2013 Volkswagen Tiguan Brakes Problems

NORMALLY VW IS EXTREMELY INTELLIGENTLY DESIGNED BUT THEIR DESIGN OF THE ELECTRONIC BRAKE MODULE LEAVES MUCH TO BE DESIRED. THE MODULE CONSISTS OF A RECESSED ELONGATED TOGGLE SWITCH THAT ALLOWS ONE TO SET THE PARKING BRAKE AT THE FLICK OF A FINGER AS OPPOSED TO THE OLD HANDBRAKE/FOOTBRAKE PEDAL (EFFECTIVE MODEL YEAR 2013). UNFORTUNATELY, IT IS SUPER EASY TO ACTIVE THE EMERGENCY BRAKE/PARKING BRAKE BY CAUSING YOUR COFFEE CUP TO PULL UP ONE THE TOGGLE SWITCH (IF MEMORY SERVES ME RIGHT, THERE HAVE BEEN 8 ACCIDENTAL ACTIVATIONS WHILE ON THE FREEWAY.) MY PROBLEM DE JOUR WAS THE OPPOSITE. I WAS IN MY DRIVEWAY AND LATE FOR WORK AND THE PARKING BRAKE WOULDN'T DISENGAGE. I TRIED EVERYTHING FROM DISCONNECTING THE BATTERY TO WIGGLING IT BACK & FORTH AND NOTHING WORKED. MY DEALER'S QUOTE WAS APPROXIMATELY $1,500.00 WHICH CAUSED ME TO FAINT. I RAN MY BLUE DRIVER OSBD II SCANNER AND IT SHOWED NO PROBLEMS? I THEN STARED HOPELESSLY AT THE SWITCH AND NOTICED IT WASN'T FLUSH WITH THE CONSOLE, MEANING IT WAS A TOP LOADER (THANK GOD). I IMMEDIATELY REMOVED IT BUT COULDN'T UNDO THE WIRE HARNESS WITHOUT TURNING IT UPSIDE DOWN & SHAKING IT. WELL, WHEN I DID THAT...AN AMERICAN D-I-M-E FELL OUT AND UNBLOCKED THE MECHANISM. IF YOU STORE LOOSE CHANGE ON TOP OF THE TWO CUBBY HOLES ABOVE THE CONSOLE---YOU WILL RISK JAMMING THE CAR IN PARK EVEN THOUGH NOTHING ELSE IS WRONG. MY SOLUTIONS: (A) MAKE IT IDIOT PROOF BY SCOTCH TAPING A BUSINESS CARD OVER THE E-BRAKE (ONE PIECE ONLY SO AS TO MAKE IT A REUSEABLE PAPER FLAP (B) BE AS STUPID & CARELESS AS YOU ALWAYS ARE/WERE AND IF YOUR PARKING BRAKE FAILS TO RETRACT, TAKE YER FINGERNAILS AND POP OPEN THE SWITCH, REMOVE THE WIRE HARNESS (PULL THE RED TONGUE OUT FIRST), TURN IT UPSIDE DOWN AND THEN BANG IT VIOLENTLY UNTIL YOUR DIME OR TORTILLA CHIP OR PAPER CLIP OR CHERRY PIT WORKS ITS SELF OUT....OR SEE SOLUTION (A). FYI, CAR WAS STATIONARY.

TL* THE CONTACT OWNS A 2013 VOLKSWAGEN TIGUAN. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 14V441000 (FUEL SYSTEM, GASOLINE) HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIR. THE DEALER STATED THAT THEY WERE UNABLE TO PERFORM THE REPAIR BECAUSE THERE WERE NO AVAILABLE APPOINTMENTS. THE MANUFACTURER WAS MADE AWARE OF THE DELAY. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE JERKED INTERMITTENTLY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 1,798. UPDATED 10/22/14*CN UPDATED 4/8/2015 *JS

I AM A STATE TROOPER WHO INVESTIGATED A CRASH. THE VEHICLE IN QUESTION WAS INVOLVED IN THE CRASH. THE VEHICLE THAT CAUSED THE CRASH WAS A 2013 VW TIGUAN. THIS VEHICLE HAS AN ELECTRICALLY ACTUATED PARKING BRAKE. THE SWITCH, VERY SIMILAR TO A POWER WINDOW SWITCH, IS LOCATED BETWEEN THE FRONT SEATS ADJACENT TO THE CUP HOLDER. THE DRIVER, REACHING FOR THE CUP ACCIDENTALLY HIT THE PARKING BRAKE SWITCH ACTIVATING IT. THE CAR CAME TO AN IMMEDIATE STOP IN A TRAFFIC LANE OF AN INTERSTATE AND THE VEHICLE FOLLOWING STRUCK IT IN THE REAR CAUSING EXTENSIVE DAMAGE TO BOTH VEHICLES. I MANIPULATED THE SWITCH TRYING TO RELEASE THE BRAKE SO THE TOW OPERATOR COULD PULL IT UNTO THE FLAT BED OF THE TRUCK. IT WAS UNCLEAR HOW TO RELEASE THE BRAKE (I WAS UNABLE TO DO SO),OR HOW IT WAS INITIALLY ACTIVATED. THE SWITCH CAN BE PULLED UP, OR PUSHED DOWN, PRESUMABLY TO ENGAGE OR DISENGAGE THE BRAKE. IT SHOULD BE NOTED UNLIKE A PEDAL OR LEVER STYLE PARKING BRAKE, THERE IS NO WAY TO MODULATE THE AMOUNT OF BRAKING EFFORT. FROM WHAT I OBSERVED, IT APPEARS THE DRIVER GETS FULL BRAKING FORCE OR NONE AT ALL. THE LOCATION OF THE SWITCH MAKES IT EASY TO STRIKE ACCIDENTALLY EITHER BY REACHING FOR THE CUP HOLDER OR EVEN WHILE TRYING TO REPOSITION YOURSELF IN THE SEAT. *TT

BRAKE BECAME STIFF AFTER PUSHING DOWN ON THE BRAKE PEDAL APPROX 1/3 OF THE WAY AND THE CAR DID NOT COME TO A FULL STOP. AT THIS POINT ONLY PRESSING DOWN WITH FULL STRENGTH FORCES THE PEDAL DOWN FURTHER AND STOPS THE CAR. THE USUAL OPERATION IS A SMOOTH BRAKE PEDAL WHICH CAN BE PUSHED ALL THE WAY TO THE FLOOR. THIS HAS HAPPENED SEVERAL TIMES AT SEEMINGLY RANDOM INTERVALS, SOMETIMES ONE OR TWO TIMES A DAY, WITH OTHER TIMES GOING A FEW DAYS WITHOUT INCIDENT. THE DEALERSHIP MECHANICS CANNOT FIND A FAULT WITH THEIR USUAL METHOD OF TESTING. *TR