2005 Kia Optima Body & Structure Problems

Your driver's side door lock won't open when you use the armrest switch, even though the switch itself works. Your wife was trapped in the car because she couldn't reach the manual unlock lever from the armrest switch location, and had to climb out through the passenger window to escape when the car was overheating. This could be a serious safety issue if the manual lever isn't accessible in an emergency.

Your driver's side door lock is stuck and won't unlock, making it impossible to open the door normally. You have to climb out through the passenger side instead. The door's locking mechanism needs to be repaired or replaced to restore normal operation.

Your driver's door frequently gets stuck and won't open, requiring you to pull hard repeatedly to get it to budge. Sometimes you have to crawl through the passenger door instead, and once you finally get it open, you need to leave it slightly ajar to prevent it from jamming again. The door latch mechanism or hinges may need adjustment, lubrication, or replacement.

Your driver's side door lock has been sticking for several years. While it locks fine, it won't unlock from inside the vehicle at all. To unlock it from outside, you have to turn the key while simultaneously pulling the door handle open, and it usually takes multiple attempts and a few minutes of fiddling to get it to work. The fix will likely involve replacing or repairing the door lock mechanism and internal latch assembly.

THE FRAME IS EXTENSIVE RUSTED TO THE POINT WHERE THE VEHICLE'S STRUCTURAL INTEGRITY HAS LIKELY BEEN COMPROMISED. NOTHING UNUSUAL HAS HAPPENED THAT WOULD CAUSE SUCH RUST, SUCH AS BACKING INTO SALT WATER, ETC. IT HAS BEEN DRIVEN ON SALTED NY ROADS BUT STILL, THE RUST IS EXTREME ON THIS VEHICLE EVEN WITH THAT TAKEN INTO CONSIDERATION. THE BODY HAS RUSTED EXTENSIVELY AS WELL, TO THE POINT WHERE THE REAR QUARTER PANELS BY THE REAR WHEEL ARCHES HAVE RUSTED COMPLETELY THROUGH.

TL* THE CONTACT OWNS A 2005 KIA OPTIMA. WHILE THE VEHICLE WAS PARKED, THE FRONT DRIVER SIDE DOOR WAS LOCKED AND FAILED TO OPEN FROM THE INSIDE OR OUTSIDE. THE CONTACT HAD TO GO THROUGH THE FRONT PASSENGER SIDE DOOR AND CLIMB OVER THE SEAT TO THE DRIVER'S SIDE. THE FAILURE RECURRED CONTINUOUSLY. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

KEY WILL NOT UNLOCK DRIVER'S DOOR AND DRIVER CANNOT UNLOCK DOOR FROM INSIDE VEHICLE. KIA MOTORS WILL NOT ISSUE A RECALL EVEN THOUGH THIS IS A MAJOR SAFETY ISSUE. CLIMBING OVER THE CENTER CONSOLE IS REQUIRED TO ENTER OR EXIT THE VEHICLE. THIS IS A FREQUENT ISSUE WITH KIA OPTIMA CARS, WELL KNOWN AND OFTEN WRITTEN UP ONLINE, THE PART REQUIRED TO REPAIR THE VEHICLE IS SOLD ON EBAY BY MULTIPLE SELLERS ALWAYS. *TR

TL* THE CONTACT OWNS A 2005 KIA OPTIMA. THE CONTACT STATED THAT THE DRIVER'S SIDE DOOR COULD NOT BE OPENED FROM INTERIOR OF THE VEHICLE. THE CONTACT HAD TO EXIT THE VEHICLE FROM THE PASSENGER'S SIDE DOOR. THE CONTACT TOOK THE VEHICLE TO THE DEALER, WHO STATED THAT THE DOOR LATCH AND ACTUATOR WAS DEFECTIVE. THE CONTACT HAD THE ACTUATOR REPLACED PREVIOUSLY BUT THE REPAIR DID NOT REMEDY THE DEFECT. THE FAILURE MILEAGE WAS 107,038.

DRIVERS SIDE DOOR WILL NO LONGER OPEN. WHEN I TRY TO UNLOCK IT FROM EITHER THE INSIDE OR OUTSIDE, THE UNLOCK MECHANISM WORKS, BUT THE DOOR WILL NOT OPEN. I NOW HAVE TO CRAWL IN FROM ANOTHER DOOR AND WOULD NOT BE ABLE TO GET OUT IN AN EMERGENCY. THIS APPEARS TO BE A COMMON PROBLEM WITH KIAS AND COULD CAUSE SERIOUS INJURY. THIS NEEDS TO BE ADDRESSED WITH KIA. *TR

THE DRIVER SIDE DOOR WILL NOT OPEN AFTER THE DOORS ARE LOCKED . IF YOU UNLOCK THE DOORS THE DRIVER SIDE WILL UNLOCK AND THEN RE LOCK ITSELF. IF THERE WAS TO BE A VEHICLE FIRE OR OTHER PROBLEM, THE DRIVE WOULD HAVE TO CLIMB OUT OF A WINDOW OR CROSS OVER THE CENTER CONSUL TO EXIT THE VEHICLE . THIS IS WITHOUT A DOUBT A SAFETY ISSUE THAT THE VEHICLE MANUFACTURE SHOULD BE MADE RESPONSIBLE FOR REPAIRING. *TR

TL* THE CONTACT OWNS A 2005 KIA OPTIMA. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE DOORS COULD NOT BE LOCKED. THE CONTACT COULD HEAR THE LOCKS ATTEMPTING TO LATCH, BUT THEY FAILED TO DO ACTUALLY ENGAGE. THE CONTACT HAD TO CLIMB IN AND OUT OF THE VEHICLE THROUGH THE REAR DOORS. THE CONTACT HAD NOT TAKEN THE VEHICLE TO A DEALER. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 158,338.

PASSENGER SIDE DOOR AUTOMATICALLY LOCKS WHEN YOU TRY TO OPEN IT. WHETHER IN OR OUT, IT WON'T OPEN. SOMETIMES IT WILL OPEN WITH A KEY OUT OF THE CAR, BUT WILL NOT OPEN FROM INSIDE. *TR

I HAVE HAD TO TAKE MY CAR TWICE NOW TO GET MY DRIVER SIDE DOOR OPEN, I HAVE BEEN HAVING TO CLIMB IN FROM THE PASSENGER SIDE OF MY CAR AND I HAVE HURT MY KNEES IN DOING SO. EVERYTIME I LOCK MY DOORS AND THEN UNLOCK THE DRIVER SIDE DOOR DOESN'T OPEN FROM THE INSIDE OR OUTSIDE. THIS NEEDS A RECALL .I HAVE ALREADY SEEN OTHER COMPLAINTS ABOUT THE SAME PROBLEM... *TR

TL* THE CONTACT OWNS A 2005 KIA OPTIMA. THE CONTACT STATED THAT THE FRONT DOORS DID NOT OPEN WHEN USING THE KEY, KEY FOB, OR FROM THE INTERIOR. THE CONTACT HAD TO ENTER THE VEHICLE FROM THE REAR. THE VEHICLE HAD NOT BEEN TAKEN TO THE DEALER. THE FAILURE MILEAGE WAS 73,000 AND THE CURRENT MILEAGE WAS 75,000. THE VIN WAS NOT ACCEPTED.

TL*THE CONTACT OWNS A 2005 KIA OPTIMA LX. WHILE THE VEHICLE WAS IN THE IDLE POSITION, THE CONTACT WAS UNABLE TO OPEN THE DRIVER SIDE DOOR. HE COULD NOT OPEN IT FROM THE OUTSIDE WITH THE KEY OR EVEN USING THE HANDLE INSIDE THE VEHICLE. THE CONTACT HAD TO CLIMB OUT THE FRONT PASSENGER DOOR. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 89,000.

I HAVE A 2005 KIA OPTIMA. I HAVE NOT EVEN HAD THE CAR FOR THREE YEARS AND AM HAVING A MAJOR PROBLEM. APPROXIMATELY SIX MONTHS AGO MY DRIVER SIDE DOOR WOULD NOT OPEN. I COULD NOT AFFORD TO HAVE THE CAR REPAIRED UNTIL LAST WEEK. I PICKED THE CAR UP YESTERDAY AND DID NOT DRIVE IT FOR HALF AN HOUR WHEN THE DOOR WOULD NOT OPEN AGAIN. I PAID ALMOST $400 AND THE DOOR STILL WILL NOT OPEN. IT IS BACK IN THE SHOP AND MY MECHANIC DOES NOT SEEM TO BE ABLE TO FIX THE PROBLEM. CAN ANYONE TELL ME HOW TO FIX THIS BEFORE SOMETHING TRAGIC HAPPENS TO ME AND MY SON BECAUSE OF THIS VEHICLE? I CANNOT AFFORD TO BUY ANOTHER ONE!*CW