2003 Chevrolet Malibu Engine Problems

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE EXPERIENCED A LOSS OF ENGINE POWER THE FAILURE OCCURRED WITH NO WARNING. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 88,000. UPDATED 05/31/17*LJ *AS

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING 40 MPH, THE CHECK OIL WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE CAMSHAFT FAILED AND CAUSED SEVERE DAMAGE TO THE ENGINE. THE CONTACT WAS INFORMED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS UNABLE TO RESTART AND WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE ATTEMPTING TO START THE VEHICLE, IT FAILED TO START INTERMITTENTLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING 60 MPH, THE VEHICLE LOST POWER AND THE ANTI-THEFT WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 111,000.

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STALLED. THE VEHICLE WOULD NOT RESTART. THE ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS RECOMMENDED TO TAKE THE VEHICLE TO A DEALER FOR DIAGNOSIS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.

WHEN DRIVING MY CAR THE THE ENGINE SHUTOFF AND THE BRAKES FAILED.

WHILE DRIVING AT STOP INTERVALS I NOTICED THAT MY TEMP GUAGE WAS REACHING THE HOT MARK, I MADE IT HOME AND MY RESERVOIR WAS BOILING. THEN I NOTICE COOLANT LEAKING FROM THE MANIFOLD HOUSING. WHEN I HAD IT CHECKED OUT, I WAS TOLD THAT MY MANIFOLD GASKETS HAD TO BE REPLACED AT A COSTLY EXPENSE. UPON FURTHER INVESTIGATIONS I FOUND OUT THAT GM KNEW THAT THIS WAS A DEFAULT ISSUE AND ONLY SENT OUT RECALLS TO CERTAIN CUSTOMERS AND I WASN'T ONE OF THEM. I BELIEVE THAT GM SHOULD BE HELD ACCOUNTABLE AND MAKE THE PROPER RECALLS TO GET THIS MATTER SOLVED. ANY HELP WOULD BE GREATLY APPRECIATED SINCE I MISSED THE RECALL. I BELIEVE THAT THE RECALL IT WAS IN 2008, AND MY PROBLEM DIDN'T OCCUR UNTIL NOW.

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE THE VEHICLE WAS BEING INSPECTED, THE INSPECTOR STATED THAT THE FUEL WAS NOT TRAVELING THROUGH THE VEHICLE PROPERLY. THE DEALER STATED THAT THE INTAKE MANIFOLD FAILED AND DAMAGED THE ENGINE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE KEY WAS ABLE TO TURN TO THE ON POSITION IN THE IGNITION, BUT WOULD NOT TURN COMPLETELY TO START THE VEHICLE. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. AN INDEPENDENT MECHANIC REPLACED THE IGNITION SWITCH, BUT THE FAILURE RECURRED. THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO RESTART AFTER SEVERAL ATTEMPTS. THE CONTACT WAS LATER INFORMED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM), BUT THE PART NEEDED FOR THE REPAIR WAS UNAVAILABLE. THE DEALER DID NOT PROVIDE A SPECIFIC DATE FOR WHEN THE REMEDY WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 57,000. UPDATED 11/05/14*LJ *JS

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING 55 MPH, THE VEHICLE'S RPMS DECREASED AND THE ENGINE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND THE ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.

AS I WAS TURNING ON A STREET THE CAR SHUT OFF AND WOULD NOT CRANK BACK UP. WHEN IT SHUT OFF IT LOCKED UP AND I WAS UNABLE TO TURN THE WHEEL. I WAS GOING ABOUT 30MPH THE NEXT TIME IT HAPPENED I WAS GOING OVER A BRIDGE AND THE CAR SHUT OFF. IT WOULD NOT CRANK BACK UP IMMEDIATELY AND I HAD TO ENGAGE THE EMERGENCY BRAKE SO THAT THE CAR DID NOT DRIFT BACKWARD. THE NEXT TIME THAT IT HAPPENED I WAS ON A MAIN HIGHWAY AND THE CAR SHUT OFF IT WOULD NOT CRANK BACK UP IMMEDIATELY. MY LIGHTS DID NOT WORK SO I WAS UNABLE TO ENGAGE MY HAZARDS THE CAR LOCKED AND I WAS UNABLE TO LET THE WINDOWS UP OR DOWN NOW WAS THE LOCKS WORKING. I HAD TO SIT THERE FOR 15 MIN BEFORE THE CAR CRANK BACK UP. THERE ARE TIMES WHEN THE CAR WILL NOT CRANK UP AND YOU HAVE TO LET IT SIT FOR A WHILE WITH THE KEY TURNED TO THE ON POSITION. EACH TIME THAT THE CAR HAS SHUT OFF I HAVE BEEN IN TRAFFIC HELPLESS. IT HAS SHUT OFF ON ME WHILE I HAVE HAD MY INFANT CHILD AT THE TIME IN THE CAR AS WELL. *TR

I ALONG WITH A FRIEND WAS RIDING FROM PHILA. TO CHESTER,PA. ABOUT 25MILES SOUTH ON. INTERSTATE 95. .I WAS IN THE MIDDLE LANE ABOUT 10 MILES IN AND THE ENGINE CUT OFF..I REMAINED CALM AND GLAD MY FRIEND WAS WITH ME I SHIFTED INTO NEUTRAL TURNED THE KEY AND THE ENGINE STARTED RIGHT AWAY. THIS HAPPENED TWO OTHER TIMES BEFORE GETTING TO MY DESTINATION. ON THE WAY HOME THE ENGINE CUT OFF TWO MORE TIMES.THIS TIME I WAS ALONE, AS YOU CAN IMAGINE I WAS SCARED AND QUITE UPSET. I HAVE ALSO HAD PROBLEMS WITH THE KEY TURNING IN THE IGNITION SOMETIMES IT WORKS OFTEN NOT EVEN AFTER PURCHASING A NEW KEY AND BATTERIES. THE ENGINE LIGHT REMAIN ON , THE ANTI THEFT SYSTEM LIGHT ON AND OFF, THE HORN, LIGHTER AND THE RECEPTACLE FOR PHONE NOT WORKING EVEN WITH NEW FUSE AND THE RADIATOR LEAKS. JUST THIS YEAR I HAVE SPENT OVER 1100.00. THIS IS DANGEROUS AND DISGUSTING. OUR FAMILY HAVE BEEN VERY CONSCIENCE ABOUT PURCHASING AMERICAN MADE CARS AND HAVE INVESTED IN MADE IN THE USA BUT IT SEEMS GM HAS LITTLE TO NO INTERESTED IN OUR SAFETY. TODAY THE PROBLEMS STILL EXIST AND I WAS TOLD THAT I HAVE TO PAY EVEN MORE TO GET A DIAGNOSTIC 149.00. WRONG ANSWER...PLEASE HELP RESTORE MY FAITH IN GM AFTER ALL WE THE PEOPLE DID BAIL YOU OUT NOW OWN UP AND LOOK OUT AND TAKE RESPONSIBILITIES FIX THIS BEFORE MORE TRAGEDY.. TAKE CARE OF AMERICANS WHERE IS YOUR HONOR ? *TR

THE CAR WAS PURCHASED IN NOVEMBER OF 2012 IN WASHINGTON. ON THE DRIVE FROM WASHINGTON TO MISSOURI, THE CAR WOULD NOT START AFTER THE ENGINE WAS OFF. AFTER WAITING THREE DAYS FOR THE MECHANIC IN A SMALL SOUTH DAKOTA TOWN, HE "FIXED" IT IN TEN MINUTES. THE "SOLUTION" OF KEEPING THE ENGINE ON FOR TEN MINUTES, TURNING TO OFF, AND THEN STARTING IT AGAIN IS ONLY A TEMPORARY FIX TO A VERY REAL PROBLEM. THIS PROBLEM IS SO REAL AND OBVIOUS THAT THE TEN MINUTE SOLUTION IS INCLUDED IN THE OWNER'S MANUAL (WHY THAT INSTEAD OF FIXING IT, I'M NOT REALLY SURE...) THE PROBLEM HAS PERSISTED INTERMITTENTLY FOR THE LAST YEAR AND A HALF, ANYWHERE FROM TWO TO EIGHT TIMES A MONTH- UNTIL THIS LAST MONTH. I BEGAN KEEPING TRACK ON A CALENDAR THE NUMBER OF TIMES THE CAR WOULD FAIL TO WORK - 26 TIMES IN FIVE WEEKS. THIS IS BEYOND ANNOYING. THE PROBLEM WOULD BE EVEN WORSE IF IT WERE NOT FOR THE FACT THAT I AM A TEACHER AND THE LAST WEEK OF SCHOOL WAS THE FIRST WEEK IN THESE FIVE WEEKS. NOW THAT I AM OUT FOR THE SUMMER, MANY DAYS NOW I STAY AT HOME, THUS REDUCING THE CHANCE OF THE CAR FAILING TO WORK AS I AM NOT USING IT. THAT LAST WEEK OF SCHOOL, IT "STALLED" EVERY SINGLE DAY. TWO DAYS AGO, IT QUIT WORKING FOUR TIMES IN ONE DAY. I HAVE BEEN LATE FOR WORK, CHURCH, AND OTHER OBLIGATIONS. I HAVE BEEN STRANDED IN DARK PARKING LOTS LATE AT NIGHT. ALONE. THIS IS NOT A PROBLEM ANYONE SHOULD HAVE TO WORRY ABOUT. I DRIVE AS INFREQUENTLY AS I POSSIBLY CAN NOW, AND WAS FERVENTLY PRAYING THAT MY CAR WOULD START AFTER FILLING IT UP WITH GAS THIS MORNING. THIS IS A KNOWN PROBLEM. I WAS HOPING THE MOST RECENT RECALLS WOULD AFFECT THIS CAR AND WHEN TYPING "2003 MALIBU RECALLS," INTO A SEARCH ENGINE, WHILE NO RECALLS WERE SHOWN, WEB SITE AND FORUMS APLENTY ALL CAME UP, WITH MULTIPLE COMPLAINTS ABOUT THIS SINGULAR PROBLEM OF THIS SINGULAR CAR. IT IS A KNOWN SAFETY PROBLEM. WHY IS THERE NO RECALL? *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED SEVERAL TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 28,000. THE CURRENT MILEAGE WAS 33,500.

CAR FAILED TO START. A LOCAL MECHANIC WAS AWARE OF THE PROBLEM THAT GM WAS HAVING WITH THE MALIBU'S. HE SHOWED ME HOW TO TURN THE KEY TO ON FOR 10 MINUTES AND THEN THE THEFT LIGHT WOULD STOP BLINKING AND YOU COULD THEN START THE CAR. THIS PAST YEAR IT HAS BEEN HAPPENING ABOUT DAILY OR EVERY 5 TO 6 TIMES THAT YOU GO TO START THE CAR. MOSTLY ON SHORT TRIPS OF LESS THAN 2 MILES. I CONTACTED 2 LOCAL CHEVY DEALERS AND THEY CLAIM TO KNOW NOTHING ABOUT THE PROBLEM! I HAVE BEEN TOLD TO BRING IT IN AND THEY WOULD CHECK IT OUT - AT A CHARGE. WHAT IF THIS HAPPENED IN AN AREA THAT WAS NOT SAFE FOR MY FAMILY OR ME - WE COULD NOT START THE CAR AND WOULD HAVE TO JUST SIT THERE FOR 10 MINUTES!

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT UPON INSPECTION, THE ENGINE COOLANT WAS FOUND TO HAVE MIXED WITH THE ENGINE OIL WHEN THE DIP STICK WAS PULLED TO CHECK THE ENGINE OIL. THE CONTACT ALSO MENTIONED THAT THE VEHICLE STALLED WITHOUT WARNING AND HAD TO BE TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE ENGINE HAD TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE AND CURRENT MILEAGE WAS 139,126. UPDATED 01/28/14*LJ THE CONSUMER STATED THE INTAKE MANIFOLD WAS DEFECTIVE. UPDATED 04/21/14 UPDATED 06/30/14

OVER THE LAST YEAR, 2003 CHEVY MALIBU HAS NOT STARTED ON FOUR DIFFERENT OCCASIONS. IT WAS STARTED AND DRIVEN TO ANOTHER LOCATION (IE WORK, SHOPPING, CLASS, ETC) AND THEN UPON RETURNING TO THE CAR, IT WOULD NOT START. THIS IS A MAJOR SAFETY CONCERN AND ESPECIALLY SO IF ONE OF THE CHILDREN IS USING THE CAR. AS I HAVE READ, OTHERS ARE HAVING SIMILAR ISSUES - THIS IS A SAFETY ISSUE AND WARRANTS ATTENTION BY THE MANUFACTURER! *TR

MY 2003 MALIBU(65000 MILES) STARTED TO IDLE HIGH (2000-2500RPM). WE TOOK IT TO OUR REGULAR MECHANIC SHOP, THEY DECIDED IT WAS THE IDLE AIR CONTROL VALVE, REPLACED IT AND IT WORKED FINE UNTIL EARLY JUNE WHEN IT STARTED IDLING HIGH, INTERMITTENTLY. THE RISING IDLE WOULD START WITH A ROUGH ACCELERATION, THEN THE RPM'S WOULD START TO RISE AND NOT COME BACK DOWN. WE TOOK IT BACK AND THEY COULD NOT GET THE PROBLEM TO RECUR, SO THEY TOLD US TO BRING IT IN WHEN IT WAS ACTING UP, SINCE IT WAS NOT CONSTANT. THEY ASSUME AT THIS POINT IT WAS A FAULTY IAC THAT HAD BEEN REPLACED. 2 WEEKS LATER, IT DID AND WE TOOK IT IN. THE RPM'S WERE CLOSE TO 4000 AND IT WAS STARTING TO OVERHEAT WHILE THE MECHANIC WAS CHECKING IT. THAT WAS ON MONDAY, JUNE 24, 2013. THE MECHANIC REACHED INTO THE ENGINE AND DID SOMETHING TO STOP THE RPMS FROM CONTINUING TO INCREASE. TODAY IS WEDNESDAY AND THEY DO NOT KNOW WHAT THE PROBLEM IS. IF ANYONE HAS ANY INFORMATION ON IF THIS IS A PROBLEM WITH THIS MAKE AND MODEL, PLEASE LET ME KNOW. THANK YOU. *TR

INTAKE MANIFOLD GASKET AT LESS THEN 55,000 MILES DUE TO PLASTIC GASKETS.. AFTER NUMEROUS MECHANICS SAY A CHEAP UNRELIABLE PART THAT WILL COST ANYONE FROM 600$ OR MORE DEPENDING ON HOW SERVER IT COULD BE. I AM SURPRISE THERE ARE NO RECALLS ON THIS... THIS SHOULD BE LOOKED INTO PLUS REIMBURSEMENT TO THOSE WHOM HAVE RECEIPTS FOR THIS PARTICULAR PROCEDURE. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT IN EARLY MAY 2012 SHE WAS UNABLE TO START THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER, WHO REPROGRAMMED THE KEY. THE FAILURE CONTINUED. THE VEHICLE WAS THEN TAKEN TO A PRIVATE MECHANIC, WHO DIAGNOSED NO FAILURE. THE MANUFACTURER WAS NOTIFIED AND PROVIDED A CASE NUMBER WHICH WAS NOT AVAILABLE. THE MANUFACTURER ADVISED TO TAKE THE VEHICLE BACK TO THE DEALER. THE DEALER AGAIN DIAGNOSED THAT THERE WAS NO FAILURE. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 86,000 AND THE CURRENT MILEAGE WAS 88,000.

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE VEHICLE OVER HEATED ABNORMALLY. THE FAILURE WAS RECURRING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT A MODULE FAILED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE CONTACT'S PERSONAL MECHANIC WHO ADVISED THAT THE HEAD GASKET WAS DEFECTIVE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 100,000. THE CURRENT MILEAGE WAS112,000.

PLEASE BRIEFLY DESCRIBE YOUR COMPLAINT: I HAVE A 2003 CHEVY MALIBU THAT HAS BEEN LEAKING COOLANT SINCE THE DAY I HAVE BOUGHT IT. I HAVE TAKEN IT NUMEROUS MANIACS AND THEY HAVE ALL TOLD ME THE SAME THING THAT MY INTAKE MANIFOLD GASKETS WERE LEAKING COOLANT AND THAT THIS ISN'T THE FIRST TIME THEY HAVE SEEN THIS PROBLEM. THESE MECHANICS TOLD ME THAT THE GASKETS FOR THIS CAR AND THE MANIFOLD ITSELF WERE NOT ENGINEERED CORRECTLY AND THAT'S THE REASON IT IS LEAKING COOLANT. I WAS ALSO TOLD GM DID HOWEVER FIX THIS PROBLEM BY DESIGNING NEW GASKETS WHICH THEY ARE USING TO REPLACE THE OLD ONES WHEN THESE PEOPLE BRING THERE CAR IN FOR THIS PROBLEM. OKAY ONE PROBLEM RIGHT THERE WHERE WAS THE RECALL ON THAT? THAT A HEALTH AND SAFETY HAZARD RIGHT THERE BECAUSE OR GMS ENGINEERING. IM NOT SURE IF YOUR AWARE OF THIS BUT THE SMELL AND FUMES FROM THIS LEAKING INTO THE ENGINE ARE DISGUSTING. ALSO I HAVE DONE ONLINE RESEARCH ABOUT THIS PROBLEM ALL YOU NEED TO TYPE IN IS PROBLEMS WITH CHEVY MALIBU INTAKE MANIFOLD GASKET THOUSAND AND THOUSANDS OF COMPLAINTS WHIT PEOPLE ALL OVER AMERICA HAVE THIS SAME EXACT ISSUE AND ITS NOT THAT THEY PAY THE $900.00 TO GET IT FIXED THE FIRST TIME THEN AGAIN ABOUT A YEAR TO A YEAR IN A HALF LATER THEY ALSO PAY THIS PRICE AGAIN BECAUSE THE SAME THING HAS HAPPENED I AM ONE ANGRY AMERICAN AND I THERE ARE THOUSANDS OF MORE I WILL NOT GIVE UP ON MY CASE FOR AS WELL AS MY FELL AMERICAS IN THIS COUNTRY WHO ARE EXPERIENCING THIS ISSUE. PLEASE HELP US!! THIS IS NOT FAR THIS SHOULD BE A RECALL ON GM AND I WILL DO WHAT EVER IT TAKE TO GET TO THAT POINT. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

FOR YEARS, CAR STALLS WHILE DRIVING AND CAN NOT BE RE-STARTED, OR MORE FREQUENTLY, JUST WON'T START. NO WARNING EXCEPT A FINE, DIM RED ANTI-THEFT SYSTEM LIGHT WHICH IS UNLIKELY TO BE NOTICED AT ALL, AND CERTAINLY NOT IMMEDIATELY. CAN HAPPEN SEVERAL TIMES PER DAY, OR CAN GO TWO WEEKS WITHOUT A PROBLEM. SHORT TERM REMEDY IS RELIABLE IF INCONVENIENT AND IN SOME SITUATION, DANGEROUS; WITH CAR IN "PARK," TURN OFF ALL SYSTEM, TURN ON IGNITION SWITCH BUT DO NOT START, DO NOT DISTURB FOR AT LEAST EN MINUTES. SYSTEM WILL THEN BE RESET. THERE IS EVIDENCE THAT THIS PROBLEM HAD MULTIPLE CAUSES. GOT PARTIAL, TEMPORARY IMPROVEMENT (LESS FREQUENT FAILURE) BY REPLACING DEFECTIVE DS LOCK SWITCH, WHICH IS ALSO USED TO PROGRAM THAT LOCKING SYSTEM FEATURES. BECAUSE THE USERS IS SUPPOSED TO INITIATE LOCKING SYSTEM PROGRAMMING BY HOLDING THE SWITCH CLOSED, AND THE LOCK WAS STICKING CLOSED AND OPENING UNPREDICTABLY, IT WAS SURELY CREATING INPUTS NOT ANTICIPATED BY THE SYSTEM'S PROGRAMMERS. I BELIEVE THE IGNITION SWITCH SYSTEM, INCLUDING THE INTERFACE WITH THE TRANSMISSION SELECTOR SYSTEM, IS STILL CAUSING THIS PROBLEM, AND FREQUENCY OF OCCURRENCE INCREASES. HAVE NOT FOUND SATISFACTORY SOLUTION. CAN'T AFFORD THE $400 DEALER SAYS IT WILL COST FOR (POSSIBLE) FIX, AMBIGUOUS EXPLANATIONS MAKE ME DOUBT THE DEALER REALLY UNDERSTANDS THE CAUSE. NO ACTUAL PROPERTY DAMAGE OR CRASH YET, BUT OBVIOUSLY RISK IS HIGH WHEN CAR SUDDENLY STALL IN TRAFFIC. *TR

TL*THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE WOULD SUDDENLY SHUT OFF AT LEAST FIVE TO SIX TIMES A DAY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP BUT THE DEALER COULD NOT DUPLICATE THE FAILURE. THE DEALER REPLACED THE FUEL PUMP, FUEL MODULATOR AND COIL SPRINGS. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT. THE VEHICLE WAS AT THE DEALERSHIP AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 47,000.

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE TRAVELING AT 35 MPH, THE BATTERY WARNING LIGHT ILLUMINATED ON THE DASHBOARD. SECONDS LATER, THE VEHICLE STALLED. THE VEHICLE HAS NOT BEEN DIAGNOSED OR REPAIRED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 9,000

I HAVE A 2003 CHEVY MALIBU AND I HAD TO GET A GASKET REPLACED DUE TO THE POSSIBILITY OF ANTI-FREEZE LEAKING INTO THE OIL. I'VE BEEN TOLD THE PROBLEM WILL HAPPEN AT ABOUT 77,000 MILES. ONE PERSON CREATED A WEBSITE ABOUT THIS PROBLEM. IF NOT FIXED IT WOULD CAUSE MASSIVE PROBLEMS FOR THE CAR. *TR

MY WIFE HAS A 2003 CHEVY MALIBU. WE WENT TO TAKE MY CAR TO AN AUTO SHOP BECAUSE WE THOUGHT THERE WAS A LEAK SOMEWHERE UNDER MY CAR. THE MECHANIC TOLD ME IT WAS A GASKET ON THE THERMOSTAT. HE REPLACED THAT AND STILL THE CAR LEAKED. THEN MECHANIC TOLD ME IT WAS ANTIFREEZE LEAKING FROM THE LOWER INTAKE MANIFOLD GASKET AND THAT THIS WAS A COMMON PROBLEM ON THIS TYPE OF ENGINE. IMAGINE HOW UPSET WE WAS TO KNOW THAT CARS THIS PROBLEM IS OCCURRING TO A LOT OF PEOPLE AND THAT IT WILL COST NEARLY $500.00 TO FIX. SINCE THIS IS HAPPENING TO ALOT OF CAR THERE MUST BE A MAJOR PROBLEM. I WAS LATER TOLD GM USES A GLUE ONTO A GASKET IN THIS AREA WHEN THEY BUILD THE CAR. GM MUST DO BETTER. THIS IS NOT RIGHT. *TR

WENT TO TAKE MY CAR TO AUTO SHOP BECAUSE I THOUGHT HAD A TRANSMISSION LEAK. THE MECHANIC TOLD ME THE GOOD NEWS ,THE TRANNY WASN'T LEAKING, HOWEVER IT WAS ANTIFREEZE LEAKING FROM THE LOWER INTAKE MANIFOLD GASKET AND THAT THIS WAS A COMMON PROBLEM ON THIS TYPE OF ENGINE. IMAGINE HOW UPSET I WAS TO KNOW THAT CARS THIS PROBLEM IS OCCURRING TO A LOT OF PEOPLE AND THAT IT WILL COST $700 TO FIX IT. THE MECHANIC SAID THAT THERE WAS A CLASS ACTION SUIT FOR THIS DEFECT. CONSIDERING THE ECONOMIC PROBLEMS AND ALL THE HELP GM HAS RECEIVED FROM AMERICANS IT SEEMS LIKE THEY WOULD HELP THEIR LOYAL CUSTOMERS BY FIXING THIS FOR NOTHING. THIS MALIBU IS THE 4TH CHEVY THAT I HAVE OWNED SINCE DRIVING. IF AMERICAN COMPANIES WANT US TO BUY THEIR PRODUCT THEY SHOULD MAKE WITH QUALITY MATERIAL. I ALSO HAD TO HAVE THE FUEL PUMP ABOUT 3 MONTHS AFTER BUYING THE CAR IN 2007. THAT COST ME ALMOST $800. IF I HAD KNOWN THAT THESE CARS WERE GOING HAVE SUCH A LIST OF PROBLEMS I WOULD HAVE LISTENED TO MY BROTHER AND GOT A FOREIGN VEHICLE. GM CAN EARN SOME GOODWILL WITH ITS VEHICLES BY ADMITTING ITS MISTAKES AND HELPING THE LITTLE GUY OUT, LIKE THE LITTLE GUY HAS HELPED THEM OUT WITH THE BAILOUT. *TR

ENGINE CUTSOFF WHILE DRIVING CAUSING THE CAR TO LOSE POWER AND COME TO A COMPLETE STOP. *TR

I HAVE A 2003 CHEVY MALIBU WITH APPROX 72,000 MILES THAT HAS BEEN LEAKING ANTIFREEZE (SMALL VISIBLE MARKS ON PAVEMENT) THAT REQUIRE REFILLING COOLANT EVERY 3 TO 4 WEEKS. I TOOK THE CAR IN FOR A DIAGNOSIS, AND IT WAS FOUND TO HAVE A LEAK AROUND THE INTAKE MANIFOLD. THE PRICE ESTIMATE IS $878 AND 7 HOURS TO REPAIR. THERE WAS A CLASS ACTION LAWSUIT AGAINST DEXCOOL FOR THIS PROBLEM, BUT WINDOW FOR CLAIMS ENDED ON OCT. 2008. I SPOKE WITH GM DEALERSHIP, AND THERE IS NO GM RECALL FOR THIS ISSUE, EVEN THOUGH THERE ARE MANY CARS WITH THIS PROBLEM (LEAKY INTAKE MANIFOLD GASKET). WILL HAVE WORK DONE, BUT UNHAPPY WITH THE COST INVOLVED. *TR

I OWN A 2003 CHEVROLET MALIBU WITH 51,000 MILES ON IT. I WAS CHECKING MY OIL WHEN THE DIP STICK SHOWED IT A QUART LOW. I THEN CHECKED THE ENGINE COOLANT AND DISCOVERED THE OIL HAD GOTTEN INTO THE COOLANT. I TOOK IT TO A MECHANIC AND HE CONFIRMED THAT THE COOLANT HAD OIL IN IT. HE SAID THE MANIFOLD GASKETS HAD TO BE REPLACED WHICH INCLUDED FLUSHING THE COOLING SYSTEM. I KNOW GM DOESN'T CARE ABOUT OUR PROBLEMS WITH THEIR SORRY BUILT CAR. THE TOTAL COST OF THE REPAIR WAS OVER $600. THIS IS THE FIRST CAR THAT I HAVE EVER OWNED THAT A MANIFOLD OR HEAD GASKET HAD TO BE REPLACED. *TR

AFTER ENGINE COOLANT LIGHT COMING ON AND RESERVOIR BEING ALMOST EMPTY SERVICE STATION ADDED COOLANT. SAME THING HAPPENED APPROX 2 MONTHS LATER SAME ACTION TAKEN. WENT TO GET OIL CHANGED AND PERSON SAID DON'T WASTE YOUR MONEY BECAUSE YOU HAVE OIL MIXED WITH YOUR RADIATOR FLUID, YOU HAVE SOME MAJOR ENGINE PROBLEMS. TOOK CAR TO MY LOCAL MECHANIC AND HE SAID THIS WAS A COMMON PROBLEM ON THE 2003 MALIBU AND THAT THE MANIFOLD GASKET WAS THE PROBLEM AND NEEDED TO BE REPLACED. HE REPLACED IT AT GREAT EXPENSE TO MYSELF,AND HE DID MAKE THE COMMENT THAT THERE IS A DESIGN FLAW WITH THIS PARTICULAR PART. *TR

TL*THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 5 MPH, THE ANTI-FREEZE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE CONTACT PULLED BACK INTO THE DRIVEWAY AND NOTICED THAT THE RESERVOIR WAS EMPTY. HE HAD TO REFILL THE VEHICLE WITH ANTI-FREEZE. APPROXIMATELY ONE MONTH LATER, THE RESERVOIR WAS ALMOST EMPTY AGAIN AND HE HAD TO REFILL THE VEHICLE WITH ANTI-FREEZE. IN JANUARY OF 2009, THE VEHICLE WAS DRIVEN TO A LOCAL REPAIR SHOP FOR AN OIL CHANGE AND THE MECHANIC STATED THAT THERE WAS SOME ANTI-FREEZE ON THE ENGINE DUE TO THE MANIFOLD GASKET BEING DEFECTIVE. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND THE MANUFACTURER WERE NOT NOTIFIED. THE CURRENT MILEAGE WAS 79,000 AND FAILURE MILEAGE WAS 78,500. UPDATED 2/5/09 *CN THE CONSUMER WAS INFORMED THE GASKET WAS MADE OUT OF PLASTIC THAT WAS THE REASON FOR THE FAILURE. UPDATED 02/10/09. *JB

TL*THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE VEHICLE HAS BEEN SHUTTING OFF INTERMITTENTLY FOR THE PAST EIGHT MONTHS. THE DEALER KEEPS RESETTING THE COMPUTER, BUT THE FAILURE PERSISTS. THE WEATHER WAS NOT A FACTOR. THE POWER STEERING AND BRAKES FAIL WITHOUT WARNING. THE FAILURE OCCURS WHILE ACCELERATING OR CRUISING. THE FAILURE MILEAGE WAS 132,000. UPDATED 2/5/09 *CN UPDATED 02/10/09. *JB

2003 CHEVY MALIBU WITH 88K. DURING ROUTINE OIL CHANGE WAS ADVISED OF OIL IN COOLANT. UPON TAKING TO MECHANIC WAS TOLD I HAD BAD HEAD/INTAKE GASKET AND NEEDED REPLACED , ESTIMATE COST $2400. UPON RESEARCHING FARTHER I FOUND OUT THAT THIS IS COMMON ON SOME GM VEHICLES WITH THE SAME ENGINE AND THAT IN FACT A CLASS ACTION LAWSUIT HAD BEEN SETTLED IN CALIFORNIA EARLIER THIS YEAR. IN ANY CASE, I'M STUCK WITH THE BILL ON A REPAIR THAT WAS CAUSED BY THE COOLANT THAT THE GM USED AND REQUIRED AS APART OF THE WARRANTY. *TR

THE INTAKE MANIFOLD GASKET ON MY 2003 CHEVY MALIBU HAD TO BE REPLACED SINCE IT WAS PLASTIC. HAS THEIR BEEN A RECALL ON THIS PART? IF SO, WHAT FORMS NEED TO BE FILLED OUT TO GET PROPER REFUNDING? *TR

I OWN A 2003 CHEVY MAILBU. I HAVE HAD NUMEROUS PROBLEMS WITH THE ANITFREEZE DRAINING OUT. I HAVE HAD IT IN THE SHOP A COUPLE TIMES AND HAVE HAD THE MANIFOLD INTAKE GASKET REPLACED. THIS WAS VERY EXPENSIVE FOR A SINGLE MOM ON A BUDGET. THE PROBLEM STILL PERSISTS. I HAVE ALSO STARTED HAVING PROBLEMS WITH THE THEFT SYSTEM LIGHT COMING ON AND PREVENTING THE CAR FROM STARTING. I CAN TURN IT TO "ON" AND GET IT STARTED AFTER 10 MINUTES, BUT THIS IS BOTHERSOME WHEN I AM IN A HURRY. I THINK THAT GM SHOULD HAVE THESE PROBLEMS UNDER RECALL AND PAY TO HAVE THEM FIXED. *TR

2003 MAILBU 6 CY. I JUST HAD $1,300.00 CAR REPAIR THAT COULD HAVE BEEN AVOIDED IF GMC WOULD HAVE RECALLED ALL CARS THAT HAVE THE ANTIFREEZE WITH ACID IN IT. THIS IS A REPAIR THAT THEY ARE FIGHTING IN A CLASS ACTION LAW SUIT BLAMING THE DRIVERS WHEN OUR BOOKS STATE NO CHANGING ANTIFREEZE FOR 150,000 MILES. IN STEAD THEY ARE PUTTING PEOPLE WHO BOUGHT AMERICAN MADE CARS HAVE THIS UNNECESSARY EXPENSE. THIS IS MONEY THAT I HAD TO BORROW AND NOW FIND SOME WAY TO PAY BACK SO THAT I MAY CONTINUE TO WORK. THIS SHOULDN'T EVEN BE A LAW SUIT. THEY SHOULD OWN TO THEIR MISTAKE AND MAKE GOOD THE ERROR THAT THEY MADE. *TR

YOU CAN ADD MY NAME TO THE LIST OF INDIVIDUALS SHELLING OUT AN EXCESSIVE AMOUNT OF MONEY TO REPLACE WHAT APPEAR TO BE DEFECTIVE PARTS AND/OR MANUFACTURING DESIGNS IN THE 2003 CHEVY MALIBU. WE PURCHASED THE CAR NEW IN FEB 2003 AND REPAIR COSTS TO DATE ARE IN EXCESS OF $2,000 AND THE CAR ONLY HAS 52,000 MILES ON IT. FIRST, THE BRAKES AND ROTORS NEEDED PLACED AFTER ABOUT 40,000 MILES (MOST OF WHICH WERE INTERSTATE DRIVING)...COST WAS OVER $300. NEXT, WE WERE GETTING THE CAR REPAIRED AFTER AN INCIDENT WITH A DEER AND THE MECHANIC INFORMED US THAT COOLANT WAS STARTING TO LEAK INTO THE ENGINE BECAUSE OF A FAULTY INTAKE MANIFOLD GASKET...REPAIR COST ALMOST $1,000. FINALLY, MY WIFE WAS RECENTLY STRANDED BECAUSE THE FUEL PUMP FAILED...REPAIR COST $1,000. ALL OF THESE INCIDENTS OCCURRED WITHIN THE PAST 6 MONTHS. BY FAR THE MOST FRUSTRATION THING IS THAT ALL THESE ITEMS APPEAR TO BE VERY COMMON FAILURES WITH THIS MAKE AND MODEL MADE BY CHEVROLET AND THERE HAS YET TO BE ANY RECALLS...VERY DISAPPOINTING. MY ENTIRE EXPERIENCE HAS CONTINUED TO SNOWBALL EVER SINCE WE HAD ISSUES WITH GETTING THE DEALERSHIP TO FIX ITEMS THAT WERE STILL UNDER WARRANTY. GENERAL MOTORS SEEMS TO BE MORE FOCUSED ON EARNING PROFITS THAT COMPETE WITH THE FOREIGN PRODUCERS RATHER THAN TAKING CARE OF THEIR CURRENT CUSTOMERS. IF THINGS DON'T CHANGE, THE COMPANY WILL HAVE VERY LIMITED REPEAT CUSTOMERS. *TR

I HAVE BEEN INFORMED THAT I NEED A NEW INTAKE MANIFOLD GASKET. I WAS TOLD THAT GM WENT TO A CHEAP CAM SHAFT AND INTAKE GASKET ON MOST OF THE 3.1 TO 3.8 LITRE V6 ENGINES ABOUT 7 YEARS AGO AND THAT OVER 90% OF THESE ENGINES HAVE A LEAKING INTAKE GASKET WHICH CAUSES THE CHEAP CAM SHAFT TO RUST AND THEN BREAK DESTROYING THE ENGINE. I WAS TOLD THAT THIS HAPPENS BETWEEN 50,000 AND 90,000 MILES ON THESE ENGINES, THAT THERE ARE NO REPLACEMENT ENGINES AVAILABLE IN THE SALVAGE YARDS AND THAT GM CONTINUES TO PRODUCE THIS DEFECTIVE PRODUCT. NOW IM LOOKING AT APPROX. $600.00 TO REPLACE JUST THE INTAKE MANIFOLD GASKET. I DON'T THINK THAT I SHOULD HAVE TO FOOT THIS BILL TO REPLACE A PROBLEM THAT GM HAS KNOWN ABOUT FOR A LONG TIME AND REFUSES TO CORRECT. *TR

THE CAR HAS DIED AT NIGHT IN NOT A VERY GOOD SIDE OF TOWN AND WOULD NOT START ON 10/07. HAD IT TOWED AND THEY FOUND THE INTAKE MANIFOLD GASKET DAMAGED $1,000.00. FEB 08 CAR WOULD NOT START AFTER WORK. 10 MILES AWAY FROM HOME. HAD THE CAR TOWED BACK TO FIRESTONE THINKING IT WAS THE SAME THING INSTEAD THE ANTI-THEFT SYSTEM HAD CAUSED THE CAR NOT TO START. 4/08 CAR AGAIN WOULD NOT START AFTER WORK. PLEASE FORCE GM TO TAKE RESPONSIBILITY FOR THEIR VEHICLES MALFUNCTIONS BEFORE SOME ONE GETS HURT BECAUSE OF THE ANTI THEFT SYSTEM. *TR

INTAKE MANIFOLD IS LEAKING COOLANT. *TR

MANIFOLD INTAKE GASKET CRACKED AND LEAKED INTO THE ENGINE. THIS CAUSED THE CAR NOT TO START. *TR

MY 2003 CHEVY MALIBU HAD DIED ON ME 3 TIMES WHILE I WAS DRIVING IT AND WOULD NOT RESTART. TWICE I HAD IT TOWED TO THE DEALERSHIP (JBA IN GLEN BURNIE, MD) AND THEY CANNOT FIND A PROBLEM WITH IT. I CAN'T DRIVE IT, BECAUSE I HAVE A 45 MINUTE COMMUTE TO WORK AND CANNOT AFFORD TO KEEP HAVING IT TOWED. *TR

TL*THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING 30 MPH FOR APPROXIMATELY TEN MINUTES, THE TEMPERATURE GAUGE DISPLAYED HOT. THE COOLANT LIGHT ILLUMINATED, WHICH INDICATED THAT THE COOLANT LEVEL WAS LOW. THE CONTACT STOPPED THE VEHICLE AND CHECKED THE LEVEL. HE THEN TOOK THE VEHICLE TO CARMAX AND THEY CONFIRMED THAT THE LOWER INTAKE MANIFOLD GASKET CAUSED THE FAILURE. THE FAILURE WAS REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 45,000. UPDATED 12/12/07 *BF

COOLANT IS LEAKING, MECHANIC SAID IT IS OUR LOWER INTAKE MANIFOLD GASKET THAT HAS FAILED. ALSO HE SAYS TO FLUSH OUT THE DEX COOL BECAUSE IT IS A HORRIBLE COOLANT. *TR

I HAVE A 2003 CHEVY MALIBU, THE COOLANT STARTED TO SLOWLY LEAK OUT, THEN PROCEEDED TO LEAK FASTER WITHIN A FEW WEEKS, WE COULDN'T SEE WHERE THE COOLANT WAS GOING. I CALLED MY OLDER BROTHER EVERY WEEKEND, AND HIS 2001 PONTIAC GRAND PRIX WAS IN THE SHOP GETTING A NEW ENGINE INSTALLED, HIS GRAND PRIX, AND MY CHEVY MALIBU HAVE THE SAME ENGINE, I ASKED WHAT HAPPENED, AND HE SAID THAT HIS COOLANT STARTED LEAKING, HE COULDN'T SEE WHERE IT WAS GOING SO HE TOOK IT INTO THE SHOP, AND THE MECHANIC TOLD HIM THAT A COMMON PROBLEM WITH THESE VEHICLES MADE BY GM WAS THAT THE LOWER INTAKE MANIFOLD GASKET IS FAULTY. I HAVE LOOKED IT UP ON LINE,AND THERE IS A CLASS ACTION LAW SUIT IN CANADA AGAINST GM FOR THIS PROBLEM, AS WELL MANY PEOPLE SAY (INCLUDING MY MECHANIC) THAT THE DEX COOL IS VERY BAD FOR YOU VEHICLE. ANYWAY, MY BROTHER GOT HIS CAR TO THE MECHANIC TOO LATE, AND AFTER SHELLING OUT 700 TO FIX THE LOWER INTAKE MANIFOLD GASKET, HE ENDED UP HAVING TO PAY 5900 TO REPLACE HIS 2001 GRAND PRIX ENGINE. AS IT TURNS OUT MY MALIBU HAD THE SAME PROBLEM WITH THE LOWER INTAKE MANIFOLD GASKET, WE HAVE YET TO REPLACE IT, IT IS WORTHLESS, THE MECHANIC WHO IS CHEVY CERTIFIED, SAID THAT THE COOLANT HAS GOTTEN INTO OUR OIL, AND THE ENGINE IS WORTHLESS, WE DON'T HAVE THE 5900 TO SHELL OUT FOR A NEW ENGINE. I HAVE CONTACTED GM TWICE, THE FIRST TIME I TALKED TO A REPRESENTATIVE ON THE PHONE, AND HE SAID THAT HE DOESN'T KNOW WHY THEY ARE NOT RECALLING THE GASKET, IT IS A KNOWN PROBLEM, BUT THEY AREN'T GOING TO RECALL IT, THE SECOND TIME I TALKED TO THEM THEY TOLD ME THAT THEY WILL NOT DISCUSS THE MATTER WITH ME ANY FURTHER. I AM A SINGLE MOM WITH THREE KIDS, AND A FULL TIME JOB, AND FULL TIME SCHOOL, I HAVE A CAR THAT WHEN I BOUGHT IT THE SALESMAN TALKED ME INTO, HE TOLD ME "A MALIBU WILL LAST YOU A VERY LONG TIME," AS IT SITS IN MY PARKING LOT WHILE I AM LEFT RIDING THE BUS, AND MAKING PAYMENTS ON A CAR THAT DOES NOT RUN, DUE TO A PROBLEM THAT GM KNOWS ABOUT. *JB

MY FIANCE AND I BOUGHT A 2003 CHEVY IMPALA IN NOV OF 2006 WITH ONLY 40,000 MILES. IN JULY OF 2007, THE CAR WAS STARTED AND SHUT OFF BY ITSELF A FEW MINUTES LATER. IT WOULD THEN NOT START. WE FIRST HAD IT TOWED TO A LOCAL SHOP THAT INFORMED US THAT THE UPPER INTAKE MANIFOLD HAD CRACKED. IT LEAKED ANTIFREEZE INTO THE CYLINDERS, THE SPARK PLUGS AND OTHER PARTS OF THE ENGINE AND THE COST FOR REPAIR WOULD BE 1400.00. WE HAD THE CAR TOWED TO A 2ND SHOP FOR A 2ND OPINION. THEY TOLD US THAT THE ANTIFREEZE THAT LEAKED HAD TOTALLY LOCKED UP THE ENGINE AND WE NEEDED A WHOLE NEW ONE. THAT WAS GOING TO COST US AT LEAST 2,000 FOR A USED ONE. WE THAN DECIDED THAT A 4 YEAR OLD CAR WITH 60K MILES ON IT SHOULD NOT BE IN NEED OF A NEW ENGINE SO WE AGAIN HAD IT TOWED TO A CHEVROLET DEALER REPAIR SHOP. THEY TOLD US THE SAME THING. THE CAR WAS OFFICIALLY IN NEED OF A WHOLE NEW ENGINE. WE CONTACTED CHEVROLET'S CUSTOMER CARE DEPT AND THEY ARE SO FAR UNWILLING TO HELP. WE'VE ONLY HAD THE CAR 8-9 MONTHS AND ARE CONTINUING TO MAKE PAYMENTS ON THE LOAN. PER THE DEALER, THE USED ENGINE WILL COST US 3000.00 AND A NEW ONE WILL COST IS 5050.00. *JB

DT*: THE CONTACT STATED THE VEHICLE ENGINE HESITATED AND LOST ALL POWER AT VARIOUS SPEEDS UNDER NORMAL ROAD CONDITIONS. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO COULD NOT IDENTIFY THE PROBLEM.

DT*: THE CONTACT STATED AT 75 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE COASTED TO THE SIDE OF THE ROAD AND AFTER A HALF AN HOUR, IT RESTARTED. THE DEALERSHIP WAS UNABLE TO DUPLICATE THE PROBLEM AND THERE ARE NO CODES ON THE COMPUTER.

VEHICLE EXPERIENCED SUDDEN STALLING AT VARIOUS SPEEDS. TOOK VEHICLE TO THE DEALER FOR CHECKUP, BUT THE CAUSE WAS UNDETERMINED AT THIS TIME.*AK

THERE WAS A DELAY AND OR LACK OF POWER WHEN PASSING. THE DELAY WAS IN BETWEEN ACCELERATION. *AK *SC

WHILE DRIVING 40 MPH ENGINE FAILED. AS RESULT, CONSUMER ENGAGED THE VEHICLE IN NEUTRAL AND COASTED TO THE SIDE OF THE ROAD. *AK

THE MUFFLER ON MY 2003 CHEVROLET SILVERADO NEEDS ITS SECOND MUFFLER IN AS MANY YEARS. IT APPEARS THE BAFFLE IS BECOMING LOOSE DUE TO INSUFFICIENT WELDS WITHIN THE MUFFLER. THIS IS CAUSING A VIBRATION A VARIOUS RPM/SPEEDS.*AK

WHEN DRIVING UNDER NORMAL CONDITIONS THE IDLE STICKS. RPM FIRST TIME STUCK AT APPROX 2000 RPM, 2ND TIME WAS 3,000 RPM. ONLY WAY TO GET IDLE TO RELEASE IS TO TURN ENGINE OFF AND RE-START. DANGEROUS AS IT MAKES IT HARD TO JUDGE HOW MUCH PRESSURE TO APPLY TO BRAKE PEDAL TO STOP VEHICLE. *JB

PROBLEMS WITH PC VALVE ON CHEVROLET MALIBU. *MR EMISSION ERROR-THE COMPUTER HAD GIVEN INCORRECT READINGS/PCV VALVE SMOG VALVE. (ONGOING PROBLEM) *SCC *JB