2011 Volkswagen Jetta Fuel System Problems

I HAVE BEEN GETTING HORRIBLE GAS MILAGE (250 PER TANK). THIS HAS BEEN FOR OVER A YEAR NOW OF TRYING DIFFERENT THINGS (DRIVING, FUELING, REPAIRS, ECT.).

TWICE THE CAR JUST STALLS. ON THE ROAD OR IN A INTERSECTION. CAR WAS IN MOTION, ON STREET, AND JUST KILLED, MOTOR SHUT OFF! CHECKING SEVERAL FORUMS THERE HAS BEEN MULTIPLE REPORTS OF DIESELS PRIOR TO 2013 WHERE THE HIGH PRESSURE FUEL PUMP GOES OUT. LUCKLY I DID NOT GET HIT BY ANOTHER CAR.

WHEN DRIVING CAR THE ENGINE WILL STALL AND LOCK UP THE POWER STEERING. IT MAY HAPPEN 3-4 TIMES WITHIN IN 3 MILE DISTANCE. IT HAS BEEN TAKEN TO TWO DIFFERENT AUTO REPAIR SHOPS ONE OF WHICH DEALS ONLY WITH GERMAN MOTORS. THE PROBLEM CANNOT BE DIAGNOSED. AFTER REPLACING THE FUEL PUMP AND CRANK SHAFT SENSOR THE PROBLEM STILL EXISTS. THIS IS SO DANGEROUS TO DRIVE AS YOU DON'T KNOW WHEN IT WILL HAPPEN. PLEASE HELP WITH SUGGESTIONS AS THE MECHANICS AREN'T ABLE TO DIAGNOSE THE PROBLEM. THANK YOU

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA SPORTWAGEN. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED AND THE GLOW PLUG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS COASTED TO A PARKING LOT AND WAS TOWED TO THE DEALER (JOE HEIDT VOLKSWAGEN, 515 ROUTE 17 SOUTH, RAMSEY, NJ, 201-327-2900) WHERE IT WAS DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP CONTAINED PIECES OF METAL, WHICH CAUSED THE FUEL SYSTEM TO FAIL. ALSO, A DIAGNOSTIC TEST WAS PERFORMED AND THE CONTACT WAS INFORMED THAT THE FUEL WAS BAD. THE FUEL PUMP SYSTEM WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE FAILURE MILEAGE WAS 70,205.

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS NOT ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FUEL PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.

WHILE DRIVING THE CAR TO WORK LAST THURSDAY (07/28/16) THE CAR STALLED AND ROLLED TO A STOP. I HAD IT TOWED TO MY MECHANIC AND HE INDICATED THAT THE FUEL PUMP AND POSSIBLY THE INJECTORS NEED TO BE REPLACED. THE CAR HAD JUST UNDER 1/4 TANK OF DIESEL FUEL AT THE TIME. THERE WERE NO ERROR LIGHTS OR OTHER INDICATION OF FAILURE. THE VEHICLE IS STILL AT THE MECHANIC, HE INDICATED THAT THE PARTS ARE $900 AND LABOR WILL BE ADDITIONAL. DEPENDING ON WHAT HE FINDS AS HE DOES THE REPAIR. HE INDICATED THAT THE INJECTORS MAY BE DAMAGED WHICH WOULD ADD AN ADDITIONAL $1000 FOR PARTS PLUS LABOR. I DIDN'T TAKE THE CAR TO VW BECAUSE I DON'T TRUST THEM. THE AC FAILED LAST MONTH AND THEY WANTED $1900 FOR THE REPAIR, I BROUGHT IT TO MY MECHANIC AND HAD IT REPAIRED FOR $800. THEY BILLED ME $200 TO TELL ME THE AC WAS BAD. THE CAR CURRENTLY HAS 40,000 MILE ON IT. I DON'T HAVE THE REPAIR INVOICES AT THIS TIME. UP TO THE TIME OF THE AC FAILURE ALL WORK HAS BEEN COMPLETED BY VW.

DRIVING ON THE HIGHWAY AND THE GLOW PLUG INDICATOR LIGHT STARTS FLASHING WITH A LOSE OF POWER. THE VEHICLE STALLS BUT LUCKILY WHILE EXITING FREEWAY. THE JETTA WAS TOWED TO DEALER WHERE IT WAS DETERMINED HPFP FAILURE AND THE WHOLE FUEL SYSTEM NEEDS TO BE REPLACED. THE CAR WAS NOT FIXED ($6000) AS IT WAS PAST THE WARRANTY BY 1000 MILES.

HIGH PRESSURE FUEL PUMP FAILED CONTAINATED THE FUEL SYSTEM WITH METAL PARTICLES WELL I WAS ON VACATION ON FIVE LANE FREEWAY JUST SOUTH OF PASADENA HIGHWAY 5 FALL LEFT LANE JUST STOPPED RUNNING ALMOST ACCIDENT TRYING TO CROSS FOUR LANES WITH NO POWER.

2011 JETTA DIESEL COMPLETE FAILURE OF HIGH PRESSURE FUEL PUMP WITHOUT WARNING AT 50 MPH ASCENDING A LARGE BRIDGE IN VEHICLE WHAT HAS HAD SCRUPULOUS PERIODIC MAINTAINANCE. OCCURRING AT RUSH HOUR ON A 4 LANE HIGH TRAFFIC RIVER BRIDGE (295 DELAWARE MEMORIAL BRIDGE) A VERY DANGEROUS TIME AND PLACE DUE TO COLLISION POSSIBILITIES. MY RESEARCH SO FAR IS THAT THIS IS A COMMON PROBLEM WITH THE COMPANY COVERING IT UP TO 120 THOUSAND MILES. NO NOTICE HAS EVERY BEEN RECEIVED OF THIS PROPENSITY OR OF THE, WHAT SEEMS TO BE "SECRET" WARRANTY EXTENSION.

HIGH PRESSURE FUEL PUMP FAILURE JULY 2015, WAS DRIVING AT HIGHWAY SPEED WHEN GLOW PLUG INDICATOR STARTED FLASHING, PULLED OFF HIGHWAY AND CAR STALLED IN HIGHWAY OFF-RAMP INTERSECTION. PUSHED CAR OUT OF INTERSECTION TO SIDE SHOULDER. CAR TOWED TO FOX VW OF ROCHESTER HILLS MI. VW AUTHORIZED WARRANTY CLAIM ON REPLACEMENT OF ENTIRE FUEL SYSTEM. REPAIR WAS COMPLETED AND CAR RETURNED. CAR SMELLED OF DIESEL IN THE INTERIOR COMPARTMENT. SMELL DID NOT LESSEN AFTER 1 WEEK EVEN WITH WINDOWS OPEN TO AIR OUT. RETURNED VEHICLE TO FOX VW. FOX VW STATED THAT THERE WAS A SPILL AT THE ACCESS TO THE FUEL PUMP SENDING UNIT UNDER THE SEAT. THE SPILL WAS CLEANED UP AND VEHICLE RETURNED. DIESEL SMELL WAS LESS. FAST FORWARD 3 MONTHS TO NOVEMBER 2015, RETURNED CAR FOR EXTENDED WARRANTY SERVICE FOR GLOW PLUG REPLACEMENT AT PURCHASING DEALER IN PENNSYLVANIA (THREE RIVERS VW), DEALER SERVICE TECHNICIANS DISCOVERED AND DOCUMENTED MULTIPLE FUEL SYSTEM LEAKS WITH INCORRECTLY INSTALLED COMPONENTS. FUEL WAS PRESENT ON TOP OF ENGINE, HIGH PRESSURE FUEL PUMP HOUSING AND FUEL FILTER HOUSING. TRAVELED IN THIS CAR WITH NEWBORN DAUGHTER AND 4YO SON MULTIPLE TIMES WITH LONG ROAD TRIPS IN THE TIME FROM THE FUEL SMELL COMPLAINT TO THREE RIVERS VW FINDING THE LEAKING FUEL. THREE RIVERS VW REPAIRED VEHICLE WITH AUTHORIZATION FROM VW AMERICA.

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE VEHICLE JERKED, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED, AND THE VEHICLE STALLED. THE VEHICLE WAS RESTARTED, BUT THE FAILURE RECURRED. THE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE FUEL INJECTOR SYSTEM FAILED. FOUR INJECTORS, THE FUEL RINGS, THE IGNITION COIL, AND THE WIRES WERE REPLACED. THE CONTACT STATED THAT THE WINDSHIELD WIPERS FAILED TO OPERATE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE WINDSHIELD WIPER MOTOR FAILED. THE WINDSHIELD WIPER MOTOR WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 38,000. UPDATED 01/12/16*LJ; 04/19/18*JB *CN

CAR WITH APPROXIMATELY 56,500 MILES. ABOUT 50 MILES AFTER FUELING WITH DIESEL FUEL FROM A SUNOCO STATION, GLOW PLUG LIGHT STARTED BLINKING, CHECK ENGINE LIGHT ON AND CAR ENTERED A "LIMP MODE". WAS ATTEMPTING TO ACCELERATE ONTO A HIGHWAY FROM AN ON RAMP. WOULD NOT ALLOW ME TO GO OVER 25 MILES PER HOUR. BROUGHT TO NEAREST VW DEALERSHIP. WAS TOLD THE HIGH PRESSURE FUEL PUMP HAD ESSENTIALLY DISINTEGRATED AND THERE ARE METAL SHARDS THROUGHOUT THE ENTIRE FUEL SYSTEM, WHICH WILL NEED TO BE REPLACED. FUEL SAMPLE SENT TO VW FOR TESTING. AWAITING TO HEAR FROM DEALER WHETHER OR NOT THIS WILL BE COVERED UNDER WARRANTY.

HIGH PRESSURE FUEL PUMP FAILURE.

THE CAR , 2011 VW JETTA TDI, STALLED WHILE DRIVING ON THE HIGHWAY FOR THE THIRD TIME. THIS IS THIRD REPAIR TO THE HIGH PRESSURE FUEL SYSTEM. METAL DEBRIS WERE FOUND PER DEALER. THE SECOND TIME WAS APPROX 1 1/2 YRS AGO WHILE MY WIFE WAS DRIVING ON THE FREEWAY WITH 2 KIDS. THE FIRST TIME WAS APPROX 3 YRS AGO.

WHILE DRIVING ON THE FREEWAY, THE DIESEL COIL LIGHT STARTED FLASHING AND OUR VEHICLE LOST POWER. WE PULLED OFF OF THE ROAD, THE VEHICLE STALLED, SO WE HAD THE VEHICLE TOWED TO THE DEALERSHIP. DEALERSHIP DETERMINED IT WAS A FUEL SYSTEM FAILURE(METAL IN THE SYSTEM) AND SENT THE FUEL TO BE TESTED. TEST RESULT SAID INSUFFICIENT LUBRICANT IN FUEL, THEREFORE REPAIRS NOT COVERED UNDER EXTENDED WARRANTY. DEALERSHIP INFORMED US THAT WE NEEDED TO BE USING "TOPTIER" DIESEL. WE RESEARCHED THIS (HAVING NEVER BEEN TOLD THIS BEFORE) AND REALIZED WE HAD PURCHASED DIESEL FROM A "TOPTIER" LISTED STATION (SHELL). DEALERSHIP TOLD US TO MAKE A CLAIM WITH OUR INSURANCE COMPANY SINCE IT WAS AN "OUTSIDE INFLUENCE" THAT CAUSED THE FAILURE. INSURANCE COMPANY IS INVESTIGATING WHETHER OR NOT THIS IS A VALID CLAIM.

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL FAILED AND NEEDED TO BE DRAINED. IN ADDITION, THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000.

VEHICLE BEGAN STUTTERING AND LOST POWER. AFTER AN ADDITIONAL 20 SECONDS SHUT DOWN AND WOULD NOT RESTART. IT APPEARS TO BE A PROBLEM WITH THE DIESEL FUEL PUMP AS METAL DEBRIS WERE FOUND. DEALER CLAIMS VW MUST TEST FUEL HOWEVER I KNOW THE CAR HAS ALWAYS BEEN PROPERLY FUELED AND HAS THE FUELING SAFEGUARD DEVICE INSTALLED.

HIGH PRESSURE FUEL PUMP FAILURE.

HPFP CATASTROPHIC FAILURE STARTED VEHICLE AND WHILE DRIVING EXPERIENCED LOSS OF POWER. DIESEL GLOW PLUG ILLUMINATED AND MFD MESSAGE READ "SERVICE NOW". STALLED AT TRAFFIC LIGHT AND WOULD NOT RESTART. TOWED TO VW OF CORPUS CHRISTI THE NEXT DAY. VW REPAIRED AT THEIR COST. NEVER FUELED WITH ANYTHING BUT DIESEL. REPAIR TICKET INDICATED THAT 'DIESEL LOOKED OK". I WAS FORTUNATE THAT THIS DID NOT OCCUR AT HIGHWAY SPEED. I BELIEVE THAT THE COMPLAINT WAS CLOSED TOO EARLY BY THE NHTSA AND IS NOT DUE TO MISFUELING AS YOU HAVE BEEN CONVINCED BY VW BUT RATHER A DESIGN FLAW IN THE HPFP. I HAVE LOST CONFIDENCE IN THIS BRAND AND THE NHTSA DUE TO THIS ISSUE. *TR

4:45 AM AT 45 MPH, THE ENGINE SPUTTERED THEN TWO DASH LIGHTS SHOWED UP, I PULLED OVER TO CHECK WHAT THEY MEANT. ONE SAID PRE GLOW BEFORE START UP; IF FLASHING MALFUNCTION IN THE DIESEL ENGINE, THE OTHER WAS THE ENGINE MALFUNCTION WHICH SAID EMISSION MALFUNCTION. I HAD THE VEHICLE TOWED TO LOCAL GARAGE THEY DETERMINED IT WAS A FUEL PUMP ISSUE AND SHOWED ME ALL THE METAL SHAVINGS IN THE FUEL METERING VALVE. THEY TOLD ME TO TAKE IT TO VW AS THERE ARE MANY BULLETINS ON THE PROBLEM. *TR

OUTSIDE TEMP WAS 3 DEGREES F, APPROX 0730 ON 16FEB15 I HAD BEEN ON SHIFT THE CAR HAD NOT BEEN STARTED FOR 48 HRS. I STARTED THE CAR, AND WENT BACK INSIDE THE WORK BUILDING FOR APPROX. 5 MIN. WHEN I WENT BACK TO THE CAR I NOTICED A LARGE FLUID SPILL EMANATING FROM THE BOTTOM OF THE ENGINE COMPARTMENT. I IMMEDIATELY TURNED OFF THE VEHICLE. AFTER REQUESTING ASSISTANCE FROM A CO-WORKER IT WAS DISCOVERED THAT WHEN THE IGNITION SWITCH WAS ACTIVATED LARGE AMOUNTS OF DIESEL FUEL WAS SPURTING FROM THE TOP-FRONT PORTION OF THE FUEL PUMP. THE VEHICLE HAS BEEN LEFT OFF, IS CURRENTLY AWAITING TOW, DIAGNOSTIC AND REPAIR ESTIMATES. *TR

HIGH PRESSURE FUEL PUMP FAILURE, RESULTING IN DAMAGE THAT REQUIRED REPLACING THE ENTIRE DIESEL FUEL SYSTEM. REPAIR COVERED UNDER VW WARRANTY, ESTIMATED COST (ACCORDING TO VW) HAD THIS NOT BEEN COVERED WAS $8000. THIS FAILURE WAS NOT DUE TO MIS-FUELING, HOWEVER THE FUEL TANK WAS VERY LOW. I HAVE NO REASSURANCES FROM THE MANUFACTURE THAT THIS PROBLEM WILL NOT REOCCUR. *TR

WHILE DRIVING, THE HPFP PUMP FAILED. THE GLOW PLUG LIGHT CAME ON, STARTED TO BLINK, THE CAR WENT INTO FAIL SAFE MODE, AND THEN DIED. ALL TOOK PLACE WITHIN 6 MINUTES ON A HIGHWAY. CAR TAKEN TO DEALER AND CONFIRMED THAT THE HPFP FAILED AND SENT METAL DEBRIS INTO THE FUEL SYSTEM WHICH CONTAMINATED ALL OTHER FUEL SYSTEM COMPONENTS (PUMPS, LINES, FILTERS, HOUSINGS, INJECTORS, ETC.) VW CUSTOMER CARE PROVIDED EXCELLENT SUPPORT DURING REPAIRS WHICH REQUIRED REPLACING ALL COMPONENTS IN THE FUEL SYSTEM. THIS IS BEING REPORTED FOR TRACKING PURPOSES. *TR

WAS DRIVING MY CAR ON A 2 LANE ROAD WHEN IT BUCKED AS IF IT HAD A CYLINDER GO DEAD FOR JUST A SECOND. NOTE: THERE IS NO WARNING WHEN THIS IS OR DOES HAPPEN. IT JUST DOES IT.... BUT IT WAS HIT AN MISS. I LOOKED AT THE DASH PANNEL AND SEEN THE GLOW PLUG LIGHT FLASHING, CHECK ENGINE LIGHT WAS ON AND THE MESSAGE CENTER SERVICE ENGINE NOW. I WAS 40 MILES FROM THE CLOSEST VW DEALER. SO, I HEADED TO THE CLOSEST AUTO PARTS SHOP TO SEE THE CODES IT HAD PRODUCED. P1007, P0088 AND P0087 ARE THE ONES I REMEMBERED. THE CAR WAS RUNNING BUT OBVIOUSLY NOT GOOD. IT LACKED ANY POWER,COULD BARELY PULL ITSELF UP A HILL UNLESS YOU DOWN SHIFTED. IT FINALLY DIED AT A INTERSECTION AND WOULD NOT RESTART. I GOT MY TRUCK AND TRAILER AND TOWED IT TO THE DEALER WHO STATED IT HAD SUFFERED HIGH PRESSURE FUEL PUMP CATISTROPHIC FAILURE.... WHEN THEY CALLED THEY STATED IT WAS GOOD AND BAD NEWS. BAD NEWS IT WAS GOING TO BE 2-3 WEEKS IN THE SHOP. GOOD NEWS IS, THERE IS SO MUCH DAMAGE (6500.00) WORTH THAT VW IS PAYING FOR ALL THE REPAIRS PLUS I HAVE A LOANER CAR. THE WHOLE FUEL SYSTEMS HAS TO BE REPLACED. 1 IN TANK FUEL PUMP AND PRE HIGH PRESSURE FUEL PUMP AND THE PRIMARY HPFP THE ONE THAT SELF IMPLODED THE INJECTORS, AND ALL THE FUEL LINES AND FILTERS. REASON IS THE METAL PARTS THAT FLOATED THRU THE SYSTEM COULD BLOCK ANY PART OF THE FUEL SYSTEM OR BE HUNG UP AND IF SO, COULD RETURN TO THE FUEL TANK AND BE PUMPED BACK IN. WITH SUCH CLOSE TOLERANCES ANY THING COULD INTURN RE-DESTROY THE SYSTEM SO TOTAL REPLACEMENT IS REQUIRED. THIS WAS THE FIRST TIME IN 35 YEARS I WAS LEFT ON THE SIDE OF THE ROAD. THANKS VW CORPORATION FOR OWNING UP TO THIS ISSUE AND COMPLETING THE REPAIRS. *JS

DRIVING THE CAR AT FREEWAY SPEEDS PRIOR TO TAKING THE EXIT. WHEN WE TOOK THE EXIT, THERE WAS A SUDDEN LOSS OF POWER AND THE VEHICLE WOULD NOT GO OVER 1000 RPM. THE VEHICLE WAS LIMPED TO THE SHOULDER WHERE IT DIED AND WOULD NOT RESTART. VEHICLE WAS TOWED TO THE MECHANIC SHOP WHERE THEY ARE IN THE PROCESS OF REPAIRS. THE VW IS EQUIPPED WITH A 2.0L TDI ENGINE AND I HAVE READ MULTIPLE OTHER REPORTS OF THE SAME ISSUES OCCURRING INVOLVING THE HPFP FAILING. *TR

CAR WAS RUNNING SMOOTH AND PARKED IN THE DRIVEWAY AND THEN WOULDN'T TURN OVER. BATTERY POWER WAS FINE, HOSES WERE FINE(VACUUM OK) AND THEN IDENTIFIED THAT FUEL MIGHT BE THE PROBLEM, USED MULTIMETER TO IDENTIFY THAT FUEL PUMP UNDER BACK SEAT WAS DEAD AND PROMPTLY ORDERED A NEW ONE AND REPLACED IT. NOT EXPECTED FOR A CAR WITH 45,000 MILES AND A 2011 DIESEL BUT THIS IS APPARENTLY A COMMON PROBLEM. HAD IT IN FOR REGULAR MAINTENANCE AT THE DEALER TOO. *TR

THE VEHICLES GLOW PLUG LIGHT STARTED FLASHING, THE CAR STARTED RUNNING SLUGGISH, I QUICKLY PULLED INTO A GAS STATION. I TURNED OFF THE CAR AND WHEN I TRIED TO RESTART IT, IT WOULD CRANK BUT NOT START. I HAD IT TOWED TO MY MECHANIC, WHO AFTER SOME INVESTIGATION DISCOVERED THE HIGH PRESSURE FUEL PUMP FAILED AND SENT METAL SHAVINGS THROUGHOUT THE FUEL SYSTEM. LINES, INTAKE, FUEL INJECTORS ALL HAVE BEEN AFFECTED. I AM BEING QUOTED SEVERAL THOUSANDS TO REPAIR. THIS SHOULD SIMPLY NOT HAPPEN, I SEE IT AS FAULTY ENGINEERING! *TR

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE SUDDENLY STALLED AND EXPERIENCED A REDUCTION IN POWER. THE CONTACT WAS UNABLE TO RESTART THE ENGINE. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL INJECTOR SYSTEM AND FUEL PUMP HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 33,000.

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA SPORTS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, AN UNUSUAL WIRE SYMBOL WARNING ICON ILLUMINATED ON THE INSTRUMENT PANEL IN ADDITION TO A REDUCTION IN ENGINE POWER. AFTER DRIVING 30 ADDITIONAL MILES, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE HIGH PRESSURE FUEL PUMP FAILED. THE VEHICLE WAS REPAIRED. AFTER THE REPAIR WAS PERFORMED, A DIFFERENT UNKNOWN WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 109,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA WAGON. THE CONTACT STATED THAT WHILE DRIVING 75 MPH, THE COIL LIGHT ILLUMINATED. THE VEHICLE THEN STALLED AND THE CONTACT SMELLED FUEL INSIDE THE VEHICLE. THE CONTACT PULLED OVER AND EXITED TO INSPECT THE VEHICLE. THE CONTACT THEN NOTICED A FUEL LEAK ON THE GROUND AND ON THE ENGINE. THE VEHICLE WAS TOWED TO A DEALER BUT WAS NEITHER DIAGNOSED NOR REPAIRED. THE FAILURE MILEAGE WAS 35,000.

2011 VOLKSWAGEN TDI JETTA. CAME TO A THREE WAY LIGHT, THE LIGHT CHANGED, I HIT THE GAS AND THE CAR DIED. I WAS IN THE TURN LANE AT THE BOTTOM OF A HILL AT A BUSY INTERSECTION. I TRIED SEVERAL TIMES TO RESTART TO NO AVAIL. NO ENGINE CODES OR ERROR MESSAGES. HAD THE VEHICLE TOWED TO THE DEALERSHIP WHERE THEY FOUND METAL SHAVINGS IN THE FUEL FILTER. PARTS ARE BEING ORDERED AND THE FUEL SYSTEM IS BEING REPLACED. WAITING TO HEAR WHEN THE PARTS ARE IN AND THE WORK IS COMPETED. *TR

WHILE DRIVING 65 MPH THE VEHICLE BEGAN TO SPUTTER. THE GLOW PLUG COIL LIGHT BEGAN TO FLASH AND THE CAR STALLED WHILE ON THE INTERSTATE. TRIED TO MOVE IMMEDIATELY TO THE SHOULDER ALMOST CAUSING AN ACCIDENT AT HIGH SPEED. TURNED THE KEY OFF AND RESTARTED THE VEHICLE AND THE CHECK ENGINE LIGHT STAYED ON. DROVE IT BACK TO THE DEALERSHIP UNDER VERY REDUCED POWER. THE DEALER HAD JUST COMPLETED MY 40,000 SERVICE ONLY HOURS BEFORE. NOW BEING TOLD THAT THE HIGH PRESSURE FUEL PUMP AND ONE OF THE INJECTORS IS BAD. CLAIMING BAD FUEL BUT THAT IS NOT CORRECT. HAVE ONLY BURNED HIGH QUALITY DIESEL IN THE VEHICLE AND HAD ALL SERVICES DONE. APPEARS THAT THIS IS A RECURRING PROBLEM ON THESE CARS AND IT'S AMAZING SOMEONE HAS NOT BEEN HURT. VW NEEDS TO ISSUE A RECALL ON THIS PROBLEM. THE ESTIMATE TO REPAIR IS $10K AND IT'S NOT COVERED BY WARRANTY. *TR

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP EXPLODED DUE TO FUEL CONTAMINATION AND AS A RESULT, THE FUEL PUMP NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 20,000. *TR

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 70 MPH AND APPLYING THE BRAKES IN AN ATTEMPT TO AVOID ANOTHER MOTORIST, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A DEALER FOR DIAGNOSIS. THE CONTACT WAS INFORMED THAT THE FUEL INJECTOR LINE WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 33,000.

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS AT THE DEALER FOR ROUTINE MAINTENANCE THE ENGINE WARNING LIGHT ILLUMINATED. THE DEALER PERFORMED A DIAGNOSTIC; THE FAILURE WAS LOCATED AT THE FUEL PUMP FILTER. THE DEALER ADVISED THAT THE FUEL USED CONTAMINATED THE FUEL PUMP FILTER WITH DIBRIS. THE FUEL PUMP WAS REPLACED, HOWEVER THE FAILURE WAS NOT CORRECTED; THE ENGINE LIGHT ILLUMINATED AND THE VEHICLE MADE A LOUD NOISE WHILE DRIVING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 20,200.

MORNING RUSH HOUR TRAFFIC IN NEW ORLEANS (CENTER LANE) WHEN GLOW PLUG LIGHT STARTED FLASHING AND NO POWER TO CHANGE LANES. AT THIS TIME, TRYING NOT TO GET RUN OVER, I MANAGED TO GET OVER AND COAST TO AN OFF RAMP INTO THE LOWER 9TH WARD(SCARY). CAR WAS DEAD AND WOULD NOT START. BROUGHT TO A DEALERSHIP AND WAS TOLD IT WOULD BE 1 WEEK BEFORE IT COULD BE LOOKED AT IT. NOT KNOWING IF IT WAS COVERED UNDER WARRANTY NO RENTAL WAS GIVEN AND HAD TO BE PICKED UP BY WIFE, 100 MILES AWAY. ONE WEEK LATER WAS NOTIFIED THE HIGH PRESSURE FUEL PUMP HAD FAILED AND EXTENDED WARRANTY WOULD COVER THE COST FOR $109 BUCKS. IT'S AMAZING HOW I BOUGHT THE EXTENDED WARRANTY AND A MAJOR PART GOES OUT AND I GOT NO RENTAL AND IT'S GOING TO COST ME MONEY. VW DOESN'T STAND BEHIND THEIR PRODUCT.END RESULT FROM OWNING A VW TDI, GETTING RUN OVER AT 5 A.M IN THE MORNING, BEING STRANDED IN THE LOWER NINTH WARD OF NEW ORLEANS FOR 3 HOURS SCARED TO GET OUT OF CAR, RIDE WITH WRECKER FOR 1 HOUR TO DEALERSHIP, NO RENTAL CAR TO GET BACK TO WORK, WAIT FOR 1.5 HOURS FOR FAMILY MEMBER TO COME GET ME, WAIT FOR 1 WEEK TO BE TOLD THE REPAIR COST WOULD BE @7K AND A REMANUFACTURED PART WOULD BE PUT BACK, COST OF $109 FOR WARRANTY, ANOTHER WEEKS WAIT FOR REPAIR AND BEST OFF BEING STUCK WITH A CAR THAT HAS NO TRADE IN AFTER ANYONE CHECKS CARFAX. WHILE BEING STRANDED AND CHECKING INTERNET FIND OUT VW IS HAVING MAJOR PROBLEMS WITH THIS AND IT COULD HAVE BEEN PREVENTED WITH A RECALL. *TR

A WARNING LIGHT CAME ON, AND THE ENGINE BEGAN PERFORMING POORLY AT 75MPH ON A BUSY HIGHWAY. SLOWING TO EXIT ABOUT A MILE FURTHER, THE ENGINE ABRUPTLY STALLED AND QUIT ON THE OFF RAMP. THE REPAIR REPORT INDICATED THAT IT WAS AN INTERNAL HIGH PRESSURE FUEL PUMP FAILURE. IT CAUSED METAL PIECES TO SPREAD THROUGHOUT THE FUEL SYSTEM. THE TOTAL FOR PARTS ONLY WAS $4445. PROBLEM IS BEING BLAMED ON FUEL QUALITY IN THE US. *TR

I WAS DRIVING ON THE EXPRESSWAY AT NIGHT DURING TRAFFIC HOURS WHEN MY ENGINE MALFUNCTION LIGHT STARTED FLASHING. I WAS DOING 50MPH WHEN MY ENGINE SHUT OFF. I WAS IN THE MIDDLE LANE AND TRAFFIC WAS FLYING BY ME ON BOTH SIDES OF MY CAR SO I WAS AFRAID TO GET OUT THE VEHICLE. LUCKY FOR ME A TOW TRUCK SEEN ME IN DISTRESS AND HELPED GET ME AND MY CAR OFF THE EXPRESSWAY. I TOOK MY CAR TO THE DEALERSHIP AND THEY TOLD ME IT WAS THE HIGH PRESSURE FUEL PUMP DISINTEGRATED AND SENT METAL SHARDS THROUGHOUT THE ENTIRE FUEL SYSTEM. VW TRIED TO ACCUSE ME OF PUTTING REGULAR GAS IN A LOW DIESEL FUEL ENGINE. BUT I HAD MY RECEIPTS FOR PROOF. VW NEEDS TO INVESTIGATE FURTHER. SINCE A VEHICLE SHUTTING OFF DURING TRAFFIC HOURS IS A SAFETY HAZARD. IF THE TOW TRUCK HADN'T SEEN ME WHEN HE DID THE RESULTS MIGHT HAVE BEEN FATAL. *TR

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE THE BRAKES WERE DEPRESSED THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSE THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE WAS 16,690 AND THE CURRENT MILEAGE WAS 16,700.

ON MAY 14, 2012 WHILE DRIVING HOME FROM WORK ON CALIFORNIA I-15 NORTH. I WAS STUCK IN TRAFFIC AROUND THE TAMECULA AREA, AND TRAVELING 15-20 MPH TO DUE TO THE TRAFFIC. I STOPPED MY VEHICLE BECAUSE TRAFFIC STOPPED. TRAFFIC BEGAN TO MOVE ONCE AGAIN, I PRESSED THE ACCELERATOR AND MY VEHICLE BEGAN TO MOVE ONCE AGAIN. WHEN I REACHED 15 - 20 MPH, MY VEHICLE SUDDENLY STARTED TO LOSE POWER AND SLOW DOWN. I RECEIVE A ORANGE BLINKING AMBER LIGHT ON MY DASH CONSOLE. I DOWN SHIFT, AND PRESSED THE ACCELERATOR ONCE AGAIN AND VEHICLE PRODUCED LITTLE POWER. I REFERENCED THE BLINKING ORANGE AMBER LIGHT IN OWNER'S MANUAL AND THE MANUAL STATED THE LIGHT MEANT "ENGINE MALFUNCTION" AND TO CONTACT DEALER IMMEDIATELY. I AS PROCEED ON I-15 NORTH, WHEN I HAD TO TRAVEL UP A HILL, THE VEHICLE BEGIN TO DECELERATE EVEN IF I DOWN SHIFT. THE NEXT MORNING MAY 15, 2012 I TOOK THE VEHICLE TO THE LOCAL VOLKSWAGEN DEALERSHIP TO DIAGNOSE THE VEHICLE. LATER THAT AFTER NOON, I WAS CONTACTED BY THE DEALERSHIP STATING THE FUEL SENSOR HAD GONE BAD AND NEEDED TO BE REPLACED. THE DEALERSHIP REPLACED THE FUEL SENSOR AND I PICKED UP THE VEHICLE ON THURSDAY MAY 17, 2012. ON FRIDAY MAY 18, 2012 I DROVE THE VEHICLE TO WORK. ON THE WAY HOME, AROUND THE SAME AREA ON THE I-15 NORTH TAMECULA CITY LIMITS. AGAIN MY VEHICLE EXPERIENCED THE SAME MALFUNCTION AS BEFORE, LOST OF POWER, LOST OF ACCELERATION, AND BLINKING ORANGE AMBER LIGHT. I STOPPED THE VEHICLE TURNED IT OFF AND BACK ONE I PROCEEDED TO GO, AND 20 MILES LATER RECEIVED THE BLINKING ORANGE AMBER "ENGINE MALFUNCTION" LIGHT AND "CHECK ENGINE" LIGHT. I TOOK THE VEHICLE TO THE DEALERSHIP ON THE MAY 19, 2012 AND LATER THAT DAY WAS TOLD THE FUEL SENSOR AND FUEL PUMP HAD GO BAD. IT IS MAY 29, 2012 AND THE DEALERSHIP STILL HAS THE VEHICLE. DEALERSHIP UNABLE TO DETERMINE THE PROBLEM, AND HOW TO FIX VEHICLE. VEHICLE WAS PURCHASED BRAND NEW IN AUGUST 2011. *TR

WITH LITTLE OR NO WARNING, ENGINE STALLED IN BUSY INTERSECTION DURING EVENING RUSH HOUR. LUCKILY CAR COST INTO ADJACENT PARKING LOT. HAD CAR TOWED TO LOCAL VW DEALER WHO SAID TOTAL FUEL SYSTEM HAD TO BE REPLACED DUE TO HIGH PRESSURE FUEL PUMP FAILURE. REPAIR TOOK SEVERAL WEEKS. *TR

MY 2011 VW JETTAS HIGH PRESSURE FUEL SYSTEM STOPPED WORKING AND THE CAR WILL NOT START. THE DEALER SAID THAT IS WAS CAUSED BY THE FUEL. THE REPAIRS ARE WELL OVER $8000. I UNDERSTAND THAT NHTSA IS LOOKING INTO THIS PROBLEM BECAUSE IT HAS HAPPENED TO SO MANY OTHER VW DIESEL JETTA CARS. I HAVE NOW TALKED TO OVER 15 PEOPLE IN MY AREA THAT HAVE HAD THE SAME ISSUE WITH THE FUEL SYSTEM. I OWN NUMEROUS OTHER DIESEL TRUCKS THAT FILL UP AT THE SAME FILLING STATION AND HAVE NOT HAD THIS PROBLEM. PLEASE DO SOMETHING ABOUT A RECALL SO THIS IS COVERED BY VW. I CAN SEE IF THIS PROBLEMS WAS JUST A FEW CARS, BUT THE TDI WEB SITE LISTS THOUSANDS OF CARS THAT THIS HAS HAPPENED TO. *JS

CAR IS A 2011 VW JETTA TDI. I WAS TOLD BY THE VW DEALER THAT THE HIGH PRESSURE FUEL PUMP HAD FALLEN APART CAUSING METAL TO GO THROUGH THE FUEL SYSTEM.I BOUGHT THE CAR NEW IN JULY OF 2011.VOLKWAGEN IS REPLACING THE ENTIRE FUEL SYSTEM BUT I AM CONCERNED THAT DAMAGE MAY HAVE ALREADY BEEN DONE TO THE ENGINE. *JS

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS THEN TOWED TO AN AUTHORIZED DEALER. THE DEALER STATED THAT THE HIGH PRESSURE FUEL PUMP FAILED. THE DEALER REPLACED THE FUEL TANK, HIGH PRESSURE FUEL PUMP, AND THE FUEL LINES. THE STALLING FAILURE WAS CORRECTED, BUT THE VEHICLE NO LONGER PERFORMED WITH THE SAME FUEL EFFICIENCY. THE CONTACT FELT THAT THE RECALL REPAIRS CAUSED THE DECREASE IN FUEL EFFICIENCY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND DENIED ASSISTANCE WITH THE FUEL EFFICIENCY FAILURE. THE FAILURE MILEAGE WAS 14,299 AND THE CURRENT MILEAGE WAS 20,558.

THE CAR MADE LOUD KNOCKING NOISES AND STOPPED. THE SERVICE ADVISOR FIRST SAID THERE WAS AN IGNITION IN THE FUEL PUMP, THEN 10 DAYS LATER HE SAID IT WAS FUEL PUMP FAILURE. ALL DIESEL FUEL I PURCHASED FOR THE CAR WAS PURCHASED AT PMM MOBIL, 26393 VERMONT AVE., HARBOR CITY CA., 90710. I HAD JUST FILLED UP WITH FUEL 10 MILES EARLIER AND I WAS 1/2 BLOCK AWAY FROM MY HOME WHEN THE CAR FAILED, I COULD HAVE BEEN ANYWHERE! THE SAME SERVICE ADVISER GAVE NO SUGGESTIONS TO HELP PREVENT ANOTHER FAILURE, LEAVING ME TO RELY ON THE INFORMATION ON THE INTERNET TO KEEP THE CAR RUNNING. *TR

ATTEMPTED TO START 2011 JETTA TDI WITH 11000 MILES AFTER IT HAD BEEN SITTING IN A PARKING LOT FOR 9 HOURS. TEMPERATURE 45F OUTSIDE. VEHICLE STARTED PERFECTLY AND THEN DIED SECONDS LATER. ATTEMPTED TO START VEHICLE AGAIN, BUT WOULD NOT TURN OVER. HAD A LOT OF TROUBLE GETTING IT TO START AND WHEN IT DID IT WAS RUNNING VERY ROUGH AND THEN WOULD DIE IMMEDIATELY. FINALLY ABLE TO START VEHICLE AND KEEP IT RUNNING AFTER APPROXIMATELY 30 MINUTES. WAS ABLE TO DRIVE 30+ MILES HOME - STARTED FINE AFTER. THIS IS THE SECOND OCCURRENCE. THIS FIRST OCCURRED APPROXIMATELY 1 MONTH AGO WITH 8000 MILES ON VEHICLE. OUTSIDE TEMPERATURE WAS IN MID FORTIES. CAR WOULD NOT START AT ALL - KEPT TURNING OVER, BUT WOULD NOT START. GLOW PLUG LIGHT FLASHED INTERMITTENTLY. AFTER WAITING APPROXIMATELY 45 MINUTES TO 1 HOUR THE CAR STARTED UP FINE WITHOUT HESITATION. VEHICLE WAS AT DEALER 2 DAYS PRIOR TO SECOND INCIDENT, BUT THEY COULD NOT FIND ANYTHING. VEHICLE WILL BE RETURNING TO DEALER ASAP. *TR

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA. THE CONTACT STATED WHILE DRIVING 65 MPH THE ENGINE STALLED WITHOUT WARNING. THE LIGHTS ON THE INSTRUMENTAL PANEL ILLUMINATED AFTER THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC TEST THAT LOCATED THE FAILURE IN THE FUEL SYSTEM. THE VEHICLE WAS REPAIRED. THE DEALER REPLACED THE FUEL LINES, PUMP, AND THE FUEL TANK. THE CONTACT STATED THE ENTIRE FUEL SYSTEM WAS REPLACED. THE FAILURE AND CURRENT MILEAGE WAS 14,299.

BOUGHT MY JETTA TDI NEW 4 MONTHS AGO. FILLED UP WITH DIESEL ON A MONDAY MORNING AND HAD DRIVEN APPROXIMATELY 70 MILES BEFORE I HAD THIS PROBLEM. WAS DRIVING HOME TUESDAY (AT 60MPH) WHEN SUDDENLY LOST ACCELERATION AND GLOW PLUG LIGHT STARTED FLASHING. WAS ABLE TO LIMP TO A VW DEALERSHIP ABOUT 1 MILE BACK BUT CAR WOULD NOT ACCELERATE ABOVE 35MPH. THE NEXT DAY THE DEALERSHIP GAVE THE DIAGNOSIS OF WATER IN THE DIESEL AND TOLD ME "EVERYTHING THAT THE DIESEL HAD TOUCHED" WOULD HAVE TO BE REPLACED (FUEL TANK, LINES, FILTER, ETC.) .THEY SAID THE VW WARRANTY WOULD PAY FOR IT THIS ONE TIME BUT IF IT HAPPENED AGAIN I WOULD BE RESPONSIBLE FOR THE OVER $5000 COST. WHEN I ASKED HOW I COULD AVOID THIS IN THE FUTURE I WAS TOLD I JUST NEEDED TO PURCHASE MY DIESEL FROM A "REPUTABLE" PLACE. (SERIOUSLY!!! DO THEY THINK I AM BUYING "BUBBA'S HOME BREWED BIODIESEL" ON THE SIDE OF THE ROAD OR SOMETHING???) I REPORTED TO THE TEXAS DEPT OF AGRICULTURE THAT THE VW DEALERSHIP WAS CLAIMING THE DIESEL I HAD PURCHASED ON MONDAY HAD WATER IN IT. THE TDA PROMPTLY CAME OUT AND INVESTIGATED THE STATION WHERE I PURCHASE FUEL AND REPORTED TO ME THAT THEY FOUND NOTHING WRONG WITH THE DIESEL. THIS SOUNDS TO ME LIKE A MAJOR OVERSIGHT ON THE PART OF VW IF THERE IS NO WAY TO AVOID SUCH A POTENTIALLY DANGEROUS AND COSTLY PROBLEM. I TRADED A MUCH NICER AND MORE COMFORTABLE SUV FOR THIS JETTA IN AN ATTEMPT TO SAVE $$$ ON FUEL. I THINK I'VE MADE A HUGE MISTAKE. *TR

LOSS OF POWER WHEN ACCELERATING AWAY FROM A STOP SIGN ON A LARGE BUSY INTERSECTION. WEATHER CONDITIONS WERE LIGHT RAIN TEMP IN THE 70'S. CONTINUED TO DRIVE FOR SEVERAL MILES AT SLOWER SPEEDS (ABOUT 40 MPH). NOTICED A DASH WARNING LIGHT WAS ALSO FLASHING, SOMETHING ABOUT A GLOW PLUG. ALL GAUGES LOOKED NORMAL. SEVERAL DAYS LATER NOTIFIED THE VW DEALER OF THE OF THE CONDITION THE CAR WAS TO GET THE 20,000 MILE SERVICE. SERVICE PERSON SAID HE WOULD CHECK IT OUT. CALLED NEXT DAY TO ASK IF I HAD USED BIO DIESEL FUEL. REPLIED I HAD NOT AND THE SAME FUEL IN THE TANK HAD BEEN UN USE WHEN THE POWER LOSS WAS NOTICED. CALLED NEXT DAY TO REPORT PARTS WERE ON ORDER.GOT CAR BACK ABOUT 5 WEEKS LATER AND CAR WORKS OK. SAID THEY FOUND PARTICLES OF METAL IN THE FUEL SYSTEM. CHANGED THE FUEL PUMP AND A BUNCH OF OTHER FUEL SYSTEM PARTS ON WARRANTY. *TR

DRIVING DOWN ROAD WHEN GLOW PLUG LIGHT, CHECK ENGINE LIGHT CAME ON THEN CAR DIED AND WOULD NOT RESTART. HPFP FAILURE. DEALER CLAIMS CONTAMINATED FUEL. I HAVE RECEIPTS FOR EVERY TANK FULL. *TR

ON 9/9/2011 WHILE DRIVING ON CA 91 FWY, I STARTED NOTICING ABNORMAL DROP IN THE FUEL TANK, BY MONITORING MY DASHBOARD, AT THE TIME I HAD HALF TANK OF FUEL. I STOPPED THE CAR ON A SAFE LOCATION, AND DISCOVERED A FUEL LEAKAGE UNDERNEATH THE TRUNK. THE FUEL WAS COMPLETELY DRAINED, AND I HAD TO CALL FOR VOLKSWAGEN ROAD SIDE ASSISTANCE TO TOW THE VEHICLE TO THE NEAREST DEALER. THE VEHICLE WAS TOWED TO A VOLKSWAGEN DEALER IN GARDEN GROVE, CA. THE DEALER INVESTIGATED IT THE PROBLEM, AND ACKNOWLEDGED THAT THE PROBLEM WAS DUE TO PROBABLE ASSEMBLY LINE FAULT. THE DEALER ORDERED NEW PARTS, AND FIXED THE PROBLEM, UNFORTUNATELY, THE FUEL SMELL STILL EXIST, BUT I CAN'T SEE LEAKAGE. *KB

IN RUSH-HOUR TRAFFIC IN BOSTON THE DRIVER'S FOOT WAS ON THE ACCELERATOR WHEN THE CAR STOPPED MOVING IN THE MIDDLE OF THE HIGHWAY. LUCKILY, THE AMBULANCE AND POLICE ARRIVED PROMPTLY AND WERE ABLE TO GET THE CAR OFF THE ROAD. THEN IT WAS TOWED TO THE NEAREST VW DEALERSHIP. THE CARS DIAGNOSIS WAS A FUEL PUMP COLLAPSE. THIS WAS HARD TO BELIEVE SEEING AS WE HAVE ONLY OWNED THIS BRAND-NEW CAR FOR ONE MONTH.

THE SECOND CYLINDER OF THE FUEL INJECTED DIESEL ENGINE BEGAN TO LEAK THE DIESEL FUEL INJECTED. THE UNDERCARRIAGE OF THE CAR AND THE RIGHT SIDED PANELS WERE COVERED WITH DIESEL FUEL. THE ENGINE LOST POWER AND AT SLOWER SPEEDS FUEL BEGAN TO POOL UNDER THE CAR.

AFTER EXITING HIGHWAY, I NOTICED SMOKE COMING FROM UNDER THE HOOD. THE ENGINE TEMP. WAS NORMAL SO I DROVE STRAIGHT TO MY DEALERSHIP. WHEN I ARRIVED I NOTICED A STRONG SMELL OF DIESEL FUEL. THE DEALER TOOK THE CAR IMMEDIATELY AND INVESTIGATED, THEY FOUND A FUEL LEAK CAUSED BY A PINHOLE IN THE FUEL LINE AT THE #2 INJECTOR. THEY REPAIRED THE PROBLEM AND RETURNED THE CAR THE NEXT DAY. UPDATED 2/8/12 *CN

1 RECENTLY PURCHASED A (2011) VW JETTA AT "CHAPMAN VOLKSWAGEN" IN TUCSON, ARIZONA.IT SEEMED TO RUN WELL THE FIRST DAY I DROVE IT,BUT ON THE SECOND DAY OF PURCHASE I MADE U-TURN TO PROCEED ONTO THE HIGHWAY AND IT MYSTERIOUSLY DECELERATED. I PULLED THE VEHICLE OVER AS I WAS GOING ONTO THE ON-RAMP AND NOTICED THAT THE LOW FUEL LIGHT WAS LIT. WHAT STUCK ME AS BEING MOST PECULIAR WAS THAT THE REGULAR FUEL GAUGE WAS READING NEARLY HALF FULL. THE VEHICLE DID NOT STALL AND THE GAUGE RETURNED TO NORMAL FUNCTIONING, BUT IT LEFT ME WITH QUESTIONS ABOUT THE SAFETY OF THE VEHICLE. I WAS WONDERING IF OTHER SIMILAR VEHICLES HAD SIMILAR ISSUES AND IF THEY WERE RESOLVED. THE REPRESENTATIVES AT THE DEALERSHIP ARE NOT RETURNING MY CALLS AND HAVE OFFERED NO EXPLANATION FOR THE INCIDENT. *TR