2010 Volkswagen Jetta Fuel System Problems

While driving at 55 mph, your high-pressure fuel pump failed catastrophically, sending metal debris through the engine and causing it to shut off immediately. The entire fuel system stopped working as a result of this failure.

I was driving 75 miles an hour on a major interstate and the car stopped accelerating while I was driving.(major safety issue) I was able to get to the side of the road and the car died and would not start again. The glow plug warning light started flashing as this was happening. I was able to get it towed to a repair shop or they told me the high-pressure fuel pump failed and that it was a catastrophic failure because there was metal from the pump through the whole fuel line.

VEHICLE WILL CUT OUT WHILE DRIVING AT HIGHWAY SPEEDS. THIS HAS BEEN HAPPENING FOR OVER A YEAR. MULTIPLE PARTS HAVE BEEN REPLACED OVER THIS TIME. THE INTERNET HAS MANY CASES OF THIS SAME PROBLEM HAPPENING TO OTHER PEOPLE. VW MUST KNOW ABOUT THIS PROBLEM. THIS IS A VERY DANGEROUS PROBLEM?

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA SPORTWAGEN. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED AND WAS UNABLE TO BE RESTARTED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE INDEPENDENT MECHANIC CONTACTED MAG VOLKSWAGEN (6335 PERIMETER LOOP RD, DUBLIN, OH 43017, (614) 389-5556) TO ASSIST WITH THE DIAGNOSTIC TEST. THE CONTACT WAS INFORMED THAT THE HIGH PRESSURE FUEL PUMP FAILED AND NEEDED TO BE REPLACED ALONG WITH THE ENTIRE FUEL SYSTEM DUE TO METAL SHAVINGS IN THE FUEL PUMP AND FUEL LINE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.

ON JUNE 6TH, WHILE ROLLING UP TO AN INTERSECTION, THE GLOW PLUG SENSOR LIGHT FLASHED, AND THEN CAR STALLED. IT WOULDN'T START AGAIN. IT WAS EXTREMELY DANGEROUS AS THE MPH ON THE ROAD IS 50, AND THE CAR WAS NOT IN A GOOD POSITION TO BE MOVED TO THE SIDE OF THE ROAD. TONS OF CARS PASSING VERY FAST AT 9:30 PM. WE HAD IT TOWED TO THE DEALERSHIP, WHO FOUND METAL IN THE FUEL. THEY DIAGNOSED IT AND SAID THE FUEL PUMP HAD DIED. DUE TO THE EMISSIONS SCANDAL, VW GAVE US AN EXTENDED EMISSIONS WARRANTY, WHICH THANKFULLY COVERS THE ENTIRE FUEL SYSTEM! WOW! BUT THEN, THE DEALERSHIP SAID THEY TESTED THE FUEL AND SAID IT FAILED THE CONTAMINATION TESTS. I HAVE KEPT A LOG OF MY MILEAGE EVER SINCE I GOT THE CAR. IN FACT, I EVEN SAVED MY LAST FEW RECEIPTS WHICH SHOW I ONLY PUT DIESEL IN MY VEHICLE. THE DEALERSHIP DOES NOT WANT TO HONOR THE WARRANTY BECAUSE THEY ARE BLAMING ME FOR MISFUELING AND CONTAMINATING MY FUEL. IT'S REALLY FRUSTRATING WHEN I HAVE OWNED THE CAR IT'S ENTIRE LIFE AND HAVE NEVER PUT THE WRONG FUEL IN. I CALLED VW CORPORATE AND THEY ARE TRYING TO BLAME ME FOR MISFUELING, TOO. THEY "TALKED WITH THE DEALERSHIP" AND THINK THEIR "FUEL CONTAMINATION TEST" WAS ACCURATE. THE SERVICE MANAGER, ACTUALLY, COULDN'T EVEN TELL ME WHAT THE REASON FOR THE FAILING OF THE FUEL WAS, AND EVEN SAID IT COULD POTENTIALLY BE THE METAL SHARDS FAULT. SO HOW CAN THEY TRY TO BLAME ME WHEN THEY DON'T EVEN KNOW WHY THE TEST FAILED, ESPECIALLY WHEN I HAVE MY LAST 3 RECEIPTS FROM THE GAS STATION SHOWING DIESEL FUEL GOING IN. 10+ GALLONS EACH RECEIPT. I HAD DRIVEN 384 MILES ON THE TANK OF FUEL BEFORE THE VEHICLE STALLED. WITH SUCH DELICATE HIGH PRESSURE FUEL PUMPS AND COMMON RAIL INJECTOR, IT WOULD HARDLY TAKE MUCH CONTAMINATION TO CAUSE THE HPFP TO BREAK. I HAVE EVEN CONTACTED THE GAS STATION I LAST FILLED UP AT, AND THEY HAVE HAD ZERO COMPLAINTS ABOUT BAD FUEL.

ENGINE STALLS OUT AS IF IT IS GETTING NO FUEL. IT HAPPENS WHEN IT IS STATIONARY, IN MOTION AND ON CITY STREETS ON OCCASIONS AND VERY DANGEROUS. SEEMS LIKE SOMETHING WRONG WITH THE FUEL PUMP.

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA SPORTWAGEN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER BRANDON VOLKSWAGEN LOCATED AT 9816 E ADAMO DR, TAMPA, FL 33619 WAS CONTACTED AND CONFIRMED THAT THE VIN WAS NOT PART OF THE RECALL AND THE CONTACT HAD TO PAY FOR THE REPAIR. THE MANUFACTURER WAS NOT CONTACTED AND WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. ...UPDATED 10/13/17 *BF

OCCASIONALLY THE CAR WILL STALL AND SURGE CREATING A JOLT AT VARIABLE SPEEDS BUT ALWAYS WHILE IN MOTION. USUALLY WHEN ACCELERATING FROM IDLE BUT SOMETIMES DURING HIGHWAY DRIVING.

VEHICLE STALLS WHILE IN MOTION ON A STATE HIGHWAY BUT COASTING TO A STOP AT A TRAFFIC SIGNAL. CLUTCH PEDAL WAS FULLY DEPRESSED. HAS HAPPENED ABOUT 5 TIMES BETWEEN JULY 1, 2017 AND AUGUST 29, 2017. THIS VEHICLE IS A DIESEL. FUEL PUMP MIGHT BE LOOSING POWER. WEATHER WAS DRY. AIR AND FUEL FILTERS ARE NOT DIRTY. THEY WERE RECENTLY REPLACED.

LATERAL SPACING BETWEEN ACCELERATOR AND BRAKE PEDAL TOO NARROW. THIS SITUATION CAUSES THE DRIVER TO PUSH THE ACCELERATOR PEDAL WHEN REQUIRING BRAKING. ON AT LEAST ONE OCCASION THIS CAUSED ME TO IMPACT A STATIONARY VEHICLE DIRECTLY IN FRONT OF ME. THIS IS A DANGEROUS CONDITION THAT IS AGGREVATED WHEN LARGER FOOTWEAR IS WORN, THIS CONDITION SHOULD BE INVESTIGATED, AS IT AN UNACCEPTABLE PRESENTS A SAFETY RISK

WHILE DRIVING TO WORK ON A VERY BUSY INTERSTATE MY 2010 VW JETTA TDI HAD A CHECK ENGINE LIGHT COME ON, IMMEDIATELY FOLLOWED BY MY CAR STUTTERING AND SHUTTING OFF IMMEDIATELY. AFTER NEING TOWED TO THE DEALER, I WAS INFORMED THE ENTIRE FUEL SYSTEM HAD TO BE REPLACED AND THAT THIS WAS A MAJOR ISSUES WITH VW DIESELS (ESP. YEARS 2009 & 2010). THE HPFP HAD BECOME SUCH A PROBLEM THAT THE MANUFACTURER EXTENDED THE WARRANTY FOR THE FUEL SYSTEM TO 120K MILES OR 10 YEARS. MY MILEAGE WENT OVER THE ALLOTTED AMOUNT BY 5K MILES BUT AFTER MANY CALLS TO VW CUSTOMER SERVICE THEY REFUSED ANY HELP, THEY WOULD NOT COVER THE $5,000 REPAIR, THE $3,000 IN PARTS OR ANYTHING. THEY REFUSED ANY TYPE OF HELP EVEN THOUGH THEY MOST CERTAINLY COULD HAVE ASSISTED ME. IT IS WELL KNOWN THAT THE FUEL PUMP IS POOR, EVEN THE REPLACEMENT PUMPS HAVE A HUGE FAILURE RATE YET VW DOES NOTHING TO ASSIST THEIR CUSTOMERS. THEY HAVE FAILED TO PRODUCE A HPFP THAT DOES NOT BREAK DOWN AND THEN THEY MAKE IT THE CUSTOMERS FAULT BY NOT RECALLING THE PART. THESE FUEL SYSTEMS SHOULD HAVE BEEN REPLACED AS A RECALL BEFORE THEY CAUSE THE CAR TO SUDDENLY STOP ON A BUSY INTERSTATE. I AM THANKFUL THAT I WAS NOT INJURED BUT I AM FURIOUS THAT I AM JUST ONE OF MANY THAT HAVE WENT THROUGH THIS AND BEEN OFFERED NO HELP. WE ARE LEFT TO PAY THE PRICE, ONE THAT RUNS ANYWHERE FROM $5,000-$9,000. THAT IS AN UNACCEPTABLE REPAIR COST TO A VEHICLE WITH UNDER 125K MILES, AND IT HAPPENS AS SOON AS 6K. THE ENGINEERS AT VW SHOULD BE HELD ACCOUNTABLE FOR THEIR POOR DESIGN, INABILITY TO CORRECT IT AND ABANDONMENT OF THEIR LOYAL CUSTOMERS. VW HAS SHOWN A COMPLETE DISREGARD FOR HUMAN LIFE BY FAILING TO PROPERLY ADDRESS THIS ISSUE.

CAR SUDDENLY UNABLE TO ACCELERATE BEYOND 30 MPH. CAR GENTLY DRIVEN TO DEALERSHIP WHERE CAR DIED AND WAS UNABLE TO START. DEALERSHIP HAS INVESTIGATED AND FOUND METAL SHARDS FROM FUEL FILTER HAVE MIGRATED THROUGHOUT THE FUEL SYSTEM. COST OF REPAIR $5400. CAR IS PART OF VW BUYBACK PROGRAM. DEALER REFUSED TO BUY BACK VEHICLE WITHOUT REPAIR STATING VEHICLE MUST BE " ABLE TO GET TO DEALERSHIP ON ITS OWN'. I DROVE VEHICLE TO DEALER. DEALER REFUSES TO WORK WITH ME ON BUYBACK. NOW FORCED TO PAY FOR EXPENSIVE REPAIR. DEALER STATE REPAIR " EXPECTED DUE TO HIGH MILEAGE" I HAVE ALWAYS HAD HIGH MILEAGE VEHICLES AND HAVE NEVER BEFORE HAD METAL IN FUEL LINE DUE TO FUEL FILTER FAILURE.

WHILE ON A CITY STREET AT STOPPED AT A STOP LIGHT MY VW JETTA TDI MADE A FUNNY NOISE AND SHOOK. THEN IT ACTED LIKE IT WANTED TO STALL, THE GLOW PLUG LIGHT CAME ON. THE STOP LIGHT CHANGED AND I WAS ABLE TO PULL INTO A PARKING LOT. WHEN I PULLED INTO A PARKING SPOT BEFORE I COULD TAKE THE CARE OUT OF GEAR, IT STALLED. I WAS NOT ABLE TO GET THE CAR TO START AGAIN. I WAS TOLD BY VW OF SAN BERNARDINO THAT THIS WAS A KNOW ISSUE WITH THE HIGH PRESSURE FUEL PUMP. THE RECALL UPDATE WAS PREFORMED BACK IN 2014 TO PREVENT THE INCORRECT FUEL FROM BEING PLACED INTO THE VEHICLE. I AM A LONG TIME DIESEL OWNER AND HAVE NEVER PLACED THE INCORRECT FUEL INTO THE CAR. I BELIEVE THERE IS A DEFECT IN THE DESIGN OR MATERIAL RELATED TO THE HIGH PRESSURE FUEL PUMP.

MY CAR STALLED WHILE DRIVING IT WAS TOWED TO THE DEALERSHIP WHERE I WAS INFORMED THAT THERE WAS AN EXTENDED WARRANTY ON THE HIGH PRESSURE FUEL PUMP ASSOCIATED WITH MY CAR MAKE AND MODEL. I WAS THEN INFORMED THAT MY CAR WAS NOT COVERED UNDER THE EXTENDED WARRANTY BECAUSE I DID NOT HAVE A MISFUEL GUARD INSTALLED. I NEVER RECEIVED ACTUAL NOTICE THAT I WAS TO INSTALL A MISFUEL GUARD UNTIL THE DAY MY CAR STALLED AND HAD TO BE TOWED TO THE DEALERSHIP. THE DEALERSHIP RAN A FUEL TEST WHICH REVEALED THAT THERE WAS NO IMPROPER FUEL IN MY CAR, THUS, EVEN IF THE MISFUEL GUARD HAD BEEN INSTALLED, MY FUEL PUMP WOULD HAVE STILL FAILED. I HAVE CONTACTED VOLKSWAGEN AS WELL AND THEY ALSO INFORMED ME THAT BECAUSE I DID NOT HAVE THE MISFUEL GUARD INSTALLED, I WAS UNABLE TO BE COVERED UNDER THE WARRANTY, EVEN THOUGH THERE WAS NO IMPROPER FUEL LOCATED IN MY CAR. I AM EXTREMELY FRUSTRATED THAT EVEN THOUGH THERE WAS NO USER ERROR, I AM BEING STUCK WITH THE BILL ($5,000) DUE TO VOLKSWAGEN'S DEFECTIVE PART.

CATASTROPHIC MALFUNCTION OF HIGH PRESSURE FUEL PUMP WITH METAL SHARDS IN THE FUEL SYSTEM. FUEL WAS NOT CONTAMINATED. THE VEHICLES MIL LIGHT CAME ON WHILE DRIVING ON THE HIGHWAY, WAS ABLE TO STEER THE VEHICLE OFF HIGHWAY.

HIGH PRESSURE FUEL PUMP FAILED WHILE DRIVING ON THE FREEWAY 60 MPH CAR SUDDENLY LOST POWER AND LUCKILY I WAS IN THE SLOW LANE AND WAS ABLE TO PULL OVER TO SHOULDER

I BOUGHT THIS CAR IN MAY 2015 DUE TO THE AWESOME FUEL ECCONOMY PAIRED WITH SUPPOSED GREAT RELIABILITY.THE HIGH PRESSURE FUEL PUMP WENT OUT AROUND OCTOBER 2015. I WAS HEADED TO WORK AND THE ENGINE STARTED SKIPPING JUST FOR A SHORT TIME. I DROVE TO WORK WITHOUT ANY MORE ISSUES. WHEN I WAS LEAVING WORK, THE ENGINE STARTED RUNNING REAL ROUGH SO I PULLED OVER AND I HEARD A SQUEALING/RATTLING NOISE FROM AN AREA AROUND THE TIMING COVER. THE ENGINE STALLED. I STARTED IT BACK UP AND AFTER MAYBE 10 SECONDS IT STALLED AGAIN AND WOULDN'T START BACK UP. I TOWED THE CAR TO A VW SPECIALIST SHOP AND THEY DIAGNOSED THE ISSUE AS A FAILED HIGH PRESSURE FUEL PUMP AND REQUIRING REPLACEMENT OF THE ENTIRE FUEL SYSTEM. I HAD THE CAR TOWED TO A VW DEALERSHIP AND THEY'RE DIAGNOSTIC WAS THE SAME. THEY SENT OUT A FUEL SAMPLE AND IT FAILED FOR LUBRICITY. I EXPECTED VW TO COVER THIS SINCE THIS WAS A KNOWN VW ISSUE. THE CAR SAT AT A DEALERSHIP FOR OVER A MONTH BEFORE HAVING TO TOW IT BACK HOME. THE REPAIR WILL COST AROUND $5,600. I WOULD FIX IT MYSELF BUT THE PARTS ALONE CAN BE $3,000 TO $4000. I PURCHASED THIS CAR IN MAY 2015, SO ONLY GOT TO DRIVE IT FOR FIVE MONTHS. I HAVE LOST ALL FAITH IN THE RELIABILITY AS WELL AS THE CONFIDENCE THAT VW WILL FIX ANY ISSUES THAT ARE DUE TO FAULTY PARTS. THERE HAVE BEEN SEVERAL CASES WITH FAULTY HIGH PRESSURE FUEL PUMPS FROM 2009 TO PRESENT. THERE WAS AN INVESTIGATION BEFORE. HTTP://WWW-ODI.NHTSA.DOT.GOV/ACMS/CS/JAXRS/DOWNLOAD/DOC/UCM475595/INCR-EA11003-61863.PDF

ENGINE BEGAN TO RUN ROUGH AND GLOW-PLUG LIGHT ILLUMINATED. WITHIN 3 MILES THE POWER DIMINISHED AND CHECK ENGINE LIGHT CAME ON. STOPPED FOR A STOP SIGN AND THE CAR STALLED IN THE INTERSECTION AND WOULD NOT START. DEALER HAS IDENTIFIED METAL IN THE HIGH PRESSURE FUEL PUMP.

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE STALLED SEVERAL TIMES WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP AND THE FUEL INJECTORS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V621000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 115,000. THE VIN WAS NOT AVAILABLE.

I AM UNABLE TO OPEN THE GAS FILLER FLAP TO FILL MY GAS TANK WITH GAS. THE FILLER FLAP USUALLY OPENS USING THE CENTRAL LOCKING SYSTEM IN CAR OR THE KEY POD. NEITHER ACTIVATES THE FILLER FLAP NOW. THIS IS A SERIOUS SAFETY ISSUE WHICH VOLKSWAGEN DOES NOT HAVE A SOLUTION FOR.

MY 2010 VW JETTA TDI IS THROWING CHECK ENGINE LIGHT CODES OF P0472 AND P0471. BOTH OF THESE HAVE TO DO WITH EXHAUST PRESSURE SENSORS AND I THINK THIS IS AN ENVIRONMENTAL ISSUE AND SHOULD BE SUBJECT TO A MANDATORY RECALL. THE LOCAL VW DEALERSHIP DENIES ANY RECALL WOULD COVER THESE CEL CODES.

JETTA HPFP. IN EARLY 2013 MY JETTA TDI HAD TO HAVE THE FUEL PUMP REPLACED DUE TO A DEFECT IN THE MATERIALS. THE ISSUE HAS JUST HAPPENED AGAIN, SAME SYMPTOMS. ONLY THIS TIME VOLKSWAGEN IS CLAIMING THE FUEL PUMP FAILED DUE TO CONTIMINATED FUEL. MY INSURANCE COMPANY DENIES THAT FACT AND IS POINTING THE FINGER AT VW FOR A FAULTY FUEL PUMP. THE REPAIR IS UPWARDS OF $5000 AND VOLKSWAGEN IS NOT OFFERING TO COVER IT. MY CAR IS NOW SITTING IN DISASSEMBLED STATE AT THE DEALERSHIP WHILE I AM PAYING FOR A RENTAL CAR AND MY INSURANCE COMPANY AND VW PLAY A PING-PONG MATCH OF PASSING THE BLAME. *JS

UNDER NORMAL DRIVING CONDITIONS, CAR LOST ALL POWER, COMPLETELY STALLED IN FLOWING TRAFFIC ON A 2 LANE HIGHWAY AND WOULD NOT RESTART.

HPFP, HIGH PRESSURE FUEL PUMP FAILURE, IN MOTION ON CITY STREET STOPPED RUNNING, WILL NO LONGER START.

FUEL LINE #2 FAILED AFTER RECALLED REPAIR ON FUEL LINE #2 WAS PERFORMED. FUEL WAS SPILLING ONTO HOT ENGINE. I THINK THE ORIGINAL RECALL WAS NHTSA CAMPAIGN ID NUMBER : 11V490000. LOOKS TO ME THAT CAUSE OF FAILURE WAS SAME AS COVERED IN RECALL-VIBRATION FATIGUE.

YEAR: 2010 BUILD DATE: AUG 2009 MAKE/MODEL: JETTA SPORTWAGEN TDI TRANNY: 6M MILEAGE: (ACTUAL MILES AT TIME OF PROBLEM OR WHEN PROBLEM BEGAN) 57,500 DIESEL FUEL SOURCE: SHELL AND CHEVRON ADDITIVES: NOPE PROBLEM: TOOK MY TDI TO AN INDEPENDENT. FIRST TIME EVER (ALWAYS DEALER SERVICED). HAD A CHECK ENGINE LIGHT COME ON. CODE WAS A FUEL PRESSURE SENSOR. REPLACED. CAR WOULD NOT START. FOUND RUST IN FUEL FILTER CANISTER. FOUND RUST ON THE IN-TANK PUMP. REPLACED ALL THREE PUMPS, CANISTER, FUEL LINES '*THE INDEPENDENT TOOK IT ONE PIECE AT A TIME AS TO NOT OVERCHARGE. ULTIMATELY, REPLACING THE HPFP SOLVED THE ISSUE. IN FACT, THE FUEL PRESSURE SENSOR THEY ORIGINALLY REPLACED THEY PUT BACK IN AND IT WORKED, SO THEY RETURNED THE ONE FROM THE DEALER. DEALER: CHARLES MAUND, AUSTIN, TX STATUS: SINCE I HAD MY WORK DONE AT AN INDEPENDENT, VW OF AMERICA IS SCOFFING AT PAYMENT AS NOTED UNDER THE EXTENDED WARRANTY REPAIR BECAUSE THE FUEL WAS NOT TESTED BY SOMEONE AT VW. I STILL HAVE THE SAME TANK OF FUEL AS IT HAD WHEN IT WENT IN, BUT THEY REFUSE TO TEST IT CITING THAT I COULD HAVE PUT ANYTHING IN THERE. I HAVE RECEIPTS FOR MY LAST TANK OF DIESEL, AND MILEAGE/CURRENT TANK LEVELS TO PROVE THAT IT IS THE SAME. CAR HAS HAD ALL THE REQUIRED FACTORY WARRANTY INCLUSIONS, LIKE THE STICKERS AND THE FILLER TANK GUARD. WHAT'S MORE, AT 56,000 MILES (THREE MONTHS AGO) I HAD THE 60K MAINTENANCE DONE AT THE DEALER. DEALER SAYS THEY REPLACED THE FUEL FILTER AND THAT THE RUST IN THE CANISTER IS LIKELY BECAUSE OF ALL THE RAIN WE HAD THOSE THREE MONTHS. MY CAR IS GARAGE KEPT AND HARDLY USED, AS YOU CAN SEE FROM THE MILES, BUT THAT IS THEIR STORY. CURRENTLY ASKING TO TALK WITH SENIOR LEVEL CUSTOMER CARE. NOT FEELING GOOD ABOUT THIS, ESPECIALLY WITH EVERYTHING HAPPENING WITH DIESELGATE. OUT OF POCKET COSTS ARE $2600 TO DATE. I HAVE KEPT ALL THE PARTS.

MY 16 YEAR OLD DAUGHTER WAS DRIVING OUR 2010 VW JETTA CLEAN DIESEL TDI ON THE INTERSTATE AT 65 MPH WHEN SUDDENLY THE GLOW PLUG LIGHT CAME ON AND THERE WAS LOSS OF POWER; SHE PUSHED DOWN ON THE ACCELERATOR BUT TO NO AVAIL. AS THE CAR SLOWED DOWN, SHE WAS ABLE TO TAKE THE NEARBY OFF RAMP AND GET CAR TO THE SIDE OF THE ROAD. BY THE TIME THE CAR WAS COASTING TO THE SIDE OF THE ROAD THERE WAS A TOTAL LOSS OF POWER - STEERING, BRAKES, EVERYTHING. THE CAR WAS TOWED TO THE LOCAL VW DEALERSHIP WHERE THEY INFORMED WITH THE HIGH PRESSURE FUEL PUMP HAD FAILED AND IT WOULD COST $8,000 TO REPAIR. THE VOLKSWAGEN APPROVED MISFUELING GUARD WAS INSTALLED AT THE LOCAL VW DEALERSHIP SOON AFTER WE RECEIVED A LETTER FROM VW REGARDING IT. A WEEK PRIOR WE HAD RECEIVED IN THE MAIL FROM VW THEIR HPFP WARRANTY EXTENSION LETTER. HOWEVER OUR CAR IS AT 131,000 MILES. WE CONTACTED THE VWOA CUSTOMER CARE GROUP AND EXPLAINED OUR CASE ASKING THEM TO COVER THE COST OF THE REPAIR. WE HAD PURCHASED THE EXTENDED WARRANTY FROM THE VW DEALERSHIP AT THE TIME OF PURCHASE. WE EVEN POINTED OUT THAT WE HAD BEEN LOYAL VW CUSTOMERS OVER THE YEARS - HAVING PREVIOUSLY PURCHASED A JETTA, PASSAT AND BEETLE AND MY WIFE'S FAMILY HAS A LONG HISTORY OF VW PURCHASES. VW RESPONSE WAS THERE WAS NOTHING THEY COULD DO FOR US AS THE WARRANTY ONLY WENT UP TO 120,000 MILES AND WE WERE OVER IT. IT APPEARS BEING A LOYAL VW CUSTOMER IS NOT WORTH ANYTHING TO VW. WE HAVE APPEALED SEVERAL TIMES BUT KEPT GETTING THE SAME RESPONSE - NOTHING THEY COULD DO AND THEY HAVE NOW REFUSED TO FORWARD UP OUR CASE UP IN THE VWOA ORGANIZATION. WE HAVE PUT NOTHING BUT DIESEL INTO THE CAR AND URGE THE NHTSA TO ISSUE A RECALL ON THE HPFP. IT SEEMS TO ME THAT A PART THAT COSTS LESS THAN $1,000 CAN CAUSE $8,000 IN DAMAGES IS POOR ENGINEERING DESIGN. ONE EXPECTS BETTER AND FOR A DIESEL ENGINE TO LAST AT LEAST 200,000 MILES.

WHILE DRIVING IN MIDDLE LANE OF THE FREEWAY MY 2010 VOLKWAGEN JETTA TDI LOST POWER AND AND ENGINE LIGHT CAME ON. VEHICLE WAS ALMOST STRUCK BY TRAFFIC WHILE MAKING MY WAY TO THE RIGHT SIDE OF THE ROAD. CAR WAS TOWED TO LOCAL REPAIR SHOP WHERE I LEARNED THAT THE VEHICLE'S HIGH PRESSURE FUEL PUMP HAD FAILED. AFTER RESEARCHING THIS ISSUE I LEARNED FAILURE THIS HAPPENED FREQUENTLY 2009 - 2010 TDI CLEAN DIESEL VEHICLES AND INFORMATION ABOUT THIS PROBLEM IS WELL DOCUMENTED. THIS ISSUE NEEDS TO FIXED BEFORE A SERIOUS INJURY OR DEATH OCCURS.

THE HPFP FAILED ON MY VEHICLE CAUSING METAL TO CONTAMINATE THE ENTIRE FUEL SYSTEM. VWOA STATES THAT THEY WILL ONLY COVER VEHICLES WITH UNDER 120000 MILES. HOWEVER, MY VEHICLE IS SLIGHTLY OVER THAT AMOUNT. FROM THE RESEARCH I HAVE DONE, THIS PROBLEM HAS EFFECTED A LARGE AMOUNT OF VW TDI OWNERS. SINCE DIESELS ARE PURCHASED FOR THE SOLE PURPOSE OF BEING DRIVEN ON THE HIGHWAY, EXTENDING THE WARRANTY TO 120,000 MILES WILL NOT COVER MOST 5 YEAR OLD DIESELS ON THE ROAD. VW NEEDS TO TAKE RESPONSIBILITY FOR THIS FAILURE AND ISSUE A RECALL TO THOSE IMPACTED BY THIS FAILURE.

WHILE DRIVING CAR STALLED AND THE GLOW PLUG LIGHT CAMP ON, LUCKILY WE WERE ON OUR STREET AND NOT IN HIGH TRAFFIC AREA. CAR WILL NOT START AND BEING TOLD THAT WE HAVE METAL PIECES IN OUR ENGINE. 8500 FIX FOR A 2010 CAR THIS SHOULD BE COVERED UNDER SOME SORT OF RECALL OR WARRANTY IF THESE HIGH PRESSURE FUEL PUMPS ARE FAULTY. *TR

WHILE TRAVELING EASTBOUND ON INTERSTATE 82 IN WASHINGTON OUR 2010 JETTA EXPERIENCED A SAFETY-RELATED MALFUNCTION; THE "GLOW PLUG" LAMP ILLUMINATED, THEN THE "SERVICE ENGINE NOW" LAMP ILLUMINATED, FOLLOWED BY AN IMMEDIATE COMPLETE LOSS OF POWER AND THE ENGINE SHUT OFF. AFTER COMING TO A STOP, THE ENGINE WAS ABLE TO BE RE-STARTED AND THE VEHICLE WAS "LIMPED" WITH LIMITED POWER TO WITHIN A MILE OF OVERTURF VOLKSWAGEN IN KENNEWICK, WASHINGTON. THERE THE ENGINE EXPERIENCED ANOTHER TOTAL LOSS OF POWER AND WAS UNABLE TO BE RE-STARTED. THE VEHICLE WAS TOWED TO OVERTURF VOLKSWAGEN AND WE WERE INFORMED THAT THE "HIGH PRESSURE FUEL PUMP" HAD EXPERIENCED A CATASTROPHIC FAILURE, RESULTING IN METAL SHAVINGS FROM THE PUMP ENTERING THE FUEL SYSTEM, CLOGGING THE FUEL INJECTORS, AND STARVING THE ENGINE OF FUEL. WE WERE INFORMED THAT THIS ISSUE IS A DESIGN FLAW AND IS WELL KNOWN TO VOLKSWAGEN, BUT WERE TOLD THAT OUR VEHICLE WAS NOT QUALIFIED TO HAVE THIS "WARRANTY ISSUE" RESOLVED AT VOLKSWAGEN'S EXPENSE BECAUSE OF THE VEHICLE'S "REBUILT" BRANDED TITLE. IT IS MY UNDERSTANDING THAT THIS PUMP FAILURE IS OCCURRING ONLY IN VEHICLES EQUIPPED WITH THIS PARTICULAR PUMP, AND VOLKSWAGEN HAS BEEN REPLACING THEM ON VEHICLES THAT ARE PAST THEIR WARRANTY PERIOD, AT NO COST TO THE CONSUMER. I SEE THIS ISSUE AS A SAFETY ISSUE, NOT A WARRANTY ISSUE, DUE TO THE COMPLETE LOSS OF ENGINE POWER THAT CAN OCCUR WITHOUT WARNING AT HIGHWAY SPEEDS. I SEE NO DIFFERENCE BETWEEN "CLEAN TITLED" VEHICLES AND "REBUILT TITLED" VEHICLES AND THE CHANCE OF THIS PUMP FAILURE OCCURRING WITHOUT WARNING. I WOULD LIKE TO HAVE THIS ISSUE RESOLVED AT VOLKSWAGEN'S EXPENSE, DUE TO THE DESIGN FLAW OF THE VEHICLE'S HIGH PRESSURE FUEL PUMP. THANK YOU.

HIGHWAY DRIVING, GLOW PLUG LIGHT STARTED FLASHING, STARTED LOSING POWER, THEN STALL. MANAGED TO COAST OFF ONTO AN EXIT RAMP. MECHANIC TOWED, FOUND BATTERY/ALTERNATOR FINE, FUEL PRESSURE FINE, SUGGESTED DEALER REPAIR. VW DEALER SAYS ENTIRE FUEL SYSTEM NEEDS REPLACING: HPFP, FUEL LINES, ETC. NOTED NHTSA INVESTIGATION PENDING ON VOLKSWAGEN FUEL PUMP PROBLEMS FOR SIMILAR MAKE, MODEL, YEAR: NHTSA ACTION NUMBER :EA11003

THE CAR STARTED TO MAKE A STRANGE SOUND AND SHORTLY AFTER LOST ALMOST ALL POWER THEN STALLED OUT. THE GLOW PLUG LIGHT WAS FLASHING WHICH INDICATES A SIGNIFICANT PROBLEM. IT RESTARTED BUT STILL HAD NO POWER. I PULLED OVER TO THE SIDE OF THE ROAD WHERE IT STALLED AGAIN AND NOW WOULD NOT RESTART. I HAD THE CAR TOWED TO MY MECHANIC WHERE THEY FOUND THAT THE HPFP HIGH PRESSURE FUEL PUMP HAD FAILED. WHEN IT FAILED IT SELF DESTRUCTED PUTTING METAL SHAVINGS THROUGHOUT THE FUEL SYSTEM. VW'S RECOMMENDED REPAIR IS TO REPLACE THE ENTIRE FUEL SYSTEM AT A COST OF OVER $8000. THIS VEHICLE HAS BEEN METICULOUSLY MAINTAINED AND HAS NEVER BEEN MISFUELED. *TR

VEHICLE LOST POWER AND WENT INTO LIMP MODE, DASH SAID SERVICE ENGINE. CAR DIED A FEW MINUTES LATER AS I TRIED TO LIMP IT TO THE DEALER AND IT WOULD NOT RESTART. I HAD TO TOW THE VEHICLE AT MY OWN EXPENSE BUT VOLKSWAGEN DID PAY FOR A COMPLETELY NEW FUEL SYSTEM. CAUSE OF THE PROBLEM WAS A FAILURE OF THE DIESEL HIGH PRESSURE FUEL PUMP. THERE ARE THOUSANDS OF CASES OF THIS SAME PROBLEM DOCUMENTED HERE: HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=299854 VOLKSWAGEN NEEDS TO BE HELD ACCOUNTED FOR A DEFECT IN THEIR COMMON RAIL DIESEL CARS IF THERE ARE THIS MANY PROBLEMS. *TR

MY HUSBAND LEFT FOR WORK AND GOT ABOUT 1/4 MILE FROM THE HOUSE AND WAS NOT ABLE TO ACCELERATE ABOVE 30 MILES PER HOUR. THE GLOW PLUG LIGHT WAS FLASHING ALONG WITH THE ENGINE LIGHT. MY HUSBAND WENT ABOUT A MILE TOTAL BEFORE RETURNING HOME. HE LET THE CAR SIT FOR ABOUT AN HOUR AND TRIED TO START THE CAR. THE CAR WOULD NOT TURN OVER AND THE GLOW PLUG LIGHT WAS FLASHING BUT NOT THE ENGINE LIGHT (THIS TIME). AFTER SEVERAL MORE ATTEMPT TO START THE CAR IT STARTED BACK UP. HE DECIDE TO DRIVE IT TO THE DEALERSHIP, WHERE WE PURCHASED IT, TO DIAGNOSE THE PROBLEM. THE DEALER SHIP IS 30 MILES FROM OUR HOUSE. HE MADE IT ABOUT 20 MILES AND THE CAR DIED WHILE MAKING A TURN AT A STOP LIGHT. THE LIGHT TURNED RED, AS MY HUSBAND WAS STILL TRYING TO START THE CAR. IT WAS STALLED IN THE MIDDLE OF THE INTERSECTION. I WAS FOLLOWING MY HUSBAND IN ANOTHER CAR AND HAD TO STOP IN THE MIDDLE OF THE ROAD WITH MY HAZARDS ON SO CARS WOULD NOT HIT US AND GO AROUND. AFTER SEVERAL TRIES OF STARTING THE CAR HE WAS ABLE TO GET IT STARTED JUST LONG ENOUGH TO PULL TO THE SIDE OF THE ROAD. THE CAR DIED AGAIN. AT THIS POINT WE HAD TO PUSH THE CAR TO A PARKING SPOT (DOWN A DEAD END ROAD) AND CALL A TOW TRUCK. THE CAR WAS TOWED TO THE CAR DEALER SHIP THAT WE PURCHASED THE CAR. IT HAS BEEN AT THE CAR DEALERSHIP OVER A WEEK WITH NO NEWS OTHER THAN THE HIGH PRESSURE FUEL PUMP IS BAD AND SHRAPNEL HAS GOTTEN INTO THE ENGINE. *TR

2010 JETTA TDI (DIESEL) STALLED WHILE DRIVING SLOWLY ON RESIDENTIAL ROADS AND WOULD NOT START AGAIN. CAR WAS TOWED TO DEALERSHIP WHERE METAL FRAGMENTS WERE FOUND THROUGHOUT FUEL SYSTEM DUE TO FAILURE OF HIGH PRESSURE FUEL PUMP (HPFP). VW OF AMERICA PAID FOR ENTIRE FUEL SYSTEM TO BE REPLACED (~$7000). OWNER IS SURE THAT VEHICLE WAS FILLED WITH CORRECT FUEL. *TR

MY HUSBAND BROUGHT MY CAR IN FOR ROUTINE MAINTENANCE TO THE VW DEALER IN FEB 2014 INCLUDING A TIMING BELT CHANGE. HE ALSO DISCUSSED A "HARD START- NO START" ISSUE I WAS HAVING. THE SERVICE REPRESENTATIVE SAID TO MAKE SURE THE GLOW PLUG LIGHT GOES OUT BEFORE TRYING TO START (I'VE BEEN CAREFULLY WATCHING WITH EACH START SINCE THAT TIME AND THERE IS NO RELATIONSHIP BETWEEN THE LIGHT AND THE VEHICLE STARTING ISSUE). TODAY (5 MARCH 2014), I HAD A REPEAT OF THE SAME PROBLEM I'VE HAD 3 TIMES THIS WINTER: CAR STARTS FINE IN THE AM EVEN DURING BELOW ZERO TEMPERATURES, I DRIVE TO WORK AND LET IT SIT FOR 3-8 HOURS. CAR WILL NOT START, REGARDLESS OF AIR TEMP. IT TAKES 4-8 ATTEMPTS TO START THE CAR INCLUDING "PUMPING THE FUEL" PEDAL. I BELIEVE THIS IS A KNOWN AS A "HARD START- NO START" INTERCOOLER ISSUE AND IS ADDRESSED IN THE FOLLOWING VW TECHNICAL BULLETIN -- HTTPS://DRIVE.GOOGLE.COM/FILE/D/0B162-SX2NN5LUZBIDG9HCVR6NUU/EDIT?USP=SHARING. *TR

THE CAR STALLED GOING DOWN THE ROAD IN TRAFFIC AS I LOST POWER STEERING AND BRAKING. ALMOST CAUSED A WRECK EXCEPT I PULLED THE EMERGENCY BRAKE. THE ENGINE CODES PULLED WERE P0191 AND P0087. THIS LED MY MECHANIC TO DISCOVERING THIS IS A WELL KNOWN ISSUE FOR THESE 2010 VOLKSWAGEN TDI'S WHERE THE HIGH PRESSURE FUEL PUMP FAILS. SINCE THIS FUEL PUMP HAS A KNOWN HIGH RATE OF FAILURE I'M WONDERING WHAT VOLKSWAGEN IS GOING ABOUT IT. PLEASE CONTACT ME AT [XXX] IF THEY ARE OFFERING ASSISTANCE OR LET ME KNOW WHAT TO DO NEXT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WHILE DRIVING 60 MPH ON HIGHWAY 95 IN NEEDLES CALIFORNIA THE GLOW PLUG LIGHT CAME ON AND BEGAN TO FLASH. CRUISE CONTROL DISABLED AND THE SPEED OF THE VEHICLE BEGAN TO DECREASE. NO POWER COULD BE FELT WHEN PRESSING THE ACCELERATOR PEDAL AND THE ENGINE RPM BEGAN TO FALL. VEHICLE WAS PLACED INTO NEUTRAL AND COASTED TO SIDE OF THE ROAD. AFTER COMPLETE SHUTDOWN THE VEHICLE WOULD NOT RESTART, UNABLE TO DRIVE. HAD VEHICLE TOWED BY AAA TO THE NEAREST VW DEALER IN HENDERSON NEVADA AND PROBLEM WAS DIAGNOSED AS HIGH PRESSURE FUEL PUMP FAILURE (HPFP). FUEL PUMP WAS DAMAGED AND METAL DEBRIS FROM THE PUMP WAS SENT INTO THE FUEL DELIVERY SYSTEM AND RETURNED TO THE FUEL TANK. ALL FUEL RELATED PARTS WILL REQUIRE REPLACEMENT AND/OR CLEANING TO REMOVE DEBRIS. THE VEHICLE REQUIRED PARTS THAT TOOK APPROX 3 DAYS TO OBTAIN AND ADDITIONAL DAYS TO COMPLETE THE REPAIR. *TR

WHILE DRIVING THE 2010 JETTA SPORTWAGEN TDI THE GLO-PLUG LIGHT CAME ON WITH A CHECK ENGINE NOW WARNING. DEALERSHIP WAS CALLED AND THEY SAID BRING IT IN FOR INSPECTION. TWO MILES LATER THE CAR QUIT RUNNING WHILE STOPPED AT A TRAFFIC LIGHT. CAR WAS TOWED TO DEALERSHIP WHO CALLED AND SAID THAT THE HIGH PRESSURE FUEL PUMP - HPFP - HAD EXPERIENCED A CATASTROPHIC FAILURE AND METAL WAS PRESENT IN THE FUEL SYSTEM. A DAY LATER VW AGREED TO REPAIR THE CAR EVEN THOUGH WELL OUTSIDE OF THE WARRANTY PERIOD. EARLY IN THE LIFE OF THE CAR, THE FUEL PUMP LOCATED UNDER THE PARKING BRAKE HANDLE FAILED. AFTER THE FIRST FUEL PUMP FAILURE A FUEL INJECTOR FAILED, FOLLOWED BY 2 MORE FUEL INJECTOR FAILURES. THE HPFP FAILURE WAS THE FINAL FAILURE IN THE FUEL SYSTEM. *TR

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE FUEL PUMP FAILED WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE FUEL SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 33,700.

I WAS TRAVELING IN RURAL ALABAMA AND MY ENGINE FAILED; I PULLED OVER AND IT WOULD NOT CRANK. IT IS CURRENTLY IN THE SHOP. FUEL PUMP FAILURE. *JS

WHILE ON THE FREEWAY THE CAR LOST ALL POWER AND DIED. THE CODES INDICATE THAT IT IS THE FUEL PUMP. THIS SEEMS TO BE A COMMON ISSUE ON THE TDI ENGINES. 000135 - FUEL RAIL/SYSTEM PRESSURE P0087 - 000 - TOO LOW FREEZE FRAME: FAULT STATUS: 01100000 FAULT PRIORITY: 2 FAULT FREQUENCY: 1 MILEAGE: 140659 KM TIME INDICATION: 0 DATE: 2118.14.04 TIME: 01:27:53 FREEZE FRAME: RPM: 2208 /MIN INJ. QUANTITY: 21.7 MG/STR (NO UNITS): 5.0 PRESSURE: 1400.0 BAR PRESSURE: 1112.0 BAR TEMPERATURE: 52.2C TANK CONT.: 24.4 L *JS

THE CAR LOST POWER AND COULD NOT DRIVE FASTER THAN 20 MPH, DROVE IF OFF OF THE HIGHWAY AND INTO A GAS STATION WHERE THE CAR DIED AND COULD NOT BE RESTARTED. TOWED IT TO A VOLKSWAGEN DEALER, THEY REPORTED IT WAS A FUEL PUMP FAILURE AND THAT THE ENTIRE FUEL SYSTEM WOULD NEED TO BE REPLACED AT A COST OF $6100.00. *JS

2010 JETTA SPORTSWAGEN TDI APRIL 2012 - 50K MILES - FUEL PUMP SYSTEM FAILURE. VW FOUND METAL SHARDS THROUGHOUT WHOLE SYSTEM, ALL HAD TO BE REPLACED. COST OVER $7,000 PAID FOR BY VW. FUEL WAS TESTED AND FOUND NO FAULT OF DRIVER (I.E., NO GAS). FAULTY FUEL PUMP. FEBRUARY 2014 - 97K MILES - SECOND FUEL PUMP FAILURE. SAME ISSUE, METAL SHARDS THROUGH ENTIRE SYSTEM, ALL HAD TO BE REPLACED. COST OVER $8,000 PAID FOR BY VW. FUEL TESTED AGAIN AND NO FAULT OF DRIVER. HAD TO TOW OUR CAR HOME FROM VACATION SEVERAL HOURS AWAY. THERE SHOULD BE A RECALL FOR THESE CARS. IT'S DANGEROUS TO HAVE YOUR CAR STOP WORKING ALL THE SUDDEN, AND IT WILL LEAVE YOU STRANDED. NOT TO MENTION, YOU CAN ANTICIPATE IT HAPPENING EVERY 50,000 MILES. NOT A DEPENDABLE CAR. *TR

UPON CHANGING THE FUEL FILTER, THE MECHANIC NOTED THAT THERE WERE VISIBLE METAL PARTICLES IN THE FILTER HOUSING. THIS IS THE SECOND FUEL FILTER CHANGE TO SHOW METAL FILINGS. TWO DIFFERENT CERTIFIED MECHANICS NOTED THAT THIS IS A SYMPTOM OF HIGH PRESSURE FUEL PUMP FAILURE AND IF THE FUEL PUMP FAILS AT HIGH SPEED IT COULD BE A SAFETY HAZARD. VOLKSWAGEN REFUSES TO PROACTIVELY REPLACE THE FAILING FUEL PUMP. *JS

SUMMARY: WHILE DRIVING ON THE HIGHWAY IN THE HIGH SPEED LANE IN TRAFFIC AT NIGHT IN A UNLIT AREA OF RT 84 IN WILLINGTON CT. GOING TO PICKUP MY TEENAGE DAUGHTER AND HER 2 FRIENDS AFTER A CONCERT CAR WITHOUT WARNING LOST ALL POWER. I HAD TO NAVIGATE THROUGH 3 LANES OF TRAFFIC WITHOUT POWER STEERING OR POWER BRAKES TO THE BREAKDOWN LANE. I MADE IT TO THE BREAKDOWN LANE BUT ENDED UP CLOSE TO THE ROAD IN A RURAL DARK UNLIT PART OF THE HIGHWAY. THE CAR WOULD NOT RESTART AND HAD TO BE LEFT LEAVING ME STRANDED LATE AT NIGHT AND I AM DISABLED WITH DIABETES AND SEVERAL OTHER SERIOUS HEALTH ISSUES.I COULD FEEL MY BLOOD SUGAR WAS DANGEROUSLY LOW WITH NOTHING IN THE CAR TO STABLIZE IT. I HAD PROBLEMS CONTACTING HELP BECAUSE OF THE TIME OF NIGHT AND LACK OF CELL SERVICE IN THAT AREA. UPON FURTHER INVESTIGATION IT WAS FOUND THAT THE PROBLEM WITH THE CAR WAS THE HIGH PRESSURE FUEL PUMP EXPLODED SENDING METAL THROUGHOUT THE ENTIRE FUEL SYSTEM. I THINK IT IS UNACEPTABLE FOR THIS TO HAPPEN WITHOUT WARNING. MY DAUGHTER AND 2 FRIENDS WERE ALSO STRANDED 60 MILES AWAY IN WORCESTER MA.VW IS AWARE OF MANY THOUSAND OF THIS SAME EVENT BUT WON'T RECALL. I THINK THE NTSB SHOULD DEMAND A RECALL. I AM SURE PEOPLE HAVE DIED AND BEEN SERIOUSLY INJURED IN SIMILAR EVENTS. COST OF REPAIR $11,000.00 OR MORE TO REPLACE THE ENTIRE FUEL SYSTEM.I CALLED VWOA FOR SUPPORT AND THEY SAID THEY WOULDN'T COVER THE REPAIR. I THEN CALLED THE DEALER WHO SOLD ME THE CAR VW OF HARTFORD CT. AND THEY WERE RUDE AS THEY TOLD ME I WOULD HAVE TO PAY FOR ANY REPAIRS.I AM LOW INCOME AND WITH MY HEALTH ISSUES I THOUGHT THIS CAR WOULD OUTLIVE ME. I DON'T HAVE THE MONEY TO FIX THIS AND I SHOULDN'T HAVE TO. VW IS COVERING THESE ISSUES EVEN OUT OF WARRANTY TO QUIET THE NTSB BUT WON'T COVER MINE THE POOR DISABLED MAN. *JS

1WHILE DRIVING ON THE HIGHWAY IN THE HIGH SPEED LANE IN TRAFFIC AT NIGHT IN A UNLIT AREA OF RT 84 IN WILLINGTON CT. CAR WITHOUT WARNING LOST ALL POWER. I HAD TO NAVIGATE THROUGH 3 LANES OF TRAFFIC WITHOUT POWER STEERING OR POWER BRAKES TO THE BREAKDOWN LANE. I MADE IT TO THE BREAKDOWN LANE BUT ENDED UP CLOSE TO THE ROAD IN A RURAL DARK UNLIT PART OF THE HIGHWAY. THE CAR WOULD NOT RESTART AND HAD TO BE LEFT LEAVING ME STRANDED LATE AT NIGHT AND I AM DISABLED WITH DIABETES AND SEVERAL OTHER SERIOUS HEALTH ISSUES. I HAD PROBLEMS CONTACTING HELP BECAUSE OF THE TIME OF NIGHT AND LACK OF CELL SERVICE IN THAT AREA. UPON FURTHER INVESTIGATION IT WAS FOUND THAT THE PROBLEM WITH THE CAR WAS THE FUEL PUMP EXPLODED IN THE FUEL TANK SENDING METAL THROUGHOUT THE ENTIRE FUEL SYSTEM. I THINK IT IS UNACCEPTABLE AND DANGEROUS FOR THE FUEL PUMP TO EXPLODE IN A TANK OF FUEL WITHOUT WARNING. VW IS AWARE OF MANY THOUSAND OF THIS SAME EVENT BUT WON'T RECALL. I THINK THE NTSB SHOULD DEMAND A RECALL. I AM SURE PEOPLE HAVE DIED AND BEEN SERIOUSLY INJURED IN SIMILAR EVENTS. COST OF REPAIR $11,000.00 OR MORE TO REPLACE THE ENTIRE FUEL SYSTEM. UPDATED 11/24/2014 *JS

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE VEHICLE DID RESTART AFTER A FEW ATTEMPTS, HOWEVER, THE VEHICLE DID NOT ACCELERATE ABOVE 50 MPH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE NUMBER TWO FUEL INJECTOR NEEDED TO BE REPLACED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 11V490000( FUEL SYSTEM, DIESEL). THE VIN WAS NOT INCLUDED AND THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.

VEHICLE INDICATED A CHECK ENGINE LIGHT, AND FLASHING GLOW PLUG INDICATOR. DRIVING VEHICLE TO REPAIR SHOP, AND VEHICLE SUDDENLY STOPPED IN TRAFFIC AND WOULD NOT RESTART. VERY DANGEROUS SITUATION AS MORNING TRAFFIC WAS HEAVY AND AGGRESSIVE. MANAGED TO GET VEHICLE TO SIDE OF THE ROAD WITHOUT INJURY OR PROPERTY DAMAGE. VEHICLE TOWED TO DEALERSHIP. PRELIMINARY EVALUATION IS FAILED HIGH PRESSURE FUEL PUMP. *JS

NOTE TO ENGINEERS INVESTIGATING 2009-2010 VW JETTA HIGH PRESSURE FUEL PUMPS: I AM A SEMI-RETIRED AUTOMOTIVE ENGINEER THAT INVESTIGATES INSURANCE CLAIMS. I CURRENTLY HAVE ONE OF THESE ISSUES WITH METAL FLAKES APPEARING ON THE FILTERING SCREEN FOR THE HPFP LOCATED UNDER THE PRESSURE TRANSDUCER. OBVIOUSLY, THIS ISSUE HAS BEEN BUILDING FOR SOME TIME IN ORDER FOR THIS AMOUNT OF METAL FLAKES TO ACCUMULATE (VEHICLE WOULD BARELY RUN--IDLED TO DEALER). THIS IS NOT AFFECTING JUST VW'S. I SEE THE SAME ISSUE IN DODGE, GM, FORD, AUDI, AND MANY OTHER MODELS. THE PROBLEM LIES WITH THE ULTRA-LOW SULFUR FUEL. SULFUR IS A LUBRICATING MOLECULE UNDER HIGH PRESSURE APPLICATIONS. PROBLEMS BEGAN CROPPING UP AFTER SWITCH TO ULTRA-LOW SULFUR FUEL. THE OLDER LOW-SULFUR FUEL WOULD STILL LUBRICATE. THE FIX IS TO EITHER HARDEN THE PUMP FACES TO A MUCH HIGHER DEGREE SUCH THAT NO LUBRICATION IS REQUIRED. OR, ADD A 5% MIX OF BIODIESEL TO THE PETRODIESEL TO RESTORE LUBRICITY TO FUEL. SOME ADDITIVES ALSO ACCOMPLISH THIS SAME LUBRICATING EFFECT. I HAVE NOW HANDLED AROUND 40 CASES OF DIFFERING MAKES WHERE THIS SAME ISSUE CROPS UP. HOWEVER, I ONLY SEE THE CASES WHERE AN INSURANCE CLAIM IS FILED WITH AN INSURANCE CARRIER. IN ALL CASES, I GO BACK TO THE STATION WHERE THE CUSTOMER FUELS THE VEHICLE TO OBTAIN SAMPLE. THIS IS TO RULE OUT CONTAMINATED FUEL BEING DISPENSED AT A FILLING STATION. SO FAR, NO CONTAMINATION FOUND FROM FILLING STATIONS. *TR

WHEN MAKING A LEFT HAND TURN CAR STALLS. DASH PANEL LIGHTS GO OUT AND BATTERY WARNING LIGHT FLASHES AND CAR SHUTS OFF. CAR HAS TO BE COMPLETELY STOPPED,IGNITION TURNED TO THE OFF POSITION AND PUT INTO PARK, BEFORE IT CAN RESTART. VERY DANGEROUS WHEN DRIVING IN HIGH TRAFFIC AREAS. YOU DON'T HAVE TIME TO PULL OVER. THE CAR JUST DIES! *TR

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 65 MPH, THE VEHICLE SUDDENLY LOST ACCELERATION POWER AND STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE FUEL SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 11V490000 (FUEL SYSTEM, DIESEL). THE FAILURE MILEAGE WAS APPROXIMATELY 52,000.

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE TRAVELING 65 MPH, THE VEHICLE SUDDENLY LOST ACCELERATION POWER. THE CONTACT ALSO MENTIONED THAT FUEL WAS SMELLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE HIGH PRESSURE FUEL PUMP HAD FAILED. THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 58,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE HIGH PRESSURE FUEL PUMP HAD FAILED AND CONTAINED METAL FRAGMENTS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 50,000.

I WAS DRIVING AT HIGHWAY SPEED AND THE CAR IMMEDIATELY LOST POWER. A SEMI ALMOST REAR ENDED ME BECAUSE I LOST SPEED SO QUICKLY. I LOST CONTROL OF THE VEHICLE AND HAD TO FIGHT THE STEERING WHEEL TO GET OFF THE ROAD AS THE STEERING GOT EXTREMELY TIGHT. I HAD THE VEHICLE TOWED TO THE DEALER AND THEY IDENTIFIED THE HIGH PRESSURE FUEL PUMP AS FAILING. *JS

I HAVE HAD 3 DIFFERENT BOUTS WITH MY JETTA STALLING SEEMINGLY RANDOMLY AT HIGHWAY SPEEDS. EACH SET OF INCIDENTS RESULTED IN A SERVICE TRIP TO THE VW DEALERSHIP FOR REPAIRS. FOR THE FIRST INCIDENT THE VEHICLE WAS UNDER THE 60,000 MILE WARRANTY AND AN EXPENSIVE REPAIR WAS COVERED UNDER WARRANT. THE SECOND SERIES OF INCIDENTS OCCURRED ABOUT 6 MONTHS LATER, AFTER THE CAR WAS NO LONGER UNDER WARRANTY AND THE REPAIR - REPLACEMENT OF THE CAM SHAFT POSITION SENSOR. ANOTHER SERIES OF INCIDENTS HAS JUST BEGUN AND I'M HEADED TO THE DEALERSHIP AGAIN. ALL 3 SERIES OF INCIDENTS HAD THE SAME SYMPTOMS: 1) THE CAR INTERMITTENTLY STALLING UNEXPECTEDLY DURING ACCELERATION AND 2) SLOW CHUGGING START OCCASIONALLY WHEN THE CAR IS WARMED UP. *JB

I WAS DRIVING DOWN A RESIDENTIAL STREET, AND SUDDENLY THE ENGINE LIGHT CAME ON AND THE CAR COMPLETELY SHUT DOWN. I WAS ABLE RESTART THE ENGINE, BUT COULD ONLY DRIVE FOR ABOUT 5 YARDS BEFORE THE CAR STALLED OUT AGAIN. DEALERSHIP SAYS THIS IS A FUEL PUMP FAILURE, AND I SEE MANY REPORTS OF THIS WITH THE JETTA TDI MODEL FOR 2010.

I HAD A HPFP FAILURE ON MY JETTA WHILE I WAS DRIVING. THE CAR DIED AND WOULD NOT START. I GOT A P0087 CODE OFF THE ENGINE. I HAD THE FUEL TESTED AND IT WAS CLEAN. IT LOOKS LIKE IT'S GOING TO BE A HPFP FAILURE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

2010 JETTA TDI. WHILE DRIVING, HIGH PRESSURE FUEL PUMP FAILED CAUSING MAJOR ENGINE DAMAGE DUE TO METAL SHAVINGS IN FUEL SYSTEM. VOLKSWAGEN USED THE CONTAMINATED FUEL EXCUSE BUT COVERED THE NEAR $5000 REPAIR BILL. *TR

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA TDI. THE CONTACTED STATED THAT WHILE DRIVING 5 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS CONFIRMED THAT THE HIGH PRESSURE FUEL PUMP HAD FAILED. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS BEING REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 67,000.

WE BOUGHT OUR 2010 VOLKSWAGEN JETTA AT JEREMY FRANKLIN IN KANSAS CITY AS OF DECEMBER 2012 WITH APPROXIMATELY 33000 MILES. IN FEBRUARY OF 2013 WHILE DRIVING ON THE HIGHWAY AT 65 MPH THE CAR SUDDENLY SHUTS DOWN WITH NO WARNING. WE TOWED THE CAR TO A LOT AND THE CAR SAT FOR A FEW DAYS AND THEN STARTED AGAIN. WE THEN DROVE THE CAR WITHOUT INCIDENT FOR ANOTHER WEEK, THEN WHILE ON THE HIGHWAY THE CAR SUDDENLY SHUTS DOWN AGAIN. THE CAR AGAIN SAT FOR A COUPLE OF DAYS AND THEN STARTED AGAIN. WE TOOK OUR CAR BACK TO THE DEALERSHIP AND WAS TOLD THEY COULDNT FIND THE SOURCE OF THE ISSUES AND WE WERE INSTRUCTED TO TAKE THE CAR HOME. WE DID AND FOUND OURSELVES AGAIN STRANDED AT A GROCERY STORE PARKING LOT THIS TIME. WE FINALLY TOWED THE CAR BACK TO THE DEALERSHIP WHERE WE PURCHASED THE CAR AND THEY HELD THE CAR FOR TWO AND HALF WEEKS AND AGAIN COULD NOT FIND THE SOURCE OF THE ISSUE. NO ISSUES WERE SHOWING UP ON THEIR COMPUTERIZED DIAGNOSTIC SYSTEM. THE DEALERSHIP FINALLY TOWED THE CAR TO VOLKSWAGEN, WHERE THEY FOUND THE FUEL PUMP AND CRANK WERE BAD ON THE CAR. *TR

GLOW PLUG LIGHT CAME LIT ON DASH AND SAID "SERVICE ENGINE IMMEDIATELY." ENGINE THEN LOST POWER ON INTERSTATE (DANGEROUS). WHEN RE-CRANKED, ENGINE WAS SLUGGISH AND WOULD NOT ACCELERATE ABOVE 40MPH. VW SERVICE SAID IT WAS DUE TO A FAULTY FUEL PUMP. *TR

THE VEHICLE STALLED IN TRAFFIC. THE VEHICLE WOULD NOT RESTART. IT HAD TO BE TOWED TO A VW DEALER. THE VW DEALER TOLD ME THE PUMP DISINTEGRATED AND SENT METAL FINES THROUGH THE FUEL RAIL CLOGGING THE FUEL INJECTORS. THE DEALER CLAIMS IT WAS DUE TO THE DIESEL FUEL BEING CONTAMINATED. I HAVE DOCUMENTATION THAT ONLY DIESEL FUEL WAS IN THE TANK (FUEL RECEIPTS). THE DEALER DID NOT DO A LAB ANALYSIS ON MY FUEL. THEY SAID IT DIDN'T SMELL RIGHT. *TR

STOPPED AND FILLED UP VEHICLE WITH DIESEL FUEL AROUND 5 PM 9/16/12. DROVE APPROXIMATELY 10.2 MILES AND THE VEHICLE ENGINE STOPPED. EXACTLY AT THAT MOMENT, THE WARNING 'CHECK ENGINE NOW' INDICATOR PHRASE WAS DISPLAYED IN THE DISPLAY PANEL. IT STAYED ON FOR A FEW SECONDS, AND THEN TURNED OFF, AND THERE WERE NO INDICATOR LIGHTS ON AT ALL THAT WOULD INDICATE LOW OIL PRESSURE OR FUEL OR ANY OTHER SYMPTOM. WE HAD ENOUGH MOMENT TO ROLL TO THE SHOULDER OF THE ROAD TO GET OUT OF THE WAY OF TRAFFIC. ELECTRIC WAS WORKING AS WE WERE ABLE TO ROLL DOWN THE WINDOWS OF THE CAR, THE RADIO WAS ON. PUT THE CAR IN PARK AND TRIED STARTING THE ENGINE. IT WOULD CRANK OVER, BUT NEVER CATCH. EVEN THOUGH WE HAD JUST PUT IN 13.5 GALLONS OF FUEL, THE CAR BEHAVED AS THOUGH IT WERE OUT OF FUEL. I CHECKED THE RECEIPT TO VERIFY DIESEL WAS PUT INTO THE CAR. I ALSO CALLED THE CHEVRON STATION WHERE I PURCHASED THE FUEL TO ASK IF THERE HAD BEEN A MISTAKE OR IF THEY'D HAD OTHER REPORTS OF BAD DIESEL FROM THEIR STATION. THE OWNER OF THE STATION CALLED ME BACK AND LET ME KNOW THAT HE RAN LAB TESTS TO DETERMINE WHETHER OR NOT THEIR WAS CONTAMINATION IN THE FUEL LINES (EITHER FROM GASOLINE OR FROM WATER), AND HE SAID THERE HAD NOT BEEN. CALLED THE VOLKSWAGEN ROADSIDE ASSISTANCE AND THEY SENT OUT A TOW TRUCK TO COLLECT THE CAR AND TAKE IT BACK TO THE DEALERSHIP. *TR

I WAS TRAVELING APPROXIMATELY 45 MPH IN MY 2010 JETTA TDI WHEN THE CAR SUDDENLY STALLED WITHOUT ANY WARNING. I WAS UNABLE TO NAVIGATE THE CAR TO A SAFE PLACE AND WAS STUCK IN THE MIDDLE TWO LANES. I WAS UNABLE TO RESTART THE CAR AND HAD TO WAIT 40MIN FOR A TOW TRUCK TO ARRIVE. THE DEALERSHIP INDICATED THAT THE FUEL PUMP FAILED. THEY ARE ALSO HAVING TO REPLACE THE FUEL DISTRIBUTOR AND FILTER. *TR

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 60 MPH THE VEHICLE STALLED. HE WAS ABLE TO RESTART THE VEHICLE SHORTLY THEREAFTER. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER STATED THAT THE FUEL SYSTEM NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND THE CURRENT MILEAGE WAS 119,000.

FIRST INCIDENCE: DRIVING 45 MPH, GLOW PLUG LIGHT STARTS FLASHING, CAR GOES INTO LIMP MODE. DRIVE SLOWLY HOME. CALL DEALERSHIP, TOLD TO RECYCLE (TURN OFF/ON). IF LIGHT GOES AWAY SHOULD BE OKAY THEY SAID. TOOK TO DEALER TO CHECK OUT TO BE SURE. THEY FOUND NOTHING. A WEEK LATER WAS ON THE HIGHWAY AND NEEDED TO ACCELERATE AND FLASHING LIGHT AND LIMP MODE AGAIN. PULLED OVER, TURNED OFF AND ON. DROVE SLOW TO THE DEALER, CAR VERY SLUGGISH. IT IS AT THE DEALER NOW AND THEY ARE GOING TO REPLACE THE HIGH PRESSURE FUEL PUMP (HPFP). *TR

CHECK ENGINE LIGHT CAME ON WHILE DRIVING JETTA TDI TO/FROM WORK. TOOK IT TO DEALER AND THEY REPORTED IT WAS THE HIGH PRESSURE FUEL SENSOR (VEHICLE STORING FAULT P0191). THEY REPLACED THE SENSOR (THINKING IT FAULTY), BUT THE FOLLOWING DAY THE CHECK ENGINE LIGHT CAME ON AGAIN. RETURNED THE VEHICLE TO THE DEALER AND THEY REPORTED THE SAME FAULT. DEALER KEPT VEHICLE FOR INVESTIGATION. THEIR INVESTIGATION REVEALED METAL SHAVINGS IN THE FUEL SYSTEM. THE VEHICLE REMAINED WITH THE DEALER BETWEEN 03/23-03/27 WHEREIN THEY REPLACED THE ENTIRE FUEL SYSTEM. ON THE MORNING OF 06/29 WENT TO START CAR AND COULD NOT GET IT TO START. VEHICLE WAS TOWED TO DEALER AND THE REPLACEMENT HIGH PRESSURE FUEL PUMP WAS DETERMINED FAULTY. *JS

I HAVE EXPERIENCED REPEATED PROBLEMS WITH MY TDI MANUAL TRANSMISSION JETTA SPORTWAGEN. WITHIN THE FIRST MONTH OF BUYING THIS VEHICLE, I EXPERIENCED A LURCHING SENSATION WHICH WOULD COME AND GO RANDOMLY ESPECIALLY WHEN IN THIRD GEAR. BROUGHT IT TO THE DEALER, BUT THEY COULDN'T REPLICATE. THIS HAS CONTINUED SPORADICALLY FOR OVER A YEAR AND A HALF. THE VEHICLE ALSO SOMETIMES IDLES VERY ROUGHLY WHEN AT A STOP. MORE RECENTLY, IN MARCH 2012, THE VEHICLE STALLED TWICE WHILE DRIVING AT ABOUT 30 - 40 MPH AND ALSO NOW IN MAY 2012 IT HAS DONE THIS AGAIN. THERE ARE NEVER ANY WARNING LIGHTS THAT GO ON, ONLY THE ENGINE LIGHT ONCE IT HAS ACTUALLY STALLED. BROUGHT IT TO THE DEALER EVERYTIME THIS HAS HAPPENED AND THEY ARE NEVER ABLE TO REPLICATE THE SITUATION, SO THEY SEND ME HOME WITH IT. I WAS VERY UPSET WITH THIS AND CONFRONTED THE DEALERSHIP ABOUT THIS WHEN I REALIZED HOW MANY OTHERS HAVE HAD SIMILAR PROBLEMS. THEY SAID THEY COULDN'T DO ANYTHING BECAUSE THEY COULDN'T FIND ANYTHING TO FIX. THEY SAID THEY WOULD NOTIFY VOLKSWAGEN AND I CALLED THEM AS WELL AND HAVE NOW BEEN GIVEN A CASE NUMBER. THIS IS A SERIOUS ISSUE AND NEEDS TO BE ADDRESSED. THERE IS POTENTIAL FOR MAJOR LIFE THREATENING SITUATIONS IF A CAR STALLS WHILE DRIVING IN THE MIDDLE OF TRAFFIC. I FEEL LIKE I AM DRIVING AROUND IN A TIME BOMB, BECAUSE YOU NEVER KNOW WHEN IT IS GOING TO HAPPEN. *TR

JETTA TDI, CHECK ENGINE LIGHT AND GLOW PLUG WARNING LIGHT FOLLOWED BY REDUCED POWER. VEHICLE RAN FOR SEVERAL MILES BEFORE STALLING. WOULD NOT RESTART. DEALER REPORTED FAILURE OF THE HIGH PRESSURE FUEL PUMP AND METAL IN THE FUEL FILTER. *TT

WHILE DRIVING ON THE INTERSTATE AT APPROX 72 MPH, THE VEHICLE SUDDENLY LURCHED, THE INDICATOR LIGHT FOR THE GLOW PLUG CAME ON, AND THEN ALL POWER WAS LOST AS THE ENGINE STALLED. I WAS ABLE TO SAFELY MANEUVER THROUGH TRAFFIC TO THE EMERGENCY LANE AND STOP. THE VEHICLE WOULD NOT RESTART. I HAD REFUELED THE VEHICLE APPROX 168 MILES EARLIER AND HAD BEEN RUNNING AT HIGHWAY SPEEDS THE ENTIRE TIME UNTIL THE VEHICLE MALFUNCTION. I HAVE A 2010 VW JETTASPORTWAGEN TDI. DIAGNOSTIC TESTS RUN BY THE VW DEALER TWO DAYS LATER REVEALED THAT THE HIGH PRESSURE FUEL PUMP HAD DISINTEGRATED, SENDING METAL DEBRIS INTO THE FUEL FILTER AND THROUGHOUT THE FUEL SYSTEM. THE VEHICLE HAD UNDERGONE A 40K SERVICE JUST THREE DAYS PRIOR BY A VW DEALER. *TR

DRIVING ON INTERSTATE AT 70MPH. ENGINE GLOWPLUG LIGHT AND MAIN FAILURE LIGHT CAME ON AND ENGINE QUIT. DEALER ADVISED FAILURE WAS DUE TO HIGH PRESSURE FUEL PUMP FAILURE. *JS

WHILE DRIVING IN THE CITY, THE CAR DIESEL ENGINE STARTED TO LOOSE POWER AND VIBRATE. THE CAR STALLED IN THE MIDDLE OF THE ROAD WITH TRAFFIC HAVING TO STOP BEHIND US. WE MANAGED TO MOVE ASIDE AND PUSH THE CAR TO A LOW TRAFFIC ROAD. WE TOWED THE CAR TO THE NEAREST GARAGE. AN INITIAL INSPECTION INDICATED THAT THE FUEL SYSTEM WAS DAMAGED, REASON FOR SENDING IT TO THE VW DEALER AT CLEAR LAKE. THE DEALER TOLD US THAT VW OF AMERICA IS CONSIDERING HELPING US WITH THE REPAIR, QUOTED BETWEEN $7,200 TO $10,000, AND HAD INSTRUCTED THEM TO ORDER THE PARTS. TODAY, HOWEVER, IT WAS SUGGESTED THAT I COULD APPROVE THE REPAIRS FOR THEM TO START WORKING ON THE CAR AND NO RESPONSE WAS AVAILABLE FROM THE MANUFACTURER. THE PROGNOSIS IS A CATASTROPHIC FAILURE OF THE HIGH PRESSURE FUEL PUMP THAT RELEASED METALLIC DEBRIS INTO THE FUEL SYSTEM. AT THE MOMENT OF THE INCIDENT THE CAR WAS BARELY 15 MONTHS OLD, WITH 43K MILES AND PROPERLY MAINTAINED. IT DOES NOT GO THROUGH HEAVY TRAFFIC AND ONLY RIDDEN ON REGULAR ROADS. TO MY QUESTION ABOUT HOW COULD I HAVE AVOIDED THIS PROBLEM, THE VW SERVICE REP STATED THAT IT WAS A SIMPLE MECHANICAL FAILURE. *TR

OVER A WEEK AND 200 MILES AFTER FILLING UP. WITH DIESEL. THE CAR SUFFERED A FUEL SYSTEM FAILURE RESULTING IN A COMPLETE ENGINE SHUTDOWN AT 45 MPH WITH NO RESTART. THIS INCLUDED A REDUCTION IN STEERING AND BRAKING POWER. VW DEALER STILL HAS THE CAR AS OF 3/27/2012. CLAIMING HIGH LEVELS OF GASOLINE IN THE FUEL. WHEN ASKED HOW THEY DETERMINED THE PRESENCE OF GASOLINE THEY SAID THEY COULD SEE IT IN A SAMPLE. NO REAL ANALYSIS. JUST VISUAL ASSESSMENT. OPENED AN INCIDENT REPORT WITH FUEL SUPPLIER AND THEY SAY IT IS MOST LIKELY A DIFFERENCE IN SEASONAL MIXES OF DIESEL FUELS. VW SAYS THEY ARE GOING TO REPAIR THE CAR FOR FREE THEN VOID MY WARRANTY ON THE FUEL SYSTEM. *TR

THE FIRST TIME INCIDENT HAPPENED CAR ALMOST STALLED AND CHECK ENGINE LIGHT CAME ON AN CAR HAD LOSS OF POWER CAR WAS TAKEN TO COOLEY VW THEY TOLD ME AT FIRST THAT IT WAS A TUBE FROM THE TURBO HAD TO BE REPLACED AND THE PART WAS ON BACK ORDER SO I CALLED BACK A WEEK LATER AN THEN THEY TOLD ME THAT THE EMISSION SYSTEM WAS PLUGGED AN IT HAD TO REPLACE THE WHOLE EXHAUST SYSTEM THAT TOOK THEM A MONTH TO COMPLETE AN THEY PUT 100 MILE ON THE CAR BECAUSE THEY COULDN'T GET THE CHECK ENGINE LIGHT TO GO OUT THEN THEY TOLD ME THAT THE CAR NEED AN EMISSION ECM THEY REPAIRED THE CAR I PICKED THE CAR UP I DIDN'T EVEN GO 1 MILE FROM DEALER AN THE CAR ALMOST STALLED ON ME AGAIN SO I CHECKED THE FUEL FILTER FOR MY SELF AND FOUND THAT IT WAS RUSTING INSIDE FILTER HOUSING AN THE HOUSING WAS FULL OF GOLD METAL FILLING I REPLACED THE 92 DOLLAR FUEL FILTER MYSELF BECAUSE THE DEALER DIDN'T EVEN CHECK THE FILTER THE SECOND TIME THE INCIDENT HAPPENED I WAS DRIVING DOWN I91 IN VERMONT AN THE CAR JUST COMPLETELY DIED WHILE I WAS DRIVING AT 68 MPH I THEN HAD THE CAR TOWED OVER 100 MILES TO CAPITAL CITY'S VW THEY HAD TOLD ME THAT THE EXHAUST EMISSION WERE PLUGGED AN THAT THEY HAD TO CHANGE THE EXHAUST SYSTEM AGAIN THERE WAS ABOUT 4000 MILES ON IT SINCE COOLEY DID IT THEN THE DEALER CALLED ME BACK AN SAID THAT THERE WAS RUST AND THE METAL FILLINGS IN THE FILTER HOUSING AGAIN THE FILTER BARELY 2000 MILES ON THE FILTER CAPITAL CITY'S THEN TOLD ME THAT THE WHOLE FUEL SYSTEM HAD TO BE CHANGED THEY CHANGED THE TANK PUMPS LINE INJECTOR RAIL INJECTORS ITS BEEN 2000 MILES SINCE THEY DID THAT AND NOW THE CAR IS ACTING UP AGAIN IT HAS ALMOST DIED SEVERAL TIME AGAIN I DON'T WANNA TAKE IT BACK TO DEALER IF THEY ARE GOIN TO KEEP PUTTING THE SAME INFERIOR PART BACK ON 3 TIMES WITH IN 10000 MILES IS RIDICULOUS I AM LOOKIN MYSELF FOR A PUMP THAT WILL WORK SINCE VW DOESN'T WANT TO FIX IT RIGHT. *TR

DIESEL ENGINE HIGH PRESSURE FUEL PUMP FAILED WHILE I WAS TRYING TO PASS ANOTHER CAR ON THE FREEWAY. GLOW PLUG LIGHT WHEN ON AND CAR IMMEDIATELY WENT INTO LIMP MODE, DROPPING DOWN TO 35-40MPH, MAKING ME UNABLE TO FOLLOW THROUGH ON PASSING THE OTHER CAR AND FORCING VEHICLE BEHIND ME TO BRAKE. WAS ABLE TO DRIVE SLOWLY 1/4 MILE TO EXIT, WHERE THE CAR STALLED AND WOULD NOT RESTART. TOWED TO VW SERVICE CENTER, WHERE THEY FOUND METAL PARTICLES THROUGHOUT FUEL SYSTEM. HIGH PRESSURE FUEL PUMP HAD FAILED CATASTROPHICALLY, DESTROYING FUEL SYSTEM AND REQUIRING ENTIRE FUEL SYSTEM REPLACEMENT. *TT

2010 JETTA WAGON TDI (35,500 MILES); WOULDN'T START IN AM BEFORE WORK. WOULD CRANK BUT NOT TURN OVER. HAD IT TOWED TO DEALERSHIP. SAID "FUEL WAS CONTAMINATED" AND THAT THE TECH SAW SPECKS OF SOMETHING THROUGHOUT THE FUEL SYSTEM. THEY TRIED THE LINE ON ME OF "YOU MUST HAVE MIXED IT WITH GAS". I BOUGHT A DIESEL B/C I WANTED TO DRIVE A DIESEL. I DIDN'T MIX THEM UP. NOT TO MENTION I HAD ALREADY DROVE THROUGH HALF A TANK OF FUEL BEFORE THIS INCIDENT. VW AGREED TO WARRANTY THE REPAIR HOWEVER AT $7500. WHAT HAPPENS NEXT TIME? AM I OUT $8K? I HAVE THE TOP TIER "PLATINUM" WARRANTY BUT WILL IT BE COVERED FOR "CONTAMINATION?" MY VW SERVICE DEPT COULDN'T (OR WOULDN'T) TELL ME ANYTHING. I CALLED VWOF AMERICA CUSTOMER SERVICE LINE TO HAVE A CASE OPENED OR GET ANY INFORMATION. I WAS CALLED BACK IN 24HRS BY A WOMAN THAT SAID, "IT'S NOT VW'S FAULT YOU NEED TO CALL THE GAS STATION B/C IT WAS CONTAMINATED FUEL". I FIND IT ODD THAT VW IS COVERING THE COST YET IT'S "NOT THEIR FAULT". WHAT COMPANY HONORS A WARRANTY WHEN THEY ARE NOT RESPONSIBLE FOR THE DAMAGE? SO WHERE DOES THAT LEAVE TDI OWNERS? ARE WE SUPPOSED TO CARRY AROUND A CHEMISTRY SET AND TEST THE FUEL BEFORE WE FILL UP? IF I WANT TO TAKE A TRIP WITH MY CAR I GUESS I CAN'T NOW B/C I MAY NOT BE ABLE TO FIND A "BRAND NAME" LIKE SHELL OR EXXON. I THINK I HAVE TO SELL THE CAR. KBB TRADE-IN IS $20,000. I WONDER WHAT VW WILL OFFER ME ON A TRADE OF MY TDI...... MY CAR IS STILL IN THE SHOP A WEEK LATER, I HAVE A LOANER, I'M TERRIFIED TO PICK UP THE CAR AND TOMORROW IT DOESN'T START AGAIN. *TR

FIRST OCCURRENCE MY WIFE WAS DRIVING , SHE CALLED ME AND SAID THE CAR WAS GOING ABOUT 10 OR 20 MPH. I ASKED WERE THERE ANY WARNING LIGHTS ON THE DASH THAT WERE ON SHE SAID THE SERVICE ENGINE SOON WAS ON AND THAT WAS ALL. SHE MADE IT HOME , CALLED THE LOCAL DEALERSHIP. WE CARRIED THE CAR THEY SAID THEY CHANGED THE FUEL FILTER. BROUGHT THE CAR HOME ,IT RAN FINE FOR A FEW DAYS THEN THE SAME THING HAPPENED AGAIN. THE NEXT DAY I CONTACTED VOLKSWAGEN ASSISTANCE FOR THEM TO TOW IT TO THE SHOP. THE CAR WAS UNDER THE CARPORT , I WAS GOING TO PUSH IT OUT TO GO ON THE TOW TRUCK , BUT IT STARTED AND RAN FINE WITH THE EXCEPTION OF THE ENGINE LIGHT BEING ON. THE WRECKER CARRIED IT TO THE SHOP. THE DEALERSHIP CALLED ME ONJAN. 03 2012 AND TOLD ME THE FUEL WAS CONTAMINATED WITH WATER, AND THEY WOULD HAVE TO FLUSH THE SYSTEM($500_+). THEY CALLED BACK THE NEXT DAY AND SAID THEY WOULD HAVE TO REPLACE EVERYTHING IN FUEL SYSTEM($8500 +). AFTER SOME RESEARCH MY CAR IS DOING THE SAME THINGS AS IF THE FUEL PUMP HAD FAILED. THIS IS A VERY COMMON THING FROM WHAT I"VE READ ON THIS MOTOR . THAT'S WHERE WERE AT NOW. *TR

THE HIGH PRESSURE FUEL PUMP ON MY 2010 VW TDI FAILED ON THE HIGHWAY CAUSING A SUDDEN LOSS OF POWER. THE VEHICLES WAS TOWED TO THE DEALERSHIP WHERE THEY CONFIRMED THAT THE INJECTOR PUMP WAS THE PROBLEM. *KB

TL- THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THAT THE FUEL LINE AND THE FUEL INJECTOR WAS CRACKED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE REPAIRS WERE MADE TO THE VEHICLE UNDER NHTSA CAMPAIGN ID NUMBER: 11V490000 (FUEL SYSTEM, DIESEL) BUT THE REPAIR DID NOT RECTIFY THE FUEL LINE ISSUE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT THAT THEY WOULD NOT TAKE THE LIABILITY FOR REPLACING ANY ADDITIONAL PARTS. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 28,000 AND THE CURRENT MILEAGE WAS 29,000. KMJ

ACCELERATING AT 40MPH CAR BEGAN TO RUN ROUGH AND LOSE POWER. ENGINE GLOW PLUG LIGHT BEGAN TO FLASH. CAR STALLED AND COULD NOT BE RESTARTED. CAR TOWED TO HILEY VOLKWAGEN IN ARLINGTON TEXAS. SERVICE DEPARTMENT STATES THAT HIGH PRESSURE FUEL PUMP DISINTEGRATED AND THAT METAL PARTICLES WERE FOUND IN THE FUEL LINES. WILL BE REBUILDING THE FUEL SYSTEM AND REPLACING THE FUEL TANK. *TR

CAR ENGINE DIED ON THE HIGHWAY. COASTED TO SIDE OF ROAD. HIGH PRESSURE FUEL PUMP FAILURE. ENTIRE FUEL SYSTEM BEING REPLACED. METAL SHAVINGS THROUGHOUT FUEL SYSTEM. *KB

HIGH PRESSURE FUEL PUMP FAILED DURING ROUTINE DRIVING IN A RESIDENTIAL AREA. CAR WAS ABLE TO COST TO A SAFE LOCATION AWAY FROM TRAFFIC. *TR

THE VEHICLE GLOW POINT WARNING LIGHT STARTED FLASHING AND VEHICLE LOST POWER. RESTARTED AND DROVE HOME WITH NO FURTHER INDICATOR LIGHTS. RESTARTED THE FOLLOWING MORNING, CHECK ENGINE AND GLOW POINT WARNING LIGHTS ILLUMINATED (GLOW POINT WAS FLASHING). CAR LOST POWER TO THE POINT THAT WHEN THE TOW TRUCK CAME THE CAR COULD NOT CLIMB THE RAMP UNDER ITS OWN POWER THOUGH ENGINE WAS RUNNING. VW DEALER REPORTS THAT FUEL PUMP DISINTEGRATED AND SENT METAL FRAGMENTS INTO FUEL SYSTEM DAMAGING COMPONENTS OF SYSTEM BUT NOT ENTERING ENGINE. *TR

TOOK MY CAR TO GET THE OIL CHANGE AND WAS TOLD I HAVE A FUEL LEAK. LOOKED UP CAR ONLINE AT SAFECAR.GOV AND SAW THE 2010 JETTA HAS BEEN RECALLED FOR: POWER TRAIN:AUTOMATIC TRANSMISSION/ FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS. HAVING A FUEL LEAK IS MORE THAN DRAINING ON GAS MILEAGE IT IS A FIRE/EXPLOSIVE HAZARD. ON THE WEBSITE IT STATES: CONSEQUENCE: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE. I AM HAVING ISSUES WITH THE FUEL LEAKAGE AND NEED MY CAR RECALLED OR FIXED BY THE MANUFACTURER. HTTP://WWW-ODI.NHTSA.DOT.GOV/RECALLS/RESULTS.CFM THANK YOU *TR

WHILE TRAVELING AT 70 MPH ON CRUISE CONTROL GLOW-PLUG LIGHT FLASHED SOLID, COMPLETE LOSS OF POWER, ENGINE STALLED, AND NO RESTART. DEALER STATED CATASTROPHIC FAILURE OF THE HIGH PRESSURE FUEL PUMP CONTAMINATED ENTIRE FUEL SYSTEM AND WOULD NEED TO BE REPLACED.

DEAD PEDAL - HESITATION - STALLING. ABSOLUTELY NO THROTTLE RESPONSE WHEN TRYING TO PULL OUT INTO TRAFFIC. YOU PRESS THE PEDAL AND THERE IS NOTHING THERE. STOP AND GO TRAFFIC ON THE EXPRESSWAY OR STOPPING AT AN INTERSECTION THE CAR STALLS. ALSO HAVE EXPERIENCED SURGING AT HIGHWAY SPEED AS IF THE FUEL SUPPLY IS CUTTING OUT. WE RECENTLY RETURNED FROM A TRIP TO PORTSMOUTH NH. WE WERE IN SIX LANES OF STOP AND GO TRAFFIC ON I-95 AND THE CAR KEPT STALLING. WHEN YOU WOULD DEPRESS THE GAS PEDAL TO CONTINUE MOVING THERE IS NO THROTTLE RESPONSE. WE PARKED IN THE PORTSMOUTH MUNICIPAL GARAGE. AS WE ASCENDED THROUGH THE GARAGE LOOKING FOR A PARKING SPACE [INCLINE POSITION] ABOUT 5 MPH, THERE WAS NO THROTTLE RESPONSE. THE CAR WOULD NOT MOVE. I HAD TO CONTINUE TO FEATHER THE PEDAL TO PULL INTO A PARKING SPACE. WE NOW HAVE 20K MILES ON THE CAR AND HAVE HAD THE CAR LOOKED AT 6 TIMES AT THE LOCAL VW DEALER WITH NO FIX. THE CAR HAS SERIOUS THROTTLE ISSUES AND HAS BECOME DANGEROUS TO DRIVE. PLEASE NOTE TO NUMEROUS TO MENTION VW TDI HESITATION ISSUES ON MANY WEB FORUMS. SOMEONE IS LIKELY TO GET SERIOUSLY INJURED OR KILLED WITH THIS PROBLEM THAT VW MUST KNOW ABOUT. PLEASE ADVISE !!!!!

VEHICLE WAS GOING AT 25 MPH WHEN IT STARTED LOSING POWER. IT STOPPED BARELY FEW FEET AFTER THE INTERSECTION. ENGINE WOULD NOT START. VEHICLE WAS TOWED AWAY TO THE NEAREST VW DEALERSHIP. AFTER INVESTIGATION DEALERSHIP SAYS THAT THEY FOUND TRACES OF GASOLINE IN THE FUEL PUMP AND GASOLINE HAS DESTROYED THE FUEL SYSTEM. I SHOWED THEM MY LAST THREE RECEIPTS AS PROOF THAT I ALWAYS PUT DIESEL IN THE VEHICLE. CAR IS AT THE DEALERSHIP SINCE 01-AUG-2011. THEY SAID THEY HAVE TO REPLACE THE WHOLE SYSTEM. INITIALLY THEY HAVE QUOTED ABOUT $4800 + LABOR BUT LATER ON THEY AGREED TO FIX IT UNDER WARRANTY , CAR IS ONLY 18 MONTHS OLD AND HAS 1800 MILES. I AM CONCERNED THAT THIS MAY HAPPEN AGAIN AS I STILL WOULD END UP GOING TO THE SAME DIESEL STATIONS FOR FILLING AND IF THEY ARE CONTAMINATED AS DEALER SAYS I MAY END UP WITH A DEAD ENGINE AGAIN.

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA SPORTSWAGEN. THE CONTACT STATED THAT THE HIGH PRESSURE FUEL INJECTOR PUMPED FAILED, CAUSING THE VEHICLE TO STALL. THE FAILURE RECURRED REPEATEDLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 9,000 AND THE CURRENT MILEAGE WAS 51,000. UPDATED 9/13/11 *CN UPDATED 2/22/12 *CN

WAS TRAVELING ON A CITY BLOCK IN SAN FRANCISCO WHEN THE ENGINE LIGHT WENT ON. THERE WAS A SLIGHT POWER SURGE BUT NO STALL. DRIVING INTO THE NEXT CITY BLOCK THE CAR COMPLETELY DIED AND I PULLED OVER TO CURB. UNABLE TO START AGAIN. CAR WAS TOWED TO VW DEALER. WAS TOLD THE FUEL PUMP IN THE TANK HAD MALFUNCTIONED, AND CONTAMINATED THE FUEL TANK. ENTIRE FUEL PUMP, TANK, SYSTEM IS BEING REPLACED UNDER WARRANTY.

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT ATTEMPTED TO START THE VEHICLE BUT IT WOULD NOT START. APPROXIMATELY TWENTY MINUTES LATER, THE CONTACT WAS ABLE TO START THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD THAT THERE WAS WATER IN THE FUEL SYSTEM. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 18,000.

GLOW PLUG LIGHT CAME ON, THEN ENGINE LIGHT, CAR WOULDN'T ACCELERATE WHEN I STEPPED ON THE GAS. HAD TO PULL OFF THE INTERSTATE. BUT MADE IT HOME SLOWLY. CAR TOWED TO DEALER. DEALER SAYS ITS BAD FUEL. DEPT OF CONSUMER PROTECTION CHECKED STATIONS. NO PROBLEMS FOUND WITH FUEL. CAR NEEDS WHOLE NEW FUEL SYSTEM-8K TO REPAIR. VW WON'T FIX. TOLD ME TO CALL INSURANCE COMPANY. CAR STILL AT DEALER NOW OVER 3 WEEKS.