2004 Ford Focus Lights Problems
5 owner-reported lights complaints from NHTSA data
Data sourced from NHTSA public database. For informational purposes only. Always consult a qualified mechanic.
Lights Recalls (3)
EXTERIOR LIGHTING:HEADLIGHTS
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Fix: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
EXTERIOR LIGHTING:HEADLIGHTS
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Fix: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
EXTERIOR LIGHTING
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Fix: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Owner Complaints (5)
DRIVING MY 2004 FORD FOCUS, WHEN I TURN ON THE LEFT BLINKER AND IT STARTS BLINKING VERY FAST SO I ASSUME IT NEEDS A NEW BULB OR FUSE. I GO TO REPLACE THE BULB ONLY TO FIND THAT THE HOUSING UNIT HOLDING THE BULB FOR THE BLINKER IS MELTED. NOW I HAVE TO REPLACE THE ENTIRE THING AND THIS COST ME $120.00 DOLLARS. FAST FORWARD SIX MONTHS, NOT ONLY IS THE LEFT BLINKER OUT BUT NOW THE RIGHT BLINKER AS WELL, AND GUESS WHAT SAME PROBLEM NOT JUST A BULB BUT BOTH HOUSING UNITS HAVE MELTED AND NEED TO BE REPLACED. LOOKED TO SEE IF THERE IS A RECALL ON THIS ISSUE, SINCE ONE, IT IS THE MATERIAL OF THE CAR THE HEAT GENERATED BY THE MANUFACTURES BULB AND IT CONTINUES TO HAPPEN EVEN WHEN REPLACED WITH NORMAL DRIVING. PLUS NO BLINKERS IS A HUGE SAFETY ISSUE. NO RECALL! LOOKS LIKE FORD THINKS MELTING CAR PARTS ON THEIR VEHICLES IS NORMAL. *LN
2004 FOCUS ZWT 1. LOSS OF FRONT WIPER PARK FUNCTION ! 2. LOSS OF HEADLIGHT / AUXILIARY LAMP FUNCTION ! HAPPENED AT 2 SEPARATE INCIDENTS DURING 2009. *TR
1) TURNED HEADLIGHT SWITH TO "ON" ON MY 2004 FORD FOCUS ZTW 2) TURNING THE HEADLIGHTS ON CAUSED THE REAR HATCH TO OPEN UNCOMMANDED. 3) I REMOVED THE COVER FROM THE HATCH AND DISCONNECTED THE WIPER MOTOR AND LATCH UNLOCK SOLENOID CONNECTORS. THEN, TO FIND THE POSSIBLE PROBLEM, I INSPECTED THE WIRE BUNDLE IN THE AREA OF THE HATCH HINGE AND FOUND SEVERAL WIRES FRAYED AND BROKEN. SO TURNING ON THE HEADLIGHTS APPARENTLY SENT A SIGNAL (SHORT) TO THE LATCH SOLENOID. A FRIEND HAD A SIMILAR PROBLEM. HIS HATCH WOULD POP OPEN WHEN THE IGNITION WAS TURNED TO START THE CAR. TWO DEALERS TOLD ME THEY WOULD NOT BE OF ANY HELP UNLESS I PAID AT LEAST $350 TO REPAIR THE PROBLEM. THIS IS A SAFETY ISSUE. REMEBER THE CHYSLER MINI VAN HATCH RECALL? I HAVE BEEN WATCHING THE TOYOTA SUA HEARINGS AND DECIDED TO CHALLENGE YOU GUYS AND SEE IF YOU WOULD REVIEW AND CONTACT ME AS MR. LAHOOD SAID YOU WOULD. I KNOW YOU ARE BUSY AND UNDERSTAFFED. I DO NOT BLAME YOU AS SOME ARE INTENT UPON. I SPENT MY LIFE AS AN A&P MECHANIC AT AMERICAN AIRLINES AND KNOW THE IMPORTANCE OF SAFETY. THANKS FOR READING AND HOPE TO HEAR FROM YOU SOON. PS FORD HAS HAD KNOWLEDGE OF THIS PROBLEM IN OTHER MODEL YEARS OF THE FOCUS. *TR
TL* THE CONTACT OWNS A 2004 FORD FOCUS. WHILE PREPARING TO MAKE A RIGHT TURN AT APPROXIMATELY 45 MPH, THE RIGHT TURN SIGNAL FAILED TO OPERATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN STATED THE FAILURE WAS CONTRIBUTED TO THE BURNING AND MELTING OF THE TURN SIGNAL BULB SOCKET. THE VEHICLE WAS REPAIRED AT THE COST OF $300.00. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON A THREE SEPARATE OCCASIONS FOR THE IDENTICAL FAILURES. THE MANUFACTURER WAS NOTIFIED AND REIMBURSED FOR THE PRIOR SERVICE REPAIR. ALSO, PERFORMED ONE FREE REMEDY REPAIR ON THE VEHICLE. THE FAILURE MILEAGE WAS 45,000. THE CURRENT MILEAGE WAS 120,000.
THE INDICATOR LIGHTS ON THE INSTRUMENT PANEL FOR THE HIGH BEAM HEADLIGHT AND TURN SIGNALS WERE NOT BRIGHT ENOUGH. *AK *NM