2002 Ford Explorer Lights Problems

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT SPORADICALLY, THE BRAKE LIGHTS WOULD NOT ILLUMINATE WHEN THE BRAKE WAS DEPRESSED. THE DEALER DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE MANUFACTURER WAS AWARE OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS 111,000. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT THE REAR TAIL LIGHTS AND BOTH TURN SIGNALS STOPPED ILLUMINATING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO INSPECTED THE LIGHTS AND STATED THAT THE WIRES WERE CORRODED AND NEEDED TO BE REPAIRED. THE MECHANIC PERFORMED THE REPAIRS. THE FAILURE RECURRED APPROXIMATELY THREE WEEKS LATER. THE MANUFACTURER WAS NOTIFIED, AND OFFERED ASSISTANCE. THE FAILURE MILEAGE WAS 111,000.

MY LEFT TURN SIGNAL WENT OUT. REPLACED BULB...NO CHANGE. WENT TO DEALERSHIP. THEY REPAIRED STEERING WHEEL HARNESS ISSUE. WORKED UNTIL I DROVE MY AUNT TO DET. METRO FOR A FLIGHT TO DALLAS. SPENT THE WHOLE DRIVE TRYING TO MAKE OTHER DRIVERS REMEMBER HAND SIGNALS FROM THERE TO CENTER LINE, MI ON FREEWAYS. THIS TIME THE DEALERSHIP CLAIMED THE WIRES NEEDED TO BE COVERED WITH A MELT-WRAP TO STOP THE TILT WHEEL FROM PINCHING THE WIRES. I THINK IT SHOULD HAVE BEEN RIGHT FROM DAY 1 AND FORD'S SHOULD PAY US BACK FOR BOTH THE BRAKES AND THE LIGHTS. RECALL AND FIX THIS! I HAVE NEVER HAD TO PUT THIS MUCH INTO BRAKES/LIGHTS BEFORE. I'VE BEEN DRIVING FOR 44 YEARS. ALL FORD PRODUCTS. WHAT'S THE PROBLEM WITH THIS ONE????? I NEGLECTED TO SAY THAT MY ROTORS WENT AT 12000 MILES. CAR TURNED INTO A DEATH TRAP SHORTLY AFTER. KEPT TAKING IT TO DEALERSHIP COMPLAINING THAT IT TOOK OFF AND PULLED RIGHT WHEN I BRAKED. THEY REPLACED EVERYTHING THEY COULD TALK ME INTO PAYING FOR TO THE TUNE OF $1100 AND WHEN IT DIDN'T FIX IT THEY STILL CLAIMED THAT THEIR CHARGE WAS TAKING CARE OF "OTHER" PROBLEMS. I MADE THE TECH. DRIVE WITH ME AND REPEAT WHAT CAUSED THE PROBLEM (SLOW BRAKING AS IF AT A STOP SIGN/TRAFFIC LIGHT) AND HE ACTUALLY YELPED WHEN THE TRUCK TOOK OFF AGAIN AND TURNED RIGHT ON HIM. TURNS OUT IT WAS A BAD RIGHT FRONT ANTI-LOCK SENSOR THAT COST ME A FORTUNE. TOO BAD FORD DOESN'T HAVE MORE CAPABLE TECH'S TO FIND THE PROBLEM. ALSO TOO BAD THAT THE SENSOR WASN'T WORKING WELL IN THE FIRST PLACE. BRAKE MODULE REPLACEMENT, ROTORS, PADS...STILL UNDER 30000 AND HAVE NO CONFIDENCE. ALL MY OTHER CARS/TRUCKS WENT WAY BEYOND 70000 MILES WITHOUT ROTOR PROBLEMS. I'M A "LIGHT" BRAKER. THIS IS THE FIRST TIME I EVER HAD TO DO THE BRAKES LIKE THIS. I'M BEGINNING TO THINK IT'S A CHEAP-DOWN, MORE WORK FOR THE DEALERS ISSUE. SHAME ON SOMEBODY! *TR

BRAKE LIGHT SWITCH INOPERATIVE (STAYS STUCK ON). *TR

TL*THE CONTACT OWNS A 2002 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE LIGHT SWITCH THAT CONTROLS THE HEADLIGHTS HAS BEEN REPLACED FOUR TIMES. THE FAILURE OCCURRED ONCE WHILE DRIVING 25 MPH. HE FEELS THAT THE VEHICLE IS UNSAFE TO DRIVE BECAUSE THE LIGHT SWITCH MAY NOT WORK WHILE DRIVING AT NIGHT. THE CURRENT AND FAILURE MILEAGES WERE 22,000. UPDATED 01/06/09. *LJ UPDATED 01/06/09. *JB

THE DOME LIGHT ON THE 2002 FORD ESCAPE 3.0L CAUSED BURNING ON THE SUNROOF SLIDING COVER WHEN THE COVER WAS OPENED. THIS HAS THE POTENTIAL TO STARTING A FIRE, ALTHOUGH NOW THEREWAS ONLY A SLOW BURN. *AK

EVERY TIME IT RAINS WATER LEAKS THROUGH THE REAR TAIL LIGHT ON THE TOP REAR OF THE VEHICLE. ON SOME OCCASIONS, THE BULBS SHORT OUT. VEHICLE IS OUT OF WARRANTY AT 72,000 MILES. WATER ALWAYS POOLS IN THE REAR AREA.

DT*: THE CONTACT STATED THE BRAKE LIGHT SWITCH HAD MALFUNCTIONED. THE ORIGINAL SWITCH WAS NO LONGER AVAILABLE. UPDATED 12/28/06. *JB

THE HEADLIGHTS CONTINUES TO GO ON AND OFF. MOST OF THE TIME IT IS THE PASSENGER SIDE LIGHT BUT THE DRIVERS SIDE ALSO DOES THE SAME THING. I HAVE REPLACED THE PASSENGER SIDE PIGTALE BUT THE PROBLEM IS STILL THERE. *NM

BRAKE LIGHT SWITCH FAILS TO ACTIVATE UNTIL MODERATE BRAKE PEDAL FOOT PRESSURE IS APPLIED; RESULTING IN DELAYED/INADEQUATE BRAKE LIGHT ACTIVATION AND DIFFICULTY DISENGAGING GEAR SELECTOR FROM PARK. ALSO, SPEED CONTROL WILL NOT TURN OFF UNTIL PRESSING HARD ENOUGH TO ENGAGE SECONDARY/BACKUP DISCONNECT ON SPEED CONTROL. INITIAL APPLICATION OF BRAKE WILL RESULT IN VEHICLE ATTEMPTING TO MAINTAIN SPEED, INCURRING INCREASED THROTTLE APPLICATION AND AUTO TRANSMISSION DOWN SHIFTING. REMOVAL AND OBSERVATION OF THE SWITCH ACTION APPEARS TO SHOW THE MECHANICAL INTERFACE BETWEEN PLUNGER AND CONTACTS RESULTS IN CONTACTS OPENING WIDER IN THE INITIAL TRAVEL OF THE SWITCH BEFORE ACTUALLY CLOSING, RESULTING IN DELAYED CLOSING OF THE SWITCH. *JB

THE BREAK LIGHTS ON MY CAR GET STUCK ON, I HAVE HAD IT HAPPEN TO ME THREE TIMES, I HAVE TAKEN IT TO THE DEALER WHEN I WAS IN PENSACOLA AND HAD TO PAY TO HAVE IT FIXED...IT SEEMS TO BE THE SENSOR ATTACHED TO THE BREAK PEDAL. *NM

LEFT TURN SIGNAL INOPERABLE AT TIMES. BULB REPLACED BUT DID NOT HELP. DEALERSHIP DETERMINED THAT CONNECTOR @ MULTI-FUNCTION SWITCH DID NOT KEEP GOOD CONNECTION IN STEERING COLUMN. UNIT IS 2002 MODEL WITH LESS THAN 45,000 MILES. COST OF REPAIR EXCESSIVE. *NM

DASHLIGHT ILLUMINATES, DOOR CHIME SOUNDS AND AUTOMATIC DOOR LOCKS ENGAGE INTERMITTENTLY WHILE DRIVING. I HAVE TAKEN THE CAR TO MULTIPLE DEALERS AND HAVE HAD MULTIPLE ATTEMPTS TO RECTIFY YET THE ISSUE HAS YET TO BE RESOLVED.*AK

THE LIGHTING SYSTEM ON THE FORD EXPLORER SPORT, IS NOT GOOD FOR NIGHT DRIVING AT LONG DISTANCES, I HAVE A 98 FORD F-150 AND THE LIGHTS ARE MORE PROPER FOR THIS KIND OF DRIVING. THE NEW SYSTEM THAT IS BEING USED NOW, HAS POOR VISABILITY ON BRIGHT. THIS IS A PROBLEM SINCE I HAVE HAD THE SPORT. ALSO I HAVE NOTICED SEVERAL AUTO MANUFACTORS ARE USING THIS SYSTEM, WHICH COULD POSE A SAFETY HAZARD.*AK

VARIOUS PROBLEMS WITH 2002 FORD EXPLORER.*MR THE LEFT SIGNAL WIRE INSULATION RUBBED THROUGH THE BOAT TRAILER. WHEN IT SHORTED OUT THE FUSE BLEW AFTER IT TOTALLY MELTED THE INSULATION OFF THE WIRES THROUGH THE TONGUE OF THE TRAILER ALL THE WAY BACK TO THE LEFT SIGNAL LIGHT. CONSUME NOTED THIS IS A SAFETY CONCERN, HAD THIS BEEN A CAMPER A FIRE WOULD'VE RESULTED. *PH

NO SUMMARY. DT

WHILE DRIVING AT HIGHWAY SPEEDS HEADLIGHTS WENT OUT. DEALER HAS REPLACED HEAD LAMP CONTROL AND HEAD LAMP RELAY. PLEASE PROVIDE FURTHER INFORMATION.*AK

WHILE DRIVING, HEADLIGHTS TEND TO BE DIM, MAKING IT DIFFICULT TO VIEW FRONT OF VEHICLE, MECHANIC HAS ADJUSTED HEADLIGHTS TWICE; HOWEVER, HEADLIGHTS TEND TO SET BACK IN DIM MODE. *AK *JB