2001 Volkswagen Jetta Fuel System Problems

TL* THE CONTACT OWNS A 2001 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THERE WAS A STRONG ABNORMAL ODOR OF FUEL COMING FROM THE REAR INTERIOR SEAT AREA. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS AWAITING DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

I DROVE THROUGH LITTLE STAGNANT WATER ABOUT 6 TO 8 INCHES ON PERIMETER RD. WEST. AFTER DRIVING THROUGH THE WATER, THE CAR BEGAN RUNNING AND IDLING ROUGHLY. THE CAR EVENTUALLY STALLED ON PERIMETER RD. WEST, IMMEDIATELY SOUTH OF THE BLUE PLAINS TUNNEL SITE. A PASSING DRIVER HONKED AND YELLED TO GET OUT OF THE CAR BECAUSE IT WAS ON FIRE. WE WITNESSED FLAMES COMING FROM THE UNDERSIDE OF THE VEHICLE. *TR

MY CAR SMELLS LIKE GAS SO BAD THAT I GET A HEADACHE. DEALERSHIP SAYS THEY DO NOT KNOW WHAT IS WRONG. NO INCIDENT BUT I KNOW MOST VOLKSWAGEN VEHICLES HAVE THIS PROBLEM. THE GAS SMELL MUST BE TOXIC, SO THIS SEEMS LIKE A SAFETY PROBLEM. *TR

TL* THE CONTACT OWNS A 2001 VOLKSWAGEN GOLF. WHEN DRIVING AT VARIOUS SPEEDS, THE CONTACT WOULD NOTICE A STRONG GASOLINE ODOR COMING FROM THE REAR INTERIOR SEAT AREA. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE FUEL PUMP WAS REPLACED. THE FAILURE AND CURRENT MILEAGES WERE 95,000.

THE CHECK ENGINE LIGHT CAME ON AND EVERY TIME YOU FILL THE GAS TANK UP ALL THE WAY, FUEL SPILLS ALL OVER THE PLACE. THE ENGINE LIGHT WAS DIAGNOSED AT THE MECHANIC WHO STATED THE LEAK DETECTION PUMP NEEDED TO BE REPLACED. I CONTACTED THE VEHICLE DEALER TO OBTAIN THE PUMP IN EARLY AUGUST 2009. THEY DID NOT HAVE ONE IN STOCK SO I PLACED AN ORDER FOR ONE. THE DEALER SAID THEY PUT A RUSH ORDER ON IT; HOWEVER, IT IS NOW DECEMBER 2009, THE PART REMAINS ON BACKORDER ACCORDING TO THE DEALER AND I AM UNABLE TO RESOLVE THE PUMP FAILURE. WE ARE STILL UNABLE TO FILL THE FUEL TANK WITH GASOLINE POURING OUT ALL OVER THE GROUND. *TR

MY 2001 VOLKSWAGEN JETTA HAS ALWAYS HAD A BURNING CRAYON SMELL AND HAS BEEN GETTING WORSE. I THOUGHT IT WAS ONLY MY CAR UNTIL I LOOKED ONLINE AND SAW THAT THERE ARE MANY COMPLAINTS ON DIFFERENT FORUMS ABOUT THE SAME THING. THE MAIN CONCERN IS IF THIS SMELL IS TOXIC. ON DAYS THAT THE SMELL IS WORSE I TEND TO GET A HEADACHE. PLEASE HELP. *TR

SMELL OF GASOLINE INSIDE VEHICLE FOR 2-3 DAYS. NOTICED GAS MILEAGE WAS EXTREMELY BAD - HAD TRAVELED 100 MILES AND USED 1/2 TANK OF GAS. TOOK VEHICLE IN TO DEALER FOR DIAGNOSTIC. DEALER STATED FUEL LINE WAS COMPLETELY CORRODED, FUEL PUMP TO SENDING UNIT - GAS LEAKED INTO CAR'S TRUNK & REAR SEAT CARPETS. DEALER REPLACED FUEL PUMP, FILTER AND CLEANED CARPET - TOTAL CHARGE OF JUST OVER $1300. REQUESTED OLD PARTS BUT DEALER CLAIMED THEY WERE THROWN AWAY. *TR

2001 VW JETTA. ENGINE TUNE UP (REPLACED SPARK PLUGS, SPECIFICALLY) AT 77K; ENGINE LIGHT GOES OFF AND IS IDENTIFIED AS MAF SENSOR. WARRANTY EXTENDED THROUGH DEALER TO 70K. THE CAR DOES NOT HAVE OPTIMUM FUEL EFFICIENCY WITHOUT PROPERLY FUNCTIONING SENSOR. SENSOR WAS CLEANED AT INDEPENDENT MECHANIC, WORKED FOR 4 DAYS, LIGHT WENT OFF AGAIN. THIS PART NEEDS TO BE RECALLED RATHER THAN JUST HAVE AN EXTENDED WARRANTY!! IT'S EXPENSIVE!*JB

I HAVE A 2001 VOLKSWAGON JETTA WITH 50000, VEHICLE HAS ONLY BEEN IN SERVICE FOR 31 MONTHS. IT HAS A CRACKED HARNESS VW PART # 06A-971-627-MF THAT HAS TO BE REPLACED DUE TO MANUFACTURER'S DEFECT, PART ALONE COSTS $465.00 VOLKSWAGON IS SEEING MORE OF THESE SHOW UP, BUT THEY ARE REFUSING TO ISSUE A BULLITEN NOW TO FIX THE PROBLEM. THE SERVICE MANAGER TOLD ME THAT VW IS AWARE OF THE PROBLEM, AND ARE GOING TO ISSUE A BULLETIN. BUT UNTIL THEY DO, I HAVE TO FRONT OVER $500 TO FIX THE DEFECT AND WAIT TILL THEY ISSUE THE BULLETIN TO GET MY MONEY BACK. THAT IS THE SAME WAY THAT VW HANDLES ALL THE OTHER DEFECTS, I HAD TO DO THE SAME PROCESS WITH THE IGNITION COIL RE-CALL. IT IS NOT FAIR HOW THEY TREAT CUSTOMERS ONCE THEY CROSS THE 24000 MILE THRESEHOLD. SOMETHING HAS TO BE DONE TO CORRECT THIS!*AK

MIL LIGHT ON WITH RICH FUEL MIXTURE ODOR FUEL PUMP RELAY WAS REPLACED DRIVER SIDE MIRROR DEFROST NOT WORKING O2 SENSOR WAS REPLACED AGAIN AIR MASS METER REPLACED AGAIN. *AK

THE FUEL INJECTION SYSTEM ON MY JETTA TDI WENT BAD. THE CAR HAD 35,000 MILES ON IT WHICH WAS 5,000 PAST WARRENTY. VOLKSWAGEN AGREED TO PAY PART OF THE REPAIR, BUT THE COST TO ME WAS STILL OVER $600.00. THE GLOW PLUGS AND HARNESS TO THE GLOW PLUGS HAVE ALSO BEEN REPLACED AFTER WARRENTY. I HAVE NEVER HAD SO MANY EXPENSIVE REPAIRS ON A "NEW" CAR BEFORE. NOW THE BRAKE SWITCH NEEDS REPLACED BECAUSE THE BRAKE LIGHTS WOULD NOT COME ON. REPLACEMENT SWITCH HAS PART NO. VWN 1J0945511D.

MY FUTURE DAUGHTER IN LAW OWNS A VOLKSWAGEN JETTA. WENT TO GAS STATION FOR GAS AND COULD NOT FILL THE TANK. TOOK THE CAR TO VOLKSWAGEN DEALER WHERE THEY ARE CHARGING OVER 800. DOLLARS TO PUT IN A NEW GAS TANK, SINCE THE CAR IS RELATIVELY NEW THIS SEEMS LIKE IT SHOULD BE A RECALL. OR AT LEAST UNDER WARRANTY. IF SHE WAS ON THE HIGHWAY SHE WOULD HAVE BEEN STUCK IN THE LANES WITH NO WAY OF FILLING THAT TANK...CAN YOU RESEARCH THESE GAS TANKS FOR THE SAFETY OF PEOPLE. *NLM

SOMETHING FLEW UP FROM ROAD AND HIT FUEL LINE AND CUT IT OPEN SO FUEL WAS PUMPING OUT CONTINOUSLY BELOW THE FUEL TANK. ABOUT 2 FEET OF PLASTIC FUEL LINES ARE COMPLETELY EXPOSED ON THE BOTTOM OF CAR JUST FORWARD OF FUEL TANK. THESE LINES SHOULD BE SHIELDED BELOW WITH A METAL OR HARD PLASTIC PLATE. THIS COULD HAVE BEEN A VERY SERIOUS PROBLEM HAD THE EJECTING FUEL CAUGHT FIRE.*AK

THE VEHICLE HAS BEEN SEEN BY MECHANICS FROM TWO DIFFERENT DEALORSHIPS ON FIVE OCCASIONS DUE TO THE CHECK ENGINE LIGHT TO DATE. ON THE FOURTH TRIP TO THE SHOP IT WAS EVALUATED BY THE MECHANICS AS HAVING DEFECTIVE GAS TANK THAT HAD A SLOW LEAK. ON THIS OCCASION THE AUTO WAS KEPT FOR 1 WEEK FOR REPAIRS. HERE WE ARE A WEEK LATER AND THE LIGHT IS BACK ON AND IT'S BACK IN THE SHOP AGAIN. MEANWHILE I AM ON PROBATION AT MY NEW JOB AND AM HAVING TO TAKE CONSIDERABLE TIME OFF DUE TO THESE REPAIRS. I AM STILL ON PROBATION AT THIS JOB AND I HAVE ALSO MISSED OUT ON THE OPPORTUNITY OF OVERTIME BECAUSE OF CONTINUAL TRIPS TO THE DEALORS SHOPS. I HAVE ONLY MADE THREE PAYMENTS ON THE CAR TO DATE AND I AM PAYING FOR SOMETHING THAT IS IN THE SHOP AS MUCH AS IT IS IN THE DRIVEWAY. ASIDE FROM THE FACT THAT I HAVE REACHED THE POINT WHERE I AM AFRAID TO DRIVE IT FOR I FEAR IT COULD POSSIBLY BE A DEATHTRAP! I AM NOT SURE ABOUT THE BELT QUESTION THAT ARE WITHIN THIS FORM.*AK