2009 Honda Odyssey Engine Problems

Your engine caught fire without warning about 10 minutes after you parked your van. The alarm sounded first, and as soon as you disarmed it, the entire engine became engulfed in flames. The vehicle was well-maintained with no warning lights, so there were no signs of a problem beforehand. You'll need a professional fire investigation and engine inspection to determine what caused the fire.

Your engine is misfiring, which causes the car to slow down noticeably when climbing hills or running the air conditioner. This problem could potentially worsen while driving and create a safety hazard.

Your engine stalled while driving at speeds over 70 mph, and multiple warning lights appeared on your dashboard including the Check Engine light, Vehicle Stability Assist warning, and tire pressure warning. The Drive indicator light was also flashing. This happened at around 150,000 miles and hasn't been diagnosed or repaired. The engine stalling at highway speeds could indicate a fuel system problem, ignition issue, or sensor malfunction that needs professional diagnosis.

Your 2009 Honda Odyssey is consuming excessive engine oil and showing check engine and low oil pressure warning lights while driving at various speeds. You've also noticed abnormal vibration when idling. A Honda dealership diagnosed the issue as worn engine rings that need replacement, but the repair wasn't completed because your warranty had expired. Fixing this will likely require engine ring replacement, which is a major internal engine repair.

Your muffler has developed severe rust and has become so deteriorated that it can be easily punctured. You may notice rust flakes falling from underneath the vehicle. The muffler will likely need to be replaced to prevent exhaust leaks and further damage.

THE VEHICLE IS CONSUMING A LOT OF OIL. THE LAST 2 TIMES I TOOK IT TO WALMART I WAS INFORMED THERE WAS NO OIL IN MY ENGINE. NO LIGHTS CAME ON, THE OIL INDICATOR STATED I STILL HAD LIFE LEFT IN THE OIL. THERE HAS BEEN NO OIL ON THE GROUND. THIS IS DANGEROUS AS THE ENGINE CAN SEIZE AND CAUSE AND ACCIDENT.

TL* THE CONTACT OWNED A 2009 HONDA ODYSSEY. THE CONTACT STATED THAT WHILE HIS SON WAS DRIVING AT 50 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE ENTIRE VEHICLE BEGAN RATTLING AND THEN SMOKING. THE CONTACT IMMEDIATELY PULLED OVER AND THE VEHICLE BURST INTO FLAMES. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE VEHICLE; NO INJURIES WERE SUSTAINED. NO REPORTS WERE FILED; THE VEHICLE WAS TOTALED ON THE SCENE AND TOWED TO A TOW YARD. THE DEALER ( OPEN ROAD HONDA 50 US-1, EDISON, NJ 08817 (732) 839-4800) WAS CONTACTED AND INFORMED OF THE FIRE; THEY ARE AWAITING A REPORT FROM THE INSURANCE COMPANY. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THERE ARE NO RECALLS ASSOCIATED WITH THE VEHICLE AND THE FAILURE MILEAGE WAS 102,000. *AS *TR

WHILE MY CAR WAS PARKED AT A STORE, MY ENGINE CAUGHT FIRE LEADING TO A TOTAL LOSS OF THE VEHICLE. I DROVE MY CAR FOR A SHORT DISTANCE TO DO TWO ERRANDS (MAYBE 15 MIN. DRIVE). I PARKED MY CAR AND WENT IN TO SHOP FOR MAYBE 15 - 20 MINUTES. WHEN I CAME OUT OF THE STORE, BLACK SMOKE WAS BILLOWING OUT FROM THE ENGINE FOLLOWED SHORTLY AFTER BY FLAMES. BY THE TIME THE FIRE DEPARTMENT WAS ABLE TO PUT OUT THE FIRE, THE CAR'S ENGINE COMPARTMENT WAS DESTROYED. IF THIS HAD HAPPENED AT HOME WHILE MY CAR WAS IN THE GARAGE, MY HOUSE COULD HAVE CAUGHT FIRE AS WELL. THANKFULLY THERE WERE NOT MANY CARS PARKED CLOSE TO MINE SO NO OTHER VEHICLE WAS AFFECTED. MY CAR HAD THE FUEL PUMP REPLACED WITH THE 2014/5 RECALL NOTICE. THE CAR HAD BEEN SERVICED AT THE DEALER IN JANUARY AND SUCCESSFULLY PASSED A STATE SAFETY AND VEHICLE EMISSIONS TEST TWO DAYS BEFORE THE FIRE. THE FIRE CLEARLY STARTED IN THE ENGINE COMPARTMENT.

WHILE DRIVING THE CHECK ENGINE LIGHT COMES ON AND THE VEHICLE LOSES POWER AND SHAKES. THE VEHICLE CONSUMES EXCESSIVE OIL WHICH CAUSES THE PLUGS TO FOUL AND FAIL. THE KNOWN ISSUE IS CAUSED BY A DEFECTIVE VEHICLE CYLINDER MANAGEMENT (VCM). WHEN THIS OCCURS, THE VEHICLE EXHIBITS A BURNING OIL SMELL AND GAS SMELL IN THE CABIN. THIS HAS ALMOST CAUSED A MAJOR HIGH SPEED ACCIDENT BECAUSE OF THE INABILITY OF THE VEHICLE TO MAINTAIN HIGHWAYS SPEEDS AND THE REDUCED POWER TO THE ENGINE MAKES THE VEHICLE HARD TO STEER DUE TO LOSS OF POWER ASSISTED STEERING CAUSE BY THE REDUCED ENGINE POWER. THERE SHOULD BE A RECALL OF THE HONDA VCM SYSTEM BEFORE A FATALITY OCCURS.

3.5L V6 ENGINE MISFIRE, PLUGS FOULING, PISTON RING REPLACEMENT AS PART OF THE CLASS ACTION SETTLEMENT FOR ENGINE MISFIRE, HONDA CORP ISSUED A SERVICE BULLETIN TO UPDATE THE PCM SOFTWARE AND REPLACE THE AFFECTED SPARK PLUGS. THIS REMEDY DOES NOT FIX THE PROBLEM. RECOGNIZING THE ORIGINAL REMEDY WAS NOT AFFECTIVE, HONDA CORP ISSUED A SERVICE BULLETIN TO EXTEND ENGINE WARRANTY TO 8 YEARS OR 125,000 MILES WHICHEVER IT COMES FIRST. FOR MY SPECIFIC CASE, THE FIRST TIME THIS PROBLEM OCCURRED WHILE DRIVING IN AUG 2014 WITH 57,486 MILES (MIL LIGHT ON, ENGINE STUMBLES, LOSS OF POWER), THE HONDA DEALERSHIP SERVICED MY VEHICLE BY FOLLOWING THE SERVICE BULLETIN TO UPDATE THE PCM SOFTWARE AND REPLACE THE AFFECTED SPARK PLUGS. THE 2ND TIME THIS PROBLEM OCCURRED IN APR 2018 WHILE DRIVING WITH 112,805 MILES (MIL LIGHT ON, ROUGH IDLE, VIBRATES EXCESSIVELY WHILE DRIVING), THE HONDA DEALERSHIP CHARGED ME A FEE IN EXCESS OF $619 TO REPLACE FOUL PLUGS AND V TEC SWITCHES. THE 3RD TIME THIS ISSUE OCCURRED WHILE DRIVING ON AUG 2018 WITH 112,805 (MIL LIGHT ON, VEHICLE VIBRATES EXCESSIVELY WHILE DRIVING, LOSS OF POWER AND STUMBLE), THE HONDA DEALERSHIP IS CHARGING ME OVER $1100 TO REPLACE PISTON RINGS AND AFFECTED FOUL PLUGS. THIS IS A SAFETY ISSUE WHEN THE ENGINE IS LOSING POWER AND VIBRATES EXCESSIVELY WHILE DRIVING. THE SERVICE BULLETIN AND THE EXTENDED WARRANTY DOES NOT RESOLVE THE PROBLEM COMPLETELY AND LEAVE THE CUSTOMERS WITH A LARGE COST TO REPAIR FOR SOMETHING THAT SHOULD BE RESOLVED. A SAFETY RECALL IS STRONGLY RECOMMENDED FOR THE AFFECTED VEHICLES WITH 3.5L V6 ENGINES. MANY CUSTOMERS ARE AT RISK WHILE DRIVING THEIR VEHICLES WITH LOSS OF POWER, STUMBLES, VIBRATES EXCESSIVELY, AS WELL AS MANY ANGRY CUSTOMERS ARE DEMANDING ACTION TO RESOLVE THIS ISSUE COMPLETELY.

ENGINE IS BURNING EXCESSIVE AMOUNTS OF OIL RESULTING IN A P3497 OBD II FAULT CODE. LOW OIL PRESSURE LIGHT DOES NOT TURN ON, EVEN THOUGH THE ENGINE BURNED OVER 2 QUARTS OF OIL. BECAME AWARE OF ISSUE WHEN CHECK ENGINE LIGHT TURNED ON. ADDED 2 QUARTS OF OIL, THEN OBTAINED AN OIL CHANGE THE NEXT DAY. THIS HAS HAPPENED MULTIPLE TIMES. THERE IS A VERY HIGH RISK OF ENGINE SEIZING. HONDA HAS NOT ISSUED A RECALL. HONDA DID ISSUE A SERVICE BULLETIN 11-033 TO REPROGRAM THE COMPUTER AT A COST OF $125. I ONLY BECAME AWARE OF THE SERVICE BULLETIN AFTER SEARCHING THE INTERNET...NO NOTIFICATION FROM HONDA.

VARIABLE CYLINDER MANAGEMENT SWITCHES ON AND OFF AND CAUSES EXCESSIVE OIL CONSUMPTION. OIL LIGHT COMES ON AND CODES P3400 AND P3497 SHOW ON THE READER.

IN FALL 2016, THE DEALERSHIP ADDRESSED A MISFIRE ENGINE READING ON MY VAN. I HAD TAKEN IT IN AT LEAST TWO OTHER TIMES BECAUSE OF SLUGGISH ACCELERATION OR VEHICLE DYING WHILE AT A STOP. IN SPRING 2017, THE VAN BECAME DISABLED AT AN INTERSECTION AND IT WAS FOUND THAT THE CAUSE WAS THE SAME MISFIRE CODE. ACCORDING TO HONDA'S NHTSA ID NUMBER: 10099308 MANUFACTURER COMMUNICATION NUMBER: WE - A13-080, THIS REPAIR WOULD HAVE BEEN COVERED. BUT BECAUSE OF THIS EXTENDED WARRANTY'S 8YR FROM DATE OF PURCHASE TIMEFRAME, HONDA CORP. DENIED MY REPAIRS BECAUSE IT WAS THREE MONTHS OUT OF THE 8YR EXTENDED WARRANTY. I COMMUNICATED WITH HONDA BACK AND FORTH URGING THEM TO FIX THE VAN ESPECIALLY SINCE THE REPAIR HAD BEEN ADDRESS BEFORE AND IT WAS THREE MONTHS OUT OF THEIR CLASS ACTION AGREEMENT. ULTIMATELY, THEY DENIED COVERAGE OF ANY REPAIRS.

HONDA ODYSSEY OIL CONSUMPTION-I HAVE A 2009 ODYSSEY THAT CONSUMES OIL. ROUGHLY, EVERY 1,000 MILES, I AM ADDING 1 TO 2 QUARTS OF OIL EVERY 3 TO 4 WEEKS. NO SPOTS ON THE GROUND. ENGINE IS CONSUMING OIL. HAVE READ THAT THIS IS A KNOWN PROBLEM WITH HONDA.

EXCESS OIL USEAGE, FOULED PLUGS. REPAIRS OFFERED ARE ONLY A TEMPORARY FIX, ACCORDING TO MY MECHANIC.

LOSING A QUART OF OIL EVERY 3 TO 4 WEEKS. NO SPOTS ON THE GROUND. ENGINE IS CONSUMING OIL!

BOUGHT THIS VAN AT 83,000 MILES BEFORE IT TURNED 100,000 IT IS BURNING AT LEAST 2 QUARTS OF OIL BETWEEN REGULAR CHANGES. READ ON FORUMS THAT THIS IS A MAJOR ISSUES WITH THE 3.5LITRE ENGINES

DURING DRIVING IN THE CITY OR ON THE HIGHWAY I'VE BEEN HAVING AN ENGINE MISFIRE WITH SPARK PLUG FOULING CAUSING PROBLEMS RESULTING IN A CATALYTIC CONVERTER AND O2 SENSOR REPLACEMENT. MY VAN IS STILL IN THE SHOP AND HAS TO BE TOWED TO A DEALER 46 MILES AWAY TO SEE IF THEY CAN GET IT TO STOP SPEWING OIL INTO THE COMBUSTION CHAMBER.

I JUST PURCHASED THIS VEHICLE ON APRIL 19, 2016. I HAD THE OIL CHANGED MID JUNE. MY WIFE HAD A TRIP TO FLORIDA NEAR THE END OF JUNE, SO I CHECKED THE OIL AND IT WAS FINE. AS OF TODAY I HEARD A KNOCKING SOUND AND CHECKED THE OIL. IT WAS TWO QUARTS LOW. I FILLED THE OIL AND THE KNOCKING SOUND REMAINS.

FRONT AND SIDE ENGINE MOUNTS FAILED AT LESS THAN 60,000 MILES WITH REGULAR LIGHT USE AND NO ACCIDENTS. SYMPTOMS WERE CLUNKING OF THE ENGINE WHEN SHIFTING INTO GEAR AND STARTING AND STOPPING.

ENGINE BURNS EXCESSIVE AMOUNT OIL WITHOUT ANY WARNING LIGHTS. SLOWING EATING UP THE CAMSHAFT AND VALVE ROCKER ARM. CASING MISFIRE TO THE ENGINE AND EVENTUALLY ENGINE STOPS WORKING. MINE DID NOT HAVE THE ENGINE STOP, BUT LOCAL MECHANIC VERIFIES THAT THERE IS A EXCESSIVE WEAR TO THE CAMSHAFT UNITS

IVTEC 3.5L ENGINE. TOURING MODEL. REAR ENGINE MOUNT FAILURE. ALUMINUM ENGINE MOUNT ATTACHMENT SHEARED. NO CAR DAMAGE HISTORY OR ABUSE. FAMILY CAR, DAILY DRIVING AROUND TOWN AND HIGHWAY. NOT SURE WHEN IT FAILED, BUT TOTAL MILEAGE IS 120,000 MILES. OWNED THIS CAR SINCE NEW. DEALER SAID THE PROTECTIVE BOOT HAD TORN, AND THE MOUNT NEEDED REPLACING. HONDA PART, $650, COMPLETELY UNREASONABLE. I BOUGHT A PART, AND REPLACED IT MYSELF, THAT IS WHEN I DISCOVERED THE PART HAD FAILED. THE DEALER REFUSED TO REMEDY THE SITUATION, AND SAID ENGINE MOUNTS BREAK ALL THE TIME. ENGINE MOUNTS? A PRIMARY PART OF THE ENGINE STRUCTURE? SHOULD NEVER FAIL LIKE THIS. THE PART IS SIGNIFICANTLY UNDER DESIGNED AND SHOULD BE RECALLED AND REINFORCED, MOST LIKELY REPLACE THE ALUMINUM WITH A STEEL PART. AGAIN, NOT SURE WHEN THE PART FAILED, COULD HAVE BEEN THAT WAY FROM THE FACTORY FOR ALL I KNOW. HAVE NEVER HIT ANYTHING OR BOTTOMED OUT THE CAR. UPON INSPECTION OF THE FAILED PART, IT DOES NOT APPEAR TO BE A DEFECT, OR FATIGUE FAILURE, BUT AN OVERLOAD OF THE DESIGN. I AM AN ENGINEER AND AIRCRAFT MECHANIC. I CAN GIVE YOU THE FAILED PART IF YOU DESIRE.

TL* THE CONTACT OWNS A 2009 HONDA ODYSSEY. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE SERPENTINE BELT FRACTURED AND THE ENGINE STALLED WITHOUT WARNING. THE FAILURE OCCURRED ON TWO OCCASIONS. THE VEHICLE WAS TOWED TO THE DEALER ON TWO OCCASIONS. THE TECHNICIAN DIAGNOSED ON THE SECOND OCCASION THAT THE SERPENTINE BELT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 96,852.

VAN BEGAN TO STUTTER ON ACCELERATION AND CHECK ENGINE LIGHT CAME ON. TOOK TO PERSONAL MECHANIC WHO DIAGNOSED A MIS-FIRE IN CYLINDER #2. REMOVED SPARK PLUG TO FIND IT COATED WITH OIL AND CARBON. SAYS IT APPEARS OIL IS LEAKING THROUGH THE ENGINE VALVE STEM SEALS AND COATING THE PLUG. HE REPLACED THE PLUG. HAVE SINCE TOOK IT TO LOCAL HONDA DEALERSHIP AND PERFORMED AN OIL CONSUMPTION TEST. OVER 1 QUART CONSUMED IN 1200 MILES OF DRIVING. HAVE ASKED THAT STEM SEALS BE REPLACED UNDER GOOD WILL BUT HONDA HAS DENIED REQUEST BECAUSE SERVICE HAS NOT BEEN PERFORMED AT DEALERSHIP AND THUS THEY CANNOT GUARANTEE WORKMANSHIP AND PARTS INSTALLED. VEHICLE CONTINUES TO CONSUME OIL AND AFTER CHECKING #2 CYLINDER PLUG RECENTLY, CONTINUES TO CONTAMINATE SPARK PLUGS. *TR

WHILE DRIVING ON AN INTERSTATE AT APPROXIMATELY 65-70MPH, THE CHECK ENGINE LIGHT CAME ON AND THE CAR BEGAN TO RIDE VERY ROUGH (APPROXIMATE DATE OF 6/1/2012 AT ~65,000 MILES). PULLED OFF THE HIGHWAY AND HAD THE CAR TOWED TO THE NEAREST HONDA DEALERSHIP (AS RECOMMENDED IN OWNERS' MANUAL). SERVICE AT DEALERSHIP INSPECTED THE CAR AND FOUND THE SPARK PLUGS TO BE FOULED. REPLACED SPARK PLUGS (#3 WAS ONE), AND ALL SEEMED FINE. THE SAME SCENARIO HAPPENED AGAIN ON JANUARY 31, 2013 (AT 75,126 MILES) - AGAIN WITH NO WARNING THE CHECK ENGINE LIGHT CAME ON (WHILE DRIVING) AND CAR BEGAN TO SPUTTER. HAD CAR TOWED TO NEAREST DEALERSHIP. AGAIN THE SPARK PLUGS (#3 SPECIFICALLY) WERE FOULED. REPLACED THE ALL SPARK PLUGS. FOUND OUT THAT I WAS TWO QUARTS LOW ON OIL EVENTHOUGH THE OIL HAD BEEN RECENTLY CHANGED (1/7/13 AT ~73,000 MILES) AND NO OIL WAS LEAKING FROM MY CAR (I.E. NO OIL SPOTS ON DRIVEWAY, ETC...). THE SAME SCENARIO HAPPENED AGAIN ON 5/2/2013 (AT 81,320 MILES)...CHECK ENGINE LIGHT CAME ON (WHILE DRIVING AND WITH NO WARNING), CAR STARTS TO SPUTTER. I HAVE IT TOWED TO NEAREST DEALERSHIP, AND THE SPARK PLUG (#3) ARE FOUND TO BE FOULED AGAIN. AGAIN, OIL IS TWO QUARTS LOW (OIL HAD BEEN CHANGED ON 3/21/13 AT 78,976 MILES). FIX ALL AGAIN AND CHANGE OIL TO TO AN OIL CONSUMPTION TEST. TEST FOUND THAT MY CAR IS CONSUMING AT LEAST 1 QT OF OIL PER 1000 MILES AND THAT IS CAUSING MY SPARK PLUGS TO FOUL. HONDA SAYS MY OIL CONSUMPTION IS WITHIN "NORMAL PARAMETERS" AND WILL DO NOTHING TO FIX THE PROBLEM. HONDA FEELS THAT HAVING TO ADD OIL EVERY 1000 MILES ACCPETABLE. I DISAGREE! IF I DON'T CHECK THE OIL EVERY 1000 MILES (AND ADD AT LEAST A QT), THEN I RISK DRIVING WITH NO OIL WHICH WILL CAUSE MY ENGINE TO SEIZE. ALSO, EVEN ADDING THE OIL DOESN'T RESOLVE FREQUENT SPARK PLUG DAMAGE CAUSING ENGINE BREAKDOWN. THIS CAR IS UNRELIABLE AND UNSAFE! *TR

ENGINE OIL SERVICE WAS PERFORMED BY INDEPENDENT MECHANIC AT 33,599 MILES, WHO INFORMED THAT THE ENGINE OIL LEVEL WAS LOW PRIOR TO DRAINING THE CRANK CASE. I BEGAN MONITORING ENGINE OIL QUANTITY THEREAFTER. CURRENTLY WITH 39,252 MILES ON THE VEHICLE THE ENGINE OIL CONSUMPTION RATE IS ABOUT 1 QUART PER 2,500 MILES, WHICH SEEMS EXCESSIVE FOR AN ENGINE WITH LOW MILEAGE. THIS RATE EQUATES TO CONSUMPTION OF HALF OF THE ENTIRE CRANK CASE BETWEEN ENGINE OIL CHANGE CYCLES. IF NOT MONITORED AND FILLED THE ENGINE MAY BE DAMAGED DUE TO LOW ENGINE OIL QUANTITY AND PRESSURE. A SIGNIFICANT SAFETY IMPACT IS PRESENT IF THE OWNER IS NOT AWARE OF OIL CONSUMPTION AND THE ENGINE SEIZES. THE ENGINE IS THE HONDA SOHC VCM, 6-CYLINDER (V6), GASOLINE ENGINE. *TR

ENGINE PING, DETONATION, PREIGNITION ISSUES. *TR

CHECK ENGINE LIGHT OR CHECK OIL LIGHT WARNING LIGHTS GO ON. WHEN DEALER IMMEDIATELY CHECKS OIL UPON ARRIVING AT DEALERSHIP, DIPSTICK SHOWS NO OIL. THIS HAS OCCURRED 3 TIMES SINCE 10/09. *LN

MY VEHICLE IS HONDA ODYSEE 2009 I PURCHASE THIS UNIT U=IN TRIANGLE DEALERS IN P.R. AND MY UNIT HAVE A DIFFICULT IN THE FRONT WITH THE PUNTA DE EJE Y TIENE QUE REEMPLAZARLA MY HUSBAND PAID FOR SECURITY BUMPER TO BUMPER AND HE SEVICE IS BAD I WAITING UP JANUARY AND THIS PIECE NO ARRIVE BECAUSE TRIANGLE TALK ME AND SAID AMERICAN HONDA WORKED ORDER OF NOVEMBER 2009 AND MY UNIT CONTINUE WITH DEFECT I NEED HELP BECAUSE IS VERY ICONVENIENT THAT THIS UNIT IS NEW. I CALLNG AND THIS CALL TO DEALER ALWAYS IS NEGATIVE PLEASE CHEK THIS UNIT. *TR

HONDA ODYSSEY EXL OIL CONSUMPTION-I HAVE A 2009 ODYSSEY THAT CONSUMES OIL. ROUGHLY, EVERY 1,500 MILES, I AM ADDING A QUART OF OIL. *TR

TL*THE CONTACT OWNS A 2009 HONDA ODYSSEY. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE BOLTS FOR THE ENGINE DISINTEGRATED. THE FRONT OF THE ENGINE WAS REPLACED. THE MANUFACTURER WOULD NOT ASSIST. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 3,700.