2004 Ford Focus Transmission Problems

Your 2004 Ford Focus is making a loud noise from the front of the vehicle, and your check engine light has come on. You may also notice the key getting hot in the ignition, the engine hesitating when you press the accelerator, higher fuel consumption than normal, and difficulty opening both passenger doors (one requires extra force, the other is stuck). Dealers indicated the ignition switch and engine valve may need replacement, though the exact cause of the door problems wasn't determined.

TL* THE CONTACT OWNS A 2004 FORD FOCUS. WHILE DRIVING AT APPROXIMATELY 15 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS UNABLE TO RESTART. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

WHILE DRIVING THE VEHICLE STOPPED RUNNING SUDDENLY. MY DAUGHTER SAW STEAM OR SMOKE COMING FROM THE FRONT ENGINE COMPARTMENT. WITHIN A MINUTE OR SO THE WHOLE FRONT OF THE VEHICLE WAS ENGULFED IN FLAMES. THE FIRE WAS INTENSE, THE TOP OF THE ENGINE WAS MELTED, THE INTERIOR OF THE DASH WAS DESTROYED, AND THE VEHICLE WAS DAMAGED BEYOND REPAIR. IT LOOKS LIKE THE MOST INTENSE FIRE AREA WAS AROUND THE FUSE PANEL. I DID CONTACT FORD THROUGH SEVERAL AVENUES BUT THEY APPEARED TO BE DISINTERESTED. *TR

2004 FORD FOCUS. CONSUMER STATES TRANSMISSION GAVE OUT WITH A MILEAGE UNDER 20,000. CONSUMER REQUESTS REIMBURSEMENT. *TGW IN JULY 2009, THE VEHICLE NEEDED A NEW BATTERY. ABOUT A WEEK AFTER THE NEW BATTERY WAS INSTALLED, PERIODICALLY THE CLUSTER LIGHTS WOULD MAKE A SOUND AND THE LIGHTS WOULD BLINK ON AND OFF. IT WOULD HAPPEN TWICE IN A MATTER OF SECONDS, BUT DID NOT HAPPEN EVERYDAY. THE CONSUMER FOLLOWED INSTRUCTION ON WHAT TO DO. THE SITUATION WAS A LITTLE BETTER, BUT THE CLUSTER BLINKING, ETC STILL OCCURRED PERIODICALLY. A WEEK LATER, AS THE CONSUMER BACKED OUT OF HER DRIVEWAY, THERE WERE SOUNDS COMING FROM THE VEHICLE AND THEY SEEMED TO GET WORSE. THE CONSUMER HAD THE VEHICLE TOWED TO A TRANSMISSION SHOP. UPON INSPECTION, THE TRANSMISSION PLATE WHICH WAS LOCATED UNDER THE ENGINE SHOWED TRANSMISSION FLUID AN D EXCESSIVE AMOUNTS OF METAL FILLINGS. THE MECHANIC SHOWED THE CONSUMER THE DAMAGED PARTS WHERE THE TEETH IN THE GEARS WERE NOT WORKING PROPERLY WHICH CAUSED THE METAL FILLINGS IN THE TRANSMISSION PLATE. *JB

ON 8/19/09, I WAS DRIVING MY 2004 FORD FOCUS AND ALL OF A SUDDEN WHILE I WAS DRIVING, IT FELT LIKE PRESSURE (OR HAVING TO FORCE CAR TO GO) WITH MY FOOT ON GAS PEDAL. AFTER I EASED MY FOOT OFF GAS PEDAL, CAR WOULD SWITCH IN TO GEAR. THIS SAME PATTERN OF PRESSURE AND EASING FOOT OFF GAS PEDAL SO THAT CAR WOULD GO INTO GEAR HAPPENED EACH TIME I WOULD MAKE A STOP. CAR IS CURRENTLY AT SHEEHY FORD DEALERSHIP AND I HAVE BEEN TOLD THAT THE TRANSMISSION HAS FAILED WITH 2ND AND 4TH GEAR NOT WORKING & THAT I COULD NOT DRIVE CAR HOME UNTIL TRANSMISSION IS REPLACED BECAUSE ALSO TRANSMISSION IS READY TO FALL OUT OF CAR DUE TO WEAK SUPPORT IS HOLDING TRANSMISSION IN PLACE. CAR HAS APPROX ONLY 83,000 MILES. *TR

ON ACCELERATION FROM STOP CAR TACKS OUT TO 6 AND TRANSMISSION REVS THEN SHIFTS VERY HARD, CALLED FORD AND THEY TOLD ME IT WAS THEY WAY I DRIVE MY CAR. SAID TRANSMISSION LEARNS HOW TO SHIFT THAT WAY, CAR STILL NOT REPAIRED. *TR

TL*THE CONTACT OWNS A 2004 FORD FOCUS. WHILE SHIFTING AT 30 MPH, THE CLUTCH FAILED. THE DEALER REPLACED THE CLUTCH, HOWEVER, THEY NEGLECTED TO REINSTALL ONE OF THE BOLTS AND THE FAILURE RECURRED. NO ADDITIONAL REPAIRS WERE MADE. THE CURRENT MILEAGE WAS 39,000 AND FAILURE MILEAGE WAS 37,800.

GENTLEMEN MY PROBLEM IS TWO FOLD, FIRST I AM REALLY DISAPPOINTED THAT THE NHTSA IS NOT PROVDING ALL THE INFORMATION ON ALL THE COMPLAINTS, RECALLS, AND SAFETY INVESTIGATIONS THAT IT USE TO. NOW I AM HOPING THAT A REP WILL EITHER WRITE ME OR CALL ME AND TELL ME THIS IS THE WAY ITS ALWAYS BEEN. THIS IS B.S..... MR NHTSA WHY ISNT THERE A ARCHIVE WHERE WE CAN GO BACK 3 MONTHS, 6,12 OR MORE. WHY HAVE YOU ROMOVED THIS OPTION???? IT USE TO BE THERE!!! NOW FOR MY COMPLAINT I HAVE A FORD FOCUS, 2004 AND THE AXLE JUST BROKE, 34000 MILES AND ITS AT THE DEALER SHIP HOPEFULLY GETTING FIXED, NOW THERE WAS NO FORWARNING, NO SNAP, POP, BANG OR ANYTHING, I BACKED OUT OF A PARKING SPACE AND PUT IT IN DRIVE, IT MOVED ABOUT SIX FEET AND STOPPED. NOW IF THIS WOULD HAVE BEEN IN THE MIDDLE OF AN INTERSECTION OR TRYING TO MOVE OUT OF THE WAY OF ON COMING TRAFFIC IT COULD HAVE BEEN A BAD THING, FORTUNATLY I WAS IN A PARKING LOT. WHEN I REVIEWED YUOUR ENTRIES ON THIS MATTER YOU ONLY HAVE ONE. GIVE ME BREAK I WANT TO SEE THE HISTORY. I HAVE BEEN WRENCH PULLING FOR A FEW YEARS AND THERE I NO WAY IN HELL YOUR GOING TO CONVINCE ME THIS ALL YOU HAVE. HELL EVEN THE DEALERSHIPS SAY ITS NOTHING OUT OF THE ORDINARY. ITS UNDER WARRENTY BUT THE FACT STILL RAMIANS THIS SHOULD BE A SAFETY ISSUE AT THE VERY LEAST. WAITING TO HEAR FROM YOU MR NHTSA

I WAS ON MY WAY HOME AND I STARTED TO HERE A NOISE FROM THE FRONT END. THEN IT FELT LIKE MY CAR WAS STOPPING WHILE I WAS ACCELERATING. WHEN I PUT IT IN REVERSE MY FRONT TIRES LOCKED. I PUT IT IN NEUTRAL TO TRY TO PUSH IT BACK PUT IT WOULD NOT MOVE. I HAD MY KIDS IN THE CAR AND I WAS GLAD WE WERE NOT IN TRAFFIC. I TOOK IT TO A DEALER AND THEY ARE TAKING THEIR TIME AND HAVEN'T LOOKED AT YET. I PAY 334. A MONTH AND MY CAR IS A DEATH TRAP. I HAVE NOTHING TO DRIVE AND I CANT AFFORD TO KEEP UP A RENTAL CAR. 2004 FORD FOCUS. *NM

DT: CONTACT OWNS A 2004 FORD FOCUS. WHILE DRIVING ON THE HIGHWAY THE CAR SHUT DOWN WITHOUT WARNING. NO PARTICULAR SPEED OR CIRCUMSTANCE. THIS INCIDENT HAPPENED SEVERAL TIMES ON INTERSTATE. WHILE GOING 70 TO 75 MPH. THE CAR SHUT DOWN, NO BATTERY, NO LIGHTS, AND IT WAS VERY HARD TO STEER. IT HAPPENED AT STOP SIGN OR AT SPEEDS OF 35 TO 45 MPH .AFTER PUTTING VEHICLE IN PARK THEN IN NEUTRAL OR PARK IT WILL START BACK UP. VEHICLE WAS TAKEN BACK TO DEALERSHIP 3 TIMES IN THE LAST 3 WEEKS. MECHANIC RECALIBRATED THE AUTOMATIC TRANSMISSION CONTROL MODULE (PCM) ,AND WAS TOLD IT WOULD BE OKAY. TOOK IT OFF THE DEALERSHIP AND WITHIN 10 MILES INCIDENT STARTED HAPPENING AGAIN. FLIGHT RECORDER WAS INSTALLED ON OCTOBER 6, 2005 WAS TOLD TO PUSH A BUTTON EVERY TIME THE VEHICLE SHUT OFF, BUT THE PROBLEM WAS THAT THERE WAS ELECTRICITY GOING TO ANYTHING TO MAKE THE FLIGHT RECORDER SHOW THE PROBLEM. *AK

MANUAL TRANSMISSION REVERSE AND FIRST GEAR FAILED, CAUSING CAR TO OVER REV ENGINE. CAR WAS TAKEN TO DEALER WHERE I WAS TOLD A PIN CLAIMED LOSE IN THE CLUTCH. DURING TOWING OF VEHICLE, TOW TRUCK DRIVER NOTICED THAT THERE WAS A LARGE AMOUNT OF RUST ON THE UNDERCARRIAGE OF THE CAR. THIS PROBLEM IS NOT YET RESOLVED. *NM

VEHICLE WAS DRIVEN LESS THAN SEVENTY MILES AFTER BEING RELEASED FROM THE MANUFACTURER. WITHIN THAT TIME, UPON MERGING ONTO THE HIGHWAY, TRANSMISSION FAILED. TRANSMISSION STARTED SLIPPING WITH ENGINE REVVING TO 3000 RPMS, AND VEHICLE SLOWLY ACCELERATED ONTO THE HIGHWAY. WITHIN A FEW SECONDS THE TRANSMISSION ENGAGED,BUT ONLY IN THE FIRST GEAR. THIS ENTIRE INCIDENT OCCURRED AFTER THE MANUFACTURER HAD HELD THE VEHICLE BECAUSE OF A QUALITY CONTROL ISSUE. THE DEALERSHIP WANTED TO REPLACE THE ENTIRE TRANSMISSION.*AK