2001 Subaru Forester Suspension Problems

While driving at about 30 mph, your rear cross member fractured and failed. This is a structural component that connects the suspension and frame. An independent mechanic diagnosed and repaired the failure. This happened at approximately 190,000 miles.

2001 SUBARU FORESTER 87500 MILES ON IT. 12/2007 HAD REAR WHEEL BEARINGS REPLACED AT INDEPENDENT SHOP. NOW IT IS 12/2008 WITH ONLY 92K MILES ON IT, AND THE DRIVER'S SIDE REAR WHEEL BEARING IS HOWLING LIKE A BANSHEE. PASSENGER REAR WHEEL BEARING GETTING LOUDER BUT NOT AS BAD. MIGHT HAVE DEALER REPLACE THEM THIS TIME AND CHECK HUB ASSEMBLY FOR DAMAGE ETC. *TR

LEFT REAR WHEEL BEARING HAS BEEN REPLACED TWICE. RIGHT REAR WHEEL BEARING NEEDS TO BE REPLACED NOW. DEALER SERVICE PERSONNEL TOLD ME THAT THE WHEEL WAS ABOUT TO FALL OFF OF THE VEHICLE THE FIRST TIME I HAD THE BEARING REPLACED. *TR

01 FORESTER WAS BOUGHT FROM VAN BORTEL SUBARU ON 4/24/04 COMING OFF A LEASE WITH 29,000 MILES. I HAD TO NEGOTIATE THAT DEALER TO CHECK CAR FOR SERVICE BULLETINS AND RECALLS AND ASKED FOR THE 30K MAINTENANCE TO BE COMPLETED. MINIMAL WORK WAS COMPLETED AND SUBSEQUENTLY MAJOR PROBLEMS SUCH DUE TO DEFECTIVE PARTS SUCH AS HEAD GASKET FAILURE AND WHEEL BEARING FAILURE HAD TO BE DONE. VEHICLE HAS BEEN REGULARLY SERVICED AT DEALER AND COMPLAINTS OF ROAD NOISE HAD BEEN SHARED WITH DEALER. TIRES WERE REPLACED AT OWNER EXPENSE IN RESPONSE. HEAD GASKET COST WAS COVERED BY WARRANTY BUT ONE REAR WHEEL BEARING ($400) WAS NOT COVERED AND PAID BY OWNER. THESE PROBLEMS HAVE BEEN WELL DOCUMENTED BY OTHER OWNERS SINCE 2002 AND NEITHER SUBARU NOR VAN BORTEL INFORMED OWNERS OF PROBLEMS. AS A RESULT THEY PLACED OWNERS AT RISK OF SERIOUS MECHANICAL FAILURE AND INCREASED COST OF REPLACEMENT OF ENTIRE REAR AXEL AND POSSIBLE SERIOUS ACCIDENT/INJURY. *TR

SUBARU 2001 FORESTER, 71,440 MILES, ONE OWNER, PURCHASED 04/2000. WHILE DRIVING, GRINDING NOISE FROM REAR OF VEHICLE. TALKED WITH SUBARU AND TWO INDEPENDENT GARAGES, AND ALL WITH SAME CONCLUSION - DEFECTIVE WHEEL BEARING. ALL STATED THIS WAS/IS A KNOWN PROBLEM WITH THIS VEHICLE BECAUSE PART WAS NOT STRONG ENOUGH. SUBARU MECHANIC DIAGNOSED RIGHT REAR WHEEL BEARING IS PROBLEM AND IT WAS REPLACED. ASKED FOR AND RECEIVED REPLACED PART. *NM

FAILURE OF REAR WHEEL BEARINGS. *NM

I OWN THREE SUBARU VEHICLES ONE OF WHICH IS A 2001 FORESTER-L. I HAVE HAD TO REPLACE THE R/R WHEEL BEARING ON MY FORESTER TWICE @ 28017 MILES AND AT 75375 MILES. THE FIRST INCIDENT WAS COVERED UNDER THE VEHICLE WARRANTY. I WAS REIMBURSED BY SUBARU FOR HALF THE COST FOR SECOND INCIDENT. IN DISCUSSION WITH OTHER FORESTER OWNERS AND LOCAL MECHANICS THIS APPEARS TO BE A RECURRING PROBLEM (PLEASE SEE VQ 7510621 AND VQ 7510621). I HAVE ALSO HAD TO REPLACE BOTH FRONT WHEEL BEARINGS ON MY 1998 LEGACY L WAGON, BUT IN FAIRNESS THIS WAS AT 112, 000 MI. MY FEAR HERE IS THAT I WILL ALSO INCUR THIS REPAIR ON MY 2002 IMPREZA. *JB

DT: THIS IS THE THIRD TIME THAT THE REAR WHEEL BEARINGS ON THE PASSENGER SIDE NEED TO BE REPLACED. THERE WAS A LOUD NOISE IN THE BACK WHILE THE VEHICLE WAS IN MOTION. GOT LOUDER ON TURNS, MOSTLY TO THE RIGHT. *AK *SB *NM

WHILE DRIVING IN CITY LIMITS CONSUMER HEARD A NOISE. AS SOME TIME PASSED THE NOISE BECAME LOUDER. WITHIN TWO YEARS THE RIGHT REAR WHEEL BEARING WAS REPLACED TWICE. SEVERAL MILES LATER, THE LEFT REAR WHEEL BEARING WAS REPLACED TWICE. CURRENTLY, NOISE RECURRED AGAIN WITH OWNER NOT SURE WHICH REAR WHEEL BEARING HAS FAILED. *AK

CONSUMER STATED REAR WHEEL BEARING WORE OUT PREMATURELY. THIS PART WAS REPLACED FOUR TIMES. *AK

A NOISE COULD BE HEARD WHILE DRIVING THE VEHICLE. THE DEALER DETERMINED THAT THE RIGHT REAR WHEEL BEARING MUST BE REPLACED. *AK

I HAVE A 2001 SUBARU FORESTER. IN THE FALL OF 2002, THE RIGHT REAR WHEEL BEARING WENT BAD AND WAS REPLACED BY THE DEALER (LESS THAN 30,000 MILES ON THE CAR). IN FEBRUARY 2003, THE LEFT REAR WHEEL BEARING WENT BAD AND WAS REPLACED BY THE DEALER. IN JUNE 2003, THE LEFT WHEEL BEARING WENT BAD AGAIN AND WAS REPLACED/REPAIRED AGAIN BY THE DEALER. THERE IS A SERIOUS DEFECT IN THESE VEHICLES BECAUSE THE REPAIRS ARE NOT EVEN LASTING SIX MONTHS. DEALERS SERVICE DEPT. HAS BEEN COURTEOUS AND ALL REPAIRS HAVE BEEN COVERED AT NO CHARGE. *NLM

THE REAR WHEEL BEARING FAILED, HOWEVER THE MANUFACTURER DID NOT AGREE TO CORRECT THE PROBLEM. *JB. *AK

I HAVE BROUGHT MY VEHICLE BACK TO THE DEALER IN DELRAY BEACH FL AND IT STILLS PULLS TO THE RIGHT AND I HAD THE CUDTOMER SERVICE REP DRIVE IT WITH ME IN THE CAR AND HE AGREED THAT IT HAS A PULL TO THE RIGHT . I HAVE SPOKEN TO SUBARU AND THEY HAVE DONE NOTHING TO TAKE CARE OF THIS PROBLEM. IT IS A SERIOUS SAFETY ISSUE.*AK

CONSUMER STATES THE LEFT AND RIGHT REAR WHEEL BEARINGSFAILED. *JG

CONSUMER STATES THE LEFT AND RIGHT REAR WHEEL BEARINGSFAILED. *JG

I ALREADY HAD TO CHANGE BROKEN BEARINGS IN BOTH REAR WHEELS OF MY 2001 SUBARU FORESTER. I AM TRAINED TO MONITOR NOISE AND VIBRATION AND WAS ABLE TO CATCH THE PROBLEM IN-TIME. THE REPLACEMENT WAS MADE BY A SUBARU DEALER WITH NO COST TO ME. I THINK THAT MOST DRIVERS WOULD NOT BE ABLE TO CATCH THE PROBLEM AND THE SITUATION MAY BE LIFE THREATENING IF THE BEARING FINALY COMPLETELY BREAKS AT HIGH SPEED AND FREEZE THE WHEEL. I SENT ACOMPLAIN TO SUBARU COMPANY. THE COMPANY RESPONSE (CASE # 332444): "THE PARTS THAT YOU HAD REPLACED ARE MECHANICAL. AS YOU KNOW, MECHANICAL PARTS CAN FAIL." I DO NOT THINK THAT IT IS NORMAL IF WHEEL BEARINGS FAIL IN A NEW CAR IN THE FIRST YEAR.*AK