2024 Honda Pilot Other Problems

Your 2024 Honda Pilot experienced an engine fire on November 12th at 7:30 AM, which you were able to safely escape with your three young children. There was an open recall related to this fire risk that Honda's website shows as incomplete, even though you have documentation that you took the vehicle in last year for the recall repair. Honda's service records and your paperwork appear to conflict about whether the recall was actually completed, and the fire department responded and extinguished the fire. This will likely require Honda to investigate why the recall repair may not have been properly completed and to perform the correct repair to address the underlying engine fire risk.

While driving on I-95 North near Pooler, Georgia, your panoramic sunroof suddenly shattered with a loud explosion-like sound, sending glass into the cabin. The tempered glass appears to have burst outward. This occurred on December 17, 2025, and no crash or fire was involved.

While driving our 2024 Honda Pilot Touring, I came to a full stop at a red light. When the light turned green and I attempted to accelerate, the vehicle completely shut off without warning. There was no sputtering, no warning lights, and no error messages. The engine shut off instantly, and all systems—including both screens, air conditioning, horn, and hazard lights—were completely unresponsive. The vehicle was entirely disabled. It remained unresponsive for 5–10 minutes before showing any sign of power. It took four attempts to restart the vehicle. This happened in an active intersection, creating a serious safety risk. I could not move or signal to other drivers, and the car gave me no way to handle the emergency safely. The vehicle was taken to a Honda dealership for inspection. They ran diagnostic tests but were unable to reproduce or identify the issue and called it a “fluke.” No repairs were made, and the root cause was not identified. I was told to take the vehicle home and monitor it. This issue has not recurred yet, but I am concerned it could happen again at any time. The vehicle is available for inspection upon request. The problem has not been confirmed by the manufacturer or a third-party inspector. No warning lights or other symptoms appeared before the failure

On three occasions, my car has not started as expected. Twice I was at busy intersections at a stop, and when I started to go, the car shut off and would not allow me to restart the engine. The third time I had not been driving and was in a parking lot, trying to start the car to leave and it also would not start. When this happens, the brake locks, the steering locks, but the lights are still on around the center console. The start stop button goes black and refuses to work on all three occasions. I have had to wait and try again and try again and try again before the car will restart and allow me to drive again. Then all of the panic alerts flash on the dash and cycle over and over and over telling me to see the dealer also saying there is a brake system problem. I do have a video of these, but my video is too large to attach here. This is very dangerous being stuck in an intersection with cars all around not being able to move. I took the car into the dealer today and they wanted to tell me that my battery was having interference or corrosion. The car is only one year old. They also said that the idle start stop was draining amperage from the battery perhaps keeping it from restarting if I were making short trips or in heavy traffic. Either way, this is a huge problem and safety concern on my part. I am paying for a brand new car that I feel is unsafe. They did not share with me that there is an active investigation about this very issue. I feel they were not very transparent with me. Down below, I will attach an image of what the dealer said about the issue when I visited them today.

Vehicle has many fault codes that will not clear. Took to dealership and the state they believe its a wheel speed sensor and vehicle is safe to drive. Flashing warnings include AWD system problem, electric parking brake problem, brake system problem, brake hold system problem, electric power steering problem, antilock brake system problem, vehicle stability assist problem, hill start assist problem, trailer stability assist problem, hill descent control system problem, adaptive cruise control problem, lane keep assist problem, collision mitigation system problem, road departure mitigation system problem, low speed braking problem, auto high beam problem, parking sensor problem, antilock brake system problem, as well as drive mode change unavailable, rear hatch will not open, drivers seat will not automatically move into position once vehicle is started, vehicle will not shut off without having to hit the off button numerous times, and vehicle is not auto shutting off after the 10-15 min timeframe. Dealer states they have ordered the part and is currently on back order. Was told Honda does not provide loaner vehicles for warranty work. Seems strange that a wheel sensor could cause so many errors and shut off all safety features, brakes and drivetrain of the vehicle.

Rattling noise when using heater. Seems to happen when the car is cold and fan speed doesn't seem to change it much. Once the car is warmed up it mostly disappears.

Just returned back home from a quick drive and the vehicle was sitting in my driveway. After about 20 min I walked by the car and noticed the entire back window in multiple pieces. There was no one that walked by or drove by. Pieces of glass were noted to be 10 feet behind the vehicle on the driveway. There was no one in the vehicle at the time and nothing in the trunk area that was potentially pressing on the glass. Vehicle was towed to the dealership where it was collision wrapped until the glass could be replaced.

I purchased a 2024 Honda Pilot on [XXX]. In March, between the 4th & 22nd (approx 1800 mi) I thought I saw a crack but as my vehicle had been parked in the parking structure where I live adjacent the ports of LB & LA (prone to excessive dust) & recent rain/moisture causing the dust to form into lines I figured to wait until washing before confirming. On 3/22 I confirmed a crack - no point of impact. As I had planned a vacation to Mexico I opted to photograph the crack AND the vehicle in Mexico capturing date and location stamp. I returned on 4/16. On 4/29 I took my vehicle to El Monte Honda. I let the service advisor know about the crack & upon inspection he found a 2nd crack - no point of impact. The advisor said they were scratches on the inside - 2 piece laminated. I pushed back because the visible thickness of the crack I discovered did not match the hairline feel. He convinced me that replacing the windshield could lead to other issues such as leakage - a known problem on the current generation so I asked him to note the damage - he noted a scratch. I took the vehicle but ultimately decided it wasn't fair as both were in drivers line of sight. Upon return he said the system used to communicate between the dealership and manufacturer was down and would have to come back. I called 2 months later - no return call. 9/13/24 I decide to go to local dealer (Long Beach Honda). The service advisor inspected and said he would call Honda but did not. Driving away I noted a smudge where the advisor located a crack - a 3rd crack, no point of impact. Called Honda & they said no record of me going to the dealer. Closed case. On 10/1 I returned to LB Honda with a record from 4/29 and images. He said possible glass delamination but only because a Boeing engineer reenforced stress cracks. He did not return calls nor advise Honda. Called Honda. They refuse to do anything without a diagnosis and service advisors are running away in what appears a deliberate effort. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

on 3/9/24 while traveling west on I10 the panoramic rooftop window shattered. Had the canvas from the sunroof been rolled back the shattered glass from the window would have come down on my husband and myself while driving 75 miles per hour. Because the glass shattered it had to be taken back to the dealer for repair. Which is still there 6/17/24. The glass was embedded in the track for the skylight. Dealer is aware of issue.

I bought the car on 11th of November it’s has now 8000 miles today 1/24/2024 all the check engine and warning safety lights came on i went to the Kay Honda dealership to find the problem he says u have to get appointment also I complained at the dealer whom I bought car from about the brakes is not working properly as a new car with no attention mentioning to me cause that’s a big truck so the brakes like that also complained about the axles makes noises when backing like it broken I got pics for the dash board showing the issue

I was driving down the road and my sunroof exploded. It was random and there was no debris around. I had my cover closed so no glass fell into the car. Looking at the sunroof it appears as if it exploded up.