2003 Kia Sedona Suspension Problems

TL* THE CONTACT OWNS A 2003 KIA SEDONA. WHILE DRIVING APPROXIMATELY 20 MPH THE LEFT REAR WHEEL SEPARATED FROM THE VEHICLE. HE WAS ABLE TO PULL OVER ON THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE GARAGE. THE MANUFACTURER DID NOT TAKE A REPORT. THE ESTIMATED COST FOR THE REPAIR WAS $400.00. THE WHEEL BEARING SEALS, BREAK DRUM, AND MOUNTAIN PLATE MIGHT NEED TO BE REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 130,000.

TL* THE CONTACT OWNS A 2003 KIA SEDONA EX. THE CONTACT STATED THAT WHILE DRIVING SHE WOULD HEAR A LOUD NOISE. THE VEHICLE WAS TAKEN TO THE DEALER, AND THE TECHNICIAN REPLACED THE WHEEL BEARINGS. AFTER THE REPAIR THE PASSENGER FRONT TIRE EXPLODED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY FOR INSPECTION. UPON INSPECTION A MECHANIC CONCLUDED THAT THE VEHICLE NEEDED AN ALIGNMENT. HOWEVER, HE ADDED THAT BECAUSE THE WHEEL BEARINGS WERE NOT ONLY DEFECTIVE, THEY WERE IMPROPERLY INSTALLED, THEREFORE NO REPAIRS WERE MADE. THE FAILURE AND CURRENT MILEAGES WERE 72,000.

TL*THE CONTACT OWNS A 2003 KIA SEDONA EX. FOR QUITE A LENGTH OF TIME, THE CONTACT NOTICED A HUMMING NOISE IN HER VEHICLE THAT SHE THOUGHT MAY HAVE BEEN HER TIRES. SHE THEN FELT A VIBRATION THROUGH THE FLOOR OF THE VEHICLE. SHE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT HER VIN WAS NOT INCLUDED IN THE RECALL PERTAINING TO THE WHEEL BEARINGS. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC SHOP AND THEY INFORMED HER THAT THE WHEEL BEARING FAILURE WAS SO SEVERE THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE IS CURRENTLY AT THE MECHANIC SHOP. THE CURRENT MILEAGE WAS 86,355 AND THE FAILURE MILEAGE WAS UNKNOWN. THE RECALL NUMBER WAS UNKNOWN.

I PURCHASED MY 2003 KIA SEDONA IN NOVEMBER 2005. SO FAR THE FOLLOWING HAVE BEEN REPAIRED OR REPLACED: FRONT HUB ASSEMBLY LEFT SIDE ONCE, RIGHT SIDE 2X'S, THE ALTERNATOR, THE WIPER MOTOR, TWO RECALLS, THE BATTERY, NOW AT 65,000 MILES THE TRANSMISSION IS SHOT AND NEEDS TO BE REPLACED AND THE TIMING BELT HAS BEEN REPLACED. HOWEVER THE WARRANTY COMPANY SAYS THEY WONT REPLACE IT BECAUSE THE COST OF THE REPAIR EXCEEDS THE VALUE OF THE CAR. THIS IS SIMPLY OUTRAGEOUS. I HAVE BROUGHT THE CAR TO THE DEALER FOR EVERY SERVICE NEEDED. TRANSMISSION, OIL FILTER ECT. *TR

2003 KIA SEDONA, TROUBLE WITH FRONT END SUSPENSION MAKING CLUNKING NOISE. THE DEALER IDENTIFIED PROBLEM BUT CAN NOT FIX IT. THEY CONTACTED KIA DIRECT IN 2004 BUT ISSUE STILL EXIST. DUE TO PROBLEM FRONT TIRE WARE OUT. CONCERN ISSUE MAY CAUSE ACCIDENT. *JB

DT: CONSUMER STATES: THE RIGHT PASSENGER BACK END OF THE TIRE FELL OFF. HAD TO BE TOWED, THE AXLE BROKE, THE BEARING WENT OUT, AND TIRE COME OFF. ALSO, HUB ASSEMBLY CAME OFF. VEHICLE IS IN THE SHOP FOR SAME PROBLEM, AND CONSUMER HAS A LOANER VEHICLE.*AK

THE BOLTS IN ALL OF THE SEATS CONTINUED TO BECOME LOOSE. THE BACK OF THE SEAT CONTINUED TO FALL BACKWARDS OR FORWARDS. THE FRONT SUSPENSION ALWAYS HAS TO BE TIGHTENED WHEN THE CONSUMER HAS THE VEHICLE SERVICE..

THERE'S VIBRATION IN THE ENGINE COMPARTMENT AT IDLE OR DRIVING. DEALERSHIP/MANUFACTURER ARE AWARE OF THE PROBLEM, BUT DON'T HAVE A SOLUTION. *AK

THERE HAS BEEN AN ONGOING (SINCE DEC. 2003) PROBLEM OF A "THUDDING" NOISE FROM THE FRONT SUSPENSION. THE DEALER HAS ACKNOWLEDGED THE NOISE REPEATEDLY. THE SERVICE REP STATES THAT KIA MOTORS IS AWARE OF THE NOISE BUT DOES NOT HAVE A SOLUTION. HE ALSO SAID THAT THE DEALERSHIP GETS NEW '05 SEDONAS OFF THE DELIVERY TRUCKS WITH THE SAME PROBLEM! NO SOLUTION HAS BEEN OFFERED OTHER THAN "WELL, IT'S NOT GOING TO HURT ANYTHING OR BREAK DOWN AND LEAVE YOU STRANDED." BUT COME ON, A BUMPING, THUDDING NOISE FROM A VEHICHLE WITH 20K MILES.....OR A BRAND NEW VEHICHLE?!? SOMETHING HAS GOT TO BE DONE TO FIX THIS .*AK

I'VE HAD A NUMBER OF PROBLEMS WITH MY 2003 KIA SEDONA. INITIALLY ONE OF THE GASKETS LEAKED AND HAD TO N BE REPLACED. THE WINDSHIELD CRACKED OVERNIGHT IN THE GARAGE WHEN THERE WAS NO WEATHER EXTREMES. THE WHEEL BEARINGS WENT IN THE FRONT TIRE. RECENTLY THE ENGINE HAD TO BE REPLACED BECAUSE IT WAS LEAKING AND AFTER REPLACING ALL THE GASKETS IT COULDN'T GET PRESSURE. THE DRIVER'S DOOR HANDLE BROKE, THE LUMBAR SUPPORT STOPPED WORKING. THE HOOD WOULDN'T CLOSE PROPERLY. AND ON TOP OF ALL THOSE THINGS I'VE HAD 2 BLOWOUTS TO THE FRONT DRIVER'S TIRE IN A 2 YEAR PERIOD. THE DEALER SAYS THERE IS NOTHING WRONG WITH THE WHEEL BUT I'M NOT SURE HE EVEN CHECKED BECAUSE OF THE ENGINE PROBLEMS HE HAD TO DEAL WITH. *JB

WHILE DRIVING 55 MPH, A LOUD RATTLING NOISE WAS HEARD FROM THE REAR. THE DRIVER WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER A FIX FOR THIS VEHICLE WAS NOT AVAILABLE. PLEASE FILL IN ADDITIONAL INFORMATION. *LA

THUMPING NOISE IN LEFT FRONT FROM STRUT WHEN GOING OVER BUMPS KIA IS AWARE OF SITUATION AND DOES NOT KNOW HOW TO RECTIFY