2006 Ford Focus Electrical Problems

Your rear hatch wiring harness has frayed wires that are rubbing against the rubber boot covering it, which can create a fire hazard since these wires are always live and connected to all rear electrical components. This wiring problem may prevent your rear hatch from opening unless you unlock it manually with the key. The fix likely involves replacing the damaged wiring harness and ensuring proper protection around the rear hatch electrical connections.

Your 2006 Ford Focus has stalled and stopped running multiple times while driving, starting the day you purchased it and continuing through at least May 2018. When the stalling occurs, all dashboard warning lights illuminate. A dealer inspection found nothing wrong and suggested replacing the vehicle's computer, but the problem persisted. You were involved in a crash in October 2017 that you believe may have been related to electrical or brake issues. The fix will likely involve diagnosing and repairing the electrical system, engine control computer, or fuel system components causing the stalling.

Your car's wiring harness flexes where it connects the body to the tailgate, causing the insulation to break and the wiring to short against the metal body. This blows the rear lights fuse and leaves you without any rear lighting, which can happen while you're driving or just opening the hatchback. The fix would involve replacing the wiring harness or routing it with better protection to prevent the flexing and damage.

Your gas pedal occasionally gets stuck and won't push down fully, making it hard to accelerate. Additionally, your headlights and other lights flicker constantly when turned on at night, which has caused you to be pulled over. A shop inspection found no obvious problems, but the electrical and fuel system issues persist.

Your car came without a cabin filter despite it being a feature some owners expected. The electric windows have never functioned properly since you owned the vehicle. Additionally, the airbag system was never inspected by the dealership during your ownership. Getting the windows repaired and requesting a professional airbag system inspection would be important steps to address these issues.

TL* THE CONTACT OWNS A 2006 FORD FOCUS. THE CONTACT STATED THAT WHEN THE IGNITION KEY WAS TURNED, IT WOULD REMAIN STUCK IN THE ON OR OFF POSITION. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS INFORMED THAT THE KEY MIGHT NEED TO BE REPLACED. THE CONTACT MENTIONED THAT THE VEHICLE WAS LEFT AT THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 123,000.

THE REAR PASSENGER SIDE DOOR LOCK DOES NOT LOCK. THIS IS THE SIDE THE BABY CARSEAT IS LOCATED. ALL THE OTHER DOORS DO LOCK/UNLOCK. IT HAPPENED SUDDENLY WITHOUT ANY REASON. I HAVE NOTICED MULTIPLE OCCURRENCES OF THIS ISSUE ON INTERNET FORUMS FOR FORD AND FORD DOES NOT HAVE A RECALL OR A MANDATORY FIX BUT THEY NEED TO AS THIS IS A REAL SAFETY AND SECURITY ISSUE! *TR

I HAVE HAD ONLY TWO PROBLEMS WITH MY 2006 FORD FOCUS. FIRST WE HAVE HAD TO CHANGE THE IGNITION SWITCH TWICE DUE TO THE KEY BEING STICK IN LOCK WOULD RESTART BUT WOULD NOT COME OUT. SECOND THE INNER DOOR ON THE DEFROST STICKS WHEN ON FULL DEFROST OR FULL AIR CONDITIONING AND THE CABLES BRAKE KEEPING THE DRIVER FROM USING THE AIR CONDITIONER OR DEFROST AT THIS POINT IT IS STUCK ON AIR. *TR

REAR DRIVERS SIDE DOOR WILL NOT LOCK. NOT WITH THE KEY REMOTE OR MANUALLY. CHILDREN IN THE BACK SEAT CAN OPEN DOOR ANY TIME. *TR

THE TRUCK LATCH ON MY 2006 FORD FOCUS ZXW WOULD NOT ACTUATE ELECTRICALLY WHEN THE BUTTON ON THE FOB OR ON THE DASH WAS PRESSED DUE TO BROKEN WIRE IN A WIRING HARNESS RUNNING FROM THE INTERIOR TO THE REAR HATCH DOOR. IT WOULD ALSO BLOW FUSE #63 ON THE BACK OF THE INTERIOR FUSE PANEL WHICH MADE REPLACEMENT DIFFICULT (THE FUSE IS REALLY ON THE BACK OF THE FUSE BOX, THE MANUAL RECOMMENDS THAT ONLY THE DEALER SERVICE OR REPLACE THIS FUSE MAKING THIS ISSUE DIFFICULT OR IMPOSSIBLE TO PARTIALLY RESOLVE IMMEDIATELY). UNTIL THIS FUSE COULD BE REPLACED, MY INTERIOR DOOR LOCKS COULD NOT BE ACTUATED ELECTRICALLY (POWER LOCKS OR FOB) WHICH WAS A SAFETY CONCERN AS ANY CHILDREN IN THE BACK SEAT COULD NOT BE EASILY REACHED IN THE EVENT OF AN EMERGENCY. ONE WOULD NEED TO MANUALLY UNLOCK ANY AND ALL DOORS FROM THE INSIDE OF THE VEHICLE. THE CULPRIT WAS WIRING HARNESS THAT HAD WIRES WITH DAMAGE TO THE INSULATION AND TWO BROKEN WIRES. I WOULD BE HAPPY TO SEND ANY AND ALL PICTURES OF THE DEFECTS. THE DAMAGE OCCURS WHEN THE HARNESS BENDS AS THE REAR HATCH IS SHUT DUE TO POOR DESIGN THAT DID NOT INCORPORATE A STAIN RELIEF TO EITHER END OF THE HARNESS WHERE MAXIMUM BENDING STRESSES WOULD OCCUR. THE WIRES MAY HAVE ALSO SHORTED AFFECTING THE BRAKE LIGHT OPERATION, MARKER LAMP OPERATION, AND NUMEROUS OTHER FUNCTIONS AS THERE ARE AN ESTIMATED TEN WIRES THAT RUN IN PARALLEL IN THIS HARNESS AND ALL WIRE EXCEPT TWO HAD MULTIPLE INSULATION DEFECTS THAT POTENTIALLY RESULTING IN SHORTS. THIS IS A DEFINITE SAFETY ISSUE AND ALL HARNESSES THAT HAVE THE POTENTIAL FOR THIS TYPE OF FAILURE SHOULD BE REPLACED OR REPAIRED IMMEDIATELY. *TR

HAVE HAD COMPLETE ELECTRICAL FAILURE 3 TIMES WITH MY CAR FIRST TIME WAS AT 12,500 MILES, 2ND. 61 MILES LATER AND LAST WEEK WITH 20,500 MILES. EACH TIME DEALERSHIP TOLD ME THAT MY ALTERNATOR HAD GONE BAD. WAYNE AKERS FORD, LAKE WORTH, FL PUT IN THE FIRST TWO REPLACEMENT ALTERNATORS AND CAR IS NOW AT AN INDEPENDENT MECHANIC FOR A SECOND OPINION. *TR

REAR PASSENGER DOOR WON'T LOCK. MY WIFE "APPARENTLY" LOCKED THE CAR AT WORK IN AN OPEN PARKING LOT AND LATER WENT TO RETRIEVE SOMETHING FROM BACK SEAT TO FIND THAT THE DOOR WAS NOT LOCKED. NO INDICATION WAS GIVEN WHEN LOCKING THE CAR USING THE REMOTE LOCKING MECHANISM THAT THERE IS AN ISSUE BECAUSE IT SOUNDS LIKE IT IS FULLY LOCKED. IT ISN'T. I CHECKED THE ISSUE BY HAVING HER DRIVE UP AND DOWN THE ROAD MAKING SURE SHE THOUGHT ALL DOORS WERE LOCKED AND WHILE SHE HAD STOPPED, I OPENED THE REAR PASSENGER DOOR AND JUMPED IN THE BACK SEAT MUCH AS AN ATTACKER OR CARJACKER MIGHT DO. THIS IS A SAFETY ISSUE BECAUSE ANYONE CAN JUMP IN THE BACK OF THE CAR WHILE STOPPED AT TRAFFIC LIGHTS EVEN THOUGH THE OWNER MAY THINK THAT THE CAR IS SECURELY LOCKED, IT JUST MIGHT NOT BE. BEWARE AND CHECK ALL YOUR DOOR LOCKS ON A REGULAR BASIS AS THIS SEEMS TO BE REPORTED ON MULTIPLE OCCASIONS ON FORD FOCUS INTERNET FORUMS. TO THIS DATE, WE HAVE NO IDEA WHEN THE ACTUAL LOCKING MECHANISM FAILED AS IT IS NOT SOMETHING WE, OR ANY OTHER DRIVER WOULD CHECK ON A REGULAR BASIS. *TR

THE REAR PASSENGER DOOR DOES NOT LOCK ON OUR 2006 FORD FOCUS ZX4. IT OPENS AND CLOSES CORRECTLY. IT JUST WON'T LOCK, EVEN WITH CHILD LOCK ON. ALL OTHER DOORS OPERATE CORRECTLY. THIS DOOR OPERATED CORRECTLY BEFORE. WE HEARD FORD HAD A PROBLEM WITH THIS ON PREVIOUS FOCUS MODELS. CUT OFF WAS THE YEAR 2005 FOR THIS PROBLEM. WE FEEL UNSAFE FROM THIS PROBLEM BECAUSE WE TRANSPORT OUR SENIOR MOMS TO SHOPPING TRIPS. *TR

MY 2006 FOCUS ZX5 STARTED INTERMITTANTLY UNLOCKING THE HATCHBACK WHEN I STEPPED ON THE BRAKE PEDAL. I WAS DRIVING ON THE FREEWAY WHEN I PULLED OVER TO TAKE A PHONE CALL. I LEFT THE CAR IN DRIVE WITH MY FOOT ON THE BRAKE PEDAL. AFTER ABOUT 5 MINUTES I COMPLETED MY CALL AND MERGED BACK INTO TRAFFIC. WHEN I REACHED MY DESTINATION I PARKED MY CAR AND GOT OUT. I RETURNED TO MY CAR, STARTED THE ENGINE AND COULD NOT GET THE GEAR SHIFT OUT OF PARK. I HAD SOMEONE WATCH MY BRAKE LIGHTS WHILE I STEPPED ON THE BRAKE PEDAL. THE LIGHTS DID NOT WORK AND I FOUND THE FUSE FOR THE BRAKE LIGHTS WAS BAD. I TOOK A FUSE FROM ANOTHER CIRCUIT AND GOT HOME. I HAD BEEN DRIVING FOR 20 MILES WITH NO BRAKE LIGHTS. I TOOK THE CAR TO A FORD DEALER AND THEY FOUND A BROKEN WIRE AND 6 OTHER WIRES WITH CRACKING INSULATION. THEY SAID THEY FIXED THE PROBLEM AND THE CAR WORKED OK. IN JANUARY OF 2013 I NOTICED AFTER CLOSING MY HATCHBACK AND GETTING IN THE CAR MY THE "DOOR OPEN" INDICATOR STAYED ON. I CHECKED ALL DOORS AND THE HATCHBACK AND ALL WERE CLOSED. AFTER FINDING OUT ON-LINE THAT THERE HAVE BEEN COMPLAINTS ABOUT THE FOCUS WIRING SINCE THE 2000 MODELS, I TOOK OFF THE CARBODY END OF THE RUBBER CONDUIT TO THE HATCHBACK. I FOUND A BROKEN WIRE (FIXED MY DOOR OPEN INDICATOR PROBLEM WHEN I REPAIRED IT) AND 6 WIRES WITH BLACK ELECTICAL TAPE ON THEM. I FOUND THAT THE ELECTRICAL TAPE IS WEARING THROUGH JUST LIKE THE WIRE INSULATION DID. I CONTACTED THE DEALER AND COMPLAINED ABOUT THE HALF ASS REPAIR THEY DID. THE SERVICE MANAGER STATED THAT WAS THE REPAIR AUTHORIZED BY THE EXTENDED WARRANTY. I ASKED WHAT REPAIR WAS AUTHORIZED BY THE ORIGINAL WARRENTY AND HE SAID THE SAME REPAIR. FORD HAS KNOWN THAT THIS HARNESS IS A PROBLEM SINCE 2000 AND I WAS TOLD THEY ARE STILL USING THE WIRING IN THEIR 2013'S. WHY HAVEN'T THESE CARS BEEN RECALLED! *TR

DRIVERS SIDE REAR DOOR ELECTRIC DOOR LOCK WILL NOT LOCK. THE SAME THING HAPPENED ON THE PASSENGERS SIDE ABOUT TWO YEARS AGO. *TR

THE TRUNK LIGHT WOULD NOT COME ON WHEN TRUNK WAS OPENED (REPLACING THE BULB DIDN'T HELP). LATER, THE 'DOOR OPEN' DASH LIGHT CAME ON AND STAYED ON. THE ELECTRIC TRUNK OPEN BUTTON SOMETIMES WOULD NOT OPEN TRUNK. A BIT OF TROUBLESHOOTING WITH A VOM AT THE TRUNK LIGHT POINTED TO AN ELECTRICAL PROBLEM (A VOLTAGE DROP WHEN A NEW BULB WAS PLACED IN THE TRUNK LIGHT SOCKET). TURNS OUT THAT THE WIRING BUNDLE (CONTAINING SIX INDIVIDUAL MULTISTRAND WIRE LINES) HAD FIVE OF THE WIRES LINES FATIGUED APART , BREAKING THE FIVE CIRCUITS. THE WIRE LINES WERE SOMETIMES MAKING INTERMITTENT CONTACT WHEN THE TRUNK WAS OPENED AND CLOSED, NOT NECESSARILY WITH THE MATCHING WIRE LINE. I COULD HEAR NOISE AS THE WIRES WERE MOVED PAST EACH OTHER (NOT SURE IF THIS WAS JUST PHYSICAL SCRATCHING OR, WORSE, ELECTRICAL SPARKING). SINCE I SOMETIMES CARRY A GASOLINE CONTAINER IN THE TRUNK (LAWNMOWER GAS CONTAINER RETURNING FROM GAS STATION), I FEEL THAT THE DESIGN OF THIS WIRING TO THE TRUNK IS FAULTY AND COULD LEAD TO A FIRE UNDER THE RIGHT (AND NOT UNCOMMON) CIRCUMSTANCES. AFTER SEVERAL CONVERSATIONS WITH THE FORD MOTOR CO., A REPAIR WAS MADE (I PARTIALLY PAID FOR THE REPAIR) WHERE THE WIRING WAS REPLACED. I AM NOT SURE IF THE REPAIR WILL BE ANY SAFER THAN THE ORIGINAL DESIGN; HENCE THIS COMPLAINT WITH THE HOPE THAT A SAFER DESIGN (E.G., ONE WITHOUT SUCH A TIGHT RADIUS OF BEND) COULD DEVELOPED AND RETROFITTED INTO THIS CAR. *TR

KEY STICKS IN IGNITION. *TR

KEY STUCK IN IGNITION. *TR

THE KEY CANNOT BE REMOVED FROM THE IGNITION. THE CAR DOES STILL START AND DRIVE FINE, BUT NO MATTER WHAT I DO, THE KEY WILL NOT COME OUT. IT MIGHT JUST BE FOR A FEW HOURS BUT MORE SO IT HAPPENS FOR AT LEAST 24 HOURS. IT SEEMS TO ALSO HAPPEN AFTER THE CAR HAS BEEN USED ON A WARM DAY, SO IT WILL FIRST GET STUCK THAT EVENING WHEN THE CAR IS PUT INTO USE AGAIN. IT IS COSTING $285 TO GET IT FIXED BECAUSE IT NEEDS A NEW IGNITION. *TR

KEYS ARE STUCK IN THE IGNITION. *TR

IGNITION LOCK CYLINDER FAILURE ON A 2006 FORD FOCUS. THE KEY AT ONE TIME COULDN'T TURN THE IGNITION...NOW CAN'T REMOVE KEY FROM LOCK CYLINDER WITHOUT HAVING LOCKSMITH OR DEALERSHIP DO IT AT SUBSTANTIAL COST TO MYSELF. APPARENTLY THIS IS A VERY COMMON OCCURRENCE AND IS WAY MORE WIDESPREAD THEN ANY LITTLE RECALL THAT TOYOTA HAS HAD...WE NEED A RECALL OR A CLASS ACTION LAWSUIT. I*TR

KEY STUCK IN IGNITION. WAS TOLD BY DEALER MOST COMMON PROBLEM WITH FORD FOCUS. LOCK ASSEMBLY REPLACED ON 04/0210 AND KEY STUCK IN IGNITION (NEW PART) 04/23/10. *TR

TL* THE CONTACT OWNS A 2006 FORD FOCUS. THE CONTACT STATED THAT AFTER TURNING THE VEHICLE OFF, SHE COULD NOT REMOVE THE KEY FROM THE IGNITION. THE VEHICLE WAS TAKEN TO THE DEALERSHIP BUT NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 64,000. THE VIN WAS UNAVAILABLE.

2006 FORD FOCUS ZX4 YELLOW AIRBAG LIGHT ON DASH WENT ON AND REMAINED ON. DIAGNOSED AS HIGH RESISTANCE IN WIRING SYSTEM,MAKES SAFETY-AIRBAG- SYSTEM INOPERATIVE. DANGEROUS. REPAIRED BY FORD DEALER UNDER 5 YEAR WARRANTY BY REPLACEMENT OF CLOCKSPRING{WIRING PLASTICTAPE} IN STEERING WHEEL HUB. TO DETERMINE SEVERITY OF PROBLEM CHECK FORD REPLACEMENT PARTS RECORDS. *TR

2006 FORD FOCUS KEY GETS STUCK IN IGNITION....THIS HAS HAPPENED NUMEROUS TIMES......HAVE HAD TO SIT AND JIGGLE KEY BACK AND FORTH IN ORDER TO GET IT OUT OF IGNITION. *TR

2006 FORD FOCUS CONTINUOUSLY GETS THE KEY STUCK IN THE IGNITION IT SEEMS IT IS DUE TO THE GEAR SHIFT NOT LOCKING IN PLACE. I HAVE HAD TO LEAVE THE KEY IN THE IGNITION ON A FEW OF THOSE OCCASIONS AND PLACE THE EMERGENCY BRAKE ON. *TR

I HAVE A 2006 FORD FOCUS. THE KEY HAS BEEN CONSTANTLY GETTING LOCKED INTO THE IGNITION. YOU CANNOT TAKE IT OUT AND EVENTUALLY MY KEY BROKE. THIS HAPPENED MORE THAN ONCE. I RESEARCHED AND FOUND OUT THAT A LOT OF OTHER FORD FOCUS CUSTOMERS WERE EXPERIENCING THE SAME THING! *TR

TL* THE CONTACT OWNS A 2006 FORD FOCUS. THE CONTACT STATED THAT HE CAN NOT REMOVE THE KEY FROM THE IGNITION. THE DEALER WAS CONTACTED. UPON CONTACT A TECHNICIAN STATED THAT HE WOULD HAVE TO PAY $300.00 TO REPLACE THE IGNITION SWITCH. NO REPAIRS WERE MADE. THE MANUFACTURER WAS CONTACTED, BUT NO ASSISTANCE WAS PROVIDED BECAUSE THE WARRANTY EXPIRED. THE FAILURE AND CURRENT MILEAGES WERE 32000.

ABOUT HALF TO 3/4 OF THE TIME MY IGNITION WILL NOT START ON MY FORD FOCUS. THIS PRESENTS A MAJOR PROBLEM WHEN I AM AWAY FROM THE HOME AND MY CAR WILL NOT START DUE TO IGNITION SWITCH PROBLEMS. AT TIMES I HAVE TO TURN THE KEY 20-50 TIMES FOR THE CAR TO COME ON. I AM 76 YEARS OLD AND THIS IS A MAJOR ISSUE FOR ME. I DON'T WANT TO EVEN DRIVE MY CAR FOR FEAR THAT I WILL NOT BE ABLE TO RE-START IT. *TR

THE FUSE FOR THE RUNNING LAMPS KEPT BLOWING. A FEW DAYS LATER I SMELT A BURNING SMELL, PULLED OVER, TURNED OFF THE CAR, REMOVED KEY, BUT CAR WAS STILL RUNNING. A FEW DAYS LATER, BATTERY LIGHT KEPT FLASHING, TURNS OUT, THE ALTERNATOR WAS FRIED. TOOK IT TO FORD, WAS TOLD THERE WAS NOTHING THEY COULD DO BECAUSE MY POWERTRAIN WARRANTY DOES NOT COVER ELECTRICAL WORK. TOOK IT TO AN ELECTRICIAN, WAS TOLD A FEW WIRES TOUCHED METAL AND FUSED TOGETHER AND BURNT ALL THE WAY BACK TO THE FIREWALL. WHEN YOU LOOK AT THE WIRES, THERE IS METAL SITTING UNDER THEM....THERE ARE NO CLIPS TO HELP HOLD THE WIRES AWAY FROM THE METAL. THERE IS SOME FORM OF PROTECTION ON THE WIRES, I DESCRIBE IT AS A FOAM...BUT ITS WORN THROUGH. WHEN I ASKED HIM HOW THIS COULD HAVE HAPPENED, HE REPLIED WITH "GOING OVER BUMPS, RAILROAD TRACKS, OR HITTING A POTHOLE. HE ALSO TOLD ME IT WAS A FIRE HAZARD. AS A CONSEQUENCE TO THIS, MY CAR IS NOW JUST SITTING, AND I WILL NOT DRIVE IT WITH IT BEING LABELED A FIRE HAZARD. NOTHING WAS DONE TO CORRECT THE FAILURE. *TR

MY KEY BECAME LOCKED IN THE IGNITION AND COULD NOT BE REMOVED WHILE ON VACATION. I COULD TURN THE CAR ON AND DRIVE IT BUT COULD NOT REMOVE IT, THEREFORE HAD TO END VACATION EARLY TO TAKE CARE TO LOCAL DEALERSHIP. THE CAR WAS 75 DAYS OUT OF WARRANTY AND I HAD NO CHOICE BUT TO FIX THIS- COSTING ME OVER $300.00. THEY (FORD) SAID IT WAS THE SAFETY SWITCH IN THE SHIFTER. VEHICLE HAD A LITTLE OVER 18,000 MILES. THE CAR WAS PURCHASED USED FROM AN ESTATE OF A LADY WHO HAD ONLY DRIVEN 8,000 MILES. *TR

THE KEY HAS BECOME STUCK IN THE IGNITION AND WILL NOT COME OUT BECAUSE THE CAR DOES NOT THINK IT IS PARK EVEN THOUGH IT IS PARKED. THE DEALER INSIST THAT THERE WAS A SODA SPILLED ON THE IGNITION AND THIS RESULTED IN THE CHIP IN THE IGNITION SHORTING OUT. THIS KEY HAS BEEN STUCK SINCE MAY AND HAS ONLY COME OUT OF THE IGNITION ONCE SINCE THEN! THE DEALERSHIP SAYS THAT THEY HAVE TO ORDER THIS PART AND CHANGE OUT THE IGNITION TO FIX IT. SO FAR, THIS PROBLEM HAS NOT BEEN RESOLVED AND WE CANNOT LOCK ALL OF THE DOORS BECAUSE OF THIS. *TR

MY 2006 FORD FOCUS HATCHBACK DEVELOPED FRAYED WIRES IN THE HATCHBACK HARNESS THAT CAUSED A SHORT SO THAT THE DASHBOARD LIGHTS DO NOT COME ON AS THEY SHOULD WHEN THE EXTERIOR LIGHTS ARE TURNED ON UNLESS THE REAR WINDOW DEFROSTER IS ALSO TURNED ON. DESPITE BEING COVERED BY FORD'S 'EXTRA CARE' EXTENDED SERVICE PLAN THAT IS SUPPOSED TO COVER WIRING HARNESSES, FORD IS REFUSING TO PAY FOR THE REPAIR. *TR

I HAVE A 2006 FORD FOCUS AND MY KEY IS STUCK IN THE IGNITION. I HAVE CONTACTED THE DEALERSHIP AND FORD CUSTOMER SERVICE AND THEY WERE NO HELP. THE IS A COMMON PROBLEM WITH THE FORD FOCUS BUT THEY WON'T ISSUE A RECALL ON IT. THIS IS A SAFETY ISSUE- MY CAR IS AT RISK OF BEING STOLEN AND I DON'T HAVE THE 400.00 THEY ASK TO REPAIR THIS. *TR

THE KEY GETS STUCK IN THE IGNITION AND WON'T COME OUT. I HAVE TO REMOVE ONE OF THE BATTERY CABLE FROM THE BATTERY, REMOVE THE KEY FROM THE IGNITION, THEN REPLACE THE BATTERY CABLE BACK. THIS HAS HAPPEN MORE THAN ONCE. *TR

ABOUT 2 MONTHS AGO, MY KEY GOT STUCK IN THE IGNITION. I COULD START AND DRIVE THE CAR, BUT NOT GET THE KEY. I DROVE TO A FORD DEALER AND THE PERSON HAD NO TROUBLE GETTING MY KEY OUT. THIS WAS AT 34,000 MILES. NOW, AT 36,500 MILES, THE SAME THING HAPPENED. I AM TAKING TO A FORD DEALER AND THEY BETTER REPAIR UNDER THE 3/36,000 WARRANTY. *TR

2006 FORD FOCUS ZX4 MODEL SES. IGNITION KEY STUCK IN IGNITION. CAR WILL START BUT KEY WILL NOT COME OUT. CAR CAN BE PUT INTO GEAR WITH SWITCH IN OFF POSITION. SAFETY PROBLEM CAR HAS 35,000 MILES. DEALER DID WARRANTY REPAIR TODAY - WE ARE PICKING THE CAR UP TONIGHT SO I DON'T KNOW THE QUALITY OF THE REPAIR YET. *TR

2006 FORD FOCUS ZX3 SE REAR HATCH DOOR WIRING ---BROKEN WIRES AND WIRE INSULATION. FIRST STARTED WITH PLATE LIGHTS BLOWING OUT. NOW ALL PARKING LIGHTS,TAILLIGHTS AND DASH LIGHTS ARE OUT---BLOWING FUSES!!! OUT OF CURIOSITY I PULLED DOWN THE RUBBER BOOT OF THE WIRE HARNESS OF THE REAR HATCH DOOR AND FOUND BROKEN WIRES AND INSULATION. WENT TO FORD WEBSITE TO SEE IF THERE WAS A RECALL ON THIS, FOUND NO RECALLS AT ALL FOR MY CAR!!!!! UPON FURTHER RESEARCH FOUND THAT THERE IS A RECALL FOR THIS VERY PROBLEM FROM 8 YEARS AGO NOV - DEC OF 2000!!!!!!!!! *TR

I HAVE A 2006 FORD FOCUS AND THE KEY KEEPS GETTING STUCK INSIDE OF THE IGNITION WITHOUT ANY WARNING. IT WILL STAY STUCK FOR A FEW WEEKS AND THEN ONE DAY IT WILL JUST COME OUT. *TR

TL*THE CONTACT OWNS A 2006 FORD FOCUS. THE CONTACT STATED THAT HE WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. IN ADDITION, THE GEAR SHIFT INDICATOR WOULD ENGAGE WITHOUT DEPRESSING THE BRAKE. AS OF FEBRUARY 14, 2008, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 430,000.

ON FRIDAY THE IGNITION ON MY CAR DID NOT IMMEDIATELY TURN. I DIDN'T THINK ANYTHING OF IT AT THE TIME. SATURDAY AFTERNOON IT REFUSED TO TURN AT ALL. THE KEY WOULD NOT TURN IN THE IGNITION LOCK CYLINDER. IT FIT AND WAS REMOVABLE BUT JUST WOULDN'T TURN. THE CAR WOULD NOT THEREFORE, START. I WAS LEFT STRANDED IN A PUBLIC PLACE PREGNANT WITH MY 3 YEAR OLD CHILD FOR SO LONG DRUG DEALERS STARTED SHOWING UP. I HAD TO PAY FOR A TOW TRUCK WHEN IT FINALLY ARRIVED. THIS IS IN A 2003 FORD FOCUS ZTW WAGON. IT IS 3 YEARS OLD WITH 50,000 MILES ON IT. I SPENT ALL DAY TUESDAY ON THE PHONE SPEAKING WITH VARIOUS LEVELS OF MECHANICS AND MANAGEMENT. THEY ALL AGREED THAT FORD IS NOT TAKING ANY RESPONSIBILITY FOR THIS DEFECT. ONE OPERATOR DID NOT EVEN RECORD MY PHONE CALL. FORD IS RECALLING DIFFERENT MODEL VEHICLES FOR IGNITION CYLINDER PROBLEMS. THEY HAVE NOT SET UP ANY PUBLIC REIMBURSEMENT OR REPAIR FOR THIS SPECIFIC YEAR AND MODEL VEHICLE. I HAD TO PAY A PRIVATE LOCKSMITH TO COME TO MY HOUSE AND BUILD A NEW CYLINDER AROUND MY KEY BECAUSE I COULD NOT AFFORD TO HAVE THE CAR TOWED AGAIN AND PAY THE EXORBANT DEALER PRICE. I WAS WITHOUT MY VEHICLE FOR SATURDAY, SUNDAY, MONDAY AND THE TUESDAY SURROUNDING LABOR DAY WEEKEND. THE PRIVATE LOCKSMITH REPAIRED IT WEDNESDAY IN A TIMELY MANNER. I HAVE NOT BEEN OFFERED TOWING REIMBURSEMENT, A RENTAL VEHICLE, A REPAIR REIMBURSEMENT OR AN APOLOGY. THE OLD PART (WHAT WAS LEFT AFTER DRILLING IT OUT PER FORD INSTRUCTIONS) WAS NOT SAVED. *NM

ON FOUR SEPARATE OCCASIONS MY CAR, WITHOUT FOREWARNING, CUT OFF WHILE IN MOTION AND AT VARIOUS RATES OF SPEED. THE CAR IS NOW BEING SERVICED FOR THIS PROBLEM FOR THE THIRD TIME IN THE TWO MONTHS THAT I HAVE HAD IT. THE CAR ALSO HAS A PROBLEM WITH NOT STARTING, FOR NO APPARENT REASON. *JB

I PURCHASED A 2006 FORD FOCUS ON 12/3/05, IT HAD 4 MILES ON IT WHEN I DROVE OUT OF THE DEALERSHIP. ON THURSDAY MAY 3, 2006, IT CAUGHT FIRE IN MY CARPORT. THE MILEAGE IS BETWEEN 2,000-3,000 MILES, I BELIEVE. I ARRIVED HOME FROM A MEETING AT A LOCAL BANK, HAVING DRIVEN APPROXIMATELY 2 MILES. I PARKED THE CAR IN THE CARPORT, TURNED OFF THE ENGINE AND ENTERED THE HOUSE. I DID NOT NOTICE ANY STRANGE NOISES OR ODORS. MY HUSBAND ARRIVED HOME ABOUT 15-20 MINUTES LATER. HE BEGAN TOOTING THE HORN ON HIS VEHICLE TO GET MY ATTENTION. WHEN I OPENED THE DOOR, HE YELLED "GET YOUR KEYS." I COULD SEE FLAMES UNDER MY CAR AND SMOKE SEEPING OUT THE SIDES OF THE HOOD. I THREW HIM THE KEYS AND RAN FOR THE FIRE EXTINGUISHER. HE ENTERED MY FOCUS GOT THE ENGINE STARTED AND BACKED THE VEHICLE OUT OF THE CARPORT AND AWAY FROM THE HOUSE. AS HE BACKED UP THE VEHICLE, FLAMING PARTS BEGAN FALLING OUT FROM UNDER THE CAR ONTO THE CONCRETE FLOOR. HE GOT THE CAR BACKED UP ABOUT 10 FEET AND THE ENGINE QUIT AND WOULD NOT RESTART. HE EXITED THE CAR AND TRIED TO OPEN THE HOOD. THE HOOD WAS VERY HOT TO THE TOUCH BUT HE GOT IT OPENED. THE FLAMES WERE ABOUT A FOOT HIGH AT THE BACK OF THE ENGINE AREA ON THE LEFT SIDE. WE WERE ABLE TO PUT OUT THE FLAMES WITH THE EXTINGUISHER. WE THEN EXTINGUISHED THE FLAMES ON THE PIECES THAT WERE LYING ON THE CARPORT FLOOR. BOTH CONTINUED TO SMOKE FOR SOME TIME BUT THE FIRE DID NOT RE-IGNITE. WHEN THE SMOKE CLEARED AND WE FELT IT SAFE TO APPROACH THE VEHICLE, WE COULD SEE THE CHARRED REMAINS AND MELTED PARTS. IN RETROSPECT I REMEMBER ON TWO OCCASIONS SEEING THE BATTERY ICON LIGHTED ON THE DASH WHILE A SAT OUTSIDE MY OFFICE WAITING FOR THE BANK TO OPEN WITH THE CAR IDLING AND THE RADIO ON. BOTH TIMES I REVVED THE ENGINE AND THE LIGHT WENT OUT. *NM