2009 Volkswagen Jetta Fuel System Problems

FUEL PUMP NOT SHUTTING OFF AFTER ENGINE SHUTOFF. DRAINING BATTERY. THIS HAPPENED ONE NIGHT WHILE VEHICLE WAS STATIONARY IN MY DRIVEWAY.

DOING 70 MPH ON THE HIGHWAY OUR 2009 JETTA TDI LOST ALL POWER. THE HIGH INJECTION FUEL PUMP TURNED OUT TO BE THE PROBLEM. REPAIRS WILL COST AT LEAST $6,000.00 VW MODIFIED THIS PUMP 5 DIFFERENT TIMES AND NEVER NOTIFIED THE OWNERS ABOUT PROBLEMS WITH THE PUMP. THE NHTSA HAD AN INVESTIGATION AND CONCLUDED PEOPLE WERE USING THE WRONG FUEL. WE HAVE 2 DIESEL VEHICLES AND KNOW WHICH PUMP AT THE SERVICE STATIONS ARE DIESEL. THIS IS A SERIOUS LIFE THREATENING PROBLEM, CATASTROPHIC FAILURE AND NO POWER IN YOU CAR YET THE NHTSA CLOSED THEIR INVESTIGATION. VW WILL DO NOTHING TO HELP WITH REPAIRS AND THE JETTA HAS BECOME A TOTAL LEMON. WE HAVE RECEIVED SEVERAL RECALL NOTICES THROUGH THE YEARS, NONE REGARDING THE FUEL PUMP, AND THE CAR WAS TAKEN TO THE DEALERSHIP FOR THE RECALLS EACH TIME. WE WOULD LIKE TO SEE SOMETHING DONE ABOUT THIS SERIOUS PROBLEM.

THE CAR WAS DRIVEN A SHORT 7 MILES AND PARKED FOR 2.5 HOURS IN 28F WEATHER. UPON STARTING TO RETURN THE SMELL OF FUEL WAS NOTICEABLE. UPON DRIVING THE SMELL DID NOT DISSIPATE AND SEEMED QUITE INTENSE. THE VEHICLE WAS STOPPED AFTER ABOUT MILE OF SLOW IN-TOWN TRAVEL AND ON A HUNCH THE TOP ENGINE COVER WAS REMOVED. FUEL WAS FOUND TO BE ALL OVER THE TOP OF THE ENGINE IN THE AREA OF THE INJECTOR LINES. THE RECALL WORK (11V490000) FOR THESE LINES WAS DONE YEARS AGO. THE CAR IS CURRENTLY AT THE DEALERSHIP AWAITING EVALUATION BUT I CAN'T HELP WONDER IF THEIR RECALL WORK WAS NOT FULLY SUCCESSFUL AT PREVENTING THE FUEL LEAK IT WAS MEANT TO. *TR

AT 140K MILES 2009 VOLKSWAGON JETTA TDI STALLED OUT IN MIDDLE OF INTERSECTION. TOWED TO DEALER AND DIAGNOSTICS REVEALED P0191-FUEL PRESSURE SENSOR IMPLAUSIBLEAND P0087-FUEL RAIL SYSTEM PRESSURE TOO LOW. VOLKSWAGEN WILL NOT FIX DUE TO EMISSIONS RECALL OF MY VEHICLE AND OVER WARRANTY. VOLKSWAGEN KNOWS THIS IS A DEFECT WITH THE DIESEL ENGINE AND WON'T FIX IT.

VEHICLE STALLED WITHOUT WARNING WHILE TRAVELING OUT OF STATE IN 118 DEGREE WEATHER NEAR PHOENIX. STALL OCCURRED JUST AS WE WERE TURNING BACK ONTO THE HIGHWAY AFTER STOPPING TO CHECK THE MAP. CHECK ENGINE LIGHT CAME ON AND ENGINE WOULD CRANK BUT NOT START. TOWED TO NEAREST DEALER WHO DIAGNOSED HPFP FAILURE KNOWN TO OCCUR WITH VW TDI ENGINES.

THE VEHICLE IS PART OF THE VW TDI EMISSIONS SCANDAL. THE VEHICLE CURRENTLY NEEDS A DPF WHICH IS ONE OF THE PARTS AFFECTED BY THE EMISSIONS SCANDAL AND ONE THAT WILL EVENTUALLY NEED TO BE REPLACED FOR THE CAR TO MEET/PASS EMISSIONS. VW SHOULD PAY FOR THIS EXPENSIVE REPAIR NOW.

MY CAR HAS 146K MILES. IT IS A DIESEL. THE HIGH-PRESSURE FUEL PUMP FAILED WHILE IN MOTION ON 2/8/2016. VW LIMIT ON HPFP WARRANTY EXTENSION IS 120K MILES WHICH SEEMS LOW FOR A DIESEL CAR. TO REPAIR THE FUEL SYSTEM IS $5300 WHICH IS MORE THAN THE CAR IS WORTH. CALLED VW AND THEY WILL NOT OFFER ANY FINANCIAL ASSISTANCE...EVEN WITH THIS CAR BEING PART OF 'DIESELGATE'. HOPING OTHER DRIVERS WITH THIS SAME PROBLEM ARE COMPLAINING AND ODI CONSIDERS RE-OPENING THE REPORT. LINK HERE HTTP://WWW-ODI.NHTSA.DOT.GOV/ACMS/CS/JAXRS/DOWNLOAD/DOC/UCM475595/INCR-EA11003-61863.PDF.

THIS IS FOR A 2009 VW JETTA TDI. THE TDI OF COURSE HAS BEEN INVOLVED WITH VW ADJUSTING SOFTWARE TO COVER UP NOX EMISSIONS ON SEVERAL YEAR MODELS OF THEIR DIESEL 2.0 ENGINES. WHAT ALSO NEEDS TO BE LOOKED AT IS THE HIGH NUMBER OF FAILURES INVOLVING THE DIESEL PARTICULATE FILTER (DPF) UNITS. IT COULD BE THE SOFTWARE HAT HAS BEEN CHURNING OUT WRONG EMISSIONS READINGS COULD HAVE POSSIBLY OVERTAXED THE SOOT COLLECTION IN THIS VEHICLES AS WELL. I WOULD SUGGEST SOMEONE FROM YOUR OFFICE PERUSE FORUMS AT TDICLUB AND OTHER TDI SITES TO SEE THE NUMBER OF THESE UNITS THAT HAVE BEEN REPORTED BY MEMBERS. I HAVE NOT HAD THE FAILURE AS OF YET, BUT WANTED TO BRING THIS TO YOUR ATTENTION

"HIGH PRESSURE FUEL PUMP" ADDENDUM TO COMPLAINT #10808605 PLEASE ADD TO THE PREVIOUS THAT MY HUSBAND WAS DRIVING THE VEHICLE AT THE TIME & I FAILED TO MENTION THAT WHEN THE (HPFP) FAILED HE WAS IN THE FAST LANE OF THE FREEWAY & HIS POWER WAS IMMEDIATELY STOPPED. THIS HAPPENED ON THE I10 FREEWAY EASTBOUND JUST BEFORE THE "COUNTY LINE RD" OFFRAMP IN YUCAIPA, CA. THERE WAS NO SHOULDER IN THE FAST LANE FOR HIM TO PULL OVER. HE WAS VERY FORTUNATE THAT THERE WAS NO TRAFFIC TO HIS RIGHT AS HE HAD TO MAKE IT ACROSS 2 LANES OF TRAFFIC IN AN UPHILL GRADE. THE CAR BARELY MADE IT TO THE OFFRAMP! IF THERE HAD BEEN TRAFFIC (TYPICALLY SLOW MOVING TRUCK TRAFFIC), HE WOULD HAVE BEEN TRAPPED IN THE MIDDLE OF THE FREEWAY & SURELY HIT!! IN MY PREVIOUS COMPLAINT I WAS ANGRY ABOUT VW NOT TAKING RESPONSIBILITY FOR THE KNOWN FAILURE. WE ARE RESPONSIBLE CAR OWNERS & REGULARLY SERVICE OUR VEHICLES. I COULD UNDERSTAND HAD THIS BEEN NEGLIGENCE ON OUR PART. MY HUSBAND COMMUTES 200 MILES A DAY & WE RELY HEAVILY ON HAVING A RELIABLE VEHICLE, WHICH WE THOUGHT WE HAD IN A VW DIESEL. THEY RECOGNIZED THE DEFECT BY OFFERING A 10YR, 120,000 MILE WARRANTY EXTENSION. MIND YOU THIS IS A DIESEL ENGINE WHICH HAS A LIFE EXPECTANCY OF AT LEAST DOUBLE THIS. AT SOME POINT THIS FAILURE WAS BOUND TO HAPPEN & VW KNOWS IT. I SPOKE WITH MANY VW TECHNICIANS IN THE DIAGNOSIS OF THIS ISSUE & THEY ALL ACKNOWLEDGE THIS IS A FAULTY PART. SOME OF THE BLOGS TRY TO ALLUDE THAT POOR FUEL IS THE CAUSE, BUT THE MECHANICS DON'T AGREE.ANY ASSISTANCE YOU CAN PROVIDE IN GETTING VW TO TAKE RESPONSIBILITY WOULD BE GREATLY APPRECIATED. THIS NOT ONLY ENDANGERED THE LIFE OF MY HUSBAND, BUT THIS IS A $5500 REPAIR!!

DRIVING OF FREEWAY & SUDDEN LOSS OF POWER. CAR DIED ON THE OFFRAMP & UNABLE TO START. GLOW PLUG LIGHT & BATTERY LIGHT ILLUMINATED. TOWED TO LOCAL SHOP EXPECTING AN ALTERNATOR REPAIR. THEY DIAGNOSED HPFP FAILURE. $5500 REPAIR!! THIS IS A KNOWN ISSUE & SHOULD HAVE BEEN A RECALL! I RECEIVED A WARRANTY EXTENSION (10YR OR 120,000MI) LETTER JUNE 2015. MY VEHICLE IS 2009 WITH 155K MILES AT THAT TIME. MY VEHICLE HAS DEPRECIATED DUE TO THE EMISSION SYSTEM & NOW THIS.

YESTEDAY, THE ENGINE SHUT DOWN AFTER I GOT OFF FREEWAY AT OFFRAMP. AS I CAME TO A STOP AT THE TRAFFIC LIGHT AND ENGINE STOPPED. HAD A FLASHING "GLOW PLUG" ICON ON DASH FOR LESS THAN A MINUTE AND LITTLE NO ACCELERATION BEFORE EXITING FREEWAY. WOULD NOT RESTART. HAD TO HAVE CAR TOWED 50 MILES TO HOME. TODAY I FIND A DTC OF P0087, FUEL PRESSURE TOO LOW. I UNSCREWED THE SCREWS HOLDING THE FUEL FILTER ASSY TOP COVER. LIFTING THE COVER, I SAW METAL PARTICLES ON TOP OF THE FUEL FILTER. THIS ALWAYS MEANS THE HI-PRESSURE FUEL PUMP HAS FAILED - FORCING METAL PARTICLES TO THE FUEL TANK, HI PRESSURE FUEL RAIL, FUEL INJECTORS, FUEL FILTER AND FUEL LINES.

THE HIGH PRESSURE FUEL PUMP OF THE TDI DIESEL VERSION OF THIS CAR IS EASILY COMPROMISED UNDER REGULAR USE AND SENDS THE CAR INTO A DISABLED MODE WHILE DRIVING. IT IS DANGEROUS AND VERY UNCLEAR WHAT IS HAPPENING.

THIS PROBLEM IS CAUSED BY FUEL PUMP FAILURE IN VW DIESEL ENGINES. IT HAPPENS IN TWO WAYS. FUEL PUMP FAILS SENDING METAL SHARDS THROUGHOUT THE FUEL SYSTEM OR FUEL PUMP PROVIDES INADEQUATE PRESSURE AND CAR ENTERS 'LIMP MODE'. IN THE FIRST CASE THE CAR STOPS RUNNING AND ENTIRE FUEL DELIVERY SYSTEM MUST BE REPLACED. THE SECOND CASE HAPPENS UNDER LOAD (PASSING, ENTERING FREEWAY OR CLIMBING INCLINE). 'LIMP MODE' MEANS LOSS OF POWER. THE CAR MUST BE PULLED OVER, IGNITION TURNED OFF AND THEN BACK ON TO CLEAR ERROR CODE. THIS IS VERY DANGEROUS WHEN FREEWAY DRIVING. I'VE HAD BOTH CASES OF FAILURE. VW HAS OPTED NOT TO RECALL BUT RATHER DEAL CASE BY CASE. MY LAST FAILURE WAS WITH A PUMP WITH ONLY 2000 MILES ON IT. BOSCH MAKES THE PUMPS. AFTER A FEW PUMP REPLACEMENTS, VW REFUSES TO PAY. AFTER THE LAST REPLACEMENT I WAS TOLD THAT IT WOULD TAKE AN 'ACT OF GOD' TO BREAK THE NEW VERSION OF PUMP. SO I GUESS GOD BROKE IT. THERE IS MUCH DOCUMENTATION ONLINE FOR 'LIMP MODE'. A GOOD SOURCE FOR DOCUMENTING THE PROBLEM IS WWW.TDICLUB.COM (SEARCH LIMP MODE). I DON'T KNOW IF A RECALL WILL FIX THE PROBLEM SINCE THE PUMPS WILL CONTINUE TO FAIL. I DO BELIEVE THAT VW SHOULD REPLACE THE PUMPS AT THEIR OWN EXPENSE IN PERPETUITY. I ALSO BELIEVE THAT BOSCH SHOULD BE HELD ACCOUNTABLE FOR PROVIDING SUBSTANDARD PUMPS.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. WHILE DRIVING 60-70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A DEALER WHO DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP FAILED. THE DEALER STATED THAT THERE WAS NO PERMANENT REMEDY FOR THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

UPON PULLING OUT OF A DRIVEWAY, VEHICLE SHOWED FLASHING "GLOW PLUG" INDICATOR AND LOSS OF POWER (LIMP HOME MODE). PULLED OVER, TURNED OFF VEHICLE AND RESTARTED, INDICATOR CLEARED AND VEHICLE DROVE NORMALLY. ON SUBSEQUENT TRIP LATER IN THE DAY, SAME SYMPTOMS APPEARED. AGAIN, CLEARED BY STOP AND RESTART OF VEHICLE. FLASHING GLOW PLUG INDICATOR RETURNED ALMOST IMMEDIATELY, THIS TIME WITH SOLID "CHECK ENGINE" INDICATOR AS WELL. DROVE TO DEALERSHIP SERVICE DEPARTMENT WHERE THEY FOUND METAL FRAGMENTS IN THE FUEL SYSTEM AND LIKELY HIGH PRESSURE FUEL PUMP FAILURE. CURRENTLY AWAITING RESULTS OF FUEL TEST TO VERIFY FAILURE WAS NOT CAUSED BY MISFUELING WITH GASOLINE.

ENGINE STALLED WHEN DRIVING AND WOULD NOT RESTART. METAL FRAGMENTS WERE FOUND IN THE ENTIRE FUEL SYSTEM DAMAGING ALL COMPONENTS.COMPLETE FUEL SYSTEM REPLACEMENT IS ONLY ALTERNATIVE PER VOLKSWAGEN OF AMERICA. CONTACTED VOLKSWAGEN CUSTOMER ASSISTANCE AND WAS TOLD ASSISTANCE IS NOT AN OPTION DUE TO A FEDERAL MANDATE LIMITING TIME AND MILEAGE TO 10 YEARS OR 120000 MILES. ALSO STATED VOLKSWAGEN WOULD HAVE BEEN ABLE TO REPAIR AT THEIR DISCRETION IF NOT FOR THE FEDERAL GOVERNMENT REGULATIONS?? THIS IS A VERY COMMON FAILURE THAT LOCAL DEALER STATES OCCURS LOCALLY 4-5 TIMES A WEEK IN THIS AREA. THE AVERAGE REPAIR COST IS OVER 6000.00 DOLLARS. I HAVE BEEN TOLD THE NHTSA HAD INVESTIGATED THIS SITUATION AND CLOSED THE PROBE. IF DEALER RECORDS WERE INVESTIGATED THOROUGHLY, THEY WOULD HAVE FOUND A TREMENDOUS NUMBER OF LIKE FAILURES THAT CANNOT ALL BE ATTRIBUTED TO IMPROPER FUELING OR TAINTED PRODUCT. 4-5 TIMES A WEEK SINCE 2009?? ABSURD AND UNACCEPTABLE.

THE GLOW PLUG LIGHT BEGAN FLASHING AND THE CHECK ENGINE LIGHT WAS ON (HAD BEEN ON FOR THE ENTIRE DURATION OF MY OWNERSHIP OF 1 YEAR FOR THE CAR). WE WERE ON THE HIGHWAY AND THE CAR STEADILY LOST POWER IN THE SPAN OF A QUARTER MILE. WE PULLED OFF THE SIDE OF THE ROAD. THE ENGINE WOULD CRANK BUT NOT START. THE MECHANIC THE NEXT DAY FOUND METAL SHAVINGS IN THE FUEL SYSTEM AND SUSPECTS A HIGH PRESSURE FUEL PUMP FAILURE. THE RECOMMENDATION WAS TO REPLACE BOTH FUEL PUMPS AND FUEL LINES. WE HAVE NEVER MISFUELED THE CAR - WE HAVE ONLY USED DIESEL FUEL AT TOP STATIONS LIKE SHELL AND BP.

HAD BEEN DRIVING FOR WELL OVER 100 MILES ON THE INTERSTATE AND WAS EXITING FROM ONE INTERSTATE ONTO ANOTHER IN MODERATE TRAFFIC IN LOUISVILLE, KENTUCKY. DURING LANE CHANGE, FLASHING "GLOW PLUG" INDICATOR LIGHT CAME ON AND "ENGINE FAULT! WORKSHOP!" CAME ON. CAR IMMEDIATELY DECELERATED, CAUSING HARD BREAKING FROM FOLLOWING TRAFFIC AND NEAR COLLISION. ABLE TO DRIVE AT 40 MPH FOR APPROXIMATELY ONE MILE TO ANOTHER EXIT. STOPPED AT TRAFFIC LIGHT AT THE BOTTOM OF THAT EXIT AND CAR STALLED IN THE MIDDLE OF THE ROAD AND WOULD NOT RESTART. TOWED TO NEAREST DEALERSHIP. TWO DAYS LATER, LEARNED FROM VW DEALER THAT IT WAS THE "HPFP". AGAIN. A SIMILAR INCIDENT HAPPENED WITH THIS CAR IN THE FALL OF 2011 -- AROUND THE SAME TIME VW ISSUED THEIR RECALL OF THE FAULTY PUMP. I WAS TOLD THAT THE HPFP WAS REPLACED AT THAT TIME. THIS WAS ONLY 4 YEARS AGO AND PRECISELY THE SAME ISSUE. I HAVE HAD THE DIESEL FUEL PUMP MODIFICATION (ANOTHER RECALL), THE CAR IS UNDER THE 120K ON THEIR "EXTENDED WARRANTY" AND I ONLY USE VERY-LOW SULFUR DIESEL GASOLINE AT MAJOR NATIONAL CHAINS WHEN TRAVELING CROSS-COUNTRY LIKE THIS.

WAS DRIVING WHEN THE ENGINE FAULT WORKSHOP WARNING CAME ON. THE GLOW PLUG WARNING LIGHT ALSO APPEARED. CAR WOULDN'T GO PAST A LOWER RPM BUT WAS ABLE TO MAKE IT TO A PARKING LOT. AFTER GROCERY SHOPPING, TURNED THE ENGINE ON AGAIN AND STARTED TO DRIVE. BOTH WARNING LIGHTS CAME ON AGAIN AND THEN THE ENGINE STALLED. WAS ABLE TO START IT AGAIN AND PARKED IT IN A PARKING SPOT. WAITED ABOUT 5 MINUTES AND STARTED IT AGAIN AND WAS ABLE TO DRIVE IT AROUND THE PARKING LOT. ENGINE LIGHT WAS ON BUT CAR WAS RUNNING OK. PULLED OUT ONTO THE STREET AND WENT ABOUT A 1/4 OF A MILE AND THE WARNING LIGHTS CAME ON AGAIN AND STALLED. WAS ABLE TO START IT AGAIN AND MAKE A U-TURN AND THEN THE LIGHTS AND STALLED HAPPENED AGAIN. PARKED ALONG THE CURB AND CALLED A TOW TRUCK. THIS APPARENTLY IS A COMMON ISSUE WITH THE FUEL PUMP ON VW TDI'S. CAR IS CURRENTLY AT A VW DEALERSHIP WAITING ON THE RESULTS FOR A GAS TEST TO SEE WHAT TYPE OF FUEL I HAD IN THE TANK. MY CALL HAS THE GASOLINE NOZZLE BLOCKER INSTALLED PER THE RECALL A FEW YEARS AGO. THERE IS NOT ANY GASOLINE IN THE TANK.

WAS DRIVING AND THERE WAS A LOSS OF POWER, AS IF THE TURBO HAD STOPPED WORKING, IT EVENTUALLY STALLED OUT.

FOR THE 2ND (!) TIME IN 2 YEARS, THE HIGH PRESSURE FUEL PUMP FAILED ON THE CAR. AS MY HUSBAND WAS DRIVING THE MOUNTAIN HIGHWAY, HE LOST ALL HORSEPOWER AND THE DASH LIGHTS ALL LIT UP WITH VARIOUS WARNING SIGNALS AND A SYSTEM FAILURE WARNING. FUEL PUMP HAS EXPLODED AND INTRODUCED METAL SHAVINGS THROUGHOUT THE ENTIRE FUEL SYSTEM.

GAS SMELL INSIDE CAR, FUEL SPRAYING/LEAKING OUT OF METAL FUEL LINE FROM FUEL PUMP TO FUEL RAIL.

VEHICLE ENGINE SHUT OFF DURING TRAVEL, DUE TO FUEL FILTER BEING CLOGGED BY METAL DEBRIS. THE HIGH PRESSURE INJECTION PUMP FAILED EFFECTIVELY ENDING THE LIFE OF THE ENGINE. THE WELDS ON THE HIGH PRESSURE INJECTION PUMP HAD DETERIORATED, RESULTING METAL DEBRIS TO CIRCULATE THROUGH COMPLETE INJECTION SYSTEM. AFTER MULTIPLE FAILED ATTEMPTS TO FLUSH OUT THE INJECTION SYSTEM IT WAS DECIDED THAT THE BEST COURSE OF ACTION WAS TO REPLACE THE ENTIRE FUEL SYSTEM ALONG WITH THE FUEL INJECTOR PUMP. THE DEALERSHIP WOULD NOT COVER THE REPAIR THAT WAS ESTIMATED TO BE AROUND $5,500. VERY UNSATISFIED. *TR

TL*THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TOWED TO THE RESIDENCE WHERE THE CONTACT REPLACED THE FUEL FILTER. THE CONTACT INFORMED THAT THE HIGH PRESSURE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

WE BOUGHT OUR 2009 JETTA TDI USED AT A KIA DEALERSHIP ON 5/4/14 WITH 99K ON THE ODOMETER. THE CAR WAS RUNNING FINE AND WE HAD NO ISSUES DURING TEST DRIVE OR THE MONTH AFTER UNTIL 6/18/14 WHEN THE GLOW PLUG LIGHT CAME ON. WE TOOK IT BACK TO THE DEALERSHIP WE BOUGHT IT AT BECAUSE IT HAD A 12/12000 WARRANTY ON IT AND THEY COULDN'T FIND A PROBLEM. THEY REPLACED THE BATTERY. IT HAPPENED AGAIN AND WE TOOK IT IN TO THEM, THIS TIME THEY SENT IT BACK TO THE VW DEALERSHIP THEY HAD OBTAINED IT FROM TO HAVE IT CHECKED OUT. IT WAS THERE FOR 4 DAYS WHILE MECHANICS TRIED TO FIND THE PROBLEM AND THEN THEY BROUGHT IN AN EXPERT TO TELL THEM THAT THE HIGH VOLUME FUEL PUMP WAS FAILING AND IT WOULD COST $1,500 TO REPLACE. IT WAS NOT COVERED UNDER THE 12/12000 DEALER WARRANTY. WE CHOSE NOT TO HAVE THE WORK PERFORMED THERE AND I AM TAKING IT TO ANOTHER MECHANIC TO HAVE IT DONE. WE HAVE DRIVEN IT FOR THE PAST COUPLE OF MONTHS WITH ONLY MINOR ISSUES WITH THE GLOW PLUG LIGHT COMING ON AND WE HAVE LEARNED TO PULL OVER, SHUT THE CAR OFF AND TURN IT ON AGAIN. THIS WILL GO FOR A FEW WEEKS BEFORE HAPPENING AND THEN WE HAVE TO DO THE SAME THING ALL OVER AGAIN. IT IS NOW FAILING MORE OFTEN AND I WILL BE TAKING IT IN TO REPAIR. THE PROBLEM HERE IS THAT THE HVFP IS A WELL DOCUMENTED FAILURE ON THE TDI MODELS AND I BELIEVE BASED ON THE COST I HAVE BEEN SEEING ON FORUMS THAT THIS SHOULD BE A RECALL. WHEN THE FAILURE HAPPENS IT IS NOT ALWAYS IN A SAFE PLACE AND I HAVE TO MAKE SOME UNSAFE MOVES TO GET OFF THE ROAD TO SHUT DOWN. I HAVE BEEN LUCKY THAT IT DIDN'T HARD FAIL AS OTHERS HAVE AND TAKE OUT MY FUEL SYSTEM. WE ALSO LOCATED THE ORIGINAL OWNER AND SHE HAD THE SAME ISSUES, THIS IS WHERE WE LEARNED TO JUST SHUT THE CAR OFF AND RESTART IT AND ALL WOULD BE FINE. *TR

HIGH-PRESSURE DIESEL FUEL PUMP (HPFP) BEGAN TO FAIL. HEARD HIGH-PITCHED WHINE COMING FROM HPFP AFTER ENGINE HAD BEEN TAKEN AT LEAST ONCE PAST 2100 RPMS AFTER STARTUP. VW DEALERSHIP SERVICE DEPARTMENT CONFIRMED HPFP IMMINENT FAILURE AND REPLACED IT UNDER WARRANTY. *TR

THIS ISSUE HAS BEEN HAPPENING IN MY JETTA TDI FOR OVER A YEAR, AND SO FAR MY MECHANIC HAS BEEN UNABLE TO FIGURE OUT THE CAUSE. I HEAR A DING AND THE GLOW PLUG LIGHT BEGINS FLASHING, AND ON THE SMALL SCREEN I SEE "ENGINE FAULT - WORKSHOP" ONCE. THE CAR SOMETIMES SEEMS TO LOSE POWER OR GO INTO "LIMP MODE" BUT SOMETIMES THERE IS NO AFFECT ON HOW IT DRIVES. WHEN I PULL OVER AND TURN OFF THE CAR, THEN TURN IT BACK ON, THE ERROR IS GONE AND THE CAR DRIVES FINE. THIS HAS HAPPENED MORE & MORE FREQUENTLY, ALMOST ALWAYS WHEN I'M DRIVING ON THE HIGHWAY. IT NOW HAPPENS AT LEAST EVERY OTHER WEEK OR SO. AFTER DOING SOME RESEARCH I SEE THAT THIS IS A PRETTY COMMON PROBLEM FOR JETTA TDIS, AND IT SEEMS THAT VW NEEDS TO DO SOMETHING ABOUT IT! THE LAST TIME I HAD MY CAR IN THE SHOP FOR IT, ANOTHER CHECK ENGINE LIGHT HAD COME ON, AND THAT WAS FIXED, BUT THIS ISSUE WAS NOT BECAUSE MY MECHANIC COULDN'T REPLICATE THE PROBLEM. NOW THAT I'VE DONE MORE RESEARCH I AM CALLING MY MECHANIC IN THE MORNING. *TR

WHILE DRIVING MY 2009 JETTA SPORTWAGON TDI ON A 3-LANE ARTERIAL, THE ENGINE BEGAN TO SPUTTER AND AT THE SAME TIME THE GLOW PLUG DASHBOARD LIGHT BEGAN FLASHING. WITHIN 5 SECONDS THE ENGINE STALLED COMPLETELY AND WOULD NOT RESTART, LEAVING THE CAR DISABLED IN THE MIDDLE OF THE LANE. AN INDEPENDENT REPAIR SHOP DISCOVERED THAT THE HIGH PRESSURE FUEL PUMP (HPFP) HAD SHATTERED AND SENT SHARDS OF METAL DOWNSTREAM THROUGH THE FUEL SYSTEM. THOSE SHARDS IN TURN DAMAGED THE FUEL LINES AND FUEL INJECTORS. THE INDEPENDENT REPAIR SHOP WAS UNABLE TO SECURE A REPLACEMENT PART FOR THE HPFP FROM ITS USUAL SOURCES AND CONTACTED THE LOCAL VOLKSWAGEN DEALER. THE VW DEALER WOULD NOT SELL THE PART TO THE INDEPENDENT SHOP BUT INDICATED THAT VOLKSWAGEN WOULD REPAIR THE PROBLEM AT NO COST EVEN THOUGH THE CAR WAS NO LONGER UNDER FACTORY WARRANTY. WHEN I SPOKE TO THE PARTS MANAGER AT THE VW DEALER, SHE INDICATED THAT HPFP FAILURE WAS A KNOWN BUT UNCOMMON PROBLEM AND THAT SHE SAW CARS WHERE THIS HAD HAPPENED "ABOUT 10 OR 12 TIMES A YEAR." WHEN I HAD THE CAR TOWED TO THE DEALERSHIP AND SPOKE TO THE SERVICE MANAGER, HOWEVER, HE SAID THAT MY CAR WAS THE 7TH OR 8TH CAR ON HIS REPAIR FLOOR AT THAT TIME WITH A FAILED HPFP, AND THAT HE HAD BEEN SEEING "ABOUT 15 TO 20 CARS A MONTH" WITH THIS PROBLEM. HE SAID THAT SOME OF THEM HAD PROBABLY FAILED DUE TO MISFUELING, BUT THAT OTHERS FAILED FOR NO APPARENT REASON. HE SAID IT WAS PROBABLY DUE TO A SLIGHTLY DIFFERENT DIESEL FORMULATION IN THE US VS. IN EUROPE. WHEN I PICKED UP THE REPAIRED CAR TWO WEEKS LATER, I ASKED THE SERVICE MANAGER IF THERE WAS ANY EVIDENCE OF MISFUELING IN MY CAR AND HE SAID "NO." I ASKED HOW MANY HPFP FAILURES HE HAD SEEN SINCE I DROPPED MY CAR OFF AND HE SAID "YOU DON'T WANNA KNOW, PROBABLY A DOZEN." HE ALSO SAID HE HAD RECENTLY BECOME AWARE OF HPFP FAILURES HAPPENING EVEN ON VEHICLES WITH PREVIOUS HPFP REPAIRS. *TR

I TRIED STARTING MY CAR AND THE ENGINE WOULD NOT TURN OVER, AS IF IT WAS NOT GETTING ANY FUEL. AFTER NUMEROUS ATTEMPTS I HAD MY CAR TOWED TO COMMONWEALTH VOLKSWAGEN IN SANTA ANA , CA. THEY DIAGNOSED THE PROBLEM AS A FAILED HIGH PRESSURE FUEL PUMP WHICH SENT SLIVERS OF METAL THROUGHOUT THE FUEL SYSTEM. THE ENTIRE FUEL SYSTEM,(HOSES PIPES INJECTION UNITS FUEL PUMPS, FILTERS, ETC.) WAS REPLACED. VOLKSWAGEN PAID FOR THE ENTIRE REPAIRS. I WAS TOLD BY THE VOLKSWAGEN SERVICE REPRESENTATIVE THAT THEY HAD SEEN THIS ISSUE BEFORE AND THAT IT WAS NOT UNCOMMON IN 2009 & 2010 JETTA TDI AND OTHER TDI MODELS. THEY ASKED IF GASOLINE HAD EVER BEEN USED AND I INDICATED THAT I HAVE ONLY USED DIESEL FUEL AND THAT VOLKSWAGEN HAD RETROFITTED THE FUEL NOZZLE RECEPTACLE TO ONLY ACCEPT DIESEL FUEL NOZZLES. IT CONCERNS ME THAT VOLKSWAGEN KNOWS ABOUT THIS PROBLEM, THAT THEY REPAIR THE VEHICLE AT THEIR EXPENSE, NO QUESTIONS ASKED, AND IT HAS BEEN REPORTED HUNDREDS OF TIME BY VOLKSWAGEN OWNERS ON A VARIETY OF INTERNET WEBSITES, YET VOLKSWAGEN IS NOT RECALLING THE VEHICLES TO PROACTIVELY FIX THE PROBLEM. THEY FIX THE PROBLEM ONE AT A TIME AS IT OCCURS. THEY WAIT UNTIL THE SYSTEM FAILS AND THE CONSUMER IS PUT IN JEOPARDY OF BEING IN A MAJOR, LIFE THREATENING ACCIDENT OR STRANDED IN A REMOTE AREA. THIS PROBLEM HAS ALSO OCCURRED WITH MY 2010 VOLKSWAGEN JETTA TDI IN AUGUST 2014, AT NIGHT, 50 MILES FROM THE NEAREST VOLKSWAGEN SERVICE CENTER. I REPORTED THIS INCIDENT TO NHTSA AS WELL. VOLKSWAGEN NEEDS TO TAKE OWNERSHIP OF THIS PROBLEM BY RECALLING ALL THE TDI VEHICLES BEFORE PEOPLE ARE KILLED ON THE HIGHWAYS. *TR

MY HUSBAND AND I WERE DRIVING, AND WE HEARD A VERY FAINT, HIGH PITCH SCREECHING SOUND, LIKE A PULLEY SYSTEM WAS GOING OUT. WE DROVE ANOTHER 500 FEET, AND THEN THE ENGINE STALLED. THEN THE BLINKING GLOW PLUG LIGHT CAME ON. THANKFULLY WE WERE NOT GOING VERY FAST, AND THE ROAD WAS NOT BUSY. WE WERE ABLE TO COAST TO THE SIDE OF THE ROAD. WE TRIED TO START THE CAR AGAIN, BUT IT WOULDN'T TURN OVER. WE HAD TO GET THE CAR TOWED TO A SHOP. THERE ARE SMALL PIECES OF METAL FOUND IN THE FUEL FILTER, WHICH INDICATED THE HIGH PRESSURE FUEL PUMP FAILURE. *TR

WAS TURNING RIGHT ONTO A BACKROAD, SHIFTING FROM GEARS 1 TO GEAR 2 HITTING 22 MPH. LOST ALL ACCELERATION, HAD TO PULL OVER AND TURN VEHICLE OFF, SMELL OF SMOKE BUT NO VISUAL, LET VEHICLE SIT, CHECKED OIL, COOLANTS, ALL PERFECT. SMELL WENT AWAY, ATTEMPTED TO START VEHICLE WITH HOOD OPEN, CHECKED ENGINE WITH VEHICLE ON, MOVEMENT OF 1-2 INCHES FROM ENGINE ROCKING SEVERELY. TURNED VEHICLE OFF, TOWED TO DEALERSHIP. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THERE WAS A SUDDEN LOSS ON ENGINE POWER AS THE ELECTRONIC THROTTLE CONTROL WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED WITH A FRACTURED HIGH PRESSURE FUEL PUMP AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE AND CURRENT MILEAGE WAS 119,000.

I LOST POWER AND A MECHANIC HAS SINCE ATTRIBUTED IT TO THE HPFP (HIGH PRESSURE FUEL PUMP) ISSUE OUTLINED IN A TECHNICAL SERVICE BULLETINS. THE ISSUE CAUSES METAL FRAGMENTS TO CONTAMINATE THE ENTIRE FUEL SYSTEM. VW RECOMMENDS OVER $9,000 IN FIXES FOR THE COMPROMISED CAR, SOMETHING THAT IN A SINGLE STROKE EXCEEDS THE REMAINING VALUE OF AN OTHERWISE WELL MAINTAINED CAR. *JS

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED WHILE THE DRIVER DROVE AT 65 MPH, THE VEHICLE STALLED. THE ENGINE LIGHT ILLUMINATED WHILE THE FAILURE OCCURRED. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE FUEL INJECTION PUMP RUPTURED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 92,846.

2009 VW JETTA SPORTWAGEN TDI WAS BEING OPERATED NORMALLY. PARTIAL POWER LOSS WAS ENCOUNTERED AND DASH INDICATOR LIGHTS BEGAN TO ILLUMINATE. VEHICLE WAS ABLE TO CONTINUE TO NEARBY DESTINATION. WHEN DRIVER ATTEMPTED TO START THE VEHICLE AGAIN IT WOULD NOT START. VEHICLE WAS TOWED TO LOCAL VW DEALERSHIP. DIAGNOSIS WAS COMPLETE FAILURE OF THE HIGH PRESSURE FUEL PUMP (HPFP). ENTIRE FUEL SYSTEM WAS REPLACED ALONG WITH HPFP. MANUFACTURER PAID FOR ALL REPAIRS. FUEL WAS TESTED AND NO FOREIGN CONTAINMENTS WERE FOUND.

HIGH-PRESSURE FUEL PUMP FAILURE (HPFP) WHILE I WAS DRIVING 60MPH ON HIGHWAY HAS GLOW PLUG LIGHT FLASHING AND CHECK LIGHT, CAR IS MISFIRING AND STALLING. *TR

THE VEHICLE WOULD NOT START. DEALER FOUND FAILURE OF HIGH PRESSURE FUEL PUMP AND METAL FRAGMENTS SUFFUSED THROUGHOUT THE FUEL INJECTION SYSTEM (FUEL LINES, TANK, ETC.). *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY LOST ACCELERATION POWER. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE DIESEL FUEL INJECTOR NUMBER ONE HAD FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 156,000.

THE VEHICLE'S ENGINE STALLED WHILE TRAVELING DOWN THE ROADWAY AT APPROXIMATELY 35 MPH. THE VEHICLE'S ELECTRICAL SYSTEM CONTINUED TO OPERATE (DRIVING LIGHTS, INTERIOR LIGHTS, POWER STEERING AND POWER BRAKES) DURING THIS TIME. ENGAGED EMERGENCY FLASHERS AND COASTED VEHICLE TO A STOP AT THE NEAREST PARKING LOT. AFTER PLACING TRANSMISSION INTO PARK, VEHICLE RESTARTED WITH NO FURTHER INCIDENT. *TR

WE WERE DRIVING DOWN THE ROAD WHEN OUR CAR SPUTTERED ONCE AND THEN DIED. WE COASTED INTO A PARKING LOT AND TRIED TO CRANK IT AGAIN. IT SPUTTERED ONCE AND DIED AGAIN. THEN WE WERE UNABLE TO GET IT RESTARTED. THIS WAS ON A SATURDAY AFTERNOON. MONDAY MORNING WE HAD IT TOWED TO A CERTIFIED INDEPENDENT REPAIR SHOP. THEY DIAGNOSED IT AS A FUEL SYSTEM FAILURE. THERE WAS METAL SHAVINGS IN THE FUEL SYSTEM. HE INDICATED THAT REPAIRS WOULD COST SIX THOUSAND. HE HAD TO REPLACE ALL THE FUEL COMPONENTS. IT WAS THREE WEEKS TO REPAIR IT. THE FINAL COST ENDED UP BEING $5688.17. THE VEHICLE HAS NEVER HAD GAS PUT IT IN. WE WERE ALWAYS VERY PARTICULAR ABOUT WHERE WE PURCHASED DIESEL FUEL. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE STALLED AS THE ENGINE MALFUNCTION WARNING MESSAGE ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE FUEL WAS CONTAMINATED. AS A RESULT, THE HIGH PRESSURE FUEL PUMP AND FUEL SYSTEM NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED TO PAY FOR THE ENTIRE COST OF THE REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 35,000.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CHECK ENGINE WARNING INDICATOR HAD NOT ILLUMINATED UNTIL AFTER THE FAILURE HAD OCCURRED. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE HIGH PRESSURE FUEL INJECTION PUMP WAS FRACTURED, WHICH CAUSED METAL SHAVINGS TO ENTER THE FUEL TANK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 98,000. THE VIN WAS NOT AVAILABLE.

VEHICLE ENGINE STOPPED COMPLETELY DEAD AND WAS NEARLY REARENDED . WAS NOT ABLE TO RESTART VEHICLE AND WAS TOWED BACK TO VOLKSWAGEN DEALERSHIP. VOLKSWAGEN TOLD ME THE HIGH PRESSURE FUEL PUMP WAS BAD AND REPAIR WOULD COST $10,000.00 AFTER A FURIOUS ARGUMENT WAS TOLD THEY WOULD FIX IT. THIS PROBLEM HAS HAPPENED TO MANY VEHICLES THAT HAVE NOT REPORTED IT TO NHTSA WHEN ARE YOU GOING TO PUT A STOP TO THIS MAJOR PROBLEM. MAYBE WHEN SOMEONE GETS KILLED *JS

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP WAS DISINTEGRATING FROM THE INSIDE, SENDING METAL SHAVINGS THROUGH THE FUEL SYSTEM. AS A RESULT, THE HIGHER PRESSURE FUEL PUMP BECAME DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THEY DECIDED TO COVER THE COST OF THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 90,205.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED AND ALL OF THE WARNING LAMPS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 125,680 AND THE CURRENT MILEAGE WAS 127,000.

I WAS COMING TO A STOP OFF A HIGHWAY OFF RAMP. MY CAR DIED WHILE COMING TO THE STOP. THIS HAS HAPPENED BEFORE AND I'VE TAKEN IT TO THE DEALERSHIP SEVERAL TIMES FOR THIS AND STALLING OUT WHILE ACCELERATING FROM A COMPLETE STOP, AND I WAS TOLD THERE WAS NOTHING WRONG. TODAY THE CAR WOULD NOT STAY STARTED AFTER STARTING 8 TIMES. I STARTED FROM P AND N, BUT ONCE I PUT THE CAR IN D OR S IT WOULD IMMEDIATELY SHUT DOWN. PUTTING THE CAR IN R MADE A HUGE CLUNK. I WAS STUCK AND BLOCKING A HUGE LINE OF TRAFFIC! I AM GOING TO THE DEALER TO FIND OUT WHAT'S GOING WRONG, BUT THIS IS UNACCEPTABLE FOR ANY CAR TO DIE FOR NO REASON. *TR

I WAS MAKING A LEFT TURN ENTERING NORTH BOUND TRAFFIC ON GREENFIELD ROAD SOUTH OF BASELINE ROAD ON WEDNESDAY JANUARY 16, 2013. TRAFFIC WAS VERY HEAVY AND UPON ENTERING TRAFFIC THE ENGINE SUDDENLY BEGAN TO LOOSE POWER, RUN VERY ROUGH. IT SEEMS LIKE ALL OF THE DASH WARNING LIGHTS FLASHED SEVERAL TIMES BEFORE THE ENGINE COMPLETELY DIED. AFTER THE ENGINE DIED, I LOST POWER STEERING AND WAS UNABLE TO SAFELY NEGOTIATE MY WAY TO THE SIDE OF THE ROAD. I WAS ALMOST STRUCK TWO TIMES BEFORE I WAS ABLE TO COAST INTO A PARKING LOT ON EAST SIDE OF GREENFIELD ROAD. THE REPAIR OF THE VEHICLE IS CURRENTLY UNDERWAY. THE FAILURE WAS DUE TO THE HIGH PRESSURE INJECTOR PUMP FAILING, CREATING METAL SHAVINGS THAT CLOGGED AND CONTAMINATING THE ENTIRE FUEL SYSTEM. THE CAR HAS 104,000 MILES ON IT AND THERE WAS NO PRIOR INDICATION OF FUEL SYSTEM PROBLEMS. THE FAILURE WAS CATASTROPHIC. THERE WAS NO OTHER CONTAMINATION OF THE FUEL . *TR

JETTA TDI WAS RUNNING FINE WITH NO INDICATIONS OF ANY PROBLEM. FOLLOWING A ROUTINE OIL CHANGE, THE CAR JUST STOPPED RUNNING AND WOULD NOT RESTART. LOCAL VW DEALER SERVICE MANAGER INDICATES ISSUE IS WITH FUEL PUMP AND ENSUING DEBRIS IN ENGINE. COST TO REPAIR IN EXCESS OF $5,000. VW TO DATE UNWILLING TO ACKNOWLEDGE DEFECT AND CONTRIBUTE TOWARDS COST OF REPAIR, OR SHOW ANY CONCERN FOR THE SAFETY ISSUES THIS SORT OF PROBLEM PRESENTS. *TR

CAR: 2009 VOLKSWAGEN TDI SPORTWAGEN ON DECEMBER 16TH AT APPROXIMATELY 1230PM, I ENTERED INTERSTATE I-95 VIA EXIT 19 IN SOUTHPORT, CT HEADING SOUTHBOUND. AS I ACCELERATED AND MERGED INTO THE LANE FROM THE ONRAMP AS I GOT UP TO SPEED (@60 MPH) THE "GLOW PLUG LIGHT" CAME ON AND THEN THE ENGINE LIGHT CAME ON. THE CAR IMMEDIATELY BEGAN LOSING POWER AND I PULLED OVER TO THE SIDE OF THE VERY BUSY INTERSTATE. IT WAS DANGEROUS AS I LOST POWER AND HAD TO MANEUVER BETWEEN PASSING CARS IN ORDER TO GET TO THE SHOULDER TO PULL OVER. I TURNED OFF THE ENGINE AND LET THE CAR REST FOR A MINUTE OR SO. I TURNED THE ENGINE BACK ON AND THE CHECK ENGINE LIGHT CAME ON AGAIN. I ATTEMPTED TO ACCELERATE AND THE CAR HAD VERY LIMITED POWER SO I IMMEDIATELY STOPPED THE CAR AGAIN AND TURNED OFF THE ENGINE. I GOT OUT OF THE CAR, OPENED THE HOOD, AND NOTICED WHAT APPEARED TO BE GASOLINE COATING THE ENGINE AS WELL AS TRAILING BEHIND THE CAR. I CALLED AAA AND HAD MY CAR TOWED TO THE RIVERBANK VOLKSWAGEN DEALERSHIP IN STAMFORD, CT WHICH WAS CLOSED DUE TO THE FACT THAT IT WAS SUNDAY. THE FOLLOWING DAY I SPOKE WITH THE SERVICE MANAGER AND WAS INFORMED THAT THE CAR WOULD NOT BE LOOKED AT UNTIL FRIDAY DECEMBER DEC 21ST WHEN A "SPECIALIST" FROM VW WOULD ARRIVE TO INSPECT THE CAR. I HAVE PERFORMED MY OWN DILIGENCE AND HAVE FOUND THAT SIMILAR ISSUES WITH THE 2009 JETTA TDI'S HAVE BEEN FAIRLY COMMON AND I EXPECT (HOPE) VW WILL COVER ALL REPAIR AND RENTAL CAR COSTS FOR ME IN THIS MATTER. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF THE ENGINE FAULT WORKSHOP LIGHT. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY ADVISED THAT THE FAILURE COULD HAVE BEEN CAUSED BY A FAILING FUEL PUMP. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 38,000. THE VIN WAS UNAVAILABLE.

WHILE STARTING TO ACCELERATE AFTER A STOP, MY 2009 JETTA TDI SHUDDERED AND DIED WITH A "MAJOR ENGINE FAILURE" ERROR AND WOULD NOT RESTART. THE CAR WAS BLOCKING TRAFFIC AT A MAJOR INTERSECTION. HAD TO HAVE THE CAR PUSHED OUT OF THE TRAFFIC LANE AND THEN WAITED FOR A TOW TRUCK TO TOW IT TO THE LOCAL DEALER. AFTER ONE DAY THEY SAID THE HAD NO IDEA WHAT WAS WRONG WITH IT. ON THE SECOND DAY THE DEALER CALLED TO SAY THAT THEY FOUND THE FUEL PUMP HAD BLOWN APART AND THERE WERE METAL SHARDS THROUGHOUT MY ENTIRE FUEL SYSTEM AND IT WOULD NEED TO BE COMPLETELY REPLACED (APPROX $8-9000 IN REPAIRS). THEY ALSO SAID THAT THE WARRANTY WOULD NOT COVER IT UNLESS I COULD PROVE THAT I ONLY PUT DIESEL FUEL IN SO HAD TO PROVIDE RECEIPTS FOR MY RECENT FUEL PURCHASES AS WELL AS FUEL SAMPLES. STILL WAITING FOR THE WARRANTY COMPANY TO DECIDE WHETHER OR NOT THEY WILL COVER THE REPAIR SO I AM WITHOUT A VEHICLE WHILE THEY HAGGLE. LUCKILY I WAS ALMOST STOPPED WHEN IT HAPPENED OR IT COULD HAVE BEEN A BIGGER SAFETY ISSUE (ALTHOUGH I WAS IN A CAR IN A BUSY INTERSECTION CAUSING A MAJOR TRAFFIC JAM WITH MANY POTENTIAL CRASHES ALL AROUND ME -- THE HONKING HORNS AND SWERVING CARS ATTEST TO THAT -- AS I SAT WAITING TO BE PUSHED OUT OF THE WAY). *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE TRAVELING 60 MPH THE VEHICLE STALLED. THE DRIVER WAS ABLE TO MERGE TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE FUEL SYSTEM HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 90,000. THE VIN WAS NOT AVAILABLE.

WHILE DRIVING DOWN THE ROAD, MY WARNING LIGHT FLASHED A COIL SYMBOL, PULLED THE CAR TO THE SIDE OF THE ROAD AND LOOKED UP THE PROBLEM IN THE MANUAL. BLINKING COIL INDICATED 'DRIVE TO LOCAL SERVICE' SO I TRIED TO CRANK THE CAR, WHICH STARTED. BEGAN TO DRIVE, BUT AS I APPROACHED A HILL AND INTERSECTION THE VEHICLE BECAME SLUGGISH AND SLOW. UPON BRAKING AT INTERSECTION, THE VEHICLE SHUT OFF. I WAS IN THE CAR WITH THREE OF MY FOUR CHILDREN, THE OLDEST IS 17 AND HAS A DL, SO I PUT HER IN THE DRIVERS SEAT AND MY 12 YEAR OLD AND I PUSHED THE CAR OUT OF THE INTERSECTION TO AVOID COLLISION. CALLED DEALERSHIP, THEY SAID TOW IT IN, AND I HAVE EXTENDED WARRANTY TO COVER DEFECTS. THE NEXT DAY I AM TOLD THAT THERE IS BAD FUEL, NOT GASOLINE BUT SWEET SMELLING DIESEL.( SC IS RUNNING CARS ON BIODIESEL WHICH HAS A SWEETER SMELL), WARRANTY COMPANY SENDING INSPECTOR. HIS REPORT SAYS HE SMELLED GASOLINE, BUT TECH SAYS IMPOSSIBLE AS THE VEHICLE WOULD NEVER HAVE GONE 450 MILES ON GASOLINE BEFORE THIS MALFUNCTION. WE FEEL THAT VW IS TRYING TO HIDE THE PROBLEM UNDER THE GAS COMPANIES AND AVOID MAJOR COST. STARING AT $8000 REPAIR BILL FOR A CAR NOW WORTH $12K. WE CANNOT AFFORD THIS KIND OF EXPENSE AS I AM SURE MOST CONSUMERS IN AMERICA WOULD CONCEDE. WE HAVE READ AND DOCUMENTED MANY CASES WHERE VW HAS REPAIRED THIS PROBLEM IN OR OUT OF WARRANTY BECAUSE OF THE DEFECTIVE PART. FEEL THAT THIS IS JUST NOW AN ISSUE WITH THE FUEL, THEY KNEW THE STANDARDS FOR HIGHWAY DIESEL WHEN THEY PUT THE PART IN THE CAR, SHOULDN'T HAVE SOLD IT IF IT WOULD NOT STAND UP TO THE PRESSURE. WILL NOT ACCEPT THIS AS OUR FAULT. CANNOT ACCEPT THIS AS OUR FAULT. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE VEHICLE STALLED AND FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER, WHO DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE FAILURE AND THE CURRENT MILEAGE WAS 87,000.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH THE VEHICLE SUDDENLY STALLED AND AN ENGINE MALFUNCTION MESSAGE DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP BROKE APART INTERNALLY AND THE METAL SHAVINGS FROM THE FUEL PUMP WERE FOUND THROUGHOUT THE FUEL SYSTEM. AS A RESULT, ALL FUEL RELATED COMPONENTS NEEDED TO BE REPLACED. THERE WAS AN INVESTIGATION UNDER NHTSA ACTION NUMBER: EA11003 (FUEL SYSTEM, DIESEL) THAT MAY BE RELATED TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 72,000.

WHILE DRIVING AT 50 MPH, MY VEHICLE STOPPED ACCELERATING AND RPM WOULD NOT INCREASE ABOVE 2000RPM. THE GLOW PLUG AND CHECK ENGINE WARNING LIGHTS BOTH CAME ON. THIS ALMOST RESULTED IN AN ACCIDENT. I AVOIDED BEING HIT BY A LARGE TRUCK WHILE I WAS STALLED IN THE CENTER LANE OF A HIGHWAY. I HAD MY VEHICLE TAKEN TO THE DEALERSHIP FOR REPAIR. THE DEALERSHIP REPLACED THE FUEL RAIL SWITCH, BUT THE SAME ISSUE OCCURRED IN JUNE 2012, JULY 2012, AND AUGUST 2012. THIS APPEARS TO BE AN ISSUE RELATED TO THE HPFP (FUEL PUMP). I AM NOT VERY SATISFIED WITH THE VW DEALERSHIP'S INABILITY TO CORRECT THIS ISSUE. I LOSE FUEL PRESSURE ON A REGULAR BASIS WHICH CAUSES SAFETY CONCERNS WHILE MERGING INTO TRAFFIC. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE BUT IT WOULD NOT RESTART. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN STATED THE FUEL SYSTEM WOULD HAVE TO BE REPLACED BECAUSE IT BECAME CONTAMINATED BY THE FUEL PUMP. THERE WAS AN INVESTIGATION UNDER NHTSA ACTION NUMBER: EA11003 (FUEL SYSTEM, DIESEL) THAT COULD HAVE BEEN RELATED TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 114,000. UPDATED 09/18/12*LJ UPDATED 09/19/2012 *JS

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE MADE A LOUD BUZZING NOISE WITH THE ILLUMINATION OF THE INSTRUMENT PANEL WARNING LIGHTS. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE FUEL PUMP FAILED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT WAS DRIVING 45 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE HIGH PRESSURE DIESEL FUEL PUMP FAILED. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS TRADED DUE TO THE DEFECT. THE FAILURE AND CURRENT MILEAGES WERE 111,000.

DRIVING AT LOW SPEED IN THE CITY, WHEN A ENGINE FAILURE WARNING DISPLAYED AND THE VEHICLE STARTED RUNNING ROUGH. TOOK IT TO THE DEALERSHIP AND WAS TOLD THAT THE HIGH PRESSURE FUEL PUMP FAILED SENDING METAL SHARDS THROUGHOUT THE FUEL SYSTEM. THIS HAS APPARENTLY TRIGGERED REPLACEMENT OF THE ENTIRE FUEL SYSTEM FROM THE PUMP TO THE ENGINE. AFTER RESEARCHING THIS ONLINE, I HAVE FOUND THAT THIS IS A KNOWN ISSUE. TO MY KNOWLEDGE THE HPFP'S HAVE NOT BEEN RECALLED. VW AND YOUR WEBSITE SO FAR STATES THAT THE PROBLEM IS A FUEL CONTAMINATION ISSUE, BUT I HAVE ONLY BOUGHT DIESEL FROM MURPHY USA I CONFIRMED THIS WITH RECEIPTS. ( A HIGH VOLUME DEALER IN MY AREA). THE DEALERSHIP STATES THAT THE REPAIR SHOULD BE COVERED EVEN THOUGH THE WARRANTY HAS EXPIRED. THIS IS SUSPECT TO ME. EITHER OUR FUEL STANDARDS ARE NOT PAR WITH THE REST OF THE WORLD AND NEED FURTHER REGULATION OR THE PUMPS NEED TO BE RECALLED. BUT A CAR DESIGNED TO SAVE MONEY BY CONSERVING FUEL IS NOT DOING THAT IF THE 27000 DOLLAR CAR NEEDS 10000 DOLLARS OF WORK. *TR

DRIVING VEHICLE THEN LOSS OF ALL POWER. HIGH PRESSURE FUEL PUMP FAILURE. *TR

THIS IS A VW JETTA 2009 TDI WITH 74,200 MILES. I HAVE BEEN THE ONLY OWNER. VEHICLE SUDDENLY LOST POWER AND BLACK SMOKE CAME FROM EXHAUST, RED LIGHTS ON DASHBOARD CAME ON WITH ERROR MESSAGE "ENGINE FAILURE". TECHNICIAN AT VW DEALER FOUND THE TURBO CHARGER HAD AN INTERNAL FAILURE. THE FAULTY TURBO PUMPED OIL THROUGHOUT THE EXHAUST SYSTEM INTO THE CAT CONVERTERS, AND HOSES. ALL WOULD NEED TO BE REPLACED AND COSTS $7,200. *TR

VEHICLE STALLED WITHOUT WARNING IN THE MIDDLE OF AN INTERSECTION DURING FRIDAY AFTERNOON RUSH HOUR TRAFFIC AND WOULD NOT RESTART, NEARLY CAUSING MULTIPLE ACCIDENTS. DASHBOARD BRIEFLY FLASHED "ENGINE MALFUNCTION WORKSHOP" AND THE GLOW PLUG LIGHT ILLUMINATED PRIOR TO FAILURE. HAD VEHICLE TOWED TO JIM ELLIS VW IN CHAMBLEE, GA FOR DIAGNOSIS. DEALERSHIP CALLED WITH A DIAGNOSIS OF A FAILED HIGH PRESSURE FUEL PUMP AND STATED THAT THE ENTIRE FUEL SYSTEM WOULD NEED TO BE REPLACED DUE TO METAL SHAVINGS FOUND THROUGHOUT THE SYSTEM. ADVISED THAT REPAIRS WOULD NOT BE COVERED UNDER EXISTING 5-YEAR/60,000 MILE POWERTRAIN WARRANTY, CLAIMING THAT THE FUEL SYSTEM WAS SOMEHOW EXEMPT FROM WARRANTY COVERAGE, AND ESTIMATED $8700 TO FIX THE CAR. I CALLED VOLKSWAGEN OF AMERICA TO REPORT THE INCIDENT AND QUESTION WHY THE MANUFACTURER'S WARRANTY WOULD NOT COVER AN OBVIOUS DEFECT IN THE CAR; THEY EVENTUALLY AGREED TO COVER THE FULL COST OF REPAIRS UNDER WARRANTY. VEHICLE WAS REPAIRED WITHIN A WEEK, BUT IS NOW BACK AT JIM ELLIS VW FOR FURTHER EVALUATION AFTER THE SAME "ENGINE MALFUNCTION WORKSHOP" AND GLOW PLUG LIGHT ILLUMINATED AGAIN ONLY 30 MILES AFTER THE REPAIRS. PLEASE COMPEL VOLKSWAGEN TO RECALL THIS CLEARLY UNSAFE VEHICLE AND FIGURE OUT WHY THEIR HIGH PRESSURE FUEL PUMPS ARE FAILING CATASTROPHICALLY AT SUCH HIGH RATES AROUND THE COUNTRY. *JS

VEHICLES CHECK ENGINE LIGHT CAME ON AND LOSS OF POWER DIED IN MIDDLE OF ROAD TOWED TO DEALERSHIP AND IT WAS COVERED FOR WARRANTY THEY REPLACED THE WHOLE FUEL SYSTEM DUE TO CONTAMINATION, NOW NOT EVEN A YEAR LATER LESS 15,000 MILES THEY LOSS OF POWER AGAIN, DEALERSHIP HAS HAD MY CAR FOR 2 WEEKS THEY DIDN'T KNOW WHETHER OR NOT THEY WERE GOING TO WARRANTY IT THEY SAID IT HAD A FAILED FUEL INJECTOR. STILL DO NOT HAVE CAR BACK.IM BEGINNING TO WONDER IF THERE WASN'T MORE WRONG THAN JUST A FUEL INJECTOR, MAYBE THE HIGH PRESSURE FUEL PUMP WAS AT FAULT A SECOND TIME, AND THEY JUST DIDN'T WANT TO TELL ME. *JS

I WAS DRIVING UP A HILL IN A NEIGHBORING TOWN AND MY CAR LOST ALL POWER ALMOST INSTANTLY. MY ""MDF" READ "ENGINE FAULT WORKSHOP" AND MY GLOW PLUG LIGHT (SINCE THIS IS A DIESEL POWERED VEHICLE) STARTED RAPIDLY FLASHING. I WAS ABLE TO SHIFT THE CAR TO NEUTRAL AND COAST TO THE TOP OF THE HILL, THEN ONCE REACHING THE APEX OF THE HILL, COAST INTO A GROCERY STORE PARKING LOT. MY CAR WAS COMPLETELY DEAD, AND I HAD TO TOW IT TO THE DEALER. *JS

WHILE REPLACING FUEL FILTER CARTRIDGE I FOUND METAL SHAVINGS IN THE FILTER HOUSING. THE NEXT WILL BE HIGH PRESSURE FUEL PUMP FAILURE WITH THE HEAVY FUEL SYSTEM CONTAMINATION BY METAL SHAVINGS AS PER COMMON SCENARIO. SHOULD BE NOT PLEASANT EXPERIENCE. VW SHOULD CONCENTRATE ON FUEL FILTER/SYSTEM ROUTINE CHECK UP AND OFFER PREVENTIVE MAINTENANCE. *JS

HIGH PRESSURE FUEL PUMP FAILED AT 52000 MILES. THE ENTIRE FUEL SYSTEM WAS REPLACED WITH A WARRANTY ON PARTS OF 12000 MILES. AFTER 15000 MILES I EXPERIENCED ISSUE WITH HIGH PRESSURE FUEL PUMP AGAIN. THE FUEL LINE FROM HIGH PRESSURE PUMP TO FUEL RAIL WAS REPLACED. *TR

TL * THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA SPORTWAGEN TDI. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE FUEL PUMP WAS UNABLE TO PUMP FUEL INTO THE SYSTEM AND AS A RESULT, THE FUEL PUMP WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 45,000.

GLOW PLUG LIGHT AND ENGINE FAULT WORKSHOP LIGHT CAME ON AS I WAS PULLING INTO WORK IN A.M. PARKED AND RESTARTED VEHICLE, WITH NO FURTHER WARNING LIGHTS. I MADE APPOINTMENT FOR SCHEDULED MAINTENANCE WITH DEALER. WHEN I LEFT FOR HOME THAT EVENING THE VEHICLE STARTED OK WITH NO WARNING LIGHTS. WHILE DRIVING DOWN THE INTERSTATE FREEWAY AT 70 MPH THE SAME WARNINGS SUDDENLY CAME BACK ON AND VEHICLE SUFFERED IMMEDIATE DECREASE IN POWER WITH SPEED DOWN TO ABOUT 50 MPH. I EXITED THE INTERSTATE AND TRIED TO MAKE IT TO THE VW DEALERSHIP, BUT ENGINE SHUT DOWN WHEN I STOPPED AT STOP SIGN AND WOULD NOT RESTART. VEHICLE WAS PUSHED TO THE ROADSIDE BY STATE POLICE AND HAD TO BE TOWED. VW MECHANIC FOUND THAT THE HIGH PRESSURE FUEL PUMP HAD FAILED WITH EXCESSIVE METAL SHAVINGS FOUND THROUGHOUT THE FUEL SYSTEM. A DIESEL FUEL SAMPLE WAS SENT FOR TESTING AND WAS OKAY. DEALER HAD TO REPLACE THE ENTIRE FUEL SYSTEM. *TR

CAR WOULD NOT START. LUCKILY PARKED IN GARAGE. TOWED TO DEALER. DETERMINED TO BE HPFP FAILURE AND DPF FAILURE. HPFP AND DPF REPLACED ALONG WITH ASSOCIATED SMALL PARTS. BUT DID NOT REPLACE ENTIRE FUEL SYSTEM. A FUEL SAMPLE TAKEN FROM THE FUEL RETURN HOSE WHEN THE CAR DIED LOOKS LIKE FINE METALLIC PARTICLES. SETTLED TO THE BOTTOM OF THE JAR AFTER SEVERAL DAYS. A MAGNET DID NOT ATTRACT THE PARTICLES SO MUST HAVE BEEN ALUMINUM - MOST LIKELY FROM THE PISTON BORE OF THE HPFP. VW PAID FOR THE REPAIR. THE DAY I GOT THE CAR BACK I TOOK A FUEL SAMPLE FROM THE FUEL TANK. ONCE AGAIN METAL PARTICLES (ALONG WITH OTHER DEBRIS NORMALLY FOUND IN A FUEL TANK) WERE FOUND. NOW WE ARE FEARFUL OF DRIVING THE CAR DUE TO METAL PARTICLES IN THE FUEL SYSTEM WILL DESTROY THE NEW HPFP. PLEASE MAKE VW DO A RECALL AND REPLACE THE PUMP WITH A NEW DESIGN THAT WILL NOT SELF DESTRUCT! A CAR THAT SHOULD GO 200K MILES OR MORE HAS FAILED AT 67K MILES. AND IS GUARANTEED TO FAIL AGAIN DUE TO THE POOR DESIGN OF THE HPFP. THIS IS A HUGE FINANCIAL HIT FOR OUR FAMILY AS NOW WE ARE FEARFUL OF DRIVING THE CAR AND MAY HAVE TO SELL IT TO GET A MORE RELIABLE CAR. VW IS BLAMING THE PROBLEMS ON FUEL CONTAMINATION AND THAT MAY BE TRUE BUT THERE IS NO EXCUSE FOR A HUGE REPAIR BILL FROM ONE TANK OF FUEL THAT IS NOT UP TO SPECS. *TR

I WAS DRIVING THE VEHICLE WHEN THE GLOW PLUG LIGHT ON THE DASH BEGAN FLASHING, THEN THE COMPUTER DISPLAYED ENGINE FAULT, CONTACT WORKSHOP, THEN THE CHECK ENGINE LIGHT CAME ON AND THE CALL STALLED IN THE MIDDLE OF AN INTERSECTION AND HAD TO BE PUSHED TO THE SIDE OF THE ROAD. THE CAR WOULD NOT START AGAIN. *TR

I CONTACTED VW MID-AUGUST 2011 BECAUSE MY CAR BROKE DOWN WHILE I WAS DRIVING AND THEN I COULD SMELL GAS. I HAD IT TOWED TO VW AND THERE WAS A PROBLEM WITH A LEAK IN THE FUEL RAIL. ALL FOUR FUEL INJECTORS HAD TO BE REPLACED, AS WELL AS THE GASKETS, FUEL RAIL, AND SPARK PLUGS. THIS REPAIR COST ME APPROXIMATELY $1,100.00. I HAVE ENCLOSED A COPY OF MY BILL SHOWING THE REPAIRS DONE AND TOTAL COST OF REPAIRS. WHEN I CONTACTED VW IN MID-AUGUST I WAS INFORMED BY THEM THAT THERE ARE NO PROBLEMS WITH THE JETTA FUEL INJECTORS AND THAT IT IS NOT THEIR FAULT THAT I HAVE THE A LEMON OF THE BUNCH. VERY POOR CUSTOMER SERVICE SKILLS WITH ALL VW PERSONAL I HAVE SPOKEN WITH. I NOW ENCLOSE THE RECENT ARTICLES ABOUT THE FUEL INJECTOR PROBLEMS WITH THE VW VEHICLES. FOR SOME REASON THIS RECALL ONLY INCLUDES THE DIESEL ENGINES-WHICH CLEARLY SHOULD NOT BE THE CASE. I AM REQUESTING REIMBURSEMENT FOR THIS REPAIR AS IT IS RELATED TO THE SAME PROBLEMS VW IS HAVING WITH THE DIESEL-ENGINES PER THE ENCLOSED VW ARTICLE ON RECALLS. THIS VEHICLE SHOULD ALSO BE INCLUDED IN THE RECALL. *KB

WHILE DRIVING HOME THE VEHICLE WENT INTO A LIMP MODE, ONCE I MADE IT HOME, THE VEHICLE WOULDN'T START. I FELT IT WASN'T GETTING FUEL, SO I DECIDED TO TAKE IT TO THE VW SHOP I BOUGHT IT FROM. THEY CALLED ME A WEEK LATER STATING IT IS 6600 DOLLARS IN PARTS AND 1600 IN LABOR. I CALLED VW CUSTOMER CARE THEY FINALLY DECIDED TO PAY FOR PARTS. I HAVE SINCE PAID THE LABOR TO REPAIR THE VEHICLE. AFTER READING ONLINE THE COMMONALITY OF THIS PROBLEM SEEMS THE VEHICLE HAS AN ISSUE. WHAT HAPPENS WHEN IT HAPPENS AGAIN I PAY THE FULL AMOUNT.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT NOTICED RUST IN THE FUEL FILTER AND PUMP CAUSING THE FUEL SYSTEM TO FAIL. ALSO, THE CHECK ENGINE LIGHT WOULD ILLUMINATE THEN VEHICLE WOULD SUDDENLY STALL WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER AND THE CONTACT WAS AWAITING A RESPONSE. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE CURRENT MILEAGE WAS 35,700. THE FAILURE MILEAGE WAS 35,680. THE VIN WAS UNAVAILABLE.

DRIVING TO THE NEIGHBORHOOD POST OFFICE, THE CAR STALLED WITH THE GLOW PLUG LIGHT COMING ON AS WELL AS "ENGINE FAULT" BEING DISPLAYED ON THE DISPLAY. THE CAR WOULD NOT START AND WAS TOWED TO THE DEALERSHIP. IT WAS DETERMINED THE FUEL PUMP FAILED AND METAL PARTICULATES WERE FOUND THROUGHOUT THE FUEL SYSTEM. DEALERSHIP REPLACED PUMPS, HOSES, AND CLEANED OUT OTHER PARTS FUEL MAY HAVE TOUCHED (I.E.,FUEL TANK) AND COVERED THE WORK UNDER WARRANTY. THE SERVICE MANAGER INFORMED ME IT WAS OVER $4,000 WORTH OF PARTS ALONE. HE DID CONFIRM THE FUEL PUMP IS COVERED UNDER THE POWERTRAIN WARRANTY.

TL*THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA TDI. WHILE STOPPED AT AN INTERSECTION, THE CONTACT ATTEMPTED TO ACCELERATE FORWARD BUT THE ENGINE STALLED AND HE WAS UNABLE TO MOVE. THE VEHICLE WAS TOWED TO THE DEALER WHERE THEY PERFORMED A DIAGNOSTIC TEST WHICH CONFIRMED THAT THE HIGH PRESSURE FUEL PUMP HAD FAILED; THE VEHICLE WAS REPAIRED. THE CURRENT MILEAGE WAS 37,500 AND THE FAILURE MILEAGE WAS 27,450.

WHILE ON CRUISE CONTROL ON I-55 TRAVELING AT 65 MPH GLOW PLUG LIGHT ILLUMINATED, MFD MESSAGE "ENGINE FAILURE WORKSHOP" APPEARED AND ENGINE DIED. ELECTRICAL POWER WAS NEVER LOST. PRIOR TO COASTING TO A STOP ON THE SHOULDER, MFD MESSAGE WENT AWAY. AFTER COASTING TO A STOP TRIED TO RESTART ENGINE, STARTER COULD BE HEARD BUT ENGINE WOULD NOT START. VW SERVICE DEPARTMENT DETERMINED "MECHANICAL INTERNAL FAULT IN HIGH PRESSURE FUEL PUMP. METAL FRAGMENTS FOUND THROUGHOUT FUEL SYSTEM. DIESEL FUEL, MOSTLY FROM INTERSTATE HIGHWAY GAS STATIONS AND STANADYNE DIESEL FUEL ADDITIVE PURCHASED FROM VW DEALERS USED ON EVERY REFILL. ENGINE HAD 37,862 MILES AND WAS PURCHASED NEW FROM A DEALER 23 MONTHS AGO. VW REPLACED THE ENTIRE FUEL SYSTEM.

GLOW PLUG LAMP STARTED BLINKING; RECEIVED ERROR MESSAGE - "ENGINE FAULT". BROUGHT CAR IN FOR SERVICE WHICH TOOK 4 DAYS. APPROXIMATELY TWO WEEKS LATER, THE GLOW PLUG LAMP STARTED BLINKING AGAIN AND THE SECOND TIME, THERE WAS AN ERROR MESSAGE THAT SAID "ENGINE FAULT WORKSHOP!" BROUGHT CAR IN FOR SERVICE AGAIN AND IT REMAINED WITH VOLKSWAGEN FOR 5 WEEKS. I WAS TOLD THAT THE ENTIRE DIESEL FUEL PUMP SYSTEM WAS FAILING AND HAD BEEN CONTAMINATED. VOLKSWAGEN IMPLIED THAT THEY THOUGHT I HAD RECEIVED BAD GAS, BUT I AM EXTREMELY CAREFUL ABOUT MAINTAINING AND FUELING THIS CAR AND CAN SAY WITH 100% CONFIDENCE THAT IT HAS ONLY RECEIVED LOW SULFUR DIESEL FROM REPUTABLE AREA GAS STATIONS. THE FUEL SYSTEM FAILURE DID NOT RESULT IN A CRASH - THIS TIME - BUT IT IS ALSO JUST THE LATEST IN A LONG LINE OF EXTENSIVE PROBLEMS THE CAR HAS HAD SINCE IT WAS PURCHASED NEW, INCLUDING STALLING, ELECTRICAL FAILURES, TRANSMISSION FAILURES, EXTENSIVE LEAKAGE, WATER DAMAGE AND OTHER PROBLEMS.

I UNDERSTAND THAT YOU ARE CURRENTLY DOING AN INVESTIGATION ON THE 2009 JETTA TDI FOR STALLING ISSUES. WHILE MY CAR IS NOT A DIESEL, I HAVE HAD SIMILAR PROBLEMS. THREE TIMES NOW WHILE DRIVING MY CAR HAS SUDDENLY HAD THE RPMS SHOOT UP AND THE CAR STALLS OUT. I HAVE BROUGHT IT IN TO THE SERVICE CENTER ALL THREE TIMES AND GIVEN DIFFERENT REASONS FOR THIS SAME ISSUE, DIFFERENT FIXES, AND THE PROBLEM REMAINS. I USE THIS CAR TO TRANSPORT MY SON AND I LONG DISTANCES FOR OUR DAILY COMMUTE OVER THE INTERSTATE. THIS CAR IS NOT SAFE. PLEASE LOOK INTO THE 2009 WOLFSBURG ALONG WITH YOUR INVESTIGATION OF THE TDI. SOMETHING NEEDS TO BE DONE AND QUICKLY. THIS HAS BECOME A VERY FRIGHTENING VEHICLE TO BE STUCK WITH. IT WAS PURCHASED NEW AND HAS ONLY 28,000 MILES. THIS IS A MANUFACTURE DEFECT. THESE PROBLEMS SHOULD NOT OCCUR ON A TWO YEAR OLD CAR. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT WAS TRAVELING 60 MPH WHEN THE FUEL FILTER LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT ALL THREE FUEL FILTERS HAD FAILED. THE CONTACT STATED THAT THE ENGINE EXPLODED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 40,600.

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) [XXX] . (DEAF AND SIGN LANGUAGE) AND [XXX] ( DEAF AND SIGN LANGUAGE), AND WE TRADED THE 2008 TOYOTA, CAMRY TO LEASE VOLKSWAGEN 2009 JETTA WITH GASOLINE ENGINE LAST JUNE, AND WE HAVE NOT BEEN HAPPY, BECAUSE, NOT SMOOTH RIDE, BETWEEN 35 AND 50 MILE PER MILE, AND, ALSO, NOT SMOOTH RIDE BETWEEN 70 AND 84 MILE PER HOUR, EVEN, ROTATION TIRE AND BALANCE TIRE THIRD OR FOURTH TIME, ... STILL, NOT SMOOTH RIDE, EVEN THE MILE PER GALLON'S POOR, AND MANY. ... THE VOLKSWAGEN DEALERS IN MASSACHUSETTS AND FLORIDA, THEY HAVE BEEN FIXING, AND, STILL, NOT SMOOTH RIDE, MILE PER GALLON'S AND ETC. ... [XXX] AND I HAVE BEEN FED UP. ... EVEN, I DROP OFF MY CAR AT THE TRACY VOLKSWAGEN SHOP IN HYANNIS, MASSACHUETTS, ... EVEN, AT THE ALDEN VOLKSWAGEN SHOP IN FAIRHAVEN, MASSACHUSETTS, AND, ALSO, THE WALLACE VOLSKWAGEN SHOP IN STUART, FLORIDA OCCASIONALLY, ... AND, ... HAPPENED, [XXX] , SERVICE ADVISOR AND JEFF HAW, SUPERVIOR AND/OR MANAGER SERVICE ADVISOR AT WALLACE VOLKSWAGEN IN STUART, FLORIDA, THEY ADVISED ME TO VISIT A FIRESTONE STORE AND REQUEST THEM TO REPLACE THE FOUR TIRES. ...AND, SO, I WENT TO SEE A FIRESTONE TIRE STORE A FEW BLOCKS AWAY FROM WALLACE VOLKSWAGEN DEALER IN STUART, FLORIDA, AND THE FIRESTONE TIRE STORE, THEY SAID, THE TIRES ARE NOT WARRANY, CANNOT REPLACE A TIRE, EVEN A FOUR TIRE AND AT ALL. SO, I REQUEST YOU, TO TELL VOLKSWAGEN COMPANY, HEADQUARTER, TO REPLACE A NEW JETTA WITH DIESEL WITH MICHELIN TIRES AND $250.00 PAYMENT MONTHTLY AND NO DOWN PAYMENT INCLUDING WAIVE EARLY TERMINATE PENTALY, AND, ANY, AND, ANYTHING, AND, ALL, BECAUSE I HAVE NOT BEEN HAPPY AND NOT ENJOY WITH THE NEW LEASE 2009 VOLKSWAGEN WITH GASOLINE. [XXX] P.S. PLEASE TRANSFER US TO PROPERLY TO THE DEPERATURE AND FILE A COMPLIANT AT FEDERAL GOVERMENT, NOT STATE GOVERNMENT IF WE FILE A COMPLIANT A FILE AT WRONG U.S. DEPT. OF NHTS.GOV. *TR

2009 JETTA WITH 7100 MILES FAILED TO ACCELERATE AND THEN DIED. THIS HAPPENED INTERMITTENTLY 3 TIMES DURING A ONE WEEK PERIOD. THE CAR COULD BE RE-STARTED AFTER THE FAILURE BUT THEN DIED AGAIN. IT ACTED AS IF IT WAS NOT GETTING GAS. I FINALLY HAD IT TOWED TO VW DEALERSHIP BECAUSE I DIDN'T TRUST THAT IT WOULD NOT DO THIS WHILE ACCELERATING ON THE FREEWAY. VW DETERMINED THAT IT HAD A FAULTY FUEL PRESSURE REGULATOR. *TR