1998 Toyota Tacoma Suspension Problems

Your truck's frame has rusted severely, causing the rear shock mount to break through the frame. You discovered the frame had been previously repaired by welding new metal over existing rust rather than addressing the underlying corrosion. This frame rust affects the structural integrity and safety of your truck both on and off road. Addressing this will require professional frame inspection and likely extensive welding or frame replacement to ensure your truck is safe to drive.

You noticed a hole has developed in the rear passenger side wheel well of your truck's subframe, and it's getting bigger over time. The dealer and Toyota said they couldn't help because an unknown recall had expired. The hole will likely continue to worsen and could eventually compromise the structural integrity of your vehicle.

PURCHASED 1998 TOYOTA TACOMA 4WD TRUCK OCTOBER 2012. VEHICLE HAD BEEN RECALLED FOR FRAME RUST AND WAS SERVICED BY A TOYOTA DEALERSHIP 05/25/2011 AND FRAME AND UNDER CARRIAGE WAS INSPECTED, CLEANED, PREPARED AND COATED WITH UNDERCOATING. DEALERSHIP ADVISED THE PROBLEM WAS CORRECTED. MILEAGE AT TIME WAS 161,757. IN LATE 2012 RUST SPOTS DEVELOPED AGAIN AND CONTINUED TO WORSEN UNTIL THE FRAME COMPLETELY RUSTED THROUGH AND BROKE ABOVE THE RIGHT REAR WHEEL IN THE VICINITY OF THE SHOCK ABSORB-ER BRACKET WHICH ALSO WAS RUSTED THROUGH. THERE ARE VARIOUS OTHER RUST PROBLEM AREAS ON THE FRAME AND SUSPENSION PARTS AND ANOTHER FRAME RUST THROUGH IS EVIDENT ON THE LEFT SIDE OF THE VEHICLE ABOVE THE REAR TIRE AT THE SHOCK ABSORB-ERR BRACKET.. DECEMBER 2016, MILEAGE 211,927 THE VEHICLE WAS CONSIDERED TO BE UNSAFE FOR OPERATION AND TAKEN OFF THE PUBLIC ROADWAYS BY THE CURRENT OWNER AFTER THE FRAME BROKE INTO WHILE TURNING INTO THE DRIVEWAY. THE VEHICLE WAS PLACED OUT OF SERVICE DUE TO FEAR OF BEING HELD LIABLE FOR DEATH, INJURY OR DISMEMBERMENT TO SELF, PERSON OR PERSONS DUE TO KNOWINGLY CONTINUED OPERATION OF THE VEHICLE WOULD BE UNSAFE. AFTER EXTENSIVE RESEARCH OF FRAME RUST THROUGH PROBLEMS, THE TOYOTA DEALERSHIP THAT HANDLED THE RECALL IN 2011 WAS CONTACTED IN PERSON BY THE CURRENT OWNER ON FEBRUARY 21, 2017 AT 1:30 PM AND WAS ADVISED BY THE DEALERSHIP SERVICE DEPARTMENT THAT THE ENHANCED WARRANTY WAS ONLY GOOD FOR 15 YEARS FROM THE DATE THE VEHICLE WAS FIRST PURCHASED NEW AND PLACED IN SERVICE WHICH WAS APRIL 1998 AND HAD EXPIRED IN APRIL 2013. AS THE CURRENT OWNER OF THE VEHICLE I WAS NEVER NOTIFIED BY TOYOTA THAT A WARRANTY HAD EVER EXISTED AND WOULD SOON EXPIRE AND NOR MYSELF OR THE PREVIOUS OWNER WAS EVER NOTIFIED TO HAVE THE VEHICLE REINSPECTED BY TOYOTA TO MAKE SURE THE PROBLEM HAD NOT REOCCURRED AND VEHICLE WAS SAFE FOR CONTINUED OPERATION.

THERE IS AN ACCELERATED AND ABNORMAL AMOUNT OF CORROSION AND RUST SHOWING UP ON UNDERCARRIAGE OF THE VEHICLE. REAR LEAF SPRINGS HAVE LOST RUBBER BUMPER DUE TO RUST, AND SUSPENSION/FRAME MAKE NOISES DUE TO STRESS ON FRAME WHICH IS THE RESULT OF RUST/CORROSION. I AM THE ORIGINAL OWNER TO THIS VEHICLE, HAVING PURCHASED IT NEW AND HAVING ALWAYS HAD IT IN COLORADO A MOSTLY DRY CLIMATE NOT CONDUCIVE TO RUST/CORROSION. I HAVE IT AT THE SAME DEALERSHIP I BOUGHT IT FROM MULTIPLE TIMES PER YEAR FOR SERVICE, AND IT IS STILL UNDER 150K ORIG MILES. I HAVE NEVER BEEN INFORMED BY THE TOYOTA DEALERSHIP REPS. ABOUT CONCERNS WITH RUST/CORROSION ISSUES, NOR HAS ANY COMPANY STAFF EVER ACKNOWLEDGED ANY CONCERNS OVER THESE ISSUES, OR HAS THE COMPANY REACHED OUT TO INFORM ME OF POTENTIAL PROBLEMS. IN NO WAY, SHAPE OR FORM HAS TOYOTA EVER ADVISED ME OF ANY RECALL, CONCERNS OR PROBLEMS. I HAVE LIVED AT MY CURRENT RESIDENCE AND HAD THE SAME PHONE NUMBERS FOR THE LAST 15 YEARS AND THIS HAS BEEN IN THE STEVENSON TOYOTA DEALERSHIP RECORDS THIS WHOLE TIME. THIS IS EXTREMELY CONCERNING DUE TO THE MOUNTAIN DRIVING CONDITIONS HERE IN COLORADO, AND SPEED AT WHICH THIS RUST/CORROSION IS EXPANDING AND MAKING THE VEHICLE WEAK AND UNSAFE TO OPERATE. APPARENTLY MORE OWNERS OF THIS VEHICLE AND MODEL YEAR ARE EXPERIENCING THE VERY SAME ISSUES AND HAVE NOT BEEN NOTIFIED BY TOYOTA. THIS APPEARS TO BE A PROLIFIC ISSUE THAT NEEDS IMMEDIATE ATTENTION.

FRAME ON MY TRUCK IS RUSTING TO A POINT OF BEING A SAFETY ISSUE . TOYOTA NEEDS TO REPLACE THIS SO VEHICLE WILL BE SAFE .

TL* THE CONTACT OWNS A 1998 TOYOTA TACOMA. WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS A LOUD ABNORMAL NOISE COMING FROM THE VEHICLE. THE CONTACT OBSERVED THAT THE FRAME WAS COMPLETELY RUSTED AND FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000. UPDATED 8/31/15*CN THE CONSUMER STATED TOYOTA HAD NOT HONORED THE PROMISE TO REPLACE THE RUSTED FRAMES. UPDATED 10/14/2015*JS

MY VEHICLE'S FRAME IS DANGEROUSLY RUSTING OUT. I HEARD THERE WAS A RECALL AND WHEN I CALLED TOYOTA ABOUT TWO YEARS AGO THE SAID I HAD JUST MISSED THE CUT OFF. SINCE THEN IT HAD GOTTEN PROGRESSIVELY WORSE. THE BODY MOUNTS HAVE SEPARATED FROM THE FRAME AND WHERE THE LEAF SPRING IS ATTACHED IS GETTING READY TO SEPARATE. THESE ARE ALSO HOLES IN THE FRAME. IF ANYBODY HAS ANY ADVISE WOULD BE GREATLY APPRECIATED. DOES NOT SEEM RIGHT THAT THEY COULD HAVE A RECALL AND I WAS NEVER CONTACTED AND WHEN I CONTACTED THEM THAT THEY TOLD ME I MISSED IT BY ONLY MONTHS?

FRAME RUSTED OUT CAUSING LEAFSPRING TO SINK INTO FRAME. *TR

WHEN CHECKING TO SEE IF MY SHOCKS NEED TO BE REPLACED I FIND I HAVE A RUSTED FRAME ABOVE RIGHT REAR WHEEL AND IN FRONT OF LEFT FRONT WHEEL. THIS WAS THE FIRST I HAD ANY KNOWLEDGE OF IT. A FRIEND ADVISED ME THERE WAS A RECALL SO I CALLED TOYOTA. I WAS ADVISED THEY STILL HAD THE PREVIOUS OWNERS INFORMATION EVEN THOUGH I PURCHASED IT FROM A DEALER ON 2/11/2005. I NEVER RECEIVED A RECALL NOTICE AND NEVER HEARD ANYTHING ABOUT IT AND WAS TOLD THEY WOULD NOT DO ANYTHING TO FIX IT. IS THERE ANYTHING YOU CAN DO TO HELP. THE TRUCK IS STILL A GOOD 4WD TRUCK. *TR

TL* THE CONTACT OWNS A 1998 TOYOTA TACOMA. WHILE PARKED, THE CONTACT NOTICED THAT THE REAR FRAME WAS CORRODED AND THE REAR AXLE HAD DETACHED FROM THE FRAME. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSTIC TEST. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 172,000. UPDATED 05/16/12*LJ THE CONSUMER STATED TOYOTA PURCHASED THE VEHICLE BACK FROM HIM. UPDATED 05/22/12

I OWN A TOYOTA TACOMA, 1998 MODEL. ONE OF THE REAR LEAF SPRINGS BROKE. PART OF IT SHIFTED SIDEWAYS IN ITS LOCATION AND BEGAN TO PUNCTURE THE FUEL TANK. UPON SEARCHING FOR A REPLACEMENT ON THE USED MARKET, I LEARNED THAT NUMBER ONE, ALL OF THESE TACOMAS DEVELOP BROKEN LEAF SPRINGS, AND NUMBER TWO, ALL USED SPRINGS HAVE BEEN ABSORBED TO REPAIR BROKEN ONES ON TRUCKS STILL IN USE. NUMBER THREE, TOYOTA CHANGED THE CONFIGURATION OF THE REAR SPRING ASSEMBLY FROM A THREE LEAF TO A FOUR LEAF ASSEMBLY TO TRY TO DEAL WITH THE PROBLEM, BUT MADE THE RETROFIT A COST BORNE BY THE CONSUMER. EVEN A PARTS EMPLOYEE OF A TOYOTA DEALERSHIP AGREED THAT TOYOTA SHOULD HAVE HAD A RECALL OF THE TACOMA FOR DEFECTIVE LEAF SPRING DESIGN/ENGINEERING. THE BREAKAGE CREATES AN UNSTABLE SUSPENSION SUBJECT TO LOSS OF CONTROL AND IF THE SPRING SHIFTS SIDEWAYS DOES PUNCTURE THE FUEL TANK. *TR

FRONT SUSPENSION LOWER BALL JOINT FAILED WHILE IN OPERATION. RESULTING IN SEPARATION FROM THE KNUCKLE, CAUSING A COLLAPSE IN THE SUSPENSION AND LOSS OF STEERING CONTROL WHILE DRIVING. THE COLLAPSE HAPPENED IN TRAFFIC AND CAUSED OTHER DAMAGE TO THE VEHICLE INCLUDING DRIVE SHAFT AND TIRE DAMAGE. *TR

DRIVER'S SIDE REAR LEAF SPRING BROKE LAST YEAR. I HAD IT REPAIRED/REPLACED AT A LOCAL SPRING SHOP. NOW THE SAME SPRING ON PASSENGER SIDE HAS BROKE AT THE SAME PLACE. THIS AFFECTS HANDLING OF VEHICLE AND LEAVES THE SPRING HANGING BY A FACTORY CLAMP WHICH IF IT BREAKS THE REST OF THE WAY COULD CAUSE ACCIDENT. *TR

THIS TRUCK IS THE CENTER PIECE OF MY LIFE. MY 1998 TOYOTA TACOMA WAS THE PERFECT VEHICLE FOR ME. I STILL OWN MINE BUT IT IS TOUGH TO DRIVE KNOWING THAT IF I WAS IN A CRASH MY LIFE COULD BE THREATENED DUE TO THE LACK OF FRAME RIGIDITY. I NEED THIS TRUCK TO LAST ME UNTIL I AM OUT OF COLLEGE BECAUSE THERE ARE NO FUNDS FOR ME TO PURCHASE A DIFFERENT ONE. THIS DEFECT WAS BROUGHT TO BY ATTENTION DURING A RECENT SNOWSTORM WHEN DRIVING HOME FROM ONE OF MANY JOBS. I RAN OVER A SHALLOW POT HOLE AND HEARD A CLUNK. THE VEHICLE BEGAN TO DRIVE VERY ODDLY CAUSING CONCERN TO ME. I HAD MY MECHANIC LOOK IT OVER THE NEXT DAY AND HE EXPLAINED THAT HE HAS SEEN MANY OF THESE TRUCKS WITH THE SAME TYPE OF ISSUE. MY ISOLATED ISSUE INVOLVES THE ATTACHING SITE OF THE REAR LEAF SPRING. THE MECHANIC QUOTED MY $1000 DOLLARS WITH NO GUARANTEE OF REPAIR. I COULD NOT DO THIS BECAUSE I DO NOT HAVE THE MONEY TO PUT INTO IT. I TOOK IT TO ANOTHER MECHANIC WHO IS A FAMILY MEMBER WHO FIXED IT AND SHOWED ME THE MULTIPLE OTHER WEAK SPOTS WITH IN THE FRAME. IN THESE MULTIPLE AREAS THE FRAME IS SO WEAK THAT IF YOU TOUCH IT PIECES FALL OFF. HE TRIED HIS BEST TO REINFORCE IT BUT OTHER SPOTS STILL LACK STRENGTH. NOT SAFE AND NOT GOING TO SELL!!!!!! *TR

THE OTHER DAY I WAS DRIVING DOWN THE ROAD AND HIT A SMALL POTHOLE WITH MY 1998 TOYOTA TACOMA AND THE BOTTOM LEAF IN THE DRIVERS SIDE REAR LEAF SPRING PACK SNAPPED IN HALF. AND IS NOW HANGING DOWN AND IT CAN POTENTIALLY MAKE CONTACT WITH MY TIRES SIDEWALL. *TR

MY 1998 TOYOTA TACOMA HAD ITS LEFT REAR LEAF SPRING BREAK JUST IN FRONT OF THE REAR DIFFERENCIAL. THIS CAUSE THE LEAFS TO TWIST INWARDS AND RUB AGAINST THE GAS TANK EXPOSING THE BARE METAL OF THE TANK. LUCKLY I TOOK THE TRUCK TO THE MECHANIC BEFORE THE RUBBING AGAINST THE TANK WORKED ITS WAY THROUGH POTENTIALLY CAUSING AN EXPLOSION WITH A SPARK. AT THIS TIME I WILL BE REPLACING THE LEAF SPRINGS (AFTER TAKING SOME PHOTOS). I HAVE ALSO FILED A COMPLAINT NO 2005-12280233 WITH TOYOTA MOTOR CORP. THEIR POSITION IS THAT I WILL HAVE TO BEAR THE COST OF THE REPAIR AS IT IS OUT OF WARRANTY. I BELIEVE THIS IS A POTENTIALLY UNSAFE CONDITION AND A RECALL TO CHECK LEAF SPRINGS SHOULD BE MADE. *NM

EMPLOYEE WAS DRIVING ON HIGHWAY, 60 MPH IN OUR 1998 TOYOTA TACOMA PICKUP TRUCK. WITH NO WARNING THE DRIVERS FRONT WHEEL ASSEMBLY (HUB AND ALL, EVERYTHING) CAME OFF THE TRUCK AND LODGED UNDER THE FRONT AXLE. HE WAS ABLE TO CONTROL THE VEHICLE SAFELY TO THE SIDE OF THE ROAD. CURRENTLY IN TRANSPORT TO AN AUTO SHOP FOR REPAIRS.

CONSUMER STATES THAT WHEN HAVING AN OIL CHANGE WAS INFROMED THAT THE LEAF SPRINGS WERE FALLING APART. DEALER CONTACTED, THIS IS A COMMON PROBLEM. TS

BROKEN LEAF SPRINGS ON BOTH SIDES OF THE REAR. *AK

THE VEHICLE VIBRATES AT HIGHWAY SPEEDS AND THE BRAKES VIBRATE WHEN APPLIED AS IF THE DISCS ARE BENT, MECHANIC CAN NOT FIND ANY PROBLEMS THAT WOULD CAUSE THESE SYMPTOMS. *MJS

AT SPEEDS OVER 45, FRONT END VIBRATES BADLY AND IS HARD TO CONTROL. I HAVE REPLACED THE TIRES WHICH WORKED UNTIL THE TIRES HAD 5000 MILES OF THEM, BALANCED TIRES, AND HAD FRONT END ALIGNMENTS. THE TOYOTA DEALERSHIP IS AWARE OF THE PROBLEM, BUT CANNOT COME UP WITH A SOLUTION TO CORRECT THE PROBLEM. I KNOW OF OTHER TACOMA OWNERS WITH SIMILAR PROBLEMS.( DOT NUMBER: TIRE SIZE: 31X10.5 15 )

GRINDING NOISE IN THE FRONT END SUSPENSION AND THE TIRES ARE WEARING EXCESSIVELY (TIRE TREADS WERE VISIBLE). NLM

1. FRONT WHEEL ALIGNMENT SHIFTS UNDER LOAD(IN SPEC) AS MUCH AS 1/4 IN. THIS TOE OUT CAUSES EXCESSIVE AND DANGEROUS TIRE WEAR. TIRES CAME APART AFTER 3000 MI. THE VEHICLE IS HARD TO CONTROL WITH TOE OUT OF THIS MAGNITUDE. I HAVE TO GET THE ALIGNMENT DONE WITH A LOAD IN THE TRUCK TO BE ABLE TO SAFELY STEER IT AND GET SOME RESPECTABLE TIRE WEAR. GOD SAVE AN UNSUSPECTING DRIVER! 2. REAR SPRINGS BOTTOM OUT "HARD" CAUSING THE VEHICLE TO JUMP. THE REAR SPRING BUMPER TO AXLE HOUSING SPACE IS 1 IN. (WITH LOAD). TOYOTA SAYS "DON'T LOAD IT, IT'S NOT REALLY A TRUCK! THESE TWO ITEMS MAKE THIS VEHICLE TRICKY TO DRIVE AND IS SETTING DRIVERS UP FOR A REAL ROAD TEST.

SUSPENSION SYSTEM MUSHY, REPLACED ALL SHOCK ABSORBERS AND SPRINGS TO CORRECT PROBLEM. YH

BALL JOINT FAILED. YH

SHOCK ABSORBER FAILED. YH

CHASIS/LEAF SPRING/REAR AXLE IS DEFECTIVE, THE VEHICLE LEANS OVER A ONE INCH DEGREE TO THE DRIVERS SIDE, NO ONE HAS TO BE IN THE VEHICLE, THE DEALER REPLACED THE SPRING AND FIXED UP THE BED LEVEL, VEHICLE STILL LEANS OVER ONE HALF INCH WITHOUT ANYONE IN. DEALER CONTACTED SIX TIMES OR MORE AND CANNOT DUPLICATE THE PROBLEM. *AK