2015 Ford Focus — Known Issues & Recalls

The contact owns a 2015 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle hesitated while accelerating and changing gears. The vehicle was driven to an independent mechanic, where it was diagnosed, and the failure was associated with NHTSA Campaign Number: 13V523000 (POWER TRAIN); however, the VIN was not associated with the recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 75,000.

My name is [XXX] I own a 2015 ford focus 4dr sedan It has 131908 miles and the issue I've been having is with The TCM module on the transmission it won't go into sleep mode and it's draining the battery is have gotten a customer care warranty notice on my car but the local Ford dealer said it's expired in November of last year and I've been having family issues and personal issues we're i wasn't able to take care of it but I need this issue fixed on my car it's my only means of transportation for me and my mom because she has altzimers and dementia Here's my number [XXX] this my cell to contact me I live in Portland Oregon And also right now I have no way of paying for the repairs on my car because I lost my job because of a lower back injury I thought it was going to be a easy fix but it something I'm not able to do And thought it was going to be covered under the so called warranty which it's actually part of the recall I've gone through something like this with a previous car I owed and it was supposed to be taken care of through a recall but the dealer wouldn't do anything about they wanted me to pay on my vehicle I have i need this repaired I should not have to pay for the repairs that should be done through warranty or a recall it's been happening since the past couple years INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owned a 2015 Ford Focus. The contact stated that the vehicle had experienced transmission failures, including the transmission slipping, the vehicle stalling, and the check engine warning light being illuminated. Additionally, after starting the vehicle, the vehicle failed to respond after shifting to the reverse or drive. The vehicle was towed to the residence and examined by an independent mechanic, who diagnosed the vehicle and determined that the transmission power shifter was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 149,000.

Vehicle acceleration dies out during normal pressure of gas pedal. Coding showing transmission Actuators malfunctioning. Odometer Reading 120,631 check engine light came on. Date of malfunction 11/24/2025 , Vehicle was taken to Affordable Transmission on 11/25/2025

2015 Ford Focus with DPS6 automatic transmission failure. 109,### miles only. Symptoms: No reverse gear, severe clutch slip (high RPM but car barely moves), strong burnt clutch smell, check engine light on. DTC codes: P07A3, P07A5, P087A, P087B, P090C. Ford dealer (Camelback Ford, Phoenix AZ) diagnosed the issue but quoted $3,175 just for labor to open the transmission for inspection, refusing any goodwill assistance after 14M02 program expired in August 2025, despite low mileage and known widespread DPS6 problems covered by TSB 16-0129. Note : "November 20, 2025 – Date I purchased the vehicle. The transmission problem (no reverse, clutch slip, burnt smell) was present immediately upon purchase." Requesting NHTSA investigate Ford's refusal to offer reasonable post-warranty assistance for this well-documented safety-related transmission defect.

The contact's son owns a 2015 Ford Focus. The contact stated that while her son was driving at various speeds, the vehicle hesitated while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to a dealer however, the mechanic could not diagnose the failure because there were no active warning lights illuminated. The contact's son had received a message from the Ford App that there was a Customer Satisfaction Program for the TCM (Transmission Control Module). The failure persisted, and the dealer was notified of the program, and the contact was informed that the Customer Satisfaction Program had expired. The contact was referred to the manufacturer, and the manufacturer informed the contact that there was a warranty on the vehicle for the purge valve. The contact was instructed by the manufacturer to inform the dealer to have the purge valve replaced under the warranty. The contact informed the dealer about the purge valve warranty, and the dealer informed the contact that the failure was not related to the purge valve and insisted that the failure was related to the TCM. After several disputes between the dealer and the manufacturer about the issue, the contact was informed that no assistance for the repair would be provided. The vehicle was not repaired. The failure mileage was approximately 113,000.

Transmission problem

Vehicle was checked by local dealer and stated repair code 14M02 needed to be completed. 10 year extended warranty was concluded in June, 2025, but this is a safety concern. The car stopped in the road, right off the interstate, because the transmission quit working properly. Gears shifted very hard when transmission started working again. After parking, the car would not go back into reverse.

After my car was left on idle for a couple minutes ( about 5), it began to shake, the check engine light came on, then it completely died. When I went to restart it, it stalled and then finally turned on but when I began to take off it began to shake and died on me again while driving. I was left in the middle of rode. I put my blinkers on and had to leave my car off for a couple minutes so it would restart again. Then I pulled over to the side so I wouldn’t be in harm’s way. My mechanic believes there is something wrong with thee fuel pressure system whether it be a fuel pump or a fuel pressure sensor.

I am in possession of Recall18S32/NHTSA recall18V-735 notice that has not been repaired but it is not showing up on my VIN and Model lookup.

Car is stalling at low speed and losing power. Does not do it at high speed. Occasional check engine light. Will start surging. This is a know issue with the Ford Focus and Ford has issued a Customer Satisfaction Program 24N07. They refuse to honor the program unless you keep paying them for diagnostic work until the code shows up for it. I have ran the codes myself on it and it is fuel related to the Canister Purge Valve. This issue is very dangerous in that the car does stall out on the road with no warning. I have had this issue with the car for several years and have received the CSP letter but cannot get the work done. The issue happened 3 times yesterday, 11-5-2025.

Your transmission is overheating and not shifting gears properly, causing the car to jerk and hesitate when you press the gas pedal. This has happened repeatedly even after five repair attempts, and you've experienced near-miss accidents because the car won't respond normally while driving. The transmission may need to be rebuilt or replaced entirely.

Your car jerks and loses power while driving, feeling like it's not getting enough fuel and struggling to accelerate. You believe this is related to a part that was already recalled and replaced twice on your vehicle, not a transmission problem. A Ford dealer quoted $200 to diagnose it but insisted it's a transmission issue. Fixing this likely involves inspecting or replacing the same recalled component that's been replaced before.

While driving steering suddenly stopped working. Red light came up onto dash stating "steering down safely pull over"

I’m writing about my 2015 Ford Focus (VIN: [XXX] ), which has under 38,500 miles. While heading to work, I suddenly lost power steering—no warning, just stiff steering out of nowhere. The repair cost me over $5,000 to replace the electric power steering rack, which only a Ford dealer could handle due to software restrictions. This follows a TCM replacement that Ford covered under recall. I contacted Ford for goodwill assistance, but they refused. At this mileage, these failures are unacceptable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

At 116,500 miles, the oil pump failed on my Ford Focus. This was verified by an auto repair shop. The car has the Ford ecoboost 1.0 engine. Ford has a recall on this engine with a build date of March 24, 2015 to May 4, 2018. My car was built on Aug 4, 2015 within the range of the recall. The recall states that cars with automatic transmission are included. My car has a manual 6 speed. I don't believe that the transmission has anything to do with the oil pump failure. The car "check engine" and "check oil" lights came on and there were multiple instances where the car stalled and I became stranded, often on busy roads. It has been well documented on the internet that Ford has had issues with this engine. I am not planning on repairing this car as the shop explained it probably will be in the range of $7000 which way more than the value of this car that is almost 10yrs old and 116500. The car is currently sitting in my garage non drivable with a scrap value of pennies compared what trade-in value or extend life of the car.

I was getting ready to leave the grocery store and I crank up my car and I had a light come on stating that my car was overheating transmission turn off the car and as I tried to pull out of the parking lot, the car would barely accelerate it would barely go to mountain and it was stuttering up the heels I had to turn off the vehicle. Let it sit for five minutes to let it cool off and then I had to crank the car back up and then it started to drive again, but I did get a indication on my front dash stating that it was transmission

Transmission overheating and internal wear (metal particles in fluid) following electrical/TCM malfunction in Ford Focus DPS6. Transmission failure recurred after earlier repair under 14M02. Current failure includes overheating messages, shudder, and loss of safe drivability. Ford acknowledges issue relates to known PowerShift defect but refuses coverage. Vehicle unsafe.

The transmission keeps slipping at 2nd and 3rd gear. The shop I got it at fixed it twice and this time the transmission light turned on. They told me to go through this process

The car would not shift into a gear, would not shift gear to propel itself in traffic causing a safety issue. A warning light would come on saying the transmission was getting overheated. Ford of Glenwood Springs Colorado refused to look at the car because of its age despite the recall on the clutch for the year, make and model of the car. A NAPA shop determined the clutches were out. NAPA quoted $4,253 to fix the problem. I called Ken Garff Ford in Fort Collins Colorado at 4809 S. College Avenue to get this fixed under the recall. They said my VIN number wasn't covered, and the cost would be $6,000. I called Ford 1-866-436-7332 spoke to Ron employee #2192738 and was told he would document the call but could not do anything. Ford is aware of the safety issue we simply want them to standby their product and fix the problem or reimbursing us for the repairs to avoid a further hardship to get to work. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)