2011 Toyota Tacoma Body & Structure Problems

Your truck's frame has developed several holes in the underbody, which prevented a mechanic from completing a vehicle inspection. This structural damage was discovered at around 168,000 miles. The frame may need to be inspected for rust or corrosion damage, and depending on the severity, sections may need to be repaired or replaced.

Your 2011 Tacoma's underside has developed significant rust that has weakened metal brackets, body panels, and the gas tank support straps. The dealer said since there's no hole rusted all the way through yet, they won't address it—but one of the two gas tank straps has failed, and you're currently using a bungee cord to help hold the tank up as a temporary fix. This is a structural concern that needs professional inspection and repair to secure the fuel tank properly.

You noticed a hole has developed in the frame rail on the passenger's side of your truck near the rear. Your Toyota dealer inspected it under a service bulletin but declined to repair it, and Toyota confirmed the truck is out of warranty for this issue. Frame rust-through or corrosion repair typically involves cutting out the damaged section and welding in a reinforced replacement piece.

Your 2011 Toyota Tacoma was subject to a frame corrosion service campaign, but the dealer and manufacturer denied coverage because your vehicle is in a non-cold climate state. You've discovered corrosion on the sub-frame that hasn't been repaired. Addressing frame corrosion typically involves inspection, cleaning, and applying protective coatings or replacement of corroded sections.

TOYOTA SCRANTON IS WILLFULLY DEFRAUDING OWNERS ENTITLED TO REMEDY FOR SEVERELY RUSTED FRAME UNDER CASE NUMBER 2:15-CV-02171, US DISTRICT COURT, CENTRAL DISTRICT OF CALIFORNIA. SEE ATTACHED DOCUMENTATION AND PHOTOGRAPHS.

THE HORN IN MY 2011 TOYOTA TACOMA QUIT WORKING. I WENT TO USE IT MY HORN, AND IT DID NOT WORK. I'VE TAKEN MY TRUCK TO SEVERAL PLACES TO SEE IF IT COULD BE FIXED. I HAVE BEEN READING WHERE THIS IS A COMMON PROBLEM FOR MANY TOYOTA OWNERS. ALSO, THE WHITE PAINT ON MY CAR IS STARTING TO FLAKE OFF. THE TRUCK ISN'T EVEN 10 YEARS OLD AND HAS BEEN MAINTAINED. YET AGAIN, THERE ARE THOUSANDS OF CONSUMERS AFFECTED BY THIS. APPARENTLY THERE ARE TWO TYPES OF WHITE PAINT THAT TOYOTA KNOWS TO BE AN ISSUE ON CERTAIN YEAR MODELS, BUT THEY HAVE NOT ISSUED A RECALL. HAVING A PAINT JOB IS AN EXPENSE THAT MOST CAN NOT AFFORD! I COULD SEE IF IT WAS SOMETHING THAT WAS CAUSED FROM AN ACCIDENT OR THE OWNERS FAULT, BUT THIS IS RIDICULOUS. MINE IS STARTING TO PEEL AND FLAKE ON MY PASSENGERS SIDE DOOR AROUND THE WINDOW. THERE WAS NO PRELIMINARY FLAKING OR PEELING OF THE CLEAR COAT, IT WENT STRAIGHT FROM WHITE PAINT TO GRAY. NUMEROUS PEOPLE HAVE WRITTEN IN ABOUT BOTH OF THIS ISSUES AND THERE IS NOTHING BEING DONE! THERE IS NO REASON WHY THEY CAN'T FIX OUR HORNS. I LIVE IN N.C. AND MY TRUCK WILL NOT PASS INSPECTION WITHOUT IT. THIS LEADS TO OTHER TICKETS AND FINES THAT SHOULDN'T BE HAPPENING. I CAN'T TELL YOU HOW MANY TIMES I HAVE NEEDED MY HORN, AND IT DOESN'T WORK.

FRAME IS VERY RUSTY

TL* THE CONTACT OWNS A 2001 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THE FRAME OF THE CHASSIS FRACTURED. THE CONTACT STATED THAT THE VEHICLE HIT A BUMP IN THE ROAD. THE CONTACT EXITED THE VEHICLE TO EXAMINE THE FAILURE. THE CONTACT NOTICED THAT THE DRIVER SIDE OF THE CHASSIS BEAM [FRAME] HAD BECOME SEVERELY RUSTED AND CORRODED TO THE POINT OF FRACTURE. THE CONTACT STATED THAT THE RUST AND CORROSION WAS PREMATURE. THE VEHICLE WAS TAKEN TO SLOAN TOYOTA OF GLENSIDE (503 NORTH EASTON ROAD, GLENSIDE, PENNSYLVANIA 19038, (215) 885-5400) TO BE ASSESSED. THE DEALER STATED THAT THE VEHICLE COULD NOT BE LIFTED IN THE AIR FOR REPAIR DUE TO THE SIGNIFICANT DAMAGE OF THE CHASSIS WHICH WOULD WORSEN THE CONDITION OF THE VEHICLE AND CAUSE POTENTIAL RISK TO THE SERVICE TECHNICIAN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 300,000.

TL* THE CONTACT OWNS A 2011 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE'S FRAME WAS RUSTED ALL THE WAY AROUND. THE VEHICLE WAS TAKEN TO THE DEALER (TOYOTA OF MELBOURNE, 24 N HARBOR CITY BLVD, MELBOURNE, FL 32935, 321-426-9420) WHERE IT WAS DIAGNOSED AND CONFIRMED THAT THE FRAME HAD RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT IT WAS FINE FOR NOW, BUT WOULD BE AN ISSUE LATER. THE CONTACT WAS PROVIDED CASE NUMBER: 1807201377. THE FAILURE MILEAGE WAS APPROXIMATELY 106,000.

2011 TOYOTA TACOMA. CONSUMER WRITES IN REGARDS TO RUST HOLES IN FRAME. *LD THE CONSUMER STATED THERE WAS A RECALL FOR VEHICLES OF PREVIOUS YEARS. THE CONSUMER BELIEVED THE VEHICLE SHOULD BE INCLUDED IN THE FRAME RECALL. *JS

YELLOW RUST SPOT ALL OVER THE TRUCK BODY PAINT

TL* THE CONTACT OWNS A 2011 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRONT FRAME WAS COMPLETELY FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

TL* THE CONTACT OWNS A 2011 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRAME AND BODY OF THE VEHICLE WERE RUSTED AND CORRODED. THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION. THE MECHANIC STATED THAT THE VEHICLE WAS UNABLE TO BE REPAIRED BECAUSE THERE WAS TOO MUCH CORROSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 18,400. UPDATED 02/10/16*LJ UPDATED 05/04/18*JB *TR

WHILE PULLING MY TRUCK INTO THE GARAGE, I APPLIED THE BRAKE. I WAS SLOWING DOWN AND HEARD THE ACCELERATION TRACTION CONTROL TURN ON AND MY TRUCK LUNGED FORWARD ABOUT ONE TO TWO FEET. THE FRONT OF MY TRUCK HIT AGAINST SOME ITEMS IN MY GARAGE AND BROKE MY HEADLIGHT HOUSING ON THE PASSENGER SIDE AND SCRATCHED MY BUMPER. *TR

THERE IS A HIGH PITCHED WHINING NOISE FROM THE WINDSHIELD STARTING AT 72 MPH. THERE MUST BE A CROSS WIND. THE NOISE IS AT A PITCH SO HIGH THAT VEHICLE OPERATION IS DIFFICULT, AND AT BEST HIGHLY DISTRACTING TO SAFE OPERATION OF THE VEHICLE. VEHICLE SPEED MUST BE REDUCED TO A SPEED THAT IS BELOW THE FLOW OF NORMAL TRAFFIC FLOW.

2011 TOYOTA TACOMA TRUCK. CONSUMER STATES PROBLEM WITH FACTORY INSTALLED RUNNING BOARDS *TGW THE CONSUMER STATED THE RUNNING BOARDS WERE TOO CLOSE TO THE BODY ALLOWING ONLY A SMALL PORTION OF ONES HEEL TO CONTACT THE BOARD WHEN EXITING THE TRUCK. IF THE BOARDS WERE WET, ONE COULD EASILY SLIP WHILE EXITING THE VEHICLE. ALSO, IF THE VEHICLE WAS PARKED ON AN UNEVEN SURFACE, IT WOULD BE DIFFICULT FOR SOMEONE TO GET THEIR FOOT ON THE BOARD WHEN ENTERING FROM A SLOPING GRADE. *JB

The rubber strip that runs along the passenger side of your roof has come off or is missing. This is a trim piece that helps seal and protect the roof edge.