1998 Nissan Pathfinder Fuel System Problems
9 owner-reported fuel system complaints from NHTSA data
Data sourced from NHTSA public database. For informational purposes only. Always consult a qualified mechanic.
Fuel System Recalls (1)
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
ON CERTAIN VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, TENNESSEE, VERMONT, VIRGINIA, WEST VIRGINIA , WISCONSIN AND THE DISTRICT OF COLUMBIA, DURING THE COATING PROCESS OF THE FUEL FILLER TUBE ASSEMBLY, AN INSUFFICIENT AMOUNT OF COATING MAY HAVE BEEN APPLIED AT THE LOWER MOUNTING BRACKET. THIS COULD RESULT IN AN OPENING IN THE COATING WHICH CAN ALLOW WATER TO ENTER AND MAKE CONTACT WITH THE BARE METAL OF THE TUBE.
Fix: DEALERS WILL REPLACE THE FUEL FILLER TUBE ASSEMBLY WITH A NEW ONE WITH AN IMPROVED COATING PROCESS. THE RECALL BEGAN ON NOVEMBER 26, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Owner Complaints (9)
Your 1998 Nissan Pathfinder is leaking a strong gasoline odor from the fuel system. The smell is so intense that it filled your home's first floor when the vehicle was parked in the garage with about a quarter tank of fuel. Even though the filler tube was previously replaced, the odor problem persists. You'll likely need to have the fuel system inspected and possibly have the fuel filler tube or related seals replaced again.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
Your fuel filler neck has developed rust holes, which can cause fuel leaks. This was confirmed by a Nissan dealer and the vehicle was repaired. The issue occurred at 144,000 miles. The repair will likely involve replacing the corroded fuel filler neck with a new one.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
You notice a gas smell when driving after filling up your tank, which has forced you to only fill it halfway to avoid the odor. A dealership identified a gas neck recall issue during a previous repair but said they didn't have parts available and would contact you—but never followed up over a year later. The underlying gas smell and fuel system problem should be inspected and repaired by a qualified technician.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
TL* THE CONTACT OWNS A 1998 NISSAN PATHFINDER. THE CONTACT RECEIVED A RECALL NOTIFICATION. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 07V435000 (FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: FILLER PIPE AND CAP). THE CONTACT STATED FUEL WAS LEAKING FROM THE FILLER PIPE AFTER THE RECALL REPAIR AND THAT THE RECALL REMEDY DID NOT CORRECT THE SAFETY DEFECT MENTIONED IN THE RECALL. THE AUTHORIZED DEALER WAS NOTIFIED OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 160,000.
NISSAN PATHFINDER RECALL 07V-435 R0705 FUEL FILLER TUBE AND FUEL LEAKAGE. IN JANUARY WHILE DRIVING FROM COLORADO THROUGH WYOMING OUR CAR STARTED PUTTERING AND DIED ON BUSY ROUTE 80 IN COOPERS COVE OUTSIDE OF LARAMIE, WY AT 9:30 PM IN A MAJOR SNOW STORM. ROADS WERE COVERED IN ROCK SALT AND WE WERE LUCKY TO PULL OVER TO SHOULDER WHERE WE REMAINED FOR 2 HOURS. MY 2 DAUGHTERS WERE THERE, ONE OF WHOM HAD NO COAT AS WE DID NOT EXPECT TO BE HEADING NORTH. TEMPERATURE WAS -27. WE WERE PRETRIFIED AND I KEPT THE LIGHT ON IN CAR SO TRUCKS COULD SEE US. TWO HOURS LATER THE POLICE ARRIVED AND WE WERE TOWED 40 MILES TO A NISSAN DEALER. OUR CAR REMAINED THERE FOR 3 DAYS. NOW I KNOW WHY WE WERE PUT IN HARMS WAY. WE WERE LUCKY TO PULL OVER AS THE ROAD CONDITIONS DEFINITELY AFFECTED THE CAR DYING. I HAVE THE BILL FROM MCCARTY NISSAN AND THE MOTELS. I HOPE THAT WE WILL BE SUFFICIENTLY REIMBURSED AND THAT THIS DOES NOT HAPPEN TO OTHERS. IT WAS THE MOST FRIGHTENING EXPERIENCE FOR MY FAMILY BUT THANK GOD WE WERE SAFE. MY DAUGHTER BECAME ILL FROM THE -27 DEGREE WEATHER AND OUR MOTEL ROOM WHICH HAD NO HEAT AND HAD TO CUT HER TRIP SHORT AND RETURN HOME EARLY LEAVING FROM THE COLORADO SPRINGS AIRPORT WHEN OUR VEHICLE WAS REPAIRED. REIMBURSEMENT FOR OUR REPAIRS AND INCONVENIENCE WOULD BE APPRECIATED. *TR UPDATED 05/13/09.*JB
1998 NISSAN PATHFINDER HAD A RECALL FOR THE FUEL FILLER TUBE ASSEMBLY. CONSUMER STATES THAT HE REPAIRED THE VEHICLE BEFORE THE RECALL CAME AND WANTS TO BE REIMBURSED FOR THE REPAIRS. *NJ THE CONSUMER STATED THE FUEL FILLER TUBE BEGAN LEAKING AT A RATE OF ABOUT ONE DROP PER SECOND. THE CONSUMER RECEIVED A RECALL LETTER IN THE MAIL 20 MONTHS LATER. WHEN HE CONTACTED NISSAN, HE WAS TOLD HIS VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED IN THE RECALL. RECALL# 07V435000. *JB
1998 NISSAN PATHFINDER WITH RECALL WORK DONE. CONSUMER STATED THAT THE DEALER PERFORMED THE RECALL WORK AND NOW HE WOULD LIKE TO BE REIMBURSED FOR THE RECALL REPAIR. *KB RECALL# 07V435000. *JB
TL*THE CONTACT OWNS A 1998 NISSAN PATHFINDER. IN 2006, THE CONTACT HAD HIS FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: FILLER PIPE AND CAP REPAIRED. HE RECEIVED A RECALL NOTICE IN JANUARY OF 2008 FOR THE SAME COMPONENT. ON FEBRUARY 18, 2008, THE VEHICLE WAS AT THE DEALER AND INSPECTED AND THE SAME PART THAT HE PAID TO HAVE REPLACED IN 2006 WAS AGAIN REPLACED BY NISSAN. THE CURRENT MILEAGE WAS 117,000 AND FAILURE MILEAGE WAS 101,154.
I RECENTLY RECEIVED A RECALL ON MY NISSAN FOR THE FUEL FILLER TUBE. I HAD THIS REPLACED IN SEPT. I CALLED NISSAN AND THEY SAID BECAUSE I DIDN'T HAVE IT FIXED AT A NISSAN DEALER THAT I HAVE TO BRING IT TO THE DEALER TO MAKE SURE IT WAS DONE PROPERLY. THE WOMAN SAID I WOULDN'T BE REIMBURSED FOR THAT, WHICH I THINK IS TOTALLY WRONG. I ALREADY SPENT MONEY ON HAVING IT REPAIRED. *TR