2012 Ram 2500 Engine Problems

Your exhaust manifold on the passenger side has warped and broken one of its bolts, causing exhaust fumes to leak into your vehicle's cabin. This is a serious issue that requires immediate attention to prevent exposure to dangerous exhaust gases. The fix will involve replacing the exhaust manifold and its bolts to restore a proper seal.

Your truck's exhaust manifold bolts are warping and breaking because steel and aluminum expand at different rates when heated, causing an exhaust leak into the engine bay. Exhaust fumes are being drawn into your cabin through the heating and air conditioning system, creating a noticeable smell and potentially causing headaches from carbon monoxide exposure. You may notice a loud ticking noise along with strong exhaust odors inside the cab. Fixing this typically involves replacing the exhaust manifold bolts and possibly the manifold itself to prevent exhaust fumes from entering the cabin.

Your 2012 Ram 2500 Hemi engine developed a ticking sound that persists even after a tune-up, spark plug replacement, and distributor work. A dealership confirmed internal engine damage is causing the problem, and you've learned other Dodge owners report the same issue. Repair or replacement would cost between $8,000 and $10,000, and neither Dodge nor NHTSA has provided a solution. Fixing this will likely require engine rebuild or replacement.

Your engine has been making a ticking noise on the passenger side due to a warped exhaust manifold that broke two bolts in the engine block. This caused an exhaust leak before the oxygen sensor, which made your truck run rich and reduced fuel efficiency. The repair involved replacing the exhaust manifold, gasket, and bolts.

The bolts that attach your exhaust manifold to the engine are breaking off repeatedly. You'll first notice a tapping noise as the manifold comes loose, and then exhaust fumes may leak into the cabin, creating a safety and health hazard. This has happened three times on your truck despite only having 85,000 miles, requiring a dealer repair that included replacing the passenger-side cylinder head. The repair will involve removing the exhaust manifold, replacing the broken bolts, and potentially inspecting or replacing the cylinder head.

TL* THE CONTACT OWNS A 2012 RAM 2500. WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND POWERED OFF THE ENGINE. THE VEHICLE WAS RESTARTED AND WAS ABLE TO DRIVE NORMALLY. THE FAILURE RECURRED NUMEROUS TIMES. THE CONTACT CALLED UNIVERSITY CHRYSLER DODGE JEEP RAM OF FLORENCE (LOCATED AT 2354 FLORENCE BLVD, FLORENCE, AL 35630, (256) 766-7324) AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.

TL* THE CONTACT OWNS A 2012 RAM 2500. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED NORMALLY. THE CONTACT STATED THAT THE FAILURE OCCURRED ON A DAILY BASIS FOR APPROXIMATELY ONE MONTH. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 37,000. *DT*JB

TL* THE CONTACT OWNS A 2012 RAM 2500. WHILE DRIVING APPROXIMATELY 25 MPH, A RATTLING NOISE WAS HEARD FROM THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED AND REPLACED THE WATER PUMP. THE DEALER WAS NOT CALLED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE FAILURE MILEAGE WAS 67,197.

WE TOOK OUR TRUCK TO THE DEALERSHIP FOR A BRAKE RECALL. AFTER THE RECALL WAS FIXED, MY DAD WAS DRIVING HOME ON THE FREEWAY WITH MY TRUCK WHEN MY CHECK ENGINE LIGHT STARTED FLASHING AND BLINKING. IT WAS ALMOST IMMEDIATELY AFTER THAT THE TRUCK STARTED TO SHAKE AND WAS HAVING A HARD TIME ACCELERATING. HE GOT THE TRUCK TO MY HOUSE. I DROVE IT STRAIGHT TO THE MECHANIC A FEW MILES FROM MY HOUSE AND EXPERIENCED THE SAME ISSUES. WHENEVER I WOULD SLOW DOWN THE TRUCK WOULD START SHAKING. IT WAS EXTREMELY HARD TO ACCELERATE AND MADE IT DIFFICULT TO TURN AS I DIDN'T KNOW IF IT WOULD ACTUALLY GO. I DIDN'T WANT TO BE STUCK IN ONCOMING TRAFFIC. THE CHECK ENGINE LIGHT WAS CONTINUOUSLY BLINKING AND BEEPING. AFTER A TOW TRUCK TOOK IT BACK TO THE DEALERSHIP, THEY SAID THE CAM SHAFT AND LIFTERS NEEDED TO BE REPLACED. WE WERE TOLD IT WOULD BE A VERY EXPENSIVE REPAIR. AFTER LOOKING ONLINE, THERE WERE MANY FORUMS WHERE PEOPLE HAD EXPRESSED CONCERN ABOUT THIS SAME ISSUE IN 2011 AND 2012 DODGE RAM TRUCKS. THERE WERE NO INDICATIONS THAT THERE WERE ANY ISSUES WITH THE TRUCK BEFORE IT HAPPENED.

TL* THE CONTACT OWNS A 2012 RAM 2500. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD AN ABNORMAL NOISE WHEN THE STEERING WHEEL WAS TURNED LEFT OR RIGHT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE EXHAUST MANIFOLD FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 52,000.

WHILE DRIVING NORMALLY AT A SPEED APPROXIMATELY 45 MPH, THE TRUCK FLASHED THE CHECK ENGINE LIGHT A COUPLE TIMES AND CHIMED, THEN I LOST ALL POWER. THE POWER STEERING WAS DISABLED, AND I HAD TO MANUALLY GUIDE THE TRUCK OFF THE ROADWAY INTO A PRIVATE DRIVE AND CALL FOR A TOW. I WAS TOLD BY A SHOP THAT THE VALVE SEAT OF CYLINDER 1 FAILED AND BROKE APART INSIDE THE CYLINDER AND DAMAGED THE CYLINDER WHILE ALLOWING OIL INTO THE CYLINDER AS WELL. I AM TOLD THE ENGINE NEEDS REPLACEMENT. I AM WAITING FOR THE SHOP'S DIAGNOSIS DOCUMENTATION.

TL* THE CONTACT OWNS A 2012 RAM 2500. WHEN STARTING THE VEHICLE, THE WATER PUMP FAILED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 50,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2012 RAM 2500. THE CONTACT STATED THAT THE VEHICLE SHOOK WHILE DRIVING HIGHWAY SPEEDS. THE CONTACT TOOK THE VEHICLE TO THE DICK HUVAERES DEALER WHERE IT WAS DIAGNOSED THAT THE TICKING IN THE MOTOR WAS DUE TO A FAULTY WATER PUMP. THE DEALER REPLACED THE WATER PUMP; HOWEVER, THE FAILURE RECURRED. THE CONTACT RETURNED THE VEHICLE TO THE DEALER, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. AFTER RETURNING HOME FROM THE DEALER, THE VEHICLE SUDDENLY CAUGHT FIRE WHILE PARKED IN THE DRIVEWAY. THE CONTACT CALLED THE BERLIN TOWNSHIP AND ELMONT FIRE DEPARTMENTS TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED. THE VEHICLE WAS SALVAGED. THERE WERE NO INJURIES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED CASE NUMBER: [XXX]. THE APPROXIMATE FAILURE MILEAGE WAS 89,000. *TT INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

TL* THE CONTACT OWNS A 2012 RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE EXHAUST FRACTURED CAUSING THE EMERGENCY BRAKE WIRING AND THE ABS WIRING TO MELT WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT DIAGNOSED THAT THE EXHAUST PIPES ,THE ABS, AND THE WIRING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000.

TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL) AND STATED THAT THE PART WAS NOT AVAILABLE FOR AN EXTENDED PERIOD OF TIME. THE DEALER DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE CONTACT'S VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V635000 (FUEL SYSTEM); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE). THE CONTACT RECEIVED A RECALL LETTER IN JANUARY OF 2015. THE DEALER STATED THAT THE PARTS WERE NOT AVAILABLE TO PERFORM THE RECALL REPAIR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL); HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL). TWO DEALERS STATED THAT THE PART NEEDED WAS NOT AVAILABLE. THE DEALER DID NOT PROVIDE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 7/13/15*CN

TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER:14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL); HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 6/11/15*CN

TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER:14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 5/28/15 *TA THE VEHICLE WAS REPAIRED UNDER RECALL. UPDATED 11/23/2015*JS

TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL); HOWEVER, THE CONTACT WAS UNABLE TO HAVE THE VEHICLE SERVICED UNDER THE RECALL BECAUSE THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE REPAIR. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 6/8/15*CN

TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED A NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT FELT THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. MA 08/05/15

TL*THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

CHRYSLER HAS HAD NHTSA CAMPAIGN NUMBER: 14V635000 COMPONENT(S): ENGINE AND ENGINE COOLING , FUEL SYSTEM, DIESEL IN EFFECT SINCE OCTOBER 2014. MY TRUCK HAS THIS RECALL PROBLEM. I CONTINUALLY HAVE ENGINE CODE P2609 ACTIVE. I HAVE CONTACTED CHRYSLER ABOUT THIS AND ALL THEY WILL SAY IS THAT THE REPAIR PARTS ARE NOT AVAILABLE. MY TRUCK IS STILL UNDER WARRANTY BUT CHRYSLER WILL NOT REPAIR THE TRUCK. ALONG WITH THE "CHECK ENGINE LIGHT", I HAVE A DIESEL FUEL SMELL ENTERING THE PASSENGER COMPARTMENT AT VARIOUS TIMES. CHRYSLER WILL GIVE ME NO DATE AS TO WHEN THEY WILL REPAIR THIS PROBLEM. THE LOCAL DEALERS SAY THEY CAN DO NOTHING UNTIL CHRYSLER GET THE REPAIR PARTS NEEDED. IT SEEMS LOGICAL THAT IF CHRYSLER HAS ISSUED A WARRANTY ON A VEHICLE THEN THEY SHOULD BE ABLE TO REPAIR THE VEHICLE. *TR

TL*THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING , FUEL SYSTEM, DIESEL) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

DODGE HAS ISSUED A RECALL FROM OCTOBER 7 2014 FOR RECALL P65 / NHTSA14V-635 STATING THAT THE DIESEL FUEL HEATER MAY OVERHEAT LEAK DIESEL AND CAUSE SMOKE UNDER THE HOOD OR CATCH FIRE. AFTER HAVING SERVICE AT THE DEALER THEY STATED THEY HAVE NO FIX YET OR PARTS FOR THIS SAFETY ISSUE WHICH MAY CAUSE A FIRE, HERE ARE THEIR WORDS FROM THEIR WEBSITE UNDER RECALL STATUS FOR MY VIN INCOMPLETE BUT REPAIR PARTS ARE NOT AVAILABLE. THIS IS THE SECOND SAFETY ISSUE WHERE DODGE RAM HAS HAD A SAFETY ISSUE BUT NO PARTS THE FIRST WAS THE LEFT TIE ROD WHERE THEY HAD NO PARTS AVAILABLE. WHY ARE THEY ALLOWED TO ISSUE SAFETY RECALLS AND HAVE NO PARTS TO FIX ISSUES THAT COULD CAUSE THE VEHICLE TO CATCH ON FIRE OR SMOKE THIS PLACES PEOPLE ON THE ROAD AT RISK. *TR

TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT STATED THAT WHILE THE VEHICLE WAS ON AND IN PARK, THE UNDERCARRIAGE AREA OF THE CABIN CAUGHT FIRE WHICH CAUSING THE VEHICLE TO BECOME ENGULFED IN FLAMES. THE CONTACT DID NOT DISCLOSE IF A POLICE REPORT WAS FILED OR NOT OR HOW THE FIRE WAS EXTINGUISHED. THE VEHICLE WAS DESTROYED. THE CONTACT RECEIVED NHTSA CAMPAIGN ID NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL) AFTER THE FAILURE WAS EXPERIENCED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.

WHEN DRIVING THE TRUCK I WILL OCCASIONALLY SMELL A VERY STRONG DIESEL EXHAUST ODOR FROM THE A/C VENTS IN THE CABIN OF THE TRUCK, ONLY WHEN FRESH AIR IS SELECTED (NOT RECIRCULATE). I HAVE NOTICED THIS SMELL ONLY OCCURS WHEN COMING TO A STOP, AND USUALLY CORRESPONDS WHEN THE TRUCK IS IN A REGENERATION PROCESS. THE ONLY INDICATOR I HAVE FOR REGENERATION IS SEVERELY DECREASED FUEL MILEAGE THE VERY STRONG UNTREATED EXHAUST SMELL BEING EMITTED INTO THE CABIN OF THE TRUCK. AFTER 5 VISITS TO THE DEALERSHIP FOR ATTEMPTED WARRANTY REPAIR, THE TRUCK STILL WAS NOT REPAIRED AND THE CONDITION CONTINUED. I CONTACTED CHRYSLER'S CUSTOMER CARE AND TO SEEK RESOLUTION AND WAS ASSIGNED A CASE NUMBER. IN THE MEANWHILE, I WAS INSTRUCTED BY THE DEALERSHIP TO KEEP THE VENTILATION SYSTEM IN RECIRCULATION MODE TO AVOID BREATHING IN THE EXHAUST FUMES. SUBSEQUENTLY, AFTER SEVERAL DIFFERENT CONVERSATIONS WITH CHRYSLER CUSTOMER CARE STAFF, I WAS INFORMED THIS IS A "CHARACTERISTIC" OF THE VEHICLE AND THAT I RESERVED MY LEGAL RIGHTS TO PURSUE ACTION. CHRYSLER KNOWS THIS IS A PROBLEM, AND WOULD RATHER SEEK PROTECTION FROM LEGAL SETTLEMENT OR SOME OTHER MEANS TO AVOID ADDRESSING THE PROBLEM. I DON'T THINK THE OWNERS OF THESE VEHICLES (INCLUDING MYSELF) SHOULD BE EXPOSED TO UNTREATED EXHAUST IN THE CABIN OF THE TRUCK, PERIOD. THIS IS A CARBON MONOXIDE SAFETY HAZARD THAT NEEDS TO BE REVIEWED AND ADDRESSED. UPON RESEARCH I DISCOVED SIMILAR COMPLIANTS WERE MADE TO THE NHTSA FOR MODEL YEARS 2010 AND 2011. ADDITIONAL RESEARCH SHOWS OTHER RAM 2500/3500 OWNERS WITH THE 6.7 CUMMINS TURBO DIESEL HAVE THE SAME ISSUE. I HAVE DOCUMENTATION OF ALL THE DEALERSHIP VISITS, ALL THE TIMES/DATES AND NAMES OF THE CHRYSLER EMPLOYEES I SPOKE WITH, ALONG WITH MY ORIGINAL COMPLAINT SENT TO CHRYSLER. FURTHERMORE, I HAVE THE RESEARCH DOCUMENTATION AVAILABLE FROM OTHER NHTSA COMPLIANTS. *TR

TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT STATED THAT THE COMPUTER SYSTEM WOULD NOT WORK IN COLD WEATHER, CAUSING ALL OF THE GAUGES TO MALFUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER WHO COULD NOT LOCATE OR DIAGNOSE ANY FAILURE WITH THE VEHICLE. THE MANUFACTURER WAS NOTIFIED WHO INFORMED HIM TO TAKE THE VEHICLE BACK TO THE DEALER FOR A SECOND DIAGNOSTIC TEST. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 16,487.