2023 Kia Sorento Electrical Problems

Your 2023 Sorento is displaying multiple warning lights and error codes related to electrical and safety systems. You're experiencing several interconnected problems including windshield wipers malfunctioning, non-functional lights and climate control, unexpected emergency braking activation, and the lane departure warning system pulling the steering wheel without reason. These electrical issues suggest a potential wiring problem that may affect vehicle safety and drivability. The fix will likely require a comprehensive electrical system diagnostic and wiring inspection at a Kia dealership, and you should verify whether this matches any existing recalls for your vehicle's VIN.

While driving on the Dallas North Tollway, your 2023 Kia Sorento suddenly lost acceleration, so you had to pull over. The engine then started smoking and caught fire under the hood. Your vehicle is currently at the dealership, but after over two weeks, you haven't received a clear explanation or timeline for repairs—the dealership is waiting for a Kia engineer to assess the damage. This will likely require a complete engine inspection and potential replacement of engine components and electrical systems.

Your 2023 Sorento is under recall (SC351) because the HVAC blower motor wiring harness may be inadequate and could cause a fire. You've been unable to get this fixed at your Kia dealership for three months, and there's currently no available remedy. The fix will involve Kia replacing or repairing the HVAC wiring harness once a solution becomes available.

Your car is experiencing multiple electrical and safety system failures including a check engine light, non-functioning rear defrost, and cruise control that won't work. Your vehicle sometimes stalls while stopped and loses power while driving, and you're seeing warning messages cycling across the dashboard for tire pressure monitoring, lane departure warning, lane keeping assist, forward collision avoidance, and speed limit systems. Even after the dealer replaced a module, the same problems returned within two days, suggesting a deeper electrical issue that needs diagnosis.

Your 2023 Kia Sorento suddenly shut off while stopped at a red light and wouldn't restart, even though the dashboard lights worked. The engine wouldn't turn over, and jump-starting didn't help. A repair shop diagnosed a complete starter failure, which required replacement at a cost of approximately $500, plus $290 in towing fees. The fix will involve replacing the starter motor.

When you try to use your HVAC system, you notice a burning plastic smell inside the car with no warning lights appearing. A mechanic found that your blower motor relay short-circuited and needed replacement. Even after you replaced it yourself following the mechanic's advice, the same problem happened again. You've been notified of a related recall (NHTSA Campaign 25V649000), but your dealer told you the repair isn't available yet.

Your emergency lights have flashed unexpectedly while driving on the highway on 8 separate occasions, and when this happens, your car won't accelerate properly. You've had to pull over and restart the car to fix the problem each time. The dealership has checked your car three times but found no trouble codes, and couldn't reproduce the issue during a 70-mile test drive. The underlying electrical cause may need further diagnosis with extended test driving to identify the intermittent fault.

Your car's touchscreen display is not responding to your touch inputs the way it should. This could make it difficult to control your infotainment system, navigation, or climate settings through the screen. The issue may require a software update or replacement of the touchscreen unit itself.

The car is accelerating without anyone pressing down on the gas, not accelerating when our foot is on the gas, jerking unexplainably and the emergency brake warning is coming on when it has not been employed.

Even though the dealership reports that safety recall 23V610 / SC280 for the mounting clip replacement was completed on 2/16/24, my rearview camera has just fell out of its housing, hanging by its wires, with the mounting clips laying broken in my driveway. My rearview camera is currently unusable; its taped up so that it is not just swinging by the wires. When I contacted my dealership, they are pretty sure they can get this work covered under the warranty, but they are not sure. And my VIN# is currently not pulling up any "Active Recalls". Either the clips they used to replace the previous clips were also bad, or the dealership didnt actually complete the work as reported.

All safety features disabled, srs light turns on, vehicle shuts off when driving, guage cluster is inop doesn’t show speed.

Vehicles instrument cluster goes black at times ( speedometer, tach and all exterior lights and turn signals are inoperative during this time) I took it to the dealership and they said they couldn’t duplicate the problem

The USB ports disconnect intermittently cause maps and phone calls to disconnect temporarily. Sometimes not connecting again until I turn off and on the car.

Was driving up a hill when the 'Auto-Off' light started flashing on the driver display. Car would not accelerate above 20mph. At the top of the hill, I switched gears to neutral and the car began operating as expected; however, the same behavior occurred again at the next hill. Pulled over and restarted the car. Car worked as expected after restart. This is dangerous. I was taking my daughter to school in morning rush hour traffic. We live in a very hilly area and I'm terrified to drive the car. I dropped it off at the dealership almost 2 weeks ago and they have yet to identify the issue. I do see similar complaints on this site so I'm hoping that you are investigating.

What component or system failed or malfunctioned, and is it available for inspection upon request? I was driving and the car completely shut down- I could not use my brakes or accelerate. I had to pull along the road in ongoing traffic to coast to a stop. I lost all control. How was your safety or the safety of others put at risk? I was in traffic and the cars behind me had to slow down immediately, I could not speed up or even brake to come to a stop. Others around me as well as myself were in danger. Has the problem been reproduced or confirmed by a dealer or independent service center? They reviewed and said they scanned it and did a drive test and could not find the cause. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, It was seen at the Kia dealer I bought it from. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? As soon as the vehicle lost power there was a warning sign on the dash that showed "limit" with a half circle emblem.

While driving vehicle looses throttle power, goes into limb mode. Does not throw any codes. Turn the car off then back on and drives fine for a little bit. Has happened numerous times. Multiple trips to the dealership but since no codes pop up nothing can be fixed. Major safety issue!!!!

The vehicle was purchased new. From day one, there were issues. When it was delivered from the factory, it was discovered to be partly unpainted. This raised quality concerns. So far, the most serious has been that the motor blower failed at approximately 29,700 miles. This resulted in the vehicle filling with noxious fumes. It then had to be abandoned on the side of the highway. This led to a fire dispatch and later urgent care visits. Prior to towing, it was discovered that the AC was not working and the engine coolant reservoir was at ~ 1/4 of the minimum line. Ultimately, the vehicle was towed to King KIA. They held the vehicle for 2 weeks. They drove the vehicle 16 miles. However, they did not diagnose the problem. The only action that they took was to refill the engine coolant reservoir. Prior to pick-up, we notified the KIA Customer Service Escalation Case Manager in writing that the vehicle had not been fixed and continued to represent a safety risk to our family. They took no further action. After pick-up, the vehicle was driven approximately 35 miles before the smoke started to fill the engine cabin. It was taken to two independent mechanics along the side of the highway. One was Vienna Auto Care and the other was Jiffy Lube Auto Care. Both identified that the motor blower resistor had likely failed. The JLAC manager also identified white material on the engine manifold believed to be engine coolant. All was documented in writing. The vehicle was towed back to King KIA. Prior to towing, the JLAC manager told us that melted motor blower casing was highly toxic. (Later, the KIA Case Manager informed us that he would admit that our family was put at risk by being told to pick-up the unfixed vehicle.) He also told us that if the motor blower failed then it likely was not an isolated case. This time, the motor blower failure was reproduced. However, the engine coolant issue has yet to be resolved. We are now being instructed to pick-up the car again.

Twice while driving on the highway the engine power went off and all the safety lights flash and I could not accelerate. I was able to pull Over in neutral and restart the engine. When taken in for inspection, no problems were found. It happened again in June after the 7500 mile inspection on May 9th. This issue is life threatening as it could easily cause a fatal crash if I was not in the right lane, on flat ground, with a shoulder. There was no warning light.

The contact owns a 2023 Kia Sorento. The contact stated that the engine START/STOP feature was malfunctioning. The contact stated that while at a complete stop, the engine START/STOP system caused the vehicle to restart, and then to stall, nearly causing a crash. The battery warning light was illuminated and the message "Shift to Park to Start Vehicle" was displayed. The contact stated that the failure had been recurring intermittently. The vehicle was taken to the dealer however, the failure could not be duplicated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 1,200.

I bought a 2023 Kia Sorento SX with 11 miles on the vehicle in June of 2023, On 7/17/23, within a month and a half of driving it, it would lose all power and would not respond to excelleration, whereby coasting to the side of the road. All warning lights would come on, 3 codes popped up, one of which is the malfunction of the engine. I would turn it off and back on to reset the computer and it would drive. I took it to my local Kia service department and they cleared off the codes and couldn't recreate or duplicate the problem. On 8/23/23 I experienced the exact same experience the same scenario, but this time I could barely pull over it had loss of power and I was about to drive through an intersection. Took it back to service they performed a complete check without success they kept it for 2 weeks to try and duplicate the problem, wasn't fixed. The 3rd time on 5/06/24, same problem, they still don't know what causes the car to lose power. I am concerned that the car will cause a fatality to myself, my family, or to another motorist. This car is not safe to drive because the computer systems shut down while driving and it is sporadic and unnerving when it happens.

The contact owns a 2023 Kia Sorento. The contact stated while driving at various speeds, several unknown warning lights and messages flashed on the instrument panel. The contact was forced to pull over and restart the vehicle due to the failure. The failure was intermittent. The vehicle had been taken to the dealer on multiple occasions; however, the dealer was unable to determine the cause of the failure. The manufacturer was notified of the failure and a claim was filed. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 2,000.

Battery draining on new car after new battery replacement.

1. I have been complaining about the vehicle turning off by itself. No one is listening to me or telling me what is causing the problem. I have numerous witnesses when the car turns off by itself. It isn’t safe. It could cause a deadly accident. No it’s not the auto shut off either. I have to put the car in park and hope it restarts each time. 2. When auto shut off is in use the vehicle stalls leading it to act like it’s trying to get fuel to move and turns off. I’ve come too close to having accidents. I never know when it will do it. Sometimes I don’t drive it because I don’t want to be held liable for causing an accident and harming somebody's life. 3. I had been complaining to them that I smelled something burning but I couldn’t identify it. I asked them to keep my car and check it out and they refused. While driving in the hottest summer the AC goes out. I immediately took it to the dealership. The worker said we can’t fix it. It'll be a week before they will take my vehicle. The lady was rude and said go to another dealership. It was too hot not to have AC then on top of that it rained the rest of the week and I wasn’t able to work because I couldn’t defog my windows to drive. It finally stopped raining and I was able to get another dealership to check it out and they told me something had burned up that makes the AC work ( I have the paperwork). If they would have checked the car like I asked when I first started complaining about smelling the burning smell this could have been avoided. Also, I don’t get notifications about recalls via mail, phone, call, email etc.

Dear NHTSA, I am writing to report a serious safety issue with my 2023 Kia Sorento, purchased in February 2023 from Ken Garff Kia Avondale. In July 2023, I began experiencing alarming issues, including flashing lights, dashboard error messages, and malfunctions, despite the vehicle being unused for several days with no visible damage. The air conditioning system malfunctioned, blowing hot air even when turned off. Upon inspection at the dealership, I was told the front sensor was damaged, with a repair estimate of $1700. However, no visible damage was evident, and I believe this issue should be warranty-covered due to its electronic nature. The dealership noted that 35 others faced similar problems, raising concerns of a manufacturing issue. Despite persistent efforts and a replacement part installed nearly two weeks later, the problem persists. I've incurred nearly $500 in rental car expenses, as the situation remains unresolved, even with involvement from Kia Corporate engineers. My aim in reporting this issue is to ensure consumer safety and seek a prompt resolution, as I continue to make $1k monthly payments for an unused Sorento. I respectfully request your assistance and prompt investigation into this matter. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was driving down the highway on cruise control going 67 on a 65. The car started revving up and then proceeded to go faster. I turned off the cruise control but its continued to speed up. I stomped on the brake 4 or 5 times with no effect. I rammed into the back of a bus at 110 mph.

My passenger interior dash and glove box trim are melted. I’ve had it checked out by Kia, however they do not see where an origin could have come from. The day i noticed it, my vehicle had been hit on the front right passenger fender. The melting looked to be electrical or caused by a combustion of sort but we also believe it could have been caused by reflection off of the interior of my vehicle to that spot. I live in Michigan, the temperature was above 80*.