2009 Hyundai Santa Fe Fuel System Problems

You noticed a strong smell of gasoline coming from your air vents while driving with your children. When you opened the hood, you found the engine area was wet with fuel, and your brother traced the leak to the front fuel rail. You'll need to have the fuel rail replaced, which typically requires dealership service or a qualified mechanic since it's a critical fuel system component.

The vehicle's check engine light came on and the fuel gauge shows "E". I did an OBD scan and it shows the fuel sending unit has issues. The gauge will work intermittently and the check engine light will go away. Further reviews from others show the same issues with their vehicle with each needing a bad sending unit replaced.

2009 Hyundai Santa Fe Stalls out/DEATH TRAP, occasionally with no warning, seem to be when going up or down hills usually with quarter tank of gas approx. Possibly when decelerating. We have replaced both fuel pumps and it was ok for a while. The other day I was going down steep hill and it quit, i coasted to bottom and tried at least 10 times to restart. A DEATH TRAP for people, i had cars flying up on me almost rear ending me even thou I had my emergency flashers were on and my arm out the window flagging then around. I let car sit still a few minutes and it finally cracked. I started looking online for solutions but found many 2009 Santa Fe's have this problem. I called Hyundai and no Recall. I have already spend over $500 trying to repair this. I do see settlement against Hyundai for this problem on other years. They seem to know it is a problem but are not fixing unless forced. Please help.

MY GAS GAGE STARTED TO WORK IMPROPERLY. I TOOK IT TO A MECHANIC I TRUST. HE TOLD ME THE FUEL PUMP SENDERS WERE BAD. AFTER HE REMOVED THEM HE CALLED ME TO TELL ME I WAS LUCKY MY VEHICLE DIDN'T CATCH FIRE OR BLOW UP! ONE SENDER HAS INSULATION BROKEN AND THE WIRE IS EXPOSED. HE ALSO FOUND THAT AN INTERNAL WIRE WAS EVEN WORST. THE PROTECTIVE CONNECTOR WAS GONE! THAT LEFT THOSE WIRES WITH NO PROTECTION. THEY SHOW SIGNS OF BAD CORROSION ON BOTH THE WIRES AND THE TERMINALS. THEY APPEAR TO MAYBE EVEN HAVE SHORTED OUT. THEY ARE BLACK AND A RUST ORANGE COLOR. THEY ARE ALSO PITTED. I CONTACTED HYUNDAI. THEY DIDN'T SEEM TO CARE. THEY WERE MORE CONCERNED THAT I HADN'T BROUGHT MY CAR TO A DEALER FOR OVER FIVE YEARS. I EXPLAINED THAT TWO DIFFERENT DEALERSHIPS HERE IN MIAMI HAD CHEATED ME AND TREATED ME BADLY. THE REPRESENTATIVE WAS TRYING TO INSIST IF I HAD BROUGHT MY VEHICLE IN THEY WOULD HAVE DISCOVERED THE PROBLEM SOONER. THAT IS JUST NOT TRUE. THEY ONLY WAY TO OBSERVE THIS PROBLEM WAS TO PHYSICALLY REMOVE THE BACKSEAT AND OPEN THE FLOOR TO EXPOSE THE GAS TANK AND THEN REMOVE THE PUMP! THEY WILL NOT DO ANYTHING! I HAVE THE FEELING THAT THEY WON'T EVEN REPORT THIS TO THEIR OWN COMPANY OR TO YOU. I STILL HAVE THE PARTS. THEY WERE ALSO NOT INTERESTED IN SEEING THEM OR PICTURES. THEY JUST DON'T CARE! WHAT IF MY CAR CAUGHT FIRE? WHAT IF THE FUMES IGNITED? ANYONE IN THE BACKSEAT WOULD HAVE BEEN EITHER KILLED OR INJURED!

FILLED UP WITH GAS AND DID SOME GROCERY SHOPPING WITH MY WIFE. AFTER ABOUT 15 MINUTES, WE STARTED SMELLING STRONG FUEL COMING THROUGH AIR VENTS WHILE DRIVING AROUND. GOT HOME AND REMOVED ENGINE COVER AND SPOTTED FUEL SEEPING FROM THE FUEL RAIL ABOVE THE FUEL INJECTORS. THE FUEL RAIL TUBE IS MADE OF PLASTIC AND HAD CRACKED.

CHECK ENGINE LIGHT ON FOR FAILED FUEL LEVEL SENSOR. GAS GAUGE IS ERRATIC. WHEN I START THE CAR THE GAUGE FALLS TO EMPTY. NEVER KNOW EXACTLY HOW MUCH GAS I HAVE. VERY COSTLY TO REPAIR.

FUEL GAUGE BECAME ERRATIC AND TRIGGERED CHECK ENGINE LIGHT TO COME ON ALSO IT WILL FLUCTUATE A LITTLE BIT WHEN IT HITS THE 1/4 MARK AND THE LOW FUEL LIGHT WILL COME ON. IT WILL GO FROM 1/4 TO EMPTY CAN NOT TELL HOW MUCH FUEL IS IN THE TANK. WHEN I FILL THE TANK IT REGISTERS EMPTY AND THE AND THE LOW FUEL LIGHT INDICATOR COMES ON. STARTING THE CAR AGAIN ON THE SAME DAY OR THE NEXT DAY, THE GAGE COMES UP AGAIN TO THE FULL OR HALF WAY MARK AND THE LIGHT GOES OUT. THE CAR STALLS WHILE IN CITY TRAFFIC CAUSING A DANGEROUS SITUATION ANOTHER CAR COULD CRASH INTO ME.

THE FUEL GAUGE VARIES WIDELY. IT IS DIFFICULT TO KNOW AT TIMES HOW MUCH GAS THE CAR TRULY HAS. THIS SEEMS TO BY A SYSTEMIC PROBLEM WITH THIS VEHICLE.

GAS GAUGE HIGHLY INACCURATE. FUEL WARNING LIGHT GOES ON AND CHECK ENGINE LIGHT ALSO APPEARS. HAVE TO PULL OVER AS AFRAID TO DRIVE. FINALLY GO TO NEAREST GAS STATION ONLY TO FIND OUT THAT GAS TANK WAS STILL HALF FULL. THIS HAS HAPPENED A NUMBER OF TIMES. VEHICLE HAS ONLY 60,000 MILES.

FUEL GUAGE DOES NOT WORK PROPERLY. FLUCTUATES GREATLY CAUSING POTENTIAL SAFETY ISSUE IF ONE WERE TO RUN OUT OF GAS ON THE HIGHWAY. CHECK ENGINE LIGHT ON AFTER FILLING GAS TANK.

BOTH FUEL LEVEL SENSORS WENT BAD

CAR DOES NOT WANT TO START AFTER FILLING WITH GAS. IT DOES NOT MATTER IF 5 OR 15 GALLONS ARE PUT IN.

BOTH OF THE FUEL GAUGES WOULD DROP DOWN TO EMPTY WYNFALL WHILE STATIONARY. IF I TURN OFF MY CAR THEN TURN IT BACK ON IT WOULD STAY EMPTY EVEN AFTER BEING AT THE GAS STATION. I DO NOT KNOW HOW MUCH GAS I HAVE LEFT IN MY CAR AND HAS BEEN ON GOING PROBLEM AND A SAFETY ISSUE

ALL OF A SUDDEN THE GAS GAUGE DOES STOPPED READING FUAL PROPERLY.. I NEVER KNOW HOW MUCH GAS I HAVE. ON ONE OCCASION I WAS DRIVING TO WORK EARLY IN THE MORNING THE VEHICLE STUDDARD I PUT ON MY HAZARD LIGHTS AND HAD TO MANEUVER QUICKLY TO AVOID BEING HIT IN THE REAR. I FOUND OUT I HAD RUN OUT OF GAS. ATTACHED IS A LINK WITH OTHER OWNERS WITH THE SAME ISSUE. IT DOESN'T MATTER HOW MUCH GAS I PUT IN IT I DO NOT GET CORRECT READING. IF I PUT $30 WORTH OF GAS IN MY VEHICLE IT WILL ONLY READ HALF FULL. I FEEL THIS IS A DANGER BECAUSE I NEVER KNOW WHEN I RUN OUT OF GAS AND BEING ON THE HIGHWAY ALL OF A SUDDEN RUNNING OUT OF GAS IS A SAFETY ISSUE. HTTP://WWW.CARPROBLEMZOO.COM/HYUNDAI/SANTAFE/OTHER-FUEL-SYSTEM-FUEL-GAUGE-PROBLEMS.PHP

VEHICLE STALLED IN ROAD, ONCE ON LEVEL GROUND EXITING A PARKING LOT GOING STRAIGHT AND IN MOTION CROSSING TRAFFIC AND ABOUT TO TURN LEFT, ONCE ON SLIGHT DECLINE IN MOTION TURNING RIGHT. AFTER SITTING FOR A FEW MINUTES EACH TIME, CAR RESTARTED. HEAVY GAS SMELL IN CAR. FUEL SENDERS HAD BOTH BEEN REPLACED TWICE (SECOND TIME RIGHT AFTER FIRST STALL) BUT FUEL GAGE STILL MALFUNCTIONING. FUEL LEVEL INDICATION UNRELIABLE.

FUEL GAUGE WENT UP AND DOWN. RAN OUT OF GAS GOING 70MPH ON TURNPIKE IT WAS HARROWING. GAUGE SAYS FULL AND THEN EMPTY RIGHT AWAY. FUEL SENSORS NEED REPLACED, CHECK ENGINE LIGHT IS NOW SHOWING. I NOTICE MANY OTHERS WITH THE SAME PROBLEM. MINE COULDVE CAUSED A BAD ACCIDENT. OUTRAGEOUSLY EXPENSIVE AND COST PROHIBITIVE TO FIX WHAT I THINK IS A SAFETY ISSUE. 70,000 MILES IS NOT A LOT FOR THIS TO HAVE HAPPENED.

THE CHECK ENGINE LIGHT COMES ON WHEN YOU ARE AROUND A HALF A TANK OF GAS AND EVEN IF YOU FILL IT UP IT TAKES IT 2 OR 3 TIMES OF STARTING IT FOR IT TO GO OFF. I'M NOT SURE WHAT IS CAUSING THIS. ALSO THE ESC AND THE ABS LIGHTS HAVE BEEN ON AND WON'T GO OFF. THE BOOK SAYS THE ABS LIGHT IS FOR SERVICE BUT I HAVE HAS IT SERVICED SEVERAL TIME AND IT STILL DOESN'T GO OUT.

THE FUEL GAUGE FLUCTUATES ALL THE TIME. SOMETIMES I GET A READING BUT MOST TIMES IT TURNS ON THE EMPTY LIGHT . I HAVE CONSULTED SEVERAL HYUNDAI DEALERS MECHANICS AND BEEN TOLD THAT THIS IS A BIG AND FREQUENT PROBLEM. I HAVE READ OF SO MANY COMPLAINTS , THAT I DON'T UNDERSTAND WHY THERE HASN'T BEEN A RECALL ON SAID DEFECT. .IT IS AS YOU KNOW VIRTUALLY IMPOSSIBLE AND VERY EXPENSIVE AND DANGEROUS FOR ME TO TRY TO FIX..I'VE RAN OUT OF GAS SEVERAL TIMES AND HAVE BEEN IN HARMS WAY.

AFTER FILLING GAS TANK THE FUEL GAUGE WENT TO EMPTY AND THE CHECK ENGINE LIGHT CAME ON. BAD FUEL SENSOR

THE FUEL SYSTEM LIGHT KEEPS COMING ON, I PUT GAS IN IT BUT IT KEEPS TELLING ME THAT THE TRUCK IS EMPTY AND IT SOMETIMES STALLS. THEN IT I LET IT SIT A DAY OR 2, THEN THE GAS ARROW STARTS TO MOVE UP AND DOWN, I AM SCARED TO DRIVE IT, MOST OF THE TIME IT DOESN'T SHOW IF I HAVE GAS OR NOT.

OIL LEAK FROM VALVE COVER GASKET WHICH HAS BEEN FIXED ON TWO DIFFERENT OCCASIONS. AND GAS METER IS NOT READING THE CORRECT LEVEL OF GAS.

CHECK ENGINE LIGHT IS ON AND GAS GAUGE SHOWS EMPTY EVEN AFTER FILLING UP TANK.THE PROBLEM STARTED AT AROUND 100,000 MILES ( GIVE OR TAKE) MECHANIC SAID IT THE FUEL SENSOR ON DRIVER'S SIDE AS PER ELECTRONIC READING.A RECALL MUST BE ISSUED FOR THIS DANGEROUS DEFECT. ITS PLAIN TO SEE ITS A COMMON ISSUE. I ALREADY RAN OUT OF GAS DURING MY MORNING COMMUTE ON NYC WESTSIDE HIGHWAY & FDR DRIVE, I LITERALLY ALMOST DIED THE 1ST TIME IT HAPPENED.

SERIOUS FUEL GAUGE MALFUNCTION. GAUGE ALWAYS READS EMPTY, EVEN AFTER A FILL UP. GAUGE CONTINUES TO READ EMPTY WHETHER STATIONARY, IN MOTION, ON A CITY STREET, TURNING BRAKING, ETC. I BELIEVE THE CAUSE OF THE SAFETY RISK IS A FAILED FUEL SENDER ASSEMBLY, LIKELY PARTS 94460-0W000 AND 94430-0W000. THIS APPEARS TO BE A WIDESPREAD PROBLEM IN THE 2009 HYUNDAI SANTA FE MODEL. DEFINITELY A SAFETY HAZARD, AS I CANNOT TELL HOW MUCH FUEL IS IN MY TANK WHILE DRIVING. ANOTHER COMMON ISSUE WITH THIS MAKE AND MODEL IS A FAILURE OF THE PURGE VALVE. THIS HAS ALSO HAPPENED IN MY VEHICLE. THIS DEFECT WILL PROHIBIT THE CAR FROM STARTING IF YOU FILL UP A FULL TANK. SO, THE DRIVER IS FORCED TO FILL UP LESS THAN A FULL TANK SO THAT THEY CAN BE CONFIDENT THAT THE CAR WILL START AFTER PUTTING GAS IN THE VEHICLE. THIS IS A LESS SERIOUS HAZARD THAN THE FUEL GAUGE, BUT WORRISOME NONETHELESS.

FUEL GAUGE DOES NOT READ PROPERLY WILL GO FROM FULL TO EMPTY LEADING TO RUNNING OUT OF FUEL WHILE DRIVING

TL* THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT NOTICED THAT THE FUEL GAUGE DISPLAYED AN INCORRECT READING. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 52,000.

FUEL SENDERS ARE FAILING. CHECK ENGINE LIGHT COMES ON AND FUEL GAUGE SHOWS NEAR EMPTY EVEN WHEN VEHICLE HAS FULL TANK.

LIKE THE OTHER POSTED COMPLAINTS, MY 2009 SANTA FE IS HAVING FUEL GAUGE ISSUES. IT NEVER SHOWS THE CORRECT LEVEL. I CHANGED THE FUEL CAP BUT THIS DID NOTHING TO SOLVE THE PROBLEM. MY CHECK ENGINE LIGHT COMES ON BECAUSE OF THIS PROBLEM. THE READOUT COMES BACK: "FUEL LEVEL SENSOR". THIS CAN BE A DANGEROUS SITUATION AND WILL PREVENT ME FROM PASSING A STATE INSPECTION. I USE MY TRIP ODOMETER TO GAUGE WHERE I AM WITH FUEL TANK LEVEL. I HAVE TO SET MY TRIP TO ZERO AT EVERY FILL-UP. AT 144 MILES I KNOW I'M AT 1/2 A TANK ROUGHLY. THIS IS AN ISSUE THAT HYUNDAI IS REFUSING TO ADMIT TO SO THEY CAN SAVE MONEY. MAYBE THIS ISN'T AN AIR BAG, BUT, IF I LOAN MY CAR TO MY DAUGHTER AND SHE RUNS OUT OF FUEL ON A HIGHWAY......I DON'T WANT TO THINK ABOUT IT. FORCE HYUNDAI TO FIX THIS!

THE FUEL GAUGE SLOWLY OSCILLATES BETWEEN THE (ASSUMED) CORRECT VALUE AND ZERO, OFTEN TRIGGERING THE LOW-LEVEL LIGHT. IT MAKES IT IMPOSSIBLE TO BE CONFIDENT ABOUT HOW MUCH GAS YOU HAVE IN THE VEHICLE. IT DOESN'T MATTER IF THE VEHICLE IS STATIONARY, IN MOTION, OR WHAT KIND OF DRIVING CONDITION YOU ARE IN, OR WHETHER THE ENGINE IS RUNNING OR NOT. IT SEEMS TO BE A MALFUNCTION IN THE SENSOR OR ELECTRONIC CONTROLS. MY LOCAL DEALER SAID THIS IS A COMMON ISSUE (~$400 TO FIX) BUT HYUNDAI HASN'T ISSUED A RECALL BECAUSE IT'S NOT A "SAFETY ISSUE". THIS IS A SAFETY ISSUE AS YOU ARE NEVER SURE WHETHER IT IS CORRECTLY INDICATING A LOW FUEL LEVEL OR NOT... I WORRY ABOUT MY 16 YEAR OLD DAUGHTER DRIVING BY HERSELF AT NIGHT WITHOUT KNOWING WHETHER SHE HAS ENOUGH GAS OR NOT TO MAKE IT HOME! IF THIS IS A KNOWN/COMMON ISSUE FOR THIS MAKE/MODEL IT SHOULD BE RECALLED AND REPAIRED BY HYUNDAI.

FUEL INDICATOR GAUGE FLUCTUATES SEVERELY AND DOES NOT SHOW CORRECT LEVEL. SINCE THE LEVEL IS INCORRECT, AND THE WARNING INDICATOR DOES NOT FUNCTION, THIS CAN CAUSE THE VEHICLE TO UNEXPECTEDLY RUN OUT OF FUEL AND SHUT DOWN THE ENGINE WHILE DRIVING. THIS CAUSES DANGEROUS DRIVING CONDITIONS. THERE ARE NUMEROUS COMPLAINTS ABOUT THIS ISSUE.

GAS GAUGE DOES NOT REGISTER AMOUNT OF GAS THAT IS IN THE TANK. FILL UP TANK AND GAUGE REMAINS A EMPTY OR GOES TO FULL AND THE QUICKLY MOVES TO EMPTY. MANY COMPLAINTS ABOUT SAME ISSUE WITH 2009 SANTA FE. SAFETY ISSUE BECAUSE YOU NEVER KNOW HOW MUCH GAS YOU HAVE AND CAN VERY EASILY RUN OUT OF GAS ON A MAJOR HIGHWAY CAUSING A MAJOR ACCIDENT.

I NOTICED THE FUEL GAUGE WAS ERRATIC AND MOSTLY INCORRECT. AFTER A COUPLE OF WEEKS IT QUIT WORKING AT ALL. IVE TRIED TO RESET THE TRIP ODOMETER AND KEEP UP WITH THE AMOUNT OF GAS I SHOULD HAVE IN THE TANK. I GAVE OUT OF GAS ON AN INTERSTATE AT 11PM IN SUB FREEZING WEATHER. THE DEALERSHIP DIAGNOSED THE FUEL SENSOR AS THE PROBLEM. I'VE NOTICED SEVERAL HUNDREDS OF SIMILAR COMPLAINTS HERE. THE ESTIMATED FIX IS $500. ADDITIONALLY THERE IS A HISSING SOUND FROM THE TANK WHEN I STOP TO FILL UP. UPON FILLING THE TANK THE ENGINE WILL NOT CRANK INITIALLY. IT APPREARS TO BE FLOODING THE ENGINE WITH GASOLINE. IF IM PATIENT I WILL EVENTUALLY GET IT CRANKED. WHEN I PULL OFF IT SHUTS OFF. THIS CONTINUES AS I INTENTIONALLY DRIVE AROUND IN THE PARKING LOT DUE TO HAVING THIS HAPPEN ONCE AFTER PULLING OUT ONTO THE HIGHWAY ALMOST CAUSED AN ACCIDENT. I AM A RETIREE ON FIXED INCOME. THE AUTO WILL NOT PASS NC EMISSIONS INSPECTION DUE THIS MONTH UNTIL THE CHECK ENGINE LIGHT GOES OFF.

THE FUEL READING FLUCTUATES CONTINUOUSLY WITH INCORRECT READINGS SOMETIMES IT SAYS EMPTY WHEN IT'S FULL OR HAS A SIGNIFICANT AMOUNT OF GAS IN IT. THEN THE CHECK ENGINE LIGHT COMES ON. I TOOK IT TO AN AUTO CARE SHOP TO HAVE THEM USE THEIR COMPUTERIZED SYSTEM TO SEE WHY MY CHECK ENGINE LIGHT IS ON. IT SHOWED THE CODES P0464 AND P0463. THIS IS THE FUEL SENSOR CIRCUIT AND IT IS EXTREMELY DANGEROUS BECAUSE YOU COULD BE DRIVING AND THE GAGE SUDDENLY READS EMPTY AND YOUR CAR SHUTS DOWN. IF YOUR ON THE HIGHWAY AND THIS HAPPENS YOUR DEAD! THIS IS HAPPENING TO SO MANY HYUNDAI SANTA FE'S YET NO ONE IS DOING ANYTHING ABOUT IT. THIS NEEDS TO BE ADDRESSED ASAP OR THERE WILL BE EXTREME CONSEQUENCES! THIS HAPPENS WHEN THE VEHICLE IS IN MOTION WHEN IT'S STATIONARY AND EVERYTIME YOU START THE CAR! IT IS SO DANGEROUS AND I'M AFRAID TO DRIVE MY CAR NOW

2009 HYUNDAI SANTA FE LIMITED WITH A 3.3 LITER ENGINE WITH APPROXIMATELY 53,500 MI. I WAS SETTING STOPPED ON A CITY STREET WITH MY FOOT ON THE BRAKE WHEN THE ENGINE SUDDENLY STARTED REVVING UP AS FAST IT COULD GO (APP 6K TO 7K RPM'S). IT WAS ALL I COULD DO TO KEEP THE VEHICLE FROM TAKING OFF AND SLAMMING INTO THE VEHICLE IN FRONT OF ME. IT WAS CREEPING ALONG AND TAPPED THE TRUCK IN FRONT OF ME WHEN I GOT THE VEHICLE IN NEUTRAL AND THE ENGINE SUDDENLY SLOWED DOWN. I HAVE TAKEN THE VEHICLE TO THE DEALER WHICH NOT TO MY SURPRISE CANNOT FIND ANYTHING WRONG WITH IT. AFTER I TALKED TO THE OWNER OF THE DEALERSHIP THEY CONTACTED HYUNDAI WHO IS SUPPOSEDLY LOOKING INTO IT. NOT THAT I BLAME HER MY WIFE IS VERY RELUCTANT TO DRIVE IT UNLESS THEY CAN FIX THE PROBLEM. *TR

MY FUEL GAUGE IS NOT WORKING NOW THE ENGINE LIGHT HAS COME ONE

FAULTY FUEL SENSOR GAUGE. WHEN TRYING TO FILL AN EMPTY TANK THE PUMP SHUTS OFF AFTER ONLY A COUPLE OF GALLONS. IF I WASN'T PAYING ATTENTION I WOULD HAVE THOUGHT IT WAS FULL. I'VE SEEN COMPLAINTS THAT THE FUEL GAUGE STOPS WORKING ON THIS CAR AT SIMILAR MILEAGE, IF THAT HAPPENS TOO I WON'T KNOW HOW MUCH GAS IS IN MY CAR. I COULD THEN RUN OUT OF GAS WHILE DRIVING AND LOSE POWER STEERING. THIS IS AN ACCIDENT HAZARD. *TR

TL* THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. WHILE DRIVING VARIOUS SPEEDS, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE FUEL GAUGE DISPLAYED AN INCORRECT READING. THE DEALER DIAGNOSED THAT THE FUEL SENDER ASSEMBLY AND FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 95,000. UPDATED 01/05/2017*CT

HAVE HAD THE SAME ISSUE AS OTHERS. FUEL GAUGE ISN'T WORKING, OR WORKS ERRATICALLY. CHECK ENGINE LIGHT IS INTERMITTENT. NEVER KNOW IF THE ENGINE LIGHT IS STILL ON FOR FUEL ISSUE OR SOMETHING DIFFERENT, THAT COULD BE CONSIDERED DANGEROUS. CODE RETURNED AS FUEL SENSOR OR SENDING UNIT. I NOW BELIEVE IT HAS CAUSED ISSUES WITH MY CATALYTIC CONVERTER. WHAT DOES IT TAKE FOR HYUNDAI TO STEP UP TO THE PLATE?? I WILL NEVER BUY THIS AGAIN. TOO MANY PROBLEMS THAT NO ONE CAN FIX. I SWEAR THIS CAR IS HAUNTED!

I WANT TO JOIN THE MANY OTHERS WHO HAVE LAUNCHED COMPLAINTS ON THIS AND OTHER WEBSITES ABOUT THE FAULTY FUEL GAUGE SENSORS OF THE 2009 SANTA FE. WHEN I FILL MY GAS TANK, THE FUEL GAUGE ONLY REGISTERS AT HALF A TANK AND THE LOW FUEL LIGHT COMES ON. NOW MY CHECK ENGINE LIGHT IS ON. WHEN I BROUGHT THE VEHICLE TO AUTO ZOHN TO HAVE THE ENGINE LIGHT CHECKED, IT DOES, INDEED, COME UP AS A FAULTY FUEL LEVEL SENSOR. HYUNDAI IS OBVIOUSLY AWARE OF THIS PROBLEM AS EVIDENCED BY ALL OF THE CONSUMER FEEDBACK, YET IT HAS FAILED TO DO ANYTHING TO ASSIST. UNLIKE THEIR COUNTERPARTS AT TOYOTA, VOLKSWAGEN AND CHRYSLER, IT SHOULDN'T TAKE A TRAGEDY FOR HYUNDAI TO STEP UP AND ADDRESS THIS SAFETY CONCERN.

STARTING ON JULY 15, 2016, THE CHECK ENGINE LIGHT (MIL) CAME ON, AS WELL THE FUEL GAUGE INCORRECTLY INDICATING THE AMOUNT OF FUEL, IN THE FUEL TANK, AT 107130 MILES. I HAD THE MIL DIAGNOSED AS P0464, FUEL SENSOR DEFECT. MANY OTHER HYUNDAI SANTA FE OWNERS, HAVE REPORTED THIS PROBLEM, REQUESTING FINANCIAL ASSISTANCE TO REPAIR THIS SIGNIFICANT SAFETY PROBLEM, TO HYUNDAI CUSTOMER SERVICE, TO NO AVAIL. THEIR RESPONSE HAS BEEN IT IS NOT THEIR CONCERN AND HAVE NOT OFFERED TO PROVIDE FINANCIAL ASSISTANCE. IF I WERE TO BE DRIVING AT HIGHWAY SPEED, E.G., 55-75 MPH, AND HAVE THE ENGINE SHUT DOWN, DUE TO LACK OF FUEL, THE POWER STEERING WOULD BE SIGNIFICANTLY IMPAIRED, WITH LOSS OF CONTROL. THIS COULD LEAD TO LOSS OF CONTROL OF MY VEHICLE, WITH SUBSEQUENT PROBABILITY OF AN "ACCIDENT", RESULTING IN PERSONAL INJURY, RESULTING IN DEATH, TO ME AND MY FAMILY MEMBERS, AS WELL AS OTHERS, AS WELL AS SERIOUS PROPERTY DAMAGE. THE COST FOR REPLACEMENT OF THE FUEL LEVEL SENSORS IS APPROXIMATELY $600.00 TO $800.00. THIS FUELS SENSOR PROBLEM AND MIL, OCCURS WHEN STATIONARY, WHEN THE IGNITION SWITCH IS TURNED TO START, AS WELL AS WHEN IN MOTION, AT ANY SPEED. I BELIEVE THAT BEFORE SOME DISASTROUS EVENT OCCURS, HYUNDAI SHOULD ASSIST IN THE REPLACEMENT OF THESE DEFECTIVE FUEL SENSORS.

FUEL SENSOR SHOWS GAS LEVEL ERRATICALLY BOTH ON GAUGE AND DIGITAL DISPLAY, USUALLY WHEN FUEL LEVEL IS BELOW 1/3 LEFT IN TANK. CHECK ENGINE LIGHT ALSO THEN DISPLAYS ERRATICALLY. THIS HAPPENS ONLY WHEN VEHICLE IS STOPPED IN TRAFFIC OR IN PARKED POSITION WITH ENGINE ON. HAPPENS ONLY ,SO FAR, IN STOP AND GO TRAFFIC AND NOT ON THE HWY. HAS BEEN OCCURRING SINCE MAY 2016 WITH 105,000 MILES.

AROUND 90,000 MILES MY FUEL SENSOR STARTED NOT WORKING THE CHECK ENGINE LIGHT WILL COME ON AND THE NEEDLE WILL GO UP AND DOWN AS WELL AS THE DIGITAL MILES LEFT ON TRIP, I BOUGHT AN EXTENDED WARRANTY WHEN I PURCHASED THE VEHICLE, BUT IT ONLY LASTED UNTIL 80,000 MILES OF COURSE. THE SENSOR BARELY WORKS AND WHEN IT DOES IT ONLY LASTS FOR A LITTLE WHILE. I HAVE TO KEEP TRACK MYSELF OF HOW MUCH GAS IS IN THE CAR. I HAVE SEEN SEVERAL COMPLAINTS ABOUT THIS ISSUE AND RECALLS FOR MUCH LESS. I DO NOT THINK VEHICLE OWNERS SHOULD HAVE TO PAY TO REPLACE THESE SENSORS AND/OR FUEL PUMPS WHEN THIS IS CLEARLY A DEFECT BY HYUNDAI. I WILL NEVER PURCHASE ANOTHER HYUNDAI AGAIN.

THE CHECK ENGINE LIGHT AND LOW FUEL LIGHT COME ON EVEN WITH A FULL TANK OF GAS. I'VE RECEIVED SEVERAL ESTIMATES TO HAVE THE FUEL SENSOR REPLACED AND IT WILL COST ANYWHERE FROM $600 TO $700. THIS SHOULD BE A RECALL CONSIDERING THE AMOUNT OF PEOPLE WITH THE SAME PROBLEM AND SAFETY ISSUES.

ABOUT A MONTH AGO MY ENGINE LIGHT KEPT COMING ON AND EVERY TIME I FILLED THE TANK WITH GAS THE CAR WONT START UNLESS I KEEP THE FOOT ON THE GAS WHILE TURNING THE IGNITION KEY THEN I HAVE TO SWITCH THE GEAR TO DRIVE WITH A FOOT ON THE BRAKE AND ONE ON THE GAS. I TOOK IT TO THE DEALERSHIP AND HAD TO REPLACE THE PURGE VALVE AND THE PURGE HOSE. NOT EVEN A WEEK I WENT TO FILL THE TANK AND MY GAUGE DROPPED TO EMPTY AND WHILE I DRIVE IT STARTS TO GO UP AND DOWN CONSTANTLY IT IS HARD TO TELL HOW MUCH GAS YOU HAVE, I NOTICE IS VERY COMMON ON THIS MAKE AND MODEL AND YEAR. THIS SHOULD BE A RECALL SINCE IT IS A SAFETY HAZARD.

MY ADDRESS IS [XXX]. MY NAME IS [XXX]. THE PROBLEM IN MY CAR IS FUEL LEVEL SENSOR WHEN I DRIVE IN HIGHWAY MY FUEL GAUGE IS GOES CRAZY THEIR GOING UP THEN DOWN THEN WARNING LIGHT NO FUEL IN TANK BUT FUEL IS FULL THAT THE PROBLEM IN MY CAR. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

AFTER FUELING MY CAR, THE GAS GAUGE IMMEDIATELY DROPPED TO EMPTY AND THE LIGHT WOULD COME ON. WHILE DRIVING IT WOULD THEN SLOWLY CREEP UP TO ABOUT 3/4 OF A TANK. AT THE HALF WAY MARK, IT WOULD GO UP AND DOWN GRADUALLY SO THAT I COULD NEVER TRUST HOW MUCH GAS WAS TRULY IN MY TANK, LEADING ME TO ALWAYS WANT TO REFUEL AT THE HALFWAY MARK. THIS HAPPENED CONTINUALLY IN BETWEEN FUELING AND NEVER CORRECTED ITSELF.

AT APPROX 65000 MILES OF NORMAL DRIVING FUEL GAUGE BECAME ERRATIC AND UNRELIABLE. GUAGE READS ANYWHERE FROM FULL TO ONE EIGHTH AND FLUCTUATES ALMOST CONSTANTLY REGARDLESS OF ACTUAL FUEL LEVEL. CHECK ENGINE LIGHT ON PRODUCED ERROR CODE P0464. THIS IS A DANGEROUS SITUATION.

CK ENGIN LIGHT COMES ON CODE P0464 NOT A LL UNCOMMON.

CHECK ENGINE LIGHT CAME ON. FUEL GAUGE READ EMPTY. I HAD JUST FILLED UP A DAY OR SO PRIOR. I TOOK TO MY MECHANIC HE SAID THAT IT IS THE FUEL SENSOR. SO I FILL UP THE CAR AND RESET MY TRIP TO 0 EVERY TIME I FILL UP NOW. OTHERWISE I HAVE NO IDEA HOW MUCH GAS IS IN THE CAR...THE FUEL GAUGE JUMPS AROUND...SOMETIMES IT SAYS HALF EMPTY...SOMETIMES IT SAYS LOW FUEL LIGHT. THIS IS A DANGEROUS AND EXPENSIVE SITUATION...THE FUEL SENSORS SHOULD NOT FAILING! I SEE THAT MAY OTHER PEOPLE ARE EXPERIENCING THE SAME PROBLEM...ALTHOUGH THIS FIRST HAPPENED OVER THE SUMMER THE PROBLEM IS ONGOING AND APPARENTLY WIDE SPREAD.

FUEL LEVEL STOPPED WORKING, CHECK ENGINE LIGHT CAME ON. MECHANIC SAID THE CODE CALLED FOR REPLACEMENT OF FUEL LEVEL SENSORS. $500 REPAIR AND THE PROBLEM WAS NOT CORRECTED. I NEVER KNOW HOW MUCH GAS I HAVE AND I CAN NEVER PUT MORE THAN 8 GALLONS IN WHEN I FUEL UP. BUT GAS GAUGE WILL GO UP TO HAVE THEN DROP TO EMPTY THEN GO UP TO HALF A TANK. VERY HORRIFIC. CHECK ENGINE LIGHT IS ON WHICH WILL CAUSE ME TO FAIL INSPECTION.

AFTER FILLING VEHICLE WITH FUEL, FUEL GAUGE SHOWED TANK EMPTY AND YELLOW LIGHT ON DASH SHOWS FUEL EMPTY. FUEL GAUGE RECOVERED TO SHOW 1/2 FULL, THEN DISPLAYS ERRATIC RESULTS. ONLINE FORUMS SHOW DEFECTIVE FUEL SENSOR WITH A LARGE NUMBER OF HYUNDAI VEHICLES. THERE SHOULD BE RECALL ON THIS ISSUE. DRIVERS MAY THINK THEY HAVE SUFFICIENT FUEL, TO THEN HAVE VEHICLE RUN OUT OF GAS IN A DANGEROUS DRIVING ENVIRONMENT.

CAR LOST POWER WHILE IN MOTION TAKING A TURN AND SLOWING DOWN TO A STOP. STARTED JULY 2015, ONCE AGAIN IN AUG. NOW SINCE OCT, HAPPENS MORE REGULARLY, SOMETIMES TWICE A DAY. DEALER LOOKED AT IT TWICE. NO CODES, CAN'T REPLICATE SO THEY DON'T KNOW WHAT'S CAUSING THE PROBLEM. REPLACED TCS AND DID RECALL 9H292430 ALL WITH NO LUCK. DEALERS NEXT BEST GUESS IS REPLACING THROTTLE BODY.

SEVERAL MONTHS AGO, THE CHECK ENGINE LIGHT CAME ON. I TOOK THE CAR TO THE DEALER AND WHILE NOTHING WAS WRONG WITH THE ENGINE, I NEEDED TO PAY $1000 TO REPAIR THE SENSOR BECAUSE I NEEDED MY CAR EMISSION INSPECTED. IN THE LAST MONTH, WHILE ON A ROAD TRIP, THE CHECK ENGINE LIGHT CAME ON AGAIN AND THE CAR JUST LOST POWER AND STALLED. WHEN WE RESTARTED THE CAR, THE LIGHT WAS STILL ON BUT WENT OFF THE NEXT DAY. SINCE THEN, THE CHECK ENGINE LIGHT COMES ON RANDOMLY AND THE FUEL GAUGE JUMPS ALL OVER THE PLACE. IT WILL INDICATE I HAVE 88 MILES TO EMPTY AND THEN JUMP BACK UP TO 130. THE CHECK ENGINE LIGHT WILL COME ON ONE DAY AND BE OFF THE NEXT.

ONCE THE GAS GAGE REACHES 1/4 FULL, IT GOES TO EMPTY. AFTER FILLING WITH GAS, IT WILL TAKE OVER 1 HOUR TO RECORD A FULL TANK. CANNOT USE THE GAGE AS WE ARE NEVER SURE HOW MUCH GAS IS IN THE TANK. THE ENGINE LIGHT ALSO APPEARS AND STAYS ON UNTIL THE GAS SENSOR RECORDS FULL.

VEHICLE FUEL SYSTEM GAUGE INACCURATE. AFTER A FILL UP, THE GAS GAUGE WOULD CHANGE FROM 3/4 FULL TO EMPTY, TO 1/4 FULL, TO 3/4 FULL TO EMPTY, REGARLDESS OF HOW MUCH FUEL WAS IN THE VEHICLE. CHECK ENGINE LIGHT INTERMITTENTLY COMES ON AND OFF. THIS IS CLEARLY THE MOST COMMON SAFETY COMPLAINT ON NHTSA, AND OTHER INTERNET COMPLAINT PAGES RELATED TO SAFETY ISSUES WITH THE HYUNDAI SANTA FE. SEVERAL MODEL YEARS APPEAR TO BE HEAVILY AFFECTED. NOT KNOWING HOW MUCH FUEL THE VEHICLE HAS IS A MAJOR SAFETY CONCERN AND COULD LEAD TO ACCIDENTS, INJURIES, AND DEATHS. I'M HAVING TO PAY FOR VERY EXPENSIVE REPAIRS BECAUSE OF THIS, AND HYUNDAI REFUSES TO ACCEPT RESPONSIBILITY, EVEN THOUGH THEIR SERVICE FOLKS ACKNOWLEDGE THEY SEE THIS OFTEN. THIS SHOULD BE A RECALL, AND ALL THOSE WHO HAVE PAID FOR THIS COSTLY REPAIR SHOULD BE REIMBURSED.

MY GAS GAUGE SHOWED A HALF TANK ONE DAY THEN IT SHOWED EMPTY THEN IT SHOWED EMPTY/ THE NEXT DAY IT WOULD NOT START I NEW THERE WAS GAS IN IT AN HOUR LATER IT STARTED BUT AFTER I WAS OUT IT WENT BACK TO EMPTY. THIS PROBLEM NEEDS TO BE FIXED SEVERAL PEOPLE I MEET IN PARKING LOTS HAVE THE SAME PROBLEM. ARE YOU WAITING FOR SOMEONE TO GET IN THE REAR WHEN IT SHUTS OFF AND PEOPLE GET KILLED BIG LAW SUITS WILL HAPPEN IAM SURE IT WOULD CHEAPER TO FIX THIS THEN GET SUED. I SEE THERE ARE A LOT COMPLAINTS

FUEL GAUGE DOES NOT WORK PROPERLY. NO MATTER HOW MUCH GAS IS IN TANK IT USUALLY REGISTERS EMPTY, AND OCCASIONALLY IT WILL RANDOMLY FLUCTUATE UP AND DOWN. BECAUSE OF THIS ISSUE THE CHECK ENGINE LIGHT IS ALWAYS ON. THIS HAPPENS WHILE CAR IS STATIONARY OR IN MOTION. THIS IS A KNOWN ISSUE BY HYUNDAI.

FUEL GAUGE IS NOT WORKING AND CAR IS RUNNING OUT OF GAS EVEN THOUGH INDICATOR INDICATE THERE IS GAS. I HAD BOTH FUEL SENSORS REPLACED AND THE PROBLEM STILL CONTINUES. I HAVE RUN OUT OF GAS MULTIPLE TIMES AND RECENTLY RAN OUT OF GAS ON AN EXTREMELY DANGEROUS STRETCH OF 101. WITH TWO YOUNG CHILDREN, THIS CONTINUES TO BE A MAJOR SAFETY THREAT AND CONCERN FOR ME. BASED ON SOME QUICK GOOGLING IT'S CLEAR THIS IS A MAJOR PROBLEM AND SECURITY CONCERN FOR OTHER SANTA FE OWNERS AND IT SHOULD BE REPAIRED OR REPLACED UNDER A RECALL.

THE CHECK ENGINE LIGHT CAME ON AS I WAS FILLING UP MY VEHICLE. ONCE I FILLED IT, I COULD NOT GET IT TO START. TOOK TWO TO THREE TRIES TO GET THE VEHICLE TO TURN OVER. I HAD THE BATTERY CHECKED AND MY BATTERY IS GOOD. MY FUEL GAUGE SITS AT EMPTY FOR THE FIRST 100 MILES AFTER FILLING UP WITH THE LOW FUEL INDICATOR LIGHT ON. I HAVE HAD THE CAR CHECKED AND WAS TOLD IT WAS TOLD I HAD A PROBLEM WITH THE FUEL SENSOR. I HAD ONE REPLACED FOR $250 IN 2014. CAR WORKED FINE. THEN AFTER 500 MILES, THE SAME THING HAPPENED. WHEN IS HYUNDAI GOING TO REALIZE THAT THEY HAVE A SERIOUS ISSUE WITH THIS VEHICLE! I CAN'T EVEN GET A FAIR TRADE IN VALUE FOR THE VEHICLE DUE TO THE PROBLEM.

HAD ABOUT A HALF TANK OF GAS AND FILLED UP BEFORE TAKING A ROAD TRIP. LEFT STATION AND NOTICED GAUGE DID NOT MOVE TO FULL. FEW MILES DOWN THE ROAD IT STARTED TO SLOWLY INCREASE UP TO THE FUEL MARK. AFTER STOPPING AGAIN ON DOWN THE ROAD AND RESTARTING FUEL GAUGE WOULD SHOW HALF TANK THEN DROP TO EMPTY AND THEN BACK UP TO HALF TANK. I HAVE TO KEEP GETTING GAS AND KEEP TRACK OF MILEAGE SO THAT I DO NOT RUN OUT WHILE ON THE INTERSTATE. FROM WHAT I'VE READ THIS IS A VERY COSTLY REPAIR AND IS CERTAINLY A SAFETY HAZARD AS I TRAVEL A LOT FOR WORK ON THE BUSY INTERSTATES AND CANNOT CHANCE RUNNING OUT OF FUEL

THE LIGHT FOR MY FUEL TANK CAME ON SAYING EMPTY, HOWEVER I RECALLED JUST HAVING PUT GAS IN THE TANK. A FEW DAYS LATER THE ENGINE LIGHT BEGAN TO COME ON. I TOOK MY CAR TO AUTOZONE TO TEST THE ENGINE LIGHT, I WAS TOLD THERE WAS A PROBLEM WITH THE FUEL SENSOR. I LATER CALLED HYUNDAI AFTER CONSTANTLY HAVING TO WATCH MY GAS AND MILEAGE TO MAKE SURE THE TANK DOES NOT RUN EMPTY. HYUNDAI ADVISED IT IS POSSIBLY THE FUEL SENDING UNIT WITHOUT EVEN HAVING TO LOOK AT THE CAR AND ADVISED IT WOULD COST ABOUT $800 TO REPAIR. THE REP IN THE PARTS DEPARTMENT STATED THEY HAVE HAD SEVERAL CALLS REGARDING REPLACING THE PART. THIS COULD POTENTIALLY BE A SERIOUS ISSUE, ESPECIALLY IF YOU ARE DRIVING ON A BUSY ROAD OR HIGHWAY. THERE SEEMS TO BE SEVERAL PEOPLE HAVING THE SAME ISSUE.

FILLED FUEL TANK AND BEGAN DRIVING ON HIGHWAY. AS USUAL CHECKED GAGES AND NOTICED FUEL GAGE AT 1/4 FULL. OVER TIME DRIVING, NEEDLE ON GAGE BEGAN TO MOVE UP TO POINT INDICATING APPROX. 3/4 FULL. OVER BALANCE OF DRIVE NEEDLE DANCED AROUND THE 3/4 FULL MARK. I AM READING NUMEROUS COMPLAINTS FROM HYUNDAI OWNERS OF SAME PROBLEM OVER SEVERAL MODEL YEARS. IT APPEARS HYUNDAI IS DENYING A PROBLEM AND HAS TAKEN NO STEPS TO IMPROVE FUEL LEVEL SENSORS AND THUS REPLACING WITH THEM WITH SAME IS ONLY BAND AIDE FIX WITH POTENTIAL OF SERIOUS ACCIDENT IF VEHICLE DOES RUN OUT OF GAS ON HIGHWAY OR CROSSING INTERSECTION. VEY POOR POSITION OF COMPANY AND WHEN SHOPPING FOR NEW CAR I WILL CONSIDER ANOTHER MANUFACTURER.

THE FUEL GAUGE SENDING UNIT IS INOPERATIVE. PERUSAL OF THE INTERNET SHOWS IT IS A COMMON PROBLEM WITH 2007-2013 HYUNDAI SANTA FE VEHICLES. THE FIX IS $ 500. HYUNDAI USA AND HYUNDAI WORLDWIDE H.Q. REFUSE TO ACKNOWLEDGE THAT THE PROBLEM EXISTS OR OFFER ANY REPAIRS FOR THE FAULTY UNIT OR WHY INDEED IT FAILED. TRY DRIVING ANY DISTANCE WITHOUT A GAS GAUGE. THE CAR IS USELESS UNLESS REPAIRED. MANUFACTURERS SHOULD EITHER STAND BEHIND THEIR VEHICLES OR THE PUBLIC SHOULD BE ADVISED TO LOOK TO A MORE RELIABLE MANUFACTURER FOR A BETTER, SAFER AND MORE RELIABLE PRODUCT.

FUEL FLOAT IN GAS TANK STUCK THEREFORE NO FUEL GAGE READING.

AFTER FILLING THE GAS TANK, THE GAS GAUGE READ EMPTY, ALONG WITH THE LOW-FUEL WARNING LIGHT. AFTER DRIVING APPROXIMATELY 10 MILES, THE GAUGE THEN APPEARED TO BE FUNCTIONING NORMALLY. THE GAUGE CONTINUES TO MALFUNCTION IF THE GAS TANK IS FILLED. WHEN THE TANK IS BELOW HALF FULL, THE GAUGE WILL RANDOMLY READ EMPTY OR HALF FULL. AN INTERNET SEARCH QUICKLY REVEALED THAT MANY OWNERS ARE EXPERIENCING THIS PROBLEM. I HOPE HYUNDAI WILL INITIATE A SAFETY RECALL TOO CORRECT THE ISSUE.

WHEN THE FUEL GAUGE GETS AROUND HALF FULL, THE GAUGE BOUNCES AROUND BELOW THE HALF FULL AND EMPTY. THE CHECK ENGINE INDICATOR LIGHT COMES ON AND STAYS ON. CANNOT EXACTLY DETERMINE HOW MUCH FUEL IS LEFT IN TANK. HAD FUEL SENSING PARTS REPLACED AT A COST OF APPROXIMATELY $600 BY A MASTER ASE CERTIFIED TECHNICIAN. AFTER REPAIRS WE FILLED THE TANK WITH FUEL. ALTHOUGH TANK WAS FULL IT ONLY REGISTERED 3/4 FULL WITH A RANGE OF 254 MILES. BEFORE THIS INCIDENT, THE RANGE WAS 320 - 324 MILES. RETURNED TO TECHNICIAN WHO ALERTED US THAT HE HAS SEEN MANY SIMILAR PROBLEMS WITH HYUNDAIS AND KIAS. HE BELIEVES HYUNDAI SHOULD RECALL AND FIX PROBLEMS. THIS ATTESTED TO BY SIMILAR PROBLEMS LISTED ON YOUR SITE SAFER CAR.GOV. MY WIFE AND I ARE IN OUR 70S AND ARE CONCERNED WE WILL RUN OUT OF GAS ON A REMOTE HIGHWAY OR ENGINE WILL STALL IN TRAFFIC.

TL* THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. WHILE HAVING THE VEHICLE INSPECTED, THE INSPECTION TECHNICIAN NOTIFIED THE CONTACT THAT THE VEHICLE FAILED DUE TO THE FUEL SENSOR GAUGE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 132,000. THE VIN WAS UNAVAILABLE.

I HAVE TAKEN THIS VEHICLE TO THE DEALERSHIP 11 TIMES IN THE LAST 2 1/2 YEARS TRYING TO FIX AN ISSUE WHERE I RANDOMLY CANNOT PUT FUEL IN THE CAR. THE NOZZLES CLICK OFF AS IF THE TANK IS FULL, USUALLY AFTER PUMPING A FEW GALLONS. THE DEALERSHIP SAYS THEY HAVE REPLACED EVERY SINGLE PIECE OF THE FUEL SYSTEM, BUT IT CONTINUES TO HAVE ISSUES AND THEY'RE NOT SURE WHY. SOMETIMES IT WORKS FINE; SOMETIMES PUMPING GAS SLOWLY HELPS AND I'M ABLE TO FILL UP; SOMETIMES NOTHING I DO WORKS AND I HAVE TO DRIVE OFF AND TRY AGAIN ANOTHER DAY. THE CHECK ENGINE LIGHT HAS ONLY COME ON ONCE, WITH THE FIRST REPAIR ATTEMPT IN 2013. SINCE THEN, THERE ARE NO WARNING LIGHTS, JUST THE INABILITY TO PUMP GAS. I'VE TRACKED MILEAGE TO MAKE SURE IT'S NOT JUST AN ISSUE WITH THE FUEL GAUGE SHOWING AS BEING EMPTIER THAN IT REALLY IS. UNLESS THIS SUV IS GETTING 60+ MPG, IT'S NOT THE GAUGE. I GENERALLY START ATTEMPTING TO FILL UP WHEN I GET DOWN TO HALF A TANK OF GAS, BECAUSE I NEVER KNOW HOW MUCH GAS I'LL BE ABLE TO PUT INTO THE VEHICLE AT A TIME.

CHECK ENGINE LIGHT COMING ON. HAD IT CHECKED OUT AND IT WAS THE FUEL LEVEL SENSOR. GAS GAUGE NOT WORKING PROPERLY NOW. I CHECKED AND THERE HAS BEEN MANY MORE REPORTS FOR THIS TYPE OF PROBLEM. COMPANY SHOULD FIX THIS PROBLEM AT LITTLE OR NO COST.

CHECK ENGINE LIGHT CAME ON MAY 28 2015, DEALER ADVISED FUEL SENSOR/PUMP ISSUE, REPAIRED IT $$$$ JUNE 5TH SAME ISSUE BACK AT DEALER, ALSO WILL NOT START AND FUEL GAUGE ACTING UP 33RD RECORD OF THE SAME ISSUE AT NTSHA FOR THIS 2009, OVER 100 FOR THE CUMULATIVE YEARS FOR THE SANTA FE SAME ISSUE

TL* THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE FUEL GAUGE FAILED TO PROVIDE A PROPER READING AND WOULD FLUCTUATE FROM FULL TO EMPTY AFTER THE TANK WAS REFUELED. THE CONTACT MENTIONED THAT THE VEHICLE STALLED DUE TO THE FAILURE. THE FAILURE WAS REPORTED TO THE AUTHORIZED DEALER WHO STATED THAT THE CONTACT WAS NOT INCLUDED IN A MANUFACTURER RECALL AND THAT THE VEHICLE WOULD NEED TO BE DIAGNOSED TO DETERMINE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

THE CHECK ENGINE LIGHT CAME ON AND FUEL GAUGE WENT DOWN TO EMPTY, EVEN THOUGH I HAD A FULL TANK. TOOK TO MY MECHANIC AND HE SAID THE CHECK ENGINE CODE INDICATED "P0464 - FUEL LEVEL SENSOR 'A' CKT INTERMITTENT" PROBLEM. HE INFORMED ME OF HIS PRICE, BUT RECOMMENDED I GO TO A HYUNDAI DEALERSHIP FIRST TO SEE IF COVERED UNDER THE 100K POWER TRAIN WARRANTY. TOOK TO LOCAL DEALER ON 11/10/14 AND THEY SAID IT WASN'T COVERED OR CONSIDERED A RECALL, AND IT WOULD COST OVER $800 TO REPAIR. MY MECHANIC SUGGESTED I USE A BOTTLE OR TWO OF CHEVRON TECHRON FUEL ADDITIVE WITH MY NEXT FILL UP BECAUSE IT MAY CLEAN THE SENDING UNIT, AS GASOLINE TENDS TO COAT THE GRID THAT CONTACTS PASS OVER CAUSING THE GAGE FAILURE. A 20 OZ AND 12 OZ BOTTLE WERE ADDED AND SHORTLY AFTER, THE CHECK ENGINE LIGHT WENT OUT AND THE FUEL GAGE BEGAN TO REGISTER PROPERLY AGAIN. THIS LASTED ABOUT 2 MONTHS, BUT THEN THE LIGHT CAME ON AGAIN IN JANUARY AND GAGE WENT DOWN WHEN I STARTED UP THE CAR ONE MORNING. I TRIED THE SAME THING AGAIN WITH THE TECHRON, AND IT WORKED FOR ABOUT 1 MONTH. THE PROBLEM HAS OCCURRED SEVERAL MORE TIMES LATELY BUT THE GAGE PROBLEM IS INCONSISTENT. SOMETIMES EVERYTHING SEEMS GOOD THEN IF I HAPPEN TO ACCELERATE QUICKLY, EVERYTHING GOES HAYWIRE AGAIN. I DON'T WANT TO KEEP PAYING FOR BOTTLES OF TECHRON ON EVERY OTHER FILL-UP OR USE PREMIUM GAS (WHICH DIDN'T WORK BTW), AND I ALSO THINK THIS PROBLEM IS COMMON ENOUGH ON 2007-2009 SANTA FE'S ON INTERNET POSTINGS THAT ITS TIME FOR HYUNDAI TO STEP UP TO FIX THIS PROBLEM AS A RECALL. SOME THINK IT'S NOT IMPORTANT BECAUSE IT HASN'T CAUSED A CRASH, FIRE, OR ACCIDENT RESULTING IN INJURY OR DEATH, BUT IF SOMEONE IGNORES IT AND RUNS OUT OF GAS ON A MAJOR HIGHWAY, IN A TUNNEL (I GO THROUGH ONE 2X PER DAY), OR ANOTHER DANGEROUS SPOT, IT VERY WELL COULD CAUSE A MAJOR ACCIDENT OR DEATH. DO THE RIGHT THING HYUNDAI AND ISSUE A RECALL FOR THIS ISSUE!! *TR

VEHICLE FUEL GAUGE IS ERRATIC. WITH A FULL TANK OF FUEL THE GAUGE SOMETIMES READS EMPTY WITH THE LOW FUEL LIGHT ON. OTHER TIMES IT MAY READ AS HALF OR ANYWHERE IN BETWEEN. PROBABLY DEFECTIVE FUEL SENDING UNIT. *TR

TL* THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE FUEL GAUGE FAILED TO OPERATE. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS 100,700.

FILLED UP GAS TANK AND A SHORT TIME LATER GAS GAUGE SHOWED HALF TANK. WE PAID PARTICULAR ATTENTION TO WATCHING GAUGE AND IT RANDOMLY WOULD GO UP AND DOWN. A FEW DAYS LATER THE CHECK ENGINE WARNING LIGHT CAME ON. WE WENT TO OUR MECHANIC WHO CHECKED FOR THE REASON FOR CHECK ENGINE LIGHT AND THE RESULT WAS A CODE INDICATING THAT THE FUEL TANK LEVEL SENSOR WAS WORKING INTERMITTENTLY. THIS IS A REAL PROBLEM AS WE'RE NOT SURE AT ANY TIME WHAT THE LEVEL OF FUEL IS SINCE IT GOES UP AND DOWN. IT IS OBVIOUS IN RESEARCHING THIS PROBLEM THAT THIS IS AN ONGOING ISSUE. WE LOVE OUR SANTA FE BUT THESE TYPES OF ISSUES WILL CERTAINLY WEIGH IN ON OUR CAR REPLACEMENT DECISION. *TR

PULLED INTO GAS STATION WITH A HAIR UNDER A 1/4 TANK OF GAS, SHUT OFF ENGINE AND HAD THE ATTENDANT FILL THE TANK. AFTER THE FILL WAS COMPLETE I STARTED THE CAR ENGINE AND THE FUEL GAUGE READ "E" AND THE YELLOW LIGHT CAME ON. I MOVED THE CAR FORWARD, BACKWARD AND FORWARD AGAIN AND THE GAUGE MOVED SLIGHTLY OFF THE "E". I DROVE HOME THE GAUGE MOVE TO JUST UNDER HALF. I TURNED THE CAR OFF AND WHEN I STARTED IT THIS MORNING WITH THE REMOTE START THE GAUGE READ HALF A TANK BUT WHEN I PUT THE KEY IN AND TURNED IT THE GAUGE WENT TO "E" AGAIN AND THE YELLOW LIGHT WAS BACK. AFTER ABOUT 10 MINUTES ON MY RIDE TO WORK THE GAUGE WENT TO 1/4 TANK AND THE LIGHT WENT OFF AND SO FAR TODAY IT HAS STAYED THERE. BY THE LOOKS OF COMPLAINTS ON THE INTERNET IT SEEMS TO BE A PROBLEM HYUNDAI HAS. *TR

I OWN A 2009 HYUNDAI SANTA FE, THE CHECK ENGINE LIGHT CAME ON WITH ODBII CODE P0464, FUEL LEVEL SENDER(SENSOR) UNIT MALFUNCTION "INTERMITTENT OPERATION". I NORMALLY REPAIR MY OWN VEHICLES AND HAVE REPAIRED CARS FOR MANY YEARS. THE ISSUE I HAVE IS THAT, ONLY ON RARE OCCASIONS SHOULD THESE FUEL TANK PARTS GO BAD ON A VEHICLE WITH LESS THAN 100,000 MILES ON IT. I'M NOW SEEING MORE AND MORE COMPLAINTS ABOUT THESE FUEL TANK ISSUES, CONSIDER A RECALL FOR HYUNDAI VEHICLES. *TR

AS WITH MANY OTHER OWNERS, WE SHARE THE FUEL SENDER SENSOR PROBLEM WITH OUR 2009 HYUNDAI SANTA FE . THE CODES ARE FOR BOTH THE LEFT AND RIGHT SIDES, MEANING BOTH WILL HAVE TO BE REPLACED. THE FUEL GAUGE EMPTY LIGHT IS ALWAYS ON, NO MATTER HOW MUCH GAS IS IN THE TANK, AND CHECK ENGINE LIGHT AS WELL. QUOTED FROM $350 TO $620 DOLLARS FROM LOCAL REPAIR SHOPS. WE FAILED NJ INSPECTION DUE TO ENGINE LIGHT, AND THIS IS A DANGEROUS AND COSTLY PROBLEM, AND WE RAN OUT OF GAS ON THE BUSY GARDEN STATE PARKWAY WITH OUR CHILDREN IN THE CAR, INCURRING TOWING CHARGES. IT IS CERTAINLY A SAFETY ISSUE THAT HYUNDAI IS AVOIDING. I HAVE ANOTHER 2009 HYUNDAI (ACCENT) WITH NO PROBLEMS, SO IT IS SAFE TO ASSUME ( WITH SO MANY COMPLAINTS ) THAT IT IS A SANTA FE PROBLEM. PLEASE HAVE HYUNDAI LOOK INTO THIS DANGEROUS PROBLEM . THANK YOU. *TR

LOW FUEL INDICATOR LIGHT COMES ON AND GAS GAUGE READS EMPTY AFTER RECENT FILL UP, THEN IT SLOWLY RISES TO FULL, INDICATOR LIGHT THEN GOES OUT AND CHECK ENGINE LIGHT COMES ON, ABOUT 20 MILES LATER CHECK ENGINE LIGHT GOES OUT AND GAS GAUGE RESPONDS CORRECTLY. THIS HAS HAPPENED SEVERAL TIMES, CURRENTLY CHECK ENGINE LIGHT IS OFF. *TR

ENGINE AND FUEL WARNING LIGHTS COME ON AND OFF SPORADICALLY, AND THE GAS GAUGE SHOWS THE TANK IS EMPTY EVEN AFTER WE FILLED IT. THIS HAPPENS REGARDLESS OF THE AMOUNT OF FUEL IN THE GAS TANK, AND IT MAKES IT IMPOSSIBLE TO KNOW THE ACTUAL AMOUNT OF GASOLINE IN THE VEHICLE. WE BROUGHT IT TO THE DEALER TODAY AND WAS TOLD THE 2 FUEL SENSORS NEED TO BE REPLACED AT A COST OF $600. WHEN WE PURCHASED THE VEHICLE NEW WE ALSO PURCHASED A MAINTENANCE PROGRAM, BUT, OF COURSE, THE FUEL SENSORS ARE EXCLUDED FROM COVERAGE. UPON DOING ONLINE RESEARCH WE LEARNED THERE ARE MANY OTHERS WHO ARE EXPERIENCING THIS SAME PROBLEM. WE FEEL THAT BECAUSE THIS HAS HAPPENED TO OTHER HYUNDAI OWNERS IT MAY BE A PROBLEM THAT HYUNDAI NEEDS TO REPAIR AT NO COST TO THE OWNERS OF THESE VEHICLES. *TR

FUEL LIGHT WAS ON. FILLED GAS TANK. FUEL LIGHT REMAINED ON AND FUEL GAGE DID NOT RISE TO FULL. CHECK ENGINE LIGHT CAME ON. AFTER DRIVING 20+ MILES THE FUEL GAGE ROSE BUT DROPS RAPIDLY. THE FUEL LIGHT WILL GO ON AND THE CHECK ENGINE LIGHT GOES ON AND OFF. HYUNDAI DEALER SAYS THEY KNOW IT IS AN ISSUE BUT NO RECALL HAS BEEN ISSUED. THE DANGER ARISES IF I FAIL TO RESET THE MILEAGE AND SHOULD RUN OUT OF GAS WITHOUT WARNING. *TR

TL* THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE FUEL GAUGE READING FLUCTUATED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL SENDER ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 73,500.

THE FUEL INDICATOR ON OUR SANTA FE IS ONLY ACCURATE FOR THE FIRST 1/4 OF A TANK, AFTER THAT IT INDICATES THE TANK IS EMPTY AND THE "CHECK ENGINE" LIGHT APPEARS. WE HAVE TO KEEP TRACK OF OUR MILEAGE IN ORDER TO KNOW WHEN WE ARE LOW ON FUEL. VERY ANNOYING TO HAVE TO DO THIS. WHAT IF THE "CHECK ENGINE" LIGHT IS ON FOR ANOTHER REASON? HOW WILL WE KNOW? THIS IS AN ON-GOING PROBLEM WITH HYUNDAI,WHO HAS NOT ADDRESSED THE ISSUE, AND IT WILL COST $300-$700 TO REPAIR! WE ARE THINKING OF SELLING OUR SANTA FE BUT WE KNOW WE CAN'T SELL IT WITH A "CHECK ENGINE" LIGHT ON! HYUNDAI SHOULD OWN UP TO THIS PROBLEM AND RECALL THEIR VEHICLES. WE HAVE OWNED 5 HYUNDAI'S IN THE PAST 15 YEARS AND THIS WILL MAKE US RECONSIDER EVER BUYING ANOTHER. *TR

2009 HYUNDAI SANTA FE EXPERIENCING WILD FUEL GAGE SPIKES, READS E WHEN TANK IS FULL, THEN READS 1/2 FULL AND IS ALL OVER THE MAP.. HYUNDAI IS AWARE OF THE PROBLEM BUT HAS NOT INDICATED A RECALL.. THIS ITEM SHOULD BE PLACES ON RECALL AS IT IS A HAZARD, TO THE DRIVER, OCCUPANTS AND OTHERS ON THE ROAD. GAUGE COULD READ FULL WHEN IT'S ACTUALLY EMPTY RESULTING IN TRAFFIC ACCIDENTS.. THIS ISSUE ALSO RESULTS IN A CHECK ENGINE LIGHT TRIGGER, CAUSING FAILURES AT INSPECTION. *TR

I'M EXPERIENCING A PROBLEM WITH THE FUEL SENSOR FAILING. THE FUEL GAUGE SHOWS EMPTY AND THEN SLOWLY RISES TO INDICATE I HAVE FUEL. SOMETIMES THE FUEL INDICATOR LIGHT COMES ON AFTER I'VE JUST FILLED UP AND STAYS ON FOR A DAY OR SO. I CALLED MY DEALER AND THEY TOLD ME THIS IS A COMMON PROBLEM. THEY SAID AT THIS TIME THERE'S NO RECALL OUT FOR THIS REPAIR, BUT AGREED THAT THERE SHOULD BE. THIS CAN BECOME A SAFETY ISSUE AND COULD CAUSE SERIOUS INJURIES TO THE DRIVER AS WELL AS OTHER VEHICLES ON THE ROAD. I FEEL THAT HYUNDAI SHOULD STEP UP AND THAT CARE OF THIS FAULTY PART. *TR

TL* THE CONTACT OWNS A 2009 HYUNDAI SANTE FE. THE CONTACT STATED THAT WHEN REFUELING TO CAPACITY, THE LOW FUEL WARNING LIGHT WOULD ILLUMINATE AND THE FUEL LEVEL GAUGE WOULD SHOE EMPTY WITHIN 50 MILES. THE VEHICLE WAS TAKEN TO A DEALER BUT THE FAILURE WAS UNABLE TO BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 86,000.

THE VEHICLE LOOSES ALL POWER. IT ALSO SURGES AND STALLS. *TR

I HAVE 2009 SANTA FE. THIS HAPPENED FIRST TIME IN FEBRUARY 2014 THAT I WAS FILLING GAS (I ALWAYS DO FULL) AND AS I STARTED LEAVING THE GAS STATION MY FUEL GAUGE SHOWED EMPTY. I WENT BACK TO THE GAS STATION AND ASK THE ATTENDANT THAT THERE IS A MISTAKE, MY TANK IS NOT FULL IT IS EMPTY. BUT I WAS WRONG, BECAUSE HE TOLD ME THERE IS NO WAY THE PUMP MACHINE WILL LIE AND HE FILLS 100S OF VEHICLE PER DAY FROM EACH OF HIS MACHINE. JUST TO DOUBLE CHECK, THE NEXT FILLING I USED A DIFFERENT GAS STATION AND IT HAPPENED AGAIN. NOW THIS HAS BECOME ROUTINE AND SINCE MY LAST TWO VISIT AT PUMP, EVEN THE CHECK ENGINE LIGHT IS COMING ON NOW. I HAVE TO WAIT FEW DAYS AND MILEAGE TO PUT ON THAT THE CHECK ENGINE WILL GO OFF BUT THE FUEL GAUGE WILL STILL SHOW LESS THAN HALF THE TANK. AT THIS MOMENT, I KNOW MY CAR AND CAN PREDICT WITH SOME DEGREE OF CERTAINTY ABOUT THE MILEAGE MY CAR WILL PROVIDE BUT AS THE CAR AGES AND OTHER THINGS IN THE ENGINE AGES, IT WILL BECOME MORE DIFFICULT TO PREDICT THE GAS LEVEL. SO I MIGHT BE IN TROUBLE STRANDED ON HIGHWAY OR IN CITY DURING RUSH HOUR. ALSO I FOUND ONLINE THAT THIS IS NOT JUST MY PROBLEM, MANY OF OTHER SANTA FE HAD SIMILAR ISSUES. THEREFORE, I THOUGHT I SHOULD ALSO SHARE MY EXPERIENCE HERE. *TR

WHILE DRIVING ON THE INTERSTATE AT APPROXIMATELY 70 MPH, USING CRUISE CONTROL, THE CAR SUDDENLY LOST POWER. I STEPPED ON THE GAS AND IT WOULD NOT ACCELERATE. I COASTED TO A STOP AND PULLED ONTO THE SHOULDER. THE ENGINE WAS RUNNING, TRANSMISSION WAS IN GEAR, BUT THE CAR WOULD NOT MOVE. I TURNED OFF THE IGNITION AND LET IT SIT FOR A FEW MINUTES. I RESTARTED IT, HAD POWER, EVERYTHING SEEMED NORMAL, EXCEPT THE ENGINE LIGHT REMAINED LIT. I DROVE APPROXIMATELY 10 MILES TO MY DESTINATION. THE CAR SAT FOR SIX HOURS AND I WAS THEN ABLE TO DRIVE THE 65 MILES HOME WITHOUT INCIDENT. REPAIR RESULTS: MY HYUNDAI DEALER INDICATED THE PROBLEM WAS CAUSED BY A 'THROTTLE POSITION SENSOR'. THEY REPLACED THE ELECTRONIC COMPONENT AND RESET THE ERROR CODES IN THE VEHICLE'S COMPUTER. *TR

FUEL SENDER IS DEFECTIVE, IT IS BROKEN CAUSING THE FUEL GAUGE TO FAIL. THIS HAPPENS OFTEN TO MY MODEL CAR, RIGHT AFTER WARRANTY PERIOD. *JS

TL* THE CONTACT OWNS A 2009 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE FUEL GAUGE WAS SHOWING AN EMPTY READING WHEN THE FUEL TANK WAS HALF FULL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE FUEL SENSORS WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 95,800 AND THE CURRENT MILEAGE WAS 96,215.

WHILE DRIVING DOWN ROAD, GAS GAUGE WENT FROM FULL TO EMPTY AND BACK AGAIN. SINCE THAT DAY, GAUGE MOVES EVERY 5/10 MINUTES, DAILY. HAVE TO SET TRIP MILEAGE AFTER EACH FILL UP. *TR

ABOUT 6 TO 9 MONTHS AFTER PURCHASING SANTA FE CAR STALLED WHILE DRIVING DOWN ROAD WITH 1/4 TANK OF GAS INDICATED. GAS WAS PUT IN CAR AND DRIVEN TO DEALERSHIP WITH CAR STALLING A SECOND TIME IN ROUTE. DEALER SAID IT WAS A FAULTY FUEL SENSOR AND IT WAS REPLACED UNDER WARRANTY. CAR STALLED ON INTERSTATE WHILE GOING 70MPH 3/2013 WITH 1/3 TANK OF GAS SHOWING. UPON ADDING GAS CAR RAN AGAIN. WAITED A FEW MONTHS UNTIL CAR STALLED AGAIN WHILE DRIVING AROUND TOWN WITH "PLENTY OF GAS." TOOK IT TO DEALERSHIP 7/2013 AND THEY SAID IT WAS A FLUKE AND THE FUEL SENSOR WAS REPLACED AGAIN. ONCE AGAIN, 12/2013 CAR STALLED ON HIGHWAY WHILE TRAVELING AT 65 WHILE GAUGE INDICATED 1/3 TANK OF GAS. FILLED WITH GAS AND CAR RAN. TOOK IT TO DEALER 12/2013 AND THEY SAID IT WAS JUST A FLUKE (SEEMS TO BE PARTY LINE) BUT THIS TIME THEY SAID THE FLOAT IN THE FUEL TANK WAS GETTING HUNG UP ON SOMETHING SO WAS GIVING A FALSE READING. DEALER SAID HOSE THAT GOT CAUGHT ON FLOAT HAD BEEN RECONNECTED AND SHOULD NOT CAUSE ANY FURTHER PROBLEMS. DRIVING AROUND TOWN TWO DAYS AGO WITH 1/4 TANK OF GAS CAR STALLED AGAIN. HAVE ADDED GAS BUT IT IS SPUTTERING. ASSUME IT WILL BE ANOTHER FLUKE! *TR

FUEL SENSOR FAILED AND REGISTERED EMPTY TANK WITH LOW FUEL WARNING LIGHT, CHECK ENGINE LIGHT ACTIVATED. SINCE THEN THE FUEL GAUGE HAS NOT OPERATED CORRECTLY AND THE CHECK ENGINE REMAINS LIT. FAULT HAS BEEN TRACED TO FUEL TANK SENSOR WHICH REQUIRES REMOVAL AND REPLACEMENT. *TR

WAS GOING ABOUT 70 MPH AROUND TOPEKA KANSAS WHEN THE VEHICLE LURCHED, THEN THE ESC, ENGINE AND CHASSIS LIGHTS FLASHED. IMMEDIATELY AFTERWARDS THE CAR LOST ALL PROPULSION. FORTUNATELY I WAS BY AN OFF-RAMP, BUT COULD OF GOTTEN IN AN ACCIDENT WHICH SUCH A SUDDEN DECELERATION. MANAGED TO GET TO AN AUTOZONE STORE TO CHECK THE FAULT. THE FAULT CAME UP AS THE THROTTLE POSITION SENSOR (TPS). MANAGED TO GET IT TO THE DEALERSHIP IN TOPEKA. THEY FIXED IN WITHIN 10 MINUTES, BUT AFTER COMPLETING MY TRIP BACK TO COLORADO NOTICED THE CAR IS LURCHING AGAIN IN LOWER SPEED, IN-TOWN TRAFFIC...VERY DANGEROUS!!! WILL BE CONTACTING THE DEALERSHIP IN COLORADO ON MONDAY MORNING!! HAD A SIMILAR PROBLEM TWO YEARS AGO, TOOK IT INTO THE DEALERSHIP AND THEY SAID THEY COULDN'T FIND A PROBLEM WITH IT. GUESS THEY WON'T BE SATISFIED UNTIL THE WARRANTY PERIOD ENDS AND SOMEONE GETS KILLED. *TR

INCIDENT 1: (10-20-2010) DRIVER SIDE HEAD LIGHT WAS FOGGING UP CONSTANTLY. DEALER REPLACED THE HEAD LIGHT UNDER WARRANTY. INCIDENT 2: (02-22-2011) UPON FILL-UP OF THE GAS TANK, JUST BEFORE IT WAS TOPPED OFF, THERE WAS A SERIES OF CLUNKING NOISES. AFTER TAKING IT TO THE DEALERSHIP, THE GAS TANK WAS REPLACED. INCIDENT 3: (05-01-2011 APPROX.) UPON REMOVAL OF THE CABIN AIR FILTER COVER, THE LITTLE PLASTIC PARTS THAT ARE SQUEEZED TO REMOVE THE COVER BROKE, WHICH WOULDN'T ALLOW THE COVER TO GO BACK ON. THE DEALER REPLACED THE PART AND I HAVE NOT YET REPLACED THE FILTER YET. INCIDENT 4: (11-12-2011) DRIVING 60 MPH DOWN THE HIGHWAY, I HEARD A LOUD BANGING NOISE COMING FROM THE ENGINE COMPARTMENT. AS I WAS PULLING OVER TO CHECK OUT THE SITUATION, THE CAR LOST POWER STEERING AND AIR CONDITIONING! MY SERPENTINE BELT BROKE! AFTER IT WAS TOWED, THE DEALER REPLACED IT, ALONG WITH BELT TENSIONER AND IDLER PULLEY! INCIDENT 5: (07-30-2012) I WAS COMING UP TO A STOP LIGHT AND UPON DECELERATION, THE CHECK ENGINE LIGHT AND ESC OFF LIGHT CAME ON. AFTER COMING TO A COMPLETE STOP, THE RPM GAGE SHOWED 1100 RPM AND IT FELT LIKE THE VEHICLE WANTED TO MOVE AS IF I WAS PRESSING THE ACCELERATOR. WHEN I DID TRY TO ACCELERATE, THERE WAS NO POWER TO ACCELERATE ( THE ENGINE WAS STILL RUNNING, ETC, BUT WHEN I PRESSED THE ACCELERATOR, I COULD ONLY MOVE A FEW MILES PER HOUR.) I PULLED OVER AND SHUT THE VEHICLE OFF FOR A FEW MINUTES. I STARTED IT BACK UP AND THE CHECK ENGINE LIGHT REMAINED ON, AND I GAINED ACCELERATION POWER. I TOOK THE VEHICLE TO THE DEALERSHIP. THEY DETERMINED I HAD A FAULTY THROTTLE POSITION SENSOR AS WELL AS BRAKE LIGHT SWITCH AND BOTH WERE REPLACED BY THE DEALER. [CURRENT MILEAGE ON VEHICLE AFTER ALL INCIDENTS: 48,897]