2010 Ram 1500 Engine Problems

Your engine shut off while you were driving, and now the check engine light is on and the car won't start again. You believe the timing chain may have failed. This typically requires replacing the timing chain and related components to get your engine running again.

Your truck is shutting off unexpectedly while slowing down or approaching stops, which happens several times while driving. When this occurs, your power steering and brakes stop working, making the vehicle difficult to control—you then have to put it in neutral and restart it. The truck restarts without any issues and runs normally after each incident. Diagnosing this stalling problem may involve checking the fuel system, ignition system, or engine sensors.

Failure in cam and lifters, this am I going problem that needs to be addressed. These repairs should be covered 100% by Dodge / Ram.

vehicle has 113,000 miles on it now, the engine is knocking so I brought it in to Weber in Detroit Lakes Minnesota they say it needs cams and lifters e c t. Estimate is $5,000 or new engine $9,000 so now I can't get to work! I commute back and forth every day 70 miles each way, this vehicle should not have this problem as of yet in my eyes! Will the factory / dealership warranty this fix for me? I purchased vehicle from Weber in Detroit Lakes almost four years ago with 80,000 miles on it I have only driven at 33,000 miles since then!! I don't have that kind of money for this fix nor can I afford to buy a replacement vehicle but now the knocking you can hear it outside the vehicle but you cannot hear it in the cab of the vehicle so how long has this problem actually been going on before the fact of me noticing it just very recently so then I quit driving it immediately and brought it directly to Weber as per appointment

TL* THE CONTACT OWNS A 2010 RAM 1500. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE LOSS MOTIVE POWER AND STALLED WITHOUT WARNING. THE CONTACT HAD TO PUT THE VEHICLE IN NEUTRAL TO ATTEMPT TO RESTART THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE WOULD START INTERMITTENTLY, AS WELL AS MAKE AN ABNORMAL CRACKING SOUND WHILE DOING SO. THE CONTACT TOOK THE VEHICLE FEDERICO CHRYSLER DODGE JEEP RAM (1875 E EDWARDSVILLE RD, WOOD RIVER, IL 62095, (618) 254-1000) HOWEVER, THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 7,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2010 RAM 1500. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE SHOOK AND VIBRATED WITH THE ELECTRONIC THROTTLE CONTROL WARNING LIGHT DISPLAYED ON THE INSTRUMENT PANEL. THE CONTACT REPLACED THE ENGINE COIL PACKS HOWEVER, THE FAILURES RECURRED WITH THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE NUMBER 5 CYLINDER WAS DEFECTIVE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 150,000.

THE LIFTERS AND CAM HAVE FAILED, BASED ON THE INFORMATION YOU CAN GATHER ONLINE THESE DAYS- SEEMS TO BE A DESIGN FACTOR AND DOES NOT MATTER HOW WELL YOU TAKE CARE OF YOUR ENGINE (MAINTENANCE) THIS WILL EVENTUALLY HAPPEN! THIS WORK/PARTS SHOULD BE REPLACED AT NO COST (RE-CALL) TO THE VEHICLE OWNER. I HAVE NOT MADE THE REPAIRS DUE TO THE LACK OF FUNDS FOR THE REPAIR. *TR

I WAS DRIVING THE TRUCK FOR 30 MINUTES I PARK THE TRUCK ACROSS FROM DEPARTMENT STORE I COMEBACK TRYING TO START AND DOESN'T MAKE A SOUND LIGHTS AND EVERYTHING WORK JUST FINE I DID TRY A NEW BATTERY AND STILL DON'T MAKE A NOISE. *TR

WHILE TRACING THIS ANNOYING TICKING NOISE DOWN I NOTICED IT COMING FROM THE EXHAUST MANIFOLD. I LOOKED AROUND IT AND SAW THAT TWO BOLTS WERE LOOSE AND BROKEN INSIDE THE BLOCK. I SEARCHED THIS UP ONLINE AND SEEN THAT MANY PEOPLE ARE HAVING THIS ISSUE. PLEASE HELP *TR

TL* THE CONTACT OWNS A 2010 DODGE RAM 3500. THE CONTACT STATED THAT THE EVAPORATOR CORD BECAME LOOSE AND THE AIR CONDITIONER LEAKED COOLANT INTO THE VEHICLE FROM THE VENTS. THE VEHICLE WAS TAKEN TO MAGUIRE DODGE (959 HIAWATHA BLVD W, SYRACUSE, NY 13204, (315) 487-6211) WHERE IT WAS DIAGNOSED THAT A NEW COMPRESSOR AND THE EVAPORATOR NEEDED TO BE INSTALLED. THE COMPRESSOR WAS REPAIRED, BUT NOT THE EVAPORATOR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000. *BF *TR

EXHAUST MANIFOLD BOLTS INFERIOR! HEARING A TICKING SOUND, MUCH LIKE A TAPPET, I TOOK MY VEHICLE TO MORLAN DODGE IN CAPE GIRARDEAU, MO. THEY EXAMINED THE PROBLEM AND SAID IT IS PROBABLY DUE TO THE BOLTS USED, LOOSENING UP OR EVEN BREAKING. FURTHER INSPECTION IS NEEDED. MY TRUCK HAS 54002 MILES ON IT. DEALER IN CAPE GIRARDEAU SAYS IT HAS SEEN THIS PROBLEM BEFORE DUE TO MANIFOLD BOLTS CAUSING LEAKS. 54,000 MILES AND THE BOLTS ARE FAILING?? AND NO RECALLS TO REPLACE THEM??? WHY NOT? THE BOLTS ARE SAID TO BE OF LOW QUALITY ALUMINUM ALLOY. ?? WHY HAVEN'T THE COMPANY ISSUED A RECALL TO REPLACE THESE DEFECTIVE BOLTS???

5.7 HEMI ENGINES ARE WEARING CAMS OUT. THE LIFTERS ARE SIEZING UP AND WEARING THE LOBES OFF THE CAM. THE TRUCK LOOSES POWER WHEN DRIVING UNTIL I CAN AFFORD TO REPLACE THE ENGINE. THIS HAPPENING WITH ALL 5.7 ENGINES DODGE KNOWS THERE IS A PROBLEM BUT OFFERS NO HELP. I AM ON FIXED INCOME ALWAYS TAKEN CARE OF MY TRUCK. I FEEL THAT IF DODGE KNOWS THERE'S A PROBLEM THEY SHOULD HELP OUT .

TL* THE CONTACT OWNS A 2010 RAM 1500. WHILE THE ENGINE WAS RUNNING, AN ABNORMAL TICKING NOISE WAS HEARD FROM BOTH FRONT WHEELS. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE MANIFOLD STUD FAILED AND NEEDED TO BE REPLACED. THE PASSENGER SIDE MANIFOLD WAS REPAIRED, BUT THE FAILURE RECURRED. THE DEALER (LILLISTON CHRYSLER DODGE, 1501 N SECOND ST, RTE 47, MILLVILLE, NJ 08332, (856) 825-1937) WAS CONTACTED TO SCHEDULE A DIAGNOSTIC APPOINTMENT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT A SECOND DIAGNOSTIC TEST NEEDED TO BE PERFORMED. THE FAILURE MILEAGE WAS 87,268.

TRUCK HAS SHUT OFF AT LOWER SPEEDS WHILE TURNING TWICE IN 30 DAYS. VERY SCARY AND SERIOUS POTENTIAL FOR ACCIDENT. TRUCK HAS 114K MILES

I WAS INFORMED BY THE CHRYSLER DEALER THAT MY VEHICLE WOULD NOT PASS SAFETY INSPECTION. THE REASON FOR THE FAILURE WAS BECAUSE OF EXHAUST MANIFOLD BOLTS THAT HAVE BROKEN, THEREFORE THE SEAL BETWEEN THE MANIFOLD AND THE ENGINE HAD BEEN COMPROMISED. MY VEHICLE HAS ONLY 60000 MILES ON IT. AFTER FURTHER RESEARCH IT IS EVIDENT THAT THIS IS A KNOWN ISSUE WITH MY VEHICLE AND ENGINE COMBINATION. THERE ARE VAST AMOUNTS OF COMPLAINTS CONCERNING THIS EXACT ISSUE AND HOW TO REMEDY THIS DESIGN FLAW. I ATTEMPTED TO REACH OUT TO CHRYSLER SO THEY COULD PERFORM A GOODWILL GESTURE REPAIR. MY ATTEMPT WAS DENIED, WITH NO EXPLANATION AS TO WHY. THE ISSUE WITH THE EXHAUST MANIFOLD BOLTS BREAKING CREATES A SERIOUS SAFETY AND ENVIRONMENTAL CONCERN, AND CHRYSLER IS AT FAULT AND NEEDS TO TAKE RESPONSIBILITY FOR USING INFERIOR BOLTS OR IMPROPER ENGINEERING TECHNIQUES. THE EVIDENCE IS CLEAR, AND WHILE COSTLY, CHRYSLER SHOULD BARE THE COST TO MAKE THESE VEHICLES SAFE AND ENVIRONMENTALLY FRIENDLY.

92,000 MILES AND AM REPLACING THE EXHAUST MANIFOLD BOLTS FOR THE 4TH TIME. EXTENDED WARRANTY HAS COVERED UP TO NOW, BUT NEXT TIME AND ALL THE TIMES AFTER WILL BE ON ME.

TL* THE CONTACT OWNS A 2010 RAM 1500. WHILE DRIVING 75 MPH, THE ENGINE SEIZED AND THE VEHICLE STOPPED IN THE PASSING LANE. THE VEHICLE WAS TOWED TO TWIN RIVERS CHRYSLER JEEP DODGE, INC (529 W COURT ST, BEATRICE, NE 68310, (402) 228-3311) AND THEY TESTED THE OIL, BUT NO DIAGNOSIS WAS DETERMINED. THE MANUFACTURER DID NOT PROVIDE THE CONTACT WITH A DEFINITIVE ANSWER REGARDING THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 144,000.

TL* THE CONTACT OWNS A 2010 RAM 1500. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD. THE CONTACT WAITED APPROXIMATELY 3 MINUTES AND THE VEHICLE STARTED NORMALLY. THE CONTACT ALSO MENTIONED THAT THE FAILURE HAD OCCURRED ON ANOTHER OCCASION. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR A DIAGNOSIS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 147,000.

TL* THE CONTACT OWNS A 2010 RAM 1500. THE CONTACT STATED THAT THE EXHAUST STUDS FAILED AND THE EXHAUST LEAKED ON BOTH SIDES. THE VEHICLE WAS TAKEN TO CHRYSLER DODGE JEEP RAM CRESTVIEW (5200 S FERDON BLVD, CRESTVIEW, FL 32536, 850-404-7731) WHERE IT WAS DIAGNOSED THAT THE EXHAUST WAS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 233,000.

CAMSHAFT FAILURE.

TAKATA RECALL, I HAVE A TICKING! KNOCKING NOISE COMING FROM PASSENGER SIDE OF VEHICLE. WHEN START VEHICLE AND WHILE DRIVE TICKING SOUND OVER 2 WEEKS HAVE GOTTEN LOUDER.

TL* THE CONTACT OWNS A 2010 RAM 1500. WHILE DRIVING 55 MPH, THE CONTACT NOTICED EXHAUST FUMES ENTERING THE VEHICLE. THE VEHICLE WAS TAKEN TO CHRYSLER DODGE JEEP RAM FIAT FT. WALTON BEACH (541 MARY ESTHER CUT OFF NW, FORT WALTON BEACH, FL 32548, (850) 244-7611) WHERE IT WAS DIAGNOSED THAT SEVERAL BOLTS TO THE EXHAUST MANIFOLD WERE FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 109,000.

EXHAUST MANIFOLD LEAKING.

FAILURE OF VALVE LIFTERS AND CAMSHAFT. QUESTIONABLE DESIGN REDUCES OIL FLOWDURING MDS ACTIVATION. MANY CASES OF THIS FAILURE.

AS I'M DRIVING,THE TRUCK JUST SHUTS OFF WHEN COMING TO A STOP SIGN OR RED LIGHT FOR A FEW WEEKS NOW. TODAY I CAME WITH IN INCHES OF MY LIFE WHEN AS I WAS TURNING INTO A DRIVEWAY IT JUST SHUT OFF. ON SOCIAL MEDIA I HAVE SEEN QUITE A FEW COMPLAINTS WITH THIS SAME ISSUE. BUT YET THERE ARE NO RECALLS FOR THIS PROBLEM.

THE EXHAUST MANIFOLD BOLTED TO THE ENGINE BLOCK IS LEAKING AT 75000 MILES, UPON FURTHER INVESTIGATION THIS IS DUE TO BOLTS BREAKING OFF AT THE ENGINE BLOCK LEVEL. BOLTS ARE SHEARING INSIDE THE ENGINE HOLE THREADS. THIS IS A VERY DISTINCT AND REOCCURRING ISSUE PLAGUED BY EVERY DODGE RAM OWNER. PLEASE PERFORM A SEARCH AT GOOGLE (OR ANY OTHER ENGINE), KEYWORDS "DODGE RAM EXHAUST MANIFOLD LEAK" (HTTPS://WWW.GOOGLE.COM/SEARCH?Q=DODGE+RAM+EXHAUST+MANIFOLD+LEAK&OQ=DODGE+RAM). THERE IS A VERY LOUD DISTINCT TICKING NOISE COMING FROM THE RIGHT SIDE ENGINE MANIFOLD. AFTER 30-60 SECONDS IT ALMOST DISAPPEARS; SIMILAR TO ANY OTHER VIDEO OR COMPLAINT FOUND ON THE WWW. SOME HAVE CALLED THEIR DODGE DEALER COMPLAINING ABOUT IT AND EVEN THE DEALERS ARE RECOGNIZING THAT IT IS A FLAW BUT A RECALL WILL NEVER HAPPEN!

TAKATA RECALL. THERE WAS A RECALL FOR THE YEAR AND MODEL OF MY TRUCK, BUT NOT MY VIN NUMBER.THE SAME EXACT PROBLEM THAT THE RECALL WAS MADE FOR IS WHAT GOING ON WITH MY TRUCK. I HAVE WENT TO THE DEALERSHIP AND THEY CONFIRMED THAT HAVE BROKEN BOLTS ON MY EXHAUST MANIFOLD GASKET, BUT IT IS NOT UNDER THE RECALL, BECAUSE MY VIN DOES NOT STATE IT. THE TRUCK HAS THE SAME PARTS AS ALL THE OTHER TRUCKS, BUT IS NOT CONSIDERED UNDER THE RECALL ALTHOUGH IT IS THE SAME PROBLEM AS THE OTHERS. THE DEFECT IS COSTING MAJOR MONEY ON MY BEHALF ON SOMETHING THAT IS OUT OF MY CONTROL AND SHOULD HAVE BEEN FIXED BY THE MANUFACTURE.

TWO REAR MANIFOLD BOLTS BROKE OFF INSIDE HEADER. CAUSES SEVERE TICKING NOISE ANYTIME THE MOTOR IS RUNNING RESULTING FROM HEAT SHIELD AND MANIFOLD RATTLING AGAINST HEADER. CAN CAUSE EXHAUST FUMES TO BE FILTERED BACK INTO CAB CAUSING INJURY

DODGE 5.7L HEMI ENGINES HAVE 2 COMMON, RECURRING ISSUES. 1) ENGINE LIFTERS FAIL PREMATURELY CAUSING EXCESSIVE WEAR ON THE CAMSHAFT LOBES. THE END RESULT IS A COSTLY REPAIR HAVING TO REPLACE THE CAMSHAFT AND LIFTER. A CHECK ENGINE LIGHT WILL COME ON AND WILL THROW A P030# CODE FOR A MISFIRE ON CYLINDER(S). WHEN THE MISFIRE HAPPENS THE VEHICLE STARTS SHACKING HORRIBLY. I HAVE SEEN A REPORT THAT A 2016 WITH 15K MILES HAD THE ISSUE ALL THE WAY BACK TO 2009 WITH ONLY 72K MILES AND SEVERAL IN BETWEEN. THERE ARE MULTIPLE FORUMS, THREADS, AND COMMENTS ON THIS ISSUE. IT SEEMS VERY COMMON AND DODGE SHOULD BE PROVIDING ASSISTANCE OUTSIDE OF WARRANTIES. YET THEY CHOOSE TO DO NOTHING EXCEPT LOSE CUSTOMERS. 2) THE RECURRING EXHAUST MANIFOLD BOLTS BREAKING. MINE WAS REPAIRED ONCE UNDER WARRANTY AND IS CURRENTLY HAVING THE ISSUE AGAIN. AGAIN DODGE SEEMS TO DO NOTHING TO IMPROVE THE MATERIALS TO PREVENT THE ISSUE FROM RECURRING.

EXHAUST MANIFOLD LEAK, BOLTS BREAK, CAUSING AN EXHAUST MANIFOLD LEAK, MAKING A LOUD CLICKING NOISE THAT INCREASES WITH TIME.

TL* THE CONTACT OWNS A 2010 RAM 1500. WHEN THE VEHICLE WAS STARTED, THERE WAS A LOUD NOISE COMING FROM THE ENGINE WITHOUT WARNING. THE NOISE REMAINED UNTIL THE VEHICLE WAS WARMED UP. AFTERWARDS, THE NOISE WENT AWAY. THE VEHICLE WAS TAKEN TO THE DEALER (LITHIA CHRYSLER JEEP DODGE OF GRAND FORKS, LOCATED AT 2373 32ND AVE S, GRAND FORKS, ND 58201; (701) 864-3645) WHERE IT WAS DIAGNOSED THAT THE MANIFOLD BOLTS NEEDED TO BE REPLACED ON THE EXHAUST. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AT 866-726-4636 AND STATED THAT THE VEHICLE WAS OUT OF WARRANTY; THEREFORE, THEY COULD NOT ASSIST. A CASE NUMBER WAS NOT PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

WHILE DRIVING MY 2010 RAM, WITH 85,000, MY ENGINE BLEW WITHOUT WARNING AS MY FAMILY AND I TRAVELED DOWN THE ROAD AT 40 MPH INTO ONCOMING TRAFFIC. THERE WERE NO WARNINGS WHATSOEVER, NO CHECK ENGINE OR OIL LIGHTS, ETC. AND NOW I'M TOLD I OWE BETWEEN 4-9 K FOR A NEW ENGINE.

THERE IS A CONSISTENT TICKING NOISE IN THE ENGINE AREA WHEN TRUCK IS STATIONARY. NOISE IS PRESENT WHEN ENGINE IS BOTH COLD AND HOT.

THERE IS A CONSISTENT TICKING NOISE IN THE ENGINE WHEN TRUCK IS STATIONARY. THE NOISE IS PRESENT WHEN ENGINE IS BOTH COLD AND HOT.

2010 DODGE RAM 1500 5.7. CHECK ENGINE LIGHT. CYLINDER 2 MISFIRE ERROR CODE. BROKEN VALVE SPRING AND LIFTER. FOUND EXACT PROBLEM ALL OVER THE INTERNET DODGE RAM FORUMS. PLEASE ISSUE RECALL.

AT ABOUT 65000 MILES I STARTED HEARING A "TICKING" SOUND FROM THE ENGINE, WHEN IT WAS COLD. I TOOK THE VEHICLE BACK TO THE DEALER AND I WAS TOLD THAT THE EXHAUST MANIFOLD BOLTS HAD BROKEN, THIS CAUSES EXHAUST FUMES TO ENTER THE PASSENGER COMPARTMENT DURING THE WINTER WHEN USING THE HEATER, AND THE SUMMER USING THE AIR CONDITIONER. . I BELIEVE THAT THE PROBLEM WAS CAUSED BY CHRYSLER USING SUBSTANDARD MATERIALS FOR THESE BOLTS. THIS SEEMS TO BE A CHRONIC PROBLEM WITH THE "HEMI" ENGINE, SO MUCH SO THAT THERE ARE YOU TUBE VIDEOS SHOWING HOW TO REPAIR THE PROBLEM. THE DEALER ESTIMATED THE REPAIR COST TO BE $ 1800.00. AS TIME GOES BY I FELT THAT THIS SHOULD BE A RECALL, DUE TO THE FACT THAT THIS WAS NEVER A PROBLEM WITH OLDER VEHICLES, AND IT HAPPENED AROUND 65,000 MILES THOUGH I TOOK IT IN AROUND 70000 MILES FOR THE ESTIMATE. THESE BOLTS SHOULD OUTLAST THE USEFUL LIFE OF THE VEHICLE IF THEY WERE MADE OF THE PROPER MATERIALS OR WERE PROPERLY HEAT TREATED. IT SEEMS TO BE A REGULAR OCCURRING PROBLEM WITH DODGE RAMS WITH THE HEMI ENGINE. THE DATE OF THE ESTIMATE IS APPROXIMATE.

EXHAUST MANIFOLD BOLTS SHEERING OFF INSIDE ENGINE BLOCK ALLOWING MANIFOLD TO UNSEAT MAKING TICKING NOISE AND ALLOWING EXHAUST TO ESCAPE OUTSIDE THE VEHICLES MUFFLER. VERY EXPENSIVE TO REPLACE THE FAULTY BOLTS BECAUSE MOST MUST BE DRILLED OUT OF THE BLOCK.

EXHAUST STARTED LEAKING IN THE MORNING WHEN IT'S COLD, IT GOES AWAY AFTER WARMING UP, SOUNDS LIKE DONUT GASKET OR EXAUST MANIFOLD.ALSO THE PUDDLE LIGHTS IN THE MIRRORS QUIT WORKING.

TL* THE CONTACT OWNS A 2010 DODGE RAM 1500. WHEN STARTING THE VEHICLE, THERE WAS AN ABNORMAL NOISE UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BOLTS WERE FRACTURED ON THE EXHAUST MANIFOLD. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 94,000.

TL* THE CONTACT OWNS A 2010 DODGE RAM 1500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. . .. .UPDATED 07/21/15 *BF THE CONSUMER STATED THIS IS NOT HER NAME OR COMPLAINT AND TO REMOVE HER NAME. UPDATED 07/28/15*JB

MY TRUCKS EXHAUST MANIFOLD GASKETS HAVE ALREADY FAILED AT 70,000 MILES, I HAVE A TERRIBLE EXHAUST LEAK AND I KNOW THIS TRUCK HAS NEVER BEEN BEAT FOR AN EXHAUST LEAK TO HAPPEN THIS EARLY THERE HAS BEEN MANY ONLY FORMS WITH THE SAME ISSUES SOME WHERE ABLE TO GET IT BY THE DEALER AT NO CHARGE. HTTPS://YOUTU.BE/ND3C_JI7PAA

TL* THE CONTACT OWNS A 2010 DODGE RAM 1500. THE CONTACT RECEIVED A NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL); HOWEVER, THE PARTS NEEDED FOR REPAIR WERE UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REMEDY. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

EXHAUST MANIFOLDS ARE LEAKING GAS. I CAN SMELL EXHAUST GAS INSIDE THE TRUCK CAUSING DROWSINESS ON LONG RIDES. *TR

UPON STARTING VEHICLE I HEARD SOME TYPE OF GEAR GRINDING/KNOCKING, SOMETIMES IT HAPPENS WHEN I TURN THE KEY OFF TOO. ALONG WITH THIS I NOTICED I HAD NO HEATING CONTROL WHICH KEPT ME FROM DE FOGGING MY WIND SHIELD OR HAVING HEAT IN GENERAL. COULD BE A BIG ISSUE IF THE WINDOWS WERE ICED OVER. HAS HAPPENED RANDOMLY OVER THE LAST SEVERAL WEEKS AND I HAVE FINALLY DISCONNECTED THE BLEND DOOR ACTUATOR LOCATED BEHIND THE GLOVE COMPARTMENT. WILL CONTACT DEALERSHIP. *TR

EXHAUST MANIFOLD BOLTS BREAK OFF AND THE TRUCK DEVELOPS EXHAUST LEAK...THE TRUCK THEN HAS NO CONTROL OF REGULATING EXHAUST GASES AND NEXT YOU WILL GET A DAMAGED CATALYTIC CONVERTER. THIS WILL ALSO CAUSE OXYGEN SENSOR TO CHANGE MIXTURE. THESE BOLTS ARE BREAKING ON THE ENGINE, ON THEIR OWN. THE BOLTS ARE TOO SMALL FOR A EXHAUST AREA BOLT. THE INTERNET IS FULL OF FORUMS ABOUT THIS ISSUE AND DODGE HAS DONE NOTHING TO ADDRESS. MODEL 5.7 HEMI HAS HAD ISSUES FROM 2005 -2012. THESE BOLTS CAN NOT STAND UP TO THE HEAT AND STRESS FOR THE INTENDED APPLICATION. *TR

TL* THE CONTACT OWNS A 2010 DODGE RAM 1500. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, ALL OF THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL AS THE VEHICLE STALLED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURE WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 45,000 AND THE CURRENT MILEAGE WAS 50,300.

EXHAUST RESONANCE AT 1500 RPM ON 5.7 LITER MDS VVT ENGINE. HAVE MADE 7 TRIPS TO TWO DEALERSHIPS. DEALERSHIPS UNABLE TO CORRECT. HAVE CONTACTED DODGE THREE TIMES. MANUFACTURER THINKS IT IS CONNECTED WITH THE MDS BUT WILL NOT COVER UNDER WARRANTY. DEALERSHIPS CAN NOT SAY IF THIS WILL HAVE AN ADVERSE AFFECT ON THE ENGINE OVER TIME.

TL*THE CONTACT OWNS A 2010 DODGE RAM 1500. WHILE DRIVING APPROXIMATELY 65 MPH, THE ENGINE STALLED. THE CONTACT WAS ABLE TO START THE IGNITION AND DRIVE THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIANS RESET THE COMPUTER. THE FAILURE OCCURRED A SECOND TIME. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CAM AND CRANK SENSORS WHERE REPLACED. THE FAILURE OCCURRED A THIRD TIME AND WAS TAKEN BACK TO THE DEALER WHERE THE TECHNICIANS REPLACED THE VAPOR CANISTER AND THE LINER VALVE. THE CONTACT STATED THE VEHICLE STALLED A FOURTH TIME AND WAS TAKEN BACK TO THE DEALER WHERE THE TECHNICIANS WHERE UNABLE TO DUPLICATE OR DIAGNOSE THE FAILURE. THE VEHICLE STALLED A FIFTH TIME AND WAS TAKEN BACK TO THE DEALER WHERE THEY FLUSHED THE FUEL OUT AND REPLACED THE COMPUTER MODULE. THE CONTACT SPOKE WITH THE OWNER OF THE DEALER WHO STATED HE WOULD GIVE THE CONTACT A CALL WITH MORE INFORMATION ABOUT RETURNING THE VEHICLE BUT HAS NOT RETURNED THE CALL. THE SERVICE DEPARTMENT STATED A DIFFERENT TECHNICIAN WOULD INSPECT THE VEHICLE AND AN APPOINTMENT WAS MADE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 700.

TL*THE CONTACT OWNS A 2010 DODGE RAM 1500. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO REPLACED THE PCM AND TIFF. THE FAILURE OCCURRED AGAIN AND THE CONTACT COASTED TO THE SIDE OF THE ROAD. THE VEHICLE SUDDENLY RESTARTED AND ACCELERATED. THE CONTACT APPLIED THE BRAKES TO SLOW THE VEHICLE DOWN. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO REPLACED THE COMPUTER AND IGNITION PARTS, BUT COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 12,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 17,000.

TL*THE CONTACT OWNS A 2010 DODGE RAM 1500. WHILE DRIVING 40 MPH THE ROCKER ARM BROKE IN THE HEMI ENGINE. HE STATED THAT THE ENGINE STARTED MAKING A NOISE AND HE DROVE ONTO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER. THE DEALER REPLACED THE ROCKER ARM AND A PUSH ROD WHICH WERE COVERED BY THE WARRANTY. THE FAILURE MILEAGE WAS 670 AND THE CURRENT MILEAGE IS 1,312. UPDATED 01/11/2011*LJ UPDATD 01/24/11*JB

I PURCHASED A NEW 2010 DODGE 1500 RAM PICKUP THREE WEEKS AGO. SINCE THAT TIME INTERMEDIATE THE LIGHTS FOR THE ANTILOCK BRAKES AND TRACTION CONTROL COME ON AND OFF WHILE DRIVING DOWN THE ROAD AS WELL AS SEVERAL OTHER ELECTRICAL COMPONENTS NOT WORKING OR WORKING OFF AND ON. I CONTACTED THE DEALER AND THEY INFORMED ME THAT I SHOULD POP THE HOOD BECAUSE THE MAIN ELECTRICAL BLOCK UNDER THE HOOD ON SOME HAVE HAD NOT PROPERLY CONNECTED PLUGS ON THE BACK AND THEY MAY VIBRATE LOOSE AND I SHOULD WIGGLE THEM AROUND AND SEE IF THAT FIXES THE PROBLEM. I WILL TAKE THE TRUCK IN FOR THEM TO TRY AND REPAIR BUT IT APPEARS TO ME THAT IF THE CONNECTOR IS LOOSE ON THESE THAT THE POWER INTERRUPTION TO THE CIRCUIT WILL MAKE THE ABS AND TRACTION CONTROL SYSTEMS INOPERABLE FOR THE PERIOD OF TIME THE LIGHTS ARE ILLUMINATED AND COULD CAUSE ACCIDENTS IF THIS OCCURS AT THE WRONG TIME. I HAVE PICS AND VIDEO OF THE ISSUES. THERE IS ALSO TO GIVE A BIGGER SCOPE OF THE BLOCKS LOOSENESS NO HEATED SEAT EXCEPT DRIVER NO COOLED SEAT EXCEPT DRIVER ALL 4 POSITIONS ARE SUPPOSED TO BE HEATED AND COOLED. THE RADIO WORKS OFF AND ON, THE POWER PEDALS DON'T WORK AT ALL. THERE IS AS A UNRELATED NOTE AN INTERMITTENT KNOCK IN THE LOWER PART OF THE ENGINE. *TR

TRUCK MAKES DRONE SOUND AND VIBRATIONS CAN BE FELT WHEN THE MDS SYSTEM IS ACTIVATED. THIS IS NOT A SAFETY-RELATED CONCERN BUT RATHER QUALITY/COMFORT. WHEN TAKEN TO THE DEALER, THEY INDICATED IT WAS NORMAL AND DUE TO THE MDS TURNING ON. *TR