2007 Ford Focus Suspension Problems

Your car experienced repeated wheel detachments on both the passenger and driver sides due to control arm failures, with the first two incidents occurring within weeks of each other. Three months later, while stopped at a traffic light, the front passenger wheel detached again and the transmission apparently shifted into the engine, leaving the vehicle undriveable and unsafe to tow. Additionally, your headlights flicker on and off while driving, which your mechanic couldn't resolve by replacing the bulbs. These issues suggest serious suspension damage and electrical problems that require professional diagnosis and repair of the control arms, suspension components, and electrical system.

While servicing your brakes, you noticed a small hole had rusted through your front control arm. The stamped sheet metal design was failing due to rust, and Ford discontinued this design the following model year, suggesting it was a known issue. This control arm failure can affect your car's handling and suspension alignment, potentially making it unsafe to drive.

TL* THE CONTACT OWNS A 2007 FORD FOCUS. WHILE SLOWING DOWN TO 5 MPH TO APPROACH AN INTERSECTION, THE VEHICLE DROVE OVER A POTHOLE. THE CONTACT LOST CONTROL OF THE VEHICLE, BUT MANAGED TO APPLY THE BRAKES TO STOP THE VEHICLE. THE CONTROL ARM ASSEMBLY WAS RUSTED AND SPLIT IN HALF, THE PLASTIC SHROUD WAS RIPPED, AND THE FENDER ON THE PASSENGER SIDE WAS PUSHED INTO THE FRONT PASSENGER DOOR, WHICH MADE THE DOOR DIFFICULT TO OPEN AND CLOSE. THE VEHICLE WAS TOWED TO A RESIDENTIAL HOME WHERE IT WAS DIAGNOSED. THE INDEPENDENT MECHANIC DETERMINED THAT THE LOWER CONTROL ARM FAILED. THE CONTROL ARM FAILURE WAS REPAIRED BY THE INDEPENDENT MECHANIC. THE CONTACT DID NOT NOTIFY THE MANUFACTURER OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 98,000. ..UPDATED 06/08/17 *BF *AS

TL* THE CONTACT OWNS A 2007 FORD FOCUS. WHILE DRIVING OVER 50 MPH, THE VEHICLE BECAME UNSTABLE AND WAS DIFFICULT TO DRIVE IN A STRAIGHT LINE. IN ADDITION, THE AIR BAG SENSOR AND OVERDRIVE SENSOR LIGHTS SUDDENLY ILLUMINATED WHILE OPERATING THE VEHICLE. THE CAUSE OF THE FAILURES WERE NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 155,000. UPDATED 02/18/16*LJ

TL* THE CONTACT OWNS A 2007 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 10 MPH, THERE WAS A ABNORMAL NOISE COMING FROM THE FRONT AND REAR PASSENGER SIDE OF THE VEHICLE. THE FAILURE OCCURRED MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THEY WERE RECEIVING A VEHICLE STRUCTURE ERROR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.

WHILE DRIVING ON SNOW FOR THE FIRST TIME WITH THIS VEHICLE, I EXPERIENCED SIGNIFICANT AND EXTREMELY DIFFICULT TO CONTROL FISHTAILING OF THE REAR END. I HAVE SIGNIFICANT EXPERIENCE DRIVING IN THE SNOW, THE TIRES ARE IN EXTREMELY GOOD CONDITION AND THE VEHICLE WAS CHECKED PRIOR TO THE TRIP. THE PROBLEM IS NOT WITH THE TIRES OR MAINTENANCE. THE PROBLEM IS WITH THE DESIGN OF THE SUSPENSION. AFTER THE INCIDENT, A QUICK INTERNET SEARCH REVEALS THAT THIS IS A KNOWN PROBLEM WITH THE FORD FOCUS OF THIS VINTAGE. IT IS BEYOND BELIEF THAT FORD IS UNAWARE OF THE PROBLEM. THE VEHICLE IS DEFECTIVE AND UNSAFE. WE WERE LUCKY TO KEEP THE VEHICLE UNDER CONTROL AND GET OFF THE ROAD ALIVE. ATTEMPTS TO CONTACT FORD DIRECTLY HAVE PROVEN UNSUCCESSFUL. *TR

FRONT LEFT TIRE BLEW CAUSING TO LOOSE CONTROL OF THE CAR IT WENT OFF ROAD AND SLAMMED INTO A DITCH. FRONT BUMPER AND QUARTER PANEL DAMAGE, FRONT AXLE BROKE, RIMS DENTED, SUSPENSION NEEDS TO BE REPLACED TO NAME A FEW. ALMOST 5000.00 IN DAMAGE. PERSON JERKED FORWARD ENOUGH TO HAVE CUTS IN THE CHEST/SHOULDER BY THE SEAT BELT YET THE AIRBAG DID NOT DEPLOY. *TR

SOMETHING IN THE CAR MAKES A SQUEAKY NOISE AIR CONDITIONER GAVE OUT. *TR

I HAVE A 2007 FORD FOCUS, I HAVE REPLACED THE REAR TIRES 4 TIMES SINCE I BOUGHT THE CAR. THE MECHANIC SAID ALL FOCUS EAT REAR TIRES. I HAVE READ SEVERAL OTHER REPORTS OF THE SAME ISSUE. THANKS FORD. *TR

I NOTICED A VIBRATION THAT SEEMED TO INCREASE OVER TIME OF ABOUT 2 WEEKS. I TOOK THE VEHICLE INTO THE DEALER WHERE THEY REPLACED A WHEEL BEARING AND RECOMMENDED I REPLACE THE REAR TIRES DUE TO SEVERE CUPPING. THE TIRES ARE CONTINENTAL CONTACTS WITH ABOUT 10,000 MILES ON THEM AND SHOULD HAVE LASTED THE NEXT 5 YEARS. I WENT TO THE TIRE SHOP WHERE THEY TOLD ME THAT FORD FOCUSES ARE KNOWN TO HAVE ALIGNMENT PROBLEMS AND WILL DESTROY THEIR TIRES PREMATURELY. RESEARCHING THE INTERNET I FOUND 47 SUCH COMPLAINTS OVER THE YEARS RELATING EXACTLY TO WHAT I EXPERIENCED. THE PROBLEM IS THE REAR SUSPENSION IS CAMBERED IN TOO MUCH AT THE TOP AND FORD NEVER MADE THE SUSPENSION ADJUSTABLE. MINE MEASURED 1/4 INCH DIFFERENCE BETWEEN THE TOP OF THE 15 INCH RIM COMPARED TO THE BOTTOM. THIS SITS THE CAR ON THE INSIDE EDGE OF THE TIRE CREATING THE PREMATURE WEAR. FORD MUST KNOW THIS PROBLEM EXISTS. *TR

2007 FORD FOCUS ST EXCESSIVE TIRE WEAR. AT 71,000 MILES THE VEHICLE IS DUE FOR THE FOURTH SET OF TIRES. GOODYEAR EAGLE GT P205/50-16 TIRES HAVE TWICE LASTED LESS THAN 25,000 MILES WHILE THE TIRES ARE WARRANTIED FOR 50,000 MILES. ALIGNMENT AND BALANCE ARE GOOD AND MAINTAINED, NO 'UNUSUAL' WEAR PATTERNS. MANY OWNERS OF THIS VEHICLE HAVE REPORTED SIMILAR ISSUES. *TR

TL* THE CONTACT OWNS A 2007 FORD FOCUS. THE CONTACT STATED THE TREAD ON THE REAR TIRES WAS WEARING FASTER THAN THE FRONT. THE CONTACT STATED THE WEAR WAS ON THE OUTSIDE OF THE TIRES BUT THEY REPLACED THE REAR TIRES FOR THE THIRD TIME. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THERE WAS NOTHING THAT COULD BE DONE TO THE REAR ALIGNMENT OF THE VEHICLE. THE DEALER STATED THE CONTACT HAD TO TRY AND MANAGE THE PREMATURE WEAR OF THE TIRES. THE FAILURE MILEAGE WAS 27,000 AND THE CURRENT MILEAGE WAS 57,000.

2007 FORD FOCUS HAS WORN FRONT SWAY BAR RUBBER BUSHINGS AT 41602 KM THERE IS A RATTLING SOUND UNDER VEHICLE UNIT HAS NEVER BEEN DRIVER ON GRAVEL ROADS REPAIR COST ESTIMATE $ $246.49 WARRANTY REFUSED BY FORD FACTORY CUSTOMER REP PROBLEM IS RELATED TO IMPROPER SIZING OF BUSHINGS. *TR

WHILE DRIVING WESTBOUND ON I-90 THE FRONT RIGHT TIRE ON MY 07 FORD FOCUS CAME OFF WITH ITS STRUTS STILL ATTACHED TO THE TIRE; RESULTING IN THE CAR SPINNING OUT OF CONTROL AND FLIPPING OVER A FEW TIMES BEFORE LANDING DRIVER SIDE DOWN IN THE CURB. THE CAR WAS TOTALED TO SAY THE LEAST. *TR

REAR TIRES WERE"CHOPPED" DUE TO REAR ALIGNMENT OFF. REPAIR SHOP HAD TO INSTALL SUSPENSION MODS TO GET ALIGN. HAD TO REPLACE ALL TIRES. TOTAL BILL WAS OVER $500.00. CAR WAS STILL UNDER WARRANTY (ONLY 28,000 MILES ON IT). WAS TOLD BY DEALER IT WASN'T COVERED. *TR

TL*THE CONTACT OWNS A 2007 FORD FOCUS. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD A LOUD NOISE COMING FROM THE FRONT END OF THE VEHICLE. SHE TOOK THE VEHICLE TO THE DEALER AND HAD ALL FOUR TIRES REPLACED. SHORTLY AFTER THE REPAIR, THE FAILURE RESURFACED ACCOMPANIED BY MILD DRIFTING TO THE RIGHT AND EXCESSIVE VIBRATION. SHE TOOK THE VEHICLE BACK TO THE DEALER AND WAS INFORMED THAT THE WHEEL BEARINGS CAUSED THE FAILURES. THEY RECOMMENDED THAT AN ALIGNMENT BE PERFORMED. IN ADDITION, ALL FOUR TIRES NEEDED TO BE REPLACED AGAIN. THE TIRE SPECIALIST STATED THAT THE A COMPONENT ON THE VEHICLE WAS CAUSING THE TIRES TO FAIL. THE VEHICLE HAS NOT BEEN REPAIRED AGAIN. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 5,000 AND CURRENT MILEAGE WAS 36,000.

I WAS DRIVING MY 2007 FORD FOCUS WITH 40K MILES ON A HIGHWAY GOING ABOUT 60MPH. I HEARD/FELT A VIBRATION FROM THE REAR OF THE VEHICLE. I THOUGHT THE MUFFLER WAS COMING LOOSE. THEN THE LEFT REAR WHEEL CAME OFF THE CAR. THERE WERE NO CARS BEHIND ME AND I WAS IN THE RIGHT HAND LANE SO I MADE IT TO THE SHOULDER. THE WHEEL BEARING HAD FAILED. THE COST TO REPAIR IT WAS $500. I SEE THERE WAS A RECALL ON 2007 FORDS FOR A SIMILAR PROBLEM 07V270000 WITH WHEELS COMING OFF BUT THAT WAS FOR FRONT WHEELS OF REAR WHEEL DRIVE CARS. I HAD THE CAR IN FOR THE 35K MAINTENANCE IN SEPTEMBER AND HAD NOT BEEN IN ANY ACCIDENTS, OR HAD ANY SERVICE DONE TO THE CAR SINCE THEN. THE DEALERSHIP EMPLOYEES SAID IT WAS UNUSUAL FOR A CAR WITH JUST 40K MILES TO HAVE THAT TYPE OF FAILURE AND SAW NOTHING, PARTS MELTED, ETC TO INDICATE ANYTHING OTHER THAN THE BEARING FAILURE. THE FLAT BED DRIVER STOPPED AND PICKED UP THE WHEEL AND IT WAS REATTACHED TO THE SPINDLE. THE CAR IS ONLY 2 YEARS OLD AND I HAVE TO DRIVE IT THOUGH I CAN NO LONGER TRUST IT. I WAS PLANNING TO DRIVE TO FLORIDA WITH MY DAUGHTER TO TAKE HER TO COLLEGE IN 4 WEEKS SO IT WAS A MERCY IT FAILED NOW RATHER THAN COMING DOWN A STEEP HIGHWAY IN KENTUCKY DOING 75. I WILL HAVE TO GIVE HER MY OTHER CAR TO KEEP AS I CANNOT TRUST THE FOCUS. *TRW

2007 FORD FOCUS 6 TIRES BOUGHT IN LITTLE UNDER 30,000 MILES DEALER SAID NOR ROTATING ENOUGH. ANOTHER FORD DEAL SAID IT FOCUS IS A HIGH TIRE MAINTENANCE CAR GET RID OF IT. THE WHEEL ALIGNMENTS SO EXTREME TILT TIRES ARE CUPPING ON THE INSIDE BUT IF FACT SPECS. INDEPENDENT TIRE DEALER SAID THIS IS A TYPICAL FOCUS AND THERE IS A FIX AT THE COST OF $500.00 TO SET THE NUMBERS CLOSER TO 0 .THE TIRES ARE WEARING IN THE DIRECTION THE TILT SHOWS. DEALER SAYS ROTATE MORE TIRE DEALER SAYS THE NUMBERS ARE NOT RIGHT I THINK IF THERE IS A FIX THEN THERE IS A DESIGN FLAW AND THE DEALER SHOULD PAY FOR THIS BECAUSE SEEM TO BE A MAJOR ISSUE I SHOULD NOT HAVE TO ROTATE EVERY 3000 MILES. *TR

FOR ABOUT A MONTH BEFORE BRINGING MY CAR TO FORD I HAD BEEN NOTICING A VIBRATION FEELING IN THE STEERING WHEEL THOUGH THE WHEEL WAS NOT SHAKING. THIS WAS ONLY HAPPENING WHEN I WAS GOING FASTER THAN 50-55MPH. I CHECKED THE AIR PRESSURE IN THE TIRES AND ALL WAS OK. FINALLY, I BROUGHT IT TO FORD AND THEY FOUND A BENT CONTROL ARM IN THE FRONT R/S. IN ADDITION, THEY FOUND A SLIPPED BELT ON THE L/R TIRE AND R/F TIRE HAD UNEVEN WEAR. OK, SO HERE'S MY COMPLAINT....THERE IS NO WAY THAT I HIT ANYTHING SO HARD THAT I BENT MY CONTROL ARM IN THE FIRST PLACE!!!! SINCE THERE IS NO WAY TO PROVE THIS I HAD TO LIVE WITH THE FACT THAT I WOULD HAVE TO PAY FOR THIS REPAIR - ALMOST $400.00. THE PROBLEM I HAVE IS WITH THE TIRES. SINCE THE REPAIR IN THE FRONT WAS THE SAME PLACE THAT THE TIRE HAD UNEVEN WEAR, I HAD TO EAT THIS ONE TOO - $125.00. THE PROBLEM IS, WHAT ABOUT THIS SLIPPED BELT IN THE REAR TIRE? I GUESS I WAS TO BLAME FOR THAT ONE TOO. MAYBE THESE PIRELLI TIRES ARE THE PROBLEM. I SHOULD HAVE READ THE COMPLAINTS HERE BEFORE I BROUGHT THE CAR BACK TO FORD. FORD DIDN'T HAVE ANY OTHER TIRES THAT FIT THESE RIMS, BUT THE SAME PIRELLI'S THAT WERE ON THE CAR IN THE FIRST PLACE. SINCE THE CAR WAS ALREADY IN THE SHOP AND MY TIME IS LIMITED, I WAS STUCK GETTING THE SAME JUNK. MY MESSAGE....DON'T MAKE THE MISTAKE I MADE - DO NOT REPLACE THE TIRES ON YOUR FOCUS WITH THE PIRELLI'S THAT CAME WITH THE CAR. IF I CAN SAVE SOME PEOPLE A FEW HEADACHES AND SOME MONEY, I WILL FEEL MUCH BETTER FOR THE MISTAKE THAT I MADE. *TR

SEVERE TIRE WOBBLE. TOOK THE CAR TO DEALER. THEY SAID IT NEEDED ALIGNMENT AND 2 NEW TIRES. TOOK TO A TIRE DEALER THEY SAID THAT THEY HAVE HAD MANY OF THE SAME CARS IN THERE WITH THE SAME PROBLEM. IT'S THAT THE REAR WHEELS ARE TOED-IN 50% TO MUCH FROM THE FACTORY SPECS AND IT JUST CHOPS THE TIRES UP. THE CAR NEEDS 2 NEW TIRES AND A ALIGNMENT JOB TO FIX THE PROBLEM FROM THE FACTORY. I FEEL THAT THE COMPANY SHOULD PAY FOR IT , SINCE IT COMES OFF THE LINE LIKE THAT. *TR

2007 FOCUS 3 DOOR SES PURCHASED NEW IN 11-06. BEGAN NOTICING MINOR STEERING WHEEL VIBRATIONS AFTER 6 MONTHS AND DEALER HAD ROTATED TIRES AT 8K MILES. AT 14 MONTHS AND 17K MILES THE STEERING WHEEL VIBRATION BECAME UNACCEPTABLE. DEALER DID A FRONT ALIGNMENT AFTER TELLING ME THE WHEELS WERE WAY OUT OF SPEC. THE PIRELLI P6 ORIGINAL TIRES ARE NOW SEVERELY WORN IN MISALIGNMENT PATTERNS AND MUST BE REPLACED. VERY DISAPPOINTED. IF YOU OWN A FOCUS AND HAVE ANY UNUSUAL FEEL IN THE STEERING AND HANDLING, GET IT CHECKED ASAP. *TR

RIGHT REAR SHOCK ABSORBER WAS LEAKING. THIS CAUSES PREMATURE TIRE WEAR (CUPPING) AND UNSAFE HANDLING CONDITIONS. VEHICLE HAD LESS THAN 1,000 MILES ON IT. SHOCK ABSORBER WAS PROBABLY DEFECTIVE FROM MANUFACTURER AND FORD FAILED TO INSPECT OR NOTICE THIS DEFECT. FORD REPLACED THE PART AT MY REQUEST AFTER I NOTICED LEAKING ITEM. FORD PART # 7S4Z*18125*AR. *NM