2018 Toyota Sienna Fuel System Problems

Your fuel line under the intake ruptured when you started your car, causing fuel to leak. The repair shop indicated this type of failure is unusual. You're fortunate the engine wasn't hot at the time, as this could have created a fire hazard. The repair will likely involve replacing the damaged fuel line.

After your Sienna had the fuel system recall repair done, gasoline has leaked from the vehicle three separate times. During one incident, your family was in the car and the gas smell was very strong, making it unsafe to drive. The dealership says you need a $1,400 fuel pressure hose and clamp replacement, which you believe is related to how they performed the original recall repair. You're requesting Toyota investigate whether this repair should be covered under warranty instead of charging you.

Your van hesitates when you press the gas pedal—both from a stop and while driving at speed—causing a noticeable delay before the engine responds. This creates a safety concern when you need to accelerate quickly to merge into traffic. The issue has been present since you purchased the van and may be related to a fuel system problem. A fuel system inspection and possible fuel filter replacement may be needed to restore normal acceleration response.

Car stalled, sputtered and died. At first, I thought I was out of gas. After several tries, the car started and went 3 miles to gas station. After getting gas, the car wouldn’t start several times and that same day the check engine light came on. We took it to Autozone to check the code and they said it was showing fuel pump failure. Today I’m taking it in to the dealer for service. It has started and run twice since the initial episode.

TL* THE CONTACT OWNS A 2018 TOYOTA SIENNA. THE CONTACT STATED WHILE DRIVING 70 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED HOWEVER, THE VEHICLE FAILED TO RESPOND. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER HANLEES DAVIS TOYOTA (4202 CHILES RD, DAVIS, CA 95616, (530)753-3352) HOWEVER, THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V012000 (FUEL SYSTEM, GASOLINE). THE RECALL REPAIR WAS SATISFIED AT MAITA TOYOTA OF SACRAMENTO (2500 AUBURN BLVD, SACRAMENTO, CA 95821, (916)481-0855) HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 52,350. THE VIN WAS INVALID.

TL* THE CONTACT OWNS A 2018 TOYOTA SIENNA. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE AND EXITING THE DRIVEWAY, THE VEHICLE SURGED FORWARD WHILE IDLE, WITH AN UNKNOWN WARNING LIGHT ILLUMINATED. THE CONTACT THEN RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V012000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. NORTH BAKERSFIELD TOYOTA (19651 INDUSTRY PKWY DR, BAKERSFIELD, CA 93308, (661) 615-1100) WAS CONTACTED AND CONFIRMED THAT PARTS WERE NOT YET AVAILABLE FOR THE RECALL REPAIR. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 2,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2018 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V012000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2018 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V012000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. ALAN JAY TOYOTA (404 US HWY 27 N, SEBRING, FL 33870) WAS CONTACTED AND CONFIRMED THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOLS CONFIRMS PARTS NOT AVAILABLE. *TR

WE RECEIVED NOTICE FROM TOYOTA OF A POSSIBLE FAILURE IN THE VEHICLE'S FUEL PUMP FOR WHICH THERE IS NO CURRENT FIX AVAILABLE. THE VEHICLE IS PARKED IN THE GARAGE. NOTHING HAPPENED. MY CONCERN IS THAT THERE'S NO DATA AVAILABLE ABOUT THE FREQUENCY OF THESE FAILURES, SO IT'S IMPOSSIBLE FOR ME TO ASSESS THE RISK OF DRIVING OUR ONLY CAR. *TR

TL* THE CONTACT OWNS A 2018 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V012000 (FUEL SYSTEM, GASOLINE). THE CONTACT CALLED THE LIA TOYOTA DEALER, LOCATED IN WEST NYACK, NY, AND IT WAS CONFIRMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2018 TOYOTA SIENNA. THE CONTACT STATED THAT AFTER COMING TO A COMPLETE STOP, THE VEHICLE HESITATED WITHOUT WARNING AS THE ACCELERATOR PEDAL WAS DEPRESSED. UPON INVESTIGATION, THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 20V012000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 35,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.