2004 Hyundai Santa Fe Airbags Problems

Your airbag warning light stays on all the time and won't turn off, even though you've never had an accident. You're not sure if this means your airbags are actually broken or if it's just a faulty light, and you're concerned the airbags might not deploy if you need them. A dealer will need to scan your airbag system's diagnostic codes to identify whether it's a sensor malfunction, wiring issue, or actual airbag component failure.

Your airbag warning light turns on and off intermittently during drives, and now stays on constantly. This suggests a wiring or electrical connection issue with your airbag system. A mechanic will need to diagnose and repair the faulty wiring to restore proper airbag function.

Your airbag warning light stays on constantly, and your brakes don't feel like they used to. Since you've owned this 15-year-old SUV for its entire life, you're concerned about your safety. You'll likely need a diagnostic scan to check the airbag system and a brake inspection to assess pad wear and fluid condition.

MY DAUGHTER WAS INVOLVED IN A CRASH WHERE AIR BAGS WERE NOT DEPLOYED

I WAS INVOLVED IN AN ACCIDENT WHILE DRIVING DOWN A CITY STREET IN PLANO, TEXAS. A TRUCK PULLED OUT TO GET INTO THE MIDDLE LANE AND WAS CAUGHT OFF AND FORCED TO PULL INTO MY LANE DIRECTLY IN FRONT OF ME. MY BRAKES LOCKED UP AFTER TRYING TO STOP, WHICH ISN'T A PROBLEM BECAUSE I KNOW IT IS NORMAL. WHAT OCCURRED WAS THAT AS I STRUCK THE TRUCK IN FRONT OF ME, MY AIR BAGS DIDN'T DEPLOY, AND MY SEAT BELT HAD FAILED TO LOCK. WHICH CAUSED ME TO COLLIDE WITH THE STEERING WHEEL. THE SPEED I STRUCK THE TRUCK, WHICH WAS GOING ABOUT 10 MPH WHEN WE COLLIDED, WAS ABOUT 45 MPH.

I WAS IN A SERIOUS CAR ACCIDENT BACK IN DECEMBER 7, 2005 WITH MY 2004 HYUNDIA SANTE FE. THE CAR WAS TOTALED AND SCRAPPED THUS I DO NOT HAVE THE VIN NUMBER HANDY. I DO STILL HAVE THE PAPERWORK FROM THE HOSPITAL AND THE PERSONAL INJURY LAWYER. THE AIRBAGS DID NOT DEPLOY. I WAS THE ONLY PERSON IN THE VEHICLE. I WAS DRIVING HOME FROM WORK ON MY USUAL ROUTE ON EASTON AVENUE. I'M TOLD (REPORTS FROM WITNESSESS) A YOUNG GIRL CAME OUT OF A SIDE STREET AND HIT ME IN THE REAR DRIVERS SIDE WHICH IN TURN SPUN MY CAR INTO 2 OTHER VEHICHLES ON THE OPPOSITE SIDE OF THE ROAD I WAS TRAVELLING DOWN. AS STATED EARLIER I HAVE LITTLE RECALL SINCE THE IMPACT KNOCKED ME UNCONSCIOUS. I SUFFERED A BROKEN NOSE (SCAR STILL THERE) AND TORN LEFT SHOULDER- WHICH STILL BOTHER ME DAILY. I WAS HIT BLINDSIDE AND SPIN INTO 2 OTHER VEHICLES- KNOCKED UNCONSCIOUS. I STILL SUFFER NIGHTMARES RESULTING FROM THIS ACCIDENT AND AM CURRENTLY SEEING A COUNSELOR SPECILIZING IN TRAUMA AND PTSD.

AIR BAG LIGHT STAY ON CONSTANTLY, AND DON'T GO OFF. I WAS RIDING AND LIGHT POP ON AND STAY ON.

WHILE DRIVING ON A STRAIGHT STRETCH OF HIGHWAY, THE DRIVER'S SIDE (LEFT SIDE) SIDE IMPACT AIRBAG DEPLOYED FOR NO APPARENT REASON. *TR

TODAY, 11/2816, RIGHT FRONT PASSENGER SIDE AIR BAG "DEPLOYED" FOR NO REASON. DRIVING AT ABOUT 55 MPH. NO IMPACT OR COLLISION. SEAT RIPPED OPEN. *TR

WAS ON HIGHWAY TRAVELING AT POSTED SPEED OF 70MPH WHEN WE WERE HIT FROM BEHIND BY A DUI DRIVER. THIS MADE MY CAR GO INTO A SPIN AND ROLLOVER 4 TIMES. NONE OF THE AIRBAGS DEPLOYED. CAR IS TOTAL LOSS. I RECEIVED DISLOCATION OF MY COLLARBONE THAT NEEDED EMERGENCY SURGERY, CONCUSSION, FRACTURED NOSE, LACERATIONS TO HEAD AND FACE, KNEE AND HIP INJURY.

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. WHILE THE VEHICLE WAS PARKED, THE FRONT AIR BAG DEPLOYED FROM THE SEAT WITHOUT WARNING OR IMPACT. A POLICE REPORT WAS NOT FILED. THE CONTACT RECEIVED INJURIES TO THE CHEST, ARM, HIP, RIB, AND HEAD THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,294.

TAKATA RECALL. JUST PRIOR TO A HYUNDAI RECALL IN 5/3/16 FOR A DEFECTIVE GAS TANK, MY "AIR BAG" LIGHT WENT OFF. LET ME BACK TRACK . IN 5/16, MY CAR BEGAN LEAKING GAS UNDERNEATH. SO BADLY, THAT ONE DAY WHILE PASSING THE FIRE/POLICE STATION IN NORFOLK, MA THE FIRE CHIEF AND HIS CREW BEGAN PURSUING ME. STOPPING ME IN MY DRIVEWAY, I WAS TOLD ABOUT THE LEAK AND WAS TOLD I WOULD HAVE TO SURRENDER MY CAR, IT WAS A "SAFETY HAZARD TO (ALL)." I PRESENTED A AAA MEMBERSHIP CARD. THE CHIEF HIMSELF CALLED AND ARRANGED A TOW TO A LOCAL REPAIR SHOP. AFTER 2 DAYS, I RECEIVED A LETTER FROM HYUNDAI CORPORATION STATING THAT MY "GAS TANK WAS FAULTY" AND WAS SUBJECT TO A "RECALL". IMAGINE THE TIMING ON THAT? THE NATIONAL OFFICE OF HYUNDAI SOUNDED JUST GREAT ON THE PHONE. BUT WHEN MY MECHANIC SAID HE WOULD NOT TOUCH THE CAR FOR FEAR OF COMPLICATING THE WARRANTY, NO ONE INCLUDING HYUNDAI WOULD SEND ANYONE TO TOW THE CAR. AT MY PERSONAL PERIL, I DROVE TO THE NEAREST DEALERSHIP. AS I APPROACHED THE RECEPTION AREA, ALL REMAINING GAS GUSHED OUT OF MY CAR. I WAS GIVEN A BEAUTIFUL CURRENT HYUNDAI TO DRIVE AS A LOANER CAR; I NEEDED THAT CAR FOR 2 MONTHS. WHEN THE DEALERSHIP CALLED TO TELL ME MY CAR WAS "READY", THEIR ADVISOR ISSUED 2 PAGES OF PROBLEMS ALLEGEDLY EXISTING AND TRIED TO SELL ME A NEW CAR. I HAVE SINCE HAD SOMEONE ELSE LOOK AT MY CAR; NONE OF THOSE PROBLEMS EXIST. WHEN I PICKED UP MY CAR FROM THE DEALER, I ALSO ASKED THEIR ADVISOR "WHY HYUNDAI HADN'T FIXED THE AIR BAG LIGHT?" OVER THE 2 MTHS THEY HAD MY CAR. I WAS TOLD THAT "HYUNDAI DIDN'T USE TAKATA AIR BAGS." HOWEVER, NUMEROUS FRIENDS OF MINE DRIVING OTHER MODELS OF HYUNDAI HAVE RECEIVED RECALLS CITING THE "TAKATA AIRBAG RECALL." MY PASSENGER AIR BAG IS DEFECTIVE. THE DEALER TOLD ME "THE BAG ALONE WOULD COST $800. BUY A NEW CAR!" WHAT IS GOING ON HERE?

ON DAY THE AIR BAG WARNING LIGHT CAME ON ON THE VEHICLE AND HAS NEVER GONE OFF. THE DEALER TOLD ME THAT THE AIR BAG CONTROL MODULE HAD FAILED. THE DEALER TOLD ME THE REPAIR WOULD COST $450!. I COULD NOT AFFORD TO SPEND THAT MUCH MONEY TO HAVE IT FIXED. I HAVE ALREADY SPENT OVER $3000 ON REPAIRS FOR THIS VEHICLE AND I CANNOT AFFORD TO PUT ANY MORE MONEY IT TO. FROM THE NUMBER OF AIR BAG COMPLAINTS I HAVE SEEN I THINK THERE SHOULD BE A RECALL ISSUED.

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE AIR BAG WARNING LAMP REMAINED ILLUMINATED NEAR THE FRONT PASSENGER SIDE, INDICATING A MALFUNCTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS MADE AWARE THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION) AND WAS WAITING FOR THE RECALL NOTIFICATION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 137,000.

MY SANTA FE WAS TAKEN IN FOR SERVICE DURING WHICH TIME THE AIR BAG LIGHT WAS ACTIVATED. I HAD IT CHECKED BY MY LOCAL HYUNDAI DEALER AND I WAS TOLD THAT THE AIR BAG MODULE HAD FAILED. I WAS TOLD THAT THE REPAIR COST WAS GOING TO BE $450. I HAVE ALREADY HAD TO SPEND OVER $4000 FOR OTHER REPAIRS ON THIS VEHICLE AND I CANNOT AFFORD TO SPEND ANY MORE. I HAVE READ ON THE INTERNET OF NUMEROUS COMPLAINTS OF AIR BAG MODULE FAILURES ON MANY DIFFERENT MODELS OF HYUNDAI'S. SINCE THERE HAVE BEEN SO MANY REPORTS OF THE SAME PROBLEM AND IT IS A SAFETY ISSUE I THINK THAT THERE SHOULD BE A RECALL TO REPAIR THE FAULTY AIR BAG MODULES. *TR

I WAS DRIVING MY CAR TO PICK UP MY SON. I DID NOT CRASH MY CAR AT ALL. ALL OF SUDDEN. MY AIR BAG LIGHT CAME ON AND WONT SHUT OFF. I HAVE CONTACTED THE WARRANTY COMPANY AND THE DEALERSHIP. THERE IS NOTHING THEY CAN DO. I BROUGHT MY CAR TO MY MECHANIC HE PUT IT UP TO THE COMPUTER IT READ RESISTANCE AIR BAG. ITS GOING TO COST ME A LOT OF MONEY TO GET IT FIXED. MY WARRANTY WAS UP A WHILE AGO. ITS A SAFETY ISSUSE. I JUST DON'T HAVE THE MONEY CAUSE I JUST GOT THE CAR 8 MONTHS AGO. ALREADY I PUT IN 1,000 INTO IT. I JUST GOT THE FOOT MODULE THE BRAKES AND NOW THE AIR BAG LIGHT IS ON. CAN YOU PLEASE HELP ME. THERE IS ALSO A PROBLEM WEIGH THE SUSPENSION.

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, HE LOST CONTROL OF THE VEHICLE AND CRASHED. THE AIR BAGS FAILED TO DEPLOY. THE POLICE WERE CONTACTED AND A REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES TO THE STERNUM. THE VEHICLE WAS LATER TOWED TO AN INDEPENDENT MECHANIC WHERE THEY DEEMED THE VEHICLE AS DESTROYED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 105,000. THE VIN WAS UNAVAILABLE. *TR

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE PASSENGER SIDE AIR BAG DEPLOYED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS WHO STATED THAT EVERYTHING APPEARED TO BE NORMAL AND NO CAUSE FOR FAILURE WAS FOUND. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 83,000.

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE DRIVER SIDE AIR BAG ERRONEOUSLY DEPLOYED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THEY COULD NOT DIAGNOSE THE CAUSE OF FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 70,000.

AIR BAG TROUBLE INDICATOR LIGHT STAYS ON AFTER STARTING ENGINE. QUESTIONED DEALER, THEY ARE AWARE OF KNOWN PROBLEM WITH DRIVER SEAT AIR BAG SWITCH AND WIRING CAUSING AIR BAG INDICATOR LIGHT TO COME. HYUNDAI WILL NOT MAKE REPAIR TO THIS SAFETY DEFECT AT THEIR COST. COST IS WELL OVER $1000.00. *TR

WHEN I PURCHASED THE CAR AS THE SECOND OWNER IN MARCH 2010, I NOTICED THAT THE AIRBAG LIGHT HAD BEEN A PROBLEM FROM THE PREVIOUS OWNER. HOWEVER, THE DEALER ASSURED ME THAT IT WAS FIXED. AFTER PURCHASING THE VEHICLE IN 2010 AND BEFORE I TOOK OWNERSHIP I HAD TO LEAVE IT WITH THE DEALER AS THE AIRBAG AND SEAT BELT LIGHTS WERE ON. I HAVE TAKEN THE VEHICLE BACK TO THE DEALER AT LEAST THREE TO FOUR TIMES FOR THE SAME PROBLEMS, HOWEVER WAS TOLD THAT THERE WERE DIFFERENT CODES EACH TIME. WAS TOLD THAT I NEEDED TO REPLACE THE SEAT BELT BUCKLE IN ORDER CORRECT THE AIRBAG LIGHT, HOWEVER, AS OF 4/3/12 WAS TOLD BY DEALERSHIP (HERB CONNOLLY HYUNDAI) THAT IN NEED TO REPLACE THE AIRBAG. ALSO THAT THE AIRBAG WAS NOT UNDER WARRANTY AND IT USUALLY HAS TO BE REPLACED AT 60K MILES. WHEN I PURCHASED MY VEHICLE IT HAD 81K MILES, GIVEN THIS FACT, THEY SHOULD HAVE REPLACED THE AIRBAG PRIOR TO ME PURCHASING IT. THE CODE THAT IS SHOWING NOW IS B1346 (AIRBAG HAS HIGH RESISTANCE). DEALER REFUSE TO CORRECT THE PROBLEM AT NO COST AFTER SEVERAL ATTEMPTS TO GET THE PROBLEM RESOLVED. *TR

I TOOK MY CAR INTO MY NEW LOCAL DEALER WALLACE HYUNDAI , STUART FL. MY AIR BAG LIGHT STARTED STAYING ON ALL THE TIME. AT THE TIME I BROUGHT IT IN, MY VEHICLE WAS STILL COVERED UNDER THE BUMPER TO BUMPER WARRANTY. THIS DEALER TOLD ME I HAD TO PAY $100.00 TO INSPECT THE VEHICLE FOR THE ISSUE. I HAVE NEVER IN THE LIFE OF OWNING 2 HYUNDAI SANTE FE'S (THIS BEING MY 2ND) DID I EVER HAVE TO PAY UP FRONT FOR BUMPER TO BUMPER ISSUES. I AM DISABLED AND DID NOT HAVE THE $100.00 SO I LEFT AND THEN THE WARRANTY RAN OUT, SO MY ISSUE HAS NEVER BEEN TAKEN CARE OF. TO THIS DAY, MY AIRBAG LIGHT IS STILL ON AND I AM CONCERNED IT WILL EITHER DEPLOY OR NOT DEPLOY AT ALL IN AN ACCIDENT. UPDATED 03/23/11

AIR BAG LIGHT STAYS ON. AIR BAGS WILL NOT DEPLOY IN AN ACCIDENT. *TR

AIR BAG LIGHT COMES ON AND STAYS ON WHEN THE ENGINE IS STARTED AND RUNNING. ALSO, THE SEAT BELT DOES NOT RETRACT EVERY TIME WHEN I EXIT THE SUV. I HAVE HAD NO ACCIDENT OR ANYTHING I KNOW OF THAT MIGHT HAVE CAUSED A PROBLEM WITH IT. AS I CALLED THEM ABOUT IT HOWEVER, THEY SAY I MUST PAY FOR THE REPAIRS. THE VEHICLE HAS 82,000 MILES ON IT. I AM THE SECOND OWNER HAVING PURCHASED THE CAR WITH 45,000 MILES ON IT ABOUT 4 YEARS AGO. I HAVE BEEN ON LINE AND NOTICED THERE ARE A NUMBER OF OTHERS THAT HAVE EXPERIENCED THIS SAME PROBLEM. *TR

THE AIRBAG SYSTEM STOPPED WORKING WITHOUT EVER HAVING BEEN USED IN A 2004 HYUNDAI SANTA FE. THE AIRBAG SYSTEM IS CURRENTLY NOT FUNCTIONING IN THE VEHICLE. THE SERVICE PROVIDER STATED THE AIRBAG WILL NOT DEPLOY IF WE ARE IN AN ACCIDENT AND TOLD US IT WOULD COST $1800.00 TO FIX IT. *TR

MY WIFE WAS DRIVING ON A LITTLE ST. IN FOSTORIA,OHIO ON OCT 16 AT APPROX. 4 PM. HER SPEED WAS AROUND 35 MPH AND THE ROAD CONDITIONS WERE GOOD. SHE HAD A LARGE VEHICLE ON HER DRIVER SIDE AS THIS IS A TWO LANE HIGHWAY. A BLAZER/BRONCO CROSSED FROM THE ONCOMING LANE ATTEMPTING TO TURN ON A SIDE STREET (SOUTH UNION STREET, CUTTING RIGHT IN FRONT OF OUR 2004 HYUNDAI SANTA FE. THE IMPACT STOPPED HER VEHICLE IMMEDIATELY AND DROVE HER CAR INTO A TRUCK WAITING TO TURN ONTO LITTLE STREET FROM THE SAME SIDE STREET. ALTHOUGH THE ACCIDENT CAUSED A FRONT END IMPACT TO OUR HYUNDAI, THE AIRBAG IN OUR HYUNDAI DID NOT DEPLOY. MY WIFE SUSTAINED INJURIES TO HER LEFT COLLARBONE AND SHOULDER, AND ALSO TO HER RIGHT KNEE, REQUIRING A TRIP TO THE EMERGENCY ROOM AND XRAYS. SHE WAS ALSO UNABLE TO WORK FOR A SHORT TIME DUE TO HER INJURIES. *TR

WE TOOK OUR VEHICLE TO GARY ROME HOLYOKE FOR ROUTINE SERVICE AND COMPLAINT OF A AIR BAG WARNING LIGHT ON. WE WERE TOLD THAT IT WAS A UNIT UNDERNEATH THE SEAT THAT WAS BAD. THEY GOT THE LIGHT TO GO OFF AND WE WERE TOLD TO SELL OR TRADE THE CAR BEFORE THE LIGHT CAME BACK ON. WE WERE TOLD WE WERE OUT OF WARRANTY,BY LESS THAN 1000 MILES AND TO REPLACE THIS PART WOULD BE IN THE $2000-$3000 RANGE. THEY ALSO SAID IT WAS THE SIDE AIRBAGS AND THEY WERE HAVING PROBLEMS WITH THIS PART ON OTHER MODELS AS WELL. MY WIFE WAS TOLD THE SAME BY THE MANUFACTURER WHEN SHE CALLED. *TR

TL*THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. WHILE DRIVING 70 MPH, THE CONTACT'S VEHICLE WAS STRUCK ON THE DRIVER'S SIDE BY A TRACTOR TRAILER. THE VEHICLE WAS DESTROYED AND NONE OF THE AIR BAGS DEPLOYED. THE FAILURE MILEAGE WAS 109,000.

FAILURE OF DRIVER'S SIDE FRONTAL AIRBAG TO DEPLOY ON A 2004 HYUNDAI SANTA FE. MY WIFE WAS DRIVING HER SANTA FE ON A TWO-LANE COUNTRY ROAD IN WESTERN PENNSYLVANIA. WEATHER AND ROAD CONDITIONS WERE NORMAL, WITH NO ICE, SNOW, OR OTHER SLIPPING HAZARDS ON THE ROAD. AS SHE ROUNDED A CURVE A CAR WAS STOPPED DIRECTLY IN FRONT OF HER AND BECAUSE HER VISION WAS OBSTRUCTED BY LANDSCALE ALONG THE ROAD SHE COULD NOT SEE THE OTHER VEHICLE (A 1988 JEEP TRUCK) BEFORE SHE STRUCK IT. DAMAGE TO THE JEEP WAS MINIMAL (BROKEN REAR WINDOW AND BENT BUMPER), BUT DAMAGE TO THE FRONT OF HER SANTA FE WAS EXTENSIVE, ESTIMATED ABOUT $9,500. I CALLED OUR LOCAL HYUNDAI DEALERSHIP IN MONTGOMERY, ALABAMA TO URGE THEM TO CONTACT THE MANUFACTURER ABOUT A POTENTIAL AIRBAG MALFUNCTION. I WAS TOLD BY THE SERVICE DEPARTMENT THE FAILURE OF THE AIRBAG TO DEPLOY WAS NOT UNUSUAL BECAUSE THE AIRBAG DEPLOYMENT SENSORS ARE LOCATED WELL BACK FROM THE FRONT OF THE CAR. GIVEN THE SEVERE DAMAGE TO THE CAR (THE FRONT IS EXTENSIVELY CRUSHED) AND THE PENNSYLVANIA STATE TROOPERS OBSERVATION THAT HE WAS SURPRISED THE AIRBAG DID NOT DEPLOY, HYUNDAI SHOULD ADDRESS THIS POTENTIAL PROBLEM. *TR

AIR BAG LIGHT CONTINUALLY COMES ON, DEALER MUST MAKE REPAIRS. WHEN LIGHT IS ON, AIR BAGS DO NOT FUNCTION. THE FIRST TIME THIS HAPPENED, THE SERVICE MANAGER STATED THAT THIS IS A COMMON PROBLEM WITH THIS MODEL. *TR

2004 HYUNDAI SANTA FE WITH AIR BAG SAFETY CONCERNS CUSTOMER STATES THAT THE REPAIR OF THE AIR BAG WARNING LIGHT IS ON**CC THE CONSUMER STATED THAT A SAFETY DEVICE SHOULD LAST LONGER THAN 69,000 AND HE SHOULD NOT HAVE TO BARE THE RESPONSIBILITY OF PAYING FOR THE REPAIR. *JB

I HAVE A 2004 HYUNDAI SANTA FE.12/9/06 MY WIFE AND DAUGHTER WERE INVOLVED IN A ACCIDENT WERE NEITHER FRONT AIR BAGS WENT OFF. THE POINT OF IMPACT WAS THE DRIVERS FRONT LEFT. PARAMEDICS AS WELL AS MYSELF WERE CONCERNED THAT THE AIR BAGS DID NOT DEPLOY. *NM

DT: WITHOUT WARNING THE PASSENGER SIDE AIR BAG DEPLOYED. CONSUMER DID NOT HIT ANYTHING OR RUN INTO A HOLE. CONSUMER HAD NO INDICATION THAT ANYTHING WAS WRONG. INSURANCE ADJUSTER SAID NO SIGN OF PHYSICAL IMPACT, APPEARS TO BE MECHANICAL OR ELECTRICAL MALFUNCTION. RIGHT SIDE AIR BAG APPEARS TO HAVE DEPLOYED PREMATURELY. DEALER LOOKED AT IT AND TOLD THE CONSUMER THEY COULD NOT TOUCH IT BECAUSE OF THE MANUFACTURER. MANUFACTURER SAID IT WAS TURNED OVER TO THE LEGAL DEPARTMENT. CONSUMER HAS NOT HEARD BACK FROM MANUFACTURER. *TT *NM

WHILE TRAVELING THROUGH AN INTERSECTION AT WHICH I HAD THE GREEN LIGHT, ANOTHER VEHICLE, TRAVELING PERPENDICULARLY, RAN THE RED LIGHT AND MY HYUNDAI SANTA FE SMASHED RIGHT INTO THE PASSENGER SIDE OF THAT VEHICLE. MY SPEED WAS APPROXIMATELY 25 MPH, YET THE AIR BAG DID NOT DEPLOY. THE ENTIRE FRONT OF MY VEHICLE IS SMASHED AND THE CAR MAY POSSIBLY BE TOTALED (WE ARE WAITING FOR INSURANCE CLAIMS ADJUSTERS TO EXAMINE). OUR CONCERN IS THAT THE AIRBAGS DID NOT DEPLOY ON IMPACT, AS THEY SHOULD HAVE. *JB

I PURCHASED A 2004 SANTA FE HYUNDAI 8-25-04. ON 9-3-04 I WENT OUT OF TOWN. ABOUT 75 MI FROM MYHOME,I WAS DRIVING 65 MPH ON I-35 AND THE PASSENGER SEAT AIR BAG EXPLODED IN THE CAR. FORTUNATELY, NO ONE WAS IN THE SEAT. I DID NOT GET HIT BY ANY CAR, I DID NOT HIT A CHUCK HOLE OR ANY DEBRIE THAT COULD HAVE BEEN SEEN ON THE HWY. I IMMEDIATELY CALLED ALLEN SAMUELS SERVICE DEPT, TALKED TO PHIL AND HE SAID HE NEVER HEARD OF THAT HAPPENING AND TO BRING IT INTO THE SERVICE DEPT ON 9-7-04 WHICH I DID. THEY GAVE ME A RENTAL CAR; THEY SAID THE SEAT AIR BAG WAS ON BACK ORDER AND THEY DID NOT KNOW WHEN IT WOULD BE AVAILABE. I HAD MY CAR THERE FOR 2 WEEKS. THEY CALLED ME ON 9-20 AND SAID THIS WAS NOT UNDER WARRANTY AND TO TURN MY RENTAL IN. I PICKED UP MY CAR AT THIS TIME. THE TECH TOLD ME I MUST HAVE HIT A SMALL OBJECT LIKE A PIECE OF WOOD AND IT HIT THE SENSOR.*AK