2006 Kia Sorento Fuel System Problems

Your car smells like fuel and loses power shortly after you start it, then stalls. After restarting multiple times, it usually works again. A mechanic replaced the fuel pump sensor three times, but the problem keeps coming back. This started happening around 122,000 miles.

Your car has a noticeable gasoline smell coming from the fuel door area. This could indicate a fuel leak or issue with the fuel cap seal. You should have the fuel system inspected to identify the source of the leak and prevent fuel loss.

Your fuel filler neck has a problem that prevents the fuel pump nozzle from fully inserting and locking into place. You have to hold the nozzle in manually and pump very slowly, or fuel won't enter the tank if you pump at normal speed. A mechanic indicated this is caused by a faulty ball valve inside the fuel tank, and there may have been a recall you didn't receive notice about.

WHEN I AM FILLING MY GAS TANK WITH GAS, THE GAS SPITS BACK OUT AT ME. THE ENGINE IS OFF WHEN I'M FILLING MY GAS TANK AND THE CAR IS STATIONARY.

CONSTANT STRONG RAW GAS ODOR INSIDE VEHICLE AND NEAR EXTERIOR REAR OF VEHICLE WHILE IGNITION OFF AND AFTER IGNITION ENGAGED. NO EXTERIOR LEAKS PRESENT. POOR GAS MILEAGE.

I HAVE HAD TO REPLACE THE LIGHTS AT LEAST THREE TIMES A YEAR ON THIS VEHICLE SINCE OWNERSHIP MANY TIMES. IN ADDITION, I HAVE HAD TO REPLACE THE FUEL PUMP 2 AND THE WHOLE STEERING SYSTEM TWICE ALSO. I WAS TOLD THAT THERE IS A RECALL ON THE VEHICLES OF MY MAKE, MODEL AND YEAR BUT NOT ON MY SPECIFIC VEHICLE. SO IM STUCK WITH A VEHICLE BREAKING DOWN ON ME AT LEAST ONCE A YEAR THAT HAS A RECALL FOR OTHER VEHICLES IN THE SAME MODEL AND YEAR. *TR

TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED THAT SHE SMELLED FUEL COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS, WHO STATED THAT THE FUEL TANK WAS LEAKING AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED BUT REFUSED ANY ASSISTANCE TO THE CONTACT. THE FAILURE MILEAGE WAS 72,900 AND THE CURRENT MILEAGE WAS 73,100.

I OWN A 2006 KIA SORENTO. SEVERAL MONTHS AGO WE NOTICED AN ISSUE WITH GAS SPRAYING BACK WHEN TRYING TO FILL THE TANK. WE WENT TO THE KIA DEALER WHERE WE BOUGHT OUR VEHICLE TO LEARN THE DEALERSHIP HAD BEEN SOLD. WE NOTIFIED THE NEW DEALER OF OUR NEED TO HAVE WARRANTY WORK DONE, EXPLAINED THE PROBLEM AND WAS TOLD THAT NO WARRANTY WORK COULD BE DONE UNTIL THEY WERE GIVEN "CODES" FROM THE PARENT COMPANY. WE MADE MANY CALLS OVER SEVERAL MONTHS AND WAS FINALLY TOLD NOT TO CALL THE DEALER, THEY HAD OUR INFORMATION AND WOULD CALL US. THE SITUATION WITH THE GAS TANK SEEMED TO SETTLE UNTIL TWO WEEK AGO WHEN THE SAME PROBLEM OCCURRED ONLY TO A GREATER DEGREE, THERE IS A GREAT DEAL OF SPRAY BACK, AND THE TANK CANNOT BE FILLED. WE RETURNED TO THE DEALER AND WAS TOLD THIS WAS A VAPOR VALVE ISSUE AND SINCE OUR CAR NOW HAD 70000 MILES THE WARRANTY WOULD NOT APPLY. THERE IS NO RECORD OF OUR CALLS NOR IS THERE ANY RECORD OF THE "CODES". I HAVE INITIATED A COMPLAINT WITH THE PARENT COMPANY, TO NO AVAIL. AFTER REVIEWING SOME OF THE LITERATURE I HAVE NOTED THAT KIA HAS HAD ISSUES SIMILAR TO THIS SINCE 1999 WITH A NHTSA INVESTIGATION OF GAS TANK LEAKS IN MAY 2006. I BELIEVE THAT THE SAME DEFECT THAT WAS IN THE KIA SPORTAGE IS IN THE KIA SORENTO. THERE SEEMS TO BE A GROWING POPULATION OF KIA OWNERS WHO ARE HAVING THE SAME ISSUE. SINCE MY ISSUE SEEMS TO BE THE SAME AS MANY OTHER KIA OWNERS WHO HAVE HAD GAS TANK PROBLEMS, I DO NOT FEEL I SHOULD HAVE TO PAY IN EXCESS OF 500 DOLLARS TO CORRECT A PROBLEM THAT KIA KNEW THEY HAD. BOTH THE DEALERSHIP AND THE PARENT COMPANY REFUSE TO ACKNOWLEDGE THIS ISSUE EVEN THOUGH THERE IS SIGNIFICANT DOCUMENTATION OF THIS EXACT ISSUE BEING INVESTIGATED OVER TIME. THANK YOU PAUL LEBLANC *TR

WE HAVE A 2006 KIA THE SUV TYPE AND THE PROBLE IS THAT WHEN WE FILLED THE GAS TANK THE GASA GAUGE WOULD WOULD GO TO EMPTY IN 32 MILES AND AL SO THE SHIFTER HANDEL POPED OUT THE HOLDER