2023 Volkswagen Taos Engine Problems

Your engine has a failing head gasket, which is causing your car to lose combustion and become unsafe to drive. The check engine light has been on for 5 months, and your dealer hasn't been able to fix the problem yet. Fixing this will require the dealer to replace the head gasket and likely perform related engine work.

Your engine required service on the cylinder head, and both the cylinder head gaskets and timing belt were replaced. This suggests there was a significant issue with your engine's sealing or timing system that needed professional repair.

Your engine's head gasket failed at just 26,500 miles, which your VW dealership discovered during a service visit. A failed head gasket can allow coolant and oil to mix, potentially leading to engine overheating or damage while driving. The repair will involve removing the cylinder head and replacing the gasket.

Your car's head gasket is leaking, causing coolant to mix with your engine oil. You'll notice the low coolant warning light coming on repeatedly. The dealer has refused to acknowledge or address this problem. Fixing this will require the dealer or a mechanic to replace the head gasket and reseal the engine.

The contact owns a 2023 Volkswagen Taos. The contact stated that while operating the vehicle, the check engine warning light illuminated. The vehicle was taken to the local dealer, who diagnosed that there was coolant intrusion into the head gasket. The head gasket was replaced, and the vehicle was repaired. Later, while driving 55 MPH, the message "Transmission Failure" was displayed and the transmission shifted to D2, causing the vehicle to decelerate to 25 MPH. The vehicle was parked, and after restarting the vehicle, the vehicle operated normally. The vehicle was later taken to the local dealer, who diagnosed that the Medtronic transmission had failed and needed to be replaced; however, parts were on back order. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 10,185.

unknown head gasket, went out at 22,000 miles Low coolant light High engine temperatures Overheating Empty coolant reservoir Smell of coolant Coolant residue on the engine block Most of the head gasket failures also occurred at relatively low miles.

3 times in the past year including today, the car has completely turned off while in drive at a red light or stop sign. It is not the auto start/stop, it simply completely shuts off the car and when I take my foot off the break the car says “shift gear into park and manually restart car” this has almost caused an accident every time and is a safety issue. I reported to dealer, they’ve heard of this before but can’t replicate or find issue. It is not safe for the cars engine to shut off while in drive and have to stop in the middle of road and shift gears and manually restart car. Major safety issue

Hazard warning light came on for low coolant on 1/18/2025. Almost empty of coolant. Bought VW coolant and filled. Brought in to dealer I bought the car from, told it was the head gasket leaking (after $170 charge). Quoted me an estimate of almost $4000. Told me it was not under warranty- my car has a little over 56,000. Warranty ends at 50,000. Dealer told me this is a known issue.

Vehicle displayed instances of overheating but was told by dealership it wasn't a big issue and the vehicle was safe to drive. I took the vehicle to the dealership for scheduled maintenance and when I returned to pick up the vehicle I was told that coolant was leaking into the oil and the head gasket was defective. The service desk representative stated the head gasket is a known issue in the 2022-23 models. The engine will need to be taken out of the vehicle, taken apart, and a new gasket installed. I was also told this issue would most likely happen again due to the design of the gasket. Parts are on order and the dealership has the vehicle as it's not safe to drive prior to repairs being made.

On August 4th, 2024 Volkswagen Taos coolant reservoir at 17,348 miles was nearly empty. Went to closest dealership, which could not set appointment to look at until October 21. Every couple hundred of miles, I have had to refill the coolant level. The VW Taos was finally able to be diagnosed with a head gasket failure on October 21, 2024 with 22,359 miles. The parts and fix are a couple of months out, with no current ETA. Was given back vehicle to drive in the meantime. This is a major safety issue, as the gasket could completely fail at any time. This is also causing premature wear on the engine, as coolant will be leaking into the oil. The manufacture, Volkswagen, was contacted and unable to offer any assistance and told to keep driving in the meantime, since the dealer gave me back the vehicle.

I was attempting to turn left across on coming traffic, plenty of room safety wise. The engine lagged and would not speed up. Pedal almost the the floor and I was going maybe 5 mph, the car was barley rolling and had the two cars coming not been paying attention I would have been tboned. Once through the intersection the vehicle aggressively sped up. Took the vehicle into the dealership they had it 28 days, confirmed they felt the engine lag and ran diagnostics and couldn’t find anything wrong but whatever they did fixed it for about 3 weeks and now the engine is lagging again.

Coolant leak and head gasket problem after only 20,000 miles. Common issue others have reported.

I bought this vehicle in April of 2023, brand new with 300 miles on it. The dealership then sold to a different dealership in June of 2023. In November/December of 2023, a light on my dash came on saying that my antifreeze was low. I opened up the hood and there was absolutely NO antifreeze in it. I called my dealership, they couldn't get me in until January 2024. So I filled it up with antifreeze and made it to my appointment in early January. The dealership told me that my previous dealership hadn't filled up my antifreeze all the way and that I had just burned that much since April. They topped it off and "checked all the lines". Then in April of 2024, the antifreeze light came on AGAIN. Not even 4 months later. I go check and AGAIN my antifreeze is completely EMPTY. NOT EVEN 4 MONTHS LATER! So I call the dealership and tell them what's going on. They get me in and then call me to tell me my head-gasket is blown. On my brand new car?!?!? So the dealership has now had my dealership since May 5th, 2024. It is now June 5th, 2024 and they are still waiting on parts. The car as of May 5th, 2024 had 12,000 miles on it. There were no signs of my antifreeze leaking, I park it in the garage everyday, nothing on the floor of the garage. The only thing that made me aware was the light coming on and screaming at me that I had no antifreeze.

Red central warning light and coolant/temp light came on when leaving home. Blown head gasket at 10,150 miles. Car had no coolant, had to be towed. Dealer agress it's the head gasket. No ETA on parts at this time.

Two months ago I noticed an issue with my 2023 VW Taos. VW topped off the fluids and told me to stop back in if it happened again. Three weeks later I was 200 miles from home and it happened again. I stopped in another VW dealer and they topped off the fluids and said if it happened again to bring it in. Today, December 15, 2023 I take my vehicle to the VW dealer with ~22,000 miles and the service advisor and mechanic come over to me and said "we are not allowing you to leave in your car today". I asked why and they said the head gasket is gone and the engine needs to be taken apart. They said corporate requires pictures of this because it is a known problem with this engine between 20K and 30K miles the engine head gasket cracks, coolant light enables, and the engine can blow. They gave me a loaner and said plan to be in the car for a few months as we have a back order on parts, corporate needs to review this, and it will take time as we must remove the engine to repair the gaskets that are in between the upper and lower sections. I come home and log into a VW Taos forum online to find 6,000 people reporting this same issue in the US and Canada. This has not been recalled, but it is obvious from the forum that models between 2019 and 2023 with this specific engine type has this issue and it is well known to VW but they're not recalling it. I don't want a car after the engine has come out and gone back in. They need to take my car back and keep it! How can this be allowed in America?

Engine cooling system has lost coolant. Very concerned because it is not leaking or evaporating - has entered the engine.

I had just purchased this car- it was my first day driving it. I drove it from the dealer to my home and then out to dinner with no problems. I should note the each time I started the car I turned off the "Stop/Start" feature. On our way home from dinner I was stopped at a red light and all of a sudden the engine shut off and a messaged displayed saying "Please Start Engine Manually". I was shocked, but put my car in park and was able to start it back up. I should note that the radio continued to work and the air continued to blow (even though it was no longer cold). I started driving and was less than 1/4 mile from my turn, but as I was approaching the car stalled again. This time while I was driving! Thankfully I was able to safely glide into the shopping center and park the car. I tried putting it back in park and starting it up again a few times with no luck. I should note that it wasn't like the engine was trying to turn over, there was nothing happening at all. I exited the car for a minute and then got back in to try again and thankfully it started up this time. I live right down the street from the shopping center so I went ahead and drove it home. Someone from the VW dealer picked the car up the next day because I refused to drive it again- my kids are always in the car with me. Since then I've researched this and found many more accounts of similar things happening to other Taos drivers. The dealer has found no error codes and they are trying to tell me it was "Low Battery Voltage", but that just doesn't make any sense considering how things happened. I'm now in contact with VW to see if they can help at all. I cannot drive this car with the possibility of stalling again. I won't put my kids at risk. The car is still at the dealership as I'm waiting to hear back from VW.

Vehicle is 6 months old, 4747 miles, stalled going uphill at 10mph. Upon attempted restart, smoke billowed out of the exhaust and engine compartment. Contacted VW Customer Service and was towed to VW dealership. Turbo failed and caused a laundry list of parts to fail. Parts are out till September.