2009 Chevrolet Colorado Fuel System Problems

Your truck intermittently loses power when you press the gas pedal, causing bucking and stalling, then suddenly accelerates normally again—creating dangerous driving conditions. The problem happens in damp or rainy weather and appears to be related to the fuel system control module. Even though the fuel system control module and throttle body have both been replaced under recall, the problem persists, and GM has been unable to fix it after multiple repair attempts.

Your fuel pump module's fuel line developed corrosion and failed, causing fuel to leak significantly from your tank. This creates a serious fire hazard and allows toxic fuel fumes to enter the cabin of your vehicle. The manufacturer has not issued a recall for this issue.

Your gas pedal has stuck in the fully open position on three separate occasions while driving on public roads, causing your truck to accelerate uncontrollably. You've been able to regain control each time, but this is a serious safety concern that you've noticed discussed frequently in online forums for this model. The issue likely involves the accelerator pedal assembly or throttle linkage and may require inspection or replacement of these components.

Your fuel system control module had water inside it, which caused your check engine light to come on and prevented your vehicle from starting. You had the module replaced, but your vehicle wasn't covered under the recall even though your symptoms match exactly what the recall describes.

I WENT TO PULL MY TRUCK OUT OF THE GARAGE AND IT WOULD NOT START. A MECHANIC CAME TO MY HOUSE TO LOOK AT IT AND STATED THAT IT IS NOT GETTING FUEL. UPON DIGGING INTO THE REPAIRS THE FUEL MODULE HAD WATER IN IT. THE MECHANIC WENT TO O'REILLYS FOR THE PART AND WAS ADVISED OF A RECALL # 08411. I REPORTED MY PROBLEMS TO JIM BUTLER CHEVEROLET AND SEPAUGH BOTH WHOM REFUSED TO ACKNOWLEDGE THIS RECALL. I ALSO CALLED GM ABOUT THIS RECALL AND GOT NO WHERE. I WAS NOT ABLE TO GET TO WORK FOR 1 DAY AND THEN RIDES FOR THE REST OF THE WEEK TO WORK. THIS IS CAUSING AN INCONVEINCE TO ME AND MY COWORKERS, AS WELL AS PUT OF POCKETS COST FOR THIS REPAIR.

TL* THE CONTACT OWNS A 2009 CHEVROLET COLORADO. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER DIAGNOSED THAT THE FUEL PUMP CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V154000 (FUEL SYSTEM). THE FAILURE MILEAGE WAS 41,000.

MY VEHICLE BROKE DOWN DUE TO KNOWN GM RECALL NO. 08411 (NHTSA CAMPAIGN NUMBER: 09V154000.) AFTER PAYING OUT OF POCKET TO HAVE IT TOWED INTO THE LOCAL CHEVROLET DEALER, THEY REFUSED TO PAY FOR THE REPAIR AS STATED IN THE REMEDY. REPORT RECEIPT DATE: MAY 06, 2009 NHTSA CAMPAIGN NUMBER: 09V154000 COMPONENT(S): FUEL SYSTEM, GASOLINE ALL PRODUCTS ASSOCIATED WITH THIS RECALL EXPAND DETAILS CLOSE 10 ASSOCIATED DOCUMENTS CLOSE MANUFACTURER: GENERAL MOTORS CORP. SUMMARY: GM IS RECALLING 27,188 MY 2009 CADILLAC ESCALADE, ESCALADE HYBRID, ESCALADE ESV, AND ESCALADE EXT; CHEVROLET AVALANCHE, SUBURBAN, TAHOE, TAHOE HYBRID, AND COLORADO; AND GMC YUKON, YUKON HYBRID, YUKON XL, AND CANYON VEHICLES. THE FUEL SYSTEM CONTROL MODULES MAY HAVE A CONDITION IN WHICH AN ADHESIVE SEPARATION OF THE ROOM TEMPERATURE VULCANIZING (RTV) SEAL BETWEEN THE SEAL AND THE HOUSING MAY ALLOW WATER TO SEEP INTO THE MODULE. CONSEQUENCE: WATER IN THE MODULE COULD CAUSE A SHORT OR OPEN CIRCUIT, ILLUMINATION OF THE SERVICE ENGINE SOON LAMP, SETTING OF DIAGNOSTIC TROUBLE CODES OR THE ENGINE MAY BE HARD TO START, MAY NOT START OR MAY STALL INCREASING THE RISK OF A CRASH. REMEDY: DEALERS WILL INSTALL A NEW FUEL SYSTEM CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON MAY 18, 2009. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM. NOTES: GM RECALL NO. 08411. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV . *TR

FUEL PUMP CONTROL MODULE SENT A CODE INDICATING AN OPEN CIRCUIT. GM HAS A RECALL BUT OF COURSE MINE IS NOT PART OF IT. THE ENGINE WOULD STALL WITHOUT NOTICE. COST $320 TO FIX. *TR

TL* THE CONTACT OWNS A 2009 CHEVROLET COLORADO. THE CONTACT STATED THAT THE VEHICLE WAS SHIFTED INTO PARK WHEN THE ENGINE BEGAN TO REV AND JERK SLIGHTLY. THE VEHICLE WAS THEN SHUT OFF AND THE CONTACT COULD SMELL A STRONG ODOR OF FUEL. UPON EXITING THE VEHICLE, THE CONTACT NOTICED THAT FUEL WAS LEAKING FROM THE VEHICLE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT A RODENT CHEWED THROUGH THE PLASTIC FUEL LINES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 22,000.