2011 Dodge Journey Engine Problems

Your 2011 Dodge Journey experienced an engine fire while stopped at a stop sign, even after being repaired for a known engine cooling issue (NHTSA Campaign 15V431000). You saw flames coming from under the hood and safely exited the vehicle before the fire department extinguished the fire. The fire started in the engine manifold area and the vehicle was a total loss. The repair involved addressing the recalled engine and cooling system components to prevent future manifold fires.

TL* THE CONTACT OWNS A 2011 DODGE JOURNEY. THE CONTACT STATED THAT THE ENGINE OVERHEATED WITH THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS PREVIOUSLY TAKEN TO KELLY JEEP CHRYSLER DODGE RAM 501 STATE AVENUE, EMMAUS, PA 180449, (610)904-8499 WHERE THE TRANSMISSION, THE ENGINE, ENGINE SOLENOIDS AND ENGINE COILS WERE REPLACED PRIOR TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000. *DT*JB

BOTH CATALYST CONVERTS WENT OUT AT THE SAME TIME AND FAILED MY GA EMISSIONS TEST. THERE IS A PERMANENT CODE. I ONLY HAD THIS SUV A YEAR AND HAVE ALREADY REBUILT THE TRANSMISSION, ALONG WITH CALIBER ISSUES. I WAS TOLD THAT MY VIN DIDN'T MATCH THE U67 CATALYST EMISSION RECALL THAT INCLUDED MY VEHICLE DESCRIPTION, TRIM, MAKE AND MODEL. THE RECALL SHOULD HAVE EXPANDED TO 3.6 LITERS AS WELL, CONSIDERING THE PROBLEM IS AN EXACT MATCH. I EXPECT DODGE WILL RECTIFY THIS EMISSIONS PROBLEM, CONSIDERING THAT GA RESIDENTS WILL FIND THIS SUV USELESS IN SUCH A STRICT EMISSION STATE.

WE PURCHASED THIS VEHICLE USED, BACK IN FEBRUARY. OVER THE LAST SEVERAL MONTHS THE VEHICLE HAD SPORADICALLY SHUT OFF WHILE DRIVING. THE ENGINE COMPLETELY STOPS WHILE MOVING. SOME TIMES IT TAKES MULTIPLE ATTEMPTS TO TURN IT BACK ON AFTER SHUTTING DOWN AND OTHER TIMES IT WILL TURN BACK ON. WE HAVE ALREADY HAD THE CAR LOOKED AT AND HAD SOME RECALL WORK DONE TO IT, BUT THIS KEEPS HAPPENING EVEN SO. IT HAPPENED AGAIN TODAY WHILE GOING 40 MPH, 2 SECONDS BEFORE THE CAR STALLED THE CHECK ENGINE LIGHT CAME ON AND THEN THE CAR STOPPED WHILE DRIVING. THANKFULLY THE PERSON BEHIND ME WAS NOT FOLLOWING TOO CLOSE BECAUSE THEY ALMOST HIT ME WHEN THE CAR STOPPED MOVING. I WAS DRIVING ON A CITY STREET WITH MODERATE TRAFFIC AROUND ME, SO I AM LUCKY THAT NO ONE HIT ME WHEN THE CAR CAME TO A COMPLETE STOP. I WAS ABLE TO PUT THE CAR IN PARK AND PUT MY HAZARDS ON, WHILE WAITING TO RESTART THE CAR. THIS ISN'T THE FIRST TIME THIS HAS HAPPENED AND I AM SURE THIS WON'T BE THE LAST.

MY 2011 DODGE JOURNEY ON THE DRIVER SIDE HEAT BLOWS HOT ON THE PASSAGE SIDE IT BLOWS CODE. THIS HAPPEN WHEN DRIVING OR WHEN IT'S STARTED TO WARM UP THE PASSAGE SIDE IT BLOWS COLD EVEN WHEN THE CAR HAS BEEN DRIVEN FROM 15 MINUTES.

NO HEAT ON PASSENGER SIDE OF VEHICLE DEALER STATES HEATER CORE PLUGGED NEEDS REPLACING AT OVER $1000.

WHILE DRIVING THIS VEHICLE, SOMETIMES AT HIGHWAY SPEEDS, THE ENGINE WILL STALL. WHILE ALL INTERIOR ACCESSORIES STAY ENERGIZED, THE ENGINE DOES NOT ATTEMPT TO RESTART. THIS HAS HAPPENED DOZENS OF TIMES AND THE VEHICLE HAS BEEN TO THE DEALERSHIP FOR THIS ISSUE THREE DIFFERENT TIMES. THIS ISSUE DID NOT START OCCURRING UNTIL THE TOUCHSCREEN STOPPED WORKING AND THE DASH DISPLAY STARTED SHOWING IN GERMAN ALONG WITH THE VEHICLE NOT STARTING. I HAD IT TOWED INTO THE DEALER WHERE THEY HAD IT FOR TWO WEEKS. THEY REPLACED THE TELEMATICS GATEWAY CONTROL MODULE, SEVERAL RELAYS, AND THE BATTERY. AFTER THIS REPAIR IS WHEN THE ABOVE ISSUE STARTED HAPPENING. THIS IS OUTRIGHT DANGEROUS AND HAS LEFT MY WIFE (HER VEHICLE) STRANDED NOW THREE SEPARATE TIMES. I UNDERSTAND THE DEALER IS TRYING TO RECREATED THE ISSUE WHEN I TAKE IT TO THEM, BUT THEY HAVE NOT BEEN ABLE TO GET THE VEHICLE TO DO IT WHEN THEY HAVE IT IN THEIR POSSESSION. I HONESTLY BELIEVE THAT THEY ARE ONLY DRIVING THE VEHICLE AROUND THE BLOCK AND CALLING IT GOOD. THIS STALLING HAS HAPPENED ON CITY STREETS AND AT HIGHWAY SPEEDS. I JUST WANT MY WIFE AND CHILD TO BE SAFE AND I DON'T FEEL THAT IS THE CASE HERE. I WILL BE LOOKING TO TRADE VEHICLE IN IF THIS ISSUE CANNOT BE FIGURED OUT. I AM ALSO ANGRY THAT I AM PAYING ON A PIECE OF JUNK THAT SPENDS MORE TIME IN THE SHOP THAN BEING DRIVEN.

WHILE DRIVING ON THE HIGHWAY THE CAR JUST SHUT OFF HAS DONE THIS MULTIPLE TIMES WITH NO CHECK ENGINE LIGHTS AT ALL.

CHECK ENGINE LIGHT WITH CODE FOR MISFIRE ON CYLINDER 4. SPARK PLUGS AND COILS REPLACED. VIN NOT LISTED WITH OTHER 3.6L V6 THAT HAS EXTENDED WARRANTY FOR SAME ISSUES FOR REPLACEMENT OF CYLINDER HEAD. CHECK ENGINE LIGHT COMES ON DURING LOW SPEED OR STOPPED AND ROUGH ENGINE IGNITION. VEHICLE IS A 2011 DODGE JOURNEY 3.6L V6. *TR

TL* THE CONTACT OWNS A 2011 DODGE JOURNEY. WHILE THE VEHICLE WAS PARKED, THERE WAS AN ABNORMAL NOISE COMING FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 89,000.

TL* THE CONTACT OWNS A 2011 DODGE JOURNEY. THE CONTACT STATED THAT THE VEHICLE AND HOUSE CAUGHT FIRE. A POLICE AND A FIRE REPORT WERE FILED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. NO INJURIES WERE SUSTAINED. THE VEHICLE WAS NOT DIAGNOSED AND WAS DESTROYED. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.

THE COOLANT SYSTEM KEEP OVERHEATING HAD FIX 2 TIMES IN 4MONTHS AT A COST $900.00 REACH TIME

TL* THE CONTACT OWNS A 2011 DODGE JOURNEY. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V431000 (ENGINE, ENGINE COOLING); HOWEVER THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2011 DODGE JOURNEY. WHILE DRIVING AT APPROXIMATELY 50 MPH, THE VEHICLE STALLED AND WAS ABLE TO BE RESTARTED. THIS WAS A RECURRING FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE CONTACT WAS UNABLE TO REMEMBER WHAT THE TECHNICIAN STATED WAS THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 117,000.

AFTER REMOVING THE CARTRIDGE STYLE OIL FILTER FROM THE ASSEMBLY, A SPRING AND BROKEN PLASTIC PIECES FLEW OUT OF THE ASSEMBLY. THIS OCCURRED AROUND 50,000 MILES. VEHICLE WAS COVERED UNDER CERTIFIED USED CAR WARRANTY PROVIDED BY DODGE. APPEARS TO BE A COMMON PROBLEM AND THE PART HAS SINCE BEEN UPDATED ON NEW VEHICLES.

I WAS DRIVING MY KIDS TO SCHOOL WHEN THE ENGINE JUST SHUT OFF. THE POWER STEERING DID NOT WORK AND THEN THE CAR JUST STARTED BACK UP ON ITS OWN. IT HAS HAPPENED 3 TIMES SINCE THEN. I BOUGHT A NEW BATTERY AND HAD A NEW ALTERNATOR INSTALLED BUT IT DID NOT FIX THE PROBLEM. *TR

WHILE THE CAR IS IN MOTION, BEING DRIVEN, IT STALLS AT LEAST ONCE PER WEEK FOR NO APPARENT REASON! *TR

THIS CAR SHAKES VERY BAD WHEN COMING TO A STOP AND MY CYLINDER HEADS ARE MISS FIRING 2 OR 3 AT A TIME THEY MISS FIRED TO THE POINT DODGE DOESN'T KNOW WHICH ONE IT IS SO THEY WANT TO REPLACE THE MAIN HEAD. *TR

PURCHASED 3/26/13 EXPERIENCING PROBLEMS W/DODGE JOURNEY..MY 1ST CALL TO FORD3-27-13@ 4:11PM .IT CONT. ON SEVERAL OCCASIONS.4/23/13 [XXX] @ DODGE STATED CYLINDER HEAD HAD MISFIRE BUT NOT BAD ENOUGH TO SIGNAL LIGHT. REC'D CALL FROM [XXX] @FORD TO COME& CHOOSE ANOTHER CAR. 4-13-13, I STOPPED LOOKING AFTER 3RD-4TH CAR WHEN [XXX] STATED TO ME &GILBERT W DODGE CALLED &STATED WILL FIX DODGE. [XXX] ASKED ME GIVE FORD2WKS 5-7-13 TO FIX THE PROBLEM.4/24/13@ 4:30PM CAR WAS P/U FROM DODGE. 5-2-13 [XXX] N STATES HE WAS UNDER IMPRESSION ISSUE WAS TAKEN CARE OF.5/7/13 MESS. FROM [XXX] STATES "WORKING NEW LOAN TO PUT ME IN ANOTHER CAR, 5/8/13 CAR STOPPED @3:33PM TOW VEHICLE DIRECTLY TO DODGE. [XXX] KNEW ALL THAT I'VE BEEN THRU .ALL HE SAID "I AM SORRY BUT NO COOLING OFF PERIOD>DON'T WANT CAR TOO MANY PROBLEMS & I'VE BEEN HERE TOO MANY TIMES.I ASKED FOR RENTAL TOLD BY [XXX] NO BECAUSE I WASN'T KEEPING CAR.I ASKED MARK [XXX]& [XXX] IF YOUR WIFE WAS HAVING THIS PROBLEMS, WHAT WOULD YOU DO? NO ONE ANSWERED. DODGE- FOUND DEAD BATTERY& MISFIRE ON CYLINDER1,2,3,5 HEADS ONDODGE. [XXX] DID LEAK DOWN TEST.5-14-13@ 12:19PM,[XXX] STATES BOTH CYLINDER HEADS NEEDED REPLACED BE READY BY 5/17/2003. MY JOB& FAMILY IS VERY IMPORTANT TO ME. ALL OF WHAT I HAVE BEEN EXPERIENCING FORD HAS CAUSED ME TO HAVE REPEATEDLY MIGRAINES&PROLONG BACK PAIN THROUGH STRESS. I AM REQUESTING TO CLOSE CONTRACT ON DODGE JOURNEY. PLEASE REFUND $4000.00 BACK,W/ VEHICLE TAGS & LIC. PLATES FEES. ON 5/22/13DODGE [XXX] G STATES CAR SHOULD BE READY 5/24/2013.STATED A VALVE HAD FAILED & STATES PARTS WILL BE RE-MANUFACTURED PARTS. 5/24/2013@ 645P I WENT TO FORD TO GET MY CAR. CHECK BATTERY SENSOR, OIL CHANGE CAME ON.LEFT CAR NEED ALTERNATOR.5/29/2013 CAR IS NOW READY.THE PROBLEMS CAR HAS NEVER BEEN DISCLOSED TO ME,& HAS BEEN GIVEN TO ME TO DRIVE UNSAFE FOR MY DAUGHTER AND I. I AM AFRAID TO DRIVE THIS CAR, WHAT'S NEXT TO HAPPEN? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2011 DODGE JOURNEY. THE CONTACT WAS TRAVELING 55 TO 60 MPH WHEN THE ENGINE STALLED. THE CHECK ENGINE WARNING LIGHT ILLUMINATED AFTER THE FAILURE. THE VEHICLE RESTARTED AFTER THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES. THE MANUFACTURER WAS ALSO CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 16,000 AND THE CURRENT MILEAGE WAS 17,500.

TL* THE CONTACT OWNS A 2011 DODGE JOURNEY. THE CONTACT STATED THAT UPON STARTING THE VEHICLE, THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE ALSO HESITATED TO ACCELERATE FROM STOPS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT A WIRING HARNESS SHAFT NEAR THE HEAD CYLINDER WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 15,000 AND THE CURRENT MILEAGE WAS 17,383.

THIS IS THE FIRST INCIDENT 2 MONTHS AFTER I PURCHASED THIS BRAND NEW TRUCK. THE CAR HAD NO POWER AT ALL. IT WOULD NOT START. I HAD TO HAVE IT TOWED FROM MY DRIVEWAY. ABOUT 6 MONTHS LATER THE CAR WOULD NOT GO INTO GEAR THE HEAD OR BRAKE LIGHTS WOULD NOT WORK. I TOOK IT BACK TO THE DEALERSHIP WHERE I PURCHASED IT FOR THE FOURTH TIME AND IT IS HAS BEEN IN THE SERVICE CENTER ABOUT A MONTH AND THEY HAVE NO ANSWERS. I HAVE HAVE CALLED DODGE NUMEROUS TIMES AND CAN'T GET ANY HELP FROM ANYONE. THIS VEHICLE IS NOT SAFE I HAVE BEEN PULLED OVER BY POLICE NUMEROUS TIMES FOR NO LIGHTS AND STRANDED BECAUSE THE CAR WOULD NOT GO INTO GEAR. *KB