2011 Volkswagen Jetta Fuel System Diesel Fuel Propulsion System Problems

WHILE DRIVING ON THE FREEWAY, THE GLOW PLUG LIGHT BEGAN TO FLASH AND A "SERVICE ENGINE NOW" INDICATOR LIT. AT THIS TIME, THE CAR ENTERED LIMP MODE AND POWER WAS GREATLY REDUCED. I DECIDED TO DRIVE STRAIGHT TO THE DEALER TO DROP IT OFF. OVER THE NEXT FEW MINUTES THE CAR PRODUCED LESS AND LESS POWER (A FEELING AKIN TO RUNNING OUT OF GAS, BUT THERE WAS STILL 1/2 TANK OF DIESEL IN THE CAR) UNTIL IT DIED AND WOULD NOT RESTART. NO OTHER WARNINGS, NO OTHER DRIVABILITY CUES, JUST A DEAD CAR ON THE FREEWAY UNABLE TO BE STARTED OR MOVED. THIS COULD HAVE BEEN EXTREMELY DANGEROUS/POSSIBLY FATAL HAD I NOT BEEN LUCKY ENOUGH TO FORCE MY WAY TO THE SHOULDER BEFORE THE CAR COMPLETELY GAVE OUT. SO TO SUM UP - ONE OWNER (PURCHASED NEW) DIESEL JETTA; CAR MAINTAINED BY DEALER AT APPROPRIATE INTERVALS. FUELED AT PRETTY MUCH THE SAME THREE STATIONS FOR MUCH OF ITS LIFE, NEVER HAD A NON-DIESEL PUMP ANYWHERE NEAR IT; DRIVING PERFECTLY ONE MINUTE, FIVE MINUTES LATER, A DEAD CAR. IT HAS BEEN TOWED TO THE DEALER TODAY, FROM THE SYMPTOMS IT SOUNDS LIKE THE NOTORIOUS HIGH PRESSURE FUEL PUMP (HPFP) HAS CATASTROPHICALLY FAILED. *TR

I HAD JUST EXITED THE HIGHWAY, WHEN THE ENGINE DIED AT 35 MPH. THE CAR WOULD NOT RESTART AFTERWARDS. THE DEALER INDICATED THAT THE FUEL SYSTEM WAS CONTAMINATED WITH METAL SHAVINGS. THIS APPEARS TO BE ANOTHER CASE OF FAILURE OF THE HIGH PRESSURE FUEL PUMP WITH THE 2.0 TDI ENGINE. ONLY DIESEL FUEL HAS *EVER* BEEN USED IN THE VEHICLE. AS PER VW'S TSB, THE DEALER TESTED THE FUEL AND INDICATED THAT IT WAS OK. VW COVERED THE REPLACEMENT OF THE ENTIRE FUEL SYSTEM UNDER WARRANTY. OTHERWISE, THIS WOULD HAVE COST APPROXIMATELY $10K. *TR

TDI DIESEL JETTA WITH 30,000 MILES BY ORIGINAL OWNER WAS BEING DRIVEN 35 MPH CITY SECONDARY STREETS, VEHICLE ABRUPTLY LOST POWER. COASTED TO SIDE OF ROAD. POLICE WERE CALLED, THEY ASCERTAINED THAT LOCATION WAS SAFE ENOUGH UNTIL TOW. TOWED TO DEALER. DEALER SAID FUEL PUMP HAD FAILED. VEHICLE HAD BEEN TO DEALER A FEW DAYS BEFORE FOR 30,000 MILE SERVICE. DIESEL FUEL ALMOST ALWAYS PURCHASED AT SAME 3 YR OLD BUSY STATION, AND CAR WAS RUNNING ON SAME TANK OF FUEL AS WHEN IT WAS SERVICED. THERE WAS NO WARNING OF PROBLEMS, NO HESITATION, NO LOSS OF POWER, NO WARNING LIGHTS BEFORE TOTAL SHUTDOWN OF ENGINE. ON A FREEWAY, THIS COULD HAVE BEEN VERY DANGEROUS. *TR

JETTA TDI HIGH-PRESSURE FUEL PUMP & FUEL LINE BLOW-OUT; STALLING OF ENGINE. *TR

2011 JETTA TDI DIESEL - SECOND OCCURRENCE OF ENGINE STALL DUE TO HIGH PRESSURE FUEL PUMP (HPFP) FAILURE WHILE DRIVING AT 40 PLUS MILES PER HOUR. CAR STALLED AND WOULD NOT RESTART AND HAD TO BE TOWED TO DEALER. THIS IS THE SECOND TIME THAT THIS CAR HAS BEEN TOWED DUE TO A DEFECTIVE DESIGN WHICH RESULTS IN THE HIGH PRESSURE PUMP FAILING SENDING DEBRIS THROUGHOUT THE SYSTEM. NHTSA SAYS IN CONCLUDING STATEMENTS DATED 12/21/12 THAT (NHTSA RECALL NO. 11V-490) 'THE ACTION TAKEN BY VOLKSWAGEN IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION. I CAN ASSURE YOU THAT THE DEFECT REMAINS AND IS POTENTIALLY A SERIOUS SAFETY ISSUES AS THE CAR SUDDENLY STALLS WHILE IN MOTION. AS THIS IS THE SECOND REPLACEMENT OF THE FUEL SYSTEM THE DEFECT REMAINS A PROBLEM AND THE CONSUMER IS EXPOSED TO NOT ONLY SAFETY ISSUES BUT HIGH COSTS IN REPAIR AT $10,000+ IF THE CAR IS NOT UNDER WARRANTY. THE TREND IS CONTINUING WITH 2012 TDIS AS WELL. PLEASE FORCE VW TO ADDRESS THIS ISSUE AS I NOW HAVE AN UNSAFE CAR. *TR