2008 Toyota Rav4 Seats Problems
3 owner-reported seats complaints from NHTSA data
Data sourced from NHTSA public database. For informational purposes only. Always consult a qualified mechanic.
Seats Recalls (2)
SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Fix: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Fix: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Owner Complaints (3)
THE DRIVER'S SEAT BACK FRAME WASN'T PROPERLY CLOSED OUT WHICH RESULTED IN THE DEGRADATION OF PADDING AND EVENTUAL CUTTING THROUGH OF THE SEAT COVER FABRIC OVER THE COURSE OF TIME. THE FRAME HAS A SHARP EDGE THAT SHOULD HAVE BEEN ROUNDED OR COVERED IN A MANNER SO AS NOT TO CUT INTO THE PADDING. AT THIS POINT THE FRAME HAS CUT THROUGH A PORTION OF THE FABRIC AND IS CUTTING INTO THE DRIVER. THE PRIMARY SAFETY CONCERN IS THE SHARP FRAME COULD CAUSE INJURY TO THE DRIVER (ESPECIALLY IF THE VEHICLE WAS REAR-ENDED IN AN OFF-CENTER, DRIVER SIDE IMPACT) BY CUTTING INTO THE DRIVER'S BACK. PER DISCUSSION WITH THEIR CUSTOMER HOTLINE TODAY, TOYOTA WILL NOT ASSIST IN THE REPAIR OF THE SEAT.
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT THE REAR SEATS BECAME WORN, FRAYED AND DAMAGED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO INSPECTED THE VEHICLE AND REPLACED THE DAMAGED REAR SEATS AT NO EXPENSE TO THE CONTACT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.
THIS IS MY EFFORT TO SUBMIT A COMMENT ON YOUR REGULATIONS, NOT A COMPLAINT OF AN INCIDENT. I WAS DIRECTED TO THIS FORM BY LOU MOLINA AT NHTSA. I AM A DRIVER WHO FOR HEALTH REASONS WISHES TO SIT ERECT. I AM NOT FAT, AND OF NORMAL HEIGHT (5'6"). THIS LAST WEEKEND I PURCHASED A RAV4. THE HEADRESTS INTRUDE INTOLERABLY INTO MY HEAD SPACE. IN ORDER TO SIT AT MY PREFERRED ANGLE AND KEEP MY BACK TO THE SEATBACK, MY HEAD IS TILTED DOWN SO THAT I MUST RAISE MY EYES TO LOOK OVER MY EYEGLASSES, OR MY STRAIGHT VISION IS DIRECTED TO THE CENTER OF THE STEERING WHEEL. I TRUST THAT THESE HEADRESTS MEET YOUR STANDARDS. IT IS MY BELIEF THAT YOU HAVE ENGINEERED THIS STANDARD FOR AN OBESE, FAT-SHOULDERED PERSON WITH TIGHT HAMSTRINGS, SOMEONE WHO PREFERS TO DRIVE RECLINED TO ACCOMMODATE HIS BELLY AND IS HELD AWAY FROM THE SEATBACK BY HIS OWN PADDING. MY PRESENT APPROACH TO BEING ABLE TO DRIVE THIS CAR IS TO TURN THE HEADREST BACKWARDS, AND I AM FULLY AWARE THAT THIS DEPRIVES ME OF THE NECK SAFETY I WOULD HAVE HAD FROM AN OLDER DESIGN OF HEADREST. I WOULD SUGGEST THAT THE COMMENTS IN SECTION VII OF RIN 2127-AH09, "SPECIFICALLY, THEY MAINTAINED THAT SMALLER FEMALE OCCUPANTS TEND TO UTILIZE STEEPER SEAT BACK ANGLES. ACCORDING TO THESE COMMENTERS, A BACKSEAT OF 50 MM MAY CAUSE SIGNIFICANT INTRUSIONS INTO THE SPACE WHERE THESE OCCUPANTS TYPICALLY PLACE THEIR HEADS, FORCING THEIR HEADS INTO AN UNNATURAL FORWARD-TILTING POSITION" IS DESCRIPTIVE OF MY SITUATION. IT IS IMPORTANT FOR THE NHTSA TO CONSIDER MINORITY AS WELL AS MAJORITY NEEDS IN DRAFTING SUCH REGULATIONS. AND IT IS IMPORTANT TO PROVIDE ALTERNATIVE SOLUTIONS TO DRIVERS WHOSE COMFORT AND SAFETY HAS BEEN DIMINISHED BY YOUR DECISIONS. THANK YOU, MELISSA READING *TR