2010 Chevrolet Malibu Body & Structure Problems

I WAS GOING TO WORK , WHEN I ARRIVED AT WORK MY DRIVER FRONT DOOR WAS STUCK SHUT IT WOULD NOT OPEN FROM INSIDE OR OUTSIDE . I HAD TO CRAWL OVER CONSOLE TO GET OUT OF CAR THRU PASSENGER SIDE, AND NOW I HAVE TO GET IN IT TO DRIVE IT FROM PASSENGER SIDE.

FRONT PASSENGER SIDE DOOR WON'T OPEN. THE DOOR WILL NOT OPEN USING EITHER THE INTERIOR OR EXTERIOR DOOR HANDLES. THIS HAS HAPPENED BEFORE AND I CAN USUALLY GET IT WORKING BY OPENING THE DOOR WINDOW AND MANUALLY LOCKING AND UNLOCKING THE DOOR WHILE SIMULTANEOUSLY PULLING AND RELEASING THE EXTERIOR DOOR HANDLE. SOMEHOW THIS REESTABLISHES THE ELECTRICAL CONNECTION AND IT WILL OPEN. IT IS A SAFETY HAZARD.

FRONT DOOR LOCKS MECHANISM SEIZES PREVENTING THEM FROM OPENING EITHER FROM INSIDE OR OUTSIDE. IN CASE OF AN ACCIDENT, OCCUPANTS WILL BE TRAPPED. I HAD TO CHANGE BOTH FRONT DOORS AT 5 YEARS OF LIFE AND THEN AGAIN AT 8 (DRIVERS). BOTH TIMES ORIGINAL OEM PARTS. INVOICES ARE AVAILABLE UPON REQUEST.

DRIVER SIDE FRONT DOOR FAILED TO OPEN BACK IN AUGUST 2015, FRONT PASSENGER SIDE DOOR WILL NOW NOT OPEN AS OF 5/30/19. SO AS OF RIGHT NOW, NEITHER FRONT DOOR WILL OPEN. PULLED INTO A PARKING GARAGE AND TRIED EXITING THRU THE PASSENGER SIDE ( LIKE I HAVE THE LAST 3+ YEARS) AND DOOR WOULD NOT OPEN. HAD TO CLIMB OUT THRU THE BACKSEAT.

DOOR LOCKS DON'T UNLOCK THE DOORS TRAPPING OCCUPANTS INSIDE THE CAR. MANUAL OR ELECTRICAL DON'T WORK. MODULES ARE DEFECTIVE, AND MANUAL LOCK PULL DOES NOT WORK EITHER. VEHICLE COULD BE RUNNING OR NOT RUNNING-STILL DOES NOT WORK. IF YOU ROLL DOWN THE WINDOW AND TRY THE OUTSIDE HANDLE, STILL DOES NOT WORK. SOLENOID, IN THE DOORS MAKE A SOUND LIKE THE DOORS UNLOCK, BUT THEY DON'T. MAYBE ONE IN THE BACK WILL WORK, BUT VERY DIFFICULT TO GET OUT OF THE CAR. YOUR STUCK WITH NO OPTIONS TO GET OUT. THIS IS A VERY SEVER SAFTY ISSUE AND NEEDS TO BE ADDRESS. TRIED TO BUT THE CAR IN DRIVE, AND BACK INTO PARK AND TURN OFF THE CAR MULTIPLE TIMES WITH NO LUCK. TRIED TO ROCK THE DOOR LOCK SWITCH DOES NOT HELP. BELIEVE THE MODULES ARE DEFECTIVE. DOOR PULLS FOR UNLOCKING THE DOORS SHOULD STILL WORK, EVEN IF THE POWER WAS LOST. THEY DO NOT. TRIED WHILE THE VEHICLE WAS MOVING AND STATIONARY. BECAUSE I WAS STUCK IN THE CAR, I WENT AROUND THE BLOCK WONDERING IF IT WAS A CHARGING PROBLEM. IT'S NOT, AFTER GOING AROUND THE BLOCK AND PULLING BACK INTO THE DRIVE WAY, THEY STILL DID NOT WORK. WHEN CAR WAS TURNED OFF AND TRIED TO UNLOCK THE DOORS STILL DID NOT WORK. HAD TO CHECK THE BACK DOOR AND FOUND IT FINALLY WORKED. HAD TO CRAWL OVER THE FRONT SEAT AND CRAWLED OUT THAT WAY. WAS STUCK IN THE CAR FOR 25 MIN. COULD NOT DO ANYTHING.

AT RANDOM OCCASIONS, THE FRONT DOOR LATCHES WILL NOT WORK. LAST NOVEMBER, THE FRONT PASSENGER DOOR DID NOT OPEN EVEN AFTER ATTEMPTING TO OPEN IT MANUALLY AND USING THE POWER DOOR LOCK SWITCH. THIS MORNING, I HAD TWO ISSUES WITH THE DRIVER DOOR. FIRST, IT WOULD NOT SHUT UNTIL AFTER I USED THE BUTTON TO MANUALLY LOCK THE DOOR ("USED" MEANING I PULLED IT UP AND PUSHED IT DOWN SEVERAL TIMES IN QUICK SUCCESSION). THEN, AFTER I PARKED MY CAR, THE DRIVER DOOR WOULD NOT OPEN UNTIL AFTER PUSHING THE BUTTON UP AND DOWN SEVERAL TIMES, USING THE REMOTE A COUPLE TIMES, ROLLING THE WINDOW UP AND DOWN, AND PUSHING THE BUTTON UP AND DOWN AGAIN. I WONDER IF HUMIDITY AND/OR MOISTURE MAY BE AFFECTING THE DOORS' ABILITY TO FUNCTION, AS IT HAD RAINED AND/OR SNOWED ON BOTH OCCASIONS; HOWEVER, THE WEATHER HAS NOT AFFECTED THE DOORS ON OTHER CARS I HAVE USED TO SUCH AN EXTENT. THE ISSUE WITH DOORS NOT OPENING/SHUTTING AS EXPECTED HAS BEEN DOCUMENTED BY OTHER 2008-12 MALIBU OWNERS ON VARIOUS WEBSITES AND SHOULD BE INVESTIGATED IMMEDIATELY.

DRIVER SIDE DOOR AT TIMES FAILED TO OPEN FROM EITHER OUTSIDE OR INSIDE. KEYFOB REMOTE PROPERLY LIFTS AND LOWERS THE LOCK KNOB LIFTER TO LOCK OR UNLOCK POSITION. MINUTES, HOURS AND ONE TIME, TWO DAYS WOULD GO BY THEN THE DOOR WOULD EVENTUALLY UNLOCKS TO OPEN. SAME FOR THE DRIVER SIDE REAR DOOR HOWEVER, I HAVE NOT BEEN ABLE TO OPEN THE DOOR SINCE 2015. ALSO, THERE ARE TIMES WHEN THE DRIVER DOOR WILL NOT CLOSE UNLESS I SLAM THE DOOR SHUT. I HAVE TRIED TO MAKE PROGRAMMING CHANGES ON THE DOOR LOCKING FEATURES THROUGH THE ON BOARD COMPUTER AND MOVING TRANS SHIFTIER TO DIFFERENT POSITIONS. NO SUCCESS. I HAVE CONTACTED THE MANUFACTURE TWICE (2015 & 2016) AND BOTH TIME WAS TOLD BY CHEVROLET THEY WILL NOT COVER SINCE OUT OF WARRANTY DUE TO THE MILES ON MY 2010 CHEVY MALIBU. FOR ME BEING A OVER WEIGHT OLDER INDIVIDUAL ITS DIFFICULT TO EXIT AND ENTER FROM THE PASSENGER DOOR. SOMEONE ELDERLY IT WOULD MOST CERTAINLY BE IMPOSSIBLE.

IT IS A 2010 MALIBU LS. YESTERDAY WHEN I WAS CLOSING THE DRIVER SIDE DOOR, IT WOULD NOT CLOSE ALL THE WAY FROM THE OUTSIDE. I LOOKED AT THE CATCH AND THE AREA MIDWAY ON THE DOOR TO SEE IF ANYTHING WAS CAUGHT IN IT OR LOOKED LIKE IT WAS MISSING. I DIDNT SEE ANYTHING. I GOT IN AND SHUT THE DOOR AND IT CLOSED, BUT WHEN I TRIED TO OPEN IT IT WOULD NOT OPEN. I TRIED PUSHING THE POWER LOCK BUTTON INSIDE A FEW TIMES LOCKING AND UNLOCKING AND IT STILL DOES NOT OPEN. WHEN YOU PULL THE LTACH ON THE INSIDE IT FEELS LIKE IT IS NOT CATCHING ANYTHING. I TRIED JUST USING THE KEY ON THE OUTSIDE AND THE HANDLE ON THE OUTSIDE SEEMS LIKE IT IS NOT CATCHING ANYTHING. THE LOCKS STILL GO UP AND DOWN, WITH AND WITHOUT USING THE REMOTE. ALSO I NOTICED THAT THE RADIO STAYS ON WITH THE DOORS CLOSED AND NO KEY IN THE IGNITION. THE PASSANGER SIDE AND REAR DOORS WORK FINE.

TL* THE CONTACT OWNS A 2010 CHEVROLET MALIBU. WHILE THE VEHICLE WAS PARKED, THE DRIVER SIDE DOOR WOULD NOT UNLOCK. THE FAILURE OCCURRED WHILE PUSHING THE LOCK/UNLOCK BUTTON INSIDE OF THE VEHICLE OR WHILE INSERTING THE KEY IN THE DOOR LOCK. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 67,000. THE VIN WAS NOT PROVIDED.

"TAKATA RECALL": THE DOOR LOCK DOES NOT WORK AT TIMES. THE DOOR WILL NOT SHUT AS WELL AS THE DOOR'S LOCK ASSEMBLY NOT DISENGAGING. THE LOCKING ASSEMBLY WILL EITHER NOT UNLOCK OR WILL NOT ALLOW THE DOOR TO STAY LATCHED. IT HAPPENS WITHOUT WARNING WHEN MOVING, STATIONARY, DRIVING ON ANY TYPE OF ROAD OR PARKING AREA. WE HAD DAVIDSON CHEVROLET IN WATERTOWN, NEW YORK ON MARCH 7, 2016 FOR A SEAT BELT PROBLEM AND HAD THE DOOR LOOKED AT THAT DAY. WE WERE INFORMED IT WOULD COST OVER $500.00 TO REPLACE THE PART. THIS IS VERY DANGEROUS AND I HAVE ALMOST FALLEN OUT OF CAR WHILE DRIVING WHEN THIS HAS HAPPENED. THE CAR WAS NOT IN AN ACCIDENT AND NOTHING CAUSED THIS TO HAPPEN. THE LAST DATE THIS HAPPENED WAS 10-27-2016. THE FIRST IT HAPPENED WAS LAST YEAR. *TR

DRIVER DOOR WON'T OPEN. RIGHT BEFORE IT WOULDN'T OPEN, THE DOOR WOULDN'T CLOSE. IT WOULD JUST BOUNCE OPEN. GOT THE DOOR TO FINALLY CLOSE AND NOW IT WON'T OPEN. TRIED UNLOCKING AND LOCKING IT AND NOTHING. SEEN LOTS OF PEOPLE COMPLAINING AND HAVING THIS SAME ISSUE WITH THEIR MALIBUS. *TR

THE DRIVERS SIDE DOOR WILL RANDOMLY STAY LOCKED EVEN WHEN ITS NOT LOCKED. THIS IS A SAFTEY HAZARD. YOU CANNOT OPEN THE DOOR FROM THE INSIDE OR OUTSIDE. THERE IS A PROBLEM WITH THE LOCK ACTUATOR.

CHROME PAINT ON INTERIOR HANDLERS IS PEELING CAUSING CUTS/LACERATIONS ON PEOPLE'S HANDS.

DRIVER DOOR HANDLES INCONSISTENTLY WORK. ONE DAY THEY WILL BE FINE, THE NEXT NEITHER INSIDE OR OUTSIDE HANDLES WORK. THE MECHANISM FOR THE DOOR LOCK APPEARS TO BE WORKING FINE.

DOOR LOCKING MECHANISM IN THE DRIVERS DOOR HAS BEEN FAILING, POWER DOOR LOCK ON DRIVERS DOOR FAILS QUITE OFTEN. WHEN THIS HAPPENS THE DRIVER CAN NOT OPEN THE DRIVERS DOOR EITHER WITH THE POWER UNLOCK OR MANUALLY WITH THE DOOR LOCK IN THE UP POSITION OR FROM THE INSIDE OR OUTSIDE OF THE DRIVERS DOOR WITH THE DOOR HANDLE. IT IS LIKE THE DOOR MECHANISM IS DISABLED. DOES NOT MATTER IF THE CAR IS IN MOTION OR NOT HAPPENS WHEN PARKED OR THE CAR HAS JUST COME TO A STOP. THE DRIVER MUST CRAWL OVER THE CENTER DIVIDER AND OUT THE PASSENGER SIDE TO EXIT OR BACK OVER TO DRIVE THE CAR. HAVE AN APPOINTMENT TO GET IT REPAIRED FOR $350 AT THE CHEVROLET DEALER ON NOVEMBER 11TH BUT THINK THIS SHOULD BE COVERED BY GM AS I HAVE READ THIS IS A COMMON PROBLEM WITH 2008 TO 2010 MALIBU CARS AND CERTAINLY IS A SAFETY ISSUE BEING TRAPPED IN THE CAR.

I WENT TO OPEN MY FRONT, DRIVER'S SIDE DOOR (FROM THE OUTSIDE) AND IT WOULD NOT OPEN. I CLIMBED THROUGH THE PASSENGER FRONT AND TRIED TO OPEN THE DRIVER'S DOOR FROM THE INSIDE...IT STILL WOULD NOT OPEN. USING THE PALM OF MY HAND, I BUMPED THE EFFECTED DOOR ON THE OUTSIDE DOOR PANEL, BY THE HANDLE AND IT OPENED. I LUBED THE INSIDE DOOR CATCH AREA AS MUCH AS I COULD AND IT SEEMED OK. 48 HOURS LATER, I WAS HAVING THE SAME PROBLEM. ADDITIONALLY, THERE HAVE BEEN A FEW TIMES DURING THIS TIME FRAME WHERE I WENT TO CLOSE THE DOOR AND IT BOUNCED BACK OPEN AGAIN. IT SEEMS THAT THE DOOR LATCH NEVER CAUGHT THE POST ON THE FRAME. THIS IS CLEARLY A SAFETY ISSUE. AN ELDERLY OR DISABLED DRIVER MAY NOT BE ABLE TO GET OUT IN THE CASE OF AN EMERGENCY. NOT EVERYONE IS PHYSICALLY CAPABLE OF FOLDING THEMSELVES UP AND CLIMBING OVER THE ARMREST INTO THE PASSENGER SEAT. ALSO, IT STANDS TO REASON THAT IF THE DOOR MAY NOT LATCH SHUT, IT MAY OPEN WHILE DRIVING DOWN THE ROAD.

WHEN EXITING THE VEHICLE FROM THE FRONT PASSENGER SIDE, THE DOOR WOULD NOT CLOSE. AFTER SHUTTING IT SEVERAL TIMES WITHOUT IT LATCHING, IT FINALLY STAYED SHUT. I HAVE NOW BEEN UNABLE TO OPEN THE DOOR SINCE. THE DOOR STILL WILL NOT OPEN. APPROXIMATELY 2 WEEKS AGO, THE DRIVER SIDE DOOR DID THE SAME THING, AND I WAS UNABLE TO EXIT THE VEHICLE THROUGH THE DOOR. I HAD TO CRAWL TO THE BACK SEAT TO GET OUT OF THE VEHICLE. THE DRIVER SIDE DOOR OPENS NOW, BUT STILL DOESN'T SHUT PROPERLY AT LEAST 2 TIMES A WEEK

TL* THE CONTACT OWNS A 2010 CHEVROLET MALIBU. THE CONTACT STATED THAT THE CHROME PLATING ON ALL THE INTERIOR DOOR HANDLES WAS PEELING AND CAUSED THE CONTACT TO SUSTAIN MINOR CUTS ON THE HAND. THE CONTACT MENTIONED THAT MEDICAL ATTENTION WAS NOT REQUIRED. THE CONTACT ALSO STATED THAT THE ESN WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER ON FOUR OCCASIONS WHERE IT WAS DIAGNOSED THAT AN UNKNOWN PART NEEDED TO BE CLEANED. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSISTED. IN ADDITION, THE CONTACT STATED THAT THE BRAKE LIGHT ILLUMINATED WITHOUT THE BRAKE PEDAL BEING DEPRESSED. THE CONTACT ALSO STATED THAT WHEN THE BRAKE PEDAL WAS DEPRESSED THE BRAKE LIGHT FAILED TO ILLUMINATE. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL) BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 106,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2010 CHEVROLET MALIBU. THE CONTACT STATED THAT IT TOOK SEVERAL ATTEMPTS TO UNLOCK THE FRONT INTERIOR PASSENGER DOOR. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

TL* THE CONTACT OWNS A 2010 CHEVROLET MALIBU. THE CONTACT STATED THAT THE DOORS WOULD NOT UNLOCK. THE DRIVER SIDE DOOR LOCK SPORADICALLY WORKED ONLY WHEN THE VEHICLE WAS SHIFTED INTO DRIVE AND BACK INTO PARK VARIOUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THE FAILURE AS MOLDING IN THE DOOR FRAME. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

ON THREE SEPARATE OCCASIONS SINCE THE 2ND WEEK IN APRIL I TRIED TO OPEN MY CAR DOOR USING MY KEY AS I TURNED, ALTHOUGH T2/15HE LOCK LOCKS AND UNLOCKS, THE DOOR WOULD NOT CLOSE. I TOOK IT TO A MECHANIC AND THEY TRIED FOR ABOUT 20 MINUTES TO CLOSE THE DOOR AND IT JUST BOUNCED BACK OPEN. I TOOK IT TO A CHEVROLET SERVICE CENTER HERE IN PA AT WHICH TIME THE DOOR LATCH CONNECTED WITH NO SIGNS OF AN ISSUE. THE SERVICE TECH LOOKED AND THE LATCH AND SAID TO ME, "IF IT HAPPENS AGAIN, JUST LIFT UP THE LATCH AND THERE SHOULD BE NO PROBLEM. YESTERDAY, I GO TO LUNCH, OPEN THE DOOR WITH THE KEY AND EVERYTHING WAS FINE. I GO TO GET OUT OF THE CAR AND THE DOOR WOULD NOT OPEN. I TRIED FOR ABOUT 1/2 HOUR. I ASKED A TECHNICIAN FROM MY JOB TO SEE IF HE CAN OPEN THE DOOR TO LET ME OUT AND IT DID NOT OPEN, I HAD TO CLIMB OUT OF THE PASSENGER SIDE DOOR AND LEAVE ALL LOCKS SO I COULD GET IN THROUGH PASSENGERS SIDE TO GO BACK HOME. APPOINTMENT SCHEDULED WITH MECHANIC ON 4/22/15. TWO WEEKS AGO MY ENGINE LIGHT HAS BEEN GOING OFF AND ON. I'VE HAD OIL AND OTHER THINGS CHECKED TO NO AVAIL.

OUR CHEVY MALIBU WAS BROAD SIDED ON THE RIDERS SIDE AT 10:10 AM ON THE FORTH OF APRIL, 2015. THIS WAS AT A YIELD INTERSECTION IN AIKEN, SC. I HAVE HAD SEVERAL NEAR MISSES WITH THIS CAR WITH VEHICLES COMING FROM THE LEFT. THIS ACCICENT WAS CLEARLY MY FAULT. HOWEVER, A CONTRIBUTING FACTOR IS THE WIDTH OF THE POST BETWEEN THE WINDSHIELD AND THE DOOR ON THAT SIDE OF THE CAR. WE OWN A 2005 SIMILAR MALIBU AND THE WIDTH OF THAT POST IS MUCH NARROWER AND WE HAVE NEVER HAD A PROBLEM SEEING VEHICLES COMING AT US FROM THE LEFT SIDE. HOWEVER, THE 2010 MALIBU HAS A MUCH WIDER POST BETWEEN THE WINDSHIELD AND THE DOOR AND IS SUFFICIENT TO HIDE VEHICLES COMING FROM THE LEFT. MY WIFE HAS HAD THE SAME PROBLEM WITH THIS VEHICLE. IT IS A DESIGN SAFETY FACTOR THAT SHOULD BE CORRECTED BY THE GENERAL MOTORS ENGINEERS. . I WOULD IMAGINE THAT THERE HAVE BEEN MANY MORE SIMILAR ACCIDENT WITH OTHER DRIVERS OF THIS MAKE AND MODEL OF CAR. HOWEVER I DO NOT HAVE ACCESS TO YOUR DATA BASE TO CONFIRM SAME. OUR CAR WAS STILL ABLE TO BE DRIVEN AFTER THE COLLISION AND IS CURRENTLY IN A BODY SHOP BEING REPAIRED. HOWEVER, I AM NOT GOING TO BE COMFORTABLE DRIVING IT KNOWING THAT THIS HAZORDOUS CONDITION STILL EXISTS. THOUGHT I SHOULD PASS THIS INFORMATION ALONG TO YOUR AGENCY IN CASE OTHERS HAVE COMPLAINED OF THE SAME CONDITION AND YOU MIGHT BE ABLE TO CONVINCE GM THAT THEY HAVE CREATED A SAFETY PROBLEM WITH THE DESIGN OF THIS VEHICLE. THE WIDTH OF THIS COLUMN ON THE 2005 MALIBU IS 4 INCHES. THE WIDTH OF THE COLUMN ON THE 2010 MALIBU HAS TO ABE A GOOD SIX INCHES OR MORE SUFFICIENT TO BLOCK THE VIEW FROM THE DRIVERS SEET OF ONCOMING VEHICLES FROM THE LEFT. THANKS FOR YOU CONSIDERATION IN THIS MATTER. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

DRIVERS DOOR FAILED TO OPEN AT TIMES. DRIVERS DOOR OPENED WHILE DRIVING. *TR

DEC 16. I HAVE BEEN HAVING ISSUES OPENING AND CLOSING MY DRIVER SIDE DOOR. THE LATCH WON'T HOOK CORRECTLY. I HAVE THE DOOR CLOSE, BECAUSE IF I OPEN IT WON'T CLOSE. IT'S DIFFICULT TO OPEN FROM THE INSIDE AND OUT SIDE. RIGHT NOW I HAVE TO CLIMB OVER TO THE PASSENGER SIDE TO BE ABLE TO GET OUT OF MY CAR. APPARENTLY THIS IS A COMMON PROBLEM WITH MY MAKE AND MODULE OF CAR. ITS DEFINITELY A HAZARD. *TR

THE PAINT ON THE HOOD IS COMING OFF AND FADING OUT BAD. *TR

WATER LEAKS INSIDE THE CAR WHEN IT RAINS OUTSIDE OR WHEN I GO THROUGH A CAR WASH. THE ISSUE WASN'T DETECTED AT THE TIME OF PURCHASE HOWEVER IT WAS NOTICED SEVERAL MONTHS LATER DURING A PERIOD OF FREQUENT AND HEAVY RAIN. THE ISSUE BEGAN WITH WATER DRIPPING ONLY NEAR THE BRAKE PEDAL, HOWEVER OVER TIME THE ISSUE HAS SPREAD TO AN AREA BETWEEN THE DRIVER'S DOOR AND FRONT WINDSHIELD. WATER NOW LEAKS FROM BOTH AREAS WHEN IT RAINS AND/OR WHEN I DRIVE THROUGH A CAR WASH. IF I PARK ON AN INCLINE, SOMETIMES THE WATER WILL DRAIN FROM THE CAR. ALSO, THE WATER HAS STAINED MY INTERIOR, LEAVES A MOLDY SMELL AND OVER TIME I WILL ASSUME THAT THE ISSUE WILL SPREAD EVEN FURTHER OR MAY DAMAGE THE INTERIOR ROOF. BECAUSE WATER LEAKS FROM ABOVE, IT SOAKS ALL OF THE BUTTONS ON THE DOOR (WINDOWS, LOCKS, ETC) AS WELL AS THE BUTTON TO HEAT THE SEAT - HOPEFULLY THAT DOES NOT CREATE AN ELECTRICAL ISSUE. *TR

TL * THE CONTACT OWNS A 2010 CHEVROLET MALIBU. THE CONTACT WAS UNABLE TO OPEN THE FRONT DRIVER SIDE DOOR FROM INSIDE THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER, BUT THE CONTACT WAS INFORMED THAT THE COST OF THE REPAIR WOULD BE APPROXIMATELY $200. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 62,000.

UPON ARRIVING AT MY DESTINATION I ATTEMPTED TO EXIT VEHICLE BUT THE DRIVER'S DOOR WOULD NOT OPEN. IT COULD NOT BE OPENED FROM EITHER THE INSIDE OR THE OUTSIDE. TRIED LOCKING AND UNLOCKING THE DOOR FROM THE KEY REMOTE, FROM THE BUTTONS ON THE DOOR AND MANUALLY AND TRIED THE KEY IN THE DOOR BUT NOTHING WOULD ALLOW THE DOOR TO OPEN. ULTIMATELY HAD TO CLIMB OVER THE CONSOLE TO THE PASSENGER SIDE TO EXIT VEHICLE. FORTUNATELY I WAS ABLE TO DO SO, SOME PEOPLE (DUE TO AGE, HEALTH, SIZE, ETC.) WOULD NOT HAVE BEEN ABLE TO. IF I HAD BEEN IN A SITUATION WHERE I NEEDED TO EXIT THE VEHICLE QUICKLY I WOULD NOT HAVE BEEN ABLE TO DO SO AND NO ONE WOULD HAVE BEEN ABLE TO OPEN THE DOOR TO HELP ME. I CONSIDER THIS TO BE A SAFETY ISSUE, ESPECIALLY IF THERE HAD BEEN A FIRE. GM IS AWARE OF THE PROBLEM AS THEY HAVE ISSUED A TSB. A QUICK SEARCH ON THE INTERNET SHOWS THOUSANDS OF REPORTS OF THE SAME PROBLEM FROM OWNERS OF MANY DIFFERENT GM VEHICLES, NOT JUST THE MALIBU, DATING BACK AT LEAST SIX YEARS. I HOPE THERE DOESN'T HAVE TO BE A FATALITY DUE TO THIS BEFORE GM ISSUES A RECALL TO FIX THE PROBLEM. *TR

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

2010 CHEVY MALIBU PASSENGER DOOR WILL NOT OPEN. THE DOOR LOCK IS IN THE UNLOCK POSITION BUT THE DOOR WILL NOT OPEN. I HAVE UNLOCKED THE PASSENGER DOOR FROM THE DOOR UNLOCK BUTTON, THE KEY REMOTE AND THE PHYSICAL KEY. THE LOCK ITSELF GOES UP AND DOWN WHEN THE DOOR LOCK/UNLOCK BUTTON IS PRESSED AND KEY REMOTE BUTTON IS PRESSED, BUT WHEN THE DOOR HANDLE IS PULLED FROM THE INSIDE OR THE OUTSIDE THE DOOR WILL NOT OPEN. *TR

THE FRONT DRIVERS SIDE AND PASSENGER SIDE DOORS WOULD NOT UNLOCK AFTER I PUT THE CAR IN PARK AND TURNED OFF THE ENGINE, STRANDING ME IN THE CAR. I ENDED UP HAVING TO EXIT THE VEHICLE FROM THE REAR DOORS. LATER THAT SAME DAY, THE DRIVERS SIDE DOOR OPENED, BUT THEN IT WOULD NOT SHUT AS THE DOOR LATCH APPEARED TO BE IN THE LOCKED POSITION, AND WOULD NOT ALLOW THE DOOR TO CLOSE. THE CAR IS NOW BEING REPAIRED AT A GM DEALER AT A COST OF CLOSE TO $600, AND SINCE THE WARRANTY HAS EXPIRED, THIS IS AN OUT OF POCKET EXPENSE FOR ME. IT SEEMS THAT OPENING THE DOOR, ESPECIALLY IN THE CASE OF AN EMERGENCY WOULD BE A BASIC OPERATING FUNCTION THAT I SHOULD REASONABLY EXPECT MY CAR TO PERFORM. I WANTED TO REPORT THIS IN CASE THEIR ARE OTHER CHEVROLET MALIBU OWNERS EXPERIENCING THE SAME ISSUE. *TR

DRIVER SIDE DOOR LATCH STUCK IN LOCKED POSITION, I COULD NOT EXIT THE VEHICLE. *TR

THE FRONT/PASSENGER DOOR WILL NOT OPEN FROM THE INSIDE OR OUTSIDE. THE DOOR HANDLES MOVE BUT DO NOT "CATCH" ANYTHING TO OPEN THE DOOR. IF THE PASSENGER NEEDED TO EXIT THE VEHICLE, HE/SHE WOULD HAVE TO CRAWL OUT THE WINDOW. *TR

I PURCHASED THE 2010 MALIBU, USED FROM THE DEALERSHIP- THEY WERE THE OWNERS PREVIOUSLY. I PURCHASED IT IN OCT. 2011 AND HAVE TAKEN IT TO THE DEALERSHIP 8 TIMES IN THE 9 MONTHS OF OWNING IT. ONE TIME THE ENTIRE DRIVER SIDE FLOOR HAD 1+ INCHES OF STANDING WATER IN IT, AFTER A RAIN. THE ESC LIGHT CONTINUED TO COME ON AND OFF- THEY COULDN'T LOCATE ANY ISSUE- THE FIRST 2 TIMES I TOOK IT IN FOR THAT. THE OIL LIFE SENSOR NEVER WENT OFF FOR SERVICE- I WAS AT 10,000 MILES SINCE THE LAST OIL CHANGE. I TOOK IT TO MY REAL MECHANIC TO HAVE FIXED. THE BATTERY WENT TOTALLY DEAD IN IT ONE DAY- THEY SAID IT HAD BAD CELLS IN IT. AND IT WOULD ALSO STALL, AND WHEN GOING ABOUT 40 MPH NOT ACCELERATE, ON INCLINES. THAT'S WHEN THE ESC LIGHT WOULD KICK ON, SOMETIMES, AND THE RPM'S WOULD GO UP AND DOWN, ALL OVER THE PLACE. FINALLY MADE THE DEALERSHIP KEEP IT UNTIL THEY FIGURED OUT SOMETHING- THEY KEPT IT A FEW DAYS, AND CALLED ME NUMEROUS TIMES ASKING ME UNRELATED QUESTIONS- THEY THOUGHT I WAS NUTS, BECAUSE THEY COULDN'T REPRODUCE THE ISSUE. FINALLY- THEY TOLD ME A WIRE IN THE FUEL INJECTION HAD COME LOOSE. MY CAR WAS SO CALLED 'CERTIFIED' BY THE DEALERSHIP- BUT I DON'T THINK THEY DID ANY OF THE TESTS, OR ELSE THEY WOULD HAVE FOUND SOME OF THESE THINGS THEMSELVES. *TR

2010 CHEVY MALIBU ROOF LEAK FROM BAD WELD WATER RAN DOWN HEADLINER AND FLOODED BACK FLOOR BEHIND DRIVE SEAT. WATER WAS ALMOST 1" DEEP. WATER RAN DOWN HEADLINER ACROSS WIRING FOR AIRBAGS, LIGHTS AND SETTLED ALONG FLOOR NEAR THE MAIN BODY WIRING HARNESS. RUST ON SEAT BRACKETS. DEALER PULLED OUT HEADLINER, WINDSHIELD, ALL SEATS AND TRIM. REPLACED CARPET CLEANED AND PAINTED SEAT BRACKETS. CALLED CHEVROLET HQ BUT WOULD DO NOTHING BUT REPLACE CARPET AND EXTEND WARRANTY - UNWILLING TO BUY CAR BACK OR TRADE FOR ANOTHER VEHICLE. HAVING DELAY ISSUES WITH LIGHTS ON DASHBOARD NOW. UNWILLING TO DO ANYTHING REGARDING RESALE VALUE OF VEHICLE, VERY ARROGANT ATTITUDE AND CAVALIER TOWARDS ME AS A CUSTOMER. MORE ROAD NOISE SINCE INTERIOR WAS RIPPED OUT. VEHICLE HAD 15,000 MILES WHEN THIS HAPPENED. STILL HAVE MUSTY ODOR SOMETIMES AFTER CAR HAS SAT FOR A DAY. *TR