2018 Ford Fusion Engine Problems

Your engine shut down suddenly while driving on the freeway, causing loss of power steering and a dangerous situation for other vehicles. The check engine light appeared, and diagnostic codes indicated misfires in cylinder 1 and general engine misfires. Your Ford dealer determined that the head gasket failed, allowing coolant to leak into cylinder 1, which caused the rough running, white smoke from the exhaust, and engine shutdown. Fixing this requires replacing the entire engine block with a revised version.

Your engine block has developed a crack that's allowing coolant to leak into cylinder 3, which your dealer confirmed. Your check engine light came on around March 5th, followed by overheating warnings starting March 12th. A cracked engine block can potentially lead to engine failure while driving, which could cause an accident or engine fire. Repair will require engine block replacement or professional engine repair.

Your car is mixing antifreeze with engine oil, causing it to overheat and produce white smoke from the exhaust. Three mechanics have indicated you need a new turbocharger and head gasket replacement, which is a major repair costing over $4,000. This type of failure (coolant leaking into the oil) typically requires removing the cylinder head to inspect and replace the failed head gasket, and possibly replacing the turbocharger if it's been damaged by the contaminated oil.

Your car has a known defect where coolant is leaking into the engine's short block, which can cause the engine to overheat without warning and shut off while driving. This issue has required over $1,000 in repairs and created a dangerous situation on the highway. The fix will likely involve replacing or repairing the short block and sealing the coolant leak.

Your car started rumbling and triggering the check engine light. A mechanic discovered coolant was leaking onto your spark plugs and into the cylinder, causing the engine to misfire. Ford has identified this as a known issue (CSP 21N12) but says they can't help because they closed the service program in November 2022. The mechanic indicated the vehicle is unsafe to drive. Fixing this will likely require replacing the spark plugs and diagnosing and sealing the source of the coolant leak.

Your 2018 Ford Fusion is losing coolant internally, which is causing the engine to misfire, run rough, and produce white smoke from the exhaust. This coolant leak can lead to engine failure and loss of power while driving, creating a safety risk. The problem appears to be a design defect in Ford EcoBoost engines rather than normal wear. Fixing this issue requires replacing the entire engine.

Your car started shaking severely and wouldn't accelerate past 35 MPH, with the check engine light flashing. The dealer found coolant had leaked into the engine cylinders, which typically requires replacing the entire engine. This issue is related to Ford's Customer Satisfaction Program 21N12, and Ford said they would issue a report about it.

Your 2018 Fusion started running rough with jerking and shaking while driving, triggering transmission and coolant temperature warning lights along with an "Engine Overheating - Reduced Power" message. The vehicle went into limp mode and had to be towed. An independent mechanic found coolant leaking into the engine, a blown head gasket, and a cracked engine block, indicating the engine needs to be replaced. This serious issue will require a complete engine replacement or a major engine rebuild.

After your 60,000-mile service, your check engine light came on with a cylinder 2 misfire code. The dealership found that pressure applied during the service caused coolant to leak into your engine, requiring a complete engine replacement. You had to pay $100 out-of-pocket with your extended warranty, while other owners without extended coverage faced the full replacement cost. The repair may involve removing the old engine, inspecting cooling system components, and installing a replacement engine with updated seals or gaskets to prevent similar coolant leaks.

Your engine is leaking coolant, and coolant is getting into the engine block itself. This can cause overheating and potential engine damage if not addressed. A mechanic will need to inspect the cooling system to find the leak source and may need to flush the system or repair/replace damaged components like hoses, gaskets, or the water pump.

Your 2018 Ford Fusion is experiencing coolant leaking into places it shouldn't be, likely due to a seal or gasket failure in the engine's cooling system. This can cause overheating, poor engine performance, and potential engine damage if not addressed. The repair will likely involve inspecting the cooling system components and replacing the faulty seal or gasket.

The contact owns a 2018 Ford Fusion. The contact stated that upon starting the vehicle, there was an abnormal rattling sound coming from the engine with white smoke coming from the exhaust system, with the check engine warning light illuminated. Additionally, the message “Service Vehicle Soon” was displayed. The vehicle was taken to a local dealer, where it was diagnosed, and the contact was informed that the engine was faulty due to coolant intrusion. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 84,112.

Coolant is leaking into the cylinders and causing overheating and no start.

I would like to respectfully request that my 2018 Ford Fusion, with the 1.5L EcoBoost engine, be considered for inclusion in the customer satisfaction programs related to the engine issues I'm experiencing. Despite my vehicle not being initially listed, the problems I've encountered, including the diagnostic trouble code P0302 and the coolant leak into cylinder #2, suggest that it may be suffering from a similar defect or design flaw that the program aims to address. Given the safety risks associated with the current condition of my vehicle, I believe it would be fair and reasonable to include it in the program and provide the necessary repairs or replacements to ensure the vehicle is safe to operate. I would appreciate your assistance in facilitating this process and exploring options for resolving this issue in a manner consistent with the treatment of similar vehicles.

The contact owns a 2018 Ford Fusion. The contact stated that after the engine was replaced, there was an abnormally loud banging sound coming from the engine compartment. The vehicle was taken back to the local dealer, who diagnosed the vehicle with a cracked engine flex plate. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 59,851.

The contact owns a 2018 Ford Fusion. The contact stated that while driving out of the driveway at 5 MPH, the engine light illuminated. The contact stated that the vehicle was difficult to start. The contact stated that the failure was like Customer Satisfaction Program: 21N12. The vehicle was taken to the local dealer for an oil change, and unknown engine repairs were completed. The vehicle was repaired, but the failure recurred. The vehicle was taken back to the local dealer, and it was determined that the engine needed to be replaced. The vehicle was not repaired. The dealer referred the contact to the manufacturer for assistance. The manufacturer was contacted and the referred the contact to the NHTSA Hotline. The manufacturer declined financial assistance, and stated that the issue would be escalated to the negative feedback department. The failure mileage was approximately 69,000.

My Vehicle was found to have a coolant intrusion. There is a know defect on these vehicles (1.5 / 2L) Ford engine. There was a hairline crack in 2 of the cylinders, which causes coolant to leak thoroughout the engine. My safety was put at risk as this issue causes the vehicles engine to overheat at an unsafe rate. 2 separate dealers found this issue CBA and Autonation Ford. Fidelity Warranty Services inspected the vehicle to see what would be covered. they appeared about 2 weeks prior but would disappear. It finally came back but was extremely repetitive

Engine light came on got it diagnosed said it was misfiring in cylinder 2. spark plugs and coil needed to be changed. Changed all spark plugs and coil and the engine light is still on and saying the same thing. Doesn’t crank right. Coolant going into engine. My vehicle only has 32,000 miles. Seems to be a know problem but ford will not do anything. Saying I need a new motor.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle briefly began to shake violently before returning to normal functionality. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that coolant intrusion into various cylinders had resulted in damages to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 130,000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at various speeds, there was white smoke coming from the rear exhaust. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed with coolant intrusion into cylinder #3, low coolant, and an overheated engine. The vehicle was not repaired due to the cost. The contact related the failure to TSB: 19-2208. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 76,000.

The contact owns a 2018 Ford Fusion. The contact stated that the check engine warning light was displayed on the instrument panel. The vehicle was taken to an independent mechanic, where a code reader determined that there was a misfire in cylinders #1 and #3. The vehicle was taken to a dealer, where the engine misfires were confirmed, and the engine's long block needed to be replaced. Upon investigation, the contact discovered Technical Service Bulletin: 22-2229; however, the vehicle was not covered under the TSB. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline to file a complaint. The failure mileage was 88,300.

Coolant intrusion, coolant and oil is mixing causing my car to run hot. Engine light keeps coming on, repairs to multiple pumps replaced, water pump replaced, spark plugs replaced, radiator replaced, thermostat replaced. Ford dealership tried replacing all the above vehicle is still running hot. Now claiming I need a new engine.

Engine failure due to coolant leaking into cylinders. This is a known issue. Also Ford has issued a bulletin on this. but no recall yet! I still own 10k on my car and now a blown engine.

The contact owns a 2018 Ford Fusion. The contact stated that the low coolant warning light had illuminated prematurely. Upon inspecting the vehicle, the contact was unable to find a coolant leak. Additionally, the contact stated that the vehicle overheated while driving, which required the contact to pull over temporarily and to resume driving after the vehicle had cooled down. The vehicle was taken to a certified mechanic, where it was diagnosed that there was coolant intrusion into the engine, which caused the engine to slowly fail. The vehicle was not repaired. The dealer was notified of the failure. The contact related the failure to an unknown recall. The manufacturer was informed of the failure and confirmed that the VIN was not included in the recall. The manufacturer referred the contact to the NHTSA Hotline to file a safety complaint. The failure mileage was approximately 150,000.

The contact owns a 2018 Ford Fusion. The contact stated that upon starting the vehicle, the vehicle started shuddering. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that there was coolant leaking into the cylinder. The mechanic informed the contact that the engine needed to be replaced. The contact called the local dealer for parts; however, the vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that the VIN was not under recall for the failure. The failure mileage was approximately 91,000.

Coolant intrusion into engine cylinder #2 causing misfire and low coolant levels and overheating and stalling. See Ford TSB 22-2229

The engine cooling system and engine block failed due to coolant intrusion into the engine cylinders. This issue has been diagnosed by an independent mechanic and is available for inspection upon request. Yes, the problem has been confirmed by an independent service center, which diagnosed coolant intrusion into the engine block, a known issue on this engine. The shop recommended full engine replacement and stated this is a common failure in this vehicle. Not yet by the manufacturer, police, or insurance. The issue has only been inspected by a certified independent mechanic. Yes, a check engine light appeared along with a coolant temperature warning message. The vehicle also began to idle roughly, produce heavy exhaust, and consume coolant. These symptoms began appearing shortly before diagnosis in June 2025. I own a 2018 Ford Fusion with a 2.0L EcoBoost engine. The vehicle recently began experiencing coolant loss, heavy exhaust, and check engine alerts. A certified mechanic confirmed that coolant has intruded into the engine block, causing internal misfires and risk of major engine failure. I was told this is a common and well-documented issue with this engine design, yet there has been no official recall from Ford despite similar problems affecting other models (referenced in Ford TSB 19-2208). The mechanic has recommended a full engine replacement with an estimated cost of $13,000. This is a serious safety concern, as the engine can overheat, stall, or seize while driving.

2018 fusion AWD Titanium, less than 70,000 miles, no warning, no reason. Driving 70mph on interstate when low coolant light comes on, check engine light comes on, car starts losing power and running rough, finally full stall in middle of freeway with catastrophic engine failure due to coolant leak and faulty design. Car was not low on any fluids as they were checked everyday before it was driven. This could have gotten me and my children killed and quite frankly I dont know how it didn't. I bought this car with 44k miles on it. Drove it less than 30k miles and had catastrophic engine failure. This was AFTER I had it in the shop several times for crank shaft position sensor, wouldn't start, and several other problems. The car was taken care of and in immaculate condition. Ford knew these engines would fail prematurely and continued to manufacture them and sell them.

The contact owns a 2018 Ford Fusion. The contact stated while the vehicle was parked, the vehicle shuddered. The contact stated that the check engine warning light was illuminated, and the message "Coolant Overheating" was displayed on the instrument panel. The failure had occurred on several occasions. The vehicle was taken to a dealer where it was diagnosed and determined that there was coolant intrusion into the cylinders, and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 90,000.

Vehicle has a loss of coolant but no visible leaks think may be due to a engine leak.

The contact owns a 2018 Ford Fusion. The contact stated that while driving 5 MPH, the contact heard a sound like running water coming from the engine. The contact stated that the check engine warning light was illuminated. An independent mechanic was contacted. The vehicle was taken to the independent mechanic, where it was diagnosed that there was coolant leaking into the engine, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The contact related to the failure of the Customer Satisfaction Program: 19B37 (Engine - Powertrain Control Module Reprogramming). The contact was transferred to the NHTSA Hotline to report the failure. The approximate failure mileage was 102,000.

The contact owns a 2018 Ford Fusion. The contact stated that while his wife was driving at an undisclosed speed, there was an abnormal sound coming from the fuel tank. The check engine warning light was illuminated. The vehicle was taken to the dealer and was diagnosed with a coolant sensor failure. The coolant sensor was replaced; however, the failure persisted. The vehicle was taken to an independent mechanic who replaced the coolant sensor. The contact stated that recently, the failure had recurred. The vehicle was taken to a different independent mechanic, who diagnosed the vehicle and determined that the engine block was cracked and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The contact related to the failure to the Customer Satisfaction Program: 21N12; however, the vehicle was not included. The failure mileage was approximately 115,000.

The contact owns a 2018 Ford Fusion. The contact stated while driving approximately 45 MPH, the message "Engine Overheating" was displayed on the instrument panel. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that there was internal coolant intrusion into the cylinders, and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 86,000.

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, the engine overheated and the check engine warning light illuminated. In addition, the contact noticed white smoke coming from the exhaust, and the engine was running abnormally rough. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion in cylinder #1, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 115,000.

My vehicle has had the check engine light come on intermittently. I took a look under the hood to see if I could spot any issues. The only issue seen was the coolant level was low. After refilling the coolant and a short time driving, perhaps 50-60 miles, the light went out. Then the light came back on a couple days later. Without making any changes the light went out a couple days later. It has done this several times and I thought it may be a faulty sensor or something. I have recently taken it to the dealership for a tune-up, emissions test, multipoint inspection and a transmission flush. I informed the service person that the check engine light will come on and go out and the only thing I have done to the vehicle was add coolant. He suggested the complimentary diagnostic to further identify the issue. During the diagnostic process the auto tech discovered that the coolant has been leaking into the number 2 cylinder. This is the reason for both the fluid loss and the check engine light. From my understanding this is a known issue with my vehicles engine type and has been for some time now. The only fix is to replace the engine. My overall issue is that the safety light (CEL) will say that there is an issue and then it goes away signifying the issue is resolved. The potential hazards of this could possibly lead to an individual unknowingly putting themselves and others at risk with an engine that is prepped for failure. An engine that could overheat, catch fire, throw a rod, or simply lose power in a very dangerous location. For example the freeway, a bridge with heavy traffic, or on train tracks…etc. I believe the risk of failure and potential to lose a life should be considered heavily against the cost of a recall. I don’t believe during the buying process it has ever been disclosed that this specific engine is prone to this problem. I know I would not have made my purchase knowing the engine would need to be replaced within the first 10 years of ownership.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the message “Low Engine Oil Pressure” was displayed. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion into the cylinders. The contact was informed that the engine block needed to be replaced. The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion); however, the vehicle was not covered. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 54,000.

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, the engine overheated with the check engine warning light illuminated. The contact stated that the message that the engine was overheating was illuminated. The vehicle was restarted after the contact added coolant to the reservoir. The contact stated that after adding coolant to the reservoir, the failure recurred. The vehicle was taken to an independent mechanic, where it was diagnosed that coolant had leaked into the cylinders, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired, and the contact was referred to the dealer for further assistance. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was 155,000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle lost automotive power. The check coolant and engine warning lights were illuminated. The vehicle was inspected by a local independent mechanic who diagnosed a misfire coming from the engine. The vehicle was not repaired. The vehicle was later towed to a local dealer, where it was diagnosed with a coolant intrusion in cylinders #1 and #2. The vehicle was not repaired. Upon further investigation, the contact related the failure to Customer Satisfaction Program: 21N12, 22-2134, and 19b37; however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 98,207.

The contact owns a 2018 Ford Fusion. The contact stated while driving at 35 MPH, the check engine light illuminated. The contact stated that the failure was related to Customer Satisfaction Program: 21N12. The vehicle was taken to an independent mechanic who determined that there was a coolant intrusion into the engine and the long block needed to be replaced.The local dealer was contacted, who confirmed that there was no recall on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and the contact was referred to the NHTSA Hotline. The failure mileage was approximately 95,308.

We have a 2018 Ford Fusion EcoBoost. The engine started to run hot, we made an appointment to bring to dealer. Morning of the appointment car would not start. We had it towed to dealer. After several hours at the dealership they called to tell us the engine needed to be replaced, quote was $14,000. The issue they explained was coolant in the engine that corroded the engine and all parts. Not salveable, needed to be replaced. We have excellent service records on our car, always keep up with routine maintenance and have owned at least 10 Fords various makes and models. Never had an issue.

Engine throws misfire code on cylinder accompanied by loss of coolant with no visible leaks. Coolant intrusion into the cylinder has begun due to Ford’s engine block design flaw.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the engine overheated with the check engine warning light illuminated. The vehicle was able to restart. The vehicle was taken to an independent mechanic where it was diagnosed and determined that there was coolant intrusion into the engine, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not diagnosed or repaired. The dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at various speeds, a warning light indicating that the engine was overheating was illuminated. The contact added coolant to the vehicle; however, the failure persisted. The contact stated that the vehicle was experiencing an excessive coolant consumption. The vehicle was taken to Advance Auto, where it was diagnosed with a misfire in cylinder #3. The vehicle was taken to the dealer and was diagnosed with coolant intrusion in cylinder #3. The dealer determined that the short block needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 91,000.

While driving about 60 miles per hour the vehicle started to buck and loose speed. The check engine light came on and I pulled over. The vehicle was taken to the dealership where I was told that I have a coolant leak. The leak caused a break in cylinder 2 and the engine would have to be replaced.

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, there was white smoke coming from the exhaust pipe. The check engine warning light was illuminated. The vehicle was taken back to the residence. A dealer was contacted and informed the contact that the failure was a known issue and that the engine needed to be replaced; however, there was no recall on the VIN for the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 120,000.

The contact owns a 2018 Ford Fusion. The contact stated while driving 15 MPH, the check engine warning light illuminated, and the vehicle started hesitating. The contact attempted to restart the vehicle and the vehicle failed to respond as needed. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion in cylinder #2, and the engine needed to be replaced. The dealer was contacted. The vehicle was not repaired. The contact related the failure to TSB: 20-2100 (Coolant in Cylinders, White Exhaust Smoke, And/or Illuminated MIL); however, the VIN was not included in the service bulletin. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the TSB. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 150,000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at 35 MPH, the temperature gauge began to indicate that the vehicle was overheating, prompting the contact to discontinue driving the vehicle. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that coolant intrusion into various cylinders had resulted in damage to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program 21N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 103,500.

The contact owns a 2018 Ford Fusion. The contact stated that the engine was misfiring with white smoke coming from the exhaust pipe. The size of white smoke coming from the exhaust pipe had increased over time. The “WRENCH” warning light remained illuminated. The check engine warning light was illuminated intermittently. The vehicle was hesitating while attempting to start. The vehicle was taken to a certified mechanic who diagnosed that the engine block had coolant intrusion in two cylinders and was causing the misfire. The contact replaced the coils and spark plugs; however, the failure persisted. The contact became aware of NHTSA ID Number: 10213732 (Engine and Engine Cooling) which was linked to the failure. The dealer was contacted and confirmed that the vehicle was not included due to the mileage. The manufacturer was made aware of the failure and confirmed that the vehicle was not covered under the NHTSA ID Number. The manufacturer referred the contact to the NHTSA Hotline to file a safety complaint. The failure mileage was 119,000.

The contact owns a 2018 Ford Fusion. The contact stated that while starting the vehicle, the vehicle shuddered with white smoke coming from the exhaust pipe. The check engine warning light was illuminated. The failure had occurred on several occasions. The vehicle was taken to an independent mechanic where it was diagnosed with coolant leak into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and filed a complaint. The vehicle remained at residence unrepaired. The approximate failure mileage was 140,000.

Engine overheated multiple times during high speed/high traffic situations due to a design flaw within the engine. Ford was aware of these issues in this engine for years and still knowingly sold them to American consumers, myself included. This is wrong and erodes the trust myself and others have in the American auto industry.

The contact's son owns a 2018 Ford Fusion. The contact's son stated while driving at an undisclosed speed, the vehicle shuddered and white smoke emitted from the exhaust pipe. The check engine warning light was illuminated. The failure occurred on several different occasions and the coolant level was abnormally low. The vehicle was not taken to a dealer. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 90,000.

The car was taken to the repair shop due to reduced speed and shaking. The repair shop mentioned that a bulletin for the car indicated that coolant could leak into the engine. They reported that the coolant had indeed leaked onto the engine, causing the gasket to blow. The dealer was contacted and was informed that it was an extended warranty of up to 84000/ 7 years. so I was referred to NHTSA Case S3H0j5

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, there was a knocking sound coming from the engine. There was no warning light illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was taken to the dealer and was diagnosed with coolant intrusion into the cylinder, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 115,000.

During traffic on the highway, my car had a slight rumble to it but no warning lights were on and there were no weird sounds or smells coming from my car. After I cleared the traffic, the rumbling dissipated but as I accelerated my check engine light turned on and began flashing. I immediately exited and pulled over. After popping my hood, it smelled of burnt oil and the entire engine bay looked like it had been misted with oil. Auto shop scanned the engine light and said I had a cylinder 2 misfire. Another auto shop had said my engine was out of commission and I’d need a new one.

The contact owns a 2018 Ford Fusion. The contact stated while driving 40 MPH, the vehicle started shuddering significantly and the engine overheated. The check engine warning light was illuminated. The contact continued driving at 20 MPH. The vehicle was driven to the residence. The vehicle was then taken to the dealer, where it was diagnosed and determined that there was a coolant intrusion in the engine. The dealer determined that the engine needed to be replaced and related the failure to Ford Campaign Number: 21N12 and TSB Number: 22-2134. The vehicle was not repaired. The manufacturer was notified of the failure but denied assistance in covering the cost of the repair. The failure mileage was approximately 110,000.

On [XXX], My car began attempting to overheat. This caused me to stop, and park the car until it cooled down, multiple times. (Unsafe) All of my fluids have been filled and checked occasionally prior to this. After multiple roadside trips, I presented my car to AutoNation FORD which is located on Philips Highway in Jacksonville, Florida. An inspection was performed on my vehicle over the weekend which proved my car in fact has a coolant intrusion which is the Latest Recall for the Ford Model. The dealership informed me that my car does not qualify under the recall due to the mileage of the vehicle which is currently 130k. This seems so unfair because I did not do anything wrong that led to this. I am unable to drive my car a mile or 2 without it trying to overheat. This is a risk and I do not feel safe operating this vehicle. It was also very displeasing hearing that operating the unsafe vehicle is my only other alternative besides coming out of pocket with 14k. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle experienced rough idling. The check engine warning light was illuminated. The vehicle was taken to the dealer, where the spark plugs were replaced, but the failure persisted. The vehicle was taken back to the dealer, and the contact was informed that the fuel injector in cylinder #3 needed to be replaced. The vehicle was then taken to Terrebonne Ford (339 St Charles St, Houma, LA 70360), where it was determined that there was coolant intrusion into the cylinder block and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 80,000.

The contact owns a 2018 Ford Fusion. While the contact's daughter was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the check engine warning light and several other unknown warning lights were illuminated. The vehicle was taken to several independent mechanics; however, the vehicle was not diagnosed. The vehicle was not repaired. The vehicle was towed to the dealer where it was diagnosed with a coolant leak in the engine and engine failure. The contact was informed that the engine and the cylinders needed to be replaced. The vehicle was repaired. The contact was informed of an Extended Warranty Program; however, the contact was informed that the mileage had been exceeded by 9,000 miles. The contact was informed that the repair was not covered under the extended warranty. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 93,451.

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle was driving rough. In addition, the contact noticed that the engine was consuming an excessive amount of coolant. The failure progressed, and the engine started overheating. The vehicle was towed to the dealer where it was diagnosed with a cracked engine and coolant intrusion. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and provided no assistance. The contact referenced Technical Service Bulletin: 22-2134; however, the contact was informed that the repair was not covered under the program. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 27,800.

The contact owns a 2018 Ford Fusion. The contact stated while driving 45 MPH, the message "Coolant Temperature Overtemperature" was displayed, causing the vehicle to decelerate. The contact stated that another message advising that the engine power was reduced, and to pull to the side of the road was displayed. The contact pulled to the side of the road and checked the coolant level. The contact noticed that the coolant was overheating and leaking. The contact added coolant to the vehicle. The contact stated that the failure recurred intermittently. Additionally, the contact stated that the engine was misfiring on cold starts. A message advising to service the engine soon was displayed. The vehicle was taken to the dealer, where it was diagnosed that there was coolant intrusion in the engine, and the dealer determined that the short block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under Ford Campaign Number: 21N12 due to the mileage. The failure mileage was approximately 120,000.

The contact owns a 2018 Ford Fusion. The contact stated while driving approximately 30 MPH, the "Engine Overheated Idle Engine" message was displayed on the instrumental panel. The check engine warning light was illuminated. The vehicle was taken to a dealer to be diagnosed and it was determined that the engine needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the dealer where it was diagnosed, and the contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 102,405.

The contact owns a 2018 Ford Fusion. The contact stated while driving at various speeds, the vehicle shuddered and white smoke came out of the exhaust pipe; there was an abnormal sound coming from the engine compartment. The "Engine Coolant Overtemperature" message was displayed on the instrument panel and the check engine warning light was illuminated. The failure occurred on several different occasions. The vehicle was taken to a dealer where it was diagnosed that there was a coolant leak intrusion into the cylinder and that the engine needed to be replaced. The dealer made the contact aware of Technical Service Bulletin Number: 19-2346. The vehicle was not repaired. The manufacturer was notified of the failure and confirmed that there was no recall associated with the failure; the manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 111,700.

The contact owns a 2018 Ford Fusion. The contact stated while driving at 35 MPH, the check engine warning light illuminated. The vehicle was able to restart on the third attempt however the failure recurred. The vehicle was driven to the dealer where it was diagnosed that the engine and the cylinder heads needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was 13,000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, there was an engine misfire with the check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the spark plugs had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the issue and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 122,000.

The contact owns a 2018 Ford Fusion. The contact stated while driving 50 MPH, the check engine warning light illuminated, and the vehicle started sputtering. The vehicle was taken to an independent mechanic, where it was diagnosed with coolant intrusion in the engine. The vehicle was then taken to the dealer, where it was diagnosed with coolant intrusion in the engine. The dealer determined that the short block needed to be replaced. The dealer informed the contact that the failure was related to Ford Campaign Number: 21N12; however, the vehicle was not covered due to the mileage. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that a notice for Ford Campaign Number: 21N12 was previously sent; however, the contact had not received the notice. The failure mileage was approximately 120,000.

The contact owns a 2018 Ford Fusion. The contact stated while attempting to start the vehicle, the vehicle took approximately three minutes to start. The vehicle started after several attempts. The contact stated while driving at approximately 35 MPH, the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the vehicle needed a tune up and an oil change. The vehicle was repaired but the power train warning light illuminated. The manufacturer was notified of the failure. The failure mileage was approximately 96,000.

Driving down the interstate and lost power due to rough running engine. I barely made it to the emergency lane before someone hit me. Coolant intrusion in the cylinders cause the engine malfunction. Ford is fully aware of this problem and refuses to help.

The car overheated and threw the code p1299, pulled over and there was no visual coolant leak. Put coolant in it and drove it to the garage a few days later, they told me coolant has leaked into the block and that I will need a whole new cylinder block and head gasket. Looked up recalls for my type of car and it showed 2013-2018 ford fusions have recalls about my problem and showed the symptoms and my car has every symptom of that recall but yet there is no active recall for my car.

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle was smoking with the engine overheating. The wrench symbol was displayed and was flashing on and off. The engine warning light was illuminated and flashing on and off. The contact stated that the failure was related to Customer Satisfaction Program: 21N12. The vehicle was taken to the local dealer, where it was diagnosed that the thermostat housing was leaking. The vehicle was not repaired. The manufacturer was contacted, and informed the contact that there was no recall coverage for the failure. The contact was referred to the local dealer for assistance. The failure mileage was approximately 76,422.

Engine has misfire in cylinder one from coolant intrusion. TSB 22-2229. Engine coolant leak can cause many problems for the engine and other components to fail and even break. Dealership confirmed, they’re are other fusion models and same engines with the same problem in the 2.0l. There were no previous lights on the dashboard the car is maintained well.

The contact owns a 2018 Ford Fusion. The contact stated that the vehicle had experienced rough starts and there was a slushing liquid sound coming from inside the dashboard. Additionally, while operating the vehicle the check engine warning light remained illuminated and the vehicle stalled. The vehicle was taken to the local dealer who diagnosed that the engine block was cracked and causing coolant to leak into the engine. The contact was advised that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 120,000.

2018 fusion ecoboost with no lights or warnings would not start. Took to ford to repair, took them several weeks and several of the same part to fix crankshaft position sensor. Was given a clean bill of health on car. Everything was I'm good condition they said after I paid the 1500.00$ repair bill. Less than 1 week later the car dies while on highway going 65 mph without warning. No lights, nothing. Just sputtered and died. Done all I could to get out of the way so I would not be hit on highway. Catastrophic engine failure resulting in engine locking up had occurred. This car has been taken care of, less than 75k miles on it and the engine is garbage. I lost my job, almost lost my life, lost my home, over half of my possessions all as a direct result of this faulty car that was designed to fail. Ford knows about this engine problem, they continue to sell these cars and refuse to pay for repairs or recall them.

The contact owns a 2018 Ford Fusion. The contact stated that while driving 45-50 MPH, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the head gasket was blown. The dealer determined that the engine block needed to be replaced. The vehicle was then taken to an independent mechanic, where the engine was replaced. The vehicle was repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 97,000.

It was losing calling but no coolant leak, rough idle/driving and blows white smoke out of the exhaust and threw the code p1299 so I took it to a garage and they told me it was the cylinder head gasket but my car has no recalls on it and I looked up my problem and it said 2013-2018 ford fusions with the 1.5l built before June 2019 and mine was built in feb 2018 and I haven’t received any mail about a recall.

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, there was an engine misfire, and the low coolant level warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion into cylinder #2 and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the repair was not covered under Customer Satisfaction Program: 21N12. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 56,000.

Coolant leaked into engine cylinder #4, requiring a new engine.

Summary: I purchased a 2018 Ford Fusion from Reliable Chevrolet on [XXX]. After driving the vehicle a little less than 15,174 miles the check engine light came on. The Ford dealership concluded there was a coolant leak into cylinder 2 and suggested a long block replacement. After further investigation it appears this vehicle falls under NHTSA CSP 21N12, 19B37 and TSB 22-2229. The Ford dealership and Ford Motor company refused to assist in providing financial assistance for the needed repairs. We were also not notified by Ford, Reliable Chevrolet, or the extended warranty company (purchased through Reliable Chevrolet (MPP Co)) that this vehicle is subject to multiple NHTSA CSPs or TSBs before the purchase (possible violation of Section 17.46 of TBCC and Section 17.41 of DTPA). Ford Motor Company Customer Ticket - [XXX] Auto Nation Ford (Frisco, TX) Invoice Date July 24, 2024 It is my opinion one or more of the parties mentioned above should be held accountable for the needed repairs as this is a documented defect that should have been disclosed before purchase or at the minimum before out extended warranty expired in March of 2024. Please let me know what other information is needed to help complete this complaint. Best Regards, [XXX] Frisco, Texas [XXX] email - [XXX] mobile - [XXX] Supplement Details: Culpable Parties Manufacture Ford Motor Company 1 American Road, Dearborn, MI 48126 PO Box 6248 Dearborn, MI 48126 Called and opened a case on 08/24/2024 Case [XXX] Seller Reliable Chevrolet 800 North Central Expressway Richardson, Texas 75080 Extended Warranty Company (provided by dealer) MPP Co., Inc P.O. Box 634, Shawnee Mission, KS 66201 Vehicle Information 2018 Ford Fusion VIN- [XXX] Manufacturer: FORD MOTOR COMPANY, MEXICO Series: SE FWDTrim: Gross Vehicle Weight Rating: Class 1: 6,000 lb or less (2,722 kg or less)Drive Type: FWD/Front-Wheel Drive Cylinders: 4Primary Fuel Type: Gasol INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Fusion. The contact stated while driving approximately 15 MPH, the vehicle stalled occasionally and returned to normal operation once the contact had turned off and restarted the vehicle. In addition, there was smoke coming from the tailpipes. The check engine warning light was illuminated. The vehicle was drivable and was driven to an independent mechanic where it was diagnosed with a coolant leak, and the mechanic suggested that the vehicle be taken to a Ford dealer. The vehicle was towed to a Ford dealer where it was confirmed that there was a coolant intrusion into the cylinder head gasket. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for further assistance. The failure mileage was approximately 135,000.

The contact owns a 2018 Ford Fusion. The contact stated while driving 45 MPH, the engine started to overheat, and there was smoke coming from underneath the hood. The message "Vehicle Temperature Overheating" was displayed. The contact pulled over to the side of the road and allowed the vehicle to cool down. The contact was able to continue driving; however, the failure recurred several times while driving. The contact pulled to the side of the road several times until arriving to the residence. The vehicle was taken to the dealer, where it was diagnosed that the PCM had failed. Additionally, the dealer diagnosed there was coolant intrusion in the engine cylinders. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to Ford Campaign Number: 21N12. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 181,000.

The contact owns a 2018 Ford Fusion. The contact stated while operating the vehicle, the message "Turn Engine Off" was displayed, and the engine temperature gauge indicated that the engine had overheated. The vehicle was taken to the local mechanic who diagnosed that the engine had failed due to coolant intrusion into the cylinders. The contact was advised that the engine short block needed to be replaced. The vehicle was not repaired. The manufacturer was contacted regarding the failure. The failure mileage was approximately 87,000.

My Vin # is: [XXX] and matches TSB 22-2322 // Customer Satisfaction Program 21N12 by all written criteria. My vehicle is exhibiting the exact symptoms as coolant leaking into cylinder bore (#3 in my situation). When I called my local Ford dealership and Ford Corporate office, they told me that my vehicle doesn't fall under that coverage, but couldn't tell me why. My make/model/year/manufacturer date/location/engine, etc. all match what is written in the TSB/CSP. If Ford states that my vehicle doesn't qualify for this program, I need an exact/specific explanation as to why my vehicle doesn't qualify for this TSB/CSP. Nobody can tell me and I keep getting the run around. This is unethical as everything written matches my vehicle and situation but I am being denied coverage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My fusion has been acting up lately. Everytime I turn on the car In the morning it sounds super rough and it shakes more than usual. I have to fill the coolant every once in a while because the car just eats the coolant up. I took it to a ford dealership to make sure there are no leaks but there weren’t. Car seems to have coolant intrusion by the amount of times I need to re fill coolant. I have attached picture of coolant always below minimum line.

I took my vehicle into a Ford dealership due to having a engine code of P0302 for engine misfire 8/3/24.Received a call from the dealership stating that I have coolant intrusion in cylinder 2 and has caused catastrophic engine failure.It has never been stated that there had been 2 previous recalls for this issue at any time while owning this vehicle.I called the Ford dealer that I recently had my oil changed at and asked if there was any notes on any issues or concerns when my oil was changed and was told no but there was a recall on the vehicle for this exact issue but it had expired.The dealership stated a new motor is needed costing $5,600 for a short block or $8,600 for a long block.I called Ford Customer Care and was told that with this being an ongoing issue to report it. I am at a loss after reading how many people have had this issue and Ford knowingly has had 2 recalls on it but people are still having to pay for a new engine because of the mileage on their vehicles at engine failure due to the boring between the cylinders causing the head gasket to fail. My car has a little over 135k miles and the previous recall stopped at 85k miles.I don't have an extended warranty and that would be the only way at this point that Ford would cover the expense.When buying a vehicle from a trusted company and then not being notified of an actual recall by Ford or even from the dealerships when being serviced if you aren't having that specific issue I don't think that is ethical or making sure their customers are safe.It puts not only my family but others at risk that have the same engine which can cause engine fires,failure while driving and money out of pocket that shouldn't have to be paid because of a known issue that currently has a pending class action lawsuit over.Ford needs to stand by their customers and reinstate this recall to include higher mileage cutoffs to make things right for all customers with the same manufacturer defect even if it takes longer to comeup

While driving car started misfiring like crazy out the blue and losing power leaving me stranded by the road in the heat. Come to find out it has coolant intrusion. I have 2018 ford fusion. Luckily it didn't catch on fire but ford is aware of this problem and continues to do nothing.

The contact owns a 2018 Ford Fusion. The contact stated whenever cold starting the vehicle, the vehicle idled rough. The contact stated that the check engine warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that coolant had leaked into the engine block and the engine needed to be replaced. The vehicle was not repaired. The contact was advised by the dealer that the vehicle was no longer under warranty coverage under recall: 21N12 - Coolant Intrusion into the Cylinder (Engine and Engine Cooling). The manufacturer was informed of the failure. The failure mileage was 101,080.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle briefly hesitated and jerked, prompting the contact to pull over to the shoulder of the roadway. After pulling over, the contact observed that the vehicle was idling rough and turned off the vehicle. Upon attempting to restart the vehicle, the vehicle initially failed to start and required a jump start. The check engine warning light was illuminated. The vehicle was taken to the dealer, who observed coolant intrusion into cylinder #3, resulting in engine damage. The contact was informed that the long block needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 102,000.

The contact owns a 2018 Ford Fusion. The contact stated that while the vehicle was parked in the driveway, upon attempting to start the vehicle, the vehicle failed to start as intended. The contact stated that when the vehicle was started and idling, there was white smoke coming from the engine compartment. The contact inspected the vehicle; however, no visible fluid leaks were noticed. The vehicle then stalled, and the check engine warning light illuminated. The vehicle was not repaired or diagnosed by an independent mechanic or local dealer. The contact related the failure to an unknown recall; however, the vehicle was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000. The VIN was not available.

Technical Service Bulletin (TSB) 1.5L EcoBoost for Ford Fusion vehicles built on or before June 10, 2019 may indicate low coolant levels, white exhaust smoke, or rough running conditions Myself and a few of my relatives and friends who have the same vehicle have experienced this and yet no recall was issued when I looked it up by vin . I have called the hotline number several times and have got ahold of no one . I have been on the phone up to an hour each time . I would like someone to contact me pertaining to this I have documentation from dealer in regards of issue. I have sent a letter to ford company pertaining to this and also have foster legal assistance to how I can proceed with getting issue fixed .

The contact owns a 2018 Ford Fusion. The contact stated that the check engine warning light illuminated while starting the vehicle, with cloud of white exhaust smoke coming from the tailpipe intermittently. The vehicle was taken to an independent mechanic where it was diagnosed that there was coolant leaking into the engine, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and it was confirmed that the VIN was not under recall for the failure. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was 73,000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, there was an alarm for the coolant temperature being elevated. The contact pulled over and turned off the air conditioner and the vehicle. The engine cooled off while driving. The vehicle was taken to the local dealer, who informed the contact that coolant was leaking into the engine and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, but there were no recalls for the failure. The contact was referred to the NHTSA Hotline. The failure mileage was approximately 120,000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle was sputtering, and the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with engine failure due to coolant intrusion into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was informed the vehicle has experienced the failure listed in Customer Satisfaction Program: 19B37 and 21N12. However, the Customer Satisfaction Programs had expired. The failure mileage was approximately 84,000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the low coolant warning light illuminated. The contact drove the vehicle to a safe location and the vehicle was towed to the dealer where it was diagnosed with engine failure due to a coolant leak. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was informed that the repair was not eligible to be covered under TSB: 22-2333. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 78,891.

Losing coolant in the engine. No apparent leaks on ground or around engine. Rough running when first started but smoothed out after a few miles. Engine overheats if close watch isn't done on the coolant reservoir. I am worried the engine may catch fire if it gets too hot. Taken to mechanic who could not repair. Codes found P 3002 & P1299.

2018 Ford Fusion 2.0L ecoboost engine coolant intrusion issue at around 76000 miles. Took to dealer today to check for needing constant coolant topoffs and rough idle and check engine light. Dealer diagnosed as coolant intrusion in cylinders and into the engine, asked for full engine replacement (long block) at $7200 + tax bill. I called Ford customer service, they said no recall or customer satisfaction program to get a discount on the repair bill. Very disappointed at Ford quality, a whole engine replacement needed at less than 80k miles on a well maintained car. Requesting NHTSA to force Ford to issue a recall and cover the repairs since its a wide spread issue.

The contact's wife owns a 2018 Ford Fusion. The contact stated that upon starting the vehicle; there was heavy white smoke coming from the exhaust pipe. The contact then stated that while driving at various speeds, the vehicle would hesitate upon depression of the accelerator pedal with the coolant and check engine warning lights illuminated. The vehicle was initially taken to an independent mechanic where a diagnostic test showed that there was coolant intrusion into one of the cylinders. The dealer was notified of the failure and the contact was informed that the vehicle was not included in a recall. The manufacturer was also notified of the failure and the contact provided the same information. The manufacturer referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 90,000.

The contact owns a 2018 Ford Fusion. The contact stated that upon starting the vehicle, the vehicle briefly vibrated before returning to normal functionality. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who determined there was a misfire in cylinder #2, requiring the spark plug to be replaced. The vehicle was not repaired. The vehicle was then taken to the dealer, who determined that coolant intrusion had damaged the engine block, requiring the engine to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 102,000.

The contact owns a 2018 Ford Fusion. The contact stated that while operating the vehicle, The check engine warning light illuminated off and on and the vehicle was driving rough. Upon inspection, the contact discovered that the engine coolant level was very low. The vehicle was taken to the local dealer who diagnosed a cylinder misfire caused by coolant intrusion in cylinder #2. The vehicle was not yet repaired. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The contact was informed that the vehicle did not qualify for the Extended Warranty coverage for the failure. The failure mileage was 50,000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at approximately 55 MPH, the check engine warning light illuminated. The vehicle was taken to a local dealer who determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 130,000.

Coolent intrusion cylinder 2 103000 miles car is undrivable sucking coolant in to cylinder within 30 minutes to an hour. paid 23,000 for a car I cannot drive. 2018 ford fusion out of warranty now for will not help or replace since no recall was placed on this vehicle. Something needs to be done there are so many others and car isn't even 7 years old.

2018 ford fusion 1.5 L coolant intrusion at 65,000 miles. Ford refuses to help us in this matter. Our vehicle was not placed under their recall list which was for 2013-2019 escapes and fusion 1.5 L ecoboost motors for design flaw causing coolant intrusion. Our car has that EXACT motor and exact problem. It has a cylinder 3 coolant intrusion.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the spark plugs. The vehicle was repaired, but the failure reoccurred. The vehicle was then taken to the dealer, who determined that coolant intrusion had damaged the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 19B37. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 76,000.

The contact owns a 2018 Ford Fusion. The contact stated the vehicle was low on coolant and failed to start. The vehicle was taken to a local independent mechanic where it was diagnosed that there was coolant intrusion into the engine. The contact stated that there was an increase of white smoke coming from the exhaust. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 125,000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the contact noticed white smoke coming from the tailpipe. Additionally, the check engine warning light was illuminated. The contact drove the vehicle to a safe location and parked the vehicle. The contact checked the oil level and confirmed that the oil level was adequate. The vehicle was taken to the dealer where it was diagnosed with a coolant leak into cylinder #3. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact was informed of an unknown recall; however, the VIN was not included in the recall. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 131,768.

The contact owns a 2018 Ford Fusion. The contact stated while driving 30 MPH, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to be restarted; however, the failure persisted. The contacted stated that the failure persisted, and the vehicle would not restart. The vehicle was taken to an independent mechanic where it was diagnosed as a malfunction with the gas cap. The contact was informed that the gas cap needed to be replaced. The dealer was not contacted. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 73,000.

My 2018 ford fusion is suffering an engine intrusion problem as a result of horrible engine design. Ford did NOT disclose or announce this very well known problem. My engine has overheated multiple times caused me to pull over on the HIGHWAY in fast moving traffic. Not only is the overheating a danger to my safety but so is sitting in a sedan on the side of the highway with tractor trailers passing me at speeds of 70mph.

The contact owns a 2018 Ford Fusion. The contact stated that while her son was driving 70 MPH, the check engine warning light illuminated. The vehicle began to run rough, and the driver veered to the side of the road. The vehicle was towed to the local Nissan dealer, where it was diagnosed that there was no coolant in cylinder #2, and the head gasket was blown. The driver was referred to the local Ford dealer. The driver called the local dealer and was informed that there was no recall or Customer Satisfaction Program coverage for the repair. The vehicle was shipped back to the contact's residence. The vehicle was towed to the local dealer where it was diagnosed that an engine replacement was needed. The vehicle was not repaired. The contact stated that the manufacturer had been contacted and the contact was referred to the NHTSA Hotline. The failure mileage was approximately 94,444.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle was shaking abnormally. The contact stated there was white and black smoke coming from the tailgate and the hood area. The accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the temperature gauge indicated that the engine was overheating. The vehicle was driven to the shoulder of the roadway. The vehicle was towed to the residence. The contact stated that a family friend who is an independent mechanic diagnosed the vehicle with engine failure. The contact was informed that the engine needed to be replaced. The manufacturer was made aware of the failure and the contact was informed that the repair would not be covered under an extended warranty. The contact was also informed that there were no available recalls associated with the VIN. The failure mileage was approximately 88,000.

When driving our 2018 Ford Fusion on vacation my wife and I were 10 hours away from home when the motor began to fail. The check engine came in and began flashing, while driving at 75 mph on [XXX] near Tifton Georgia our engine lost all power and the car began smoking profusely. The car developed a very serious misfire and was struggling to stay running. My wife was driving and had to cross 4 lanes of traffic in a vehicle lacking power and profusely smoking from under the hood reducing visibility. Two service centers have now diagnosed the car with a bad head gasket and block and informed us that the engine will need to be replaced. Ford has now informed us that our vehicle qualified for the [XXX] customer satisfaction campaign but we were never notified and now they are refusing to cover the engine due to us being 10,000 miles over their qualifications. The vehicle had issues previously with engine oil level raising as driving. When questioning the dealership they told us it was normal and there was no coolant or fuel in the oil. We have now found records that the dealership reprogrammed the power train control module according to their [XXX] campaign and cleared codes related to these coolant intrusion issues. This issue was caught and we were blatantly lied to about the coolant going into our oil. Because of this and Ford’s failure to notify us my wife and I were put into a dangerous situation traveling at a high rate of speed in a vehicle that lost majority of its power suddenly with no warning. We then put ourselves and other motorists around us at risk by having to cross 4 lanes of traffic in a cloud of white smoke in order to get ourselves to a safe place to stop. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My car is over heating, having trouble starting, shacking, and blowing white smoke out of the tailpipe. It's saying mis fire so I replaced the spark plus and it's still doing it.

P302 code. P1299. Overheating, coolant in number 2 cylinder. Head gasket failure due to engine block design flaw. Catastrophic engine failure Not covered under warranty due to mileage limitations past 84,000 on vehicle and a repair cost beyond retail value of the car.

The contact owns a 2018 Ford Fusion. The contact stated while driving 50 MPH after an oil change was performed on the vehicle, the check engine warning light illuminated, and the vehicle lost motive power an hour later. The contact was able to pull to the side of the roadway. The contact was able to restart the vehicle; however, the failure recurred while driving. The vehicle was taken to the dealer, where it was diagnosed that there was a coolant intrusion in the engine and the short block needed to be replaced. The dealer determined that the failure was related to Ford Campaign Number: 21N12. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered due to the mileage. The failure mileage was approximately 100,000.

The engine of my car is subject to a critical design flaw. Coolant intrudes into the cylinders and is consumed at an unusually high rate which may cause severe overheating and can lead to fire. Ford Technical Service bulletin 22-2229 shows that Ford is aware of this significant issue but is leaving customers to discover if their car engine is subject to the flaw. They are leaving the customer to pay for the only viable and very expensive fix, which is complete engine replacement.

The contact owns a 2018 Ford Fusion. The contact stated while his son was driving at approximately 55 MPH, the check engine and low coolant level warning lights illuminated. The contact stated that his son added coolant to the vehicle and was able to drive to the residence The vehicle was diagnosed by an independent mechanic, the next day. The independent mechanic tested the system for coolant leaks; however, no leaks were found. However, the head gasket was removed, and coolant was found in cylinder #3. The vehicle was not repaired. The vehicle was taken to the local Ford dealer for engine replacement. The manufacturer was notified of the failure and a case was opened. The contact stated that the manufacturer offered no assistance. The contact was informed that the case was closed and to call the NHTSA Hotline to file a complaint. The vehicle was at the dealer awaiting the repairs. The failure mileage was approximately 62,000.

The contact owns a 2018 Ford Fusion. The contact stated while driving 25 MPH, the vehicle stalled and lost motive power and failed to restart; however, the contact was able to pull over to the shoulder of the roadway. The vehicle was towed to a local dealer where it was diagnosed that there was coolant intrusion into the engine which caused the engine to become damaged. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12 and 19B37, but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 101,000.

The contact owns a 2018 Ford Fusion. The contact stated that while checking the coolant level routinely, the contact noticed that the coolant was significantly lower than expected. The contact stated that while the coolant level was low the vehicle was driving rough while driving at various speeds. The vehicle was taken to an independent mechanic where it was diagnosed, and it was determined that coolant was leaking into the engine. The vehicle was not repaired. The contact became aware of Ford Customer Service Satisfaction Program Number: 21N12 (Vehicles Equipped with a 1.5L GTDI Engine – Short Block Replacement After Coolant Intrusion) however, the VIN was not included in the program. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 130,000.

Coolant leak into engine

The contact owns a 2018 Ford Fusion. The contact stated that the check engine warning light was illuminated intermittently. The contact stated that she had replaced the spark plugs herself; however, the failure recurred. Additionally, the contact stated while driving 45 MPH the vehicle decelerated independently, and the vehicle failed to exceed 40 MPH while depressing the accelerator pedal. The contact also stated that while driving from a complete stop, the vehicle jerked and failed to exceed 5 MPH. The contact pulled to the side of the road. The vehicle was towed to the residence. Additionally, the contact stated that the vehicle was experiencing excessive coolant consumption, but there were no signs of a coolant leak. The coolant temperature warning light was illuminated. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The contact related the failure to Ford TSB Number: 19-2375. The failure mileage was mileage was approximately 113,000.

See attached document for complaint

The contact owns a 2018 Ford Fusion. The contact stated that while driving out of the driveway, the check engine warning light illuminated. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 85,000.

I have a 2018 Ford Fusion titanium 2.0. Upon start up thick white smoke was coming from the exhaust. Coolant level in resevoir dropping very low. Added coolant and five minutes of driving my check engine light comes on with code p0301 car ran sluggish and overheating light came on. I immediately pulled over and turned it off. Sure enough very low coolant in resevoir. No signs of leakage outside. I then took the car to a ford dealership for diagnosing. Sure enough I have coolant intrusion on number 1 cylinder. I reached out to FORD manufacturer and they will not assist with repairs/replacing the engine and all components that have been damaged due to the coolant intrustion. It will cost $9742.90 to replace all components and engine. My car only has 118013 miles on it. I am very disappointed with FORD knowing that they are aware of this coolant intrusion problem, yet do not want to fix their flaws. Enclosed is also a photo of the coolant intrusion on cylinder 1.

The contact owns a 2018 Ford Fusion. The contact stated while driving approximately 36 MPH, the vehicle failed to respond while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was driven to a local dealer to be diagnosed. The contact was informed that the engine needed to be repaired or replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 19,000.

My car started with the Ck engine light coming on, then white smoke from the exhaust randomly, then my temperature gauge randomly going up then back down, my car then losing coolant but not leaking any coolant under my car when parked. Then it started acting like it was gonna stall while at a stop or in park. I thought at first I got bad gas somewhere. These are all things I’ve never experienced since purchasing my car new in 2018. I took my car this week to the Ford dealership to get a diagnosis. They told me my car had some coolant intrusion that was a defect with my engine. They told me that Ford was replacing the engines but that my car didn’t qualify because it was over the 84,000 miles. I couldn’t believe it. So a vehicle I bought brand new( my first ever brand new vehicle) and I just paid off early in January of 2024 now needs a new engine. To say I was mad and disappointed would be an understatement. I only have my income as my husband passed away 9 years ago. I’m not old enough to collect his pension as I was only [XXX] when he passed. I also took in my 2 nieces 6 years ago when my sister passed away. I can’t believe Ford does not have to repair these vehicles. Why should mileage matter if it’s a defect on their part. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

At 100,000 miles the vehicle has experienced coolant intrusion in the engine resulting in the engine being seized. I was told by the Ford service rep that this is a known issue on this vehicle, but there is no type of warranty offered.

Purchased my car on 1/16/21. In mid-2023, I was having issues with hearing water running in my dashboard. During this time no warning messages appeared. Soon after my car started shutting off without notice again with no warning messages. It would shut off while driving or when stopped. Then it also started running hot with warning messages. Due to this, I took my car to a repair shop and was told that turbo boost oil had leaked into my engine. I was told I needed a long-block engine replacement for $12,000. I have never been in an accident that would impact my engine. I kept up on the maintenance of my car. After research, I learned that this is a problem for Ford's turbo boost engine and that Ford was aware of the possible issue.

Coolant is leaking into the engine, , Service Advisor (Lapalce Ford) said engine would need to be replaced, Said no warrantly would cost $10,000.00 to replace, Issues began in early 2023 with spark plug miss fire, Had a tune up done, but problem persisted, An engine warning light came on indicating that misfire in one of the coils, Had the spark plug and coil replaced during June of 2023, Problem persisted and warning light came on again, brought to ford to look and as was told that it was coolant leaking into the engine and that it would need to be replaced September of 2023.--I got a second opinion from Roy's Auto Tech in Marrero la and had them replace the engine with a new ford engine. $9720.59. Other than this issue this vehicle is was like new. --It has to be a mechanical defect with the design of the engine, and ford is aware as there have been multiple complaints of the exact same issue long before my problems arose.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated on the instrument panel. The vehicle was taken to an independent mechanic, who determined that coolant intrusion into the engine had damaged the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12, but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 164,000.

I purchased a 2018 Ford Fusions on [XXX]. After two days check engine light came on. The code was showing misfire of 3rd cylinder. I took it to Angela Krause Ford Dealership, in Alpharetta, Ga. The are saying coolant is getting into the cylinders and that the short block needs to be replaced. After doing research, I have found this is a big problem for Ford. A customer Satisfaction Program has been out concerning this issue. ([XXX]). In this program it states the year range, plant manufactured, and mileage that is included in this program. My car is a 2018 Ford Fusion and fits the plant manufactured location and is under mileage threshold. Ford is saying my Vin is not registered for this program. My car is having exact issues and fits the criteria perfectly. I need help to get this covered by Ford. A clear issue, that they have had and recognized. My Car fits the exact profile. Please help get this Vin registered under the program or help get this covered. I believe this could have been an issue before I purchased car. Although Bulletin says coverage is transferred to subsequent owners. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Fusion. The contact stated while driving 5-10 MPH, the message "Coolant Level Low" was displayed. The contact veered to the side of the roadway and added coolant to the vehicle; however, the same message was displayed the following day while driving. Additionally, the check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that cylinder #2 was misfiring due to coolant intrusion. The mechanic replaced 1 coil, 1 spark plug, and the coolant reservoir hose; however, the check engine warning light turned off temporarily and the failure persisted. The vehicle was taken back to the independent mechanic, where it was diagnosed that there was a coolant intrusion in cylinder #2, and the engine needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure but did not assist. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under Ford TSB: 22-2229. The failure mileage was approximately 94,000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at various speeds, the engine was running rough. Additionally, the A/C was making a loud squealing sound while activated. The contact stated that upon inspecting the vehicle, the contact became aware that the coolant level was low. There was no warning light illuminated. The vehicle was taken to the dealer it was purchased from, and the water pump kit timing belt was replaced. The vehicle remained at the dealer. The contact was unable to confirm that the vehicle had been repaired. The contact related the failure to Ford Campaign Number: 21N12; however, the campaign had expired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 101,000.

Block cracked internally inside cylinder number 2 causing a misfire, white smoke on start up, coolant lose, and overheating. Problem is called coolant intrusion. Safety is at risk is the car dies on the interstate. It has a check engine light for misfire on cylinder 2. Ford is aware of this problem but says my vin is not affected by this problem even though I have this problem.

Purchase car in 2019. 4 years later my car is overheating due to a cylinder crack. No recall was found using my vin number but with a cylinder crack and car overheating this is a safety issue.

Vehicle’s engine was misfiring for a while before check engine light came on. Showing cylinder 2 misfiring codes when scanned. The first dealership replaced the spark plugs, didn’t fix the issue. The next dealership said I have coolant intrusion and need to replace engine.

I have a 2018 ford fusion 2.0L ecoboost with around 77k miles and started to see coolant loss with no visible signs in engine bay or below.car, rough start with error P0316 and occasional misfire. White smoke comes from exhaust on start sometimes. Also have to fill coolant every other day or so. It looks as coolant intrusion issue very common with these engines.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the temperature gauge indicated that the engine was overheating, and the vehicle briefly shuddered. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed failures with the head gasket and turbo charger. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 75,000.

The contact owns a 2018 Ford Fusion. The contact stated that after starting the vehicle, he observed excessive smoke coming from the engine compartment as well as the rear exhaust. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined there was coolant intrusion into the engine cylinder that caused damage to the cylinder head. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 89,000.

The contact owns a 2018 Ford Fusion. The contact stated that upon taking the vehicle into the dealer for an oil change, the contact was informed that the engine was empty of coolant. No warning lights were illuminated. The vehicle was taken to the dealer, who determined coolant intrusion had caused damage to the cylinder head, requiring a replacement. The vehicle was not repaired. After investigating the failure, the contact related it to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 47,000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle was able to be restarted. The engine overheating warning light was illuminated. The vehicle was towed to the dealer, who determined coolant intrusion had caused damages to the engine. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 96,000.

The contact owns a 2018 Ford Fusion. The contact stated that the engine was running rough while the vehicle was idling. The contact stated that the check engine warning light illuminated the following day. The contact stated that the failure recurred while the vehicle was idling. The vehicle was taken to the dealer, where it was diagnosed that there was coolant intrusion in the engine cylinders, causing the engine to misfire. The dealer related the failure to Ford Campaign Number: 22-2322 and informed the contact that the short block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 69,900.

I bought my 2018 Ford Fusion new and it currently has 35,000 miles on it. It began misfiring about 2 months ago, and then the check engine light came on. After a diagnostic exam, I was told the engine needed to be replaced. Luckily I was still within the warranty extension window for this particular problem, so the engine was replaced. However, I spent the majority of this time without my car. They were able to secure me a loaner car, but only for 3 days out of the total duration of the repair. I was stuck without my car the remainder of the time with very little communication from Ford about what was going on. When I asked if my car was still at risk of the same thing happening again, I was given a very vague answer that was not particularly reassuring.

While driving the vehicle a light came on indicating that the "Engine compartment was overheating". The next time driving the vehicle the light was gone away and shortly later the Check Engine light came on. Took to the local dealership and they determined that their were 2 verified misfires and when they pulled the plugs using a scope they found coolant intrusion in one of the cylinders. The recommendation per Ford is to replace the engine assembly.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle was shaking, and there was white smoke coming from the exhaust tip. The contact stated that after starting the vehicle the following day, she noticed an abnormal odor. The contact stated that while driving at an undisclosed speed, the temperature gauge relayed that the engine was overheating. The vehicle was taken to the dealer but was not diagnosed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 158,000. The VIN was unavailable.

Coolant intrusion issue which is known to occur in this specific engine which is shared across many of Ford's automobiles. Customer Satisfaction Program 21N12 and 19B37 My car is just outside of the program guidelines- however it was in the dealership prior to it exceeding the program guidelines and I was never informed of the issue. Vehicle Model Year Assembly Plant Build Dates Escape 2017-2019 Louisville September 17, 2015 through April 8, 2019 Fusion 2017 Flat Rock October 1, 2015 through October 16, 2015 Fusion 2017-2019 Hermosillo October 6, 2015 through June 10, 2019

I've got engine light on then send to Ford dealer. Diagnostic says Purge Valve Replacement, I was told that there was a misfire caused by coolant intrusion cylinder 1. They also told me that this was a KNOWN ISSUE a few years back and it needed a NEW ENGINE to fix the problem. I asked them several questions about why only telling me now since it's an ongoing issue and why is it that no one from Ford dealer all different state that I brought in my car to check safety issues and regular oil changes informed me about this? I just retired and the dealer asked me to pay for the repair of new engine plus labor. I can't afford and it's hard to accept that someone lying to get some money from me. I read an article from your website with the same issue that there is a recall but the dealer told me that this was only a KNOWN problem NOT a recall. Please see the link [XXX] Kindly help me to resolve this issue and help others. Let them send a recall again to every Ford owner/user to avoid accidents that can cause death. This is ongoing and my case with the dealer has still not been given an answer for almost a week tomorrow. I appreciate your help and hoping to hear from you soon. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Fusion. The contact stated that the vehicle jerked while starting. The check engine and transmission warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed and related the failure to Technical Service Bulletin: SSM 47849 (Coolant Consumption); however, the vehicle was not covered under the TSB. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 104,000.

The contact owns a 2018 Ford Fusion. The contact stated while driving 70 MPH, the message "Coolant Hot" was displayed. The contact pulled over on the side of the road and notice that there was no coolant in the reservoir. The contact added coolant into the reservoir, but the coolant leaked out. The vehicle was towed to the dealer. The dealer diagnosed the vehicle and stated that the engine needed to be replaced and that the vehicle was out of warranty. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 99,960.

The contact owns a 2018 Ford Fusion. The contact stated while the vehicle was idling, the engine overheated. The temperature gauge increased to HOT. The check engine warning light was illuminated. The high-temperature indicator light was flashing, and the fan was engaged. The vehicle was running rough. There was white smoke coming from the vehicle. The vehicle was taken to the local dealer, where it was diagnosed that there was a crack in the engine block and that cylinder #3 had a misfire. The engine block was replaced. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 188,000.

The contact owns a 2018 Ford Fusion. The contact stated that while the vehicle was idling at a stop light, the vehicle started to shake. The coolant temperature warning light was illuminated. The contact then stated that while operating the air conditioning system, hot air started to blow from the vents. The contact stated that she was concerned for her safety. The vehicle was taken to an independent mechanic where it was diagnosed that coolant had leaked into the cylinders and the cylinder head was cracked; however, the contact then stated that she was informed by the mechanic of corrosion at an unknown location of the vehicle. The contact was unsure of what needed to be repaired. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in a recall and provided a case number. The failure mileage was approximately 51,000.

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, the message "Coolant System Temperature Above" was displayed, and the vehicle stalled. An unknown dealer was notified of the failure. The vehicle was taken to an independent mechanic, where it was diagnosed that the engine had failed and needed to be repaired. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.

Coolant leak into 4th cylinder head causing rough idle. Repair shop changed plugs and coil, and stated there was coolant in the cylinder. Stayed this is a known issue with Ford Fusion but no recall. My car only has 72000 miles.

There was a recall on my vehicle but I was never notified. When my car started having problems i was told i needed to purchase a motor. I took my car to the dealership Stivers Ford in Montgomery, Alabama and they performed a diagnostic which showed that there was a coolant leak due and my short block needs to be replaced. They said the recall would not be used because it is passed the date. This is putting the safety of myself and my children at risk. I need assistance with these repairs as I cannot afford an $8,000 repair fee. I called customer relations and was told that they would cover the charges but come to find out a week later after several attempts to reach customer relations, I was told that the agent closed my case. The agent did not call me to say anything. Please help

The contact owns a 2018 Ford Fusion. The contact stated the check engine warning light illuminated and the vehicle hesitated while attempting to accelerate. The vehicle was taken to the dealer to be diagnosed. The contact was informed that coolant was leaking into the engine. The vehicle had not been repaired. The manufacturer was made aware of the failure and informed the contact that there was no recall on the VIN. The approximate failure mileage was 122,000.

My car overheated due to a head gasket leak, which released coolant into the piston cylinders, causing the engine to overheated, resulting in engine block damage. My car almost blow up!!!! This is a lawsuit against fords ecoboost engines. They need to pay for this fully!!

I usually use an automatic starter to start my car so I did not notice when starting the car that it was shaking for a good 30 seconds after starting the engine until one day I got in my car and started it normally the whole car shook for about 30 seconds then stopped and the check engine light came on. I was on my way to dinner driving on the parkway and my engine started to over heat and I could not accelerate. I pulled over and googled what to do when your dashboard says "engine coolant over temperature" , So I rolled down all the windows and blasted the heat. After ten minutes when the engine cooled off I tried to acclerate slowly and the car would not accelerate. I had to leave my car on the side of the road to let it cool down for hours, I went back to get it two hours later. Thankfully driving slowly I made it off the parkway and managed to get the car to a local shop. They informed me that the coolant had leaked into the engine causing the engine to fail and it needed to be replaced. I began looking into it and found that there was a recall on all 2014-2018 ford fusions for that exact issue. I called the dealership, and they of course tried to make it seem like it was my issue and I needed to have it towed over so they can look at it. The dealership has been absolutely no help for a faulty engine, If I didn't do research and look into the current lawsuit against the company they would have made me pay for the brand new engine $7000+. They are fixing the engine for no charge but refuse to give me a loaner car or pay for a rental car which is beyond me. I do not understand why I should come out of pocket for a rental car for two weeks when I pay for my car that I should be driving. Terrible customer service. I hope this helps anyone else having similar issues!

I was not informed of a recall. I started having issues with my engine about 4 months ago, it stopped on me in another city and state Montgomery, Alabama. I currently live in Pensacola, Florida. I have not been able to afford a new engine. I am a single mother on one low-income. I sent my car to a ford dealership and was told that i need a new short block on my engine due to the coolant leak. Well come to find out there was a recall that I was unaware. Now Ford will not cover my repairs at all. They stated the recall was over in November 2022. Now I contacted customer relations on Friday 8/4/2023 and was told they could fix it and I was awaiting a call from the agent that was assigned to my case and never received a call back. I called everyday three times a day for about a week for a supervisor to tell me on Thursday 8/10/2023 that the agent closed my case. I was not notified at all even after being told multiple times that customer relations would cover the repairs. All I am asking is for the car to be fixed. I would like for someone to contact me

The contact owns a 2018 Ford Fusion. The contact stated while driving 40 MPH and depressing the accelerator pedal, the vehicle hesitated to respond. The check engine warning light was illuminated. The contact was able to drive to the residence. The contact connected an OBD reader to the vehicle and retrieved a diagnostic code that indicated that cylinder #2 had misfired. The contact stated that he replaced the spark plugs himself; however, the failure recurred two days later. The contact stated that the vehicle was not drivable. The vehicle was towed to the local dealer, where it was diagnosed that the compression had failed, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was 116,295.

In July 2023 my vehicle started to display a shudder upon start up. The check engine light came on. I took the vehicle to my local mechanic who informed me that there was a cylinder 1 misfire. The spark plugs were replaced. Approximately one week later the engine light came on and I took the car to the local mechanic.. The mechanic said cylinder 1 was again misfiring. The mechanic examined the engine and determined that the newly installed spark plugs were corroded due to engine coolant leaks. I was advised that Ford Motors issued TSB 22-2133 for this problem recommending an engine replacement. I took the car to the local Ford dealership for a diagnosis. The dealership informed me that the engine coolant was empty and that the engine needed to be replaced and cited the TSB. Research showed that Ford Motors has known of this problem affecting the 2.0L EcoBoost engine for many years but has not taken steps to discontinue manufacture of the type of engine affected and continued to use it in other models and year vehicles. The sudden loss of engine coolant and resulting catastrophic engine loss is a serious safety issue where a vehicle, if continued to be driven, could overheat, catch fire or cause a serious accident if occurring on a highway at speed. Ford Motors should issue a recall of this engine and replace them in all affected vehicles. Presently, Ford will only replace the engine if after the problems occur and at the consumer's expense. Ford knowingly manufactured, used, and sold defective engines in many model year vehicles risking customer safety and causing consumers financial hardships to correct the problems with no guarantee that the problems will not reoccur.

The contact owns a 2018 Ford Fusion. The contact stated that the check engine warning light was illuminated. The contact took the vehicle to a certified mechanic who after 3 days diagnosed and determined there was coolant intrusion into cylinder #2. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact spoke with the dealer and was informed that the failure was a known issue; however, the VIN was not under recall. The manufacturer was not made aware of the failure. The approximate failure mileage was 127,000.

The contact’s son owns a 2018 Ford Fusion. The contact stated that while her son was driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle decelerated while the accelerator pedal was depressed. The vehicle was taken to an independent mechanic where it was diagnosed and determined that coolant had leaked into the engine, and the engine needed to be replaced. The vehicle was not repaired. An undisclosed dealer and the manufacturer were notified of the failure and the contact was informed that the VIN was not included in a recall. Additionally, the mileage had exceeded any extended warranty coverage. No further assistance was provided. The failure mileage was approximately 129,000.

The contact owns a 2018 Ford Fusion. The contact stated while driving 35 MPH, the engine started to misfire. The contact stated that the check engine warning light was illuminated. The contact turned off and restarted the vehicle and was able to continue driving to her destination. The contact stated on July 28, 2023, while driving 35 MPH and depressing the accelerator pedal, the vehicle failed to exceed 35 MPH. The contact parked the vehicle because the vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the engine to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was 105,669.

The contact owns a 2018 Ford Fusion. The contact stated that while driving uphill at an undisclosed speed, the check engine warning light remained illuminated with the engine temperature gauge showing that the engine was overheating. The vehicle was taken to the local mechanic who diagnosed that the engine was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 124,000.

I purchased a 2018 Fusion in January with 118k miles. 6 months later the engine light came on sometimes it wouldn’t start. Misfires can cause fires and it was absolutely chugging gas. Took it to ford they diagnosed coolant intrusion and said I need the new updated cylinder block. Wasn’t covered under my extended power train warranty I had with the car and it was almost a $9000 fix. I’ve got a lemon on my credit now and ford needs to recall or compensate to this asap

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the contact self-inspected the vehicle and noticed that the coolant level was low. The vehicle was taken to the dealer, who informed the contact that the engine needed to be replaced. The vehicle was not repaired. The vehicle was taken to a second dealer, Southfork Chrysler Dodge Jeep Ram (17725 South Fwy, Manvel, TX 77578); however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 59,860.

Engine stalling while driving and stopped, excessive coolant consumption, hard start, white smoke from exhaust. My vehicle has stalled while driving on the highway at 70mph with my 7 year old child in the car with me, my vehicle has also stalled while sitting at a red light or stop sign, this puts myself, my passengers and other vehicle at risk of an accident. I called the dealership today to inquire about my issues and was told there was a FORD customer satisfaction report that was put out on the issues I was having, I Googled the issue and found the 21N12 or 19B37 which expired in November 20, 2022 or 84, 000 miles. The dealership suggested I reach out to Ford. I did this today (7/5/23) spoke with CSR Jerrica who stated there was nothing they could do. I never received the notice regarding this issue and also was told they use a 3rd party to send those out. My engine light came on over the weekend along with the wrench light. I have mentioned the stalling to the FORD dealer previously who stated there were no lights on and could not get the car to recreate the stalling so nothing was mentioned or done. They are now saying since I have issues this falls under the expired customer satisfaction they issued.

Radiator failure. Causing engine to shut down. Check engine light appears.

My engines been leaking radiator fluid and I was told there was a recall on the engine block because of this issue. I went to ford and they said they had a recall on it but they didn’t tell me that it expired. Even after I was scheduled for an appt I had to get a flex location to diagnose it and they said that the recall for it expired and they couldn’t do anything about it. Before I took it to ford I took it to 2 car repair shops and they told me the same thing that it was the engine block.

The contact owns a 2018 Ford Fusion. The contact stated while driving 25 MPH, the check engine warning light illuminated, and the vehicle started to misfire. The contact was able to drive to his destination. The contact stated he added coolant to the coolant reservoir. The contact took the vehicle to an independent mechanic and was informed that the hub gasket was leaking coolant fluid into the engine, causing the engine to overheat. The vehicle was not repaired. A dealer was not contacted. The manufacturer had been informed of the failure. The failure mileage was approximately 126,000.

I purchased my car in September 2018 and I have brought my car in for many service problems within the first year alone. I now have a broken flywheel or flex plate, and my car is under 5 years old. With the amount of repairs I have done to my car it is as if I bought a used car. I am the first person to drive my car as it was purchased brand new.

Check engine light came on and then the vehicle overheated. The vehicle started to lose power and I had to pull to the side of the road, on a busy highway. I let the car cool down and drove it to a gas station a mile away, it drove incredibly roughing, had a thick, white smoke coming from the tailpipe and coolant was low. It was then towed to a Firestone in the area. They could not diagnose it properly, so I was then towed to the nearest Ford Dealership. Codes P0217, P0302, P0316, P1285 Advised P0302 was a misfire in Cylinder 2, pulled the coil and plug and found coolant in the cylinder. Ford quoted me $10,400 to replace the entire engine assembly with a long block, said there were no recalls for this issue even though it's common and that my car was no longer under warranty.

The contact owns a 2018 Ford Fusion. The contact stated while driving at various speeds, the vehicle failed to accelerate while depressing of the accelerator pedal, with the check engine warning light flashing on the instrument panel. The contact had taken the vehicle to a dealer where he was informed that coolant was leaking into the engine cylinders. The manufacturer was notified of the failure and the contact was given a case number. The manufacturer later was informed that the vehicle would not be covered under warranty or recall. The vehicle was not repaired. The failure mileage was approximately 78,000. The consumer stated the vehicle had a coolant leak in the engine which caused corrosion and other damage to the engine.

2018 FORD FUSION. CONSUMER WRITES IN REGARD TO ENGINE BLOCK ISSUES. UPDATE 07/06/2023- Consumer states: " This is my second letter to the National Highway Traffic Safety Administration (NHTSA) to address the neglect by FMC, its attorneys and dealerships to resolve a defective 1.5L Eco­ boost engine. With recent media addressing the detrimental errors of governing agencies, whistleblowers missing submarine with reports of safety issues, and so much more, I believe you know Ford Motor Company needs to do the right thing and accept their responsibility, address the repair, replacement and financial compensation necessary to the American people. This is not an issue to make more lawyers wealthy, although they need to get paid, it's an issue that can contribute to the healing a nation, one step at a time. Please respond to myself at the above address, and my attorney for resolution." Enclosed: June 09, 2022 - FMC Letter - Customer Satisfaction Program 19837 June 09. 2022 - FMC Letter - Customer Satisfaction Program 21N12 April 17, 2023 - Letter to FMC - with multiple cc May 10, 2023 - State of Michigan. Office of the Attorney General, Consumer Protection Oiv1s1on May 17. 2023 - State of Michigan, Regulatory Monitoring Division May 18, 2023 - State of Michigan, Attorney General, Consumer Protection Case letter May 24.2023 - State of Michigan Office of Investigative Services Case letter

The contact owns a 2018 Ford Fusion. The contact stated while driving approximately 30 MPH, the vehicle started to shudder with a large cloud of bluish smoke coming from the exhaust pipe. The contact stated that the vehicle was also shuddering and idling rough when started. The contact stated that the check engine warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed, and the mechanic retrieved DTC: P0304 and determined that there had been a misfire in cylinder #4. The dealer recommended that the spark plugs be replaced, and the fuel system cleaned. The vehicle had been repaired. The contact stated that the failure had reoccurred and returned the vehicle to the same dealer who diagnosed and found that coolant had intruded into the engine block and recommended that the engine be replaced. The contact researched online and related the failure to manufacturer Customer Satisfaction Program: 21N12 Coolant Intrusion (Engine and Engine Cooling). The manufacturer had been informed of the failure. The failure mileage was 100,556. The consumer stated the vehicle is no longer in her possession.

Engine failure as described in TSB 22-2229, confirmed by local Ford dealer (Bill Brown Ford in Livonia, MI). This issue is not a normal wear & tear issue, it is a combination of Design & Manufacturing flaw (known by Ford) however Ford Warranty will not provide me with any financial assistance for the repair. An engine should never have the wall between the piston cavity and cooling cavity break down ever. This issue should be under a recall. This failure could easily have taken place on the interstate at night leading to immediate side of the road situation and very nearly did since we were to take a trip several states away the next day.

The contact owns a 2018 Ford Fusion. The contact stated while driving approximately 55 MPH, she observed that a cloud of white smoke was coming from the exhaust pipe. The contact stated that the vehicle lost motive power and stalled; however, the engine started to misfire, and the vehicle was shaking abnormally. The contact stated that a message that the engine was overheating was displayed. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that coolant had intruded into cylinders #1, #2, and #3. The dealer determined that the short block needed to be replaced. The vehicle was repaired; however, the failure recurred. The manufacturer had been informed of the failure. The contact was informed by the manufacturer that the failure was related to Customer Satisfaction Program: 21N12 - Coolant Intrusion (Engine and Engine Cooling) and that the repair had been a one-time free repair. The failure mileage was approximately 137,000.

The contact owns a 2018 Ford Fusion. The contact stated while driving 60 MPH, the powertrain malfunction warning light illuminated. The contact stated that the vehicle started overheating. The contact pulled over and turned off the vehicle. The vehicle was towed back to the residence. The vehicle was then towed to the dealer and the dealer stated that coolant was leaking into the engine and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but provide no assistance. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 151,981.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the check engine warning light remained illuminated. The vehicle was towed to the local dealer who diagnosed the vehicle and determined that engine coolant had leaked into the cylinder #3, causing severe damage to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure and informed the contact that the VIN was no longer eligible for the Extended Warranty Coverage. The failure mileage was 109,000.

The contact owns a 2018 Ford Fusion. The contact stated that while operating the vehicle, there was a sound of liquid present inside the dashboard. The vehicle was taken to the local dealer who diagnosed that engine coolant was present inside the engine cylinders and the engine short block needed to be placed. The engine short block was replaced but later the vehicle began to drive sluggishly and would not properly accelerate. The vehicle was taken to a second dealer who diagnosed that the engine was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 110,000.

Since 2021 we have had problems with the car. The car started smoking and cutting off for some known reasons. We contacted Vidalia Ford known also as Paul Thigpen where the car was purchased. There have been numerous attempt to get the car fixed by Paul Thigpen and we will get the car out the shop and take it back. The car is jerking, still cutting off, and car smoking. Told us that was normal for that car to smoke. We was told by Paul Thigpen that we needed a motor in the car. All of a sudden after this car Fusion car motor have been broken down numerous time. We are told that Ford Corporation would not send a new motor for the car. We have went to pick up the car on one occasion and started the car up and it was smoking like it was on fire. All the techs ran to the car because they thought the car was on fire. We have called Ford Corporation to speak to someone in their Consumer Affairs office. Asked us to take it to another Ford Dealership in Dublin, GA and they told us we needed a motor and they will get the motor in a few days. These people calls and say the same exact thing Paul Thigpen tech stated that Ford would not send the motor. When we got the car back, it's still jerking and smoking. The techs fails to put in notes that Ford Corporation fails to fix the vehicle. Now the vehicle is sitting in the yard and we are making payments. The oil is leaking from the motor. I reported it to the Better Business Bureau and Ford failed to respond. The Better Business Bureau stated to send it to you all. This car had stayed in the shop months at a time. Yes, we are angry consumers who has paid for an extend warranty on this vehicle when purchased. Darren from Consumer Affairs called and left a message on the voicemail that we can't get mad because Dublin Ford refused to fix our vehicle. We have not enjoyed the vehicle and it's wrong how Ford is doing people. They are trying to let the warranty runs out. Everyone claims to be full when it first happened with oil probl

The contact owns a 2018 Ford Fusion. The contact stated while driving approximately 55 MPH, the vehicle started losing motive power. The contact depressed accelerator and the vehicle continued to lose motive power. The contact stated that she observed a large cloud of white smoke coming from the exhaust pipe. The contact stated that the check engine warning light was blinking off and on. The contact pulled off the roadway and turned off the vehicle. The contact had the vehicle towed to a dealer where it was diagnosed and determined that coolant had leaked into the engine block. The manufacturer had issued a Customer Satisfaction Program Number: 21N12 (Engine and Engine Cooling), however the vehicle no longer qualified for the program. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 94,000.

The check engine light came on my 2018 Ford Fusion on 2/6/23. On 2/7/23 the car was diagnosed by a Ford dealer as having a coolant intrusion issue. Upon doing research, Ford was aware as early as 2019 that that the 2.0L EcoBoost engines have this common problem. They Issued a Technical Service Bulletin detailing the problem. However, Ford is not recalling these vehicles. They have told me that the only fix for the problem is to remove the engine and replace the long block for $8000. Vehicles like mine with the 2.0L EcoBoost engines have a defect that cause coolant to leak into the engine’s cylinders, which can cause corrosion, oil dilution and contamination and engine failure. Furthermore, this defect creates a safety risk because the lack of coolant created by the leaks causes overheating and can result in the cylinder head cracking, total engine failure, or worse an engine fire. If there is a risk that the engine could catch fire on all these vehicles, that puts my life, my passengers lives and others sharing nearby roads lives in danger. I am urging the NHTSA to investigate this claim and the numerous consumers that have these faulty engines. Please hold Ford accountable and force them to replace these engines to keep us citizens safe.

Misfires on cylinder 2. Engine burning oil slowly. Mileage is only 64,390.

The contact owns a 2018 Ford Fusion. The contact stated that while operating the vehicle, the check engine warning light remained illuminated with a message stating "Engine Coolant Over Temperature" displayed. Additionally, the engine sputtered while the vehicle was being started and there was gray smoke coming from the exhaust pipes. The contact stated that the vehicle would not properly accelerate while depressing the accelerator pedal. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that coolant was leaking into cylinder #1, causing damage to the engine long block. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 112,000.

I am a retired mechanic with over 13 years of professional experience working at multiple dealerships. I purchased my 2018 Ford Fusion with 2.0L Ecoboost on 6/29/2022 with 73,555 miles. Two days after delivery, within 1 minute of leaving home, the CHECK ENGINE light was illuminated. When I returned home, I used my diagnostic scanner to find code P0300 set. What I found interesting is that the scanner indicated that the code had been cleared 298 miles earlier, which indicated either the prior owner cleared the code, or the dealership cleared the code prior to marketing it for sale. Two days ago, on the way home from work, the CHECK ENGINE light came on again, and I was able to determine that the code was a P0302, misfire on cylinder 2. I checked the coolant level of the car, and it was below the minimum mark on the reservoir. I removed the spark plug from cylinder #1 and cylinder #2 for visual inspection and comparison. Visual inspection of the plugs had a normal carbon build-up on the piston in cylinder #1 and on the ground electrode of the same spark plug, whereas on cylinder #2 there was no carbon buildup on the spark plug nor on the top of the piston; it was "wet looking". I reinstalled the spark plugs, and topped the coolant off and bled air out of the coolant system. I did utilize a combustion gas leak detection tester marketed by Blue Point that I have used in the past to diagnose faulty head gaskets, but the results were inconclusive. On my drive to work the next day, the CHECK ENGINE light was no longer illuminated. This morning, I examined the coolant reservoir, and there is a noticeable decrease in volume of coolant in the reservoir from the day before, along with the misfire on startup and illumination of the CHECK ENGINE light, with code P0302 being set. To date, the selling dealership and Ford have denied my request for any extended warranty assistance for replacement of the defective designed 2.0L engine. I now have a car I cannot use at all.

The contact owns a 2018 Ford Fusion. The contact stated while driving 55 MPH, the check engine and the temperature warning light illuminated indicating that the vehicle was overheating. The contact was able to pull over, turn off the vehicle, and waited for the engine to cool down. The vehicle was taken to an independent mechanic and the head gasket was replaced; however, the failure recurred. The vehicle than was taken to an authorized Ford dealer to be diagnosed. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but offered no assistance. The contact was also informed that the vehicle was no longer under warranty. The failure mileage was 121,000.

Bought 2018 fusion used with 20k miles. Driving to work the check engine light came on. Took it to auto zone they ran codes and said misfire cylinder 3. Replace plugs and coil packs. Next day check engine light came on again. This time had rough idle at start up. Turned car off and contacted closest ford dealer. Upon inspection told me coolant leaking into head with no blown head gasket. Said to be common problem with ecoboost engines. Need to replace engine for over $7800. Not under warranty and Ford knows of issue and won't stand behind their product. I'm a single mom with no car to get to work now and no way to fix this. It would take me years to save enough to fix this car. Completely hopeless at this point. No car=no way to work. No job=no home or food. This is a common problem and well known issue but tough luck? How can this be right? How can I feed my children or pay rent? What am I supposed to do? This is not fair. You made a faulty product so you should stand behind it and make it right. This has literally destroyed my life.

I was driving to work one day and my car's engine light came on and then the overheating light signaled and would drop and then signal again randomly one morning, with no sign of smoke or overheating. Unfortunately, I was crossing a bridge when this happened. My car started to slow down and eventually just stopped moving ON THE BRIDGE. I finally got it to a mechanic who thought that the codes ran could be fixed with a tuneup. Got a tuneup and the Engine light came right back on. He then looked further into the issue and found out about the eco engine issue. I could not drive my car for two weeks until ford could fit me in their schedule because they were booked two weeks out. I get it to the dealer and they tell me the car is leaking coolant into my engine and now my engine needs to be replaced and that this is a common issue but I must pay for this fix myself. This is wrong and completely unsafe to put people on the road in these cars knowing this can happen.

The contact owns a 2018 Ford Fusion. The contact stated while driving 25 MPH, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that there was coolant intrusion in the cylinder and the engine block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA. The failure mileage was approximately 67,000.

Never had a problem with car no leaks nothing than starting to overheat checked coolant was empty refilled next day was empty again yet no leaks had it looked at all coolant is in engine block but no blown head or other way saw in other complaints lots with same car had same problem and said it’s a flaw engine where coolant gets into cylinder still owe more money then car is worth now and can’t drive

Ford issued a recall in 2020 for my car for coolant leaks. My vehicle was under warranty at the time (28k miles), and in the same week had white smoke emissions, engine stalling on the interstate and overheating in idle. The smoke never went away even after extensive, month long repair. The vehicle again had the same issues in august 2020 (76k miles), taken to Ford dealership with $3,000 in out of pocket expense. It is now March 2022 (82k miles) and my vehicle is still showing signs of coolant leak with no help from any Ford dealership.

Blown head gasket at only 85k miles.

Head gasket failure

My check engine light came on. It was diagnosed as a misfire in cylinder 2. Today I was told the entire engine needs to be replaced

The contact owns a 2018 Ford Fusion. The contact stated that after starting the vehicle and shifting into reverse, the vehicle misfired. The contact stated that the check engine warning light was illuminated. The contact restarted the vehicle however, the failure persisted. The failure became worse after driving for a while. The contact took the vehicle to the local dealer to be diagnosed. The contact was informed that the engine needed to be replaced. The vehicle was not repaired however, the repair was pending. The manufacturer was not informed of the failure. The failure mileage was approximately 82,700.

Check engine light (#2 cylinder misfire) was generated, rough idle on start, cold start is prolonged, high temperature indicated, coolant quickly emptied on its own (within minutes, it was half full) and white smoke exiting the exhaust. NHTSA has a TSB related to this year model vehicle: https://static.nhtsa.gov/odi/tsbs/2019/MC-10169807-0001.pdf I believe this issue is related to the above link.

45,000 MILES ON THE CAR. ENGINE COOLANT IS LEAKING INTO THE ENGINE CYLINDERS

PURCHASED 2018 FORD FUSION TITANIUM USED IN AUGUST 2019. IN DECEMBER 2020 MY CHECK ENGINE LIGHT CAME ON AND I TOOK IT FOR SERVICE. SERVICE TOLD ME THAT THERE IS A TECHNICAL BULLETIN ON THE ECOBOOST ENGINE BECAUSE THERE IS A BAD CAST ON THE HEAD. THIS CAUSES COOLANT TO LEAK INTO THE OIL. THE ONLY WAY TO REPAIR IS TO REPLACE THE ENGINE. FORD REFUSES TO STAND BEHIND THEIR PRODUCT AND THE COST OF FIXING IT FALLS ON ME. THE VEHICLE WAS MOVING WHEN THE CHECK ENGINE LIGHT CAME ON AND THE CAR SMELT OF BURNING. WHITE SMOKE WAS COMING FROM THE EXHAUST.

COOLANT LEAKED INTERNALLY. ROUGH WHILE IDLING. LOSS OF POWER WHILE DRIVING DOWN THE INTERSTATE.

RECEIVED A MESSAGE THAT FORD THAT THE COOLANT COULD BE GOING INTO ENGINE AND COULD DAMAGE ENGINE MIGHT NEED A PART IM IN FLORIDA SINCE 1/2/2020 THE CAR IS ON INSURANCE MODE NOT BEING MOVED OR STARTED SO NO DAMAGE CAN HAPPEN WE WILL BE BACK IN N Y MID JUNE , THE CAR IS A LEASE CAR AND WILL I BSTILL BE ABLE TO BRING IN FOR REPAIRS WITHOUT ANY COST TO ME WHICH I CANT CONTROL DO TO THE VIRUS IN N Y C. *TR

CHECK ENGINE LIGHT, LOTS OF WHITE SMOKE OUT OF TAILPIPE AND DARK BLACK SPARK PLUGS AT 15,000 MILES! DEALER SAID I GOT BAD GAS OR VANDALISM THEREFORE NO WARRANTY COVERAGE. I HAD TO PAY A LOCAL MECHANIC TO REPLACE SPARK PLUGS, PUMP OUT AND REPLACE FUEL. TWO WEEKS LATER I RECEIVE A FORD LETTER STATING COOLANT CAN LEAK INTO THE CYLINDER BORES CAUSING EXACTLY HAPPENED TO MY VEHICLE. NOW I HAVE TO SEEK REIMBURSEMENT.

I STARTED LOSING COOLANT AS A I DROVE WITHOUT ANY VISIBLE LEAKS AROUND THE ENGINE OR COOLING SYSTEM. I DECIDED TO TAKE THE VEHICLE IN TO MY DEALER ONLY TO FIND OUT THAT THE COOLANT IS LEAKING INTERNALLY AND THAT THE DEALER IS VERY USED TO SEEING THIS ISSUE ON 2018 AND 2019 FORD FUSIONS. THEY TOLD ME THAT THEY WILL NEED TO REPLACE THE ENTIRE ENGINE. THANKFULLY IT'S UNDER WARRANTY. IF THIS IS SUCH A COMMON ISSUE THAT THE DEALER IS AWARE OF IT AS SOON AS I BRING IN THE VEHICLE, WHY IS THERE NO RECALL ON THIS ISSUE? THEY ARE WARRANTING THE REPLACEMENT PARTS AND LABOR...SO I'M ASSUMING THEY HAVE FIXED THE ISSUE.