2005 Ford Escape Brakes Problems

Your brake pedal went completely to the floor with little resistance while backing out of a parking space, leaving you unable to stop the car. The ABS and brake warning lights came on, and you heard a loud warning noise, but had to coast slowly and use the emergency brake to get home safely. The problem disappeared the next day, but this is a serious safety concern that needs immediate professional diagnosis.

Brake Hydraulic Control Unit failed loss of braking.

Abs and master cylinder causing an unsafe braking condition hard brake pedal making it very difficult to stop the car. I replaced the entire brake system including the master cylinder assembly with pedal travel sensor attached. As recommended by Ford dealership. Then I was told that the brake system system had to be bled 2 times. Well after doing this 3 times and replacing the calipers and pads and rotors again. The same situation exists. Now I am told that this car has a different problem and a bulletin was issued by Ford stating that this is a problem with Ford Escape hybrid has to be reprogrammed to allow the master cylinder assembly to link up with the computer to rectify the issue. My car has 42000 miles on the vehicle and I is very dangerous to drive because of the unreliable braking action. Ford does not acknowledge the problem. But there are many people who have had this same issue. What can I do ? Please help me.

COMPLETE BRAKE FAILURE. DRIVEN HOME AT 40 MPH AND THE BRAKE LIGHT AND THE ABS LIGHT CAME ON AND THERE WAS A BEEP. THERE WERE THEN NO BRAKES AT ALL. LUCKILY, I WAS ABLE TO GET TO THE SIDE OF THE ROAD AND COAST TO A STOP. TURNED OFF THE TRUCK AND STARTED IT AGAIN AND IT HAD BRAKES. ON THIS LAST INCIDENT, THE SAME THING IN THE SAME ORDER HAPPENED. THIS PROBLEM IS VERY DANGEROUS. IT IS INTERMITTENT THUS MAKING IT HARD TO DIAGNOSE.

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. WHILE DRIVING 35 MPH, THE BRAKES FAILED. THE CONTACT HAD TO ENGAGE THE PARKING BRAKE TO STOP THE VEHICLE. ALSO, THE ABS WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO JERRY'S FORD ALEXANDRIA (6510 LITTLE RIVER TURNPIKE, ALEXANDRIA, VA 22312, (703) 256-5000), BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 116,000. THE VIN WAS NOT AVAILABLE.

WHILE COMING UP TO A STOP SIGN THE BRAKES STOPPED WORKING. LUCKILY THERE WERE NO CARS IN FRONT OF ME AS THE CAR CONTINUED TO ROLL PASS THE STOP SIGN. FLOORING THE BRAKES CAUSED THE CAR TO SLOW DOWN SLOWLY. I ENDED UP PULLING OVER IMMEDIATELY, TURNING OFF THE VEHICLE AND INSPECTING THE VEHICLE. I SAW NO CLEAR INDICATION OF ANYTHING BEING WRONG. WHEN I TURNED BACK ON THE VEHICLE EVERYTHING WAS FINE, UNTIL THE SAME THING HAPPENED THE NEXT DAY. I TOOK THE CAR TO A FEW CAR SHOPS BUT NO ONE COULD FIND ANYTHING WRONG WITH IT. THE CAR WAS EVEN TAKEN FOR A TEST DRIVE BY THE MECHANIC BUT PERFORMED WITH NO PROBLEMS. ONE OF THE SHOPS RECOMMENDED I REPLACE THE MASTER CYLINDER OR THE HYDRAULIC CONTROL UNIT BUT COULD NOT GUARANTEE THE PROBLEM WOULD NEVER OCCUR AGAIN. I DON'T FEEL COMFORTABLE PAYING SO MUCH FOR A NON GUARANTEED JOB SO UNFORTUNATELY I AM STILL DRIVING THE VEHICLE AND THE BRAKES CONTINUES TO STOP WORKING AT RANDOM TIMES.

ABS LIGHT IS ON CONSTANTLY MY BRAKES ARENT WORKING PROPERLY TIMES WHEN IT DIDNT STOP HAD TO SHIFT INTO LOW GEAR AND PULL OFF TO SAFE SPIOT I WAS TRYING TO STOP

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. WHILE DRIVING 30 MPH, THE "PULL OVER SAFELY NOW" WARNING INDICATOR ILLUMINATED AND THE VEHICLE CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE CONTACT STATED THAT THE BRAKING SYSTEM FAILED TO OPERATE AS INTENDED. THE CRASH OCCURRED WHILE THE CONTACT WAS EN ROUTE TO COCCIA FORD LINCOLN INC (LOCATED AT 577 E MAIN ST, WILKES-BARRE, PA 18702, (570) 823-8888) TO HAVE THE VEHICLE REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V526000 (HYBRID PROPULSION SYSTEM). THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ISSUED CASE NUMBER: CAS-14733790. THE APPROXIMATE FAILURE MILEAGE WAS 174,109.

HYDRAULIC CONTROL UNIT FAILED. HCU. LITTLE OR NO BRAKES, CITY STREET

ABS AND BRAKE LIGHT ILLUMINATE (WITH SERVICE BRAKE SYSTEM DISPLAYED) AND BRAKE PEDAL GOES ALL THE WAY TO THE FLOOR. BRAKES FAIL TO MANUAL BRAKES ONLY, VERY SENSITIVE AND WILL LOCK THE WHEELS UP; TOUCHY WITH NO REAL FEED BACK, JUST APPLIED OR OFF WITH SIGNIFICANT PRESSURE REQUIRED. HAPPENED WHEN PULLING INTO A GAS STATION AND NEARLY WENT PAST THE PUMP, BUT SKIDDED TO A STOP INSTEAD. SYSTEM RESETS WITH EACH KEY CYCLE ON/OFF. IT IS SOMEWHAT INTERMITTENT. WHILE WAITING FOR MY FORD APPOINTMENT (CAVALIER FORD IN CHESAPEAKE, VA), I DUPLICATED THE EVENT SEVERAL TIMES UNDER A CONTROLLED, OPEN PARKING LOT TEST AND DRIVE TO THE DEALERSHIP. DEALERSHIP RAN DIAGNOSTICS, AND COULD NOT DUPLICATE. THE RECOMMEND REPLACING BRAKE LINES, THEN MASTER CYLINDER, THEN HCU. REPAIRS IN ORDER ARE $615, $1400, AND OVER $4900. DIAGNOSTICS RAN $130...WITH NO DEFINITIVE ANSWER TO MY PROBLEM.

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER (TOMMIE VAUGHN FORD, 1201 N SHEPHERD DR, HOUSTON, TX 77008, (713) 869-4661) SEVERAL TIMES AND THEY WERE UNABLE TO PROVIDE A SOLUTION. THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND A MULTI-POINT INSPECTION WAS PERFORMED. THE DEALER DETERMINED THAT THE BRAKE MASTER CYLINDER AND THE HCU NEEDED TO BE REPLACED. THE MANUFACTURER HAD EIGHT TSBS FOR THE SERVICE BRAKES, HYDRAULICS AND ONE FOR THE SERVICE BRAKES, AIR. THERE WAS NO RECALL CAMPAIGN. THE VEHICLE WAS STILL AT THE DEALER TO BE SERVICED WITH NO SOLUTION OTHER THAN REPLACING THE PARTS. THE FAILURE MILEAGE WAS NOT AVAILABLE.

BRAKE LIGHT BEEPS AND THE BRAKES SUDDENLY GO OUT SO THAT YOU CAN BARELY STOP THE CAR.

WHILE DRIVING DOWN THE ROAD, I HEAR AN ALARM FOR "SERVICE BRAKE SYSTEM", AND LOSE ALL POWER TO MY BRAKES. PEDAL IS DEPRESSED TO THE FLOOR WITH MINIMAL ABILITY TO STOP.

WHEN BRAKE PEDAL IS APPLIED WITH CONSTANT PRESSURE, BRAKES WOULD ENGAGE THEN FAIL TO ENGAGE FOR SHORT SECONDS, THEN ENGAGE AGAIN, SYMPTOMS ARE INTERMITTENT. SOME TIMES IT WOULD TRIGGER A BRAKE RELATED DTC. TECHNICIAN DETERMINED IT WAS A FAILED HYDRAULIC CONTROL UNIT IN THE BRAKE SYSTEM AND WAS TOLD IT WAS COMMON AND OCCURRED ON A NUMBER OF THE SAME MODEL VEHICLES FROM 2005 TO 2012.

ABS LIGHT ON, VERY WEAK AND DIMINISHED BRAKING POWER, ALMOST NOT STOPPING, VEHICLE WAS OFF, THEN NOTICED UPON STARTUP, 123K MILES ON VEHICLE, FORD STATES IT COULD BE UP TO A $5K REPAIR WHICH FAR EXCEEDES THE VALUE OF THIS VEHICLE, SUSPECT PART IS THE HCU HYDRAULIC CONTROL UNIT WHICH PRESSURIZES THE BREAK SYSTEM BEFORE START UP, ALSO NOTICED THIS PUMP ISN'T COMING ON ANYMORE, FORD SAYS THEY WON'T COVER ANYTHING OF REPAIR, NO MORE FORDS OR CHEVY'S FOR ME!, YOU HAVE TO KILL AT LEAST 125 PEOPLE BEFORE THEY WILL RECALL ANYTHING JUST LIKE THE $2.25 IGNITION KEY RECALL, WHAT ABOUT THE 180+ PEOPLE FORDS PINTO EXPLODING FUEL TANKS, BECAUSE OF BREAK AWAY FUEL NECKS, LIVES AREN'T WORTH $8EA, TO INSTALL THE RUBBER BLADDER ARE THEY?, THANKS FOR MAKING ANOTHER THROW AWAY CAR JUST LIKE THE CHEVY VEGA, NOW FORD HAS ANOTHER TO ADD TO PINTO, EDSEL, MAVERICK? WHERE DID THEY GO? WHICH ONE'S NEXT? DON'T BUY HYBRID, NOT GOOD TECHNOLGY, DOESNT EVEN GET VERY GOOD MILEAGE , 26? IS ALL I GOT!, THANKS AGAIN FORD MOTORS, HOPE HENRY IS ROLLING OVER IN HEAVEN FOR YOUR IDIOT ENGINEERS THAT WOULD DESIGN A SYSTEM THAT IS BEYOND ECONOMICAL SENSE TO REPAIR.!!!

BRAKES GO STIFF AT RANDOM TIMES WHILE DRIVING FOR NO PRESENTED REASON AND CAUSE A SHOCK TO DRIVER AND HAVE TO LET GO OF BRAKES THEN PRESS DOWN TO SEE IF THEY WILL WORK. HAPPENS IN MOST IF NOT ALL KIDS OF CONDITIONS, NOT JUST ONE SPECIFIC KIND OF SITUATION. HAS HAPPENED AT LEAST 10 TIMES IN THE PAST 6 MONTHS.

INTERMITTENT LOSS OF BRAKING OVER THE PAST 12 MONTHS, WITH THE 3RD OCCURRENCE RESULTING IN A COLLISION ON JUNE 28, 2016 ON A CITY STREET. VEHICLE HAS HAD INTERMITTENT BRAKE AND ABS WARNING LIGHTS WITH NO DIAGNOSTIC CODES, AND WARNING LIGHTS EVENTUALLY RESET WITH NO ADDITIONAL ACTION TAKEN. BRAKE SYSTEM HAS BEEN SERVICED SEVERAL TIMES WITHOUT RESOLUTION.

AFTER DRIVING EVEN SHORT DISTANCES, THE VEHICLE IS REAL REAL HOT.HAD NEW BRAKES PUT ON AND THEY STILL SQUEEL

BOTH FRONT BRAKE CALIPER FLEXIBLE BRAKE LINES FAILED AT THE SAME TIME. I WAS FORTUNATE THAT I WAS AT LOW SPEED, HOOKING UP MY TRAILER AT THE TIME. NO ACCIDENT OCCURRED. THE BRAKE FLUID DUMPED ON THE INSIDE OF BOTH FRONT TIRES.

IN NORMAL DRIVING, WITH NO WARNING, "BRAKE" AND "ABS" WARNING LIGHTS ILLUMINATE ALONG WITH "SERVICE BRAKE SYSTEM" DISPLAY. CONSIDERABLE EFFORT IS REQUIRED TO SLOW THE VEHICLE AND STOPPING DISTANCE IS 2-3 TIMES NORMAL. I ENDED UP IN A DITCH BECAUSE I COULD NOT STOP IN TIME.

BRAKE ABS BRAKE LIGHT ON AND BRAKES DO WORK RIGHT, I TOOK IT TO A DEALER AND THEY SAID SOME KIND OF PUMP IS BAD AND IT COST $5000 TO FIT IT. LOTS OF PEOPLE HAVING THE SAME PROBLEM. I THINK FORD SHOULD RECALL THOSE CARS FOR SAFETY. I DON'T THINK NO BRAKES SHOULD COST $5000 TO FIT. I M SCARE TO DRIVE IT.

COMPUTER CONTROLLING THE BRAKES MALFUNCTION. I WAS ON A STATE HYWAY WHEN THE DASH LIGHT CAME ON TO WARN OF BRAKE FAILURE, AND A COUPLE OF SECONDS LATER I HAD NO BRAKES. I TURNED THE MOTOR OFF AND BACK ON, AND I HAD BRAKES. THIS HAPPENED OFF AND ON UNTIL I WAS ON LADSON ROAD GOING TO A FRIENDS HOUSE AND THE BRAKES WOULD NOT WORK AND I HAD TO CALL A TOW TRUCK AND BE TOWED HOME. THIS SCARES ME AND I WILL NOT DRIVE THE CAR UNTIL IT IS FIXED. FORD SAYS IT WILL COST 5000.00 TO FIX IT. I HAVE TO GET MY SON TO CARRY EVERYWHERE. I AM 82 YEARS OLD AND NEED MY CAR !!!!....UPDATED 06/15/16 *BF

I WAS ON LADSON ROAD IN THE MIDDLE OF THE HYWAY AND NO BRAKES. THE LIGHT CAME ON JUST BEFORE MY BRAKES WENT OUT. I HAD TO HAVE A TOW TRUCK TAKE ME HOME. I AM AFRAID TO DRIVE MY CAR. TEN YEARS I HAVE HAD NO TROUBLE. I HAVE TO HAVE MY SON TAKE ME ANYWHERE I HAVE TO GO. IT IS NOT VERY GOOD. THIS IS THE SECOND TIME I HAVE REPORTED TO YOU ABOUT THIS SITUATION. THE NUMBER YOU GAVE ME #14V526000. REPORT #7695006-V3DOZ3.

ON LADSON, SC ROAD MY BRAKE LIGHT WARNING CAME ON AND I HAD NO BRAKES. THIS HAPPENED THREE TIMES BEFORE, BUT I PULLED OFF THE ROAD AND TURNED THE ENGINE OFF THEN TURNED BACK ON AND BRAKES WORKED. THIS TIME ON LADSON ROAD, I COULD NOT GET THE BRAKES TO WORK, AND I HAD TO CALL A TOW TRUCK TO TAKE THE CAR HOME. I CANNOT DRIVE THE CAR, AND FEEL STRANDED AT HOME. I AM AN 82 YEAR OLD WIDOW. I HAVE TO GET MY SON TO TAKE ME WHERE I NEED TO GO. HE HAS TO GET OFF WORK TO DO THIS. I NEED MY CAR. PLEASE HELP. ACCORDING TO THE FORD COMPANY IT COSTS $5000.00 TO FIX. I DO NOT HAVE $5000.00. I LIVE ON A FIXED INCOME.

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT THE BRAKE PEDAL WAS APPLIED AND DID NOT RESPOND. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V526000 (HYBRID PROPULSION SYSTEM) AND WAS UNABLE TO DETERMINE WHEN THE REMEDY AND PART WOULD BECOME AVAILABLE TO COMPLETE THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 172,912. UPDATED 11/19/15*LJ

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 35 MPH, THE ABS CAUSED THE VEHICLE TO SLIDE EVEN WHEN THE BRAKE PEDAL WAS DEPRESSED. THE ABS LIGHT ILLUMINATED AFTER THE FAILURE OCCURRED. THE DEALER DIAGNOSED THAT THE FRONT PASSENGER SIDE TONE RING MALFUNCTIONED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 57,736.

ABS AND BRAKE LAMP ON. NO ANTILOCK BRAKES BEARLY STOPS.

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. WHILE DRIVING AT ANY SPEED, THE CONTACT WOULD EXPERIENCE A SPORADIC LOSS OF BRAKE CONTROL. THE ABS AND THE BRAKE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC STATED THAT THE MASTER CYLINDER FAILED. THE VEHICLE WAS REPAIRED HOWEVER THE WARNING LIGHTS CONTINUED TO ILLUMINATED . THE MECHANIC THEN STATED THE HYDRAULIC CONTROL UNIT WOULD ALSO HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 200,000.

FIRST, SPORADIC LOSS OF BRAKE CONTROL; VERY BRIEF; THEN, ABS AND BRAKES LIGHTS CAME ON. DASH SAID "SERVICE BRAKE SYSTEM." BROUGHT IT TO LOCAL DEALER, WHO SAID IT NEEDS A NEW MASTER CYLINDER & HCU. *TR

DRIVING DOWN THE HIGHWAY WITH MY FAMILY, A CAR SWERVED INTO OUR LANE CUTTING US OFF. WE HIT THE BRAKES, THE ABS AND BRAKE LIGHT CAME ON AND THE BRAKES ONLY WORKED WHEN WE SLAMMED ON THEM! HAD TO HAVE THE CAR TOWED AS IT WAS NOT DRIVABLE. MECHANIC SAID IT NEEDED A NEW ABS CONTROL MODULE. ORDERED THAT PART TWICE. TOOK CAR TO CAR COMPUTER SPECIALIST - SAID CAR WAS COULD NOT BE REPROGRAMMED. BILL IS NOW OVER $2,000 AND IT HAS BEEN OVER 2 WEEKS. MECHANIC CALLED FORD (LOTS OF COMPLAINTS ONLINE ABOUT THIS ISSUE). THEY SAID THEY COULD TRY TO REPROGRAM IT, BUT IT COULD TAKE UP TO 10 HOURS AND MAY NOT WORK. FORD SAID THE LAST PROBLEM THEY SAW LIKE THIS DIDN'T WORK AND THE OWNER HAD TO TRADE IN FOR A NEW CAR! NOT ONLY COULD THIS INCIDENT HAVE SERIOUSLY HARMED MY FAMILY, BUT NOW I'M OUT OF A CAR AND $2,000!

I WAS STOPPED AT A DRIVE THRU LINE MY CAR MADE A NOISE I DON'T KNOW HOW TO DESCRIBE ACCURATELY WITH WORDS. I LOOKED DOWN AND MY ABS AND BRAKE LIGHT WERE ON AND THE BRAKE SERVICE NEEDED WAS ON THE DASH DISPLAY. I PUT THE CAR IN PARK AND TURNED THE CAR OFF THEN ON. ALL THE SAME WARNINGS WERE STILL THERE. I PULLED FORWARD SLOWLY AND WHEN BRAKING I STILL DIDN'T STOP IN A REASONABLE TIME AND ALMOST COMPLETELY MISSED THE DRIVE THRU WINDOW. NEEDLESS TO SAY A DRIVE HOME AT 10-15MPH STILL FELT LIKE I WAS IN DANGER OF HITTING SOMEONE BECAUSE I COULD NOT JUDGE STOPPING DISTANCE EVEN WITH MY FOOT APPLYING FULL PRESSURE ON THE BRAKES. FROM ALL THE INFORMATION I HAVE FOUND ON LINE THIS SEEMS A VERY APPARENT CASE OF SOMETHING FORD SHOULD BE MAKING A RECALL ISSUE OF HIGH IMPORTANCE. I AM HOPING MY REPORTING IT HERE MAY HELP IN PREVENTING SOMETHING VERY DANGEROUS FROM HAPPENING IN THE FUTURE. *TR

I HAD TO HAVE TONE RINGS REPLACED ON ABS SYSTEM ON DRIVERS AND PASSENGERS SIDE FRONT WHEELS. HAD THE WORK DONE AT FORD DEALERSHIP 2 MONTHS AGO. YESTERDAY I WAS PULLING OUT ON TO MAIN ROAD AND LOST ALL BRAKES. *JS

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 30 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE REAR BRAKE HOSES NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 86,000.

I GOT AN 'ABS' LIGHT ON, AND THE PANEL TOLD ME 'SERVICES BRAKE SYSTEM'. *TR

HAVE HAD TO REPLACE ALL 4 FLEXIBLE BRAKE HOSES. THE RF FAILED ON 3/15/2012 AT 82553 MILES, THE LF FAILED ON 11/7/2013 AT 98681, THE RR FAILED ON 8/28/2014 AT 111325, THE LR WAS INSPECTED AND REPLACED ON 8/29/2014, SINCE A SEVERE CRACK WAS FOUND. IN ALL 3 CASES, THE HOSE FAILURES LED TO A TOTAL LOSS OF BRAKING. *TR

THE BRAKES FAILED ON THE CAR. AT FIRST IT LOCKED AND THEN THE PEDAL WENT ALL THE WAY TO THE FLOOR. I DIDN'T HIT THEM AGAIN AND COASTED TO A STOP FINALLY PUTTING ON THE PARKING BRAKE. THEN I HAD THE CAR TOWED. THIS HAPPENED AGAIN ABOUT FIVE WEEKS LATER AND THIS TIME IT WAS EXACTLY THE SAME BUT, I HIT THE BRAKES A THIRD TIME AND THE CAR STOPPED. AFTER THE FIRST INCIDENT, THE MECHANIC TRIED TO RECREATE THE PROBLEM AND COULD NOT. THIS SAME THING HAPPENED A FEW YEARS AGO AND WE REPLACED -- AT GREAT EXPENSE -- THE HYDRAULIC CONTROL UNIT. I THINK THIS IS A DEFECT IN THIS CAR. *TR

SECOND TIME IN 3.8 YEARS ABS AND 4X4 BRAKES BROKE, ABS FLASHING, STEADY ON, 4X4 FLASHING LOOSE BRAKES TONE RING ISSUES, FORD DOES NOT RECOGNIZE THERE ARE ISSUES, TONS OF COMPLAINTS EXCESSIVELY EXPENSIVE TO FIX, UNSAFE, ALSO SUSPENSION BARING JOINTS BRAKE EASY, BRAKES WEAR OUT FAST, I DRIVE UNDER 12K A YEAR. EXHAUST A PIECE OF JUNK, THERE SHOULD BE RECALLS, THEY REFUSE TO ACKNOWLEDGE ISSUE. *TR

WHILE DRIVING, THE BRAKING POWER WAS LOST AND THE ABS AND BRAKE INDICATORS APPEARED. THIS HAS HAPPENED SEVERAL TIMES OVER THE COURSE OF THE PAST MONTH. FORTUNATELY I HAVE NOT BEEN ON THE HIGHWAY, BUT THERE HAVE BEEN SOME NEAR MISSES...ACCIDENTS NARROWLY AVERTED. THIS BLOG (HTTP://BLOG.YAGELSKI.COM/2010/01/MY-FORD-ESCAPE-HYBRID-BRAKE-REPAIR.HTML) BY KEN YAGELSKI DETAILS HIS SIMILAR SAGA, AND HE ENDED UP PAYING OVER $7,000 IN REPAIR COSTS. I CANNOT AFFORD THAT KIND OF BILL, AND I DON'T FEEL I SHOULD HAVE TO PAY IT WHEN IT IS A KNOWN DESIGN FLAW. PLEASE HELP! *JS

I WAS BACKING OUT OF MY GARAGE INTO MY DRIVEWAY, WHEN I TRIED TO STOP THERE WAS NO BRAKE CONTROL AT ALL. I KEPT ACCELERATING DOWN THE DRIVEWAY STOMPING ON THE BRAKES SEVERAL TIMES UNTIL I WAS ABLE TO STOP THE CAR BRIEFLY ENOUGH TO THROW THE CAR BACK INTO PARK. WHEN I EXITED THE VEHICLE I NOTICED A PUDDLE ON MY GARAGE FLOOR AS WELL AS ALL OVER MY DRIVER SIDE FRONT TIRE. I CHECKED THE BRAKE FLUID LEVEL AND IT WAS COMPLETELY EMPTY. I HAD IT TOWED TO A SERVICE GARAGE AND THEY DIAGNOSED THE ISSUE AS BEING A CORRODED AND RUPTURED DRIVERS SIDE BRAKE LINE AND A PASSENGER SIDE BRAKE LINE THAT WAS CRACKED IN SEVERAL PLACES. I HAVE SINCE SEEN A FEW DOZEN COMPLAINTS ON THIS SITE REGARDING THE SAME ISSUE WITH MY VINTAGE FORD ESCAPE. I CANNOT BELIEVE THERE HAS NOT BEEN A RECALL ON THIS ISSUE. BOTH THE TOW TRUCK DRIVER AND THE SERVICE GARAGE SAID THEY HAVE HAD NUMEROUS FORDS WITH THE SAME ISSUE. I'M VERY DISAPPOINTED IN FORD FOR NOT ISSUING A RECALL ON SOMETHING AS DANGEROUS AS BRAKE FUNCTIONING. I HAVE BEEN A LIFELONG FORD BUYER BUT NOW I AM THINKING TWICE ABOUT BUYING ANOTHER ONE.....EVEN THOUGH I LOVE MY ESCAPE AND WAS GOING TO BE PURCHASING ANOTHER ONE WITHIN THE NEXT YEAR. I HOPE THAT NO ONE IS INJURED OR GOD FORBID DIES BECAUSE OF THIS ISSUE. FORD OWES IT TO THEIR OWNERS TO PERFORM RECALLS ON ANY ISSUE THAT COULD BE DANGEROUS OR LIFE THREATENING. I OF COURSE TOLD EVERYONE I KNOW THAT OWNS A FORD ESCAPE TO HAVE THEIR BRAKE LINES CHECKED IMMEDIATELY BEFORE IT'S TOO LATE. *JS

WHILE COMING UP TO A STOP SIGN I STARTED TO PRESS MY BRAKE AND WHILE COMING TO A STOP THE BRAKES STOPPED WORKING ALLOWING MY VEHICLE TO LUNGE FORWARD A FEW FEET WITHOUT ANY BRAKES BEFORE THE BRAKES KICKED BACK IN BRINGING MY CAR TO A STOP. ALSO WHILE IDLING AROUND A PARKING LOT MY ABS STARTED ENGAGING CAUSING MY VEHICLE TO START JERKING FORWARD, I WASN'T EVEN TOUCHING THE BRAKES. *TR

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE BRAKES MALFUNCTIONED AND FAILED TO STOP THE VEHICLE. THE CONTACT INDICATED THAT WHEN PRESSING THE BRAKE PEDAL THE PEDAL WAS PUSHED TO THE FLOORBOARD. THE CONTACT HAD TO USE THE PARKING BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BRAKE LINES HAD CORRODED AND THE BRAKE FLUID HAD DRAINED FROM THE VEHICLE. THE VEHICLE WAS REPAIRED AND THE DEFECT WAS REMEDIED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE FAILURE MILEAGE WAS 85,000.

BRAKES FAILED COMPLETELY DESPITE ONE MONTH PRIOR SERVICING OF BRAKES AT LOCAL BILL BRANDT FORD DEALERSHIP IN BRENTWOOD CALIFORNIA. ALARM SOUNDED WHEN TRAVELING ON HIGHWAY, BRAKELIGHT ILLUMINATED AND NO BRAKE. GRANDMOTHER DRIVING GRANDDAUGHTER BARELY MISSED COLLISION WITH STOPPING TRAFFIC. TWO MECHANICS LATER REVEAL COSTLY CONTROL UNIT IS TO BLAME. EASY INTERNET RESEARCH SHOWS MANY OTHERS WITH SAME EXPERIENCE. THIS IS A SAFETY ISSUE,DO NOT UNDERSTAND WHY NO RECALL HAS BEEN ISSUED UNLESS FORD IS WAITING FOR FATALITY FIRST. *TR

UPON START-UP BRAKE WARNING LIGHT ON AND "SERVICE BRAKES SYSTEM" MESSAGE. BRAKE NEEDED TO BE PUSHED VERY HARD TO HAVE ANY EFFECT. CODES C1473 AND C1525 COME UP. VERY EXPENSIVE COMPUTER COMPONENT REPLACEMENTS NEEDED. *TR

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE DRIVER ATTEMPTED TO ENGAGE THE BRAKES BUT THE PEDAL SUNK TO THE FLOORBOARD. THE CONTACT MENTIONED THAT THE VEHICLE FAILED TO STOP AND CRASHED INTO ANOTHER VEHICLE. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT BOTH THE DRIVER AND PASSENGER SIDE BRAKE LINES HAD FAILED. AS A RESULT, THE BRAKE LINES AND HOSES NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 120,000.

IWAS DRIVING 30 MPH WENT TO APPLY BRAKES HAD NONE,PULLED EMERGENCY BRAKE HANDLE IT WORKED GOT ME STOPPED,GOT HOME LOOKED UNDER SUV BRAKE FLUID EVERYWHERE AROUNDDRIVER SIDE FRONT WHEEL ,TOOK WHEEL OFF FOUND THE RUBBER HOSE DETERIORATED BLEW OUT,MY QUESTION IS WHY DID THE BRAKING SYSTEM ALLOW ALL FLUID TO DRAIN,IF YOU FRONT BRAKES FAIL FROM BLOWN LINE,SHOULD NOT THE REAR BRAKES RETAIN FLUID IN THE RESERVOIR AND REAR BRAKES STILL WORK,IS THIS A 2005 FORD ESCAPE FLAW. *TR

I WAS DRIVING MY DAUGHTER HOME AND PULLING TO A STOP SIGN THE BRAKE AND ABS LIGHT AS WELL AS THE SERVICE NOTIFICATION SHOWED UP AND IT BECAME VERY DIFFICULT TO BRAKE. AFTER TAKING IT TO THE DEALERSHIP I WAS INFORMED THAT THE HCU AND CONTROL MODULE ASSEMBLY WERE DEFECTIVE. *TR

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE BRAKE PEDAL ERRONEOUSLY TRAVELED TO THE FLOORBOARD AND BECAME INOPERABLE. THE FAILURE WAS EXPERIENCED WHILE CONTACT WAS AT A TRAFFIC STOP. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO ADVISED THAT THE FRONT PASSENGER'S SIDE BRAKES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.

ABS LIGHT CAME ON. 4WD LIGHT STARTED BLINKING. THERE WAS A GRINDING NOISE COMING FROM THE WHEEL/BRAKE AREA OF THE VEHICLE. THE ABS LIGHT REMAINED ON BUT THE 4WD FLASHED AND THEN TURNED OFF. IT CAME BACK ON INTERMITTENTLY AND FLASHED SEVERAL TIMES. THERE SEEMED TO BE NO FUNCTIONAL PROBLEMS WITH THE BRAKES OR WHEELS. *TR

HAD CAR IN THE SHOP FOR OIL CHANGE AND IT WAS NOTED BY THE MECHANIC THAT BOTH FRONT BRAKE LINES ARE SHOWING SIGNS OF CRACKING AND DETERIORATION. IN DANGER OF FAILING. THIS PROBLEM SEEMS TO BE VERY PREVALENT AND DANGEROUS, WHY HAVE YOU NOT INSTITUTED A RECALL OR FORCED FORD MOTOR CO. TO ADDRESS THIS ISSUE? *TR

ABS LIGHT SUDDENLY CAME ON AND I HAD TO PRESS THE BRAKES ALMOST ALL THE WAY TO THE FLOOR TO STOP THE CAR. I PULLED OVER AND TURNED THE CAR OFF. WHEN I STARTED THE CAR BACK UP, THERE WAS NO ABS LIGHT OR SERVICE ENGINE INDICATOR. MECHANIC SAID THAT I NEED TO REPLACE THE MASTER CYLINDER AND POSSIBLY THE HCU. BUT THEY DON'T KNOW IF THAT WILL FIX IT. *JS

I PRESSED ON THE BRAKE PEDDLE. IT WAS VERY LOOSE AND DEPRESSED EASILY ABOUT 1 INCH, THEN STOPPED ABRUPTLY AND HELD FIRM WITHOUT SLOWING THE CAR AT ALL. AFTER PRESSING DOWN HARDER WITHOUT BEING ABLE TO BUDGE THE BRAKES, I LIFTED AND REAPPLIED THE BRAKES. THIS TIME THEY WORKED. THE SAME THING HAPPENED AGAIN A COUPE DAYS LATER. I TOOK IT IN TO THE FORD DEALER AND THEY TOLD ME THE ABS MODULE AND MASTER CYLINDER NEEDED TO BE REPLACED. FROM MY RESEARCH, FAULTY MASTER CYLINDER AND ABS MODULE ARE COMMON FOR THIS VEHICLE. *TR

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT THE BRAKES FAILED. THE CONTACT HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO A MECHANIC AND WAS TOLD THAT THE ABS CONTROL MODULE FAILED AND NEEDED TO BE REPLACED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 98,000. *TR

FOR ABOUT A MONTH, MY CHECK BRAKE SYSTEM LIGHT WOULD COME ON ALONG WITH THE ABS AND THE RED BRAKE LIGHTS WHEN I WOULD START MY CAR. MOST OF THE TIME, I COULD TURN THE CAR OFF AND WAIT FOR THE ELECTRONICS TO TURN OFF THEN START THE CAR AGAIN AND THEY WOULDN'T COME ON AGAIN. THE LIGHTS CAME ON A FEW TIMES WHILE DRIVING AND THE BRAKES SEEM TO HAVE GIVEN OUT. I HAD TO REALLY PUSH DOWN ALL THE WAY TO GET THE CAR TO SLOW DOWN. I TOOK IT IN BUT SINCE IT WAS RANDOM, THEY COULDN'T REPRODUCE IT OR FIND ANYTHING WRONG. LAST WEEK, THE LIGHTS CAME ON AND WOULDN'T GO OFF AT ALL. I MADE AN APPOINTMENT AT THE DEALERSHIP AND TOOK IT IN A FEW DAYS LATER. THE LIGHTS DIDN'T COME ON. THE DEALERSHIP CALLED TO SAY I NEEDED A NEW HYDRAULIC CONTROL UNIT (HCU). THE PRICE WAS $4500. THIS WAS ON TOP OF THE TWO DIAGNOSTIC FEES OF $125 EACH I HAD ALREADY PAID. ALTOGETHER I HAD TO PAY $4750 AND MY FEH HAS 150,700 MILES ON IT. *TR

THE FRONT BRAKE LINE ON THE PASSENGER SIDE BLEW OUT LEAKING BRAKE FLUID, WAS PULLED IN TO GARAGE. NOW TODAY 6/17/2013 THE DRIVERS SIDE BRAKE LINE BLEW OUT LOSING BRAKES COMPLETELY, BOTH TIMES VERY DANGEROUS. *TR

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE ABS WARNING LIGHT ILLUMINATED AND THE BRAKES WOULD NOT RESPOND. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 109,000. *TR

I WAS DRIVING ON A ROAD WHERE THE SPEED LIMIT WAS ABOUT 45 MPH AND I WAS GOING ABOUT 30 MPH WHEN ALL OF A SUDDEN A RED LIGHT CAME ON WITH THE ABS WARNING MESSAGE ON IT AND THE CAR TURNED OFF. I TRIED TO HIT THE BRAKES BUT THE PEDAL WENT ALL THE WAY TO THE GROUND AND I COULD NOT STOP THE CAR. FORTUNATELY, A CAR WAS NOT IN FRONT OF ME AND I CAME TO A COMPLETE STOP AND PUT MY HAZARD BLINKERS ON. AFTER WAITING A FEW MINUTES I RESTARTED THE CAR AND IT STARTED AS NORMAL AND THE BRAKES WORKED AS NORMAL. THE NEXT DAY I TOOK THE CAR TO THE SHOP TO GET THE BRAKES CHECKED OUT AND THEY COULD NOT FIND ANYTHING WRONG WITH THE BRAKES. THANKFULLY, THE PROBLEM HAS NOT HAPPENED AGAIN. I AM VERY FORTUNATE THAT A CAR WAS NOT IN FRONT OF ME BECAUSE I WOULD HAVE SURELY HIT IT. *TR

MY DRIVERS SIDE BRAKE LINE RUPTURED AND LEFT ME WITHOUT BRAKES. LUCKILY, IT HAPPENED IN MY GARAGE, SO THERE WAS NO ACCIDENT. I INSPECTED THE OTHER 3 BRAKE LINES AND THEY WERE ON THE VERGE OF RUPTURING. I REPLACED ALL 4 LINES. I REALIZE THE PARTS ARE NOT COVERED BY WARRANTY ANYMORE, BUT REPLACING BRAKE LINES AFTER 7 YEARS IS MUCH SOONER THAN I WOULD EXPECT. BRAKE LINES SHOULD NOT BE A NORMAL SERVICE ITEM LIKE SPARK PLUGS. I LIKE MY 2005 FORD ESCAPE. I DON'T WANT TO COMPLAIN ABOUT IT, BUT I NEED TO REPORT THIS DANGEROUS INCIDENT. IT APPEARS TO ME THERE IS A QUALITY DEFECT WITH THE BRAKE LINES. OTHER ESCAPE OWNERS NEED TO KNOW ABOUT THIS. THEY NEED TO CHECK THEIR BRAKE LINES AND REPLACE THEM IF NECESSARY. I'M AFRAID SOMEONE'S BRAKE LINE WILL RUPTURE AND CAUSE AN ACCIDENT. *TR

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, HE ATTEMPTED TO DECELERATE BUT THE BRAKES FAILED TO STOP THE VEHICLE. THE CONTACT ALSO STATED THAT STOPPING DISTANCE ALSO INCREASED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE HYDRAULIC CONTROL MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 108,000.

I RETURNED HOME FROM A LOCAL TRIP. PARKED MY FORD ESCAPE IN THE GARAGE. WHEN MY SON ATTEMPTED TO LEAVE WITH THE CAR ABOUT 15 MINUTES LATER, THERE WAS LITTLE BRAKING POWER. HE RETURNED THE CAR TO THE GARAGE AND WE NOTICED A LEAK AROUND THE RIGHT FRONT PASSENGER TIRE. WHEN I INSPECTED THE LEAK UNDERNEATH THE CAR, AND HAD MY WIFE PUMP THE BRAKES, I SAW THE LEAK WAS COMING FROM THE BRAKE LINE CONNECTION OF RUBBER TO METAL UNDER THE WHEEL WELL. I LOOKED ONLINE AND READ SEVERAL ACCOUNTS OF THE SAME ISSUE, WITH THE BRAKE LINE FAILING ON THE 2005 FORD ESCAPE. I WILL BE HAVING MY ESCAPE BRAKE LINE ISSUE REPAIRED THIS WEEK. *TR

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE ABS AND BRAKE WARNING LAMPS ILLUMINATED. THE CONTACT THEN ATTEMPTED TO ENGAGE THE BRAKES AND THE BRAKE PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 102,000 AND THE CURRENT MILEAGE WAS 102,500. UPDATED 02/26/13*LJ UPDATED 03/1/2013 *JS

IN AUG 2012 WE WERE ON OUR WAY BACK FROM A VACATION AND OUR ABS LIGHT CAME ON, ALONG WITH A FLASHING 4X4 LIGHT. WE HAD NO IDEA WHAT IT WAS OR WHAT TO DO. THE VEHICLE DROVE FINE AND STOPPED FINE, EXCEPT FOR A COUPLE OF TIMES IT FELT AS IF THE ABS ENGAGED ON DRY CEMENT. WE STOPPED TO EAT AND SHOP FOR A FEW HOURS AND THE LIGHTS WERE OFF WHEN WE GOT BACK IN THE VEHICLE. THEY DIDN'T COME ON AGAIN UNTIL A FEW DAYS AGO (JAN 2013). HOWEVER, I HAD BEEN COMPLAINING TO MY HUSBAND RECENTLY THAT THE BRAKES DIDN'T SEEM TO WORK RIGHT. I HIT ICE AND THE ABS DIDN'T ENGAGE ..NO LIGHT EITHER..BUT THE GRINDING SOUND ONCE IN AWHILE WAS STILL THERE. SO WE TOOK IT IN AND PUT IT ON THE COMPUTER TO DIAGNOSE THE PROBLEM. CAME BACK WITH 2 CODES U2023 AND C1234. WHICH MEANS THE RIGHT FRONT TONE RING IS BAD. AFTER SEARCHING THE INTERNET, I FOUND THIS TO BE A VERY COMMON PROBLEM. ALSO GOT UNDER THE TRUCK AND SURE ENOUGH THE TONE RING IS CRACKED AND SPINNING AROUND LOOSELY. THE SAFETY ISSUE HERE IS THE ABS WILL LOCK UP RANDOMLY ON DRY CEMENT WHEN YOU START TO APPLY YOUR BRAKES. WHICH THEN YOU CAN'T COMPLETELY CONTROL YOUR VEHICLES DIRECTION AND IF YOU TAKE YOUR FOOT OFF THE BREAK TO CONTROL YOUR VEHICLE, THEN YOU MAY HIT SOMEONE OR SOMETHING. I AM THANKFUL FOR ALL THE INFO I HAVE FOUND SO WHEN IT GETS REPAIRED THEY CAN'T SCREW ME OVER. *TR

ON SEVERAL OCCASIONS, I WAS GETTING READY TO STOP AND NOTICED THAT THE BRAKE PAD "STUCK." THE PAD WOULDN'T DEPRESS AND I WAS UNABLE TO STOP. AFTER ADDITIONAL EFFORT, I WAS ABLE TO GET THE VEHICLE TO SLOW DOWN AND STOP, BUT I WAS ALREADY AT A REDUCED SPEED SINCE I WAS COMING TO A STOP. I THOUGHT MY CAR MAT HAD JAMMED MY BRAKES, SO I THOUGHT NOTHING OF IT UNTIL IT HAPPENED AGAIN. I TOOK MY VEHICLE TO THE FORD DEALER WHERE I MADE THE PURCHASE. THEY KEPT MY VEHICLE FOR A WEEK TO "REPRODUCE" THE PROBLEM, WHICH THEY DID. I WAS THEN TOLD THAT THE PARTS ALONE WOULD COST $3,000, BUT THAT THE ENGINEERS AT FORD CORPORATE SUGGESTED THAT THE MECHANICS PERFORM AN ELECTRO-MECHANICAL BRAKE BLEED, WHICH SEEMED TO FIX THE PROBLEM, BUT IT DID NOT. THREE WEEKS LATER, THE BRAKES FAILED AGAIN. THIS TIME THE DEALERSHIP KEPT MY VEHICLE FOR TWO WEEKS, BUT WERE UNABLE TO REPRODUCE THE FAILURE. I WAS TOLD THAT THE ONLY WAY TO FIX THE PROBLEM WAS TO COMPLETELY REPLACE THE BRAKING SYSTEM. I ACTUALLY CALLED FORD HQ ABOUT THIS ISSUE. THE PERSON WITH WHOM I SPOKE OFFERED NO REAL RESOLUTION, AND SHE SEEMED UNAWARE OF THINGS. FORD IS VERY AWARE OF THE PROBLEMS WITH THE HYBRID BRAKING SYSTEM. THIS IS A DANGEROUS SITUATION THAT IS A DESIGN FLAW--NOT A MECHANICAL FAILURE COVERED BY A WARRANTY. THERE IS A DIFFERENCE, AND FORD NEEDS TO BE HELD RESPONSIBLE. HYBRIDS ARE VERY EXPENSIVE, AND THEREFORE THE MANUFACTURERS OF THESE VEHICLES SHOULD BE FORCED TO TAKE RESPONSIBILITY FOR DESIGN FLAWS THAT ARE AS DANGEROUS AS BRAKE FAILURE. IT'S JUST A MATTER OF TIME BEFORE MY BRAKES FAIL AND I END UP IN A TERRIBLE CRASH, EITHER KILLING MYSELF OR SOMEONE ELSE. EVEN IF I SPENT $7,000 ON A NEW SYSTEM, IT'S GOING TO FAIL AGAIN BECAUSE IT HAS THE SAME DESIGN FLAW OF THE CURRENT BRAKING SYSTEM. THIS IS WHY FORD NEEDS TO REDESIGN THIS BRAKING SYSTEM AND RECALL AFFECTED VEHICLES BEFORE SOMEONE GETS KILLED. *TR

I BOUGHT THIS 2005 FORD ESCAPE HYBRID FROM DRIVER'S WORLD IN VIRGINIA BEACH, VA, AND FOUND SERIOUS PROBLEMS WITH THE BRAKES THE MINUTE I DROVE OFF THE LOT. IMMEDIATELY AFTER THE FIRST STOP SIGN LEAVING THE USED CAR DEALERSHIP, I GENTLY PRESSED THE BRAKES TO SLOW DOWN AND FELT AS THOUGH THE ABS WAS LOCKING UP PREVENTING ME FROM EVEN SLOWING DOWN. WHEN I LET OFF OF THE BRAKES AND PRESSED THEM AGAIN, I WAS ABLE TO BRAKE JUST FINE. I FIGURED IT MAY HAVE BEEN A FLUKE, SO I CONTINUED DRIVING FOR 2 HOURS FROM VIRGINIA BEACH TO MIDLOTHIAN. I STOPPED AT A STOP LIGHT IN MIDLOTHIAN WHEN THE BRAKE LIGHT AND THE ABS LIGHT BOTH CAME ON AT THE SAME TIME, AND THE VEHICLE BEGAN TO ROLL. I PRESSED THE BRAKES AS HARD AS I COULD AND THE VEHICLE STOPPED ROLLING. I CONTINUED TO DRIVE FOR 2 MILES IN THIS CONDITION OF HAVING TO PRESS THE BRAKES EXTREMELY HARD TO GET THE VEHICLE TO SLOW DOWN. WHEN I ARRIVED AT MY DESTINATION, I TURNED THE CAR OFF AND BACK ON, AND THE PROBLEM HAD GONE AWAY. I TOOK THE CAR BACK TO DRIVER'S WORLD 36 HOURS LATER. DRIVER'S WORLD KEPT THE VEHICLE FOR TWO AND A HALF WEEKS AND CLAIMED THAT THEY WERE UNABLE TO REPRODUCE THE PROBLEM. THEREFORE, EVEN THOUGH THE VEHICLE IS UNDER THEIR 30DAY/1000MILE WARRANTY THEY WILL NOT MAKE ANY REPAIRS OR GIVE A REFUND. I PICKED THE VEHICLE UP FROM DRIVER'S WORLD, AND AT THE FIRST STOP LIGHT I CAME TO THE BRAKE LIGHT CAME ON. I TOOK IT BACK TO DRIVER'S WORLD, AND THEY WERE ABLE TO FIND ERROR CODES C1471 AND C1472, BUT THEY DID NOT KNOW WHAT THEY MEANT SO THEY TOLD ME TO TAKE THE VEHICLE TO FORD'S SERVICE DEPARTMENT. ON THE WAY TO FORD'S SERVICE DEPARTMENT THERE WAS ONE OCCASION WHEN I PRESSED THE BRAKES AND FELT AGAIN THAT THE ABS WAS LOCKING UP PREVENTING ME FROM EVEN SLOWING DOWN. I LET OFF OF THE BRAKE AND PRESSED IT AGAIN, AND I STOPPED JUST FINE. AT THIS TIME FORD STILL HAS THE VEHICLE AND IS ATTEMPTING TO REPRODUCE THE PROBLEM. *TR

BRAKES BECAME VERY "SOFT" AND BRAKE LIGHT, ABS LIGHT AND "SERVICE BRAKE SYSTEM" LIGHT APPEARED. PARKED CAR FOR 5 HOURS, AND WHEN I RESTARTED, THE BRAKES SEEMED FINE AND THE LIGHTS WERE OFF. TOWED CAR TO SHOP AND HAD BRAKES REPLACED (@ 5%, SO THOUGHT THIS WAS THE "ONLY" PROBLEM). 2 WEEKS LATER, I HAD THE SAME PROBLEM. REPAIR SHOP DID MORE DIAGNOSTICS AND RESEARCH, AND DISCOVERED THE MASTER BRAKE CYLINDER / HCU ISSUE THAT IS FREQUENTLY REPORTED ON-LINE. *TR

MY BRAKES HAVE A VERY HARD PEDAL FROM TIME TO TIME. REQUIRING ME TO PUMP THE BRAKES TO STOP. MY FORD DEALER TELLS ME IT IS THE MASTER CYLINDER AND IT WILL COST $3000.00 TO REPAIR. THEY ALSO STATE THAT THEY ARE NOT SURE THIS WILL FIX THE PROBLEM. (REMEMBER THIS IS A HYBRID AND BRAKES ARE DIFFERENT) SECOND ISSUE IS THE ELECTRIC DRIVE TRAIN DOES NOT ALLOW THE ENGINE TO SHUT DOWN UNDER 30 MPH LIKE IT IS SUPPOSED TO DUE UNDER 30 MPH. AT TIMES THIS REQUIRES EXTRA BREAKING BECAUSE THE ENGINE DOES NOT IDLE DOWN LIKE IT SHOULD. FORD SEEMS TO BE AWARE OF THESE PROBLEMS. I FOUND SEVERAL COMPLAINTS ON THE WEB DESCRIBING THE SAME PROBLEMS. IT SEEMS FORD HAS DONE VERY LITTLE TO ASSIST THE CUSTOMERS, OR TO CORRECT THE PROBLEM. *TR

HAD LIGHT WARNING OF BRAKE FAILURE. INVESTIGATION DISCOVERED BROKEN RING WITH TEETH ON FRONT AXLE THAT SENSES WHEEL ROTATION. PART IS CALLED "TONE RING" FORD PART #7L8Z-2C182-B. THIS CAUSES A FAILURE OF THE ABS AND TRACTION CONTROL SYSTEM. INTERNET SEARCH SHOWED THIS AS A VERY COMMON PROBLEM WITH ALL YEAR FORD ESCAPES AND IS A VERY BAD DESIGN. THIS $32 PART CAUSES A $300 PARTS AND LABOR COST SINCE RECOMMENDED FIX IS TO REPLACE A PERFECTLY GOOD AXLE. IT APPEARS TO BE CAUSED BY EXPANSION AND CONTRACTION OF THE RING AND RUST BETWEEN THE AXLE AND THE PRESSED ON RING. *TR

AS I DROVE MY FORD ESCAPE 2005 DOWN A HILL THE BRAKE LINE ON THE PASSENGER SIDE RUPTURED, CAUSING THE BRAKE FLUID TO LEAK WHICH QUICKLY RESULTED IN NO BRAKING ABILITY. I MANAGED TO STOP MY CAR BY DOWN SHIFTING INTO FIRST GEAR AND USING THE EMERGENCY BRAKE. I WAS NOT ABLE TO CONTROL THE CAR BEFORE GOING THROUGH A STOP SIGN, FORTUNATELY, NO CARS OR PEDESTRIANS WERE IN THE WAY. THE MECHANIC WHO FIXED THE PROBLEM REPLACED THE BRAKE LINE ON BOTH THE DRIVER AND PASSENGER SIDES, AS THE DRIVER SIDE BRAKE LINE WAS CLOSE TO RUPTURING, TOO. *JB

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT SHE WAS ATTEMPTING TO EXIT FROM A PARKING SPACE WHEN THE BRAKE PEDAL DEPRESSED ALL THE WAY DOWN TO THE FLOOR. THE CONTACT WAS UNABLE TO BRING THE VEHICLE TO A COMPLETE STOP. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE FRONT BRAKE LINSE BROKE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND FILED A REPORT. THE MANUFACTURER THEN REFERRED THE CONTACT TO NHTSA. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 96,406 AND THE CURRENT MILEAGE WAS 96,506. UPDATED 05/31/12*LJ

THE BRAKES FAILED WHILE ATTEMPTING TO STOP AT A STOP SIGN. THE CAR WENT THROUGH THE STOP SIGN. A FEW MINUTES LATER WHILE DRIVING, THE ABS AND SERVICE BRAKES LIGHT CAME ON. I DROVE THE VEHICLE DIRECTLY TO THE DEALER. THEY WERE NOT ABLE TO LOOK AT IT UNTIL TWO DAYS LATER. I WAS TOLD THE BRAKE HOSES NEEDED REPLACING. I REPLACED THEM. THE BRAKES SEEMED TO BE WORKING. A FEW DAYS LATER, I GOT THE SERVICE BRAKES WARNING, AS WELL AS THE SERVICE 4X4 WARNING IN THE INFO SCREEN. THE BRAKES SEEMED TO BE WORKING. THIS TIME THEY REPLACED THE WHEEL SENSOR AT THE DEALER. ABOUT A WEEK LATER, I NOTICED THE BRAKE PEDAL WAS HARD WHEN INITIALLY PRESSED AND SOFTENED WHEN THE CAR WAS TURNED ON. I WAS DRIVING DOWN THE ROAD ABOUT 35 MPH WHEN THE SERVICE BREAKS AND ABS WARNING LIGHTS CAME ON AND THE BRAKES ONLY WORKED IF I PRESSED REALLY HARD TO THE FLOOR AND THEN IT WAS JERKY. I DROVE A SHORT DISTANCE TO RETURN FROM WHERE I STARTED AND TURNED OFF THE CAR. WHEN I TURNED IT ON AGAIN A FEW MINUTES LATER, THE WARNING LIGHTS WERE OFF AND I HAD BRAKING POWER AGAIN. I DROVE A FEW MILES TO THE DEALER AND WHEN I PULLED INTO THE PARKING LOT TO PARK, THE BRAKES FAILED AGAIN AND WARNING LIGHTS CAME ON. THIS WAS A SUNDAY. THEY LOOKED AT THE VEHICLE ON MONDAY AND NOTICED THE HARD BRAKE PEDAL, BUT HE LIGHTS WERE NOT ON. THEY LOOKED AT THE COMPUTER SERVICE CODES AND INFORMED ME I NEEDED TO REPLACE THE HYDRAULIC CONTROL UNIT/ABS MODULE AND POSSIBLE THE MASTER CYLINDER AT A PRICE TAG OF $4300 - $5500+. THE PROBLEM SEEMS TO BE INTERMITTENT, BUT THE VEHICLE IS NOT SAFE TO DRIVE. I KNOW I AM NOT THE ONLY ONE WITH A 2005 HYBRID THAT HAS EXPERIENCED THIS MAJOR SAFETY PROBLEM. *TR CONSUMER DOES NOT OWN THE VEHICLE ANYMORE. IT WAS ABOUT 5 YEARS AGO SHE HAD A BRAKE FAILURE. THERE WAS NO COLLISION. UPDATED 6/8/18*JB

THE FRONT BRAKE HOSE THAT CONNECTS THE BRAKE LINE TO THE BRAKE CALLIPER ON THE PASSENGER SIDE BEARST A HOLE IN THE BRAKE HOSE CAUSING THE SUV TO LOOSE ALL BRAKE FLUID AND TO SMASH INTO TO VAN INFRONT OF US. THE HOSE BROKE AT THE TOP HALF OF THE HOSE BETWEEN THE BRAKE LINE AND THE BRAKE HOSE STRUT MOUNT. THE OUTER RUBBER BRAKE HOSE COATING LOOKS TO HAVE DRY ROTTED AND THE INNER LINE THEN BROKE SOMETIME LATER. THE HOSE LOOKS TO HAVE SEVERAL OTHER SPOTS THAT ALSO LOOK ROTTED. I REPLACED FRONT BRAKE LINE AND WAS BLEEDING THE BRAKE LINES WHEN I FOUND THE DRIVERS SIDE LOOKED LIKE IT WAS READY TO BEARST AT ANY TIME INCLUDING SEVERAL ROTTED SPOTS AT THE UPPER PART OF THE HOSE. I REPLACED BOTH FRONT BRAKE LINES IN THE FRONT. TWO DAYS AFTER BUYING THE BRAKE LINES, I RETURNED TO THE AUTO PARTS STORE TO PURCHASE PARTS FOR ANOTHER TRUCK WHEN THE SALESPERSON TOLD ME THE NEXT DAY AFTER I BOUGHT THE BRAKE LINES THAT ANOTHER PERSON HAD THE SAME PROBLEM WITH HIS ESCAPE. THE SALESMAN WAS NOT SURE OF THE YEAR THAT FORD ESCAPE WAS. I SAVED THE BRAKE LINES FOR FURTHER INSPECTION/INVESTIGATION AS TO THE REASON THEY FAILED. I FEEL BRAKE BRAKE HOSE FAILURE IN A 05 SUV IS A MAJOR SAFETY HAZZARD AND SHOULD BE RECALLED BEFORE SOMEONE IS KILLED. *TR

THE ABS SENSOR RINGS ON MY FRONT BRAKES KEEP GETTING CRACKS IN THEM. THIS IS DISABLING THE ABS ON MY VEHICLE. I GET IT FIXED AND THEN A YEAR AND 2 MONTHS LATER IT CRACKS AGAIN. *TR

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT THE BRAKE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES WHERE THE BRAKE PADS, ROTORS AND SENSORS WERE REPLACED, BUT THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS THEN TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS ADVISED THAT THE MANUFACTURER HAD PROVIDED A TECHNICAL SERVICE BULLETIN FOR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 140,000.

LEFT FORWARD RUBBER BRAKE LINE FAILED. MECHANIC HAD TO RPLACE THEM ALL DUE TO SEVERE WEAR. IMMENANT FAILURE. *TR

THE VEHICLE WAS PARKED AND WOULD NOT START. I RECEIVED WARNINGS ON THE DASH AND THE INFORMATION PANEL STATING TO SLOW TO A STOP AND SERVICE THE BRAKES. I WAS ABLE TO START THE VEHICLE AFTER DISCONNECTING THE BATTERY AND EVERYTHING OPERATED NORMALLY. AFTER GETTING HOME AND RUNNING DIAGNOSTICS EVERYTHING CAME BACK NORMAL. LATER THAT DAY THE VEHICLE WOULD NOT START AGAIN WITH THE SAME WARNINGS AND IT WAS MORE AND MORE DIFFICULT TO GET THE VEHICLE WORKING AGAIN. I ALSO NOTICED THAT THE 12V BATTERY SEEMED TO BE LEAKING SO I INSPECTED AND CLEANED IT. THE NEXT DAY (MONDAY) I BROUGHT THE VEHICLE TO THE FORD DEALER AND EXPLAINED THE PROBLEMS INCLUDING THE LEAKING BATTERY. THE DEALER REPLACED THE 12 V BATTERY UNDER WARRANTY AND SAID MY PROBLEMS SHOULD BE FIXED BUT THEY WOULD CHECK FOR FAULT CODES. THE DEALER FOUND ADDITIONAL PROBLEMS WITH THE ABS BRAKE SYSTEM BUT COULD NOT IMMEDIATELY DIAGNOSE THE CAUSE. THE CAR WAS LEFT FOR ANOTHER DAY AND EVENTUALLY I WAS TOLD THAT IT WAS MOST LIKELY THE HYDRAULIC CONTROL UNIT (HCU) WITH WAS APPROXIMATELY A $4500 PART. I HAVE READ STORIES ONLINE THAT THIS IS A FAIRLY COMMON PROBLEM WITH THIS MODEL YEAR ESCAPE HYBRID AND FORD IS AWARE OF THE ISSUE BUT NOT DOING ANYTHING TO CORRECT IT OTHER THAN MAKING THE OWNERS BUY $4500 REPLACEMENT PARTS. *TT

ABS LIGHT AND BRAKE LIGHT WENT ON HEARD A BEEP AND HAD NO BRAKES WHAT SO EVER . I EVENTUALLY STOPPED BY ENTERING THE CAR IN TO NEUTRAL AND HITTING THE EMERGENCY BRAKE. TURNED THE CAR OFF AND WHEN I TURNED ON AGAIN IT WENT AWAY, MY MECHANIC SAYS ITS GOING TO COST $1000 MASTER CYLINDER NEEDS TO BE REPLACED. THANKS FORD FOR YOUR ASUPPORT WITH THIS OBVIOUS ISSUE YOU NEED TO ADDRESS. *TR

PURCHASED 2005 FORD ESCAPE IN MARCH 2007 WITH ABOUT 80K MILES. WITHIN THE MONTH, THE ABS LIGHT BEGAN TO INTERMITTENTLY COME ON. IT IS NOW SEPTEMBER 2011 AND THE PROBLEM STILL OCCURS AND HAS NOT BEEN SOLVED. HAD OBD II DIAGNOSTIC CODES TESTED. NO CODES FOUND WHILE LIGHT IS ON OR OFF. MANUALLY TURNING OFF THE LIGHT IS ONLY TEMPORARY. THERE ARE NO PHYSICAL PROBLEMS WITH THE BRAKES. FORD SHOULD HAVE THIS RECALLED. PLEASE NOTE THAT WHEN ABS LIGHT IS ON, THERE IS CLICKING THAT CAN BE HEARD AND FELT THROUGH THE BRAKE PEDAL WHILE BRAKING. THE VEHICLE IS SLOW TO STOP. *TR

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT THE BRAKE WARNING LIGHT ILLUMINATED ON THE DASHBOARD. WHEN THE BRAKE WAS IT WENT TO THE FLOOR AND THE CONTACT COULD HEAR A GRINDING NOISE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE ANTI BRAKING SYSTEM COMPUTER FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 67,137. UPDATED 08/31/11 *BF THE CONSUMER STATED HE HAD TO PUT THE VEHICLE IN NEUTRAL AND USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. UPDATED 11/23/11

WE HAVE OWNED SEVERAL GOOD FORD VEHICLES IN THE PAST, UP UNTIL NOW. THE SUBJECT: 2005 FORD ESCAPE HYBRID AND PROBLEMS WITH THE ABS. WE NOW UNDERSTAND THIS IS A COMMON RECURRING PROBLEM WITH THIS VEHICLE. THE MASTER BRAKE CYLINDER IS DEFECTIVE IN WHAT APPEARS TO BE CONSISTENT WITH ALL OF THE FORD'S HYBRID ESCORT LINE...DUE TO A DESIGN FLAW THAT FORD REFUSES TO RECOGNIZE. THE COST OF REPAIRS CAN RANGE FROM $1500-4000 AND AS A CONSUMER'S RIGHTS ADVOCATE I WON'T HESITATE TO BLOW THE WHISTLE ON THIS ONE...MY DAUGHTER DRIVES THIS CAR, AND SHE ALMOST HAD WHAT WOULD HAVE BEEN A SERIOUS IF NOT A FATAL ACCIDENT...;NO RESPONSE FROM THE BRAKING SYSTEM AND IT IS NOW IN THE SHOP.. AND WE CAN'T AFFORD FOR HER NOT TO CONTINUE TO GO TO COLLEGE, AND WE CAN'T AFFORD TO BUY HER A NEW CAR. WHEN IT COMES TO SAFETY, FORD SHOULD BE HELD ACCOUNTABLE...THE ONLY RESPONSE EVER FROM THEM TO ANYONE ELSE WHO HAS HAD A SIMILAR PROBLEM, HAS BEEN A WEAK APOLOGY. WHAT DOES IT TAKE FOR YOUR ORGANIZATION TO INITIATE A RECALL OR AT LEAST A RESPONSIBLE REPLY FROM FORD. I CAN'T EVEN FEEL GOOD ABOUT SELLING THIS CAR TO ANYONE ELSE UNTIL THIS DEFECT IS RESOLVED. AT LEAST TOYOTA DID WHAT THEY WERE SUPPOSE TO WHEN THEY HAD THE "STUCK" ACCELERATION ISSUE...BUT FORD - AN AMERICAN (?) COMPANY THAT HAS BEEN AROUND FOR A LONG TIME...WITH SHABBINESS LIKE THIS IT'S NO WONDER OUR TECHNOLOGIES BEING CONSTANTLY "SOLD (OUT)" ) AND EXPORTED OVERSEAS. ON BEHALF OF ALL AMERICANS WHO PREFER TO PURCHASE USA MADE PRODUCTS AND EXPECT THE QUALITY WE DESERVE, I EXPECT A RESPONSE FROM YOU THAT ADDRESSES THIS HORRENDOUS PROBLEM THAT CAN CAUSE DEATH ON THE HIGHWAYS, IF NOT ALREADY...IT SURELY WILL IN TIME. HOW EFFECTIVE AND INFLUENTIAL IS YOUR ORGANIZATION, OR IS IT ANOTHER FACADE THAT HAS BEEN DESIGNED TO MAKE US THINK OUR SAFETY RIGHTS ARE PROTECTED FROM THE FLAWS OF BIG BUSINESS WHEN THEY REALLY A? FORTUNATELY, I KNOW SEVERAL CONGRESSMEN WHO WILL NOT LIKE TO RECEIVE A COPY OF THIS MESSAGE BUT ULTIMATELY WILL. *TR

STARTED CAR AND RED BRAKE LIGHT AND YELLOW ABS LIGHT CAME ON AND STAYED ON. MESSAGE TO SEEK BRAKE SERVICE ASAP. *TR

2005 FORD ESCAPE HYBRID 127,000 "I-95" MILES (IT STILL AVERAGES 34.3 MPG) GREAT, RELIABLE, LOW REPAIR COST VEHICLE, UNTIL RECENTLY: BRAKE WARNING LIGHT AND "SERVICE BRAKE SYSTEM" WARNING APPEARS ON DASH INTERMITTENTLY. CAVALIER FORD IN CHESAPEAKE, VA QUOTED A REPAIR COST OF $3900.00 TO REPLACE THE ABS MODULE AND HCU MODULE ($3200.00 PARTS, $700.00 LABOR). AFTER CALLING AROUND THE NORFOLK, VA AREA, APPARENTLY THE HCU MODULE IS ONLY AVAILABLE THROUGH FORD (WHAT A SURPRISE), AND NO OTHER REPAIR SHOP WILL "TOUCH" OUR 2005 FORD ESCAPE HYBRID TO REPLACE THE ABS MODULE. WOW, THAT'S GREAT TO HEAR...THAT MEANS THAT I'M BASICALLY A PRISONER TO FORD???? *TR

TL*THE CONTACT OWNS A 2005 FORD ESCAPE HEV. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT NOTICED THAT THE ABS AND BRAKE WARNING LIGHTS SUDDENLY ILLUMINATED. HE CONTINUED TO DRIVE THE VEHICLE BUT WHEN HE ATTEMPTED TO APPLY PRESSURE TO THE BRAKES, THE VEHICLE FAILED TO STOP. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY PERFORMED A DIAGNOSTIC TEST WHICH CONCLUDED THAT THE HCU ASSEMBLY WAS FAULTY AND PERFORMED THE NECESSARY REPAIRS. THE CURRENT AND FAILURE MILEAGES WERE 100,000.

WHILE PULLING INTO MY DRIVEWAY, MY BREAKS SUDDENLY FAILED, WHICH CAUSED ME TO (THANKFULLY NO MORE THAN) RUN INTO THE TREE AT THE END OF MY DRIVEWAY. UPON INSPECTION, I REALIZED THAT MY PASSENGER SIDE BRAKE LINE THAT CONNECTS TO THE WHEEL CYLINDER HAD FAILED DUE TO DETERIORATION. AFTER REPLACING, AND INSPECTION OF THE DRIVER SIDE, THAT BRAKE LINE TOO WAS DETERIORATED TO THE POINT OF IMMINENT FAILURE.

SERVICE BRAKE SYS MESSAGE ON 2005 FORD ESCAPE HYBRID ALONG WITH BRAKE WARNING LIGHT. *TR

2005 FORD ESCAPE.THE TONER RINGS LOCATED ON THE CV AXLES ARE BREAKING WHICH CAUSES THE ABS BRAKING SYSTEM TO FAIL ,WHICH AFFECTS THE BRAKING SYSTEM WHEN APPLYING THE BRAKES. IT IS A VERY COMMON PROBLEM WHICH I THINK SHOULD BE RECALLED DUE TO SAFETY. *TR

LEFT FRONT BRAKE LINE FAILURE. NEAR 100% LOSS OF BRAKING ACTION. PEDAL TO THE FLOOR WITH VERY LITTLE STOPPING POWER. NEEDED TO SHIFT VEHICLE INTO LOW GEAR AND NEUTRAL TO BE ABLE TO STOP VEHICLE. COULD NOT TRAVEL OVER 30MPH, AS THERE WAS NOT ENOUGH STOPPING FORCE TO BRING THE VEHICLE TO A STOP. *TR

MASTER CYLINDER ON 2005 FORD ESCAPE HYBRID FAILED - 73940 MILES ON CAR. MOSTLY CITY & HIGHWAY DRIVING - NO RACING OR OTHER KIND OF DRIVING. *TR

TL*THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING, THE ABS AND BRAKE LIGHTS ILLUMINATED AND THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD. THE CONTACT HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE ELECTRONIC BRAKES FAILED TWICE AND THE VEHICLE LOST CONTROL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO RECALIBRATED THE HYBRID ELECTRONIC BRAKES BUT THE FAILURE OCCURRED AGAIN TWO WEEKS LATER. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO STATED THAT THE MASTER CYLINDER AND THE HYDRAULIC CONTROL UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000 AND THE CURRENT MILEAGE WAS 60,500.

THE ISSUE I AM HAVING IS THE SAME AS DESCRIBED IN COMPLAINT #10318942. INTERMITTENTLY ON DRY PAVEMENT DURING NORMAL BRAKING, THE ABS WILL ENGAGE (WITH INDICATOR LIGHT FLASHING ON) AND YOU CAN FEEL THE TYPICAL ABS ON/OFF PULSING OF THE BRAKES IN THE BRAKE PEDAL. IT APPEARS THE CAR IS ALSO TAKING LONGER TO COME TO A FULL STOP WHEN THIS OCCURS. I HAVE REPORTED IT MULTIPLE TIMES AT THE FORD DEALERSHIP, BUT THEY ARE UNABLE TO DETERMINE THE CAUSE. THIS HAPPENS TO ME REGULARLY (A COUPLE TIMES A WEEK).

TSB 05-8-5 STATES: ABS AND BRAKE WARNING LAMP ON WITH DTC C1526 - DTC C1524 MAY ALSO BE PRESENT VEHICLES BUILT PRIOR TO 2/11/2005. *TR

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE BRAKING FROM 65 MPH, THE BRAKE PEDAL WENT TO THE FLOORBOARD ABNORMALLY. THE CONTACT ADDED BRAKE FLUID TO THE VEHICLE AND WAS ABLE TO DRIVE HOME. THE VEHICLE WAS LATER TAKEN TO THE DEALER WHERE HE DIAGNOSED THE FAILURE AT THE BRAKE LINES AND MASTER CYLINDER. THE DEALER STATED THAT A BRAKE LINE WAS HITTING AGAINST THE POWER STEERING CAUSING THE BRAKE LINE TO FRACTURE. THE DEALER REPAIRED THE BRAKE LINE. THE MANUFACTURER ADVISED THE CONTACT THAT THE VEHICLE WARRANTY WAS EXPIRED THEREFORE THEY WOULD NOT ASSIST WITH THE REPAIR. THE FAILURE AND CURRENT MILEAGE WAS 99,894. UPDATED 01/13/11*LJ UPDATED 04/04/11

2005 ESCAPE HYBRID BRAKE FAILURE. I TRIED TO STOP AND BRAKES ONLY WENT HALF WAY DOWN. I RELEASED AND PUSHED AGAIN, HAD TO USE EMERGENCY BRAKE TO STOP OTHERWISE I WOULD HAVE GONE THROUGH A STORE FRONT WINDOW. TOOK TO FORD DEALER AND FOUND OUT IT WAS THE MASTER CYLINDER/SOLENOID. PER FORD'S TECHNICAL SERVICE BULLETIN 0585 ISSUED 8/5/05, THIS IS A KNOWN ISSUE CORRECTED BY INSTALLING A REVISED MASTER CYLINDER. THIS COULD HAVE KILLED ME AND THE PEOPLE INSIDE THE BUSINESS. IF THIS IS A KNOWN, VERY DANGEROUS PROBLEM, THERE SHOULD BE A RECALL. *TR

2005 FORD ESCAPE HYBRID - THE CAR WOULD BEGIN TO SKID AND SLIDE WHEN APPROACHING A STOP REGARDLESS OF THE VEHICLE SPEED OR ROAD CONDITIONS. THE ABS WOULD KICK IN AND THE INDICATOR WOULD COME ON TELLING THE DRIVER THAT THE CAR WAS SLIDING. THIS IS A DANGEROUS CONDITION AS THE CAR WOULD NOT STOP WHEN THE BRAKES ARE PRESSED. AFTER INVESTIGATING ONLINE, I DISCOVERED THAT THIS IS A KNOWN PROBLEM WITH THIS MAKE AND MODEL OF HYBRID VEHICLE. MANY OTHER DRIVERS HAVE EXPERIENCED THE SAME THING. THE SUGGESTION WAS THAT THE TONE RINGS WERE CRACKED OR BROKEN. MY REPAIR SHOP DISCOVERED THAT BOTH OF MINE WERE BROKEN AND ONE AXLE NEEDED REPLACED. INTERESTINGLY, WHEN THE MECHANICS TOOK THE CAR ON A TEST DRIVE TO DIAGNOSE THE PROBLEM, THE CAR WOULD REV BEYOND 4 RPMS, THEN THE ENGINE QUIT AND THE DASHBOARD READOUT STATED TO PULL OVER AND STOP THE CAR IMMEDIATELY. THE GAS ENGINE QUIT AND THE CAR WOULD NOT GO OVER 20 MPH. AFTER TURNING THE CAR OFF AND WAITING A FEW SECONDS, THE CAR WAS RESTARTED AND THE COMPUTER/CAR RESET ITSELF AND WOULD RUN AGAIN. THE SAME THING HAPPENED ON AN OPEN HIGHWAY GOING 60 MPH. THE INDICATOR LIGHTS WENT OFF AND THE WARNINGS TO PULL OVER AND STOP THE CAR IMMEDIATELY DISPLAYED. THIS IS A KNOWN ISSUE BY FORD AS THEY HAVE ISSUED DTC C1526. THIS PARTICULAR BLOG (HTTP://BLOG.YAGELSKI.COM/2010/01/MY-FORD-ESCAPE-HYBRID-BRAKE-REPAIR.HTML) EXPLAINS THE PROBLEM AS WELL AS THOSE OF MANY OTHERS WHO ARE ALSO EXPERIENCING THIS ISSUE, WITH GREATER DETAIL AND ACCURACY THAN I CAN. PLEASE DO WHATEVER YOU CAN TO FORCE FORD TO ISSUE A RECALL ON THIS INCREDIBLE IMPORTANT AND EXPENSIVE SAFETY MATTER. THANK YOU. *TR

2005 FORD ESCAPE HYBRID - BRAKE FAILURE. CAR HAS NOT BEEN DRIVEN HARSHLY OR IN HARSH CONDITIONS. ON JULY 31ST, APPLIED BRAKES AT STOPLIGHT, ABS LIGHT CAME ON AND BRAKES FAILED. DEALER UNSURE HOW TO FIX. *TR

1. DRIVING NORMALLY AND THEN BRAKING NORMALLY 2. THE ABS BRAKE LIGHT COMES ON AND THE BRAKES "SLIP" (I.E., THE CAR SLOWS, THEN "SLIPS" FORWARD AGAIN BEFORE THE BRAKES RE-ENGAGE AND STOP THE CAR) OCCURS ONCE OR TWICE IN A 30-MILE STRETCH CONSEQUENCES: IF YOU NEED TO STOP COMPLETELY DUE TO A PEDESTRIAN OR CAR STOPPING IN FRONT OF YOU, THE CAR DOESN'T STOP FULLY. IT SLIDES AFTER YOU'VE PRESSED THE BRAKES AND THE ABS OVERRIDES YOUR BRAKING. 3. NO REPAIR HAS BEEN UNDERTAKEN YET. *TR

WE HAVE EXPERIENCED AN UNUSUAL PROBLEM WITH THE BRAKING SYSTEM IN OUT 2005 FORD ESCAPE HYBRID. THERE HAVE BEEN MAY EPISODES OF THE YELLOW ABS AND THE RED BRAKE WARNING LAMP LIGHTING UP AND THE ALARM SOUNDING OVER THE PAST YEAR. THIS WOULD HAPPEN FOR A COUPLE OF DAYS AND THEN AFTER SHUTTING-OFF THE VEHICLE AND RESTARTING, THE BRAKES RETURNED TO NORMAL OPERATION. WE SPOKE WITH THE SERVICE DEPARTMENT AT OUR DEALERSHIP ABOUT THIS AND BECAUSE THE WARNING LIGHT WASN'T ON AT THE TIME, THEY SAID THERE WAS NOTHING THEY COULD DO TO DETECT THE PROBLEM. THE LAST TIME THIS HAPPENED THE BRAKES REVERTED TO FAIL SAFE MODE REQUIRING A "PEDAL TO THE FLOOR" EFFORT TO SLOW THE VEHICLE TO A SAFE STOP LUCKILY WHILE PULLING INTO OUR DRIVEWAY . AFTER THIS WE HAD THE CAR TOWED TO THE DEALER AND WERE TOLD WE NEEDED A NEW "HCU" UNIT AND MASTER CYLINDER WITH A TOTAL REPAIR COST OF $4K+. I DECIDED TO DO SOME RESEARCH AND DISCOVERED MANY CASES OF THE EXACT SAME THING HAPPENING WITH THE SAME YEAR AND MODEL ESCAPE. WE ARE GOING TO WAIT A FEW DAYS TO THINK BEFORE MOVING FORWARD WITH THE REPAIR. *TR

FORD HYBRID ESCAPE BRAKE LIGHT KEEPS COMING ON. I HAVE TO TURN IT OFF AND THEN BACK ON TO GET THE LIGHT OUT. DEALER SAYS IT'S A GROUND FAULT AND FORD HAS A NEW WIRING HARNESS, BUT I AM REQUIRED TO PAY FOR IT, IT'S AN '05 WITH LESS THAN 8,000 MILES ON IT, YET I AM TO PAY AND FIX FORD'S PROBLEM, AND WE ARE TALKING BRAKES HERE, THAT FORD KNOWS ABOUT AND HAS ALREADY IDENTIFIED AND HAS A FIX FOR. IT NEEDS A RECALL. THE ELECTRIC STEERING HAS ALREADY FAILED ONCE AND HAD TO HAVE A NEW COMPUTER FOR THIS. FORD IS HIDING PROBLEMS WITH THE CAR. *TR

MY 2005 FORD ESCAPE HYBRID HAVE 140,000 MILES ON IT FOR THE PAST 3 WEEKS THE ABS LIGHT AND THE RED TRIANGLE STOP THE CAR SAFELY COME ON WHEN I START THE CAT. I PULL OVER SHUT THE CAR OFF RESTART AND ALL IS WELL UNTIL THE NEXT TIME. *TR

2005 FORD ESCAPE HYBRID. PROBLEM IS FAILURE OF HYBRID REGENERATIVE BRAKE SYSTEM AS DESCRIBED IN FORD'S TECHNICAL SERVICE BULLETIN, TSB 05-8-5 (AUGUST 5, 2005) (NHTSA ID #10017553). PROBLEM HAD OCCURRED SPORADICALLY AFTER THE WARRANTY PERIOD, BUT WITHOUT ANY KNOWN INCIDENT TO HAVE TRIGGERED THE PROBLEM. REPAIR HAS REQUIRED REPLACEMENT OF THE MASTER CYLINDER AND THE BRAKE SYSTEM'S HYDRAULIC CONTROL UNIT ("HCU"). TOTAL COST HAS BEEN ABOUT $7,000. TO SUMMARIZE MY CORRESPONDENCE FROM FORD... "SINCE THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION ("NHTSA") IS NOT CONCERNED (I.E. NOBODY HAS GOTTEN KILLED BY THESE DEFECTIVE BRAKES) THERE IS NO NEED FOR A RECALL. THEREFORE, FORD HAS NO RESPONSIBILITY TO PAY FOR OR DEAL WITH MY PROBLEM." MY STORY IN MORE DETAIL AT HTTP://BLOG.YAGELSKI.COM/2010/01/MY-FORD-ESCAPE-HYBRID-BRAKE-REPAIR.HTML. *TR

BRAKE SYSTEM FAILURE ON 2005 FORD ESCAPE HYBRID: HIGHWAY DRIVING, NO BRAKING DURING FAILURE - ABS LIGHT COMES ON WITH "SERVICE BRAKE SYSTEM" MESSAGE ON CONSOLE. TOOK TO DEALER WHERE THEY "DIAGNOSED" MASTER CYLINDER FAILURE. REPLACED MASTER CYLINDER. 06 JULY 09 BRAKE SYSTEM FAILURE ON 2005 FORD ESCAPE HYBRID: NORMAL CITY DRIVING UNDER 35MPH ABS LIGHT COMES ON WITH "SERVICE BRAKE SYSTEM" MESSAGE ON CONSOLE. *TR

FRONT DRIVER'S SIDE ANTI-LOCK BRAKE TONE RING SENSOR SNAPPED OFF OF ROTOR/HUB AREA CAUSING ABS TO FALSELY ENGAGE. ONLY 38,000 MILES ON VEHICLE. LOTS OF SIMILIAR ENTRIES ON INTERNET. *TR

TL*THE CONTACT OWNS A 2005 FORD ESCAPE. ON TWO OCCASIONS, THE ABS SPONTANEOUSLY MALFUNCTIONED. PRIOR TO THE FAILURES, THE CONTACT NOTICED THAT THE ABS AND FOUR WHEEL DRIVE WARNING INDICATORS WERE ILLUMINATED ON THE INSTRUMENT PANEL. THE RISK OF A CRASH WAS INCREASED. THE DEALER STATED THAT THE FRONT BRAKE NEEDED TO BE REPLACED AT THE COST OF $1,200. THE VEHICLE HAS NOT BEEN REPAIRED. THE CONTACT IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER IN REFERENCE TO NHTSA CAMPAIGN ID NUMBER 07V156000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE). THE FAILURE MILEAGE WAS 40,000 AND CURRENT MILEAGE WAS 80,000.

ON 9-9-08 I WAS IN A FRONT END COLLISION, APPROXIMATELY 40MPH, AIRBAG DID DEPLOY, HOWEVER THE POWDER THAT CAME OUT WITH THE AIRBAG MADE MY FACE AND EYES BURN. MY 2005 FORD ESCAPE 4CYL. SUSTAINED MINIMAL DAMAGE ($5000.00). IT TOOK 3 WEEKS TO FIX, WHICH WAS NO BIG DEAL. YESTERDAY, 10-4-08, WHILE DRIVING HOME FROM WORK, MY ESCAPE WAS RUNNING FINE UNTIL I TURNED AND STARTED TO ACCELERATE TO GET UP TO SPEED (40MPH), MY ESCAPE TOOK THE PEDAL FROM MY FOOT AND LOCKED IT TO THE FLOOR, I HAVE BEEN ASKED BY SEVERAL PEOPLE IF I ACCIDENTALLY HIT THE CRUISE, AND ALL I REPLY WITH IS "IT DOESN'T HAVE CRUISE!" AS MY CAR STARTED TO SPEED UP I TRIED TO STOP, MY BRAKES WOULD ONLY KICK BACK OUT AT ME AND SINCE I WAS JUST IN A WRECK I WAS A LITTLE SCARED. I TURNED INTO A PARKING LOT AND DROVE IN CIRCLES UNTIL I COULD FIGURE OUT HOW TO STOP IT. I TRIED MY EBRAKE BUT IT DIDN'T WORK, I TRIED PULLING THE PEDAL UP, NO GOOD, I TRIED PUNCHING THE PEDAL WITH MY FOOT, NO GOOD. I DIDN'T WANT TO DO ANY DAMAGE TO THE TRANNY SO I DIDN'T TAKE IT OUT OF GEAR, FINALLY I DECIDED TO TRY SHUTTING IT OFF, IT SHUT OFF AND IS RUNNING FINE NOW. I AM CERTAIN THAT THIS IS A HUGE PROBLEM MAINLY BECAUSE I HAVE READ ALL OF THE POSTINGS FOR THIS CAR AND FOUND THAT MANY PEOPLE ARE HAVING PROBLEMS IN THIS AREA. YOU CAN BE CERTAIN THAT IF THIS HAPPENS AGAIN AND THERE ISN'T ANYTHING DONE TO FIX IT, I WILL GET RID OF IT AND STOP BUYING FORDS ALL TOGETHER. I AM VERY DISAPPOINTED THAT NO REAL ACTION HAS BEEN TAKEN WITH SO MANY OF THESE COMPLAINTS. *TR

HAVE HAD THE "SERVICE BRAKE SYSTEM" MESSAGE AND THE DASH "BRAKE" INDICATOR LIGHT GO ON RANDOMLY WITHOUT BRAKING FOR A COUPLE OF MONTHS (BEGAN IN MAY 2008) IT HAS BEEN TO THE DEALER TWICE (IN JUNE 2008) AND IS NOW DOING IT AGAIN. THE DEALER REPLACED AN ELECTRICAL HARNESS THIS FIRST TIME AND CLEANED CONTACTS ACCORDING TO A FORD SERVICE ALERT THE SECOND. I ALSO HAD A SIMILAR PROBLEM IN THE FALL OF 2007. THE "SERVICE BRAKE SYSTEM MESSAGE" APPEARED AND THE DASH "BRAKE" INDICATOR LIGHT CAME ON OVER A THREE WEEK PERIOD FOLLOWED BY THE 4X4 SYSTEM AND ABS SYSTEM MAKING NOISE, JERKING THE CAR SEVERAL TIMES AND THEN SHUTTING DOWN WHILE I WAS DRIVING (NOVEMBER 2007). THIS WAS FIXED BY THE DEALER BUT NOW THE CAR'S INDICATOR LIGHTS ARE TURNING ON AGAIN AND THE PROBLEM DOES NOT SEEM TO ABLE TO FIXED. I AM WORRIED THE BRAKE SYSTEM WILL FAIL AGAIN. *TR

TL*THE CONTACT OWNS A 2005 FORD ESCAPE. THE ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER STATED THAT THE FUEL RAIL PRESSURE SENSOR NEEDED TO BE REPLACED. THE FLOW IN THE FUEL LINE WAS UNEVEN. FORD HAS BEEN ISSUING RECALLS ON VARIOUS VEHICLES BECAUSE THE FUEL RAIL HAS CARBON CLUMPS IN THE HOSE WALL THAT MAY LEAK IN THE WALL OVER TIME. THE DEALER INFORMED THE CONTACT THAT SHE WOULD HAVE TO PAY FOR THE REPAIR. SHE IS DISPLEASED AND REFUSES TO PAY. THE CURRENT AND FAILURE MILEAGES WERE 42,750. UPDATED 04/16/08 *BF UPDATED 04/16/08 *TR UPDATED 06/23/10. *JB THE CONSUMER HAS SINCE EXPERIENCED A SECOND FAILURE. UPDATED EVOQ 08/20/10*JB THE CONSUMER STATED THE FRONT AND REAR BRAKE HOSE WAS REPLACED. UPDATED 11/25/14

IN 2006 I EXPERIENCED THE FAILURE OF MY CAR TO OPERATE ONE MORNING. I INITIALLY THOUGHT THAT I HAD MADE THE ERROR SINCE I HAVE A MANUAL VEHICLE I OCCASIONALLY TAKE MY FOOT OFF THE PEDAL; I HAD NO IDEA WHY THE CAR HAD STOPPED RUNNING RIGHT AFTER I STARTED IT AS I BEGAN TO PULL OUT OF THE PARKING SPACE. THE CAR STOPPED A COUPLE OF TIMES WHICH CONCERNED ME SO I CONTACTED THE DEALER IN NEW JERSEY WHERE I WAS LOCATED AT THE TIME FOR HIM TO LOOK AT THE CAR FOR THIS PROBLEM. HE ASSURED ME THAT THE PARTS WOULD WORK AND ALL WAS RIGHT AGAIN AS I LEFT THE SERVICE DEPARTMENT, NEW 5L8Z-2C053-BA AND YL8Z-19048-AA PARTS INSTALLED. ONE YEAR LATER, NOVEMBER 3, 2007 THE SAME PROBLEM BEGAN TO HAPPEN AGAIN. I IMMEDIATELY TOOK THE VEHICLE TO THE DEALER AND HE INFORMED ME THAT THE CABLE AND THE FOOT PEDAL VACUUM WERE NO LONGER OPERATING (5L8Z-2C053-BA AND YL8Z-19048-AA) AS WAS THE CASE THE PREVIOUS YEAR AND THAT HE HAD TO WAIT FOR A NEW PART IN ORDER TO REPLACE THESE DEFECTIVE PARTS. I ASKED WHY THIS HAD HAPPENED AGAIN, AND WHAT I WAS TOLD HORRIFIED ME. THE MANUFACTURER MOST LIKELY HAD NOT RESOLVED THE PROBLEM OF THE PAST AND THAT THE PROBLEM WAS IN THE PARTS. I ASKED WHY THERE WAS NOT A MORE LIFE SAFETY SOLUTION TO THIS VERY DANGEROUS PROBLEM AND I WAS TOLD THAT SINCE THIS DID NOT HAPPEN OFTEN IT WAS NOT DEEMED A REAL ISSUE. THE RATIONALE IS APPALLING. HOW AM I EXPECTED TO BE SAFE WITH THIS VEHICLE WHEN THE CONDITION IS NOT RESOLVED IT IS JUST PROLONGED, WITH FAILURE LOOMING OVER ME? HOW DO I DRIVE MY CHILD AND THE OTHER MEMBERS OF MY FAMILY AND FRIENDS IN A VEHICLE THAT CAN STOP OPERATING AT ANY GIVEN MOMENT?? MY COMPLAINT IS IN REGARD TO LIFE SAFETY AND VALUE OF RECIPROCITY. SINCE THERE IS NO DEATH AS OF YET, I MUST WAIT FOR THE FAILURE? THIS IS EMOTIONALLY STRESSFUL. *TR

THE BRAKES HAVE COMPLETELY STOPPED WORKING (EXCEPT FOR THE EMERGENCY BRAKE) 3 TIMES IN ONE MONTH, 4 TIMES IN TWO YEARS. *TR

ABS LEFT SENSOR FAILED REQUIRING REPLACEMENT OF THE AXLE. *AK

COMPLETE BRAKE FAILURE. FIRST TIME IT OCCURRED WAS ON THE INTERSTATE - 65 MILES AN HOUR AND THE BRAKE LIGHT AND THE ABS LIGHT CAME ON AND THERE WAS A BEEP. THERE WERE THEN NO BRAKES AT ALL. LUCKILY, I WAS ABLE TO GET TO THE SIDE OF THE ROAD AND COAST TO A STOP. TURNED OFF THE TRUCK AND STARTED IT AGAIN AND IT HAD BRAKES. ON THIS LAST INCIDENT, THE SAME THING IN THE SAME ORDER HAPPENED. THANKFULLY, MY WIFE WAS ABLE TO GET THE VEHICLE TO COAST TO A STOP WITHOUT HITTING ANYONE OR ANYTHING. THIS PROBLEM IS VERY DANGEROUS. IT IS INTERMITTENT THUS MAKING IT HARD TO DIAGNOSE. *JB CONSUMER STATED VEHICLE WAS TRADED IN 2015. UPDATED 6/8/18*JB

PURCHASED 05 ESCAPE AT 40,096 MILES IN JULY '06. ABOUT 2 WEEKS LATER, ROTORS WERE WARPED SO DEALER REPLACED THEM FOR FREE. ABOUT 10,000 MILES LATER THEY WERE WARPED AGAIN AND THEY "TURNED" THE ROTORS. ABOUT 4,000 MILES LATER THEY WERE WARPED AGAIN SO THE DEALER REPLACED THEM AGAIN. NOW LESS THAN 5,000 MILES LATER, THEY ARE WARPED AGAIN. DEALER LOOKED AT THE CAR AND REFUSED ANY REPAIRS, ONLY NOTING THAT THERE IS *NOTHING* WRONG WITH THE BRAKING SYSTEM, ONLY THE ROTORS ARE WARPED, WITH NO KNOWN REASON EXCEPT IT MUST BE "THE WAY I AM DRIVING". JUST TODAY NOW THE ABS LIGHT IS STEADY ON, WITH NO REASON THAT I CAN NOTICE FROM MY OWN DRIVING. MY OWN RESEARCH TELLS ME THAT IT MAY BE A "TONE RING" ON THE AXLE, WHICH REQUIRES A REPAIR FOR OVER $1,000 FOR EACH AXLE, AS THE ENTIRE AXLE MUST BE REPLACED TO REPAIR THE "TONE RING". *JB

FRONT BRAKE ROTORS GO OUT OF ROUND. ONE DEALER RESURFACED, WARR, NOT THERE LONG AFTER OUT OF ROUND AGAIN. REPLACED WITH NEW, AGAIN OUT OF ROUND . ANOTHER DEALER REPLACED ROTORS TWICE. AGAIN OUT OF ROUND. VEHICLE PULSATES WHILE STOPPING. *NM

HAVE READ ON YOUR SITE NUMEROUS COMPLAINTS WITH THE FORD 2005 ESCAPE ENGINE AND THE PROBLEM THAT IT SPEEDS UP DURING BRAKING. I HAVE ALSO EXPERIENCED THIS PROBLEM. HOWEVER THE PROBLEM IS THE DRIVER !! IF YOU ARE LARGE PERSON OR HAVE LARGE FEET. DURING BRAKING THE BRAKE PEDAL GOES LOWER THAN THE GAS PEDAL AND YOUR SHOE TOE CATCHES THE GAS PEDAL AND ACCELERATES THE ENGINE, THIS HAS HAPPENED NUMEROUS TIMES. THE GAS PEDAL HAS VERY LITTLE RESISTANCE AND YOU ARE NOT AWARE THAT YOUR SHOE IS PUSHING IT DOWN. IT APPEARS ALSO THAT THE PEDALS ARE CLOSER TOGETHER THAN NORMAL. I HAVE OTHER VEHICLES AND HAVE HAD MANY CARS AND THIS IS THE FIRST I HAVE EXPERIENCED THIS DANGEROUS CONDITION. *NM

DT: THE CONTACT STATED VEHICLE SURGED FORWARD WHILE BRAKING FOUR TIMES. THE VEHICLE WAS TAKEN TO THE DEALERSHIP TWICE. THEY WERE UNABLE TO DUPLICATE THE PROBLEM. THEREFORE, NOTHING HAS BEEN DONE TO CORRECT THE PROBLEM. THIS HAPPENED AT ANY PARTICULAR SPEED. *AK

I HAD A 2003 FORD ESCAPE THAT WAS 2WD. I NEEDED 4WDS SO WE PURCHASED A 2004 ESCAPE XLT BASED ON PREVIOUS GOOD EXPERIENCE. WHAT HAS FORD DONE TO THIS PREVIOUSLY EXCELLENT VEHICLE? WE HAVE TWO MAJOR COMPLAINTS, BUT NHTSA DOES NOT CONSIDER FOUR ATTEMPTS TO REPAIR AC THAT IS LEAKING FREON INTO THE PASSENGER COMPARTMENT WORTHY OF A COMPLAINT. SO WE WILL ADDRESS COMPLAINT #2. VEHICLE BRAKES IRRADICALLY, MAKES GRINDING NOISES, AND BRAKES CONSTANTLY HUM. WE THOUGHT THIS WAS DUE TO BEING A 4WD, BUT AFTER VISITING YOUR WEBSITE FIND THIS TO BE A PREDOMINATE PROBLEM ON ALL 2005 ESCAPES.

WHEN BRAKING AT A STOP SIGN OR A TRAFFIC LIGHT THE BRAKE PEDAL WOULD CONSTANTLY GO TO THE FLOOR. THE VEHICLE IS AT THE DEALER, AND THE PROBLEM IS STILL UNDETERMINED.*AK A SEVERE GRINDING NOISE IS HEARD WHEN THE BRAKES ARE APPLIED. THE CONSUMER STATED THAT THE BRAKE PEDAL IS GETTING SOFT WHEN THE BRAKES ARE APPLIED. *TC...*AK

9-1-04 MY 2005 FORD ESCAPE WAS PARKED IN THE GARAGE OF MY HOME WHERE I BEGAN TO BACK UP. THERE WAS AN OBSTRUCTION IN MY DRIVEWAY SO I PUT THE CAR INTO DRIVE AND PULLED 1/2 WAY INTO THE GARAGE TO CLEAR THE WAY. I PUT THE CAR IN PARK, OPENED MY DOOR, TOOK OFF MY SEATBELT AND GOT OUT OF MY CAR WALKING TOWARDS THE REAR. SUDDENLY THE CAR ACCELERATED IN REVERSE KNOCKING ME DOWN BECAUSE OF THE OPEN DOOR. I JUMPED INTO THE CAR (WHERE MY CHILDREN WERE IN THE BACK SEAT) TO PLACE THE CAR IN PARK-IT WAS IN PARK AND ROLLING FAST. I USED THE EMERGENCY BRAKE TO STOP THE VEHICLE WITH THE HELP OF THE OPEN DOOR JAMMING ALONG SIDE THE GARAGE WALL. THE END RESULT WAS SHOULDER AND COLLAR BONE DAMAGE AS WELL AS SEVER BODY DAMAGE CAUSED BY THE OPEN DOOR. IF THE DOOR HAD NOT BEEN OPEN, MY CHILDREN WOULD HAVE ROLLED INTO ONCOMING TRAFFIC AND BEEN HIT HEAD ON. I AM POSITIVE SOMETHING IS WRONG WITH THIS NEW CAR, YET THE GALPIN VAN NUYS FORD DEALERSHIP HAS REFUSED TO INSPECT IT FOR SAFETY. THEY INSISTED THAT I FIRST FILE A CLAIM WITH MY INSURANCE CARRIER, WHICH I DID AND STILL HAVE BEEN REFUSED THE SAFETY INSPECTION BY FORD AND THE DEALERSHIP LEVEL AND THE CORPORATE LEVEL. I WANT TO ENSURE I AM DRIVING A SAFE CAR AND THIS PROBLEM WILL NEVER HAPPEN AGAIN.*AK

BRAKES ARE MAKING NOISE INTERMITTINGLY. IT SOUNDS LIKE BLOWING IN A BOTTLE. WENT TO THE DEALERSHIP FOR SERVICE 3 TIMES IN THE FIRST MONTH OF OWNERSHIP. THEY KEEP GRINDING DOWN THE ROTORS AND IT'S NOT HELPING. APPARANTLY FORD CORP. IS AWARE OF THE PROBLEM AND ARE TRYING TO FIND A CURE. THEY DON'T KNOW WHAT TO DO AT THIS POINT. ALSO, STEALTH SECURITY SYSTEM FAILED, AND THE VEHICLE HAD TO BE TOWED BACK TO THE DEALER FOR REPAIR. THIS ALSO HAPPENED IN FIRST MONTH OF OWNERSHIP.