2008 Ford Edge Suspension Problems

While driving your 2008 Ford Edge, you experienced unexpected vibration and jumping with no warning lights. A mechanic found that the passenger-side CV axle seal and lower ball joint had failed and replaced them, but the problem happened again shortly after. The manufacturer indicated the repair requires a special kit, though the exact part wasn't clearly identified. The fix will likely involve replacing the CV axle assembly and lower ball joint with quality parts designed to prevent premature failure.

We were turning a corner at a light and our tie-rod, axel, control arm, sway bar link and CV Shaft all broke at once causing our car to come to a dead stop in the road and we could not even push it out of the road, we were able to purchase the CV Shaft, Control Arm ASY, and The Sway Bar Lnk. for the one side the car is still not moveable we need a tire that we cant afford and from the looks of it the other side may do the same and the part that worries me about our safety is that is it does it on the freeway and we come to a dead stop in traffic or something it will be bad. What we need and I was told that if my car showed up on the recall list for any reason that you would fix any safety issues free of charge and my car did come up on the list. I just purchased the vehicle in november 2020 and was told all the original parts are still on it. Please let me know where to go to get my car fixed this is our only means of transportation to go to school for me and my kids and for my husband to find a job thank you. What we need is a tire for the front passenger side and the driver side fixed asap.

WHILE DRIVING CAR MAKES SEVERE ROARING/ HUMMING NOISE. ALSO WHILE DRIVING MAKING TURNS OR NOT MAKING TURNS THE CAR JERKS UNCONTROLLABLY. MY DOOR SENSOR WILL NOT RECOGNIZE WHETHER OR NOT MY FRONT DRIVER DOOR IS CLOSED, SO WHILE I'M DRIVING DOWN THE ROAD IT SAYS MY DRIVER DOOR IS OPEN. THERE IS A RECALL THAT I WAS NEVER NOTIFIED ABOUT ON THE SUSPENSION; FRONT HUB,. I'VE CONTACTED MY LOCAL PRATER FORD & FORD MOTOR COMPANY WITH NO HELP. I HAVE THE WORK ORDER # FROM PRATER FORD WHERE WE TRIED TO RESOLVE THIS PROBLEM, IT IS WORK ORDER # 80025 ON MARCH 12, 2018. THEIR NUMBER IS 706-629-2883 ASK TO SPEAK TO ASHLEY P.; SERVICE PROVIDER.

TL* THE CONTACT OWNS A 2008 FORD EDGE. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE VIBRATED ABNORMALLY. THE CONTACT STATED THAT THE FAILURE WAS MORE EVIDENT WHILE SLOWING THE VEHICLE TO A STOP. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. NEITHER A DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 138,000.

I HAD THE LIFT GATE OPEN LOADING GROCERIES AND IT ALL OF A SUDDEN RELEASED AND CAME DOWN AND STRIKING MY HEAD AND NECK AND I QUICKLY PUSHED IT BACK UP AND IT JUST DROPPED DOWN AGAIN BEFORE I COULD GET MYSELF CLEAR STRIKING ME AGAIN, IT GOT MY NECK AND SHOULDER. I TOOK IT TO DEALERSHIP AND WAS FIRST WAS TOLD IT WAS A PROBLEM FOR THE BODY SHOP, BUT THEY QUICKLY DETERMINED IT WAS AN ELECTRICAL PROBLEM. THE LIFT GATE IS VERY HEAVY AND I DO HAVE TO SEE A DOCTOR FOR THE PERSISTENT PAIN IN THE NECK AND SHOULDER. THE VEHICLE WAS STATIONARY IN THE PARKING LOT OF THE GROCERY STORE.THERE WASN'T A VEHICLE ACCIDENT BUT I DID RECEIVE AN INJURY TO MY NECK AND SHOULDER, EXTENT TO BE DETERMINED.*DT CONSUMER STATED WHEN DRIVING VEHICLE STARTS TO SHAKE. VEHICLE WAS TAKEN TO THE DEALER, PCM MELTED TWO IGNITON COILS AND NEW COMPUTER REPLACED.*JB

WELL THIS IS BEEN RECALLED. ON OTHER 2008 FORD. EDGE BUT I THINK MY 2008 FORD EDGE SHOULD BE IN THAT RECALL I RECENTLY BOUGHT MY EDGE FROM A USED DEALER ALL THE SAFETY ISSUES AND RECALLS MY FORD EDGE HAS MY HAS ALL OF THE ISSUES MY FORD EDGE WENT IN FOR TIRE ROTATION AND OIL CHANGE WHEN THEY RETURNED MY CAR I LEFT THE SHOP AND THEN REALIZED THE FRONT TIRE IS VIBRATING WHEN DRIVEN SLOWLY AND TURNS I CALLED FORD TO ASK IF MY CAR WAS ONE OF THE ONES ON THE RECALL LIST FOR BEARING RECALL AND THE SAID NO I KNOW THIS WAS NOT AN ISSUE TILL NOW AND IM AFRAID TO DRIVE MY CAR DUE TO THIS RECALL I FEEL MY CAR SHOULD BE INCLUDED ALSO OF COURSE THE TRANNY IS DEFINITELY NOT WORKING CORRECTLY WHEN ALSO DRIVING SLOWLY IT JERKS TERRIBLY IN TO ANOTHER GEAR. SERVAL TIMES I HAVE AVOIDED CAR ACCIDENTS BY HAVING TO BRAKE ABRUPTLY CAUSE THE CAR TO GET STUCK IN THAT GEAR AND ME HAVING TO SUDDENLY FORCING THE CAR TO PULL OVER TO SIDE OF BUSY 5 O CLCK TRAFFIC AND TURN OFF CAR AND RESTART IT TO ENGAGE THE GEARS TO THE NEXT ONE I HAVE BACKED INTO MY FENCE DO TO THIS SUDDEN JERKING WITHOUT WARNING AND HAVE DAMAGED MY BACK BUMPER DUE TO THIS ISSUE AND THAT MY CAR IS NOT BEEN RECALL DUE TO THESE ISSUES. FIRST TIME I BUY AMERICAN AND FIRST-TIME I HATE MY CAR NOW IM STUCK MAKING PAYMENT ON A CAR THAT HAS SO MANY ISSUES AND UN ABLE TO DRIVE SAFELY I MAKING PAYMENT FOR THE NEXT 17 MONTHS FOR A CAR I CANT DRIVE AND I WILL NEVER BUY AMERICAN AGAIN ALSO THE BRAKES A GRINDING AND SQUEELING AND SINCE I HAVE ABS BRAKES SYSTEM SHOULDNT THE WARNING LIGHT BE WARNING ME BEFORE THEY ACTUALLY START SOUNDING LIKE GRINDING TO PIECES OF METAL TOGETHER I FEEL MY CAR SHOULD BE ONE OF THE ONE THAT SHOULD GET RECALLED FOR ISSUES OTHER CARS HAVE BEEN RECALLED FOR THE SAME ISSUES AND THIS STARTED SINCE 6/16 /2018 AND HAS BEEN EVERYDAY SINCE AND IM ALSO STILL WAITING TO GET THE AIR BAG RECALL FIXED ITS BEEN OVER A YEAR

WHILE DRIVING ON A CITY STREET AT APPROXIMATELY 30MPH, WE DROVE OVER A STANDARD MANHOLE COVER AND THERE WAS AN IMMEDIATE BANGING NOISE ABOVE THE FRONT DRIVER'S SIDE WHEEL AND THE SECTION OF THE HOOD CLOSEST TO THE WINDSHIELD WAS PUSHED UP ABOUT 6 INCHES. WE PULLED OVER AND COULD SEE THE STRUT PRESSING UP AGAINST THE HOOD. THE VEHICLE WAS TOWED TO A MECHANIC SHOP WHERE WE LEARNED THAT THE ENTIRE STRUT TOWER HAD BROKEN THROUGH THE STRUT SUPPORT DUE TO A CATASTROPHIC FAILURE OF THE SPOT WELDS THAT WERE CONNECTING THE UPPER STRUT MOUNT CAP TO THE VEHICLE BODY. THE TOW TRUCK DRIVER NOR THE MECHANIC HAD EVER SEEN THIS KIND OF STRUCTURAL FAILURE. WE ARE GRATEFUL THAT WE WERE NOT ON THE HIGHWAY WHEN THIS INCIDENT OCCURRED, AND WE ARE EAGER FOR THE ISSUE TO BE LOOKED INTO FURTHER TO DETERMINE IF THIS IS A STRUCTURAL DEFECT OF THE 2008 FORD EDGE THAT COULD FURTHER AFFECT OUR OR OTHER FAMILIES' VEHICLE SAFETY.

TIRE WEAR

TL* THE CONTACT OWNS A 2008 FORD EDGE. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A LOSS OF ENGINE POWER. THE VEHICLE COULD NOT BE DRIVEN OVER 1,000 RPMS. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT AXLE ON THE PASSENGER SIDE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE COULD NOT BE REPAIRED. PRIOR TO THE FAILURE, THE VEHICLE EXPERIENCED THE SAME FAILURE AND THE FRONT AXLE ON THE PASSENGER SIDE WAS REPLACED. THE TECHNICIAN STATED THAT THE MANUFACTURER WOULD NO LONGER BUILD PARTS FOR THE 2008 FORD EDGE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 86,000.

TL* THE CONTACT OWNS A 2008 FORD EDGE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE WAS MAKING AN ABNORMAL NOISE AND SHAKING VIOLENTLY. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE COIL AND THE POWER TRAIN CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS THEN TOWED TO A DEALER BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATELY FAILURE MILEAGE WAS 87,000.

POPPING NOISE MADE FROM FRONT DRIVER SIDE TIRES WHEN TURNING LEFT, AT GEAR CHANGE TRANSMISSION JERKS, POWERTRAIN AWD MALFUNCTION LIGHT CAME ON , TRUCK WOULD NOT ACCELERATE INTO 2ND GEAR LOUD GRINDING NOISE MADE, CENSOR HAD TO BE REPLACED, POPPING NOISE STILL EXIST IN LEFT FRONT TIRE

HAD BEEN NOTICING LOUD ROARING SOUND FROM RIGHT REAR OF VEHICLE. DROVE FROM OHIO TO FLORIDA (1,000 MILES) & GOT WORSE/LOUDER... TOOK IT TO LOCAL FORD MECHANIC WHO INFORMED KNOWN ISSUE IN THESE CARS IS THE REAR WHEEL HUB ASSEMBLY FAILS, ONCE REPLACED JUST FAILS AGAIN. NOISE IS INCREDIBLY NOTICEABLE AND NOT JUST ANNOYING BUT SCARY TO ME & ANY PASSENGERS. OBVIOUSLY A MANUFACTURER'S DEFECT, TICKED FORD'S NOT COVERING IT. *TR

NOISE COMING FROM THE RIGHT, REAR WHEEL AREA AT VARIOUS SPEEDS. SOUNDS LIKE A LIGHT RUMBLE STRIP SOUND AND A LIGHT SQUEALING/GRINDING ALSO. TOOK IT TO A LOCAL MECHANIC WHO SAYS THE BEARINGS ARE BAD. FORD NEEDS TO DO SOMETHING ABOUT THIS ISSUE. IT'S SEEMS TO BE AN EXISTING PROBLEM ON THESE EDGES AND RECURRING PROBLEMS AS WELL. *TR

VEHICLE ROLLS WHEN PLACED IN PARK, VEHICLE ROLLS BACKWARDS ON INCLINES WHILE VEHICLE IS IN DRIVE, REAR BULB CONSTANTLY BURNS OUT, STRUT AND SUSPENSION FAILED. *TR

TL* THE CONTACT OWNS A 2008 FORD EDGE. THE CONTACT STATED THAT THE PASSENGER'S SIDE REAR WHEEL EXHIBITED A LOUD ROARING NOISE WHILE THE CONTACT WAS DRIVING AT VARIOUS SPEEDS. THE DEALER REPLACED THE REAR WHEEL BEARING TWICE HOWEVER, THE FAILURE WAS NOT CORRECTED. THE WHEEL CONTINUED TO MAKE THE LOUD NOISE WHILE THE CONTACT DROVE AT ANY SPEED. THE APPROXIMATE FAILURE MILEAGE WAS 45,000 AND THE CURRENT MILEAGE WAS 99,374.

WHILE DRIVING MY 2008 FORD EDGE, A ROARING TYPE NOISE COMES FROM THE REAR OF THE UNIT. AS YOU ACCELERATE TO NOISE GROWS IN VOLUME. AT FIRST IT APPEARED TO ME AS "ROAD NOISE" I CHANGED PRESSURES IN THE TIRES AND ROTATED THE FRONT TO THE REAR. NOTHING CHANGES. AFTER RESEARCHING THE PROBLEM, IT APPEARS THAT IT IS THE REAR WHEEL BEARINGS. ACCORDING TO FORD THE BEARING HUB AND THE REAR SUSPENSION TRAILING ARM/KNUCKLE ASSEMBLY MUST ALSO BE CHANGED ON THE AFFECTED SIDE. THE TRAILING ARM CAUSES TO MUCH PRESSURE ON THE BEARINGS AND WIPES THEM OUT. ALSO THE WHEELS HAVE TO BE RE-ALIGNED DUE TO THE INSTALLATION OF THE NEW TRAILING ARM. FORD STATES THAT JUST CHANGING ONLY THE BEARING HUB WILL CAUSE THE PROBLEM TO HAPPEN AGAIN. IF THE BEARING FAILS THIS COULD CAUSE A SERIOUS ACCIDENT WITH THE POTENTIAL OF SERIOUS INJURY OR WORSE TO THE OCCUPANTS OF THIS VEHICLE AND ANYONE ELSE AS A RESULT OF THIS FAILURE.THIS APPEARS TO BE A POSSIBLE PROBLEM WITH THE DESIGN OF THE SUSPENSION SYSTEM AND NOT NORMAL WEAR AND TEAR. I PURCHASED THIS VEHICLE USED IN LATE NOVEMBER 2012. AS I DROVE IT LONGER THE NOISE IN THE REAR HAS GOTTEN LOUDER AND LOUDER. *TR

REAR WHEEL BEARING FAILURE, HAVE TO REPLACE BEARING AND TRAILING ARM. *TR

2008 FORD EDGE, RIGHT REAR SUSPENSION SYSTEM, NEEDS REAR CONTROLLING ARM AND WHEEL BEARING REPLACED. NOISE FROM REAR RIGHT OF VEHICLE NOTED. HAD TIRES CHECKED (REFERENCING TREAD), ROTATED, AND BALANCED. THE BUSINESS NOTED THE WHEEL BEARING MALFUNCTION/ISSUE AND ADVISE TO TAKE TO FORD. CONTACTED LOCAL FORD DEALERSHIP. PER PHONE CALL, WAS ADVISED THIS HAD BEEN OCCURRING ON SEVERAL EDGE VEHICLES. ONCE TAKEN TO SHOP, CONFIRMED AND ADVISED BOTH THE WHEEL BEARING AND THE CONTROLLING ARM MUST BE REPLACED AS ONE. ADVISED BACK ORDER FOR CONTROLLING ARM, BUT NOT INFORMATION AVAILABLE ON HOW LONG IT WOULD TAKE TO RECEIVE. ASKED FORD IF SAFE TO DRIVE AND WAS ADVISE "YES, IT IS SAFE TO DRIVE; IT JUST MAY BE MORE NOTICEABLE/MAKE MORE NOISE". INCIDENT DATE IS LISTED AS THE DATE TAKEN TO TIRE SHOP. NOISE SEEM TO APPEAR APPROXIMATELY 1 TO 1/2 MONTHS AGO. *CW