2019 Ford Edge Engine Problems

Your car produced white smoke from the exhaust and started idling roughly. The dealership determined that coolant has entered the engine, requiring a complete engine replacement at an estimated cost of $15,000. This problem is reportedly a known defect affecting 2019 Ford Edge 2.0 EcoBoost engines. The repair will involve removing and replacing the entire engine block.

When you accelerated to pass another vehicle, your engine started shaking and shuttering as if it had too much fuel but wasn't getting enough fuel at the same time. The engine then shut down completely while you were driving in traffic, and the car wouldn't restart. You were unable to shift out of park, leaving your car stranded in the left lane during rush hour and creating a safety hazard.

Your engine is overheating because it's losing coolant, which your mechanic indicates is a known issue with 2019 Ford Edges. This coolant leak is serious enough that it may require a full engine replacement. The fix will likely involve locating and sealing the coolant leak, or in severe cases, replacing the engine entirely.

Your 2019 Ford Edge's engine suddenly stalled and shut down while backing into the driveway without any warning, and restarted briefly before failing again. Two mechanics confirmed a blown head gasket caused by coolant leaking into the engine cylinders—a known issue affecting this engine platform. Your vehicle is now inoperable. The fix will require head gasket replacement and inspection of the cooling system to prevent further coolant intrusion.

Your engine overheated while driving at highway speeds, and you had to add coolant to keep going. A few days later, your heating system stopped working and a "Coolant Low" warning appeared on your dashboard. A dealer diagnosed coolant leaking into your engine itself, which is a serious internal problem that likely requires engine repair or replacement.

The contact owns a 2019 Ford Edge. The contact stated that while his daughter was driving at an undisclosed speed, the driver noticed white smoke coming out of the tailpipe. No warning lights were illuminated. The contact's daughter was able to drive the vehicle to the residence. The vehicle was later taken to a local service center, where it was diagnosed with coolant intrusion in cylinder #3 and cylinder #1. The contact stated that prior to arriving to the local service center, a warning message, advising that the engine temperature gauge and engine coolant temperature had risen, was displayed. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 85,000.

I have had the high-pressure fuel pump fail on me three times in less than 10,000 miles. This causes the motor to shut down, crank no start and I’ve also had it blow the fuel pump off the top of the motor and dump the oil on the highway on the windshield all over the car, creating a severe crash hazard on these events

Car stutters and hesitates when accelerating. Almost got in accident when trying to merge onto interstate. Two different repair shops say there is an issue with the Torque converter. They suggest a complete transmission rebuild or replacement.

My 2019 Ford Edge has 64,500 miles on it and the transmission needs replacing. Ford says that it will cost me $9K, but if I come up with $4500, they might help with the rest. I bought this vehicle just over a year ago and took it into a dealership with under 60K miles with the initial complaints. After a year of them looking at the computer system and making adjustments to that, they told me it needed a throttle body. I had a friend take it to another Ford dealership and they ran a diagnostic study on it right away - the transmission fluid has metal in it, it needs to be replaced. After telling the first dealership what we found, they said that it isn't covered under any warranty because when they finally found out what was wrong, it was over the 60K miles. Right now, I still have 5 years left on my loan and it sits in my driveway - UNABLE to drive it. And I don't have $4500! I do see that the transmissions have caused issues in these models, can I please get some help with getting mine fixed...? Again, I don't have the money to dish out to fix this myself and I will be making monthly payments on it for the next 5 years as it sits in my driveway!! I did get a hold of one lawyers office and they said that there might be a civil suit (?) brought up again Ford. Any help would be greatly appreciated!!! [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

COOLANT INTRUSION TO ENGINE

Design flaw in engine which causes coolant intrusion into the cylinders causing misfires, overheating, and white smoke out of the exhaust. The vehicle is unsafe to drive due to the engine overheating. The vehicle has been inspected by a licensed mechanic that confirmed all of the above. The engine temperature would overheat and there was white smoke coming out of the exhaust upon starting the vehicle.

Samochodem szarpie na niższych biegach, nierówno chodzi silnik i przy zmianie biegów też szarpie.

vehicle hesitates while accelerating

Torque Converter issue, vehicle shakes or stutters, or bucks when switching gears. It starts when I reach around 23 mph, comes out of it between 28-32, but then it happens again at 43-48. This is especially noticeable after being stopped at stop signs or red lights. Local dealer is aware. My mothers car (same make, model, year is having the same issue) No lights or anything come on.

Without warning or prior issues, while driving the car on a busy street the check engine light came on, the car shook and locked up/stopped suddenly. I was almost rear ended. The car would not restart. A known TSB is in place for this car and the head gasket design flaw allows coolant into the engine causing it to seize on even low mileage cars (under 46,000 miles). 19 year old female left stranded in highway after a near collision. Ford needs to be forced to recall these engines and fix this design flaw!

Blown head gasket due to faulty engine block design

The problem is the torque converter. It causes a hesitation when accelerating from being stopped, usually around 30-43 mph is when the car acts like it isn't going to speed up and slows down instead of speeding up. I had the torque converter replaced once in Sept. 2024. My car has 82,213 miles. I took my car in today 8/5/25 and was confirmed that the torque converter need to be replaced again. The Ford service department told me that they have had 8 - 10 Ford Edges come in in the last 2 weeks with the same problem. I have 2 family members that have Ford Edges that is having the same issues.

The contact owns a 2019 Ford Edge. The contact stated while driving 45 MPH, the vehicle lost automotive power. The contact stated that the vehicle started jerking with white smoke coming from the rear end of the vehicle. There was no warning light illuminated. The vehicle was towed to a local dealer where the vehicle was diagnosed, and the contact was advised that the engine was faulty due to coolant intrusion into the engine. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 33,867.

TRANSMISSION IS SHUDDERING AND JERKING

Longblock engine cracked between the 2nd and 3rd cylinders due to coolant intrusion without any warning. No lights indicated low coolant nor that the temperature was rising. My car kept stalling at stop lights but would restart. By the time I got home, white smoke was coming from exhaust and it smelled like fireworks. It has 38,997 miles but is 6 years old and out of warranty. Ford wanted $12,691.17 to install a new engine with only a 1 year warranty. I had the engine replaced with a used engine and before I could get the car home, the replacement engine block cracked in the same place as mine. That engine only had 40,000 miles. Ford claims no issues with my car but the 2018 and 2017 Edge's have a recall for the same issue. This is not true!!

The contact owns a 2019 Ford Edge. The contact stated that the vehicle failed to immediately start. The contact stated that after the vehicle was started, while driving approximately 15 MPH the vehicle stalled. The vehicle was towed to the local mechanic and was diagnosed with coolant intrusion in the engine cylinders. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted. The failure mileage was 61,500.

Vehicle has 71,452 miles and has started using coolant and the wrench and check engine light are coming on. This is a known issue in other years of ford vehicles and this vehicle should also be included in the recall.

Our 2019 Ford Edge (purchased in November 2018) has had a coolant leak into the engine's cylinders. As a result we are facing an estimated $12,000 expense to essentially rebuild the engine. In doing some research, it appears as if there is a class action lawsuit already filed against Ford for the 2015-2018 Edge. Our situation is exactly the same as that described in the lawsuit. Therefore, it seems as if Ford still has not rectified the issue.

The contact owns a 2019 Ford Edge. The contact stated that the check engine warning light was illuminated. The contact used a vehicle scanner to scan the vehicle. The contact retrieved DTC: P0446 (Evaporative Emission Control System (EVAP) vent control circuit malfunction). Additionally, the contact stated that the infotainment system was frozen and was inoperable, and there was rust underneath the hood because the vehicle was not equipped with a hood shroud. The dealer was notified of the failure, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a case was opened. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 64,000.

In November 2024 Customer Complaint: Engine/transmission is sputtering on acceleration between 20–40 MPH. Code Pulled: Misfire code on Cylinder 4. Action Taken: Swapped ignition coil from Cylinder 4 to 3. Removed spark plug and noted wear/carbon tracing. Replaced all 4 spark plugs with Motor craft SP-594 (ASP594). No misfire present after repair. Same misfiring issue returns May 2025.

Engine - Yes it is available for inspection. Approximately a year/18 months I was driving on the interstate and the engine shut down. I was required to pull over four lanes with no power. I took it to a Ford dealership in Franklin, TN. Supposedly it was fixed. However I now have a problem with the engine missing. I took it to my routine service repair center and their mechanic advised me coolant was seeping into the engine block. No messages or warnings were desplayed.

The contact owns a 2019 Ford Edge. The contact stated that while operating the vehicle, the message "Coolant Overheated" was displayed, and the vehicle suddenly shut off. The contact stated that moments later, the vehicle was restarted and driven to the residence and examined by an independent mechanic. The contact was informed that the head gasket had blown. No further information was available. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted. The failure mileage was 134,000.

My 2019 Ford Edge with the 2.0L EcoBoost engine began experiencing a misfire, loss of power, and white smoke from the exhaust. No engine light was on when it started and the car has less tan 46K miles. I had the car towed to a certified mechanic and he confirmed that coolant is leaking into my cylinders, which matches the issue described in Ford TSB 19-2346. This appears to be a widespread manufacturing defect affecting many vehicles with this engine. The presence of coolant in the combustion chamber caused catastrophic engine failure and poses a safety risk due to sudden loss of power while driving. I have been told that to fix the issue I need to replace the whole engine. Repair costs are estimated at $10,600 for an engine replacement at a local repair shop. I would expect it to be even higher from a Ford dealer. Ford has acknowledged this defect in a TSB 19-2346, but no recall has been issued. I am submitting this complaint so NHTSA is aware of the defect and its safety implications. I urge NHTSA to investigate this issue and require Ford to take responsibility.

Shuttering transmission/bad transmission under 100,000 miles

The contact owns a 2019 Ford Edge. The contact stated that while driving at various speeds, the vehicle was driving rough, and the temperature gauge indicated that the engine was overheating. The contact stated that on several occasions, the vehicle stalled. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that there coolant inside the engine, causing the engine to overheat. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 71,000.

The contact owns a 2019 Ford Edge. The contact stated when the vehicle was started, the contact noticed white smoke coming from the exhaust. In addition, the contact noticed a burning odor on the interior of the vehicle. No warning light was illuminated. The vehicle was driven to the residence. The contact stated that later in the day, the contact's husband was driving the vehicle and the failure reoccurred. The contact's husband parked the vehicle and checked the coolant level. The contact's husband noticed that the coolant reservoir was almost empty and noticed a burning coolant odor. The vehicle was taken to an independent mechanic and was diagnosed with coolant intrusion and engine coolant. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 50,000.

The contact’s wife owns a 2019 Ford Edge. The contact stated that on several occasions while driving at various speeds, the vehicle jerked when the accelerator pedal was depressed, and the vehicle lost power. The check engine, power train, and several other unknown warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the wastegate was stuck closed in the turbocharger valve, and the turbocharger valve needed to be replaced. The vehicle was repaired but the failure reoccurred four months later while driving at an undisclosed speed. The contact stated that during the failure, the vehicle lost power and failed to accelerate as intended. The vehicle was taken to an independent mechanic again where it was diagnosed that the wastegate was stuck closed again, and turbo turbocharger valve needed to be replaced. On another occasion, the contact stated that while driving 30 MPH, his wife observed white smoke coming from the exhaust pipe. The contact stated that his wife then observed that the EGR and check engine warning lights were illuminated. The message "Engine Overheating” was displayed. The vehicle was steered off the highway and restarted three times after cooling down and was taken back to the same independent mechanic, where it was diagnosed that the EGR valve had failed, the coolant level was low, and there was coolant passing through the exhaust EGR coolant system and had leaked into the exhaust system. The contact was informed that the EGR system needed to be replaced. The manufacturer was notified of the failure. The failure mileage was 33,654.

2019 Ford Edge ran out of coolant without any indication of low coolant level or check engine light, resulting in loss of heat and poor engine performance due to coolant combustion. According to Ford service (who confirmed the root cause), this was due to the known issue of a faulty EGR cooler [XXX] ) leaking internally, but repairs had to be paid out of pocket. Loss of heat in winter could be dangerous, and in prolonged error state, catastrophic engine failure could occur. Failure occurred at ~55,000 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 Ford Edge. The contact stated that while driving at 25-30 MPH into town, the contact noticed there was white exhaust smoke emerging from the tailpipe. The engine shut down. Several unknown warning lights were illuminated. The contact stated that the failure was related to TSB: 20-2234. The vehicle was taken to an independent mechanic who determined that water had leaked into the engine. The contact called the local dealer, where it was diagnosed that the head gasket needed to be replaced and was unable to confirm any water in the engine. The dealer referred the contact to the manufacturer. The vehicle was not repaired. The manufacturer was contacted, opened a case, and referred the contact to the NHTSA Hotline. The approximate failure mileage was 53,000.

See attached document for complaint.

The vehicle was not shifting properly and was surging while traveling at lower and higher speeds. There was NO CHECK ENGINE light on or any other warning lights at all. The vehicle is in my name, however, my daughter drives 9 hours for college by herself and could have been at risk of injury had the vehicle stalled in the wintertime between Minnesota and Kansas. I drove it while she was home over the winter break and noticed it. I took it to a Ford dealer and they said the transmission needed to be replaced. I went from diagnosing there was a problem myself with no warning lights to the dealer saying this is very common for the Ford Ecoboost engines and that the car is not drivable at all. He was also concerned the low coolant level was due to an engine failure which he said they've also seen a lot of. The vehicle only has 57,000 miles on it, however, it is 6 months past warranty. I have read the Ford forums about this vehicle and there are SO MANY people who have experienced the same thing and Ford refuses to do a recall to cover their mistake. There needs to be a recall on this to protect consumers like myself. This is so frustrating. Now I need to pay out of pocket for a new transmission on a car that I need to get rid of ASAP after hearing about all of the engine failures. I know that would be next, which would put my daughter at risk once again on the road.

The EGR cooler on my vehicle had to be replaced. This is listed on a TSB issued by Ford, however, is not a recall. The first time it had to be replaced was 11/2021 when my vehicle had 36,949 miles on it. This was diagnosed by the dealership and the part was replaced. The engine warning light came on and the messages showed in the Ford app letting me know what was occurring and that I needed to go to the dealership

The sensor on the EGR cooler failed. I have had my EGR cooler replaced two times. The most recent time was in September of 2024. In December of 2024, the engine light came on and the warning messages showed in the Fordpass app stating there was an issue with the exhaust system. After the dealership reviewed it, they had to replace the EGR sensor.

My vehicle had to have the EGR cooler replaced for the second time. The first time was when the vehicle was at almost 37,000 miles, the second time was at 129,575 miles. Just like during the previous occurrences, the check engine light came on and the message in my Fordpass app advised that there was a problem with the engine cooling system and I needed to proceed to my dealership. In this instance, I had it towed to the dealership rather than driving it. This is the same system that currently has a TSB issued for it.

While my vehicle was in the shop having the transmission rebuilt and the torque converter replaced, the techs identified that there was a continued shudder. At this time, after researching the codes on my vehicle, they identified that the EGR Purge Valve needed to be replaced. They identified it because the vehicle was running rough and should not have been after the items were repaired.

The contact owns a 2019 Ford Edge. The contact stated that while driving at an undisclosed speed, the vehicle stalled with the check engine and coolant warning light illuminated. The contact also noticed white smoke coming from the exhaust. The vehicle was taken to the dealer where it was diagnosed that the EGR valve failed and needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 26,446.

The contact owns a 2019 Ford Edge. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle shut down. The vehicle was taken to a dealer and the dealer refused to diagnose the vehicle and provided the contact an estimate for the repair. The contact stated the air conditioner and catalytic converter also had failed to operate as designed. The vehicle was then taken to an independent mechanic for the repair. The contact stated that the purge valve and spark plugs were replaced, and an oil change was performed. After the vehicle was repaired, the contact stated while depressing the accelerator pedal the vehicle hesitated to respond. The vehicle was inspected by another independent mechanic at the residence, and it was diagnosed and determined that the spark plugs and ignition coil needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was 70,000.

The contact owns a 2019 Ford Edge. The contact stated that the vehicle was experiencing excessive coolant consumption. The contact stated that there was a coolant leak. The contact stated that while driving at undisclosed speeds, the engine overheated even though coolant had been added to the vehicle five days prior. The low coolant warning light was illuminated. The contact was able to pull over safely. The contact called the local dealer and was informed that the VIN was not under recall. The vehicle was towed to an independent mechanic, where it was determined that there was no visible coolant leak. The vehicle was not diagnosed or repaired. The manufacturer was contacted and informed the contact that the vehicle was not covered under TSB Number: 19-2346. The failure mileage was approximately 50,000. The VIN was not available.

Engine overheated while driving on the highway. White smoke came out of tailpipe during engine running. Coolant reservoir was empty after I parked the car and turned off the engine. Had to get the car towed to the dealership the next day to get it checked out and was confirmed that coolant got leaked inside the engine.

Cooling intrusion to motor, engine replaced

The contact owns a 2019 Ford Edge. The contact stated that while driving at 70 MPH, the "Engine Coolant Overheating" warning message appeared on the instrument panel. Due to the failure, the contact had the vehicle towed back to the home. The manufacturer was notified of the failure and the contact was informed that there was a recall on the vehicle for the failure(recall unknown); however, the contact's vehicle was not included in the recall. The contact was then referred to the NHTSA Hotline to file a complaint. Upon investigation, the contact discovered that the failure was caused by the engine consuming coolant at a rapid pace. The vehicle had yet to be repaired. The failure mileage was approximately 57,000.

2019 Ford Edge has the same 2.0 liter eco boost 240PS that’s currently involved in the class action lawsuit. The problem is that the coolant sleeve is too close to the toy he cylinder and failed causing coolant to enter the engine. I was traveling on the interstate and with no warning the hot engine light came on and engine shut down. The dealer confirmed that the mother need to be replaced with the updated long block that is being put in the 2015 - 2018 Ford Edge and the 2017 - 2019 Fusion/MKZ/Escape and MKC vehicles. The vehicle only has 75000 miles on it and has never towed or been used hard. We had the vehicle for less that 15,000 miles and now have a completely useless vehicle. Ford refuses to admit any fault even with the engine codes being the exact same. The 2019 for edge need to be looked into and included with the class action lawsuit for safety and consumer satisfaction.

engine coolant sucked into motor. Check engine light and temp light came on. Luckly was intown and doing 40 mph. Copy of repair order from dealer uploaded.

My 2019 Ford Edge SEL has 37,000 miles and I keep it maintained regularly. We were 2 miles from our house when a loud blaring signal popped on my dashboard that my coolant was very low and at that point the car started "sputtering". We inched it home and sure enough, the coolant was empty. We've had no leaking on the driveway at any time. We filled the coolant reservoir and the message did not go away. We had it towed to our mechanic the next day and he said the engine needed to be replaced!!!! What? NO WARNING!! Now 2 days prior (which was a Friday), my check engine light came on and I could see a white smoke coming from the exhaust pipe and the car hesitated. After a few minutes, that went away. Drove it to work and back - 4 miles each way. The next day it happened again and again it stopped after a few minutes. I drove it maybe 10 miles after that running errands and then parked it for the day. The following day is when it "died". I received no other message or warning until it was too late. We were told by our mechanic that Ford has had numerous complaints on this engine. It is a Turbo on a 4 cylinder. The Turbo part will eventually overwork the 4 cylinder. Of course it is out of warranty. Now I am spending over $6,000 to replace this engine. Why in the world would Ford even install an engine like this in their vehicles? And why are they not recalling them?????? My husband has always had Ford Trucks and Mustangs - We have always been Ford People. I will never buy another Ford - SO DISAPPOINTED!!!!!

Sept. My car began bucking and jerking really bad. I was at 63,000 miles. I called Ford who said to get it in...the soonest they could get me in was over a month out. I told them it was a serious safety concern because of the jerking and that they were putting my safety at risk making me wait so long driving a car like that. I had to wait. I tried fuel injection cleaner to see if that would help, it didn't. I never had any codes or lights saying anything was wrong. Ford looked at it and drove it and the mechanics understood why I felt unsafe driving it, they said it jerked really bad. I told Ford I was afraid it would jerk and hit someone when leaving a light or cause me to get hit by jerking and pausing while turning. I was in there a few months ago trying to schedule my transmission fluid to be changed and they told me no I needed to come back between 70-75,000 miles. Today they told me that the transmission fluid was black with metal in it. They said I now need a new transmission at $8,333.

This is an update to Complaint Number 11619818 filed on 10/15/2024. The engine surging problem referenced in the original report has been resolved per Technical Service Bulletin 21-2389, found on your website and forwarded to a local Ford dealership service department. Thank you for making available to the public these important technical documents! Best Regards, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle seemed to be idling strange. Also seemed jerky while waiting at the stop light. Attempted to accelerate and it was lagging. Once I started driving it seemed better until the "Engine Coolant Over Temperature" alert displayed. The vehicle then started disbursing a white smoke. After pulling over the light went off, however the vehicle continued to jerk forward and was idling strange. Continued to have a lagging effect when attempting to accelerate. The vehicle continued to emit a white smoke. The vehicle was brought to a mechanic who indicated the head gasket and/or engine needed replacement. Had been told be the mechanic they have had several over issues exactly like this one. They also indicated there was a recall and/or possible lawsuit. My VIN came up with no recall which makes no sense considering I am having the same issue that's been reported under the recall.

The contact owns a 2019 Ford Edge. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The contact drove the vehicle to the shoulder of the road. The contact raised the hood and performed an inspection. The contact noticed that the coolant reservoir was empty, and the coolant had leaked into the exhaust. In addition, the contact stated that the coolant was burning off the exhaust. The vehicle was towed to the dealer where it was diagnosed with a failed EGR cooler, spark plugs, and an oil change. The vehicle was not repaired. The manufacturer was made aware of the failure but did not assist. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 67,035.

The contact owns a 2019 Ford Edge. The contact stated while driving approximately 35 MPH, the temperature gauge moved to the "RED zone" and the vehicle nearly stalled while slowing for a traffic light. The contact stated that the failure recurred, and the vehicle was towed to an independent mechanic. The vehicle was diagnosed, and the mechanic determined that there was coolant intrusion into the engine block. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to TSB Number: 19-2346 Coolant in Cylinders (Engine and Engine Cooling). The manufacturer was informed of the failure. The failure mileage was approximately 35,000.

The contact owns a 2019 Ford Edge. The contact stated that while driving at an undisclosed speed, the vehicle began to shake and lost motive power with the check engine warning light illuminated. The vehicle was towed to the dealer where it was diagnosed that EGR valve had failed, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 43,335.

The contact owns a 2019 Ford Edge. The contact stated while the vehicle was parked, the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed that there was coolant intrusion into the engine and the engine needed to be replaced. The contact researched and was made aware of NHTSA Campaign Number: 17V209000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 53,000.

The contact owns a 2019 Ford Edge. The contact stated that on several occasions while accelerating, the vehicle jerked back and forth continually. The vehicle was taken to a dealer where it was diagnosed and determined that the fuel pressure sensor needed to be replaced. The vehicle was repaired but the failure persisted. The vehicle was taken back to the same dealer and then taken to an independent mechanic where it was diagnosed and determined that the turbo charger needed to be replaced. The vehicle was repaired but the failure persisted. The vehicle was taken to the same dealer, but the failure could not be replicated. The contact stated that on one occasion, while the vehicle was running, the contact entered the residence, and upon returning, the vehicle stalled. The vehicle was not able to be restarted. The vehicle was then towed to an independent mechanic where it was diagnosed that the engine needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was notified of the failure. The failure mileage was 90,400.

The contact owns a 2019 Ford Edge. The contact noticed that the engine coolant was quickly depleted. There was no warning light illuminated. The failure persisted and the vehicle shuddered while idling with heavy white smoke coming from the exhaust pipe. The vehicle was taken to an independent mechanic where it was discovered that the long block was damaged. A dealer was notified of the failure and the contact scheduled an appointment for a diagnostic test. The manufacturer was also notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 86,000.

The contact owns a 2019 Ford Edge. The contact stated that while operating the vehicle, the check engine warning light illuminated, and the vehicle experienced a loss of motive power. The vehicle was taken to the local dealer who diagnosed that the coolant had leaked into the cylinders, and the engine long block needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 43,000.

The mechanic that inspected the car after it broke down said that the EcoBoost 2.0 has an issue that the engine cracks or something like that allowing coolant or whatnot to get into the spark plugs. I think I explained that. The car now needs an engine. With 83000 miles. I’m sure this could cause a fire.

This car was built in 2018 not 2029. Coolant is leaking into cylinder of engine. Can cause possible overheating and or engine fire and eventually engine failure. Not exactly sure when it started but its getting worse.

The contact owns a 2019 Ford Edge. The contact stated while driving at an undisclosed speed and coming to a stop, the vehicle stalled. The vehicle was able to restart; however, the vehicle tugged and jerked. Additionally, the contact stated that the vehicle responded as needed upon depressing the accelerator pedal harder. The contact was able to drive; however, the vehicle was tugging and jerking while driving. The contact stated while pulling into the parking lot of an independent mechanic, the contact saw smoke coming out of the exhaust pipe. The mechanic diagnosed that the exhaust gas had mixed with the coolant system, causing the head gasket failure. The mechanic determined that the head gasket needed to be replaced. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 57,624.

The contact owns a 2019 Ford Edge. The contact stated while at a complete stop with her 9-months old daughter in the vehicle, the contact heard an abnormal flushing sound. The contact stated that upon inspecting the engine compartment, the contact noticed that the coolant level was significantly low. The contact added coolant to the vehicle. The contact stated that the vehicle made the abnormal flushing sound while driving 3 days later. The contact noticed that the coolant level was low and added coolant to the vehicle. The vehicle was taken to two independent mechanics, where it was diagnosed that there was coolant intrusion in the engine. The vehicle was then taken to the dealer, where it was diagnosed and determined that there was coolant intrusion in the engine, and the engine needed to be repaired. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that there would be no assistance with the repair because the VIN was not included in a recall. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 62,000.

Was having some jerking and spudding when starting from a stop until getting above 30mph.No warnings or lights of any kind. Had a rough start one morning and the engine light came on. Took it to a Ford dealer and was told that coolant is leaking into #4 cylinder and we basically need a new engine. No warnings or anything prior to this one time and getting a health check on the Ford App about a Misfire. Miles 103,400

Transmission failed at 60k miles. Problem persisted. Now looking at service report issued in 2020. Engine stutters and stammers in cold start low gear. Losing coolant as well. Sparks changed throttle body cleaned. Problem still noticeable Car currently in repair shop along with all documents of work done

The contact owns a 2019 Ford Edge. The contact stated that on several occasions while driving and while the vehicle was idling, the vehicle was shaking abnormally. The contact stated that on two occasions while driving at slow speeds, there was a burning odor inside the cabin of the vehicle, and an "Engine Overheating - Turn Off Engine" message was displayed. The check engine warning light was illuminated. The vehicle was steered to the side of the road, turned off, and restarted. The vehicle was taken to an independent mechanic where it was diagnosed that the thermostat and the EGR cooler needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 39,800.

The contact owns a 2019 Ford Edge. The contact stated that the check engine light illuminated, and a code reader was used to determine that the coolant level was low. The coolant level was topped off; however, the failure returned as the temperature gauge indicated that the engine was overheating. Additionally, there was a heavy white smoke coming from the exhaust pipe upon starting the vehicle. The contact called the dealer and the manufacturer and was informed that the VIN was not under recall for the failure. The manufacturer referred the contact to the NHTSA Hotline. Upon investigation, the contact determined that coolant intrusion into the engine had caused damages to the engine. The vehicle was not diagnosed or repaired. The failure mileage was approximately 68,000.

Upon starting vehicle has white smoke or steam out of both tailpipes, upon my inspection found radiator reservoir almost empty. Did not drive vehicle.

At 45,494 miles, the vehicle exhibited rough idle at full stop. Further identified white smoke from the exhaust and a burning smell. No warning light displayed. Had the vehicle towed to a Ford dealership for diagnostics. Diagnostics didn't identify any error codes and there are still no warning lights. The diagnosis indicates coolant intrusion from a leaking head gasket into all cylinders. The recommended resolution is an engine replacement. This vehicle is only 8 months out of the 60 month 50,000 mile power train warranty.

relatively new car, 77,000 miles, out of warranty. temperature warning light came on. Taken to dealer. Exhaust Gas Recirculation (EGR) Cooler was leaking coolant. no puddle or evidence of a leak was apparent in parking area. EGR was replaced three weeks ago. Check engine light came on. Dealer reset warning light. light returned during a vacation trip. upon return, white smoke was noticed from exhaust. Dealer diagnosed that evidence of coolant damage was present in two cylinders. Dealer recommended that Engine be replaced. Internet research revealed many discussions about EGR Coolers leaking engine coolant into the engine intake. It was also noted that other ford makes and models in the build date timeframe have had recalls concerning coolant leaking into the engine. No current recall on Ford Edges. Ford opened a case and is investigating further with the dealer service department.

I am having trouble with my car jerking when accelerating between 30 and 50 mph. I originally began to have trouble with my 2019 Ford Edge on 5/13/22. On this date, the car began to overheat and I ended up having to incur the expense of not only having the car towed; but also of retrieving the car as the closest Ford dealership at the time was 5 hours away from my home. In this instance, the car was repaired under warranty and a code of TSB 20-2234. Shortly after the repair, I noticed that my car's wifi was no longer working; and, when I inquired I was told that there would be a $400 diagnostic fee. Furthermore, after about 6 months I noticed that the car would begin to jerk when accelerating. There were no console warnings, just an irregularity when driving. I took it back to the dealership on 8-28-2023 for the acceleration issue. I was given a rental car while they reviewed the issue. The repair cost me $600. After about 6 months, the issue returned and persisted. Until I finally turned the car in on 5-1-2024. After 26 days, I was given an estimate of more than $4,000 for diagnostic services and repairs. I trusted Ford Motor Company so I did everything to be a good client, pay my bill and retrieve my car as quickly as possible. I turned in the rental car on 5/27/24 and was able to pay my bill but 6/7/24. And not 24 hours later, I have the same jerking issue. It occurs when the car is accelerating between 30mph and 50mph; especially when going uphill. I have followed all factory requested specs and have had it serviced regularly. Clearly, there is an issue with this automobile.

We purchased a 2019 Ford Edge Titanium from Car Max. It is 5 years old with only 60k miles. While idling, the engine was bogging and running rough. In addition, a foul smell like firework smoke was coming from the vents. After bringing it to a repair pal certified mechanic, they diagnosed that coolant was leaking into cylinder 2, and we would need a new engine to rectify the issue. The 2019 Ford Edge we purchased was assemble in October 2018, as the 5 year warranty expired in October of 2023. It is experiencing the EXACT SAME problem as all earlier models that were part of the Ford recall. Consequently, we are experience emotional distress in rectifying this issue since the 2019 model year was not covered under the recall bulletin.

The contact owns a 2019 Ford Edge. The contact stated that while driving at an undisclosed speed and depressing the brake pedal, the vehicle shuddered, lunged forward, and stalled. There was no warning light illuminated. The contact was able to restart the vehicle. The contact stated that the failure had been recurring. Additionally, the contact stated that there was white smoke coming out of the exhaust pipe while starting and driving the vehicle. The vehicle was taken to the dealer, where it was diagnosed that there was coolant intrusion into the engine. The dealer determined that the coolant system needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 51,000.

The contact owns a 2019 Ford Edge. The contact stated while driving approximately 35 MPH, the vehicle started shuddering and jerking abnormally. There was no warning light illuminated. The vehicle was taken to an independent mechanic where the spark plugs were replaced; however, the failure persisted. The contact was advised that the replaced spark plugs might be defective and that the power train control module needed to be updated. The contact stated that an appointment was scheduled with a local dealer to diagnose the vehicle and confirm the information. The manufacturer was made aware of the failure; however, the contact was referred to the NHTSA Hotline. The failure mileage was approximately 64,000.

The contact owns a 2019 Ford Edge. The contact stated that the vehicle was idling rough while driving, and the vehicle stalled. There were no warning lights illuminated. There was an abnormal antifreeze odor. The contact became aware there was no coolant in the coolant reservoir. The vehicle was taken to the local dealer, where it was diagnosed that the engine was cracked. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 62,800.

The contact's friend owns a 2019 Ford Edge. The contact stated that while driving at various speeds, the vehicle would shut off without warning. Upon restart of the vehicle, the temperature gauge indicated that the engine was hot(H). Upon inspection, it was discovered that the coolant reservoir was almost empty. The contact stated that coolant was frequently added to the coolant reservoir due to the recurring failure. Upon further inspection, the contact discovered that coolant was leaking into an engine cylinder, causing heavy white smoke to come from the exhaust pipe. A dealer was notified of the failure and the contact was instructed to take the vehicle to the dealer for a diagnostic test. The contact was then referred to the manufacturer who referred the contact to the NHTSA Hotline. The dealer and manufacturer stated there were no recalls on the vehicle. The vehicle was not repaired. The failure mileage was approximately 40,000.

My car seemed like it was losing power as I was driving many times - I had concerns and took it in and they mentioned I either needed an entire transmission or the torque converter part needed to be replaced. There are MANY of the Ford Edges ranging in years close to mine that have this recall; however mine is not included. When I spoke with Ford they mentioned they wouldn't pay for it, but I fear it's a safety concern for myself and many others from my research in this predicament. This is thousands of dollars that I am not able to afford and it seems like a 5 year old car shouldn't need a new transmission. It definitely feels unsafe and unjust.

The contact owns a 2019 Ford Edge. The contact stated that while driving at an undisclosed speed, the coolant malfunction warning light illuminated, and the vehicle started shaking uncontrollably. The contact was able to pull into a parking garage and parked the vehicle. The contact attempted to start the vehicle later the same day, and the vehicle started shaking again. The vehicle was taken to an independent mechanic where it was diagnosed with a blown head gasket and an unrepairable engine. The contact stated that the vehicle was towed back to the residence. The contact called the dealer and was informed to bring the vehicle to the dealer. The vehicle was towed to the dealer, and it was confirmed that the head gasket was blown. The vehicle had not been repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not under recall. The failure mileage was approximately 61,000.

Detailed account: After my morning commute, the car started sounding like it was idleing hard with a strange smell. It didn't smell like buring oil or plastic/rubber. Midday, I went to a store 1/2 mile from my work. There was little noticable sound upon starting. I pulled into the parking lot, when I shifted into reverse to park, the car shut off. There were no warning lights on the dash. I shifted to park, then turned the car back on and parked. There was smoke coming from one of the tail pipes that lasted several minutes after shut-off. After 30 min, I turned on the car and shifted into reverse to leave the parking spot. The car shut off and the brakes were not responsive as rolled slightly down an incline. Again no warning lights, so I returned to my workplace and finished my day. We contacted a mechanic and scheduled an appointment as soon as they could get us in. Following the workday, I began the drive to my child's school (approx 3 miles city). Within 1 mile, the check engine light came on and the car shut off when I came to a complete stop at a light. I shifted to park then turned it back on when the light turned green. It shut off again when someone entered my lane and I had to come to a complete stop. Once again turned back on, and limped it to my son's school because I had to get to my child before the end of pickup time (my husband would not have made it in time if I had pulled over where I was). I tried to avoid making a complete stop but had to proceed through two 4 way stops, when the vehicle shut off again. I made it to the school where I could safely leave it and wait for it to be towed. Malfunction: Engine shut-off, lack of powered brack due to car shutting off Safety Risk: extended stopping time in the middle of the road due to time needed to turn car back on Problem has been confirmed by mechanic shop, internet research, and a friend in Ford service department as known issue (design flaw) of corrosion due to coolant intrusion. No recall.

The contact owns a 2019 Ford Edge. The contact stated that the heater was no longer operable. Additionally, the contact stated that the vehicle experienced excessive coolant consumption. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that there was coolant intrusion into the cylinders. The mechanic determined that the failure was related to an unknown Ford TSB, and the engine might need to be replaced. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that they could not assist because the VIN was not included in a recall and the vehicle was out of warranty. The failure mileage was approximately 66,000.

The contact owns a 2019 Ford Edge. The contact stated while driving at approximately 20 MPH, he observed smoke coming from the exhaust pipe with an abnormal burning odor. The vehicle was taken to a dealer where it was diagnosed that coolant intrusion had caused the engine to become blown and that the long block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage is 60,223.

I was driving on the freeway when an engine overheating warning light came on. I exited the freeway at the nearest exit and my vehicle lost power and white smoke was coming from the exhaust. My vehicle was towed to the nearest Ford dealership. Upon inspection, they discovered coolant was leaking into the exhaust and they repaired it pursuant to TSB 20-2234. This is a known issue to Ford as they have had many complaints of this same issue with all of the Ford models with the Ecoboost engine. They have offered full coverage for repairs of other models but not my vehicle. This issue could have caused a vehicle fire.

CEL light came on while at a stop light. Called my Ford dealership while I was at the light and made an appointment to bring my car in. Light went off after a couple of stops but I still took my car in as it had started to idle a little rough like it might want to stall. At first, service thought just new spark plugs were needed, but after installing them they noticed white smoke coming out of the tail pipe. Upon further inspection they saw there was coolant leaking into the engine through the head gasket and I needed either a new head gasket or a new engine. Car had 79724 mile on it, always been service on time at the Ford dealership, had just had it serviced November 8th and had them do the fuel induction service that they recommended. The car could have caught on fire, or stalled out while I was driving it. It is a good thing I took it in even though the CEL had gone off. This appears to be a known problem with the Ford Eco Boost engines and I see numerous complaints for this exact problem. I have had no accidents in this car and always serviced it at Ford.

The contact owns a 2019 Ford Edge. The contact stated while driving 65 MPH, the engine overheating warning light illuminated. The contact stated that the failure occurred while driving on the highway, and the contact took the next exit and exited the highway. The contact stated that while at the stop light, the vehicle jerked, and the contact became aware of an abnormal sound coming from the engine compartment. The contact drove to an Advanced Auto Parts parking lot and allowed the engine to cool off. The contact stated that after the engine had cooled down, the coolant level was checked, and was below the minimum level. However, the contact stated that there was no indication that the coolant was low and no evidence of a leak. The contact refilled the coolant reservoir. The contact started the vehicle, and there was heavy white smoke coming from the exhaust pipes. Additionally, the contact stated that there was an abnormal odor coming from the exhaust pipe. The vehicle was towed to the dealer where it was diagnosed with coolant intrusion into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 63,000.

In June 2023 while operating my 2019 Ford Edge with at the time 62,000 miles on it at the time. I was on a highway when the engine coolant warning light came on in vehicle . I pulled off the highway as I was endanger and the vehicle was acting erratically which almost caused an accident I then went to a gas station and had coolant restored as it had run out completely without notice or reason the mechanic advised I speak with dealer. I brought vehicle to local mechanic, who advised that the engine was blown unserviceable. He stated that he had seen this issue many times before and stated that the Ford Eco-boost engine had a widespread problem of the engine block cracking then coolant entering the engine destroying it. He said he had seen this many times over many years. He said the coolant was leaking from the tail-pipes which was a tell tale sign of the issue. he said there was a long history of engine problems with Ford Edge Eco-boost engines dating back to 2012. I looked on line and a great deal of history and documentation were present, even a large federal class action law suit based in California. The Colonial Ford Dealership in Plymouth Ma confirmed everything that the mechanic had told me but denied any responsibility saying they were not aware of any history or re-call, they charged me 7,400.00$ to replace the engine. A letter from Ford Corp said they were not responsible until a re-call is ordered The U.S. GOV should step and work to stop Ford from doing this to customers and not until after someone is killed or injured.

I first noticed a hesitancy upon acceleration which I attributed to possible bad gas. I continued driving. A few days later I noticed white smoke coming from the vehicle's exhaust, a more noticeable acceleration issue - missing, hesitancy, - and then the vehicle died when I stopped for a light. I called an independent mechanic. The engine completely stopped on me 4-5 times at traffic lights or stop signs as I drove to his shop. I had several close calls to other vehicles hitting me as my vehicle would not move when I gave gas trying to pull out. Just as I pulled onto the lot, the indicator light came on saying the vehicle was Overheating (this was the first time). The coolant was completely gone and had leaked into cylinders (according to his inspection). After performing other tests overnight on the vehicle, he determined it needed an engine replacement. It is just barely over the warranty at 65,000 miles.

2019 Ford Edge with 38K miles coolant leak into the cylinders of the 2.0-liter EcoBoost engines and cause the vehicles to misfire, overheat and even catch fire.

The contact owns a 2019 Ford Edge. The contact stated that while driving at an undisclosed speed, the vehicle started to shake violently with white smoke coming from the exhaust. No warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the head gasket was blown, causing coolant to leak into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and the contact was provided a case number and advised to call the NHTSA Hotline. The failure mileage was approximately 74,000.

Coolant intrusion on 2 motors, the Original Motor and the new replacement motor from Ford

The egr cooler developed a leak causing engine to overheat and cylinder misfire. Estimate from Ford dealer is $2500. We had a 75000 mile extended warranty, but the problem developed at 7800 miles. Only 3000 miles after expiration. We were hoping for some cost relief because of the circumstances involved, but nothing seems to be available

The CEL came on indicating a mis fire on cylinder #1. The temperature rose above the warning threshold. After new spark plugs and a new coil pack. The CEL cleared but white smoke came from exhaust pipes indicating coolant intrusion. This was an issue with prior model years. My vehicle is not in the recall window. The car has 78,000+ miles and the extended warranty was for 75,000 miles. Has this issue been reported for 2019 2.0L ecoboost engines?

The contact owns a 2019 Ford Edge. The contact stated that while driving at an undisclosed speed, the check engine and engine temperature warning lights illuminated; however, the contact immediately pulled over to the shoulder of the roadway and turned off the vehicle. The contact was able to restart the vehicle and safely drove to the location where the vehicle had received an oil change service two days before. The independent mechanic inspected the vehicle and checked the coolant level, which he had filled two days before, and informed the contact that he could smell coolant burning and that the coolant was leaking into the engine. The contact was advised to take the vehicle to the dealer for assistance. The contact safely drove the vehicle to her residence, contacted the dealer, and scheduled for the vehicle to be picked up by a tow truck service. The vehicle was towed to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced; however, the vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 89,000.

The contact owns a 2019 Ford Edge. The contact stated that while driving at an undisclosed speed, the low coolant warning light illuminated. The contact stopped, parked the vehicle, refilled the coolant, and drove the vehicle to her residence. The contact stated that the vehicle was started the following day and the low coolant warning light was illuminated. The contact checked the coolant level and became aware that the coolant reservoir was empty but there was no evidence of a coolant leak on the ground underneath the vehicle. The contact stated that the vehicle was taken to an independent mechanic for an oil change and the contact was informed that the head gasket was blown, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 85,800.

The contact owns a 2019 Ford Edge. The contact stated that while driving at an undisclosed speed and depressing the accelerator pedal, the vehicle shuddered and stalled. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where the failure was related to Ford Technical Service Bulletin Number: 19-2208 (Coolant In Cylinders). The vehicle was not repaired. There was no further information provided. The manufacturer was made aware of the failure and informed the contact that the vehicle was not under warranty. The failure mileage was approximately 61,220.

The contact owns a 2019 Ford Edge. The contact stated that while driving at undisclosed speeds, his wife noticed white smoke coming from the exhaust pipe. The contact then stated that he noticed an abnormal odor. The vehicle was taken to an independent mechanic where the contact was informed that anti-freeze had leaked into the exhaust and diagnosed that both head gasket failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline to file a complaint. The failure mileage was approximately 93,500.

I had no warning my car just stalled and there was no coolant and white smoke coming from tailpipes. 2.0L EcoBoost coolant intrusion can lead to corrosion, misfires, overheating, fouled spark plugs, engine fires, and complete engine failure. It has been such a problem in early model 2.0L EcoBoosts that Ford issued a technical service bulletin.

Vehicle stalled while out driving. White smoke coming from exhaust tail pipes & smell of gas from inside the vehicle which cause me to become dizzy & lightheaded. Engine started choking out & popping & white smoke coming from under hood. I cut vehicle off & call for roadside assistance- vehicle transported to Waldorf Ford Service Center. Vehicle diagnosed with ERG coolant leak coming from EGR cooler. Had to replace EGR cooler. Cost $1433.32. Solutions Warranty paid $607.82. I had to pay $825.50 which I am not happy about & I want Ford company to refund my $825.50. This issue was a Ford company problem that they were aware of since 2010. I bought this vehicle used on 11/29/2021 w/49,083 miles. Also in 3/28/2023 there was problem with turbo engine Waldorf Ford had to replace the turbo- cost me $400 - Solutions Warranty paid $800 to repair the turbo problem. Ford Company have faulty engine problems with Eco Boost engines. I want Ford company held accountable for my vehicle engine problems & I want Ford Company to refund my money spent on faulty Eco engines that they sold to consumer-Me. I am retired & dint have money to pay out to big Ford Company due to their negligence. Thank you [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2019 Ford Edge. The contact stated that while driving at an undisclosed speed, the oil warning light was illuminated and there was black smoke coming from underneath the rear end of the vehicle. The vehicle was towed to the dealer, who informed the contact that the EGR cooler needed to be replaced. The contact related the failure to Technical Service Bulletin: 20-2234. The manufacturer was made aware of the failure. The failure mileage was approximately 60,000.

The contact owns a 2019 Ford Edge. The contact stated while driving 60 MPH, the temperature gauge was rising with the check engine warning light illuminated. The contact stated white smoke was coming from the tailpipe. The contact parked the vehicle on the side of the road and added coolant because the coolant level was low. The contact continued driving to his residence, but the vehicle started to misfire. The contact continued driving to his residence. The contact took the vehicle to an independent mechanic, where it was diagnosed with needing the engine to be replaced. The vehicle was not repaired. The contact called the local dealer and made them aware of the failure. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 71,000.

Engine, coolant leaking from system. This our second engine and has only been been in the car 3 months less than 3000 miles! This is a on going problem with the ford eco boost engine!

The coolant of the vehicle is getting low after being filled each time. Upon research the 2019 Ford Edge models and Ford’s 2.0L EcoBoost engines are having the same problem. The coolant level gets below low and can even cause engine fire. Upon inspection from the mechanic, it is proven that the coolant fluid level decreases rapidly after filling and can be a leak that might can even cause vehicle fire.

My vehicle overheated as I was driving to work (hardly 5 months after the warranty expired). I pulled over as the engine was smoking. Turns out engine failure the engine was not repairable. So, I took it to my trusted mechanic who ordered the engine from Ford. Within 2 weeks of getting my Edge back, the check engine light was on, the power train light came on too and within seconds of that the engine overheated again. The engine was taking in coolant and burned up again just as the first time. This is a Ford engine issue. Completely ridiculous and unsafe. I’m 5 months pregnant and should not have to worry if my new vehicle is safe or if the engine is going to blow up again.

I was driving the vehicle in highway traffic with a slowdown in the morning , I was driving 14mph and vehicle had about 60,005 miles. The engine started knocking hard while I was driving, prior to this the engine had no issues. The diagnosis’s that the Ford dealership gave was that engine threw and engine rod on cylinder number 6, there was no warning lights that showed. Issue has been reported to Ford and they have yet to reached out due to their engine failing just a few miles over 60k. If i was in regular speed traffic my vehicle would of stopped right on traffic lanes and could of caused an accident. Vehicle is currently in the Ford shop awaiting for repair cost.

The contact owns a 2019 Ford Edge. The contact stated while driving 55 MPH, the vehicle performed as designed; however, while driving under 55 MPH, the vehicle would jerk and lunge while driving. No warning lights were illuminated. The vehicle was taken to the dealer where the contact was informed that there was nothing that could be done to correct the failure. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed to contact the NHTSA Hotline. The failure mileage was approximately 42,000.

The contact owns a 2019 Ford Edge. The contact stated while driving 45 MPH, the vehicle was driving rough. The contact stated that the vehicle then lost motive power and stalled without warning. The contact was not able to pull to the side of the road; however, the vehicle was towed to the dealer. The dealer stated that the EGR cooler needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and a case was filed. The failure mileage was 31,005.

I cut my car off to fill up with gas, after filling up with gas I get back in my 2019 Ford Edge Titanium 2.0 Eco Boost and my car would not crank. It was turning over but would not crank. Finally, after my fourth time trying to start my 2019 Ford Edge it finally started and I had pump the gas pedal to keep it running. Then I noticed the engine light on, and my 2019 Ford Edge was running rough and sounded horrible. I took my 2019 Ford Edge to the Ford Dealership and was told that the Purge Solenoid Valve was bad, Giving my 2019 Ford Edge a default code a P0456 Fault Code (Evaporative Emission System Leak Detected, Severity 1 of 3, Service Should Be Scheduled and Repaired). My 2019 Ford Edge Titanium 2.0 only had 74,000 miles at the time this happened. The Ford Dealership told me that the Purge Solenoid Valve is/was not covered under the warranty. I believe a recall should be posted for the 2019 Ford Edge Titanium 2.0 Eco Boost. Because the part should not fail at under 100,000 miles. Also, this could affect the Oxygen Sensors Failing also. As a result of leaving a family stranded at the gas pump because there car will not start. Thank You, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Engine coolant leaked into the engine causing catastrophic engine failure.

Engine failed. Car was jumping and shaking out of control on the highway while I was going 60 mph and before I could pull of the highway it wouldn’t accelerate at all, and stopped directly in the middle of a busy highway.I could have been rear ended at a speed of 60 mph on a highway. It’s currently at Ford dealership. Before the car while parked made a gushing sound like water coming out of bath tub. After car started shaking check engine light and engine coolant over temperature came on.

ENGINE COOLANT LEAKING INTO THE ENGINE BLOCK CAUSED THE VEHICLE TO COME TO A GRINDING HALT ON THE HIGHWAY. THE VEHICLE ALERTED TO LOW ENGINE COOLANT ROUGHLY 30 SECONDS PRIOR TO LOSING DRIVE POWER. THE VEHICLE HAS APPROXIMATELY 42000 MILES ON IT. THERE WAS SMOKE COMING FROM THE EXHAUST THAT SMELLED OF BURNT COOLANT AND SMOKE COMING FROM UNDER THE FRONT HOOD, BUT NO FIRE.

CAR SHUTS OFF WHILE DRIVING. THIS IS THE SECOND TIME THIS HAS HAPPENED. THE FIRST TIME IT HAPPENED ON THE HIGHWAY.

FROM STOP, BEGAN RIGHT TURN INTO CITY TRAFFIC. HEARD LOUD CLICKING NOISE IN DASHBOARD. ENGINE CUT OFF. LOST POWER STEERING. COASTED TO STOP ON SIDE OF THE CITY STREET. RESTARTED ENGINE SUCCESSFULLY AND DROVE AWAY.