2003 Toyota Tacoma Tires Problems
9 owner-reported tires complaints from NHTSA data
Data sourced from NHTSA public database. For informational purposes only. Always consult a qualified mechanic.
Tires Recalls (1)
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. The spare tire in the subject vehicles is located underneath the rear of the vehicle and held by a spare tire carrier. A lift plate on the carrier is used to help raise, lower and retain the tire. During its manufacture, the lift plate may not have been sufficiently coated with anti-corrosion materials. If the plate is insufficiently coated and the vehicle is operated in cold climate regions where road salts are frequently used, road spray can reach the carrier assembly and corrode the lift plate.
Fix: Toyota will notify owners, dealers will inspect the vehicle and replace the spare tire carrier lift plate as necessary, free of charge. The recall began in February 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Owner Complaints (9)
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE WAS EQUIPPED WITH GOODYEAR DUNLOP TIRES, SIZE 215/70/15. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH THE TIRE PRESSURE WARNING INDICATOR ILLUMINATED AND A LOUD NOISE EMITTED OUTSIDE OF THE VEHICLE. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE CONTACT NOTICED THAT THE REAR PASSENGER'S SIDE TIRE EXPLODED. THE SPARE TIRE WAS MOUNTED TEMPORARILY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE SPARE TIRE WAS REPLACED WITH A NEW TIRE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 2,400. THE VIN AND DOT NUMBERS WERE UNAVAILABLE.
I HAVE HAD 3 OUT OF 4 TIRES PURCHASED IN 9/08 DEVELOP LARGE "BUBBLES" AT THE RIM AND 1 ONE OF THEM WENT FLAT. THE OTHERS WERE NOTICED AND CHANGED AND ALL TIRES HAD TEARS IN THEM THAT WERE NOT VISIBLE WHEN THE TIRES WERE ON THE RIM. THE FIRST TIRE HAD AROUND 25000 MILES ON IT WHEN IT DEVELOPED A LARGE BUBBLE WHILE WE WERE TRAVELING. THE RECEIPT FROM THE DEALERSHIP THAT REPLACED THE TIRE SAID IT HAD A CUT IN IT. LAST WEEK ANOTHER TIRE WENT FLAT AFTER I HAD DRIVEN OVER 400 MILES AND THIS CAUSED ME TO INSPECT MY TIRES AND I NOTICED A "BUBBLE" THAT STARTED ON THE RIM OF ANOTHER TIRE. WHEN I TOOK THE VEHICLE IN I HAD TO BUY 2 NEW TIRES BECAUSE BOTH OF THESE TIRES HAD TEARS OR CUTS 1 1/2 - 3 INCHES LONG THAT WERE VISIBLE ONLY AFTER THE RIM WAS REMOVED. THESE TIRES HAD AROUND 40,000 MILES ON THEM. I HAVE CONTACTED THE DEALER I PURCHASED THE ORIGINAL TIRES FROM AND I AM IN THE PROCESS OF WORKING OUT A RESOLUTION WITH THEM. THE 4TH TIRE HAS A "RIPPLE" IN IT IN THE MIDDLE OF THE TIRE, NOT AROUND THE RIM, AND THE DEALERSHIP HAS TOLD ME THAT IS FROM SEPARATION AND IS NOT UNUSUAL. I AM ALSO ASKING THAT THEY REPLACE THAT TIRE FOR ME. I STILL HAVE THE LAST 2 TIRES BUT WILL HAVE TO GIVE THEM TO THE DEALERSHIP WHEN WE WORK OUT A RESOLUTION. *TR
NO INDICATION OF ANY PROBLEM PRIOR TO EVENT. TIRE WAS IN GOOD CONDITION. CATASTROPHIC SIDEWALL FAILURE OF FRONT TIRE AT 65 MPH ON BUSY FREEWAY. TIRE COMPLETELY SEPARATED. ONE SIDEWALL COMPLETELY MISSING. TIRE RETAINED AS EVIDENCE BUT REPLACED AT OWNER EXPENSE. *NM
DT: CONTACT STATED THE TIRES WERE DEFECTIVE. THE SIDEWALL BLEW OUT ON THE REAR DRIVER'S SIDE, CAUSING THE VEHICLE TO SPIN AROUND AND END UP ON THE SIDE OF THE ROAD. THE REAR TIRE ON THE PASSENGER'S SIDE WENT FLAT. THE TREAD FOR THE TWO FRONT TIRES IS SEPARATED AT THE SIDEWALL. ALL FOUR TIRES HAVE BEEN REPLACED AT THE CONTACT'S EXPENSE. HE CONTACTED THE MANUFACTURER, WHO URGED THE CONTACT TO SENT TO THEM THE TIRES. HE HAS NOT YET SENT THE TIRES TO THE MANUFACTURER. *AK
WHILE ROTATING THE TIRES ON MY NEW 2003 TOYOTA TACOMA P/U FOR THE FIRST TIME (6,000 MILES), I NOTICED A BULDGE IN THE DRIVERS SIDE FRONT TIRE (GOODYEAR WANGLER HP P205/75R15) LOCAL GOODYEAR DEALER(AUTO WORLD) CALLED GOODYEAR, THEY SAID NO WARRANTY, BUT THEY WILL SELL ME A REPLACEMENT TIRE AT THERE COST OF $97.00 (AS IF I'LL BUY ANOTHER GOODYEAR TIRE)! HOW MANY HAVE TO BE HURT OR INJURED BEFORE SOMETHING IS DONE! OR ARE THEY FOLLOWING FIRESTONE / BRIDGESTONE'S LEAD..... *LA
THE CONSUMER COMPLAINED ABOUT A FIRESTONE TIRE PROBLEM. ALL 5 TIRES SPLIT ON THE SIDEWALL. FIRESTONE SENT AN INSPECTOR, AND WAS TOLD IT WAS A ROAD HAZARD. VEHICLE WAS DRIVEN LESS THAN 1000 MILES AND THE TIRES WERE DEFECTIVE. *AK THE SECOND SET OF TIRES HAD THREE TIRES WITH SPLITS IN THE SAME AREA. THE FIRESTONE INSPECTOR SUGGESTED THAT THIS WAS DUE TO ROCKS OR SOME SORT OF PROBLEM CUTTING THE TIRES. THE CONSUMER HAD NEVER DRIVEN THE VEHICLE OFF OF PAVED ROADS. ALL EIGHT TIRES HAD SPLITS IN THE SAME AREA. *SC
WHILE DRIVING 55 MPH, THE LEFT FRONT TIRE EXPLODED. THE CONSUMER WAS ABLE TO PULL OVER TO THE SHOULDER AND CALLED ROAD SIDE ASSISTANCE TO CHANGE THE TIRE.*AK THREE DAYS LATER THE LEFT REAR TIRE BLEW OUT, THE CONSUMER WAS TOLD THAT THE SPARE TIRE WAS IN THE PROCESS OF ABOUT TO FAIL AS WELL. THE NEXT DAY, TOYOTA HAD THE VEHICLE TOWED AND ALL 5 TIRES WERE REPLACED. *CB *JB
2003 CREW CAB TACOMA: DRIVE TRAIN CLUNK WHEN STOPPING, FEELS LIKE I WAS REAR ENDED LIGHTLY. FIRESTONE TIRES ARE SPLIT DOWN THE MIDDLE OF SIDE WALLS, LOOK LIKE RE-TREADS, ALL FIVE TIRES ARE THE SAME. 7000 MILES ON TRUCK. *LA
DRIVER REPLACED FRONT DRIVER'S SIDE TIRE . THREE STUDS BROKE WHILE CHECKING THE WHEEL DUE TO CORROSION. DEALERSHIP WAS AWARE OF THE PROBLEM.*AK