WILL START BACK UP BUT IT'S RANDOM AND CUTS OFF ANYTIME IT WANTS. IT'S DONE THIS WHILE PARKED AND MOVING. THROTTLE BODY EXTENDED WARRANTY. MY CAR IS UNDER THE 150,000 MILES AND MET THE REQUIREMENTS FOR THIS TO BE REPLACED AND I TOOK IT TO RAVENEL FORD RAVENEL SC AND WAS TOLD THAT BECAUSE THEY DIDN'T GET THAT CODE THAT THEY WE'RE ALLOWED TO FIX IT

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE OVERHEATED WHILE DRIVEN AT VARIOUS SPEEDS. THE CONTACT'S HUSBAND A CERTIFIED MECHANIC, REPLACED ONE WATER HOSE. THE CONTACT BECAME AWARE OF NHTSA CAMPAIGN NUMBERS: 12V551000 (ENGINE AND ENGINE COOLING) AND 17V209000 (ENGINE AND ENGINE COOLING) HOWEVER, THE VIN WAS NOT INCLUDED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND CONFIRMED THAT THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

MY VEHICLE BEGAN TO OVERHEAT AS A RESULT OF A RECALL. I BROUGHT THE VEHICLE INTO MY DEALERSHIP AND THEY TOLD ME THE MANUFACTURERS DEFECT HAD RUINED MY ENGINE AND IT NEEDED TO BE REPLACED. FORD HAS REFUSED TO REPAIR THE VEHICLE WHICH IS NOW INOPERABLE. THEY CLAIM IT'S OUT OF WARRANTY BUT HOW CAN MY WARRANTY BE VOID IF IT'S A RECALL DEFECT.

ELECTRONIC THROTTLE BODY ERROR CODES LEAD TO LOSS OF ENGINE POWER AND ENGINE BEING THROTTLED BACK TO APPROX. 10 MPH IN "LIMP HOME MODE". ISSUE IS INTERMITTENT, AND NHTSA HAS STUDIED THE PROBLEM PREVIOUSLY. FORD SAYS MY ETB IS NOT INCLUDED IN THE RECALLS, AND THAT I NEED TO PAY FOR THE REPAIRS. IT IS A KNOWN PROBLEM WITH THIS YEAR FORD FUSION, AND FORD SUPPOSEDLY MADE A 10YR 150,000 MILE WARRANTY ON THE PART....JUST NOT MY ETB.

I EXPERIENCING A 'THROTTLE BODY' MALFUNCTION. MY VEHICLE STALLS WHILE DRIVING IN TRAFFIC. THERE ARE NUMEROUS COMPLAINTS IN REFERENCE TO THIS ISSUE, BOTH ONLINE AS WELL AS IN PERSON. THIS IS A HIGHLY DANGEROUS PROBLEM FOR MYSELF AND MY FAMILY. ON THE HIGHWAY THIS CAN / WILL CAUSE A VERY DANGEROUS SITUATION TO MANY OTHER MOTORISTS AS WELL. FORD REFUSES TO ACKNOWLEDGE THIS AS A MANUFACTURING DEFECT ISSUE AND, BY DOING SO, IS PLACING COUNTLESS PEOPLE AT RISK UNNECESSARILY. I AM FED UP WITH DEALERSHIPS COVERING UP FOR DANGEROUS MANUFACTURING ISSUES. THIS PROBLEM NEEDS TO BE ADDRESSED ASAP. THIS PROBLEM IS GETTING WORSE EVERY DAY.

CAR STALLED WITHOUT ANY WARNING. THEN IT STARTED IMMEDIATELY. NEXT DAY STARTED, THEN STALLED IMMEDIATELY AND WOULD NOT START. THE FIRST TIME WE WERE ON TRAFFIC CIRCLE, AND SECOND TIME IN GARAGE

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE DRIVING 68 MPH, THE VEHICLE STALLED AND THE POWER ASSIST INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO A LOCAL DEALER (BOB ALLEN FORD, 9239 METCALF AVE, OVERLAND PARK, KS 66212), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND ADVISED THE CONTACT THAT THERE WAS NO RECALL ASSOCIATED WITH THE VIN. NO FURTHER ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 130,000.

STARTED MAKING NOISE THE FIRST YEAR WE HAD IT AND KEPT GETTING WORSE AS TIME WENT ON!!!!!

CAR INTERMITTENTLY SHUTS DOWN/STALLS OUT WITH NO WARNING WHEN ACCELERATING ,AT ALL SPEEDS AND CONDITIONS. THE LITTLE WRENCH LIGHTS UP ON THE DASH BUT VEHICLE IS NOT THROWING ANY CODES. VERY DANGEROUS SITUATION!!! CALLED THE DEALERSHIP AND NO RECALLS OR ACKNOWLEDGEMENT FROM FORD THAT THERE IS A PROBLEM. HARD TO BELIEVE NO ACTION BEING TAKEN AS OF YET WITH ALL OF THE OTHER COMPLAINTS I HAVE READ FROM OTHER OWNERS. VERY DISAPPOINTED HERE. CAR HAS ALL ROUTINE MAINTENANCE PERFORMED ON IT AND IS VERY WELL CARED FOR, MILEAGE IS JUST OVER 58,000. SURE WOULD APPRECIATE FORD STEPPING UP TO THE PLATE AND STANDING BEHIND THEIR PRODUCT!

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE DRIVING APPROXIMATELY 30 MPH, THE BOLT FROM THE ENGINE FRACTURED AND HIT THE CV JOINT. GREASE FLOODED THE CV JOINT WHICH MADE IT DIFFICULT TO DRIVE THE VEHICLE. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT WAS NOT SURE IF THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 83,894. UPDATED 07/11/17*LJ CONSUMER STATED HE WORKED ON THE VEHICLE ENGINE TO GET THE BROKEN BOLT OUT, BUT WAS NOT ABLE, BECAUSE HE DID NOT HAVE THE RIGHT TOOL. UPDATED 9/28/18 *JB

SMALL EVAPORATIVE LEAK ATTRIBUTED TO THE FUEL FILLER NECK AS PART OF THE CAPLESS GAS SYSTEM. THIS YEAR, MAKE, MODEL PRESENTS CONSISTENT ISSUES IN THIS AREA. PREVIOUS MODEL YEARS HAD RECALLS ASSOCIATED WITH THIS ISSUE, BUT NOT THE 2012 FOR SOME REASON.

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE DRIVING AND SLOWING TO A STOP, THE CONTACT NOTICED AN ABNORMAL SMOKE ODOR EMITTING FROM THE FRONT OF THE VEHICLE. THE CONTACT STATED THAT THE ODOR WAS LIKE BURNING OIL. AN INDEPENDENT MECHANIC DETERMINED THAT THERE WAS EVIDENCE OF AN OIL LEAK, BUT COULD NOT LOCATE ITS ORIGIN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 97,900.

PLEASE REFER TO ATTACHED FILES.

ENGINE STALLS WITHOUT WARNING

DRIVING ON THE 605 FWY WITH MY 5 YEAR OLD GOING ABOUT 65MPH WHEN MY CAR SUDDENLY LOST POWER AND A ORANGE WRENCH LIGHT APPEARED, I WAS ABLE TO PULL OFF TO THE SHOULDER WHEN MY CAR JERKED AND COMPLETELY SHUT DOWN. IT TOOK ME 3 TIMES TO GET IT STARTED ONLY TO HAVE THIS HAPPEN AGAIN ABOUT 2 MILES UP THE ROAD. I WAS ABLE TO SAFELY GET HOME BUT MY MECHANIC HAS ADVISED THAT I HAVE AN ERROR CODE P2111 AND MY THROTTLE BODY WILL NEED TO BE REPLACED. THIS IS EXTREMELY DANGEROUS AND I AM NOT A HAPPY FORD CUSTOMER. I WILL BE TAKING IN MY CAR TO THE DEALER TOMORROW IN HOPES THAT THEY WILL STAND BEHIND THIER PRODUCT AND REPLACE THIS PART.

2015 HAD THROTTLE BODY REPLACED BY FORD FOR NOTHING ..8 MONTHS LATER IT HAPPENED AGAIN 6/3/16..FORD PAID FOR THE FIRST WONT DO THE SECOND WITHOUT ME PAYING FOR IT..THIS CAN BE DANGEROUS AS IT JUST STOPS , YOU HAVE NO POWER TO MOVE, THEN IT SHAKES AND DIES. I DID START IT RIGHT AFTER AND GOT HOME BOTH TIMES. JUST SAYING IF THIS IS A FAULTY PART..WHY ARENT THEY FIXING IT, NOT US. I F YOUR GOING FASDT I WOULD HATE TO THINK WHAT WOULD HAPPEN ON A BIG HIGHWAY.

CAR EXHIBITS A DRONE/MOAN OR RATTLE NOISE. THE NOISE TYPICALLY OCCURS WHILE DRIVING UP A SLIGHT INCLINE, UNDER LIGHT THROTTLE AT 45-61 KM/H (28-38 MPH) AT 1300-1400 RPM, IN 5TH GEAR. THE NOISE MAY BE PRESENT WITH THE A/C ON OR OFF BUT IS TYPICALLY AGGRAVATED WHEN THE A/C COMPRESSOR CYCLES ON. THIS IS THE EXACT SAME ISSUE AT TSB 11-10-26, BUT THAT TSB ONLY APPLIES TO ESCAPE AND MARINER VEHICLES EVEN THOUGH THE ISSUE ALSO APPLIES TO FUSIONS. THIS TSB SHOULD APPLY TO ALL VEHICLES AFFECTED, NOT JUST SOME. SEE VIDEO FOR EXACT SOUND: HTTPS://WWW.YOUTUBE.COM/WATCH?V=PMCS-0SAU5W THANKS

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE DRIVING 60 MPH, AN ABNORMAL SOUND WAS HEARD FROM THE ENGINE AND THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS UNABLE TO START. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FLYWHEEL FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 63,000. UPDATED 05/18/16*LJ *TR

DRIVING AT 10 MPH TURNING INTO A CITY STREET AND THE CAR STALLED. I SHUT OFF THE CAR AND RESTARTED IT AND IT WORKED TO GET ME TO MY DRIVEWAY (~400 FEET).

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE DRIVING AT VARIOUS SPEEDS, THE AIR CONDITIONER FAILED TO FUNCTION. IN ADDITION, THE CONTACT STATED THAT THE AIR VENTS BEGAN TO BLOW HOT AIR. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER MULTIPLE TIMES WHERE THE VEHICLE WAS UNABLE TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000.

I WAS DRIVING DOWN THE HIGHWAY AT 65 MPH. I HAD BEEN DRIVING FOR ABOUT 30 MINUTES. THE CAR SUDDENLY LURCHED. THE "WRENCH" LIGHT ILLUMINATED AND I HAD NO POWER FROM THE ENGINE. I COASTED TO THE EMERGENCY LANE. THE IDLE WAS VERY ROUGH AND SPUTTERING. I RESTARTED THE CAR AND IT OPERATED NORMALLY FOR THE NEXT 15 MILES WHEN I REACHED MY DESTINATION.

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE STALLED AND THE WRENCH WARNING LIGHT ILLUMINATED. THE VEHICLE RESTARTED AFTER SEVERAL ATTEMPTS. THE FAILURE RECURRED MULTIPLE TIMES AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

MY 17 YR OLD DAUGHTER WAS DRIVING THE CAR AT 30 MPH WHEN THE CAR BEGAN TO BUCK AND JERK AND SHE IMMEDIATELY BROUGHT IT TO A STOP. IT WOULD NOT TAKE ANY MORE POWER OR ACCELERATION. WHILE STOPPED IN THE MIDDLE OF THE ROAD SHE CALLED ME AND NOTED THE TEMP GAUGE SHOWED HOT WITH A CHECK ENGINE LIGHT. WE HAD IT TOWED. TECHNICIAN WHO DIAGNOSED THE PROBLEM FOUND A FAULTY TEMP SENSOR THAT SHOWED THE ENGINE WAS OVERHEATING AND CAUSING THE ENGINE TO GO INTO FAIL-SAFE SHUT-DOWN MODE. APPARENTLY THIS HAS HAPPENED OFTEN ENOUGH THAT FORD HAS A SERVICE BULLETIN OUT ON THE PROBLEM, BUT NO RECALL. THIS COULD HAVE BEEN A DISASTER IF SHE HAD STILL BEEN ON THE ROAD WHERE SHE PARKED IT. THERE SHOULD BE A MANUFACTURER RECALL TO HAVE THESE PARTS CHECKED OUT. THERE IS A KNOWN CORROSION ISSUE WITH THE SENSOR AND WIRING.

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE DRIVING AT 35 MPH, THE VEHICLE STALLED AND THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.

TL* THE CONTACT OWNED A 2012 FORD FUSION. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE ENGINE CAUGHT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE AND A FIRE REPORT WERE NOT FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 80,000.

VEHICLE STALLED WHILE DRIVING PROBABLY 45 MPH IN THE MIDDLE OF TRAFFIC. I HIT THE GAS, THE CAR KEPT SLOWING DOWN. I HAD TO PUT MY EMERGENCY SIGNALS ON. THE CAR TURNED OFF IN THE MIDDLE OF TRAFFIC. I HAD TO SWITCH TO PARK AND RESTART THE CAR AGAIN. *TR

VEHICLE EXHIBITED EXTREME HESITATION WHEN ACCELERATING THROUGH AN INTERSECTION. ENGINE RAN ROUGHLY, AND DID NOT RESPOND TO THROTTLE INPUTS, AND POWERTRAIN 'WRENCH' LIGHT ILLUMINATED. PULLED INTO AN ADJACENT PARKING LOT, STOPPED AND PLACED INTO PARK, WHILE THE ENGINE CONTINUED TO RUN ROUGHLY. ENGINE WAS SWITCHED OFF, AND RAN NORMALLY WHEN RESTARTED. THE TOTAL ELAPSED TIME OF THE ANOMALY WAS APPROXIMATELY 5-10 SECONDS. LATER THAT DAY A SCAN OF THE OBD II PORT INDICATED NO ANOMALIES, AND AN ON-BOARD 'VEHICLE HEALTH MONITOR' WAS RUN VIA FORD SYNC . THIS REPORT ALSO INDICATED NO ANOMALIES. WHILE LOOKING UP THE VEHICLE HEALTH MONITOR RESULTS ON THE OWNER WEBSITE, I NOTICED THAT THERE WAS A 'CUSTOMER SATISFACTION PROGRAM' 13N03 WHICH EXTENDED THE WARRANTY ON THE THROTTLE BODY. RESEARCH ON THIS 13N03 PROGRAM VIA MULTIPLE ON-LINE SOURCES REVEALED NUMEROUS FAILURES OF THE THROTTLE BODY, WITH BEHAVIOR IDENTICAL TO THAT OBSERVED IN THIS VEHICLE. CAR WAS DRIVEN (CAREFULLY) FOR A FEW DAYS UNTIL I WAS ABLE TO VISIT LOCAL FORD DEALER. SERVICE ADVISOR INDICATED THAT FORD WOULD ONLY REPLACE THROTTLE BODY IF THERE WERE STORED CODES CONSISTENT WITH THROTTLE BODY FAILURE, AND THAT DIAGNOSTIC COSTS ($159) WERE MY RESPONSIBILITY IF NO CODES WERE FOUND. AFTER DISCUSSING THE NEGATIVE RESULTS OF OBD II SCAN AND VEHICLE HEALTH MONITOR, HIS OPINION WAS THAT THERE WAS A VERY HIGH PROBABILITY THAT THEIR DIAGNOSTICS WOULD ALSO SHOW NO CODES. BASED ON THIS INFORMATION, I DECLINED TO HAVE DEALER EXAMINE THE CAR, AND REPLACED THE THROTTLE BODY WITH UPDATED PART MYSELF (TOTAL COST $125), AS A MORE EFFECTIVE APPROACH TO PREVENTING RECURRENCE. MY OPINION IS THAT THE 13N03 PROGRAM NEEDS TO BE A FULL RECALL, AS THIS FAILURE IS COMMON, UNPREDICTABLE, AND CAN HAVE VERY SERIOUS CONSEQUENCES SHOULD IT OCCUR DURING HIGH SPEED MERGING OR CROSSING TRAFFIC. *TR

A FEW MONTHS AFTER I PURCHASED THE CAR AND AS I WAS SLOWED DOWN DUE TO TRAFFIC, COASTING AT 5-10 MPH, THE CAR ACCELERATED WITH A ROAR AND TO AVOID THE ACCIDENT I SWERVED TO RIGHT, APPLIED THE BRAKES HARD TO STOP THE CAR.YESTERDAY,11/20/14, IT REPEATED THE INCIDENT ON MY DRIVE WAY WHILE I WAS ENTERING THE GARAGE AND HIT THE STORAGE OBJECTS THERE AND ALSO I HAD TO APPLY THE BRAKES HARD TO STOP THE CAR. MANY TIMES DURING THE PAST TWO YEARS THE CAR HAS BEHAVED SIMILARLY AT STOP SIGNS BUT WITH MUCH LESS FURY. *TR

WITHOUT ANY ISSUES IN THE 6 MONTHS I'VE OWNED THE CAR, THE ENGINE SHUT DOWN. THE BATTERY APPEARED FULL. GAS TANK IS FULL. AFTER ONLY DRIVING FOR 1/4 MILE, THE STOP SAFELY NOW WARNING LIGHT CAME ON AND CAR SHUT DOWN. LUCKILY WE WERE RIGHT NEXT TO A CONVENIENCE STORE AND WERE ABLE TO GET AWAY FROM TRAFFIC. IF WE WERE ON A 2 LANE ROAD, WE WOULD OF BEEN STUCK IN THE MIDDLE OF TRAFFIC. WE WERE ABLE TO RESTART AND MOVE 10 FT AT A TIME. STILL WAITING FOR DIAGNOSIS. *TR

WHILE DRIVING DOWN THE ROAD, CAR WENT INTO LIMP MODE AND WARNING LIGHT CAME ON. PULLED CAR OFF ROAD, ENGINE SPUTTERING. TURNED CAR OFF AND BACK ON. ALL OF THE ABOVE ISSUES DISAPPEARED. *TR

ENGINE LIGHT APPEARED ON DASH. FOLLOWED INSTRUCTIONAL MANUAL DIRECTIONS AND ENGINE LIGHT DISPLAY STAYED INTERMITTENT. AS OF JULY 24TH ENGINE LIGHT DISPLAY REMAINS ON AND EVERY TIME I STOP TO PUT ANY AMOUNT OF FUEL IN IT, IT STRUGGLES TO START AND TAKES AT LEAST 3 ATTEMPTS BEFORE IT WILL START. HOWEVER, IF I LEAVE IT RUNNING WHEN ADDING FUEL I HAVE NO PROBLEM, WHICH IS NOT RECOMMENDED. HAD AUTO ZONE RUN DIAGNOSTICS CHECK AND THEY GAVE ME THE CODE BUT THE FORD DEALERSHIP (KELLY FORD, MELBOURNE FL) WOULD NOT EVEN ATTEMPT TO LOOK UP THE CODE AS THEY SAID I HAVE TO COME IN AND PAY $100.00 DIAGNOSTIC FEE AND $160.00 HOURLY TO HAVE FIXED. I AM MORE WORRIED ABOUT DOWN THE ROAD ISSUES AS SEEN ON THIS WEB SITE. BOUGHT THE CAR USED IN DECEMBER OF 2012 WITH ONLY 11,000 MILES ON IT. *TR

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT SHE RECEIVED A LETTER NOTIFYING HER OF A CUSTOMER SATISFACTION PROGRAM RELATED TO NHTSA ACTION NUMBER: PE13003 (ENGINE) . THE CONTACT MENTIONED THAT SHE WAS VERY CONCERNED FOR HER SAFETY AND THAT THERE SHOULD HAVE BEEN A RECALL ISSUED FOR THE DEFECT. THE DEALER WAS CONTACTED, WHO REFUSED TO ASSIST HER UNLESS THE VEHICLE WAS EXHIBITING THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE CURRENT MILEAGE WAS 18,300.

WAS AT A STOP SIGN WHEN I ACCERLERATED THE ENGINE STOPED. I VEERED TO THE RIGHT AND THE CAR RESTARTED. I TOOK IT TO THE LOCAL FORD DEALERSHIP. THEY SAID THEY COULD FIND NOTHING WRONG THE CAR. IT HAS HAPPENED A TOTAL OF THREE TIMES WITH THE SAME RESULT, THEY SAY NOTHING WRONG WITH THE CAR. I CALLED FORD THEY INITATED A BUY BACK BUT THE CAR DID NOT PASS CALIFORNIA LEMON LAW MUSTER SO MY CASE WAS CLOSED. *TR

STATE OF NJ HAD A 2012 FORD FUSION THAT WAS BACK TO THE DEALERSHIP 5 TIMES FOR A CHECK ENGINE LIGHT. ON THE 6TH ATTEMPT TO FIX THE PROBLEM AT THE DEALERS, THE VEHICLE CAUGHT FIRE AND BURNED TO THE GROUIND WHILE OUT ON A ROAD TEST WITH A DEALERSHIP EMPLOYEE. THE VEHICLE IS A TOTAL LOSS. THE DEALERSHIP HAS NOT DISCLOSED WHAT CAUSED THE FIRE. I RECENTLY WAS INFORMED OF THE RECALL FOR 2013 FORD FUSIONS AND THOUGHT MAYBE THE 2012'S MAY HAVE A PROBLEM ALSO. THE DEALERSHIP INFORMATION IS AS FOLLOWS: ALL AMERICAN FORD, 375 ROUTE 17 SOUTH, PARAMUS, NJ. CONTACT IS [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE INTERMITTENTLY STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE REPLICATED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 5,000. ..UPDATED 12-30-13 *BF UPDATED 1/14/2014 *JS

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED WHILE DRIVING 60 MPH THE VEHICLE LOST POWER, THE WRENCH LIGHT ILLUMINATED WHEN THE FAILURE OCCURRED. THE CONTACT WAS ABLE TO COAST THE VEHICLE ONTO THE EMERGENCY LANE, RESTART IT AND RESUME NORMAL FUNCTION. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 35,000. ...UPDATED 12/03/13 *BF THE CONSUMER STATED THE VEHICLE SHUT DOWN 3 TIMES DISPLAYING THE WRENCH WARNING. UPDATED 12/6/2013 *JS

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS MERGED OFF THE ROADWAY WHERE THE ENGINE WAS RESTARTED. THE VEHICLE WAS NOT TAKEN FOR REPAIRS OR DIAGNOSIS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 44,000.

PULLED OUT OF DRIVEWAY GOT APPROXIMATELY 1/4 OF MILE FROM HOME AND ALL OF THE SUDDEN NO GAS, NO POWER AND LOOKING AT THE DASHBOARD THE ONLY INDICATOR THAT WAS LIT WAS THE WRENCH. I DRIFTED TO THE SIDE OF THE ROAD WAITED A FEW MINUTES TO TRY AND START THE CAR, LUCKILY IT DID AND DROVE IT BACK HOME. CALLED THE FORD DEALERSHIP TO EXPLAIN WHAT HAPPENED, AND THEY SAID MORE THAN LIKELY IT IS THE THROTTLE BODY. THEY SUGGESTED TO HAVE THE CAR TOWED BECAUSE IT COULD HAPPEN AGAIN WITHOUT WARNING. AS OF THIS MORNING, IT HAS BEEN CONFIRMED THAT IT IS THE THROTTLE BODY AND IT WILL ONLY COST ME A $100.00 DEDUCTABLE BECAUSE (LUCKY ME) I AM PAYING FOR EXTENDED WARRANTLY... CAN'T IMAGINE HOW MUCH IF I DIDN'T!!! I ASKED IF THIS IS A COMMON PROBLEM WITH THIS CAR AND THE SERVICE PERSON SAID THAT THIS IS NOT THE FIRST TIME SHE HAS SEEN THIS HAPPEN. I AM DEEPLY CONCERNED BECAUSE THIS SITUATION COULD HAVE BEEN CATASTROPHIC. I DRIVE ALMOST 90 MILES A DAY, FIVE DAYS A WEEK ROUNDTRIP ON A MAJOR BELTWAY AND I FEEL THIS PROBLEM IS BIGGER THAN FORD WANTS TO ADMIT. *TT

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AS THE VEHICLE INDEPENDENTLY DECELERATED TO 1 MPH. THE VEHICLE FAILED TO RESPOND TO ACCELERATION ATTEMPTS. THE VEHICLE WAS SHUT OFF AND ONCE RESTARTED, IT OPERATED NORMALLY FOR A FEW MILES UNTIL THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 4,350.

ELECTRONIC THROTTLE BODY WENT OUT ON MY 2012 FORD FUSION. *TR

DRIVING ON FREEWAY IN HEAVY TRAFFIC CAR SUDDENLY LOST POWER AND SLOWED TO 30-40 MPH. HAD TO CUT ACROSS 2 LANES OF TRAFFIC TO THE SHOULDER. LIMPED TO EXIT WHERE CAR DRIVEN AT SLOW SPEED. DEALER COULD NOT FIND PROBLEM. *TR

WHILE DRIVING AT APPROXIMATELY 50 MPH VEHICLE SUDDENLY LOST ALL POWER. ENGINE STOPPED RUNNING AND ALL LIGHTS TURNED OFF. THIS IS THE SECOND INSTANCE OF THIS HAPPENING. AFTER COASTING TO A STOP WAS ABLE TO PUT THE CAR IN PARK AND RESTART ENGINE. *TR

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT WHILE ATTEMPTING A LEFT TURN AT A TRAFFIC STOP, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 6,000 AND THE CURRENT MILEAGE WAS 8,300. *TR

PULLED UP TO A STOP LIGHT THAT WAS RED. WHILE IDLING WAITING FOR GREEN LIGHT, ENGINE STALLED. PLACED CAR IN PARK, RESTARTED ENGINE, AND AUTOMOBILE DROVE AS NORMAL. *TR

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE STALLED WITH THE ILLUMINATION OF THE SERVICE WARNING LIGHT. THE CONTACT SHIFTED INTO NEUTRAL AND COASTED TO THE SHOULDER. THE VEHICLE WAS RESTARTED AND FUNCTIONED PROPERLY. THE VEHICLE WAS LATER TAKEN TO THE DEALER FOR INSPECTION WHERE THEY ADVISED THAT THEY COULD NOT DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND ATTEMPTED TO ASSIST THE DEALER IN DIAGNOSING THE FAILURE BUT TO NO AVAIL. THE FAILURE MILEAGE WAS 3,000.

WHILE DRIVING THE WRENCH LIGHT CAME ON AND LOST POWER. I COULDN'T ACCELERATE AND PULLED OVER. I ALMOST GOT REAR-ENDED. THE CAR STARTED SHAKING. I STARTED THE CAR BACK UP AND THE WRENCH LIGHT CAME OFF. DROVE AGAIN AND THE SAME PROBLEM HAPPENED WITHIN A MILE. *JS

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT AN ABNORMAL NOISE AND SHAKING WAS EXHIBITED BY THE VEHICLE UPON STARTING. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THE CONTACT THAT THEY WERE UNABLE TO REPAIR THE VEHICLE BECAUSE THEY COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED WHO ADVISED THE CONTACT THAT THEY WOULD SEND AN INVESTIGATOR TO FURTHER INSPECT THE FAILURE. THE INVESTIGATOR NEVER SHOWED UP AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 1,000 AND THE CURRENT MILEAGE WAS 1, 3000.